Bradford-White IGI-1805, IGI-18510, IGI-180 User Manual

Page 1
TANKLESS GAS REPLACEMENT PARTS LIST
EVERHOT®IGI 180 (C,R)(5,10) Models
Meets all LoNox and (SCAQMD)
South Coast Air Quality
Management District
Requirements
ECO 6828
Dimensions and specification subject to
change without notice.
NOTE: BOTH MODEL AND SERIAL NUMBERS ARE REQUIRED FOR ORDERING REPLACEMENT PART S
Parts Book #44907A
Page 2
2
Page 3
Reference Number and Description Part Number
003 Rubber Bushing 239-44786-00 004 Connection Reinforcement Panel 239-44780-00 005 Heat Protection Plate 239-44781-00 007 Front Panel Packing 239-44783-00 008 Front Panel Packing Side 239-44784-00 009 Front Plastic Panel 239-44840-00 728 Remote Control Bracket 239-44946-00 800 Screw 239-44896-00 801 Screw 239-44895-00 802 Washer 239-44887-00
Reference Number and Description Part Number
001 Casing Assembly 239-44773-00 002 Wall Fitting Bracket 4 239-44777-00 006 Front Panel Assembly (Nat Gas) 239-44771-00 006 Front Panel Assembly (LP Gas) 239-44796-00 729 Main Body Control Panel (MC-45-4US) 239-44509-00
Reference Number and Description Part Number
001 Casing Assembly 239-44774-00 002 Wall Fitting Bracket 4 239-44778-00
006 Front Panel Assembly (Nat gas) 239-44797-00 006 Front Panel Assembly (LP gas) 239-44772-00 729 Main Body Control Panel 239-44510-00
Water Heater Accessories
- Bathroom Remote Control Kit (BC-45-4US-BW) (IGI-180R Models Only) 239-44507-00*
- 2nd Bathroom Remote Control (BSC-45-4US-BW) (IGI-180R Models Only) 239-44508-00*
- Manifold Elect. Controls, Pack A 239-44511-00*
- Manifold Elect. Controls, Pack B 239-44512-00*
Parts Common to IGI-180(C,R)-(5,10)(N,X)
Parts Unique to IGI-180R-10(N,X)
Parts Unique to IGI-180C-5 (N,X)
- Plumbing Installation Kit, Copper 239-45003-00
- Plumbing Installation Kit, Iron 239-44961-00
* Denotes Service Stock Component.
3
Page 4
4
Page 5
Reference Number and Description Part Number
103 Burner Unit Assembly 239-44790-00 104 Burner Case Front 239-44791-00 105 Burner Case Bottom Panel 239-44792-00 106 Packing 239-44793-00 107 Lean and Rich Bunsen burner Assembly 239-44794-00 108 Burner Case Back Panel 239-44795-00 109 Damper 239-44798-00 111 Packing of Combustion Chamber 239-44802-00 112 Lower Packing of Combustion Chamber 239-44803-00 113 Screw 239-44804-00 115 Combustion Chamber Front Plate 239-44807-00 116
Electrode 239-44808-00
117
Flame Rod 239-44809-00
118
Electrode Packing 239-44810-00
119
Electrode Holder 239-44811-00
120
Upper Packing of Combustion Chamber 239-44812-00 121 Tube Joint 239-44815-00 122 Pressure Tube 239-44816-00 125 Blower Motor All Assembly 239-44817-00* 126 Fan Casing Assembly 239-44814-00 127 Fan Connecting Bracket 239-44821-00 128 Fan Connecting Packing 239-44822-00 129 Blower Motor 239-44819-00* 130 Bell Mouth 239-44820-00 131 Bellows Connecting Bracket/intake Duct 239-44824-00 132 Combustion Chamber Bracket 239-44827-00 135 Air Inlet Box Assembly 239-44828-00 136 Bellows Connecting Bracket/Fan 239-44825-00 137 Bellows 239-44823-00 138 Bellows Clamping Ring 239-44826-00 139 Air Inlet Box Assembly 239-44829-00 140 Exhaust Bracket 239-44835-00 141 Exhaust Bracket Holder 239-44836-00 142 Air Inlet Box Cover 239-44830-00 143 Heat Exchanger Complete Assembly 239-44839-00 705 PCB Bracket 239-44857-00 706 Igniter 239-44858-00 707 High Tension Cord 239-44859-00 708 Electrode Sleeve 239-44860-00 709 Thermister 239-44861-00 710 Thermister Clip Large 239-44862-00 711 Thermal Fuse Clip 239-44864-00 712 Frost Sensing Switch 239-44882-00 716 Anti-Frost Heater Clip 239-44866-00 717 Anti Frost Heater Clip A 239-44867-00 718 Anti-Frost Heater Clip 239-44868-00 719 Inlet Air Thermister 239-44863-00 726 Mold-Type Over Heat Switch 239-44876-00 803 Screw 239-44888-00 810 O-ring 239-44897-00 811 O-ring 239-44898-00 812 O-ring 239-44899-00
Reference Number and Description Part Number
110 Manifold Assembly-B (Natural Gas) (U245-200-B) 239-44800-00
Reference Number and Description Part Number
110 Manifold Assembly-A (LP Gas) (U245-200-A) 239-44799-00
* Denotes Service Stock Component.
Parts Common to IGI-180(C,R)-(5,10)(N,X)
Parts Unique to IGI-180(C,R)-(5,10)N (Natural Gas)
Parts Unique to IGI-180(C,R)-(5,10)X (LP Gas)
5
Page 6
6
Page 7
Reference Number and Description Part Number
100 Gas Control Assembly 239-44787-00* 101 Screw 239-44788-00 102 Gas Connection (3/4" NPT) 239-44789-00 400 Water Inlet (3/4" NPT) 239-44841-00 401 Water Flow Servo & Sensor Assembly 239-44842-00* 402 Rectifier 239-44843-00 403 By-pass Servo Assembly 239-44844-00 404 Stop Bracket 239-44845-00 405 Plug Band 239-44846-00 406 Water Filter Assembly 239-44847-00 407 Filter Plug 239-44848-00 408 Hot Water Outlet (3/4" NPT) 239-44849-00 409 Stop Bracket 239-44851-00 410 Plug Band Small 239-44908-00 411 Drain Valve 239-44853-00 700 PCB 239-44878-00* 701 Surge Protector 239-44880-00* 702 PCB Cover-Side 239-44909-00 703 PCB Cover-Front 239-44855-00 704 Transformer Assembly 239-44856-00* 709 Thermister 239-44861-00 715 120V Valve Heater Assembly 239-44865-00
727 Remote Control Cable 239-44945-00
804 Screw 239-44889-00 805 Screw 239-44890-00 810 O-ring 239-44897-00 813 O-ring 239-44900-00 814 O-ring 239-44901-00 815 O-ring 239-44902-00 816 O-ring 239-44903-00 817 O-ring 239-44904-00 818 Packing 239-44905-00
* Denotes Service Stock Component.
Parts Common to IGI-180(C,R)-(5,10)(N,X)
7
Page 8
8
Page 9
Reference Number and Description Part Number
709
Thermister
239-44861-00
712
Frost Sensing Switch
239-44882-00 713 120V Anti-Frost Heater Assembly 239-44884-00 714
Heater Connecting Harness
239-44875-00
715 120V Valve Heater Assembly 239-44865-00 719 Inlet Air Thermister 239-44863-00 720 Power Supply Harness 239-44870-00 721 Fuse Harness 239-44871-00 722 100V Harness 239-44872-00 723 Solenoid Valve Harness 239-44873-00 724 Sensor Harness 239-44886-00 725 Thermal Fuse Harness 239-44874-00* 726 Mold-Type Over Heat Switch 239-44876-00
727 Remote Control Cable 239-44945-00
* Denotes Service Stock Component.
Parts Common to IGI-180(C,R)-(5,10)(N,X)
9
Page 10
10
* Denotes Service Stock Component.
Page 11
11
Notes
Page 12
Sales/800-538-2020
800-532-4020
Fax/215-641-1670
Technical Support/800-334-3393
Fax/269-795-1089
Warranty/800-531-2111
Fax/269-795-1089
International:
Telephone/215-641-9400
Telefax/215-641-9750
Ambler, PA
888-538-7833
Fax on Demand:
bradfordwhite.comwww.
For U.S. and Canada field service,
contact your professional installing plumbing contractor
or local Bradford White representative.
Sales/866-690-0961
905-238-0100
Fax/905-238-0105
Technical Support/800-334-3393
Mississauga, ON
www.bradfordwhitecanada.com
Email
parts@bradfordwhite.com
techserv@bradfordwhite.com
www.bradfordwhite.com
www.bradfordwhitecanada.com
Loading...