Blodgett BCS-6 Parts List

COS-6 COMBI OVEN &
BCS-6 STEAMER
REPLACEMENT PARTS LIST
EFFECTIVE NOVEMBER 22, 2013
The Company reserves the right to make substitution in the event that items specied are not available.
ERRORS: Descriptive and/or typographic errors are subject to correction.
44 Lakeside Avenue, Burlington, Vermont 05401 USA Telephone: (802) 658-6600 Fax: (802) 860-3732
BLODGETT OVEN COMPANY
www.blodgett.com
P/N 55192
SERIAL NUMBER LOCATION / KEY:
IMPORTANT: When ordering parts, please provide the model,
gas type, voltage and serial number of the oven. The identica­tion plate is located on the left side of the control compartment.
SERIAL NUMBERS CONTAINING:
HK
HR
IM
EXAMPLE:
021896HK023S
TO OBTAIN LITERATURE:
Email: literature@blodgett.com
or visit
www.blodgett.com
NOVEMBER 22, 2013 2 COS-6 & BCS-6
TABLE OF CONTENTS
Doors Are Not Returnable
COS STANDARD CONTROL .................................................... PAGE 4
COS DIGITAL CONTROL ........................................................ PAGE 6
BCS CONTROL ................................................................. PAGE 8
EXTERIOR COMPONENTS ..................................................... PAGE 9
DOOR COMPONENTS ......................................................... PAGE 10
DOOR HANDLE COMPONENTS ................................................ PAGE 12
HARNESS & PANEL ASSEMBLY ................................................ PAGE 14
THERMOSTATS ............................................................... PAGE 17
CONVECTION MOTOR COMPONENTS ......................................... PAGE 18
HOT AIR ELEMENTS, BAFFLE & RACKS ........................................ PAGE 20
STEAM GENERATOR COMPONENTS .......................................... PAGE 21
PLUMBING COMPONENTS .................................................... PAGE 22
ACCESSORIES ................................................................ PAGE 24
BODY BACK & BOTTOM OPTIONS ............................................. PAGE 26
NOVEMBER 22, 2013 3 COS-6 & BCS-6
COS STANDARD CONTROL
16
14
3
9
4
10
9
3
12
19
21
17
2
8
20
18
22
NOVEMBER 22, 2013 4 COS-6 & BCS-6
COS STANDARD CONTROL
Ref. Part No. No. Description
R5181 Control panel, Std, 60hz w/out meat probe R5814 Control panel, Std, 50hz w/out meat probe R5247 Control panel, Std, 60hz w/meat probe R5588 Harness, control (all panels listed above) R4872 Gasket, control panel 2 R5183 Decal, control Std w/o meat probe R5210 Decal, control Std w/meat probe 3 R4623 Switch, mode 4 position R8515 Knob and shaft assy, mode switch 4 R6407 Controller, temperature 150-500 degrees P5 (s/n’s HR) R1178 Thermostat, hot air P5 200-500 degrees (s/n’s HK) R6003 Probe, temp controller (item #4) R3992 Gasket, probe, temp controller (item #4) 8 R2715 Switch, momentary Flush/Drain 9 R0226 Indicator light, clear 10 R1318 Indicator light, green Power On 12 16686 Knob, temp control & timer 14 R2666 Timer, 120 minute 60hz R3942 Timer, 120 minute 50hz & CE 16 R2792 Relay, SPST 240V ice cube R7689 Relay, SPDT, CE 17 M6899 Transformer, 208/240V-24V, CE 18 R5242 Controller, meat probe R7692 Controller, meat probe, CE 19 R4622 Switch, meat probe on/off 20 R5219 Panel jack 21 R5315 Probe, meat plug-in type 22 R6988 Suppressor, arc assy R5218 Harness, meat probe R5325 Wire, thermocouple 20 awg R7717 Fuse, 24V, 2 amp, CE M3167 Holder, fuse, 24V CE R7715 Bracket, fuse holder, CE
NOVEMBER 22, 2013 5 COS-6 & BCS-6
COS DIGITAL CONTROL
9
16
10
4
17
23
25
20
24
18
2
8
22
26
21
NOVEMBER 22, 2013 6 COS-6 & BCS-6
COS DIGITAL CONTROL
Ref. Part No. No. Description
R5175 Control Panel, TNT w/o meat probe R5246 Control Panel, TNT w/meat probe R4872 Gasket, control panel 2 R7426 Decal, control TNT w/o meat probe
R7854 Controller retrot kit (from knob to all pads)
R7403 Controller, time & temp (all touch pads) R6928 Sensor, controller 8 R2715 Switch, momentary Flush/Drain 9 R0226 Indicator light, clear 10 R1318 Indicator light, green Power On 14 M0199 Tie cable, w/adhesive (not shown) 15 9067 Tie, wire (not shown) 16 R4623 Switch, mode 4 position 17-18 R8515 Knob and shaft assy, mode switch 20 R2792 Relay, SPST 240V ice cube R7689 Relay, SPDT, CE 21 M6899 Transformer, 208/240V-24V 22 R5242 Controller, meat probe R7692 Controller, meat probe CE 23 R7198 Switch, meat probe on/off 24 R5219 Panel jack 25 R5315 Probe, meat plug-in type 26 R6988 Suppressor, arc assy R5481 Nut, keps 4-40 s/s R5218 Harness, meat probe R5325 Wire, thermocouple 20 awg R7717 Fuse, 24V 2 amp, CE M3167 Holder, fuse 24 V, CE R7715 Bracket, fuse holder, CE
NOVEMBER 22, 2013 7 COS-6 & BCS-6
BCS CONTROL
15
16
4
4
5
12
11
3
14
10
Ref. Part No. No. Description
R7070 Control panel, Std, 60hz, w/out meat probe, OCB R7073 Harness, control, OCB R4872 Gasket, control panel 3 R7057 Decal, control OCB 4 R4622 Switch, mode 4 position 5 R7477 Switch, push button, green, OCB R7476 Contact block, push button switch, OCB 10 R2715 Switch, momentary Flush/Drain 11 R0226 Indicator light, clear 12 R1318 Indicator light, green Power On 14 16686 Knob, timer 15 R2666 Timer, 120 minute 60hz R3942 Timer, 120 minute 50hz 16 31558 Relay, DPST 204/240V 25amp, OCB
NOVEMBER 22, 2013 8 COS-6 & BCS-6
EXTERIOR COMPONENTS
9
10
4
7
5
8
6
Ref. Part No. No. Description
4 R2909 Door assy, RH hinge w/glass R7069 Door assy, RH hinge solid 5 R6313 Handle, door (after s/n 120198) R7833 Handle, door (before s/n 120198) 6 Various Control panel 7 R2905 Drip pan, RH hinge ovens R3926 Drip pan, LH hinge ovens 8 R4873 Panel, access R4875 Guide, access panel 9 R3012 Funnel assy, deliming 10 R2895 Handle, deliming port R2998 Adapter, hose decalcifying R3011 Cap, decalifying adapter
NOVEMBER 22, 2013 9 COS-6 & BCS-6
DOOR COMPONENTS
13
13
1
1
1
16
6
5
5
1
20
21
23
Oven
24
26
27
25
Door
22
28
29
NOVEMBER 22, 2013 10 COS-6 & BCS-6
DOOR COMPONENTS
Ref. Part No. No. Description
1 R2909 Door assy, RH hinge w/glass R7069 Door assy, RH hinge solid 5 R2105 Gasket, window (per foot) 6 R5799 Window, door 13” x 14” 13 R0759 Rivet, monobolt 1/8 dia. x 3/8 long s/s 14 R1278 Rivet, pop 1/8 dia. x 1/4 long s/s 16 R0391 Insert, 1/4-20 UNC 20 R7822 Fastener, 1/4-20 UNC rivnut s/s R2160 Nut, speed (not shown) 16469 Nameplate, Blodgett 7-3/4 (not shown) R1287 Bumper, rubber (not shown) R3013 Gasket, door perimeter (not shown) R3047 Plate, mounting gasket, horiz. R3048 Plate, mounting gasket, vert. R2292 Washer, door height adjustment 21 R2822 Bracket, hinge top 22 R2821 Bracket, hinge bottom R3658 Hardware kit, door hinge (contains parts below) 23 R3397 Pin, hinge R0047 Spring, door hinge pin R2356 Spacer, door screw R2357 Washer, lock 1/4 19775 Screw, machine 10-24 x 3/4 s/s 24 R2818 Switch, micro door R2385 Harness, door switch (not shown) 4068 Grommet, door switch 25 31485 Switch, door proximity, CE R7753 Cup, magnet, door switch, CE (not shown) R7808 Magnet, door switch, CE (not shown) 26 R2844 Pin, door switch, RH hinge 27 R3717 Pin, door switch, LH hinge 28 R3089 Holder, door trough, RH hinge 29 R2080 Trough assy, door drip, RH hinge R3675 Trough assy, door drip, LH hinge
NOVEMBER 22, 2013 11 COS-6 & BCS-6
DOOR HANDLE COMPONENTS
Oven
Door
6
5
Ref. Part No. No. Description
2
6
75
8
3
9
1
4
1 R6313 Handle assy, door (s/n’s after 120198)
R7833 Handle retrot, door (s/n’s before 120198)
R6314 Screw, door handle (s/n’s after 120198) R1286 Screw, door handle (s/n’s before 120198) R7830 Plate, door handle (s/n’s after 120198) R1452 Plate, shim handle (s/n’s before 120198) R2369 Reattachment kit, handle (s/n’s before 120198) 2 R2296 Catch assy, door (comprised of parts below) 3 R2780 Latch, door s/s 4 R2781 Catch, door s/s
5 M1820 Washer, at #10
6 R0726 Washer, lock #10 7 R2825 Screw, machine 10-32 x 3/8 s/s head 8 R0031 Screw, machine M5 x 8-16 s/s head (s/n’s prior to ‘92) 9 19775 Screw, machine 10-24 x 3/4 s/s head (s/n’s after ‘92) 16469 Name plate, Blodgett
NOVEMBER 22, 2013 12 COS-6 & BCS-6
INCOMING POWER COMPONENTS
1
4
6
3
5
Ref. Part No. No. Description
1 R1586 Block, terminal power 208/240V 1ph 50/60hz R1586 Block, terminal power 208/240V 3ph 50/60hz R1586 Block, terminal power 380/220/415/240V 3ph 50hz
R7809 Harness, lter to terminal block CE
3 20043 Cable, strain relief R0048 Connector, electrical 4 R5756 Fuse, 4 amp (s/n’s HR) R0032 Fuse, 3 amp SC3 (s/n’s HK) R0043 Fuse, 3 amp KTKR3 (Canada only) R5774 Fuse, 2 amp FNQR2 (480V only) R5773 Fuse, 1 amp FNQR1 (480V only) 5 20442 Holder, fuse 4 amp, KTKR3, FNQR2 & FNQR1 20163 Holder, fuse 3 amp SC3 15247 Screw, sdrill 10-16 x 5/8 ZNP fuse option Export M3167 Holder, 6.3 amp, CE type HTB-3 6M 15247 Screw, sdrill 10-16 x 5/8 ZNP CE
NOVEMBER 22, 2013 13 COS-6 & BCS-6
HARNESS & PANEL ASSEMBLY
22
23
19
21
20
Note: Mounted on the front of the bracket
15
18
13
16
Note: Mounted behind the timing board
Note: Mounted underneath the bracket
10
14
14
Alternate for CE Ovens Only
9
10
7
12
11
NOVEMBER 22, 2013 14 COS-6 & BCS-6
HARNESS & PANEL ASSEMBLY
Ref. Part No. No. Description
7 R1443 Controller assy, steam P2 (comprised of parts below)
Note: Mounted underneath the bracket below the relays
9 R1442 Bracket, mounting temp controller 10 18234 Potentiometer, remote 11 18268 Spacer, nylon 12 18744 Controller, 8 pot hold 13 R0022 Sensor, steam controller 14 R5708 Board, level control
R5776 Retrot kit, level sensing (from UE board w/5 orange relays)
15 R2792 Relay, 220/240V ice cube
Note: Mounted on the front of the bracket
16 R5305 Timer, solid state (HK & HR s/n’s only)
Note: Mounted behind the Timing Board
38559 Conversion kit, mercury to mechanical (208V 3ph) 18 R0038 Capacitor, suppressor, Contactor K3 19 R6402 Timing board R8338 Suppression kit, noise (update timing board) R7381 Standoff, male nylon R7382 Standoff, female nylon 20 R9498 Buzzer assy, w/resistor 21 R8724 Resistor only, buzzer assy 22 R1586 Block, terminal, power 50hz only 23 R1580 End stop, terminal block 50hz only
NOVEMBER 22, 2013 15 COS-6 & BCS-6
HARNESS & PANEL ASSEMBLY
COMPONENTS ON UNITS PRIOR TO 1996 ONLY
1
5
2
7
4
Ref. Part No. No. Description
1 51692 Contactor, motor 208V K1 2 52693 Contactor, motor 208/240V K1 4 R0261 Protector, motor PKZM F2 (s/n’s HK) 5 R2128 Protector, motor PKZM F2 480V 7 R2815 Pin connector, 10 pin R2816 Pin connector, 11 pin
NOVEMBER 22, 2013 16 COS-6 & BCS-6
THERMOSTATS
P7
P1
P3
P4
F3
2
3
Alternate for CE ovens
6
4
Pre 1996 Ovens
5
8
6
F6
Ref. Part No. No. Description
2 R3662 Thermostat, cooling fan hi limit P7 (s/n’s HR) R2039 Thermostat, cooling fan hi limit P7 (s/n’s HK) 3 R2801 Themostat, Too hot to steam P1 4 R0118 Thermostat, Steam pre-heat prioity P3 5 R0122 Thermostat, quench P4 R3755 Gasket, thermostat P4 6 R1573 Thermostat, Cooking hi limit 670 degrees F3 R5414 Grommet, thermostat 7 R2630 Thermostat, steam generator hi limit F6 8 R2040 Thermostat, stack hi limit F7 (s/n’s before 1996)
7
NOVEMBER 22, 2013 17 COS-6 & BCS-6
CONVECTION MOTOR COMPONENTS
FOR OVENS MANUFACTURED BEFORE 7/13/95
Ref. Part No. No. Description
1 R0092 Motor, 208/240V, 3ph R0079 Motor, 240V, 1ph R3025 Heat slinger, motor 3 R0037 Nut, hex motor mounting R0714 Nut, hex motor mounting 4 R0039 Washer, toothed lock 8532 Washer, toothed lock 5 R0231 Washer 6 R2328 Packing, motor shaft 8 R0232 Washer, blower wheel 9 R0233 Washer, toothed lock, blower wheel 10 R0034 Screw, hex, blower wheel 13 R3699 Blower wheel R2425 Capacitor, motor start 6mfd R2012 Cover, capacitor R2010 Bracket 15882 Nut, 1/4-20 1265 Washer, lock R3647 Hardware kit, motor mounting
NOVEMBER 22, 2013 18 COS-6 & BCS-6
CONVECTION MOTOR COMPONENTS
18
FOR OVENS MANUFACTURED AFTER 7/13/95
14
17
16
15
15
16
19
18
17
21
20
20
23
23
24
28
26
25
25
27
28
LINERSIDE
30
29
29
Ref. Part No. No. Description
14 R4227 Motor, 1/3hp 115/230V 1ph R4920 Motor, 480V 3ph 15 R5190 Spacer, motor 16 R0714 Nut, hex 5/16-18 s/s 17 1798 Washer, lock 5/16
18 R2292 Washer, at 3/8 s/s
19 R2349 Plate, motor mount 20 M0229 Washer, split lock 3/8 s/s 21 R4417 Plate assy, stud mounting 23 20559 Bolt, 3/8-16 x 3/4 hex 24 R4482 Insulation, duraboard .5 25 R9648 Washer, seal, 1/4" I.D. 26 R4244 Seal, motor shaft 27 R3471 Plate, shaft seal mounting 28 M0417 Washer, lock 1/4 split 29 R2006 Nut, hex jam 1/4-20 x 5/32 30 R5082 Wheel, blower small R2122 Insulation, motor
NOVEMBER 22, 2013 19 COS-6 & BCS-6
HOT AIR ELEMENTS, BAFFLE & RACKS
1
2
3
4
5
Ref. Part No. No. Description
1 R3652 Element assy, hot air 208V (6 ring assy) R3653 Element assy, hot air 240V (6 ring assy) 2 R7557 Pan holder, PH-5 R7868 Pan holder, PH-6 R1971 Spacer, rack guide 3 R1012 Wire rack
4 R3760 Grease lter 5 R2099 Bafe assy 6 R7320 Bafe assy, OCB only R8130 Retrot kit, bafe and grease lter
6
NOVEMBER 22, 2013 20 COS-6 & BCS-6
STEAM GENERATOR COMPONENTS
6
14
7
12
11
8
9
9
10
4
1
5
2
15
Ref. Part No. No. Description
1 R2454 Steam generator assy R2455 Insulation, steam generator 2 R2467 Boot, rubber drain R2487 Clamp, drain boot large 3 R2726 Pump, drain 60hz R7563 Pump, drain 50hz R6870 O’ring, drain pump R2927 Hose, pump outlet 7/8” ID (per foot) R0254 Clamp, hose plumbing 7/8” 4 R2814 Hose, steam transfer 1-1/4” ID (per foot) R0082 Clamp, plumbing 1-1/4” 5 R2812 Hose, pharmed, 3/8” ID (per foot) R0080 Clamp, hose plumbing 3/8” 6 R6965 Probe assy, dual level sensing (used w/Warrick Board) 7 R5361 Probe only, level sensing 8 R5343 Plate, level sensing 9 R1491 Gasket, switch level 10 R3141 Probe, level sensing, “J” hook, 3 wire (used w/UE Board)
5
Ref. Part No. No. Description
11 R2926 Plate, “J” hook probe 12 R2843 Probe only, “J” hook 14 R7180 Element assy, steam 208V 60hz w/thermocouple R7181 Element assy, steam 208V 50hz w/thermocouple R7182 Element assy, steam 240V 60hz w/thermocouple R7183 Element assy, steam 240V 50hz w/thermocouple R7184 Element assy, steam 480V 60hz w/thermocouple 15 R2769 Element assy, steam 208V 60hz R2768 Element assy, steam 208V 50hz R2772 Element assy, steam 240V 60hz R2771 Element assy, steam 240V 50hz R7187 Element assy, steam 380/220V 50hz R7723 Element assy, steam 400/230V 50hz CE R4432 Element assy, steam 480V 60hz
3
NOVEMBER 22, 2013 21 COS-6 & BCS-6
PLUMBING COMPONENTS
1
2
3
4
10
5
8
9
7
6
28
30
29
25
12
20
18
19
17
21
24
26
24
23
24
22
NOVEMBER 22, 2013 22 COS-6 & BCS-6
PLUMBING COMPONENTS
Ref. Part No. No. Description
1 R3155 Valve assy, decalicifying (comprised of parts below) 2 R1928 Elbow, street 1/2 NPT 3 R1142 Valve, ball 4 R1198 Fitting, barb 3/8 x 1/2 5 R2998 Adapter, hose decalcifying R3079 Gasket, decalcifying inlet R2895 Handle, decalicifying valve R1325 Cover, drain handle R3011 Cap, decalicifying valve R2812 Hose, decalicifying 3/8 ID (per foot) 6 R4891 Overpressure assy, steam (comprised of parts below) 7 R7581 Outlet assy, steam 8 R7575 Spring, pressure relief 9 R2657 Gasket, pressure relief 10 R7570 Cover, pressure relief R7732 Nut, 1/4-20 thin w/nylon 11 R2437 Stack, quench R2812 Hose, quench stack, 3/8” ID (per foot) R0080 Clamp, plumbing 3/8” 12 R3643 Nozzle assy, quench (comprised of parts below) 13 R1198 Fitting, barb 3/8 x 1/2 18 R2868 Gasket, cavity drain 19 R2202 Boot, drain, gray silicone 2” 20 R2207 Clamp, drain boot 21 R5079 Solenoid valve assy, triple 208/240V R5077 Valve body, solenoid triple R5075 Coil, solenoid valve 208/240V R5071 Fitting, barbed 3/8 22 R5078 Solenoid valve assy, single 208/240V CE R2522 Solenoid valve assy, dual 208/240V CE 23 R7978 Fitting, 3/4 hose, male 24 R7750 Washer, garden hose 26 R7813 Coupling, 3/4G x 3/4G brass 28 R7050 Venturi assy (comprised of parts listed below) 29 R1317 Elbow assy, venturi 30 R0640 Fitting, straight 1-3/32
R0729 Washer, at 13/16
R8651 Hose, steam transfer, green, 7/8” ID (per foot)
NOVEMBER 22, 2013 23 COS-6 & BCS-6
ACCESSORIES
10
1
Pressure
Regulator
R1036
11
12
4
3
2
5
15
7
8
9
6
24
25
27
13
23
26
30
20
22
29
28
30
31
31
NOVEMBER 22, 2013 24 COS-6 & BCS-6
ACCESSORIES
Ref. Part No. No. Description
1 R0006 Bottle, pressure spray R6332 Repair kit, spray bottle (nozzle repair only) 2 R3109 Leg set, 4” s/s w/feet 3 R3110 Leg set, 6” s/s w/feet 33196 Leg set, 6” s/s, seizmic 4 R2899 Leg set, 25” s/s w/feet R5455 Leg set, stands R5456 Leg set, stands, seizmic 5 R3112 Caster kit, 5” 2 locking/2 non-locking R8161 Caster kit, stands ACS-12 R5454 Caster kit, stands ACS-18 & ACS-31 6 R9064 Installation kit, start up (comprised of parts below) 7 R2207 Clamp, hose 8 R6884 Tee, copper 9 R6885 Reducer, 2 x 1.5 R6886 Adapter, copper 1-1/2 R1033 Vent, drain R10899 Hose, spray and nozzle assy 8’ (comprised of parts below) 11 53639 Nozzle, spray
12 R0376 “Y” tting 13 R10889 Hose, 8’ w/ttings
15 R5392 Hook, hose 20 R7648 Stand, ACS-12 (s/n’s IM) 22 R5449 Stand, ACS-31 23 R3012 Funnel assy, deliming (comprised of parts below) 24 R2999 Fitting, swivel decalcifying 25 R3000 Funnel, decalcifying 26 R7886 Tube, 3/8 ID 27 R9601 Deliming bottle assembly (comprised of parts below) 28 R8860 Hand pump assy 29 R8861 Bottle, deliming 30 R8875 Clamp, hose 31 R8084 Fitting, male hose, barbed R3128 Stacking kit, Combi on DFG R3074 Vent kit, stacking (on another 6 series oven) R3077 Vent kit, stacking (with other models) R8516 Vent kit, stacking, copper (OCB) R9047 Side shield, SS-6 w/hardware
NOVEMBER 22, 2013 25 COS-6 & BCS-6
BODY BACK & BOTTOM OPTIONS
2
1
3
87
5
Ref. Part No. No. Description
1 R7654 Body bottom, single, top or bottom section 2 R7653 Panel, access body bottom 3 R2553 Body back, ALCT 15247 Screw, sdrill 10-16 x 5/8 ZNP, body back mounting R7660 Panel, access body back s/s 5 R3161 Cover, thermostat access panel, ALCT R5356 Cover, thermostat access panel, s/s 6 R5312 Shield, fan ALCT R5384 Shield, fan s/s 7 23034 Fan, 4” axial, 230V 8 M0571 Guard, 4” axial fan
6
NOVEMBER 22, 2013 26 COS-6 & BCS-6
Loading...