Breville BJE830 Instruction Book

the Juice Fountain

Instruction Book - BJE830

™

Cold* XL

Contents

IMPORTANT
SAFEGUARDS

2 Breville Recommends
Safety First
6 Components
7 Assembly
8 Functions
10 Care & Cleaning
11 Troubleshooting
13 Tips
17 French

BREVILLE
RECOMMENDS
SAFETY FIRST

At Breville we are very safety
conscious. We design and
manufacture consumer
products with the safety of you,
our valued customer, foremost
in mind. In addition we ask
that you exercise a degree of
care when using any electrical
appliance and adhere to the
following precautions.

READ ALL INSTRUCTIONS
BEFORE USE AND SAVE
FOR FUTURE REFERENCE

• Remove and safely discard
any packaging material or
stickers before using the
juicer for the first time.

• To eliminate a choking hazard
remove and safely discard the
protective cover fitted to the
power plug of this appliance.

• Fully unwind the power cord
before use.

• Do not place the juicer near
the edge of a countertop or
table. Ensure the surface is
level, clean and free of water
and other substances.

• Always ensure the juicer is
properly assembled before use.

• Always make sure the juicer
filter basket, collector and top
cover are fitted and clamped
securely in place before the
motor is turned on.
Do not unfasten clamps while
the juicer is in operation.

• Do not use the appliance
if the rotating filter basket
(sieve) is damaged.

2

• Do not operate without the
pulp container in place.

• Before juicing any food, fruits
or vegetables, inspect and
clean to ensure the following;

−all rinds and hard skin
have been removed,

−there are no pits, stones
or heavy seeds,

−packing or bundling ties and
metal wire have been removed.

Not following the above
instructions can lead to
unsafe operation and may
cause serious injury.

• Never plug in or switch
ON the juicer with food
present in the feed chute.

• Allow the motor to reach
proper speed before pushing
food through the feed chute.

• Do not put your fingers or
other objects into the juicer
opening while it is plugged in
or in operation. If food becomes
lodged in opening, only use
food pusher or another piece
of fruit or vegetable to push
it down. When this method
is not possible turn the unit
OFF and disassemble juicer to
remove the remaining food.

• Do not leave the juicer
unattended when in use.

• Avoid contact with moving parts.

• Be sure to turn the switch to
the OFF position after each
use of your juicer. Make sure
the motor stops completely
before disassembling.

• To disconnect, turn the
control OFF, then remove
plug from wall outlet.

• Properly clean the unit and filter
basket after each use to avoid
leaks or overflow and to ensure
the unit operates as intended.

• Be careful when handling
the filter basket as the small
cutting blades at the base of
the filter basket are very sharp.
Mishandling may cause injury.

• Unplug the cord from the
power outlet when not in use,
before putting on or taking
off parts, before cleaning,
storing, moving, or leaving
the appliance unattended.

• We do not recommend
children operate this juicer.
Close adult supervision is
necessary when operating
this juicer near children.

• This appliance is for household
use only. Do not use in any type
of moving vehicles. Do not use
the appliance outdoors, or for
anything other than its intended
use. Misuse can cause injury.

3

• The use of attachments not
recommended or sold by the
manufacturer may cause fire,
electric shock or injury.

• To protect against risk of
electric shock, do not immerse
the cord, plug or motor base
in water (or other liquids).

• A representative example of
the heaviest loading suitable for
use with this juicer is equivalent
to 11 pounds (5kg) of carrots,
juiced continuously with a
push force of 11 pounds (5kg).

NOTE

If the motor stalls or strains under
load, do not operate continuously
for more than 10 seconds at
a time.

NOTE

If the juicer stops due to
improper operation or if there
is excessive noise, shaking, or
vibration, turn the unit OFF and
allow the filter to stop spinning
completely. Unplug the unit from
the power outlet, disassemble
and clean all components before
properly reassembling.

IMPORTANT
SAFEGUARDS
FOR ALL
ELECTRICAL
APPLIANCES

• Do not let the cord hang over
the edge of a table, counter, or
let touch a hot surface such
as a stove. Do not place on

or near a hot gas or electric
burner or in a heated oven.

• It is recommended to regularly
inspect the appliance and
power cord. Do not use the
appliance if there is damage to
the power cord or plug, or after
the appliance malfunctions or
has been dropped or damaged
in any way. If this occurs,
immediately stop use and call
Breville Consumer Support.

If the above issues persist, stop
use of the juicer and contact
Breville Consumer Support.

BREVILLE ASSIST® PLUG

Your Breville appliance comes
with a unique Assist® Plug,
conveniently designed with a
finger hole to ease removal from
the power outlet.

4

This appliance has a polarized
plug (one blade is wider than
the other). To reduce the risk of
electric shock, this plug will fit in
a polarized outlet only one way.
If the plug does not fit fully in the
outlet, reverse the plug. If it still
does not fit, contact a qualified
electrician. Do not modify the
plug in any way.

SHORT CORD
INSTRUCTIONS

Your Breville appliance is fitted
with a short power supply cord
to reduce personal injury or
property damage resulting from
pulling, tripping or becoming
entangled with a longer cord.
If an extension cord is used,
(1) the marked electrical rating
of the cord set or extension cord
should be at least as great as the
electrical rating of the appliance,
(2) the cord should be arranged
so that it will not drape over the
countertop or table-top where it
can be pulled on by children or
tripped over unintentionally
and (3) the extension cord
must include a 3-prong
grounding plug.

CALIFORNIA
PROPOSITION 65:

(Applicable to California
residents only).

This product contains chemicals
known to the State of California
to cause cancer, birth defects or
other reproductive harm.

FOR HOUSEHOLD USE ONLY
SAVE THESE INSTRUCTIONS

5

Components

D

A

J

B

C

D

E

F

G

H

I

A. Food pusher

(not dishwasher safe)

B. Interlocking safety arm

Stops juicer operating without cover
locked into place.

C. Juicer cover

(dishwasher safe)

D. Stainless steel filter basket

(dishwasher safe)

E. Pulp container

(dishwasher safe)

6

F. Filter bowl surround

(dishwasher safe)

G. Variable speed control and off dial
H. Overload protection indicator light
I. 70 fl. oz. (2 liter) juice jug and sealing lid

with built in froth separator
(dishwasher safe).

J. Juicing Nozzle

(dishwasher safe)
Can be placed over spout to juice directly
into a cup.

Assembly

BEFORE FIRST USE

Before using your juicer for the first time,
remove and safely discard any packaging
materials and promotional stickers
and labels.

Ensure the power cord is unplugged.
Wash the filter bowl surround, filter basket,

juicer cover, food pusher, pulp container and
juice jug and lid in warm, soapy water with a
soft cloth. Rinse and dry thoroughly.

1. Place motor base on a flat, dry surface
such as a countertop. Ensure that the
juicer is switched OFF at the dial,
and the power cord is unplugged.

2. Place filter bowl surround on top of the
motor base.

4. Place the juicer cover over the filter bowl
surround, positioning the lower part of
the feed chute over the stainless steel
filter basket.

5. Raise the safety locking arm up and lock
into the two grooves on either side of the
juicer cover.

3. Align the arrows at the base of the stainless
steel filter basket with the arrows on the
motor drive coupling and push down until it
clicks into place to create a secure fit with
the motor base.

6. The safety locking arm should now be in a
vertical position and locked into place on
top of the juicer cover.

7

7. Slide the food pusher down the food chute by
aligning the groove in the food pusher, with
the small protrusion on the inside of the top
of the feed tube.

Food
pusher
groove

Small
protrusion
inside feed
tube

Functions

1. Wash your selection of fruit and vegetables
to be juiced. Most fruit and vegetables
such as apples, carrots and cucumbers
will not need to be cut or trimmed to size
as these will fit whole into the feed chute.
Ensure vegetables such as beets, carrots
etc. have all soil removed, are washed
well and trimmed of leaves before using.

2. Plug the power cord into a 120V power outlet.

8. Place the pulp container into position by
tilting and lifting the motor base slightly.
Insert the pulp container under the juicer
cover on the back ensuring it is supported
by the juicer cover and motor base.

9. Fit the lid to the juice jug and position jug
under juice spout.

JUICE JUG

Juice can be preserved in the juice jug for up to 3
days by following these steps.

1. Lift the lid off the jug and rotate 180°

2. Press down firmly to replace the lid

3. Store juice in the fridge

NOTE

Storage time depends on the ingredients being
juiced and the freshness of the fruit prior to
juicing. Juice must be stored in the refrigerator
between 32°F to 39°F.

IMPORTANT

Do not load feed chute with produce before the
Juicer has reached the selected speed.

3. Turning the Juicer On

Turn dial to desired speed setting. Turn
dial to "Fast" range for most juicing needs.
For harder fruits/vegetables and leafy
greens select the "Boost" range. See
Speed Selector Guide table on the next
page to match speed and produce type
for maximum yield. "Quiet" allows you to
extract juice at a significantly lower noise.

4. With the motor running, place food into
the feed chute and use the food pusher
to gently guide food down. To extract
the maximum amount of juice, always
push the food pusher down slowly.

5. Full Juice Jug
You can keep juicing until the juice jug
is filled to max. level.

6. Continuous Juicing
Having just filled and removed a juice jug
with fresh juice, you can place an empty
juice jug back onto the nozzle and continue
juicing without disassembly. When the
pulp container is near full with pulp, turn
the dial to "Off", remove the pulp container
only and empty contents. Replace the empty
pulp container and turn dial to desired
speed selection to continue juicing.

8

SPEED SELECTOR GUIDE

FOOD TYPE SPEED

APPLE Boost

BABY SPINACH Boost

BEET Boost

BELL PEPPER Boost

BLUEBERRY Boost

BROCCOLI Boost

CABBAGE Boost

CARROT Boost

CELERY Fas t

CITRUS FRUIT (peeled) Quiet

CUCUMBER (green tip removed) Fas t

GINGER Boost

GRAPE (seedless) Fas t

HONEYDEW MELON (peeled) Fas t

KALE Boost

NOTE

• Do not allow the pulp container to overfill as

this may affect the operation of the appliance.

• The juicer is fitted with a safety device

which safeguards against overheating
with excessive loads. If overheating occurs,
the juicer will automatically activate the
overload protection device and the unit
will switch itself off. When the overload
protection is activated, unplug the juicer
from the power outlet for at least 30 minutes
to allow the unit to cool. Then plug juicer
into the power outlet and use as normal.

WARNING

Never use fingers, hands or utensils to push
food down the feed chute or to clear the feed
chute. Always use the food pusher provided.

Caution:

sharp blades

KIWI (peeled) Fas t

MANGO (peeled, pit removed) Boost

MINT Boost

PEACH (pit removed) Boost

PEAR Fast

PINEAPPLE (peeled) Boost

RHUBARB Boost

SQUASH Boost

STRAWBERRY Fas t

TOMATO Fas t

WATERMELON (peeled) Fas t

ZUCCHINI Fas t

The stainless steel filter basket contains small
sharp blades to cut and process fruit and
vegetables. Avoid touching the blades when
handling the filter basket.

9

Care & Cleaning

Ensure the juicer is turned off by turning the
juicer dial to the OFF position. Then unplug
the power cord.

CLEANING

1. Remove juice jug.

2. Remove pulp container.

3. Disengage locking bar, pull up entire juice
collector assembly and take to sink.

Rinse all parts after use (except the motor base)
under running water to clear away the majority
of juice and pulp. Wash in warm soapy water
with a soft cloth.

To avoid food drying on to the blades, mesh or
transparent parts, rinse and wash as soon as
possible after use.

PULP CONTAINER

To minimize cleaning, you can line the pulp
container with a biodegradable bag to collect
the pulp.

MOTOR BASE

To clean the motor base, wipe with a soft, damp
cloth then dry thoroughly. Wipe any excess
food particles from the power cord.
Do not immerse the motor base in liquids.

CLEANING AGENTS

Do not use abrasive scouring pads or cleaners
on either the motor base or the jug, as they may
scratch the surface. Use only warm soapy water
with a soft cloth.

DISHWASHER

Wash all parts (except the motor base) in warm
soapy water with a soft cloth.

All parts except for the motor base, juicer
cover and food pusher are dishwasher safe.
However washing parts on a regular base in the
dishwasher can shorten the life of them due to
prolonged exposure to harsh detergents,
hot water and pressure.

Cleaning the parts in the dishwasher also may
cause parts to deteriorate so inspect the parts
regularly and stop using the product if any
signs of damage is noticed.

FILTER BASKET

To ensure consistent juicing results, always
clean the filter basket thoroughly immediately
after use.

If pulp is left to dry, it may clog the fine pores
of the filter mesh, which can affect juicing
performance. The filter basket can be soaked in
hot soapy water for 10 minutes, if necessary.

Hold the filter basket under running water and
use cleaning brush (supplied with the juicer)
in a circular motion to clear away pulp from
the inside of the basket, including the blades.
Turn over, use the cleaning brush in a circular
motion to clear away pulp from the outside of
the basket, and repeat if necessary.

After cleaning, hold up towards a light source
to check that the fine mesh pores are not
blocked. If blocked, soak the filter basket in
hot water with 10% lemon juice to loosen, and
brush under running water again.
Do not soak the filter basket in bleach,
harsh chemicals or abrasive cleansers.

Always treat the filter basket with care, as it can
be easily damaged. Do not use if there is any
damage or deformation to the filter mesh.

Filter basket can be washed in the dishwasher
(top shelf).

The center of the filter basket has an array of
small, sharp blades. Do not touch these blades
when handling the filter basket.

STUBBORN FOOD STAINS

Discoloration of the plastic may occur with
strongly colored fruit and vegetables. To help
prevent this, wash parts immediately after use.

If discoloration does occur, the plastic parts can
be soaked in water with 10% lemon juice or can
be cleaned with a non-abrasive cleaner.

10