CaptiveAire RFS-4100-078 User Manual
MODEL: RFS-4100-078
NOTE 3 Approval or Recognition By: UL/CUL File MH6213; CSA File LR18754.
(107)
SPECIFICATIONS
1.0 Mounting Position: Diaphragm Vertical (See Diag. Below).
2.0 Set Point: Calibrate at 0.25" ±.05" W.C. Pressure Rise Vertical Plane - DO NOT SEAL!
2.1 Field Adjustable: "Operate Range" 0.17" W.C. to 5.0" W.C.
2.2 Field Adjustable: "Release Range" 0.10" W.C. to 4.7" W.C.
3.0 Approximate Switching Differential: Progressive; Increasing from 0.05 ± .02" w.c.
At Minimum Set Point To Approximately 0.3" w.c. At Maximum Set Point.
4.0 Measured Media: Air.
5.0 Operating Temperature Range: -40° F to 180° F (-40° C to 82 ° C).
6.0 Life: 100,000 Cycles Minimum at 1/2 PSI Maximum Pressure Each Cycle and at Maximum
Rated Electrical Load.
7.0 Electrical Rating.
7.1 300 VA Pilot Duty at 115 to 277VAC.
7.2 15 Amp Non-inductive to 277VAC.
8.0 Contact Arrangement: SPDT
9.0 Position of Switch Contacts Before Pressure is Applied.
C NO
NC
NOTE 1 Adjustment Screw - Turn Clockwise to Increase Set Point.
NOTE 2 Sample Line Connectors, Complete With Nut and Ferrule, Will Accept 1/4" O.D. Rigid or Semi-Rigid Tubing.
DIMENSIONS
INCHES
(METRIC)
4.63
(118)
4.14
(105)
2.75
(90)
3.75
(95)
.203 x .393 SLOT(5) (10)
(4) PLACES
.140 DIA. - (2) PLACES
COM
N.O.N.C.
1.00
(25)
4.22
(4)
SEE NOTE 1
RFS-4001-078
SNAP SWITCH WITH
LOW
1/4" QUICK-CONNECT
HIGH PRESSURE
MODEL/SETPOINT
APPROVAL LABEL
TERMINALS
INLET - SEE NOTE 2
.50
(13)
LOW PRESSURE
INLET - SEE NOTE 2
.710
(18)
CLEVELAND CONTROLS DIV. OF UNICONTROL INC. MAKES NO REPRESENTATION OR WARRANTY CONCERNING THE SUITABILITY OF THIS DEVICE FOR A SPECIFIC APPLICATION OR PRODUCT.
IT IS THE RESPONSIBILITY OF THE USER TO VERIFY THE SUITABILITY OF THIS DEVICE FOR THESPECIFIC APPLICATION.WHERE AN OPERATING CONTROL FAILUREWOULD RESULTIN
PERSONAL INJURY AND/OR LOSS OF PROPERTY, IT IS THE RESPONSIBILITY OF THE USER TO ADD DEVICES OR SYSTEMS THATPROTECT AGAINST, OR WARN OF,FAILURE OFTHIS DEVICE.
SENSING SWITCH SPECIFICATIONS
CAPTIVEAIRE P/N: A0016441
CLEVELAND CONTROLS MODEL: RFS-4100-078
USED ON
±
.XX = .015
± °
.XXX = .005
ANGLES = 1
A60087-078
SHEET OF
1 1
REV
MJA
DCN No.
DATE
7/22/09
DATE
7/22/09FL
REV
DRAWING RELEASE No.
DWN
CHKD
DATE
BY
4840
CHKD
SCALE
1/2" = 1"
CHKD
THIS PRINT ISTHE EXCLUSIVE PROPERTY OF CLEVELAND CONTROLS AND CANNOTBE
REPRODUCED IN WHOLE OR IN PART OR ISSUED OR DISCLOSED TO THIRD PARTIES
WITHOUT THE EXPRESS WRITTEN CONSENT OFCLEVELAND CONTROLS.
Loading...