Bissell 1546A Instruction manual

®

USER GUIDE

CORDLESS

POWERGLIDE

1538 SERIES

IMPORTANT SAFETY INSTRUCTIONS

READ ALL INSTRUCTIONS
BEFORE USING YOUR VACUUM.

When using an electrical appliance, basic precautions should be
observed, including the following:

WARNING

TO REDUCE THE RISK OF FIRE, ELECTRIC
SHOCK, OR INJURY:

» This appliance can be used by children

aged from 8 years and above and
persons with reduced physical, sensory
or mental capabilities or lack of
experience and knowledge if they have
been given supervision or instruction
concerning use of the appliance in a
safe way and understand the hazards
involved. Cleaning and user
maintenance shall not be made by
children without supervision.

» Children should be supervised to ensure

that they do not play with the appliance.

» If charger supply cable is damaged, it

must be replaced by the manufacturer,
its service agent, or similarly qualified
person in order to avoid a hazard.

» Keep hair, loose clothing, fingers, and

all parts of body away from openings
and moving parts of the appliance and
its accessories.

» Unplug from electrical socket when not charging.
» Do not allow to be used as a toy.
» Use only as described in this user guide.
» Use only BISSELL recommended attachments.
» Do not use with damaged cable or plug for charger.
» Do not immerse in water or liquid.
» If appliance is not working as it should, has been

dropped, damaged, left outdoors, or dropped into
water; do not attempt to operate it and return it

to a service center.
» Do not pull or carry charger by cable.
» Keep charger cable away from heated surfaces.

» Do not unplug charger by pulling on cable.
» To unplug charger, grasp the plug, not the cable.
» Do not handle charger plug or appliance with wet

hands.
» Do not put any object into openings.
» Do not use with any opening blocked; keep free of

dust, lint, hair, and anything that may reduce air flow.
» Use extra care when cleaning on stairs.
» Do not use to pick up flammable or combustible

liquids, such as petroleum, or use in areas where they

may be present.
» Do not pick up toxic material (chlorine bleach,

ammonia, drain cleaner, etc.)
» Do not use appliance in an enclosed space filled with

vapours given off by oil base paint, paint thinner, some

mothproofing substances, flammable dust, or other

explosive or toxic vapours.
» Do not pick up hard or sharp objects such as glass,

nails, screws, coins, etc.
» Use only on dry, indoor surfaces.
» Keep appliance on a level surface.
» Do not pick up anything that is burning or smoking,

such as cigarettes, matches, or hot ashes.
» Do not use without dust tank and/or filters in place.
» Do not use outdoors or on wet surfaces
» Do not leave machine running in the same spot without

handle fully upright.
» Turn off all controls before connecting or disconnecting

the TurboBrush® Tool or Pet TurboEraser® Tool.
» Only use the rechargeable Li-ion battery pack and

charging base supplied by BISSELL.
» If the appliance is to be stored unused for a long period,

the battery pack should be removed.
» Battery pack and charger base output terminals are not

to be short-circuited.
» The charger is only for charging the rechargeable

Li-ion battery pack supplied with cleaner. Disconnect

the supply before making or breaking the connections

to the battery; Warning: Explosive gases. Prevent

flames and sparks. Provide adequate ventilation

during charging.

SAVE THESE INSTRUCTIONS

FOR CHARGING ON A 220-240 VOLT A.C. 50/60 HZ POWER SUPPLY ONLY.

This model is for household use only. This user guide can also be available on BISSELL official website.

www.BISSELL.com

2

Th for buying a BISSELL vacuum

We’re glad you purchased a BISSELL
vacuum. Everything we know about
floor care went into the design and
construction of this complete,
high-tech home cleaning system.

Your BISSELL vacuum is well made,
and we back it with a limited
two-year guarantee. We also stand
behind it with a knowledgeable,
dedicated Consumer Care
department, so, should you ever
have a problem, you’ll receive fast,
considerate assistance.

My great-grandfather invented the
floor sweeper in 1876. Today, BISSELL
is a global leader in the design,
manufacture, and service of high
quality homecare products like your
BISSELL vacuum.

Thanks again, from all of us
at BISSELL.

Safety Instructions...........2

Product View ................4

Assembly ...................5

Operations ................6-7

Maintenance & Care .......8-9

Replacement Parts .........10

Troubleshooting .............11

Guarantee..................12

Service .....................12

Mark J. Bissell
Chairman & CEO

www.BISSELL.com

3

Product View

1

2

5

3

6

4

7

8

1 Handle
2 Extension Wand
3 Brush On/Off
4 Power Hi/Lo
5 Dirt Tank Release Button
6 Power Button
7 Pre-Motor Filter
8 Dirt Tank
9 Battery
10 Power Brush
11 Hose
12 2-in-1 Accessory
13 Hose Connector
14 Diverter Switch

11

12

13

14

www.BISSELL.com

4

9

10

Asmbly

Your vacuum comes in five easy-to-assemble
components:

Handle and Hose

Extension Tube
Battery
Base Unit
Foot
+
Charging Base

1. Insert the handle into the extension wand and

click into place.

2. Slide the extension wand into the base unit.

3. Insert the hose end into the hose connector

on the back of the base unit, making sure both
tabs click into place and the notch is aligned.

4. The 2-in-1 accessory can be stored in the
clip on the side of the unit.

5. Slide body of vacuum onto foot connector
until you hear a click.

6. Push the battery into the housing until
you feel it lock into place. Replace the battery
housing cover.

1. 2.

3. 4.

5. 6.

www.BISSELL.com

5

Operatis

PowerBrush switch

1. Press the button with brush bar icon to run
the PowerBrush.

2. The PowerBrush will not run when vacuum
is locked in upright position

3. If debris is keeping the vacuum from
operating, turn off power switch, remove
debris, and then turn power switch on to
resume vacuuming.

NOTE: Turn off the PowerBrush when
vacuuming hard surfaces, such as hard
wood or tiled floors, as well as when cleaning
smaller rugs that may be caught by the
rotating brush (see section Operate
PowerGlide® Cordless for additional details).

Power Mode switch

1. Press the button with the +/- icon to switch
between high and low power modes.

2. High power mode is useful for cleaning high
traffic areas.

WARNING

Before using your vacuum, make sure that the dirt
container is in locked position and that the filter is in
place. DO NOT operate your vacuum without the filter.

1.

2.

Tip

» Before cleaning under low furniture, check area

first for objects that might harm the unit or block
the vacuum hose.

www.BISSELL.com

6

Operatis

Above floor cleaning

1. Twist diverter switch to horizontal position
to direct suction to the vacuum hose.

2. Push down on the handle release button
and pull the handle and extension tube out
of the body.

3. The 2-in-1 accessory can be attached to the
end of the extension tube.

4. The extension wand can be removed by
pressing the release button and pulling it off.
The 2-in-1 accessory can also be attached to
the handle end.

5. The portable canister vacuum can be
released by pressing the button on the back
of the body and pulling away from the foot.

6. The canister vacuum can be carried around
for easy cleaning of hard to reach areas.

Charging the battery

1. Remove battery housing cover by pressing
release button and pulling away.

2. Remove battery by pulling out of machine.

3. Place battery in charging base, ensuring

it is plugged into the mains.

4. Charger light will turn red during charging
and turn green when battery is full.

5. A full charge will take 2 hours.

1.

3.

5.

1.

2.

4.

6.

2.

3. 4.

www.BISSELL.com

LED

7

Mainnce & Care

Emptying the dirt container

1. Press the dirt tank release button and pull dirt
tank away from body by the handle

2. Holding the Dirt Container over a trash bin,
press the Release Button on back. Snap the
bottom back into place.

Cleaning the dirt container

1. Release dirt tank as above, then twist
the top right to separate.

2. Remove filter by pulling up on the fabric
tab, then pull out the cyclone system.

3. Empty dirt container in trash bin. It may be
rinsed clean. Make sure it is completely dry
before replacing.

4. To reassemble, line cyclone system up with
dirt container using the semi circular and
square tabs then slide in. Place filter on top
with fabric tab on the upper face, place lid
last and twist left.

WARNING

To reduce the risk of electric shock, turn power switch o
and disconnect polarized plug from electrical outlet before
performing maintenance or troubleshooting checks.

1. 2.

1. 2.

3.

4.

Cleaning the filter and cyclone

1. Release tank and remove lid as above,
then remove Pre-motor Filter, clean with mild
detergent and rinse.

2. Reinsert inside Dirt Container, once
completely dried.

3. Remove cyclone system from dirt container
as above.

4. The cyclone system can be broken down
into three parts for easy cleaning. All pieces
come apart with a simple twist. Rinse and dry
with a paper towel.

» To maintain suction and good performance, it is

recommended that you clean your filters every

Tip

www.BISSELL.com

8

4-5 uses and clean your cyclone system every
other time you clean the filter.

WARNING

Do not operate cleaner with damp or wet filters or
without filters in place.

1.

3. 4.

2.

Mainnce & Care

Replacing the Brush

1. Turn power switch off, turn over and use a
coin or a flathead screwdriver to open the 2
locking screws on either side of the brush bar.

2. Remove both brush plates to access
brush bar.

3. Grasp the roller from the bottom, dislodge
by pulling, and then thread it through the belt.

4. Replace roller and reverse the order to
reassemble.

Disposal of batteries

If your vacuum is to be disposed of, the batteries
should be removed and disposed of properly.

1. Keep Battery Pack together – DO NOT
disassemble the battery pack. For specific
disposal instructions of batteries, please follow
local regulation.

1.

3. 4.

2.

www.BISSELL.com

9

Replacement Parts

These items are available for your BISSELL vacuum.
Call 1-800-237-7691 or visit www.BISSELL.com

PART # PART NAME PART # PART NAME

160-6691 Battery

160-6187 Battery Charger 160-6698 Extension Wand

160-7058 2-in-1 Accessory Tool 160-6359 Filter

160-6689 Brush Roll

160-6697 Hose and Handle

www.BISSELL.com

10

Trbleshting

Is your vacuum plugged in?
Are all hoses connected?

WARNING

To reduce the risk of electric shock, turn power switch o
and disconnect polarized plug from electrical outlet before
performing maintenance or troubleshooting checks.

Problem Possible causes Remedies

PowerBrush
doesn’t
rotate

The PowerBrush power switch
is turned off

Vacuum is locked in upright
position

Make sure PowerBrush switch is on

Recline vacuum and switch on the
PowerBrush

Vacuum
won’t pick
up dirt

Hose won’t
pick up dirt

Dirt is
escaping
from the
vacuum

There is a crack or hole in the
Main Hose

The Power Brush bristles are worn Replace the PowerBrush

There is a clog in the vacuum Remove debris and any other

The Dirt Container is not seated
correctly

Filter is dirty

Diverter is switched to hose

The Main Hose is not connected Locate the Main Hose and reconnect

The Dirt Container is full Empty the Dirt Container

Filters are missing Check to see if the pre-motor filter

The Dirt Container is not seated
properly

If there is a crack or hole, order a new
Main Hose from the BISSELL website

entanglements that may be
restricting its rotation

Press the Empty Button to release the
Dirt Container and reseat properly

Remove and rinse pre-motor filter.
Allow enough time for it to dry
properly before reinserting

Turn the diverter on the side of
the unit to vacuum to pick up from
the floor

by pushing the hose connection to
secure the latch

is in place

Press the Empty Button and remove the
Dirt Container. Insert the bottom first
and pivot the Dirt Container towards
the vacuum. Listen for a “click” sound,
indicating that it snapped into place

Please do not return this
product to the store.

www.BISSELL.com

11

Csumer Guare

This Guarantee only applies outside of the USA and Canada. It is
provided by BISSELL International Trading Company BV (“BISSELL”).

This Guarantee is provided by BISSELL. It gives you specific rights.
It is offered as an additional benefit to your rights under law. You
also have other rights under law which may vary from country
to country. You can find out about your legal rights and remedies
by contacting your local consumer advice service. Nothing in this
Guarantee will replace or lessen any of your legal rights or remedies.
If you need additional instruction regarding this Guarantee or have
questions regarding what it may cover, please contact BISSELL
Consumer Care or contact your local distributor.

This Guarantee is given to the original purchaser of the product from
new and is not transferable. You must be able to evidence the date
of purchase in order to claim under this Guarantee.

Limited Two-Year Guarantee

Subject to the *EXCEPTIONS AND EXCLUSIONS identified below,
BISSELL will for two years from the date of purchase by the
original purchaser repair or replace (with new or remanufactured
components or products), at BISSELL’s option, free of charge, any
defective or malfunctioning part or product.

BISSELL recommends that the original packaging and evidence
of the date of purchase be kept for the duration of the Guarantee
period in case the need arises within the period to claim on the
Guarantee. Keeping the original packaging will assist with any
necessary re-packaging and transportation but is not a condition of
the Guarantee.

If for your product is replaced by BISSELL under this Guarantee,
the new item will benefit from the remainder of the term of this
Guarantee (calculated from the date of the original purchase). The
period of this Guarantee shall not be extended whether or not
your product is repaired or replaced.

*EXCEPTIONS AND EXCLUSIONS FROM
THE TERMS OF THE GUARANTEE

This Guarantee applies to products used for personal domestic use and
not commercial or hire purposes. Consumable components such as
filters, belts and mop pads, which must be replaced or serviced by the
user from time to time, are not covered by this Guarantee.

This Guarantee does not apply to any defect arising from fair wear
and tear. Damage or malfunction caused by the user or any third
party whether as a result of accident, negligence, abuse, neglect, or
any other use not in accordance with the User Guide is not covered
by this Guarantee.

An unauthorised repair (or attempted repair) will void this Guarantee
whether or not damage has been caused by that repair/attempt.

Removing or tampering with the Product Rating Label on the
product or rendering it illegible will void this Guarantee.

SAVE AS SET OUT BELOW BISSELL AND ITS DISTRIBUTORS ARE NOT
LIABLE FOR ANY LOSS OR DAMAGE THAT IS NOT FORESEEABLE
OR FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES OF ANY
NATURE ASSOCIATED WITH THE USE OF THIS PRODUCT INCLUDING
WITHOUT LIMITATION LOSS OF PROFIT, LOSS OF BUSINESS, BUSINESS
INTERRUPTION, LOSS OF OPPORTUNITY, DISTRESS, INCONVENIENCE OR
DISAPPOINTMENT. SAVE AS SET OUT BELOW BISSELL’S LIABILITY WILL
NOT EXCEED THE PURCHASE PRICE OF THE PRODUCT.

BISSELL DOES NOT EXCLUDE OR LIMIT IN ANY WAY ITS LIABILITY FOR
(A) DEATH OR PERSONAL INJURY CAUSED BY OUR NEGLIGENCE OR THE
NEGLIGENCE OF OUR EMPLOYEES, AGENTS OR SUBCONTRACTORS; (B)
FRAUD OR FRAUDULENT MISREPRESENTATION; (C) OR FOR ANY OTHER
MATTER WHICH CANNOT BE EXCLUDED OR LIMITED UNDER LAW.

Csumer Care

If your BISSELL product should require
service or to claim under our Limited
Two-Year Guarantee, please visit:

Website or E-mail:

www.BISSELL.com

For UK inquiries:

Telephone: [phone]
Monday – Thursday 9am - 5pm
Friday 9am - 4pm
BISSELL Homecare (Overseas) Inc.
Ground Floor
226 Berwick Avenue
Slough, Berkshire, SL1 4QT
United Kingdom

Replacement parts and accessories are
available for purchase. To purchase visit
www.BISSELL.com

Visit the BISSELL website: www.BISSELL.com

When contacting BISSELL, have model number of cleaner available.
Please record your Model Number: _____________ Please record your Purchase Date: _____________

NOTE: Please keep your original sales receipt. It provides proof of the date
of purchase in the event of a Guarantee claim. See Guarantee for details.

©2015 BISSELL Homecare, Inc
Grand Rapids, Michigan
All rights reserved. Printed in China
Part Number 160-6184 Rev 07/15

12

Visit our website at: www.BISSELL.com