Blue Rhino GOT1509M Owner's Manual

0 (0)

WARNING

FOR YOUR SAFETY:

For Outdoor Use Only

(outside any enclosure)

OWNER’S MANUAL

Outdoor LP Gas

Pizza Oven & Grill

Model No. GOT1509M

WARNING

FOR YOUR SAFETY:

1. Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.

2. Read the installation, operation and maintenance instructions thoroughly before installing or servicing this equipment.

3. Failure to follow these instructions could result in ﬁre or explosion, which could cause property damage, personal injury or death.

4. This instruction manual contains important information necessary for the proper assembly and safe use of the appliance.

5. Read and follow all warnings and instructions before assembling and using the appliance.

6. Follow all warnings and instructions when using the appliance.

7. Keep this manual for future reference.

DANGER

If you smell gas -

1. Shut off gas to appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the

appliance and immediately call your fire department.

Table of Contents

Important Safeguards ...........................................Page 2

Expanded View & Hardware .......................................... 4

Assembly Instructions............................................... 5

Installing LP Gas Tank............................................... 7

Operating Instructions............................................... 8

Cleaning and Care ................................................. 9

Product Registration ................................................ 9

Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Limited Warranty ................................................. 10

Troubleshooting .................................................. 11

Failure to follow these instructions could result in fire or explosion which could cause property damage, personal injury or death.

WARNING

FOR YOUR SAFETY:

1. Do NOT store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

DANGER

Never operate this appliance unattended.

The use and installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas

and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.

THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP FOR FUTURE REFERENCE.

California Proposition 65: Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm.

California Proposition 65: Wash your hands after handling this product. If you are assembling this unit for someone else, give this manual to him or her to

read and save for future reference.

Made from 75% Bagasse

(environmentally friendly sugar

cane pulp by-product)

Manufactured in China for: Blue Rhino Global Sourcing, Inc. Winston-Salem, NC 27105 USA • 1.800.762.1142 • BlueRhino.com © Blue Rhino Global Sourcing, Inc.

™

Mr. Pizza

is a trademark of Blue Rhino Global Sourcing, Inc. GOT1509M-OM-104 EF

Outdoor LP Gas Pizza Oven & Grill

Model No. GOT1509M

Important Safeguards

W DANGER: Failure to follow the dangers, warnings and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion causing damage

to property.

W WARNINGS:

W This oven & grill is for outdoor use only, and should not be used in a

building, garage or any other enclosed area.

W Do NOT operate, light or use this appliance within ten feet (3.05 m) of

walls, structures or buildings.

W For residential use only. This oven & grill is NOT for commercial use.

W Never fill the cylinder beyond 80 percent full. W A fire causing serious injury or damage to property may occur if the

above is not followed exactly.

W Never attempt to attach this oven & grill to the self-contained LP gas

system of a camper trailer, motor home or house.

W This is NOT a tabletop oven & grill. Therefore, do NOT operate this oven

& grill on any type of tabletop surface.

W This oven & grill is not intended for and should never be used as a

heater. TOXIC fumes can accumulate and cause asphyxiation.

W This oven & grill is safety certified for use in the United States and/or

Canada only. Do NOT modify for use in any other location. Modification will result in a safety hazard and will void your warranty.

W This oven & grill is for use with liquid propane (LP) gas only. The

conversion to or attempted use of natural gas in this LP gas oven & grill is dangerous, may cause bodily harm and will void your warranty.

W LP gas characteristics:

a. LP gas is flammable and hazardous if handled improperly. Become

aware of the characteristics before using any LP gas product.

b. LP gas is explosive under pressure, heavier than air, and settles/

pools in low areas.

c. LP gas in its natural state has no odor. For your safety, an odorant is

added that smells like rotten cabbage.

d. Contact with LP gas can cause freeze burns to skin.

W Apartment dwellers: Check with management to learn the requirements

and fire codes for using a LP gas oven & grill in your apartment complex. If allowed, use outside on the ground floor with a ten foot (3.05 m) clearance from any structure. Do NOT use on or under balconies.

W LP gas cylinder needed to operate. Only cylinders marked “propane”

may be used.

W The LP gas cylinder must be constructed and marked in accordance

with the Specifications for LP-gas Cylinders of the U.S. Department of Transportation (D.O.T.) or the National Standard of Canada, CAN/

CSA-B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods; and Commission.

W LP gas cylinder must be arranged for vapor withdrawal. W The LP gas cylinder must have a listed overfilling prevention device

(OPD).

W Only use LP gas cylinders equipped with a cylinder connection device

compatible with the connection for outdoor cooking appliances.

W The LP gas cylinder must have a cylinder collar to protect the cylinder

valve.

W Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene or

alcohol with this product.

W Your oven & grill has been checked at all factory connections for leaks.

Recheck all connections as described in the “Operating Instructions” section, as shipping can loosen connections.

W Check for leaks even if your unit was assembled for you by someone

else.

W Do NOT operate if a gas leak is present. Gas leaks may cause a fire or

explosion.

W You must follow all instructions in “Checking for Leaks” section before

operating. To prevent fire or explosion hazard when testing for a leak: a. Always perform a leak test before lighting the oven & grill and each

time the cylinder is connected for use.

b. No smoking. Do NOT use or permit sources of ignition in the area

while conducting a leak test. c. Conduct the leak test outdoors in a well-ventilated area. d. Do NOT use matches, lighters, or a flame to check for leaks. e. The use of alcohol, prescription or non-prescription drugs may

impair the consumer’s ability to properly assemble or safely operate

the appliance. f. Strong odors, colds, sinus congestion, etc. may prevent the

detection of propane. Use caution and common sense when testing

for leaks. g. Do NOT use oven & grill until any and all leaks are corrected. If you

are unable to stop a leak, disconnect the LP gas supply. Call a gas

appliance serviceman or your local LP gas supplier.

W This oven & grill is designed to operate at an inlet pressure of: LP gas:

11 inches water column.

W Do NOT store or use gasoline or other flammable liquids or vapors

within 25 feet (7.62 m) of this appliance.

W Do NOT use in an explosive atmosphere. Keep oven & grill area clear and

free from combustible materials, gasoline and other flammable vapors and liquids.

W Minimum clearance from sides and back of unit to combustible

construction is 36 inches (91.4 cm). Do NOT use this appliance under any type of overhang or roof.

W Never use an LP gas cylinder with a damaged body, valve, collar or

footing.

W Dented or rusted LP gas cylinders may be hazardous and should be

checked by your LP gas supplier prior to use. W The LP gas cylinder should not be dropped or handled roughly. W LP gas cylinders must be stored outdoors out of the reach of children

and must not be stored in a building, garage or any other enclosed area.

Your cylinder must never be stored where temperatures can reach over

125°F. W Do NOT insert any tool or foreign object into the valve outlet or safety

relief valve. You may damage the valve and cause a leak. Leaking

propane may result in an explosion, fire, severe personal injury or death. W Do NOT block holes in sides or back of oven & grill. W Never keep an LP gas cylinder in a hot car or trunk. Heat will cause the

gas pressure to increase, which may open the relief valve and allow gas

to escape. W Place dust cap on cylinder valve outlet whenever the cylinder is not in

use. Only install the type of dust cap on the cylinder valve outlet that is

provided with the cylinder valve. Other types of caps or plugs may result

in leakage of propane. W If oven & grill is not in use, the gas must be turned off at the supply

cylinder and disconnected. W Do NOT store a spare LP gas cylinder under or near this appliance.

W It is essential to keep the oven & grill’s valve compartment, burners and

circulating air passages clean. W Inspect oven & grill before each use. W Do NOT alter oven & grill in any manner. Any alteration will void your

warranty. W Do NOT use the oven & grill unless it is COMPLETELY assembled and all

parts are securely fastened and tightened. W Do NOT build this model of oven & grill in any built-in or slide-in

construction. Ignoring this warning could cause a fire or an explosion

that can damage property and cause serious bodily injury or death. W This oven & grill should be thoroughly cleaned and inspected on a

regular basis. W Clean and inspect the hose before each use of the appliance. If there

is evidence of abrasion, wear, cuts or leaks, the hose must be replaced

prior to operation. W Use only the regulator and hose assembly provided. Use only the

replacement regulator and hose assembly specified by Blue Rhino

Global Sourcing, Inc. W Use only Blue Rhino Global Sourcing, Inc. factory-authorized parts. The

use of any part that is not factory-authorized can be dangerous and will

void your warranty. W Do NOT operate this appliance without reading “Operating Instructions”

in this manual.

Recipes

BlueRhino.com/recipes

Need help? 1.800.762.1142

Do not return to place of purchase.

Replacement Parts

parts.BlueRhino.com

1.800.762.1142

W Do NOT touch metal parts of oven & grill until they have completely

cooled to avoid burns, unless you are wearing protective gear (pot

holders, gloves, BBQ mittens, etc.). W Do NOT install or use in or on boats or recreational vehicles. W When cooking, fire extinguishing materials should be readily accessible.

In the event of an oil/grease fire, do NOT attempt to extinguish with

water. Use type BC dry chemical fire extinguisher or smother with dirt,

sand or baking soda. W Do NOT use oven & grill in high winds. W NEVER lean over the oven & grill when lighting. W Do NOT leave a lit oven & grill unattended. Keep children and pets away

from oven & grill at all times. W Do NOT leave oven & grill unattended while preheating or burning off

food residue on high. If oven & grill has not been cleaned, a grease fire

can occur that may damage the product. W Do NOT place empty cooking vessels on the appliance while in

operation. W Use caution when placing anything on the oven & grill while the

appliance is in operation. W Do NOT attempt to move oven & grill when in use. Allow the oven & grill

to cool before moving or storing. W LP gas cylinder must be properly disconnected and removed prior to

moving this oven & grill. W Storage of oven & grill indoors is permissible only if the cylinder is

disconnected, removed from the oven & grill and properly stored

outdoors.

W Do NOT attempt to disconnect the gas regulator from the cylinder or any

gas fitting while the oven & grill is in use. W Do not place on a wooden deck. W Always place your oven & grill on a hard, non-combustible, level

surface. An asphalt or blacktop surface may not be acceptable for this

purpose. W Move gas hoses as far away as possible from hot surfaces and dripping

hot grease. W The gas hose should be arranged so that it will not be pulled on or

tripped over. W Keep all electrical cords away from a hot oven & grill. W After a period of storage and/or nonuse, check for leaks, burner

obstructions and inspect for any abrasion, wear or cuts to the hose. W Failure to open lid while igniting the oven & grill’s burners, or not

waiting 5 minutes to allow the gas to clear if the oven & grill does not

light, may result in an explosive flame-up. W Never operate oven & grill without its heat plates installed. W Always use a meat thermometer to ensure food is cooked to a safe

temperature. W Use protective gloves when assembling this product. W Do NOT force parts together as this can result in personal injury or

damage to the product. W Never cover entire cooking area with aluminum foil. W Deaths, serious injury or damage to property may occur if the above is

not followed exactly.

W Always open oven & grill lid carefully and slowly as heat and steam

trapped within oven & grill can cause severe burns.

Outdoor LP Gas Pizza Oven & Grill

Model No. GOT1509M

Parts List

Lid Air Vent

Temperature Gauge*

Oven Door Assembly*

Lid Handle (2)

Lid*

Warming Rack

Cooking Grid

Top Hinge*

Bottom Hinge* Regulator/Hose

Assembly* Cooking Grid/Heat Plate

Support*

Side Handle (2)

Burner*

Grill Body*

Lock (2)*

Control Knob*

55-24-701

55-24-702

55-24-744

55-24-704

55-24-705

55-24-708

55-24-718

55-24-706

55-24-707

55-24-712

55-24-709

55-24-710

55-24-711

55-24-745

55-24-715

55-24-716

Expanded View

Pizza Stone

Brand Plate*

Heat Plate

Grease Cup

Front Leg (2)*

Back Leg (2)*

* Pre-assembled

55-24-735

55-24-717

55-24-725

55-24-723

55-24-719

55-24-720

Hardware

A B C D E F G H

Screw

Nut

Wing Nut

Washer

Lock Washer

M4x10 Nickel Plated Phillips Truss Head

M8 Nickel Plated

M6 Nickel Plated

ø6.4 Nickel Plated

ø8.4 Nickel Plated

ø8 Heat Resistant

ø6.4 Nickel Plated

ø8.4 Nickel Plated

8 pcs

2 pcs

4 pcs

2 pcs

4 pcs

2 pcs

Tools Required for Assembly (Included)

#2 Phillips Head Screwdriver 1 pc

M10-M8 Wrench 1 pc

Recipes

BlueRhino.com/recipes

Assembly Instructions

Need help? 1.800.762.1142

Do not return to place of purchase.

Replacement Parts

parts.BlueRhino.com

1.800.762.1142

DO NOT RETURN TO PLACE OF PURCHASE.

For assistance, call 1.800.762.1142 toll-free. Please have your Owner’s Manual and model number available for reference.

Note: The model number can be found on the back or side of the oven & grill.

Assembly Tips:

1. Select an area where you will assemble this product. To protect components, choose a smooth surface that’s free of cracks or openings.

2. Spread out all parts.

3. Tighten all hardware connections by hand first. Then, before completing each step, go back and fully tighten all hardware. Be careful not to over-tighten. That could damage surfaces or strip threads.

4. For best results, complete each step in the order presented.

To complete assembly you will need:

• (1) Leak Detection Solution (instructions on how to make solution are included in “Operating Instructions” section).

• (1) Precision-filled LP gas grill tank with Acme Type 1 external threaded valve connection (standard grill size).

Attach Lid Air Vent

Typical assembly is approximately one hour.

Attach Lid Handles

Attach Side Handles

x 3

x 2

x 4

Assembly Instructions (continued)

Outdoor LP Gas Pizza Oven & Grill

Model No. GOT1509M

Insert Warming Rack

Insert Heat Plate, Cooking Grid and Pizza Stone

Insert Grease Tray

Lock Lid

Note: Lid must be locked before transporting oven & grill.

Unlock Lid

Note: Always unlock and open lid before lighting oven & grill.

Recipes

17.9 in. / 45.5 cm

12.2 in. / 31 cm

BlueRhino.com/recipes

Insert Oven & Grill and Place Pizza Stone (if applicable)

Need help? 1.800.762.1142

Do not return to place of purchase.

Installing LP Gas Tank

To operate, you will need one precision-filled standard grill LP gas tank with external valve threads.

W CAUTION: LP gas tank must be properly

disconnected and removed prior to moving this oven & grill.

W CAUTION: Always place your oven & grill on a

hard, non-combustible, level surface. An asphalt or blacktop surface may not be acceptable for this purpose.

W CAUTION: Move gas hoses as far away as possible from hot surfaces

and dripping hot grease.

W CAUTION: The gas hose should be arranged so that it will not be pulled

on or tripped over.

Replacement Parts

parts.BlueRhino.com

1.800.762.1142

20 lb

9 Kg

Inserting and Securing LP Gas Tank in Cart (if applicable)

Note: Cart is sold separately. Loosen LP gas tank retainer bolt by turning counter-clockwise. Place precision-filled LP gas tank upright into hole in cart body so the tank valve is facing the

gas line connection. Secure tank by turning LP gas tank retainer bolt clockwise until tight.

Using as a portable grill

W WARNING: The cylinder

shall be placed 18 inches minimum away from appliance. Hose may cause tip hazard.

Connecting LP Gas Tank

1. Before connecting, be sure there is no debris caught in the head of the LP gas tank, head of the regulator valve or in the head of the burner or burner ports.

2. Control knob must be in the “ (Figure 2).

3. Connect regulator/hose assembly to tank by turning knob clockwise until it stops.

OFF” position

Disconnecting LP Gas Tank

1. Before disconnecting, make sure the LP gas tank valve is “CLOSED.”

2. Disconnect regulator/hose assembly from LP gas tank by turning knob counterclockwise until it is loose.

W CAUTION: LP gas tank must be properly

disconnected and removed prior to moving this oven & grill.

3. Place the protective cap cover on the LP tank and store the tank outdoors in a well ventilated area out of direct sunlight.

Min. / Min. :

18 in. / po.

46 cm

Operating Instructions

Outdoor LP Gas Pizza Oven & Grill

Model No. GOT1509M

Checking for Leaks

Burner Connections

1. Make sure the regulator hose and valve connections are securely fastened to the burner and the tank.

2. Visually check the connection between the burner/ venturi tube and orifice.

3. Make sure the burner/venturi tube fits over the orifice.

W WARNING: Failure to inspect this

connection or follow these instructions could cause a fire or an explosion

LP Gas Connection

Figure 1

Burner/ Venturi Tube

LP Gas Valve with Oriﬁce

which can cause death, serious bodily

Figure 2

Figure 3

Figure 4

OFF ARRÊT

injury or damage to property.

4. Please refer to diagram for proper installation (Figure 1).

5. If the burner/venturi tube does not rest flush to the orifice, as shown, please contact 1.800.762.1142 for assistance.

Tank/Gas Line Connection

1. Make 2-3 oz. of leak detection solution by mixing one part liquid dishwashing soap with three parts water.

2. Make sure control knobs are in the “ position (Figure 2).

3. Connect LP gas tank per “Installing LP Gas Tank” section.

4. Turn LP gas tank valve to “OPEN.”

5. Spoon several drops of solution, or use a squirt bottle, at all “X” locations (Figures 1, 3 and 4).

a. If any bubbles appear, turn LP gas tank valve to

“CLOSED,” reconnect and re-test.

b. If you continue to see bubbles after several

attempts, turn LP gas tank valve to “CLOSED” and disconnect LP gas tank, per “Disconnecting LP Gas Tank” section. Contact 1.800.762.1142 for assistance.

c. If no bubbles appear after one minute, turn LP

gas tank valve to “CLOSED,” wipe away solution and proceed.

OFF”

First Use

1. Make sure all labels, packaging and protective films have been removed from the grill.

2. Remove manufacturing oils before cooking on this grill for the first time by operating the grill for at least 15 minutes on closed. This will “heat clean” the internal parts and dissipate odors.

Lighting

W CAUTION: Keep outdoor gas cooking

appliance area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

W CAUTION: Do NOT obstruct the flow of

combustion and ventilation air.

W CAUTION: Check and clean burner/

venturi tubes for insects and insect nests. A clogged tube can lead to a fire.

W CAUTION: Attempting to light the

burner with the lid closed may cause an explosion.

W CAUTION: Always place your oven &

grill on a hard, non-combustible, level surface. An asphalt or blacktop surface may not be acceptable for this purpose.

W CAUTION: Move gas hoses as far away as possible from hot surfaces

and dripping hot grease.

W CAUTION: The gas hose should be arranged so that it will not be pulled

on or tripped over.

1. Open lid.

2. Check for obstructions of airflow to the burners. Spiders, insects and webs can clog the burner/venturi tube. A clogged burner tube can lead to a fire.

3. Control knob must be in the “

4. Connect LP gas tank per “Installing LP Gas Tank” section.

5. Turn LP gas tank valve to “OPEN.”

(HIGH) with the lid

Figure 5

Match

OFF” position (Figure 2).

6. Push and turn any control knob to . The burner should light. If it does not, repeat up to three times.

7. If ignition does not occur in 5 seconds, turn burner control knob “ repeat lighting procedure.

8. If igniter does not light burner, use a long lit match to light burners. Access the burners through the cooking grid and heat plates. Position long lit match near side of burner (Figure 5).

9. After lighting, observe the burner flame. Make sure all burner ports are lit and flame height matches illustration (Figure 6).

OFF,” wait 5 minutes, and

W CAUTION: If burner flame goes out

during operation, immediately turn the control knobs to the “

OFF” position, turn the LP gas tank valve to “CLOSED” and open lid to let the gas clear for 5 minutes before re-lighting.

Turning Off

1. Turn LP gas tank valve to “CLOSED.”

2. Turn all control knobs clockwise to the “ position. Note: A “poof” sound is normal as the last of the LP gas is burned.

3. Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.

OFF”

To Use as a Pizza Oven

W CAUTION: Always open oven door

carefully and slowly as heat and steam trapped within grill can cause severe burns.

W CAUTION: Always wear protective gear

(pot holders, gloves, BBQ mittens, etc) when opening and closing the oven door.

1. Remove warming rack.

2. Place pizza stone on cooking grid.

3. Light grill per “Lighting Instructions” section.

4. Wait until pizza oven is at desired temperature.

5. Wearing heat resistant gloves, open the oven door (Figure 7).

6. While wearing heat resistant gloves, use a pizza peel to carefully place the pizza on the pizza stone.

7. While wearing heat resistant gloves, close the oven door (Figure 8).

8. Cook food until proper cooking time or desired temperature is reached. Note: Cooking times with this product may vary from cooking times for microwaves and stoves.

9. Wearing heat resistant gloves, open the oven door.

10. While wearing heat resistant gloves, carefully remove the pizza with the pizza peel.

11. Turn off per “Turning Off” section.

W CAUTION: Always allow the pizza stone

to fully cool before removing it from the oven.

W CAUTION: Do NOT place pastries or

cookies directly on the stone; the butter or fat content will cause the stone to smoke.

To Use as a Grill

W CAUTION: Always open grill lid

carefully and slowly as heat and steam trapped within grill can cause severe burns.

W CAUTION: Always wear protective gear

(pot holders, gloves, BBQ mittens, etc) when opening and closing the oven door.

1. Remove pizza stone and properly store.

2. Light grill per “Lighting Instructions” section.

3. Wait until grill is at desired temperature.

Burner

Figure 6

Flame

Figure 7

Figure 8

Slight

Yellow

Slight

Blue

Dark Blue

+ 16 hidden pages