Breville BJE520 User Manual

the Froojie® Juice Fountain

Instruction Booklet

™

BJE520

CONGRATULATIONS

on the purchase of your new

Breville product

CONTENTS

4 Breville recommends safety ﬁrst

7 Know your Breville product

10 Assembling your Breville product

15 Operating your Breville product

20 Disassembling your

Breville product

23 Care & cleaning

26 Troubleshooting

29 Tips on juicing

32 Fruit and vegetable facts

35 Recipes

BREVILLE RECOMMENDS SAFETY FIRST

At Breville we are very safety conscious. We design and manufacture consumer products with the safety of you, our valued customer, foremost in mind. In addition we ask that you exercise a degree of care when using any electrical appliance and adhere to the following precautions.

IMPORTANT SAFEGUARDS

READ ALL INSTRUCTIONS BEFORE USE AND SAVE FOR FUTURE REFERENCE

• Carefully read all instructions before

operation and save for future reference.

• Remove any packaging material and

promotional stickers and labels before using the juicer for the ﬁrst time.

• Do not place the juicer near the edge of a

bench or table during operation. Ensure that the surface is level, clean and free of water, ﬂour, etc. Vibration during operation may cause the appliance to move.

• Any signiﬁcant spillage onto the surface

under or around the appliance, or onto the appliance itself, should be cleaned and dried before continuing to use the appliance.

• Do not place the juicer on or near a hot

gas or electric burner, or where it could touch a heated oven.

• Always ensure the juicer is properly

assembled before use. The appliance will not operate unless properly assembled. Refer to assembly.

• Do not leave the juicer unattended when

in use.

• Always ensure the juicer is turned OFF

by pressing the OFF/ON switch on the control panel to OFF. Then switch the appliance OFF at the power outlet and unplug the cord. Make sure the stainless steel ﬁlter basket has stopped rotating and the motor has completely stopped before releasing the safety locking arm and/or attempting to move the appliance, when the juicer is not in use, and before disassembling, cleaning and storing.

• Do not operate the Juice Extractor

continuously with heavy loads for more than 10 seconds. Allow the motor to rest for 1 minute between each use. Recipes in this instruction book are not considered a heavy load. However, hard fruits and vegetables will put excess strain onto the motor if a low speed is selected. Please refer to the juicing guide on Page 9 to determine the correct speed for the fruits and vegetables selected for juicing.

• When using the Froojie

insert, always use speed 1 and remove seeds core and skin from fruit before processing (seeds of passionfruit, berries and kiwi fruit are acceptable).

• Keep hands, ﬁngers, hair, clothing, as

well as spatulas and other utensils away from the appliance during operation.

• Do not push food into the feed chute

with your ﬁngers or other utensils. Always use the food pusher provided. Do not place hand or ﬁngers into food chute when it is attached to the appliance.

• Be careful when handling the stainless

steel ﬁlter basket as the small cutting blades at the base of the ﬁlter basket are very sharp. Mishandling may cause injury.

• Do not use the juicer for anything other

than food and/or beverage preparation.

• Keep the appliance clean. Refer to Care,

Cleaning and Guarantee.

• Do not use appliance if the rotating

sieve (ﬁlter basket) is damaged.

Disc and

BREVILLE RECOMMENDS SAFETY FIRST

• Do not touch the small sharp teeth and

blades in the centre of the Juice disc.

• Do not touch the blade in the

Feed Chute.

• Do not run ice or hard fruit/vegetables

such as raw beetroot and carrots through the Juicer when using the Froojie extractor.

• Remove rind from all citrus fruit

before juicing.

• CAUTION In order to avoid a hazard

due to inadvertent resetting of the thermal cut out, this appliance must not be supplied through an external switching device such as a timer or connected to a circuit that it regularly switched on and off by the utility.

WARNING

Extra wide feed chute. Do note place hands or foreign objects down feed chute. Always use the food pusher provided.

BREVILLE RECOMMENDS SAFETY FIRST

IMPORTANT SAFEGUARDS FOR ALL ELECTRICAL APPLIANCES

• Fully unwind the power cord before use.

• Do not let the power cord hang over

the edge of a bench or table, touch hot surfaces or become knotted.

• To protect against electric shock do not

immerse the power cord, power plug or appliance in water or any other liquid.

• The appliance can be used by children

aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved. Children shall not play with the appliance. Cleaning and user maintenance shall not be made by children unless they are older than 8 and supervised.

• Keep the appliance and its cord out of

reach of children less than 8 years.

• It is recommended to regularly inspect

the appliance. To avoid a hazard do not use the appliance if power cord, power plug or appliance becomes damaged in any way. Return the entire appliance to the nearest authorised Breville Service Centre for examination and/or repair.

• Any maintenance other than cleaning

should be performed at an authorised Breville Service Centre.

• This appliance is for household use only.

Do not use this appliance for anything other than its intended use. Do not use in moving vehicles or boats. Do not use outdoors. Misuse may cause injury.

• The installation of a residual current

device (safety switch is recommended to provide additional safety protection when using electrical appliances. It is advisable that a safety switch with a rated residual operating current not exceeding 30mA be installed in the electrical circuit supplying the appliance. See your electrician for professional advice.

WARNING

Always make sure juicer cover is clamped securely in place before motor is turned on. Do not unfasten interlock arm while juicer is in operation.

SAVE THESE INSTRUCTIONS

KNOW

your Breville product

KNOW YOUR BREVILLE PRODUCT

A. Unique Direct Central Feed System

Ensures maximum juice extraction.

B. 84mm extra wide feed chute

Fits larger fruit and vegetables whole.

C. Juicer cover (Top shelf dishwasher safe). D. 3 litre pulp container (Top shelf

dishwasher safe).

E. Stylish stainless steel design F. ON/OFF switch G. LCD speed indicator

With juicing speed guide.

H. Electronic variable speed control dial I. Food pusher

For pushing whole fruit and vegetables down the feed chute (top shelf dishwasher safe).

K L

J. Die-cast metal interlocking safety arm

Stops the juicer operating without the juicer cover locked in place.

K. Filter basket

Stainless steel, titanium reinforced micro mesh ﬁlter basket (top shelf dishwasher safe).

L. Motor drive coupling M. Filter bowl surround (Top shelf

dishwasher safe).

N. 1.2 litre juice jug and lid

With in-built froth separator (top shelf dishwasher safe).

O. Heavy duty motor

With ﬁve year motor warranty.

P. Custom designed juice nozzle

Perfect for mess free juicing straight into a glass (top shelf dishwasher safe).

KNOW YOUR BREVILLE PRODUCT

Q. Cleaning Brush

Flat end of brush assists in removal of pulp from the pulp container when juicing large quantities, nylon brush end makes for easy cleaning of the stainless steel ﬁlter basket (top shelf dishwasher safe).

R. Froojie

Insert

For processing softer fruits such as bananas, mangoes and strawberries. Integrated handle for left and right handed use.

S. Froojie

Disc

For processing softer fruits such as bananas, mangoes and strawberries.

T. Nutri Disc™

Allows you to extract only the juice from fruit and vegetables.

U. Built in froth separator

Ensures juice froth is separated from juice when poured into a glass (if preferred).

V. Juice jug lid

Allows juicer to operate with the lid on, therefore eliminating any splatter during operation. Place lid onto juice jug to store juice in refrigerator.

NOT SHOWN

Cord Exits at rear of juicer and wraps around feet.

NOTE

To retain froth in the juice jug simply remove the lid before pouring the juice.

ASSEMBLING

your Breville product

ASSEMBLING YOUR BREVILLE PRODUCT

BEFORE FIRST USE

Before using your juicer for the ﬁrst time, remove any packaging material and promotional stickers and labels. Ensure the appliance is switched off at the power outlet and the power cord is unplugged.

Wash the ﬁlter bowl surround, Nutri Disc™, juicer cover, Froojie

Disc, Froojie® insert, food pusher, pulp container and juice jug and lid in warm, soapy water with a soft cloth. Rinse and dry thoroughly. The motor base can be wiped with a damp cloth. Dry thoroughly.

FOR USE WITH JUICE EXTRACTOR

1. Place the motor base on a ﬂat, dry

surface such as a bench top. Ensure that the motor base is switched OFF at the control panel, then switch the appliance off at the power outlet and unplug the cord.

2. Place the ﬁlter bowl surround on top of

the motor base.

3. Align the arrows at the base of the Nutri

Disc™ with the arrows on the motor drive coupling and push down until it clicks into place. Ensure the Nutri Disc™ is ﬁtted securely inside the ﬁlter bowl surround and onto the motor base.

4. Place the juicer cover over the ﬁlter bowl

surround, positioning the feed chute over the juice disc and lower into position.

ASSEMBLING YOUR BREVILLE PRODUCT

5. Raise the safety locking arm up and

locate it into the two grooves on either side of the juicer cover. The safety locking arm should now be in a vertical position and locked into place on top of the juicer cover.

6. Slide the food pusher down the feed

chute by aligning the groove of the food pusher, with the small protrusion on the inside top of the feed chute. Continue to slide the food pusher down into the feed chute.

NOTE

To minimise cleaning, line the pulp container with a plastic freezer bag to collect the pulp. Pulp can then be used in other dishes, or as compost for the garden or discarded.

8. Place the juice jug provided under the

spout on the right-hand side of the juicer. The juice jug lid can be used to avoid any splatter.

Alternatively you can ﬁt the custom-designed juice nozzle over the juice spout and place a glass underneath. The juice nozzle will prevent splatter, ensuring mess free juicing.

7. Place the pulp container into position

by tilting the base of the pulp container away from the motor base and slide the top of the pulp container over the bottom of the juice cover. Tilt the base of the pulp container back into the motor base ensuring it is supported by the container support extending from under the motor base.

ASSEMBLING YOUR BREVILLE PRODUCT

FOR USE WITH FROOJIE EXTRACTOR

1. Place the Filter Bowl Surround on the

top of the Motor Base.

2. Place the Froojie® Disc into the Filter

Bowl Surround and onto the Motor Drive Coupling Push down until it clicks into place. Ensure the Froojie securely inside the Filter Bowl Surround and onto the Motor Base.

Disc is ﬁtted

3. Place the Froojie

Insert into the Filter Bowl Surround, making sure the warning label on the handle is facing upwards.

4. Place the Juicer Cover over the Froojie®

Insert and Filter Bowl Surround and lower into position.

NOTE

Never use Froojie

Froojie

insert. They must always be

used together.

Disc without

ASSEMBLING YOUR BREVILLE PRODUCT

5. Raise the safety locking arm up and lock

into the two grooves on either side of the juicer cover. The safety locking arm should now be in a vertical position and locked into place on top of the juicer cover.

NOTE

There is no need to use pulp container when using Froojie

Extractor.

7. Place the juice jug provided under the

spout on the right-hand side of the juicer. The juice jug lid can be used to avoid any splatter.

6. Slide the food pusher down the feed

chute by aligning the groove in the food pusher with the small protrusion on the inside of the top of the feed chute.

OPERATING

your Breville product

PAge heAder.....

OPERATING YOUR BREVILLE PRODUCT

PREPARATION OF FRUIT AND

VEGETABLES FOR FROOJIE EXTRACTOR

• Only soft fruits should be used with the

• When using fruits with hard inedible

• When using fruits with a hard core such

• All fruits with pits, hard seeds or stones

• Passionfruit pulp, peeled kiwi fruit

NOTE

When using the Froojie use low speeds (speed 1 or 2). Always ensure motor is running before adding fruit and/or vegetables to feed tube.

FROOJIE® EXTRACTOR SPEED

Apricots (stone removed) 1

Bananas (peeled) 1

Kiwi fruit (peeled) 1

Mangoes (peeled, stone removed) 1

Melons (peeled) 1

Pears soft (stalk and core removed) 1

Pineapple (peeled and cored) 1

Raspberries 1

Strawberries (stalks removed) 1

Watermelon (peeled, seeds removed) 1

Use speed 2 to push out any remaining fruit pulp in juice collector

Froojie

Extractor.

skins, such as mangoes, pineapple or kiwi fruit, always peel before juicing.

as pineapple, always remove this before juicing.

such as nectarines, peaches, mangoes and apricots must be pitted or deseeded before juicing.

and berries can be processed without removing seeds.

Extractor,

WITH JUICE EXTRACTOR OR FROOJIE® EXTRACTOR

1. Wash selection of fruit and vegetables to

be juiced.

NOTE

Most fruit and vegetables such as apples, carrots and cucumbers will not need to be cut or trimmed to size as these will ﬁt whole into the feed chute. Ensure vegetables such as beetroot, carrots, etc. have all soil removed, are well washed and trimmed of leaves before juicing.

2. Based on the type of fruit or vegetable

you are juicing/pureeing select either the Juice Extractor or the

Froojie

Extractor.

WARNING

Do not put hard fruit and vegetables (i.e. Carrots, apples, fresh beetroot, etc.) or ice through juicer when using Froojie® Extractor. This could damage parts of the unit.

3. Ensure the juicer is correctly assembled.

Refer to Assembling your juicer. Ensure the juice jug (or a glass) is placed under the spout and the pulp container is in position before commencing juicing.

4. Plug the power cord into a 230/240V

power outlet. Turn the power on at the power outlet. The LCD display will illuminate.

+ 36 hidden pages