Avaya Expansion Card in the Passport 5430 User Manual

Part No. 306623-A Rev 00
January 2000

4401 Great America Parkway
Santa Clara, CA 95054

Installing an Expansion Card in the Passport 5430 Multiservice Access Switch

Copyright © 2000 Nortel Networks.

All rights reserved. Printed in the USA. January 2000.
The information in this document is subject to change without notice. The statements, configurations, technical data,

and recommendations in this document are believed to be accurate and reliable, but are presented with out express or
implied warranty. Users must take full responsibility for their applications of any products specified in this document.
The information in this document is proprietary to Nortel Networks NA Inc.

Trademarks

NORTEL NETWORKS is a trademark of Nortel Networks.
BayRS and BCC are trademarks of Nortel Networks.
All other trademarks and registered trademarks are the property of their respective owners.

Statement of Conditions

In the interest of improv in g internal design, operatio nal function, and/or relia bi lity, Norte l Ne two rks NA In c. reserve s
the right to make changes to the products described in this document without notice.

Nortel Networks NA Inc. does not assume any liability that may occur due to the use or application of the product(s)
or circuit layout(s) described herein.

USA Requirements Only

Federal Communications Commission (FCC) Compliance Notice: Radio Frequency Notice

Note: This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to
Part 15 of the FCC rules. These limits are designed to provide reasonable protection against harmful interference
when the equipment is operated in a commercial environment. This equipment generates, uses, and can radiate radio
frequency energy. If it is not installed and used in accordance with the instruction manual, it may cause harmful
interference to radio communications. Operation of this equipment in a residential area is likely to cause harmful
interference, in which case users will b e required to take whatever measures may be necessary to correct the
interference at their own expense.

European Requirements Only

EN 55 022 Statement

This is to certify that the Nortel Networks Passport 5430 Multiservice Access Switch is shielded against the
generation of radio interference in accordance with the application of Council Directive 89/336/EEC, Article 4a.
Conformity is declared by the application of EN 55 022 Class A (CISPR 22).

Warning: This is a Class A product. In a domestic environment, this product may cause radio interferen ce, in whic h
case, the user may be required to take appropriate measures.

Achtung: Dieses ist ein Gerät der Funkstörgrenzwertklasse A. In Wohnbereichen können bei Betrieb dieses Gerätes
Rundfunkstörungen auftreten, in welchen Fällen der Benutzer für entsprechende Gegenmaßnahmen verantwortlich
ist.

Attention: Ceci est un produit de Classe A. Dans un environnement domesti que, ce produit risque de créer des
interférences radioélectriques, il appartiendra alors à l’utilisateur de prendre les mesures spécifiques appropriées.

T o maintai n complia nce with FCC radio fre quency em ission limit s, shield ed cables a re requ ired to conne ct equip ment
to other Class A certified devices and the use of quadshield, RG-6/U type CATV cable is required for connection to
the CATV system. Any changes or modifica tion s may void the user’s authorization to operate this equi pm e nt.

ii

306623-A Rev 00

EC Declaration of Conformity

This product conforms (or these products conform) to the provisions of Council Directive 89/336/EEC and
73/23/EEC. The Declaration of Conformity is available on the Nortel Networks World Wide Web site at
http://libra2.corpwest.baynetworks.com/cgi-bin/ndCGI.exe/DocView/.

Japan/Nippon Requirements Only

Voluntary Control Council for Interference (VCCI) Statement

Taiwan Requirements

Bureau of Standards, Metrology and Inspection (BSMI) Statement

Canada Requirements Only

Canadian Department of Communications Radio Interference Regulations

This digital apparatus (Passport 5430 Multiservice Access Switch) does not exceed the Class A limits for radio-noise
emissions from digital apparatus as set out in the Radio Interference Regulations of the Canadian Department of
Communications.

Règlement sur le brouillage radioélectrique du ministère des Communications

Cet appareil numérique (Passport 5430 Multiservice Access Switch) respecte les limites de bruits radioélectriques
visant les appareils numériques de classe A prescrites dans le Règlement sur le brouillage radioélectrique du ministère
des Communications du Canada.

Canada CS-03 Rules and Regulations

Notice: The Industry Canada label identifies certified equipment. This certification means that the equipment meets
telecommunications network protective, operational and safety requirements as prescribed in the appropriate T erminal
Equipment Technical Requirements document(s). The Dep artment does not guarantee the equipment will operate to
the user’s satisfaction.

Before installing this equipment, u sers sh ould e n sure that it is pe rmissib le t o be co nn ected to the facilities of the local
telecommunications company. The equipment must also be installed using an acceptable method of connection. The
customer should be aware th at compliance with the above conditions may not prevent the degradation of service in
some situations.

306623-A Rev 00

iii

Canada Requirements Only

Repairs to certified equipment shoul d be coordinated by a representative designated by the supplier. Any repairs or
alterations made by the user to this equipment, or equipment malfunctions, may give the telecommunications
company cause to request the user to disconnect the equipment.

Users should ensure for their own prot ection tha t the electrical g round conn ections of the po wer utility, telephon e lines
and internal metallic water pipe system, if present, are connected together. This precaution may be particularly
important in rural areas.

Caution: Users should not attempt to make such connections themselves, but should contact the appropriate electric
inspection authority, or electrician, as appropriate.

Notice: For equipment using loopstart lines, please note that the Ringer Equivalence Number (REN) assigned to each
terminal device provides an indication of the maximum number of terminals allowed to be connected to a tele phone
interface. The termination on an interface may consist of any combination of devices subject only to the requirement
that the sum of the Ringer Equivalence Numbers of all the devices does not exceed 5. The REN is located on the
“FCC Rules Part 68” label located on the bracket of the module, or on the back of the unit.

Canada CS-03 -- Règles et règlements

Avis: L'étiquette d'Industrie Canada identifie le matériel homologué. Cette étiquette certifie que le matériel est
conforme aux normes de protection, d'exploitation et de sécuri té des réseaux de télécommunica tions, comme le
prescrivent les documents concernant les exigences techniqu es relatives au matériel terminal. Le Ministère n'assure
toutefois pas que le matériel fonctionnera à la satisfaction de l'utilisateur.

Avant d'installer ce matériel, l'utilisateur doit s'assurer qu'il est permis de le raccorder aux installations de l'entreprise
locale de télécommunication. Le matériel doit également être installé en suivant une méthode acceptée de
raccordement. L'abonné ne doi t pas oublier qu'il est possible que l a conformité aux conditions énoncées ci-dessus
n'empêche pas la dégradati on du service dans certaines situation s.

Les réparations de matériel homologué doivent être coordonnées par un représentant désigné par l e fournisseur.
L'entreprise de télécomm unication s pe ut d emande r à l' utilisat eur de débra ncher u n app areil à la su ite de rép arations o u
de modifications effectuées par l'utilisateur ou à cause de mauvais fonctionnement.

Pour sa propre protect ion, l'utili sateur doi t s'assure r que tous l es fils de mise à la terre de l a sourc e d'énergie électrique,
des lignes téléphoniques et des canalisations d'eau métalliques, s'il y en a, sont raccordés ensemble. Cette précaution
est particulièrement importante dans les régions rurales.

Avertissement: L'utilisateur ne doit pas tenter de faire ces raccordements lui-même; il doit avoir recours à un servic e
d'inspection des installati ons électriques, ou à un électricien, selon le cas.

Avis: Veuille z pren dre n ote que pour tou t ap pareilla ge suppo rtant des l ign es d e typ e “lo ops tart,” l' indic e d 'équiv alenc e
de la sonnerie (IES) assigné à chaque disposi tif terminal indique le nombre maximal de te rminaux qui peuvent êt re
raccordés à une interface. La terminaison d'une interface téléphonique peut consister en une combinaison de quelques
dispositifs, à la seule condition que la somme d'indices d'équivalence de la sonnerie de tous les dispositifs n'excède
pas 5. Le REN figure sur l’étiquette “FCC Rules Part 68” située sur le support du module ou à l’arrière de l’unité.

(continued)

iv

306623-A Rev 00

FCC Part 68 Compliance Statement

This equipment complies with Part 68 o f FCC Rul es. All direc t con nectio ns to tel ephon e ne twork lin es must b e made
using standard plugs and jacks compliant with FCC Part 68. Please note the following:

1. You are required to request service from the telephone company before you connect the unit to a network. When
you request service, you must provide the telephone company with the following data:

• When you request T1 Service , yo u must pr ov ide the tele p ho ne co mpa ny with

-- The Facility Interface Code
Provide the telephon e company with all the codes below:

- 04DU9-BN (1.544 MB, D4 framing format)

- 04DU9-DN (1.544 MB, D4 framing format with B8ZF coding)

- 04DU9-1KN (1.544 MB, ESF framing format)

- 04DU9-1SN (1.544 MB, ESF framing format with B8ZF coding)

- 04DU9-1ZN (1.544 MB, ANSI ESF and ZBTSI without line power)
The telephone company will select the code it has available.

-- The Service Order Code(s) (SOC): 6.0Y

-- The req uired Universal Service Order Code (USOC) jack: RJ48C

• When you request ISDN “U” Interface Service, you must provide the telepho ne company with

-- The Facility Interface Code: 02IS5

-- The Service Order Code(s) (SOC): 6.0F

-- The req uired Universal Service Order Code (USOC) jack: RJ49C

• When you request ISDN “S/T” Interface Service, you must provide the telephone company with

-- The Service Order Code(s) (SOC): 6.0P

-- The ma ke, model number, and FCC Registration number of the NT1

Note: ISDN S/T cannot be directl y connected to the network.

• When you request Primary Rate ISDN Service, you must provide the telephone company with

-- The Facility Interface Code: 04DU9-1SN (1.544 MB, ESF framing format with B8ZF coding)

-- The Service Order Code(s) (SOC): 6.0Y

-- The req uired Universal Service Order Code (USOC) jack: RJ48C

2. Your telephone company may make changes to its facilities, equipment, operations, or procedures that could
affect the proper functioning of your equipment. The telephone company will notify you in advance of such
changes to give you an opportunity to maintain uninterrupted telephone service.

3. If the unit causes harm to the telephone network, the telephone company may temporarily discontinue your
service. If possible, they will notify you in advance, but if advance notice is not practical, you will be notified
as soon as possible and will be informed of your right to file a complaint with the FCC.

4. If you experience trouble with the unit, please contact the Nortel Networks Technical Solutions Center in
your area for service or rep a irs. Repairs should be per formed only by service personnel authorized by
Nortel Networks.

United States 1-800-2LANWAN
Valbonne, France 33-4-92-96-69-68
Sydney, Australia 61-2-9927 -8800
Tokyo, Japan 81-3-5402-01 80

306623-A Rev 00

v

5. You are required to notif y the telephone comp any when you disconnect the unit from the network.

Nortel Networks NA Inc. Software License Agreement

NOTICE: Please carefully read this license agreement before copying or using the accompanying software or
installing the hardware un it with pre-enabled software (each of whic h is re fe rred to as “So ftwa re” i n th is Ag reeme nt ).
BY COPYING OR USING THE SOFTWARE, YOU ACCEPT ALL OF THE TERMS AND CONDITIONS OF
THIS LICENSE AGREEMENT. THE TERMS EXPRESSED IN THIS AGREEMENT ARE THE ONLY TERMS
UNDER WHICH NORTEL NETWORKS WILL PERMIT YOU TO USE THE SOFTWARE. If you do not accept
these terms and conditions, return the pr oduct, unused and in the original shipping container, within 30 days of
purchase to obtain a credit for the full purchase price.

1. License Grant. Nortel Networks NA Inc. (“Nortel Networks”) grants the end user of the Software (“Licensee” ) a

personal, nonexclusive, n ontransfera ble lice nse: a) to use the So ftware eith er on a singl e compute r or, if applicable, on
a single authorized device identified by host ID, for which it was originally acquired; b) to copy the Software solely
for backup purposes in support of aut horized use of the Software; and c) to use and copy the associated user manual
solely in support of auth orized use of th e So ftware by Lic ensee. This lic ense ap plies to th e Softwa re only and do es no t
extend to Nortel Networ ks Agent software or other Nor tel Networks software products. Nortel Networks A gent
software or other Nortel Networks software products are licensed for use under the terms of the applicable Nortel
Networks NA Inc. Software License Agreement that accompanies such software and upon payment by the end user of
the applicable license fees for such software.

2. Restrictions on use; reservation of rights. The Software and user manuals are prot ected under copyright laws.

Nortel Networks and/or its licensors retain all title and ownership in both the Software and user manuals, including
any revisions made by Nortel Networks or its l icensors. The copyrig ht notice must be reproduced and included with
any copy of any portion of the Software or user manuals. Licensee may not modify, translate, decompile, disassemble,
use for any competitive analysis, reverse engineer, distribute, or create derivative works from the Software or user
manuals or any copy, in whole or in part. Except as expressly provided in this Agreement, License e may not copy or
transfer the Software or user manuals, in whole or in par t. The Software and user manual s embody Nortel Networks’
and its licensors’ con fide ntia l a n d pro pr ietary inte ll ectu al p rop e rty. Licensee shall not sublicense, assign, or otherwise
disclose to any third party the Software, or any information about the operatio n, design, performan ce, or
implementation of the Software and user manuals that is confidential to Nortel Networks and its licensors; however,
Licensee may grant permission to its consultan ts, subcon tractors, and agents to use th e Software at Licensee’s facility,
provided they have agreed to use the Software only in accordance with the term s of this license.

3. Limited warranty. Nortel Networks warrants each item of Software, as delivered by Nortel Networks and properly

installed and operated on Nortel Networks hardware or other equipment it is originally licensed for, to function
substantially as described i n i ts accompanying user manual during i ts warranty period, which begins on the date
Software is first shipped to Licensee. If any item of Software fail s to so fu nction during its warranty perio d, as the sole
remedy Nortel Networks will at its discretion provide a suitable fix, patch, or workaround for the problem that may be
included in a future Software release. Nortel Networks further warrants to Licensee that the media on which the
Software is provided will be free from defects in materials and workmanship under normal use for a period of 90 days
from the date Software is first shipped to Licensee. Nortel Networks will replace defective media at no charge if it is
returned to Nortel Netw orks during the warranty period along with proof of the date of shi pment. This warran ty does
not apply if the media has been damaged as a result of accident, misuse, or abuse. The Licensee assumes all
responsibility for selection of the Software to achieve Licensee’s intended results and for the installation, use, and
results obtained from the Software. Nortel Networks does not warrant a) that the functions contained in the software
will meet t he L ic ens ee’s requirements, b ) t hat the So ftw are w il l op er at e in t he h a rdwa re or s of twar e c omb in ati on s tha t
the Licensee may select, c) that the operati on of the Software will be uninterrupted or error free, or d) that al l d efect s
in the operation of the Software will be corrected. Nortel Networks is not obligated to remedy any Software defect
that cannot be reproduced with t he latest S oftware releas e. These warranties do not ap ply to t he Software if it has been
(i) altered, except by Nortel Networks or in accordance with its instructions; (ii) used in conjunction with another
vendor’s product, resu ltin g in the de fect; or (iii) damag ed by impro p er environ m ent, ab use, mi suse , acci dent , or
negligence. THE FOREGOING WARRANTIES AND LIMITATIONS ARE EXCLUSIVE REMEDIES AND ARE
IN LIEU OF ALL OTHER W A RRANTIES EXPRESS OR IMPLIED, INCLUDING WITHOUT LIMITATION

vi

306623-A Rev 00

ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. Licensee is
responsible for the security of its own data and information and for maintaining adequate procedures apart from the
Software to reconstruct lost or altered files, data, or programs.

4. Limitation of liability. IN NO EVENT WILL NORTEL NETWORKS OR ITS LICENSORS BE LIABLE FOR

ANY COST OF SUBSTITUTE PROCUREMENT; SPECIAL, INDIRECT, INCIDENTAL, OR CONSEQUENTIAL
DAMAGES; OR ANY DAMAGES RESULTING FROM INACCURATE OR LOST DATA OR LOSS OF USE OR
PROFITS ARISING OUT OF OR IN CONNECTION WITH THE PERFORMANCE OF THE SOFTWARE, EVEN
IF NORTEL NETWORKS HAS BEEN ADVISED OF THE POSSI BILITY OF SU CH DAMAGES. IN NO EVENT
SHALL THE LIABILITY OF NORTEL NETWORKS RELATING TO THE SOFTWARE OR THIS AGREEMENT
EXCEED THE PRICE PAID TO NORTEL NETWORKS FOR THE SOFTWARE LICENSE.

5. Government Licensees. This provision applies to all Software and documentation acquired directly or indirectly

by or on behalf of the United States Government. The Software and documentation are commercial products, licensed
on the open market at market prices, and were developed entirely at private expense and without the use of any U.S.
Government funds. The license to the U.S. Gove rnm ent is gr anted o nly with restric te d rights, and use, du p lic ation , or
disclosure by the U.S. Government is subject to the restrictions set forth in subparagraph (c)(1) of the Commercial
Computer Software––Restricted Ri gh ts cla use o f FAR 52.227-19 and the limitation s se t o ut in th is lic ense for c iv ilia n
agencies, and subparagraph (c)(1)(ii) of the Rights in Technical Data and Computer Software clause of DFARS

252.227-7013, for agencies of t he Department of Defense or their successors, whichever is applicable.

6. Use of Software in the European Community. This provision applies to all Software acquired for use within the

European Community. If Licensee uses the Software within a country in the European Community, the Software
Directive enacted by the Council of European Communities Directive dated 14 May, 1991, will apply to the
examination of the Software to facilitate interoperability. Licensee agrees to notify Nortel Networks of any such
intended examination of the Software and may procure support and assistance from Nortel Networks.

7. Term and termination. This license is effective until terminated; however, all of the restrictions with respect to

Nortel Networks’ copyright in the Software and user manuals will cease being ef fective at the date of expiration of the
Nortel Networks copyright; those restrictions relatin g to use and disclosu re of Nortel Networks’ con fide n tial
information shall continue in effect. Licensee may terminate this license at any time. The license will automatically
terminate if Licensee fails to comply with any of the terms and conditions of the license. Upon termination for any
reason, Licensee will immediately d est roy or return to Nortel Networks the Software, user manuals, and all copies.
Nortel Networks is not liable to Licensee for damages in any form solely by reason of the termination of this license.

8. Export and Re-export. Licensee agrees not to export, directly or indirectly, the Software or related technical data

or information without first o btain ing a ny req ui red exp ort li cen ses o r other gov ernm e nt al a p pro vals. Without limiting
the foregoing, Licensee, on behalf of itself and its subsidiaries and affiliates, agrees that it will not, without first
obtaining all export licenses and approvals required by the U.S. Government: (i) export, re-export, transfer, or divert
any such Software or te ch ni ca l da ta , or an y di r ect pro du c t the r eof , to any co un try to whi ch su ch ex po rt s or re-e xp orts
are restricted or em b argoed under United Sta te s expor t c on tr ol laws and regu la tio ns , or to an y na tio na l or res id e nt of
such restricted or embargoed countries; or (ii) provide the Software or related technical data or information to any
military end user or for any military end use, including the design, development, or production of any chemical,
nuclear, or biological weapons.

9. General. If any provision of this Agreement is held to be invalid or unenforceable by a court of competent

jurisdiction, the remainder of the provisions of this Agreement shall remain in full force and effect. This Agreement
will be governed by the laws of the state of California.

Should you have any questions concerning this Agreement, contact Nortel Networks, 4401 Great America Parkway,
P.O. Box 58185, Santa Clara, California 95054-8185.

LICENSEE ACKNOWLEDGES THAT LICENSEE HAS READ THIS AGREEMENT, UNDERSTANDS IT, AND
AGREES TO BE BOUND BY ITS TERMS AND CONDITIONS. LICENSEE FURTHER AGREES THAT THIS
AGREEMENT IS THE ENTIRE AND EXCLUSIVE AGREEMENT BETWEEN NORTEL NETWORKS AND
LICENSEE, WHICH SUPERSEDES ALL PRIOR ORAL AND WRITTEN AGREEMENTS AND
COMMUNICATIONS BETWEEN THE PARTIES PERTAINING TO THE SUBJECT MATTER OF THIS
AGREEMENT. NO DIFFERENT OR ADDITIONAL TERMS WILL BE ENFORCEABLE AGAINST NORTEL

306623-A Rev 00

vii

NETWORKS UNLESS NORTEL NETWORKS GIVES ITS EXPRESS WRITTEN CONSENT, INCLUDING AN
EXPRESS WAIVER OF THE TERMS OF THIS AGREEMENT.

viii

306623-A Rev 00

Contents

Preface

Before You Begin ............................................................................................................. xv

Text Conventions ............................................................................................................. xv

Acronyms ........................... .......................... .......................... ......................... ................. xv

Hard-Copy Technical Manuals .........................................................................................xvi

How to Get Help ..............................................................................................................xvi

Chapter 1
Passport 5430 Expansion Card Overview

Expansion Hardware Description ...................................................................................1-2

How to Use This Guide ...................................................................................................1-4

Chapter 2
Installing PMC Modules Onto the Expansion Card

Installing a PMC Module Onto an Expansion Card ........................................................2-1

Removing and Replacing a PMC Module .......................................................................2-5

Chapter 3
Installing Expansion Cards

Installing an Expansion Card .........................................................................................3-1

Removing the Filler Panel ...............................................................................................3-4

Removing an Expansion Card ........................................................................................3-5

306623-A Rev 00

ix