Breville BJE530 Instruction Manual

the Juice Fountain

Instruction Book - BJE530

‰

Cold Plus

Contents

2 Breville Recommends
Safety First
5 Components
6 Assembly
8 Functions
10 Care & Cleaning
11 Troubleshooting
13 Tips

BREVILLE
RECOMMENDS
SAFETY FIRST

At Breville we are very safety
conscious. We design and
manufacture consumer
products with the safety of you,
our valued customer, foremost
in mind. In addition we ask
that you exercise a degree of
care when using any electrical
appliance and adhere to the
following precautions.

IMPORTANT
SAFEGUARDS

READ ALL INSTRUCTIONS
BEFORE USE AND SAVE
FOR FUTURE REFERENCE

• Remove and safely discard
any packaging material or
promotional labels before using
the juicer for the first time.

• To eliminate a choking
hazard for young children,
remove and safely discard the
protective cover fitted to the
power plug of this appliance.

• Do not place the juicer near
the edge of a bench or table
during operation. Ensure that
the surface is level, clean and
free of water, flour, etc. Vibration
during operation may cause
the appliance to move.

• Do not place the juicer on
or near a hot gas or electric
burner, or where it could
touch a heated oven.

• Do not use the juicer on a sink
drain board.

• Any significant spillage onto
the surface under or around
the appliance, or onto the
appliance itself, should be
cleaned and dried before
continuing to use the appliance.

• Always ensure the juicer is
properly assembled before use.
The appliance will not operate
unless properly assembled.

• Always make sure juicer cover
is clamped securely in place
before motor is turned on.
Do not unfasten locking bar
while juicer is in operation.

• Do not use the appliance
if the rotating filter basket

2

or lid is damaged.

• Remove rind from all citrus
fruit before juicing.

• Ensure that the seed is removed
before juicing stone fruit.

• Keep hands, fingers, hair,
clothing as well as spatulas and
other utensils away from the
appliance during operation.

• Do not push food into the
feed chute with your fingers
or other utensils. Always use
the food pusher provided.
Do not place hand or fingers
into the food chute when it is
attached to the appliance.

• Do not leave the juicer
unattended when in use.

• Always ensure the juicer is
turned off by turning the
dial on the control panel to
OFF. Then unplug the cord.
Make sure the filter basket
has stopped rotating and the
motor has completely stopped
before releasing the safety
locking arm and/or attempting
to move the appliance,
when the juicer is not in use,
and before disassembling,
cleaning and storing.

• A representative example of the
heaviest loading anticipated for
use with this juicer is 11 lbs (5kg)
of beetroot, juiced continuously
over a period of 2 minutes.

• Do not juice more than

6.6 lbs (3kg) of carrot at a time.

• Hard fruits and vegetables
will put excess strain onto
the motor if low speed is
selected. Please refer to the
juicing guide to determine the
correct speed for the fruits and
vegetables selected for juicing.

• Allow the motor to rest for
1 minute between each use.

• Keep the appliance clean.
Refer to care and cleaning
section of this manual.

• Be careful when handling
the filter basket as the small
cutting blades at the base of
the filter basket are very sharp.
Mishandling may cause injury.

• Do not use the juicer for
anything other than food and/
or beverage preparation.

IMPORTANT
SAFEGUARDS
FOR ALL
ELECTRICAL
APPLIANCES

• Fully unwind the power
cord before use.

• Do not let the power cord
hang over the edge of the
countertop or table, touch hot
surfaces or become knotted.

• To protect against electric shock
do not immerse the power
cord, power plug or appliance
in water or any other liquid.

3

• Always disconnect the
appliance from the supply
if it is left unattended
and before assembling,
disassembling or cleaning.

• This appliance shall not be used
by children. Keep the appliance
and its cord out of reach of
children. Appliances can be
used by persons with reduced
physical, sensory or mental
capabilities or lack of experience
and knowledge if they have
been given supervision or
instruction concerning use
of the appliance in a safe
way and if they understand
the hazards involved.

• Children should be supervised
to ensure that they do not
play with the appliance.

• Cleaning and user maintenance
shall not be made by children
without supervision.

• It is recommended to regularly
inspect the appliance. To avoid a
hazard do not use the appliance
if power cord, power plug or
appliance becomes damaged
in any way. Immediately
stop use and contact Breville
Consumer Support for
examination and/or repair.

• Any maintenance other than
cleaning should be performed

at an authorized Breville
Consumer Support Center.

• This appliance is for household
use only. Do not use this
appliance for anything other
than its intended use. Do not
use in moving vehicles or
boats. Do not use outdoors.

Misuse may cause injury.

• The installation of a residual
current device (safety switch)
is recommended to provide
additional safety protection
when using electrical
appliances. It is advisable
that a safety switch with a
rated residual operating
current not exceeding
30mA be installed in the
electrical circuit supplying the
appliance. See your electrician
for professional advice.

WARNING

In order to avoid the
possible hazard of the juicer
starting by itself due to
inadvertent resetting of the
overload protection, do not attach
an external switching
device (such as a timer) or
connect the juicer to a circuit
that can regularly switch the
appliance on and off.

FOR HOUSEHOLD USE ONLY
SAVE THESE INSTRUCTIONS

4

Components

D

A

J

B

C

D

E

F

G

H

I

A. Food pusher

(not dishwasher safe)

B. Interlocking safety arm

Stops juicer operating without cover
locked into place.

C. Juicer cover

(dishwasher safe)

D. Stainless steel filter basket

(top shelf dishwasher safe)

E. Pulp container

(dishwasher safe)

F. Filter bowl surround

(dishwasher safe)

G. 2 Speed control and off dial
H. Overload protection indicator light
I. 70 fl.oz juice jug and sealing lid

with built in froth separator

(dishwasher safe)

J. Juicing Nozzle

(dishwasher safe)
Can be placed over spout to juice directly
into a cup.

5

Assembly

BEFORE FIRST USE

Before using your juicer for the first time,
remove and safely discard any packaging
materials and promotional stickers
and labels.

Ensure the power cord is unplugged.
Wash the filter bowl surround, filter basket,

juicer cover, food pusher, pulp container and
juice jug and lid in warm, soapy water with a
soft cloth. Rinse and dry thoroughly.

1. Place motor base on a flat, dry surface
such as a countertop. Ensure that the
juicer is switched to OFF at the dial,
and the power cord is unplugged.

2. Place filter bowl surround on top of the
motor base.

4. Place the juicer cover over the filter bowl
surround, positioning the lower part of
the feed chute over the stainless steel
filter basket.

5. Raise the safety locking arm up and locate
into the two grooves on either side of the
juicer cover.

3. Align the arrows at the base of the stainless
steel filter basket with the arrows on the
motor drive coupling and push down until it
clicks into place to create a secure fit with
the motor base.

6

6. The safety locking arm should now be in a
vertical position and locked into place on
top of the juicer cover.

7. Slide the food pusher down the food chute by
aligning the groove in the food pusher, with
the small protrusion on the inside of the top
of the feed tube.

Food
pusher
groove

Small
protrusion
inside feed
tube

8. Place the pulp container into position by
tilting and lifting the motor base slightly.
Insert the pulp container under the juicer
cover on the back ensuring it is supported
by the juicer cover and motor base.

9. Fit the lid to the juice jug and position jug
under juice spout.

JUICE JUG

Juice can be preserved in the juice jug for up
to 3 days by following these steps.

NOTE

Storage time depends on the ingredients
being juiced and the freshness of the fruit
prior to juicing. Juice must be stored in the
refrigerator between 32°F to 39°F.

1. Lift the lid off the jug and rotate 180°

2. Press down firmly to replace the lid

3. Store juice in the fridge

7

Functions

SPEED SELECTOR GUIDE

FOOD TYPE SPEED

1. Wash your selection of fruit and vegetables
to be juiced. Most fruit and vegetables
such as apples, carrots and cucumbers
will not need to be cut or trimmed to size
as these will fit whole into the feed chute.
Ensure vegetables such as beets, carrots
etc. have all soil removed, are washed
well and trimmed of leaves before using.

2. Plug the power cord into a 120V power outlet.

IMPORTANT

Do not load Feed Chute with produce before
the Juicer has reached the selected speed.

3. Turning the Juicer On
Turn dial to desired speed setting. Turn
Dial to "Low" setting for soft fruits and
vegetables and to "High" setting for hard
fruits and vegetables. See Speed Selector
Guide table on the next page to match
speed and produce type for maximum yield.
"Low" range, while it may not maximize
yield of some produce, allows you to extract
juice at a significantly lower noise.

4. With the motor running, place food into
the feed chute and use the food pusher
to gently guide food down. To extract
the maximum amount of juice, always
push the food pusher down slowly.

5. Full Juice Jug

You can keep juicing until the
Juice Jug is filled to max. level.

6. Continuous Juicing
Having just filled and removed a Juice Jug
with fresh juice, you can place an empty
Juice Jug back onto the nozzle and continue
juicing without disassembly. When the Pulp
Container is near full with pulp, turn the
Dial to "Off", remove the Pulp Container
only and empty contents. Replace the empty
Pulp Container and turn Dial to desired
speed selection to continue juicing.

APPLES High

BABY SPINACH High

BEETS High

BELL PEPPER High

BLUEBERRIES High

BROCCOLI High

CABBAGE High

CARROT High

CELERY High

CITRUS FRUITS (peeled) Low

CUCUMBER High

GINGER High

GRAPES (seedless) Low

HONEYDEW MELON (peeled) High

KALE High

KIWI (peeled) Low

MANGO (peeled, pit removed) High

MINT High

PEACH (pit removed) High

PEARS High

PINEAPPLE (peeled) High

RHUBARB High

SQUASH High

STRAWBERRIES High

TOMATOES High

WATERMELON (peeled) Low

ZUCCHINI High

8

NOTE

• Do not allow the pulp container to overfill as

this may affect the operation of the appliance.

• The juicer is fitted with a safety device

which safeguards against overheating
with excessive loads. If overheating occurs,
the juicer will automatically activate the
overload protection device and the unit
will switch itself off. When the overload
protection is activated, unplug the juicer
from the power outlet for 30 minutes to
allow the unit to cool. Then plug juicer
into the power outlet and use as normal.

WARNING

Never use fingers, hands or utensils to push
food down the feed chute or to clear the feed
chute. Always use the food pusher provided.

Caution:

sharp blades

The stainless steel filter basket contains
small sharp blades to cut and process fruit
and vegetables. Avoid touching the blades
when handling the filter basket.

9

Care & Cleaning

Ensure the juicer is turned off by turning the
juicer dial to the OFF position. Then unplug
the power cord.

Cleaning the parts in the dishwasher also may
cause parts to deteriorate so inspect the parts
regularly and stop using the product if any
signs of damage is noticed.

CLEANING

1. Remove Juice Jug.

2. Remove Pulp Container.

3. Disengage Locking Bar, pull up entire
Juice Collector Assembly and take to sink.

Rinse all parts after use (except the motor
base) under running water to clear away the
majority of juice and pulp. Wash in warm
soapy water with a soft cloth.

To avoid food drying on to the blades, mesh
or transparent parts, rinse and wash as soon
as possible after use.

PULP CONTAINER

To minimize cleaning, you can line the
pulp container with a biodegradable bag to
collect the pulp.

MOTOR BASE

To clean the motor base, wipe with a soft,
damp cloth then dry thoroughly. Wipe any
excess food particles from the power cord.
Do not immerse the motor base in liquids.

CLEANING AGENTS

Do not use abrasive scouring pads or
cleaners on either the motor base or the jug,
as they may scratch the surface. Use only
warm soapy water with a soft cloth.

FILTER BASKET

To ensure consistent juicing results, always
clean the filter basket thoroughly immediately
after use.

If pulp is left to dry, it may clog the fine pores
of the filter mesh, which can affect juicing
performance. The filter basket can be soaked
in hot soapy water for 10 minutes, if necessary.

Hold the filter basket under running water and
use brush (supplied with the juicer) in
a circular motion to clear away pulp from
the inside of the basket, including the blades.
Turn over to brush away pulp from the outside
of the basket, and repeat
if necessary.

After cleaning, hold up towards a light source
to check that the fine mesh pores are not
blocked. If blocked, soak the filter basket in
hot water with 10% lemon juice to loosen, and
brush under running water again.
Do not soak the filter basket in bleach, harsh
chemicals or abrasive cleansers.

Always treat the filter basket with care, as it
can be easily damaged. Do not use if there is
any damage or deformation to the filter mesh.

Filter basket can be washed in the dishwasher
(top shelf).

The center of the filter basket has an array of
small, sharp blades. Do not touch these blades
when handling the filter basket.

DISHWASHER

Wash all parts (except the motor base) in
warm soapy water with a soft cloth.
All parts except for the motor base and food
pusher are dishwasher safe.
However washing parts on a regular base
in the dishwasher can shorten the life of
them due to prolonged exposure to harsh
detergents, hot water and pressure.

10

STUBBORN FOOD STAINS

Discoloration of the plastic may occur
with strongly colored fruit and vegetables.
To help prevent this, wash parts immediately
after use.

If discoloration does occur, the plastic parts
can be soaked in water with 10% lemon juice
or can be cleaned with a non-abrasive cleaner.