Bakers pride At-express User Manual

HORIZONTAL CONVEYOR TOASTERS

BUILT BY CRAFTSMEN. TESTED BY TIME

®

.

HORIZONTAL CONVEYOR TOASTER OPERATION MANUAL

HORIZONTAL CONVEYOR TOASTERS

Models:
AT-EXPRESS

WARNING

FOR YOUR SAFETY: Do not store or use gasoline
or other flammable vapors or liquids in the vicinity
of this or any other appliance.

NOTICE

Initial heating of appliance may generate smoke
or fumes and must be done in a well ventilated
area. Overexposure to smoke or fumes may cause
nausea or dizziness.

WARNING

California Residents Only

WARNING: This product can expose you to
chemicals including chromium which is known to
the State of California to cause cancer and birth
defects or other reproductive harm. For more
information go to www.P65Warnings.ca.gov.

CAUTION

Improper installation, adjustment, alteration,
service or maintenance can cause property
damage, injury or death. Read the installation,
operating and maintenance instructions
thoroughly before installing or servicing this
equipment.

Bakers Pride Oven Company, LLC is a wholly owned
subsidiary of Standex International Corporation.

Please retain this manual for future references.

This equipment is design engineered for commercial
use only.

BAKERS PRIDE OVEN COMPANY, LLC.

1307 N. Watters Rd., Suite 180

Allen, TX 75013

[phone] Phone | [phone] Fax | www.bakerspride.com Web address

P/N 882219 09/18

TABLE OF CONTENTS

HORIZONTAL CONVEYOR TOASTER OPERATION MANUAL

ITEM PAGE

SAFETY PRECAUTIONS 1

IMPORTANT SAFETY INSTRUCTIONS 2

GENERAL INFORMATION 3

INSTALLATION INSTRUCTIONS 4

SPECIFICATIONS 5

OPERATION INSTRUCTIONS 6

CLEANING INSTRUCTIONS 6

SAFETY PRECAUTIONS

Before installing and operating this equipment be
sure everyone involved in its operation is fully trained
and is aware of all precautions. Accidents & problems
can result by a failure to follow fundamental rules and
precautions.

The following words and symbols, found in this manual,
alert you to hazards to the operator, service personnel or
the equipment. The words are defined as follows:

ITEM PAGE

WARRANTY PROCEDURE 7

TROUBLESHOOTING 7

EPLODED VIEW AND PARTS LIST 8

WIRING DIAGRAM 9

WARRANTY 19

CAUTION

This symbol refers to a potential hazard or unsafe
practice, which may result in or moderate injury
or product or property damage

NOTICE

DANGER

This symbol warns of imminent hazard which will
result in serious injury or death.

WARNING

This symbol refers to a potential hazard or unsafe
practice, which could result in serious injury or
death.

This symbol refers to information that needs
special attention or must be fully understood even
though not dangerous.

1

HORIZONTAL CONVEYOR TOASTER OPERATION MANUAL

IMPORTANT SAFETY INSTRUCTIONS

CAUTION

Read the following important safety instructions
to avoid personal injury or death, and to avoid
damage to the equipment or property.

WARNING

Do not allow untrained personnel to operate the
toaster.

NOTICE

Do not use toppings (butter, etc.) on product as
product is inverted during normal operation.

WARNING

To avoid any injury, turn the power switch off
at the fuse disconnect switch/circuit breaker
or unplug the unit from the power source and
allow to cool completely before performing any

maintenance or cleaning.

WARNING

Bakers Pride® toasters are designed, built, and
sold for commercial use. If positioned where the
general public can use them, make sure that all
cautions, warnings, and operating instructions
are clearly posted near each unit to insure proper
operation, reduce the chance of personal injury
and/or equipment damage.

WARNING

Plug unit into a properly grounded electrical outlet
of the correct voltage, size and plug configuration.
If the plug and receptacle do not match, contact a
qualified electrician to determine the proper voltage
and size and install the proper electrical outlet.

WARNING

To avoid electrical shock, always unplug the unit
before performing cleaning or maintenance.

WARNING

WARNING

An earthing cable must connect the appliance to
all other units in the complete installation and

from there to an independent earth connection.

WARNING

Operating toaster without legs invalidates any
warranty claims.

WARNING

Operating the toaster without the Reflector Tray
reduces the toasting capabilities.

WARNING

Neglecting to keep fan opening clean could result
in toaster failure.

For safe and proper operation, the unit must be
located a reasonable distance from combustible walls
and materials. If safe distances are not maintained,
discoloration or combustion could occur.

WARNING

In Europe, appliance must be connected by an
earthing cable to all other units in the complete
installation and thence to an independent earth
connection in compliance with EN 60335-1 and/

or local codes.

WARNING

To avoid electrical shock or personal injury, do not
steam clean or use excessive water on the unit.

2

HORIZONTAL CONVEYOR TOASTER OPERATION MANUAL

IMPORTANT SAFETY INSTRUCTIONS

WARNING

If service is required on this unit, contact your
authorized Bakers Pride Service Agent, or contact
the Bakers Pride Service Department directly at
[phone] or [phone]; fax (214)

565-0976.

WARNING

This product has no “user” serviceable parts. To
avoid damage to the unit or injury to personnel,
use only Authorized Bakers Pride Service Agents
and genuine Bakers Pride Parts when service is

required.

CAUTION

Use only non-abrasive cleaners. Abrasive cleaners
could scratch the finish of your unit, marring its
appearance and making it susceptible to dirt
accumulation.

WARNING

Genuine Bakers Pride Replacement Parts are
specified to operate safely in the environments in
which they are used. Some aftermarket or generic
replacement parts do not have the characteristics
that will allow them to operate safely in
Bakers Pride® cooking equipment. It is essential
to use Bakers Pride Replacement Parts when
repairing Bakers Pride® equipment. Failure to
use Bakers Pride Replacement Parts may subject
operators of the equipment to hazardous electrical
voltage, resulting in electrical shock or burn.

CAUTION

Locate the unit at the proper counter height, in
an area that is convenient for use. The location
should be level to prevent the unit or its contents
from accidentally falling, and strong enough to
support the weight of the unit and food.

WARNING

CAUTION

Some exterior surfaces on the unit will get hot.
Use caution when touching these areas to avoid

injury.

GENERAL INFORMATION

1. Consult the rating label for model and serial
number. Write this information below before
proceeding: A. Model # __________________
B. Serial # __________________

2. Overall Dimensions w/Wire Feeder - 13.27” H
(33.70cm) x 14.72” W (37.39 cm) x 17.99”D
(45.69cm)

3. Product Opening - 1.5” H (3.8cm) x 10.50” W
(26.7cm)

4. Productivity (per hour) - results will vary depending
on line voltage and bread dryness.

Failure to provide clearances will cause unit
failure and invalidate warranty claims (see
installation instructions).

5. Electrical Requirements

A. Single phase, 120 volts, 1800 watts, 15 amps.

B. Cordset configuration

1. Each toaster is equipped with a three-wire
grounded cordset and standard three-prong
plug.

2. In the United States, a four foot cordset with
NEMA5-15P plug.

3. In Canada, a six foot cordset with NEMA5­20P plug.

Net/Shipping Weight - 28Ib.(12.7kg) /33Ib.(14.97kg)

3