Broaster 765 Service Manual
OPERATION, SERVICE &
PARTS MANUAL
BROASTER® 765
PORTABLE FILTER
Be sure ALL installers read, understand, and have access to this manual at all times.
trademarks. Usage is available only to licensed operators with written authorization from the Broaster Company.
Design Certified By:
CSA & NSF
Genuine Broaster Chicken®, Broasted®, Broaster Chicken®, Broaster Foods®. and Broasterie® are registered
The Broaster Company
2855 Cranston Road, Beloit, WI 53511-3991
608/365-0193 broaster.com
Manual #10867 3/98 Rev: 6/14
© 2014 the Broaster Company
Printed In U.S.A.
All adjustments and repairs shall be made
FOR YOUR SAFETY
Do not use or store gasoline or other flammable vapors
or liquids in the vicinity of this or any other appliance.
Improper installation, adjustments, alteration, service or maintenance can cause
property damage, injury or death. Read the installation, operating and maintenance instructions thoroughly before installing or servicing this equipment.
For the sake of safety and clarity, the following words used in this manual are defined as follows:
Indicates an imminently hazardous situation which, if not avoided, could
result in serious injury or death.
Indicates a potentially hazardous situation which, if not avoided, could
result in serious injury or death.
Indicates a potentially hazardous situation which, if not avoided, could
result in minor injury, property damage or both.
by an authorized Broaster Company representative.
If there is a power failure, turn POWER
switch OFF. DO NOT attempt to operate
unit during a power failure.
Failure to read and
understand this manual
completely could result in serious injury
or death. Be sure ALL operators read,
understand and have access to this
manual at all times.
Rags or paper containing
cooking oil can catch fire
if exposed to heat. Laundering will not
remove the oil. Dispose of all oil-soiled
papers and rags in a trash container that
is in a ventilated area away from all
cooking equipment or other heat
sources such as direct sunlight.
Use only the unit’s handle
for moving the unit.
Pulling the unit with the hose can cause
damage to the hose or fittings.
Use care when handling
splash causing serious burns.
hot oil. Hot oil could
broaster.com Manual #10867 3/98 Rev: 2/14
TABLE OF CONTENTS
1 – LIMITED WARRANTY ..................................................................................................... 1-1
2 – INTRODUCTION ............................................................................................................. 2-1
3 – OPERATION .................................................................................................................... 3-1
INSTALLING FILTER PAPER ............................................................................................ 3-1
OPERATING INSTRUCTIONS .......................................................................................... 3-2
If Filter Unit fits under fryer for gravity drain ............................................................... 3-2
If Filter Unit does not fit under fryer ............................................................................ 3-3
4 – FILTERING TIPS .............................................................................................................. 4-1
5 – CLEANING INSTRUCTIONS ........................................................................................... 5-1
6 – ELECTRICAL WIRING DIAGRAMS ................................................................................ 6-1
ELECTRICAL CONNECTIONS ......................................................................................... 6-1
FILTER MODEL 765: 120V ............................................................................................... 6-2
FILTER MODEL 765: 220V ............................................................................................... 6-2
7 – TROUBLESHOOTING ..................................................................................................... 7-1
8 – PARTS .............................................................................................................................. 8-1
broaster.com Manual #10867 3/98 Rev: 2/14
i
1 - LIMITED WARRANTY - Parts and Labor
Subject to the terms and conditions of this warranty, The Broaster Company (Company) warrants that all
equipment and parts manufactured or sold by the Company and purchased new from an authorized
Company distributor are free from defects in material and workmanship for a period of one year from the
date of installation (two years on Solid State controllers and ten years on the Welded Stainless Steel
Cooking Well ), if installation is made by a qualified installer under supervision by an authorized distributor
in accordance with applicable laws and regulations. Warranty coverage is extended to the original
purchaser only and is void if the equipment is resold. If an authorized Company distributor is notified of a
warranty claim during the warranty period, the Company will at its option replace, recondition or repair at its
factory any part or parts of the equipment which the Company judges defective, provided the equipment
has been subjected to normal usage, properly installed, operated and serviced in accordance with
Company operating instructions, and there is no evidence of accident, alteration or abuse of the equipment
or the use of unauthorized repair methods. All parts replaced under this warranty carry only the unexpired
term of the warranty.
Extended cooking well warranty will cover the cooking well only and does not include any parts attached to
the cooking well, including: probe guards, basket guides, latch columns, latch column blocks, insulation,
splash shield interlock, drain valve, filter lines and fittings, high limit, thermostat, temperature sensor probe,
combustion chamber and flue, elements, burner, all mounting hardware. The aforementioned excluded
parts are covered under the 1-year parts warranty. The extended warranty does not cover any cooking well
that fails due to any misuse or abuse.
Any warranty claim on the cooking well must be presented to The Broaster Company or authorized Broaster
Distributor from whom the pressure fryer was purchased. Repairs will be made by The Broaster Company
only. Any freight charges and distributor labor costs to install the repaired cooking well, as well as the cost
of any other parts replaced will be the responsibility of the equipment owner.
Service under this warranty shall be furnished only by an authorized Company distributor. The Company
does not send service representatives to furnish warranty service. Your authorized Company distributor
should be contacted for warranty service.
This warranty covers on-site labor charges only, at a fixed rate, for one year from date of installation of
new equipment only. Transportation charges, trip charges, zone fees, or other expenses in connection with
warranty service are the obligation of the owner unless otherwise specified in the original sales contract
between the purchaser and the authorized Company distributor from which the equipment is purchased.
Please refer to that contract for coverage as to those charges.
This warranty shall be void unless genuine Broaster
XL Filtering Compound and Broaster Cooking Well Cleaner is used in conjunction with the equipment.
This warranty does not apply to consumable items and supplies such as O-rings, food baskets, bulbs,
gaskets and lamps.
The foregoing warranty is made in lieu of all other warranties, express or implied, and the Company
specifically disclaims any implied warranties of merchantability or fitness for a particular purpose. The
Company’s full obligation under this warranty, and the purchaser’s sole remedy, shall be limited to
replacement, reconditioning or repair as specified above.
®
parts & filter paper, Bro-Clean™ filtering compound or
IN NO EVENT SHALL THE COMPANY BE LIABLE TO THE ORIGINAL OWNER OR ANY OTHER PERSON
FOR ANY INCIDENTAL, CONSEQUENTIAL OR SPECIAL DAMAGES RESULTING FROM THE USE OR
INABILITY TO USE THE EQUIPMENT COVERED HEREBY, WHETHER ARISING FROM BREACH OF
WARRANTY, STRICT LIABILITY OR OTHERWISE.
The Company reserves the right to change or improve its products in any way without obligation to alter
products previously manufactured.
1-1
broaster.com Manual #10867 3/98 Rev: 2/14
Used Company equipment or Company equipment not purchased from an authorized distributor carries no
warranty expressed or implied.
1-2
broaster.com Manual #10867 3/98 Rev: 2/14
2 – INTRODUCTION
Your new 765 Portable Filter is designed to
filter particles of food from used cooking oil.
These particles, if not routinely removed,
will ultimately ruin shortening.
When filtering, Broaster® Bro-Clean or
Broaster® XL Filtering Compound must be
used as directed, so an adequate supply
must be kept in stock.
You can measurably extend the useful life of
cooking oil by the regular and proper use
of the 765XP Portable FIlter.
When the filter is operated in accordance
with the filtering instructions, it will remove
particles 10 microns and larger from the
shortening.
broaster.com Manual #10867 3/98 Rev: 2/14
2–1
Loading...