EAGLE
5 4 3 2 1
APPROACH SIDE
POWER 7
POWER 8
COM 6
N.O. 5
N.C. 4
INHIBIT GND 2
INHIBIT + 3
BLANK 1
POWER 8
POWER 7
SAFETY SIDE
COM 6
N.C. 4
N.O. 5
INHIBIT GND 2
INHIBIT + 3
BLANK 1
BODYGUARD
DK-12
DATA + 7
DATA - 6
N.C. 5
N.O. 4
COM 3
POWER 2
POWER 1
BROWN
ORANGE
RED/WHITE
WHITE
"B" CONTROL
LO21
WHITE
GREEN
RED
RED
BLACK
90 DEGREE LIMIT SWITCH
RESISTOR
SOLENOID WIRES TYPICALLY
RED OR BLACK
BLUE
MOTOR
* P1 COMMON
WHITE
CMN 6
7
5
24VAC
ISO RELAY
COIL
N/O
4
2
N/C
3
N/O
N/C WHITE*
1
8
COM.
24 V
TRANSFORMER
OPTION
N/C
MAGNETIC REED
SWITCH
115 VAC
NOTES: 1) OPTION SAFETY SIDE SUPERSCAN INHIBIT WITH MAGNETIC
REED SWITCH.
2) SWITCH MUST BE ADJUSTED TO OPEN AT APPROXIMATELY
70 DEGREES.
3) LO-21 RED AND BLACK WIRES CONNECT TO THE SOLENOID VALVE.
B.E.A., Inc.
100 Enterprise Drive, Pittsburgh, PA 15275
PH: (412) 249-4100 FAX: (412) 249-4101
TITLE: KM 2000 "B" CONTROL WITH EAGLE,
BODYGUARD, SUPERSCANS, INHIBIT
RELAY
SIZE:
A
SCALE:
CAGE CODE:
NONE
DWG NO:
80.0111
DATE:
FILE OF:
05 JAN 04
DRAWN BY:
ENG'G
SHEET:
JED
1 OF 1
REV:
01
IF USING DRY CONTACT SAFETY BEAM
CONNECT N.O. & COM. TO GRAY & PURPLE
24 V
TRANSFORMER
N.C. 5
EAGLE
N.O. 4
green
COM 3
white
POWER 2
black
POWER 1
red
BODYGUARD
RESPECTIVLEY
BROWN
WHITE
WHITE
GREEN
BROWN
+- +-
RED +
BLACK -
OPERATOR
F1
F2
J2
J10
J3
F3
J6
MICRO
W12
CONTROL
SW1
YELLOW
J1
J5
J9
DATA + 7
blue
DATA - 6
brown
N.C. 5
N.O. 4
green
COM 3
white
POWER 2
black
POWER 1
red
NOTES: 1) WIRE LO-21 RED / BLACK WIRES TO MICRO-SWITCH WHEN STACK OR LATCH ASSIST FUNCTIONS ARE TURNED
IF AFTER TROUBLESHOOTING A PROBLEM, A SATISFACTORY SOLUTION CANNOT BE ACHIEVED, PLEASE CALL B.E.A., INC.
FOR FURTHER ASSISTANCE DURING EASTERN STANDARD TIME AT 1-800-523-2462 FROM 8AM - 5PM. FOR AFTER-HOURS,
CALL EAST COAST: 1-866-836-1863 OR 1-800-407-4545 / MID-WEST: 1-888-308-8843 / WEST COAST: 1-888-419-2564. DO NOT
LEAVE ANY PROBLEM UNRESOLVED. IF YOU MUST WAIT FOR THE FOLLOWING WORKDAY TO CALL B.E.A., LEAVE THE
DOOR INOPERABLE UNTIL SATISFACTORY REPAIRS CAN BE MADE. NEVER SACRIFICE THE SAFE OPERATION OF THE
AUTOMATIC DOOR OR GATE FOR AN INCOMPLETE S OLUTION.WEB: WWW.BEASENSORS.COM
ON. (SEE NOTE 2)
2) AN ADDITIONAL MICROSWITCH WILL NEED INSTALLED ON OPERATOR ORIENTED 180 DEGREES FROM CLOSED
LATCH SPEED SWITCH. THIS WILL PROVIDE PROPER VOLTAGE TO THE LO21K. CONTACT B.E.A. TECHNICAL
SUPPORT FOR WIRING INFORMATION.
3) SW-1 SETTINGS (UP IS OFF) 1.PUSH-N-GO 2. LATCH ASSIST 3. RATCHET FUNCTION 4. STACK PRESSURE.
4) DUAL CONTROL SHOWN
5) SW-1 CALIBRATION SWITCH REMOVE JUMPER AFTER 1ST ACTIVATION AFTER INITIAL POWER UP. STORE ON 1 POST.
RED/WHITE
WHITE
RED
GREEN
LO-21K
LO21K DEFAULT DIP SWITCHES
FOR KM
BLACK -
OFF
ON
100 ENTERPRISE DRIVE
PITTSBURGH, PA 15275
PHONE: (412) 249-4100
FAX: (412) 249-4101
EMAIL: www.beasensors.com
TITLE: KM 3100 "K" CONTROL WITH
COMMANDER SYSTEM
DRAWN BY:
SIZE:
KJG TUC
A
SCALE: DATE:
NONE 23 NOV 2005
REV BY:
PART NO:
80.0134.01
SHEET
1 OF 1
24 V
TRANSFORMER
BODYGUARD
LEFT APPRCH SIDE SSCAN
SUPERSCAN QUICK
DISCONNECT CABLE
RIGHT APPRCH SIDE SSCAN
LEFT SAFETY SIDE SSCAN
SUPERSCAN QUICK
DISCONNECT CABLE
RIGHT SAFETY SIDE SSCAN
RED +
BLACK -
OPERATOR
HOLD OPEN
OFF
AUTO
N.C. 5
EAGLE
NOTES: 1 ) SW-1 SETTINGS (UP IS OFF) 1.PUSH-N-GO 2. LATCH ASSIST 3. RATCHET FUNCTION 4. STACK PRESSURE.
2 ) DUAL CONTROL SHOWN
3 ) SW-1 CALIBRATION SWITCH REMOVE JUMPER AFTER 1ST ACTIVATION AFTER INITIAL POWER UP. STORE ON 1 POST.
IF AFTER TROUBLESHOOTING A PROBLEM, A SATISFACTORY SOLUTION CANNOT BE ACHIEVED, PLEASE CALL B.E.A., INC. FOR FURTHER ASSISTANCE DURING EASTERN STANDARD TIME
AT 1-800-523-2462 FROM 8AM - 5PM. FOR AFTER-HOURS, CALL EAST COAST: 1-866-836-1863 OR 1-800-407-4545 / MID-WEST: 1-888-308-8843 / WEST COAST: 1-888-419-2564. DO NOT LEAVE
ANY PROBLEM UNRESOLVED. IF YOU MUST WAIT FOR THE FOLLOWING WORKDAY TO CALL B.E.A., LEAVE THE DOOR INOPERABLE UNTIL SATISFACTORY REPAIRS CAN BE MADE. NEVER
SACRIFIC E THE SAFE OPE RATION OF THE AUTOMATI C DOOR OR GATE FOR AN INCOMPLETE S OLUTION.WEB: WWW.BEASENSORS.COM
N.O. 4
green
COM 3
white
POWER 2
black
POWER 1
red
RED
GREEN
LO21K
OFF
ON
BLACK GREEN
BLUE
YELLOW
F1
F2
J2
J10
W12
J3
F3
J6
STALL
YELLOW
100 ENTERPRISE DRIVE
PITTSBURGH, PA 15275
PHONE: (412) 249-4100
FAX: (412) 249-4101
EMAIL: www.beasensors.com
CONTROL
MICRO
SW1
J1
J5
J9
TITLE: KM 3000/3100 (MICRO) K-CONTROL
LO21K, W/PARALLAX 2 SYSTEM
Q-DISCONNECT ON APPROACH SIDE
DRAWN BY:
SIZE:
KJG TUC
B
SCALE: DATE:
NONE 01 DEC 2005
REV BY:
PART NO:
SHEET
1 OF 1
80.0176.02
24 V
TRANSFORMER
BODYGUARD
RIGHT APPRCH SIDE SSCAN
LEFT SAFETY SIDE SSCAN
QUICK-DISCONNECT CABLE
HOLD OPEN
OFF
AUTO
N.C. 5
EAGLE
NOTES: 1 ) SW-1 SETTINGS (UP IS OFF) 1.PUSH-N-GO 2. LATCH ASSIST 3. RATCHET FUNCTION 4. STACK PRESSURE.
2 ) DUAL CONTROL SHOWN
3 ) SW-1 CALIBRATION SWITCH REMOVE JUMPER AFTER 1ST ACTIVATION AFTER INITIAL POWER UP. STORE ON 1 POST.
IF AFTER TROUBLESHOOTING A PROBLEM, A SATISFACTORY SOLUTION CANNOT BE ACHIEVED, PLEASE CALL B.E.A., INC. FOR FURTHER ASSISTANCE DURING EASTERN STANDARD TIME
AT 1-800-523-2462 FROM 8AM - 5PM. FOR AFTER-HOURS, CALL EAST COAST: 1-866-836-1863 OR 1-800-407-4545 / MID-WEST: 1-888-308-8843 / WEST COAST: 1-888-419-2564. DO NOT LEAVE
ANY PROBLEM UNRESOLVED. IF YOU MUST WAIT FOR THE FOLLOWING WORKDAY TO CALL B.E.A., LEAVE THE DOOR INOPERABLE UNTIL SATISFACTORY REPAIRS CAN BE MADE. NEVER
SACRIFIC E THE SAFE OPE RATION OF THE AUTOMATI C DOOR OR GATE FOR AN INCOMPLETE S OLUTION.WEB: WWW.BEASENSORS.COM
N.O. 4
green
COM 3
white
POWER 2
black
POWER 1
red
RED
GREEN
LO21K
OFF
ON
BLACK GREEN
BLUE
YELLOW
RED +
BLACK -
F1
F2
J2
J10
J3
J6
STALL
TITLE: KM 3000/3100 (MICRO) K-CONTROL
TITLE:
OPERATOR
J1
J5
MICRO
W12
CONTROL
F3
SW1
J9
YELLOW
100 ENTERPRISE DRIVE
PITTSBURGH, PA 15275
PHONE: (412) 249-4100
FAX: (412) 249-4101
EMAIL: www.beasensors.com
LO21K, W/PARALLAX 1 SYSTEM
Q-DISCONNECT ON APPROACH SIDE
DRAWN BY:
SIZE:
KJG TUC
B
SCALE: DATE:
NONE 01 DEC 2005
REV BY:
PART NO:
SHEET
1 OF 1
80.0177.02
TRANSFORMER
EAGLE
24 V
N.C. 5
N.O. 4
green
COM 3
white
POWER 2
black
POWER 1
red
BODYGUARD
APPROACH SUPERSCAN
QUICK DISCONNECT
CABLE
HOLD OPEN
OFF
AUTO
SAFTY SUPERSCAN
F1
F2
J2
J10
J3
F3
J6
MICRO
W12
CONTROL
SW1
J1
J5
J9
YELLOW
OFF
ON
RED
BLACK
+
MOTOR
-
LO21K
RED
GREEN
DIP SWITCHES
6, 7, 8, NOT USED
(NOT USED)
NOTES: 1) SW-1 SETTINGS (UP IS OFF) 1.PUSH-N-GO=(OFF). 2. LATCH ASSIST=(OFF). 3. RATCHET FUNCTION=(OFF).4. STACK
IF AFTER TROUBLESHOOTING A PROBLEM, A SATISFACTORY SOLUTION CANNOT BE ACHIEVED, PLEASE CALL B.E.A., INC.
FOR FURTHER ASSISTANCE DURING EASTERN STANDARD TIME AT 1-800-523-2462 FROM 8AM - 5PM. FOR AFTER-HOURS,
CALL EAST COAST: 1-866-836-1863 OR 1-800-407-4545 / MID-WEST: 1-888-308-8843 / WEST COAST: 1-888-419-2564. DO NOT
LEAVE ANY PROBLEM UNRESOLVED. IF YOU MUST WAIT FOR THE FOLLOWING WORKDAY TO CALL B.E.A., LEAVE THE
DOOR INOPERABLE UNTIL SATISFACTORY REPAIRS CAN BE MADE. NEVER SACRIFICE THE SAFE OPERATION OF THE
AUTOMATIC DOOR OR GATE FOR AN INCOMPLETE S OLUTION.WEB: WWW.BEASENSORS.COM
PRESSURE=(OFF).
2) LO21K: DIP SWITCHES 6, 7, 8, NOT USED.
3) SW-1 CALIBRATION SWITCH (LOCATED ON CONTROL) REMOVE JUMPER AFTER 1ST ACTIVATION AFTER INITIAL
POWER UP. STORE ON 1 POST.
100 ENTERPRISE DRIVE
PITTSBURGH, PA 15275
PHONE: (412) 249-4100
FAX: (412) 249-4101
EMAIL: www.beasensors.com
TITLE: KM 3000/3100 (MICRO) K-CONTROL
LO21K, W/PARALLAX 1 SYSTEM
Q-Disconnect on Safety Side
DRAWN BY:
SIZE:
TUC TUC
A
SCALE: DATE:
NONE 18 OCT 2005
REV BY:
PART NO:
80.0210.01
SHEET
1 OF 1
TRANSFORMER
EAGLE
24 V
N.C. 5
N.O. 4
green
COM 3
white
POWER 2
black
POWER 1
red
BODYGUARD
APPROACH SUPERSCAN
QUICK DISCONNECT
CABLE
HOLD OPEN
OFF
AUTO
SAFTY SUPERSCAN
F1
F2
J2
J10
J3
F3
J6
MICRO
W12
CONTROL
SW1
J1
J5
J9
YELLOW
OFF
ON
RED
BLACK
+
MOTOR
-
LO21K
RED
GREEN
DIP SWITCHES
6, 7, 8, NOT USED
(NOT USED)
NOTES: 1) SW-1 SETTINGS (UP IS OFF) 1.PUSH-N-GO(OFF). 2. LATCH ASSIST(OFF). 3. RATCHET FUNCTION(OFF). 4. STACK
IF AFTER TROUBLESHOOTING A PROBLEM, A SATISFACTORY SOLUTION CANNOT BE ACHIEVED, PLEASE CALL B.E.A., INC.
FOR FURTHER ASSISTANCE DURING EASTERN STANDARD TIME AT 1-800-523-2462 FROM 8AM - 5PM. FOR AFTER-HOURS,
CALL EAST COAST: 1-866-836-1863 OR 1-800-407-4545 / MID-WEST: 1-888-308-8843 / WEST COAST: 1-888-419-2564. DO NOT
LEAVE ANY PROBLEM UNRESOLVED. IF YOU MUST WAIT FOR THE FOLLOWING WORKDAY TO CALL B.E.A., LEAVE THE
DOOR INOPERABLE UNTIL SATISFACTORY REPAIRS CAN BE MADE. NEVER SACRIFICE THE SAFE OPERATION OF THE
AUTOMATIC DOOR OR GATE FOR AN INCOMPLETE S OLUTION.WEB: WWW.BEASENSORS.COM
PRESSURE(OFF).
2) LO21K: DIP SWITCHES 6, 7, 8, NOT USED.
3) SW-1 CALIBRATION SWITCH REMOVE JUMPER ON CONTROL AFTER 1ST ACTIVATION AFTER INITIAL POWER
UP. STORE ON 1 POST.
100 ENTERPRISE DRIVE
PITTSBURGH, PA 15275
PHONE: (412) 249-4100
FAX: (412) 249-4101
EMAIL: www.beasensors.com
TITLE: KM 3000/3100 (MICRO) K-CONTROL
LO21K, W/PARALLAX 1 SYSTEM
Q-Disconnect on Approach Side
DRAWN BY:
SIZE:
TUC TUC
A
SCALE: DATE:
NONE 18 OCT 2005
REV BY:
PART NO:
80.0211.01
SHEET
1 OF 1
LO-LINX GRE E N WH ITEYELLOWBLUE BROWN
SWING ACT.COM.SAF.STALLSTAL COM.
B ESA M 3 00 13 12 11 15, 17 16,18
BESAM M/ P 3 4 9 5 13
DOM YELLOW GREY BLUE PURPLE GREY
GT 300/400 BLACK RED WHITE WHITE RED
GT M AG 6 BLACK 5 RED 4 WHITE 3 VIOLET 5 RED
HORTON 41 90 2 3, 6, 8 4 1 0 3, 6, 8
HUNTE R ACT. RTN SAF. 1 SAF. 2 RTN
KM K GREEN WHITE RED YELLOW WHITE
STANLEY "L" ORANGE YELLOW RED BLUE YELLOW
STANLEY M/P 2 1, 8 7 7 1, 8
STANLEY 521 TB4-5 TB4-4 TB4-8 TB4-1 0 TB4-9
TORM AX TDA 2 1 ,3, 6, 8 8 & 9 7 1, 3, 6, 8
DC
MOTOR
SEE NOTE #1
+
-
LO-LINX MOTOR HARNESS p/n: 20.5076
RED
RED
EAGLE 1
RED
GREEN
WHITE
BLACK
MTR
75.5137.02
STALL
MOTOR
STALL 1
LO-LINX
SENSORS
STALL 2
EAGLE 1
EAGLE 2
DOOR MTD
AUX
BEAM
SWITCH
N/O
TX RX
COM
BODY-
GUARD
SENSOR 1
SENSOR 2
DOOR MTD
TO CTRL
GND
AUTO
HOLD
STALL
ACTIV.
SAFETY
SFTY / ACT COM
SETUP
PWR
12-24V
AC/DC
INCR.
STALL COM
FUNCT.
BLACK
RED
24 V
TRANSFORMER
Pre-wired
switch
assembly
AUTO
RED
BLACK
WHITE
HOLD OPEN
KM K CONTROL
C
O
T
E
/
H
I
W
M
OFF
SEE NOTE
#2
SEE NOTE # 4
N/O
SEE NOTE #3
LO-LINX BODYGUARD
HARNESS p/n: 20.5082
*
BODYGUARD (Y) HARNESS
USED FOR DUAL-EGRESS
APPLICATIONS
COM
LO-LINX POWER
HARNESS p/n: 20.5095
LO-LINX SWITCH HARNESS p/n: 20.5078
LO-LINX CONTROL
HARNESS p/n: 20.5097
BROWN
SEE NOTE # 4
WHITE
LO-LINX EAGLE HARNESS p/n: 20.5096
EAGLE 2
BLUE
BROWN
RED
RED
WHITE
BLACK
GREEN
SEE NOTE # 4
1
Y
T
P
M
E
4
3
2
D
N
G
+
T
T
I
I
B
B
I
I
.
H
H
C
.
N
N
I
I
N
DOOR MTD SENSOR
APPROACH SIDE
GREEN
5
.
O
.
N
RED
WHITE
BLACK
7
8
6
R
R
E
E
M
W
W
O
O
O
C
P
P
1
3
2
D
N
+
G
T
T
Y
I
I
T
B
B
I
I
P
H
H
M
N
N
E
I
I
DOOR MTD SENSOR
SAFETY SIDE
WHITE
BLACK
GREEN
7
5
6
4
.
C
.
N
R
E
.
M
W
O
.
O
O
N
C
P
LO-LINX SUPERSCAN HARNESS
p/n: 70.5071
RED
8
R
E
W
O
P
NOTES:
1. MOTOR CONNECTION IS TIED IN PARALLEL TO EXISTING MOTOR LEADS. NO RESPECT TO PALARITY IS REQUIRED.
2. EXTERNAL SWITCHES ARE REQUIRED IF INHIBIT DESIRED AT SWING SIDE SUPERSCANS, SWITCH OPENS UPON INHIBIT POINT.
3. THE KNOWING ACT SWITCH IS CONNECTED AT THE AUX INPUT AND CAN BE ANY DRY CONTACT DEVICE SUCH AS A PUSHPLATE, CARD READER,
ETC. THE AUX INPUT IS REQUIRED FOR ALL INITIAL ACTIVATION WHEN FUNCTION 'FA' ON THE LO-LINX IS SET TO '01'.
4. THE SECOND BODYGUARD AND EAGLE ARE PRIMARILY USED IN DUAL-EGRESS APPLICATIONS. ENSURE BODYGUARD RELAY VALUE IS SET TO 2.
IF AFTER TROUBLESHOOTING A PROBLEM, A SATISFACTORY SOLUTION CANNOT BE ACHIEVED, PLEASE CALL B.E.A., INC. FOR FURTHER ASSISTANCE
DURING EASTERN STANDARD TIME AT 1-800-523-2462 FROM 8AM - 5PM. FOR AFTER-HOURS, CALL EAST COAST: 1-866-836-1863 OR 1-800-407-4545 /
MID-WEST: 1-888-308-8843 / WEST COAST: 1-888-419-2564. DO NOT LEAVE ANY PROBLEM UNRESOLVED. IF YOU MUST WAIT FOR THE FOLLOWING
WORKDAY TO CALL B.E.A., LEAVE THE DOOR INOPERABLE UNTIL SATISFACTORY REPAIRS CAN BE MADE. NEVER SACRIFICE THE SAFE OPERATION
OF THE AUTOMATIC DOOR OR GATE FOR AN INCOMPLETE SOLUTION.WEB: WWW.BEASENSORS.COM
GREEN
WHITE
BLACK
1
2
D
N
G
T
Y
I
T
B
I
P
H
M
N
E
I
DOOR MTD SENSOR
APPROACH SIDE
RED
GREEN
5
4
3
+
T
I
B
.
I
.
H
C
O
.
.
N
I
N
N
GREEN
BLACK
WHITE
RED
WHITE
BLACK
7
8
6
R
R
E
E
M
W
W
O
O
O
C
P
P
BLUE
BROWN
1
2
D
N
G
T
Y
I
T
B
I
P
H
M
N
E
I
YELLOW
GREEN
5
4
3
+
T
I
B
.
I
.
H
C
O
.
.
N
I
N
N
DOOR MTD SENSOR
SAFETY SIDE
100 ENTERPRISE DRIVE
PITTSBURGH, PA 15275
PHONE: (412) 249-4100
FAX: (412) 249-4101
EMAIL: www.beasensors.com
TITLE: KM "K" CONTROL
LO-LINX SYSTEM
SIZE:
A
DRAWN BY:
JED TUC
SCALE:
NONE
REV BY:
DATE:
10/15/2007
BLUE
GREEN
WHITE
6
M
O
C
YELLOW/STALL
G
RED
BLACK
7
8
R
R
E
E
W
W
O
O
P
P
PART NO:
SHEET
1 OF 1
R
S
E
A
D
F
/
R
E
A
E
C
N
/
80.0286.00
T
Loading...