Page 1
User Manual
Page 2
HURRICANE HAZE 1DX
TABLE OF CONTENTS
1. Before You Begin ....................................................................... 1
What Is Included ........................................................................................... 1
Unpacking Instructions.................................................................................. 1
Claims ............................................................................................................................ 1
Text Conventions .......................................................................................... 1
Symbols ........................................................................................................ 1
Disclaimer ..................................................................................................... 1
Product at a Glance ...................................................................................... 2
Safety Notes.................................................................................................. 2
2. Introduction ................................................................................ 3
Product Overview.......................................................................................... 3
Product Dimensions ...................................................................................... 4
3. Setup ........................................................................................... 5
AC Power...................................................................................................... 5
Fuse Replacement........................................................................................ 5
4. Operation .................................................................................... 6
Control Priority .............................................................................................. 6
Control Panel Operation................................................................................ 6
Menu Map ..................................................................................................... 6
DMX Linking.................................................................................................. 6
Starting Address............................................................................................ 6
DMX Values .................................................................................................. 6
5. Maintenance and Storage.......................................................... 7
Hazer Maintenance....................................................................................... 7
Storage.......................................................................................................... 7
6. Technical Specifications ........................................................... 8
7. Returns........................................................................................ 9
8. Contact Us .................................................................................. 10
Hurricane Haze 1DX User Manual Rev. 2
Page 3
BEFORE YOU BEGIN
1. BEFORE YOU BEGIN
What Is Included
• Hurricane Haze 1DX
•Power Cord
Unpacking Instructions
Carefully unpack the product immediately and check the container to make sure all the parts are in the
package and are in good condition.
Claims
If the box or the contents (the product and included accessories) appear damaged from shipping, or show
signs of mishandling, notify the carrier immediately, not Chauvet. Failure to report damage to the carrier
immediately may invalidate your claim. In addition, keep the box and contents for inspection.
For other issues, such as missing components or parts, damage not related to shipping, or concealed
damage, file a claim with Chauvet within 7 days of delivery.
Text Conventions
CONVENTION MEANING
1–512 A range of values
50/60 A set of values of which only one can be chosen
Settings A menu option not to be modified
<ENTER> A key to be pressed on the product’s control panel
ON A value to be entered or selected
• Warranty Card
• Quick Reference Guide
Symbols
SYMBOL MEANING
Electrical warning. Not following these instructions may cause electrical damage to
the product, accessories, or the user.
Critical installation, configuration, or operation information. Not following these
instructions may make the product not work, cause damage to the product, or cause
harm to the operator.
Important installation or configuration information. The product may not function
correctly if this information is not used.
Useful information.
Disclaimer
Chauvet believes that the information contained in this manual is accurate in all respects. However,
Chauvet assumes no responsibility and specifically disclaims any and all liability to any party for any loss,
damage or disruption caused by any errors or omissions in this document, whether such errors or
omissions result from negligence, accident or any other cause. Chauvet reserves the right to revise the
content of this document without any obligation to notify any person or company of such revision, however,
Chauvet has no obligation to make, and does not commit to make, any such revisions. Download the latest
version from www.chauvetdj.com
The works of authorship contained in this manual, including, but not limited to, all design, text and images
are owned by Chauvet.
© Copyright 2017 Chauvet & Sons, LLC. All rights reserved.
Electronically published by Chauvet in the United States of America.
CHAUVET, the Chauvet logo, and Hurricane Haze 1DX are registered trademarks or trademarks of
Chauvet & Sons LLC (d/b/a Chauvet and Chauvet Lighting) in the United States and other countries. Other
company and product names and logos referred to herein may be trademarks of their respective
companies.
.
Hurricane Haze 1DX User Manual Rev. 2
Page 1 of 11
Page 4
Product at a Glance
BEFORE YOU BEGIN
Use on Dimmer
Outdoor Use
Sound-Active
DMX
Master/Slave
Safety Notes
• Not intended for permanent installations.
• Always connect the product to a grounded circuit to avoid the risk of electrocution.
• Always disconnect this product from the power source before cleaning it or replacing the
fuse.
• Make sure the power cord is not crimped or damaged.
• Never disconnect the power cord by pulling or tugging on the cord.
• Make sure there are no flammable materials close to the unit while operating
• Do not touch the output nozzle on this product. It is very hot during operation and it ma
re
• Do not drink the haze fluid. If you do, call your local emergency service (911
he
• Do not add perfume, alcohol, gasoline, or any other flammables to the haze fluid.
• Depending on the amount of haze generated, all haze machines may set off smoke
detectors.
• In certain environments, haze fluid-based machines may leave a slippery residue on floor
an
• Do not use for space heating purposes.
• Use only CHAUVET DJ water-based haze fluid.
• Drain the tank before transporting the product.
Auto Programs
Auto-ranging Power Supply
Replaceable Fuse
User-Serviceable
main hot for several hours after turning the unit off.
lp.
d surfaces.
y
in the US) for
s
• Always make sure that the voltage of the outlet to which you are connecting the produ
the range stated in the decal or rear panel of the product.
within
• This product is for indoor use only! To prevent risk of fire or shock, do not expose th
product to rain or
• Always install this product in a location with adequate ventilation, at least 20 in (50 cm) fr
a
djacent surfaces.
• Be sure that no ventilation slots on the unit’s housing are blocked.
• Never connect this product to a dimmer or rheostat.
• Make sure to replace the fuse with another of the same type and rating.
• Never carry the product from the power cord or any moving part. Always use the hanging/
mounting bracket.
• The maximum ambient temperature (Ta) is 104 °F (40 °C). Do not operate this produ
h
igher temperatures.
• In the event of a serious operating problem, stop using the product immediately.
• Never try to repair this product. Repairs carried out by unskilled people can lead
malfunction. Please contact the nearest authorized technical assistance center.
or
• To eliminate unnecessary wear and improve its lifespan, during periods of non-use
completely disconnect the product from power via breaker or by unplugging it.
Keep this User Manual for future use. If you sell the product, be sure that the purcha
receives this
moisture.
document.
ct is
is
om
ct at
to damage
ser
Page 2 of 11
Hurricane Haze 1DX User Manual Rev. 2
Page 5
INTRODUCTION
Fluid Level Indicator
Nozzle
Fluid Tank
Fan
Power In
DMX In/Out
Fuse Holder
Haze Volume Knob
Menu Buttons
Rubber Feet for
Surface Mounting (x4)
Carry Handle
LED Display
2. INTRODUCTION
Product Overview
Hurricane Haze 1DX User Manual Rev. 2
Page 3 of 11
Page 6
Product Dimensions
9 in
223 mm
11 in
278 mm
6 in
150 mm
INTRODUCTION
Page 4 of 11
Hurricane Haze 1DX User Manual Rev. 2
Page 7
SETUP
Safety cap
Spare fuse holder
(inside safety cap)
Installed fuse
(held by plastic clip)
3. SETUP
AC Power
The Hurricane Haze 1DX has a fixed voltage power supply and it can work with an input voltage of either
120 VAC, 60 Hz or 230 VAC, 50 Hz, depending on the specific model.
To eliminate wear and improve its lifespan, during periods of non-use completely
disconnect the product from power via breaker or by unplugging it.
While operating the Hurricane Haze 1DX, make sure there is adequate haze fluid in
the machine to prevent pump and heater damage. When the haze fluid level
becomes low, simply add more haze fluid to continue using the Hurricane Haze 1DX.
This product may NOT be tilted. This product should be level when on a surface.
Fuse Replacement
1. Wedge the tip of a flat-head screwdriver into the slot of the fuse holder.
2. Pry the fuse holder out of the housing.
3. Remove the blown fuse from the holder and replace with a fuse of the exact same type and rating.
4. Insert the fuse holder back in place and reconnect power.
Disconnect the product from the power outlet before replacing the fuse.
Hurricane Haze 1DX User Manual Rev. 2
Page 5 of 11
Page 8
OPERATION
4. OPERATION
Control Priority
The Hurricane Haze 1DX operates according to the following priority control levels:
Control Panel Operation
To access the control panel functions, use the four buttons located underneath the display, and the two
manual control knobs located to the right of the display. Please refer to the Product Overview
button and knob locations on the control panel.
BUTTON FUNCTION
<MENU> Press to find an operation mode or to back out of the current menu option
<UP> Press to scroll up the list of options or to find a higher value
<DOWN> Press to scroll down the list of options or to find a lower value
<ENTER> Press to activate a menu option or a selected value
<HAZE VOLUME> Controls the volume of the haze output, from H 1–3
Menu Map
MODE PROGRAMMING LEVELS DESCRIPTION
Haze Volume H (1-3) Displays current manual haze volume.
DMX Address d 1-512 Sets the DMX address.
DMX Linking
The Hurricane Haze 1DX can work with a DMX controller. Instructions for connecting and configuring this
product for DMX operation are in the User Manual. If you are not familiar with DMX, download the DMX
Primer from
www.chauvetdj.com.
to see the
Starting Address
To ensure full access to all channels available in DMX mode, the highest recommended DMX address is
512.
DMX Values
CHANNEL FUNCTION VALUE PERCENT/SETTING
000
1Haze Volume
Allow the Hurricane Haze 1DX one minute to heat up before continuing.
010 No function
255 Haze volume, low to high
011
Page 6 of 11
Hurricane Haze 1DX User Manual Rev. 2
Page 9
MAINTENANCE AND STORAGE
5. MAINTENANCE AND STORAGE
Hazer Maintenance
Do not allow the hazer to become clogged. After every 40 hours of continuous operation, use CHAUVET
Fog Cleaner Quart (FCQ) through the system to prevent the accumulation of particulate matter in the
heating element.
The recommended cleaning procedure is as follows.
1. Unplug the product from power.
2. Empty all haze fluid from the machine.
3. Add cleaning solution to the tank.
4. Connect the product to power and allow it to warm up.
5. Run the unit in a well-ventilated area until the tank is almost empty. Do not allow the pump to run
dry.
6. Refill with haze fluid to continue using the hazer. Run the machine briefly to clear any remaining
cleaning solution from the pump and heater.
Never operate this product without fluid.
Fog Cleaner Quart (FCQ) was specifically developed by Chauvet to clean your
Hurricane Haze 1DX. Make sure you use FCQ regularly, no longer than 90 days
between cleanings, to increase the life of your product.
Storage
Before storing the hazer, run FCQ through the system as described in the cleaning procedure above;
however, only follow steps 1 through 5. Do not refill the tank with haze fluid if storing the hazer.
Cleaning the system prior to storage will help prevent any particles from condensing inside the pump or
heater while not in use.
Test-run your Hurricane Haze 1DX on a monthly basis to achieve the best
performance.
Powering off the unit for transport
Follow these instructions to prevent leaks, and allow the air pump to entirely clear the fluid line and heater
of the haze fluid before power off.
To prevent spills or leaks before, during, or after transport, Chauvet recommends the
following steps for your Hurricane Haze 1DX:
1. Turn the "Haze Volume" output to off.
2. Wait 30-45 seconds.
3. When there is no more haze fluid in the output line, turn off the machine by pressing
the power switch.
Hurricane Haze 1DX User Manual Rev. 2
Page 7 of 11
Page 10
TECHNICAL SPECIFICATIONS
6. TECHNICAL SPECIFICATIONS
Dimensions and Weight
LENGTH WIDTH HEIGHT WEIGHT
11 in (278 mm) 6 in (150 mm) 9 in (223 mm) 7.2 lb (3.3 kg)
Note: Dimensions in inches rounded to the nearest decimal digit.
Power
POWER SUPPLY TYPE RANGE VOLTAGE SELECTION
Fixed
PARAMETER 120 V, 60 HZ 230 V, 50 HZ
Consumption 188 W 188 W
Operating Current 1.5 A 0.75 A
Fuse F 5 A, 250 V F 5 A, 250 V
POWER I/O U.S./WORLDWIDE UK/EUROPE
Power input connector IEC IEC
Power Cord plug Edison (U.S.) Local Plug
Operation
HEAT-UP TIME TANK CAPACITY FLUID CONSUMPTION
1 min 0.4 gal (1.5 L) 4 ml/min
120 VAC, 60 Hz, or 230 VAC, 50 Hz
Fixed
Fog Output
OUTPUT
800 cfm
Thermal
MAXIMUM EXTERNAL TEMPERATURE COOLING SYSTEM
104 °F (40 °C) Convection
DMX
I/O CONNECTOR CHANNEL RANGE
3-pin XLR 1
Ordering
PRODUCT NAME ITEM CODE UPC NUMBER
Hurricane Haze 1DX (120 V)
Hurricane Haze 1DX (230 V)
09071413
09071415
781462217617
781462217631
Page 8 of 11
Hurricane Haze 1DX User Manual Rev. 2
Page 11
RETURNS
RETURNS
In case you need to get support or return a product:
• If you are located in the U.S., contact Chauvet World Headquarters.
• If you are located in the UK or Ireland, contact Chauvet Europe Ltd.
• If you are located in Mexico, contact Chauvet Mexico.
• If you are located in Benelux, contact Chauvet Europe BVBA.
• If you are located in any other country, DO NOT contact Chauvet. Instead, contact your local
distributor. See www.chauvetdj.com
Benelux.
If you are located outside the U.S., UK, Ireland, Mexico, or Benelux, contact your
distributor of record and follow their instructions on how to return Chauvet products to
them. Visit our website www.chauvetdj.com
Call the corresponding Chauvet Technical Support office and request a Return Merchandise Authorization
(RMA) number before shipping the product. Be prepared to provide the model number, serial number, and
a brief description of the cause for the return.
Send the merchandise prepaid, in its original box, and with its original packing and accessories. Chauvet
will not issue call tags.
Clearly label the package with the RMA number. Chauvet will refuse any product returned without an RMA
number.
Write the RMA number on a properly affixed label. DO NOT write the RMA number
directly on the box.
for distributors outside the U.S., UK, Ireland, Mexico, or
for contact details.
Before sending the product, clearly write the following information on a piece of paper and place it inside
the box:
• Your name
• Your address
• Your phone number
• RMA number
• A brief description of the problem
Be sure to pack the product properly. Any shipping damage resulting from inadequate packaging will be
your responsibility. FedEx packing or double-boxing are recommended.
Chauvet reserves the right to use its own discretion to repair or replace returned
product(s).
Hurricane Haze 1DX User Manual Rev. 2
Page 9 of 11
Page 12
CONTACT US
World Headquarters
EUROPE
MEXICO
Address: Av. de las Partidas, 34-3B, Zona
Industrial Lerma (Entrance by Calle 2)
Lerma, Edo. de Mexico C.P. 52000
General Information Technical Support
Address: 5200 NW 108th Ave. Voice: (844) 393-7575
Sunrise, FL 33351 Fax: (954) 756-8015
Voice: (954) 577-4455 Email: chauvetcs@chauvetlighting.com
Fax: (954) 929-5560
Toll Free: (800) 762-1084 www.chauvetlighting.com
Website
General Information Technical Support
Address: Stokstraat 18 Email: eutech@chauvetlighting.eu
9770 Kruishoutem
Belgium www.chauvetlighting.eu
Voice: +32 9 388 93 97
Website
General Information Technical Support
Address: Unit 1C Email: uktech@chauvetlighting.com
Brookhill Road Industrial Estate
Pinxton, Nottingham, UK
NG16 6NT www.chauvetlighting.co.uk
Voice: + 44 (0) 17 7 3 511115
Fax : + 44 (0) 1 7 7 3 511110
Website
General Information Technical Support
Email: servicio@chauvet.com.mx
Website
Voice: +52 (728) 690-2010 www.chauvet.com.mx
CONTACT US
Visit the applicable website above to verify our contact details and instructions to request support.Outside
the U.S., United Kingdom, Ireland, Mexico or Benelux, contact the dealer of record.
Page 10 of 11
Hurricane Haze 1DX User Manual Rev. 2
Loading...