AudioLab 8200A Service Manual

8200A

VERSION HISTORY

Rev

V01

Date Update Content

2010.10.13

First Version

8200A

CONTENT

8200A

1.

Introduction

2.

Specification

3.

Assembly Sketch

4.

Schematic Diagram

5.

Wiring Diagram

6.

Silkscreen of Top/Bottom

7.

Maintenance Alignment Procedure

Assembly Parts List

8.

Electronic Parts List

9.

1

2

3

4-16

17

18-20

21

22-23

24-31

INTRODUCTION

No part of this document may be reproduced or transmitted in any form or by any means,electronic or
mechanical, for any purpose, without the express written permission of International Audio Group
Limited (IAG)

This manual is for the exclusive use of IAG, its approved distributors and approved UK service agents.

No part of this manual shall be transferred to any other party without the express written permission of
IAG.

It is the responsibility of the user to ensure that all the information contained in this manual is current.
Notification for new issues of this manual and minor updates will be given via the IAG web-site or on
request.

This manual has been prepared with the greatest care, it is intended for information only and no liability
shall be accepted for errors or changes to specification.

For further service information, parts lists and updates, please contact our web-site at
www.international audio group.com .

C

2010 International Audio Group Limited. All rights reserved.

8200A

1

SPECIFICATION

Rated Output Power

60W per channel into rated load impedance(8 Ohms)

with both channels driven

Inputs

CD,TUNER,AUX,VIDEO,TAPE1,TAPE2:125mV/20kΩ IHF

POWER AMP:782mV/47KΩ

Gain

PRE-AMP:9dB@1kHz

POWER AMP:29.0dB@1kHz

Signal To Noise Ratio

CD,TUNER,AUX,VIDEO,TAPE1,TAPE2:

Better than 80dB(IHF,rel.0.5V pre-amp output)

POWER AMP:better than 80dB(IHF,rel.0dBW)

Frequency Response

CD,TUNER,AUX,VIDEO,TAPE1,TAPE2 and POWER
AMP:

20Hz-20kHz±0.5dB:1Hz-65kHz-3dB.

Total Harmonic Distortion & Noise

Less than 0.07%

Channel Balance

Within 1dB

Channel Separation

Better than 60dB@1kHz any input

Crosstalk

Better than 80dB@1kHz

Polarity(phase)

Non-inverting for all inputs and outputs

Pre-amp Output

PRE OUT1 and PRE OUT2:Output Impedance 100Ω

Maximum Output>7.3V RMS

Headphone Output

Output impedance:330Ω

(suitable for headphones8Ω-2kΩ impedance)

Record Output

VIDEO OUT,TAPE1 OUT,TAPE2 OUT:

Output impedance:1kΩ

Gain from input to record output 0dB(x1)

Muting

Muting controlled manually or automatically

Accessories Supplied

AC Power Cord

Instruction Manual

8200RC Remote Control with 2xAA batteries

Operating Temperature Range

10-35℃

Power Requirements(Depending on Region)

50-60Hz 100V,110-120V,and220-230V models available

Maximum Power Consumption:440VA

Dimensions(WxHxD)

445x74x335mm-including feet,terminals and controls

445x64x302mm-excluding feet,terminals and controls

Weight

Net:7.4kg

Shipping:8.8kg

8200A

2

ASSEMBLY SKETCH

1414

4141

4141

4141

4141

4242

2929

2828

2727

2626

2525

2424

2323

4040

3939

3838

3737

3636

3535

3434

3333

3232

88

3131

3030

2222

1414

1212

1111

1010

99

88

77

44

33

55

22

11

66

1313

1414

1515

4343

1616

4444

1919 2020 2121

1010

1818

1717

1414

8200A

3

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P1/ 12

8200A

4

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P2/ 12

8200A

5

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P3/ 12

8200A

6

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P4/ 12

8200A

7

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P5/ 12

8200A

8

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P6/ 12

8200A

9

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P7/ 12

8200A

10

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P8/ 12

8200A

11

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P9/ 12

8200A

12

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P10 /12

8200A

13

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P11/12

8200A

14

SCHEMATIC DIAGRAM

8200A-Mainbo ard-P12 /12

8200A

15

SCHEMATIC DIAGRAM

8200A IR-Receiv er-P1/1

8200A

16

WIRING DIAGRAM

8200A -Wiring Dia gram-P1 /1

8200A

17

SILKSCREEN OF TOP BOTTOM

8200A-MainBo ard Top Silkscreeen-P1/1

/

8200A

18

SILKSCREEN OF TOP BOTTOM

8200A-MainBo ard Botto m Silkscr eeen-P1 /1

/

8200A

19

SILKSCREEN OF TOP BOTTOM

8200A IR-Receiv er Silksc reeen-P 1/1

/

8200A

20

MAINTENANCE ALIGNMENT PROCEDURE

Product Initial

setting

After 15

mins

After 30

mins

8200A 60 –65 24 – 25 21.5 – 22.5

Audiolab 8200A Bias Procedure

This procedure must only be carried out after the unit has passed a full functional test .

1.Connect the unit to be biased to mains and switch on. The mains voltage should be set to 230VAC or
120VAC +- 2% while the test is done.

4.The test continues until the bias is steady at the final value in the table.

2.Wait for the unit to power up.

All settings are mV dc.

Remarks：Also the test continues unil the bias is steady at the final value in the table.

For 8200A bias is measured across R748 (left channel) and R848 (right channel).

3.Set bias as shown in table below.

Screw driver

Step transformer for

AC mains

Anti-ESD belt

multimeter

1.If the Bias Okay, switch off the unit and put "PASSED" mark on the unit.

4):Soak test with the condition above with 48 hours.

Ageing test step

unit rated voltage variac voltage

2: Ageing test

1)Tune the "VOLUME" pot to MIN and power ON the 8200A.

Equipment andTools

Signal generator

AC110V AC120V±2%

AC100V AC110V±2%

AC240V AC250V±2%

AC220、230V

AC240V±2%

Notes：

2):Adjust the "VOLUME" until the output meet 8V rms.

1: Equipment and Set up

1):Connect the speaker terminal to 8 ohm resistor (200W), AC230V input.

5):Take out the input signal and adjust the bias vs RV701 and RV801 cross the
resistor R748 and R848. The voltage should be between 21.5 - 22.5mV.

2):Signal generator set to 1KHz and switch the 8200A to CD input.

3):Set the "RECORD" and "INPUT" knob to CD. "MODE" switch to
"INTEGRATED" position. Volume set to Max.

3):Add 5% of AC input for the test.

8200A -Bias Proce dure And Agei ng test ste p-P1/1

8200A -Ageing tes t step

8200A

21

ASSEMBLY PARTS LIST

R/N P/N PART NAME DESCRIPTION QTY

1 300-1027410000R front panel screened, light grey(silver anodized) 1

2 273-1028410000R display window 30.9*16.3*4.5mm 1
3 215-1027410001R button cap silver painted,ABS758# 1
4 340-1027410000R knob silver painted 4
5 307-1027410000R knob indicator silver painted,φ6.0 L=24MM 4
6 574-3000800011R screw M3*8 NI 9
7 215-1027410000R power button silver painted,ABS757# 1
8 588-3000066037R screw M3*6 10

9 305-1027410002R Main switch bracket painted 1
10 500-3050240300AR nut M3 NI 4
11 308-1027410000R metal block painteded 1
12 263-0020100102R EVA

20*10*10（thickness）mm，EVA，black

1
13 565-0515100001-1R bolt H5*15mm 2
14 534-3002061006R screw M3*6NI 23
15 604-1027410002-2R chassis silver painted 1
16 226-0230191911R feet φ23*φ19*13 4
17 319-1027410001R side panel sand blasting,anodized silver/black 2
18 826-0004604615R insulation pad 46*46*1.0mm 0.5
19 801-0080030030R ground terminal cap Φ8*Φ3*3mm 1
20 521-3005060500AR washer (lock type) 4*9*0.5mm NI 1
21 086-3811000000R ground terminal 1821T098-00 1

22 215-1027410002MR knob cap Φ37*3.2mm，POM、black 4

23 588-3000106037R screw M3*10 8

24 231-2114000102R rubber washer

Φ114*1（thickness）mm、black

1

25 368-1027410000R

transformer insulation

board

black painted 1

26 513-6412150780R washer φ6.4Xφ12X1.5 NI 1
27 500-6000000300R nut M6 1
28 826-0040024015R insulation pad 400*240*1.0mm 1
29 302-1027410002R top cover sand blasting,anodized silver/black 1
30 501-7075230300R nut M7*0.75mm 2
31 513-7212050300R washer Ф12*Ф7.2*0.5*2mm 2
32 501-8313200300R nut Φ8.3*2mm 1
33 513-9014050300R washer Ф14*Ф9*0.5mm 1
34 305-1027410000R bracket painteded 1
35 318-1377000000R metal plate for encoder 29*9*1mm 1
36 306-1027410000R heatsink (T type) anodized black 1
37 336-1027410000R shield cover iron 1
38 415-1027410000R shield cover sticker silver 1
39 231-2013005012R PVC washer Φ12.5*Φ4.5*0.1mm 5

8200A-Assemb ly Bom-P1 /2

8200A

22

ASSEMBLY PARTS LIST

40 262-0500005010R dustproof pad 5*50*0.25dustproof 16
41 534-3002100606R screw M3*10 4
42 425-0130000652R EVA 4.5*6*130mmblack 2
43 520-3006400000R plastic washer TW-4 2
44 303-1027410000R bottom cover silver painted 1

R/P P/N PART NAME DESCRIPTION QTY

300-1027410000R screened, light grey(silver anodized) 1
300-1027420000R screened, light grey(black anodized) 1
215-1027410001R silver painted,ABS757# 1
215-1027420001R black painted,ABS757# 1
340-1027410000R silver painted 4
340-1027420000R black painted 4
307-1027410000R silver painted,φ6.0 L=24MM 4
307-1027410000R black painted,φ6.0 L=24MM 4
215-1027410000R silver painted,ABS757# 1
215-1027420000R black painted,ABS757# 1
534-3002061006R M3*6NI 23
534-3002060906R M3*6 black 33
604-1027410002-1R silver painted 1
604-1027420004-2R black painted 1
319-1027410001R sand blasting,anodized silver 2
319-1027420001R sand blasting,anodized black 2
588-3000106037R M3*10NI 8
527-3012100806R M3*10black 8
302-1027410002R sand blasting,anodized silver 1
302-1027420000R sand blasting,anodized black 1
534-3002100606R M3*10NI 4
534-3002100906R M3*10black 11
303-1027410000R silver painted 1
303-1027420000R black painted 1

1 front panel

3 button cap

4 knob

5 knob indicator

7 power button

14 screw

15 chassis

17 side panel

23 screw

29 top cover

41 screw

44 bottom cover

8200A-Assemb ly Bom-P2 /2

Remar k:Colou r DifferenceTable

8200A

23

ELECTRONIC PARTS LIST

R/N P/N PART/NAME DESCIPTION QYT LOCATION

1 046-9400000400R 909 terminal red/black 4

2 062-1220000200R mains cable 2meter American 1

3 041-1376000000QR MAINS SWITCH

SWITCH MAINS２P SDDSA 3289A

1

4 071-1100000000R tie wrap 100MM YJ-100 20
5 060-4181650012QR 12AWG WIRE red 1
6 060-4181600412QR 12AWG WIRE black 2
7 060-4181650512QR 12AWG WIRE white 1

8 044-1700000000QR MAINS INLET MAINS INLET 2 POLE 2 FUSE LOCS 1

9 742-3501000000R heatshrink tube black 0.10

10 060-4180310312R double insulated wire UL1672 18 AWG blue L=310MM 1

11 060-4180310112R double insulated wire UL1672 18AWG brown L=310MM 1

12 053-1374001104QR MAINS SWITCH PCB PCB MAINS SWITCH 200 SERIES 1

13 085-0100000100R PVC tube φ10mm 0.22
14 742-3000000000R heatshrink tube Φ30 grey 0.06
15 022-2000042370R Transformer 230V/100V TOROID TI-103406 1

16 031-4200512121HR FUSE (T4A) T4A/250V 213 5*20MM LITTELFUSE 2

17 053-1377001137QR

PCB of SPEAKER

OUTPUT

150*52MM 1

18 088-1027411000R AMP PCB assembly 8200A PCBA 1

19 001-1000205010QR resistor 10R 1/4W 1% 4 R736.738.836.838

20 001-1500205010QR resistor 15R 1/4W 1% 2 R517.617

21 001-4700205010QR resistor 47R 1/4W 1% 16

R512.515-516.612.615-

616.708.723.726.746-

747.808.823-

826.846.847

22 001-6800205010QR resistor 68R 1/4W 1% 4 R513.514.613.614

23 001-2209205010QR resistor 2R2 1/4W 1% 5 R518-519.618-619.962

24 001-6809205010QR resistor 6R8 1/4W 1% 4 R347-350
25 001-2201205010QR resistor 220R 1/4W 1% 2 R507.607

26 001-1001205010QR resistor 100R 1/4W 1% 8

R622.731.735.831.835.9

11.979.980

27 001-2701205010QR resistor 270R 1/4W 1% 3 R903.907.915

8200A -Electron ic Bom-P1 /8

8200A

24

ELECTRONIC PARTS LIST

28 001-2702205010QR resistor 2K7 1/4W 1% 3 R508.608.909
29 001-1504205010QR resistor 150K 1/4W 1% 3 R511.611.966

30 001-1004205010QR resistor 100K 1/4W 1% 11

R510.610.663.751-

752.851-

852.951.958.961.963

31 001-4703205010QR resistor 47K 1/4W 1% 8

R702.741-742.802.841-

842.956.964

32 001-1503205010QR resistor 15K 1/4W 1% 10

R712.739-740.812.839-

840.902.905.914.916

33 001-5603205010QR resistor 56K 1/4W 1% 1 R957
34 001-1204205010QR resistor 120K 1/4W 1% 2 R501.601

35 001-8204205010QR resistor 820K 1/4W 1% 4 R704.753.804.853

36 001-3302205010QR resistor 3K3 1/4W 1% 1 R950
37 001-1005205010QR resistor 1M 1/4W 1% 1 R960
38 001-3905205010QR resistor 3M9 1/4W 1% 1 R969
39 001-3001205010QR resistor 300R 1/4W 1% 1 R912
40 001-3301205010QR resistor 330R 1/4W 1% 2 R743.843
41 001-5601205010QR resistor 560R 1/4W 1% 1 R955
42 001-1803205010QR resistor 18K 1/4W 1% 2 R707.807

43 001-2200205010QR resistor 22R 1/4W 1% 4 R744-745.844-845

44 001-6801205010QR resistor 680R 1/4W 1% 13

R908.705.706.715.716.7

32.734.805.806.815.816
.832.834

45 001-5600205010QR resistor 56R 1/4W 1% 2 R945.946

46 001-1002205010QR resistor 1K 1/4W 1% 14

R301.711.717-

718.811.817-818.866-

871.953

47 001-1003205010QR resistor 10K 1/4W 1% 36

R664.860-

864.949.959.965.R304-

311.320-

327.329.337.400-

405.407.408.661

48 001-2202205010QR resistor 2K2 1/4W 1% 5 R312.525.625.714.814

49 001-1802205010QR resistor 1K8 1/4W 1% 4 R931-934

8200A -Electron ic Bom-P2 /8

8200A

25

ELECTRONIC PARTS LIST

50 001-1801205010QR resistor 180R 1/4W 1% 2 R947.948

51 001-1202205010QR resistor 1K2 1/4W 1% 4 R505.506.605.606

52 001-4702205010QR resistor 4K7 1/4W 1% 11

R300.504.509.604.609.7

03.803.906.910.917.952

53 001-1203205010QR resistor 12K 1/4W 1% 2 R901.913
54 001-6802205010QR resistor 6K8 1/4W 1% 1 R954
55 001-2203205010QR resistor 22K 1/4W 1% 4 R937-940
56 001-2003205010QR resistor 20K 1/4W 1% 1 R660

57 001-5602205010QR resistor 5K6 1/4W 1% 8 R315-316.330-335

58 001-1101205010QR resistor 110R 1/4W 1% 2 R713.813
59 001-4704205010QR resistor 470K 1/4W 1% 2 R503.603
60 001-3304205010QR resistor 330K 1/4W 1% 2 R502.602
61 001-1102205010QR resistor 1K1 1/4W 1% 2 R701.801

62 001-0470308050R resistor 4.7Ω 2W J metal film 4 R749.849.981-982

63 001-2208920100QR cement resistor 0R22 7W+7W 10% 2 R748.848

64 008-4703002517QR CAP 0U047 +80/-20% 25V 5YF 7

C311-

312.319.320.720.820.94

0
65 836-2200005005QR CAP 22P 10% 50V POLYSTYRENE 2 C300.301
66 016-6811132201QR POLYSTYRENE CAP CAP 680P 2.5% 100V FKP2 2 C504.604
67 016-3311132201QR POLYSTYRENE CAP 330P 2.5% 100V FKP2 WIMA 2 C702.802

68 067-1104148000R DIODE IN4148 62

D946-

951.953.D301.502.504-

507.602.604-

607.661.701-709.715-

716.727-

728.801.809.815-

816.827-828.

69 067-3379339000QR ZENER DIODE DIODE BZX79C 3V3 ZENER 2 D902.904

70 067-3379629000QR ZENER DIODE DIODE BZX79C 6V2 ZENER 20

D400-408.717-718.817-

818.870-

873.903.905.945

71 067-3307912000QR ZENER DIODE DIODE BZX79C 12V ZENER 5 D711-712.811-812.952

8200A -Electron ic Bom-P3 /8

8200A

26

72 067-3379479000QR ZENER DIODE DIODE BZX79C 4V7 ZENER 4 D501.601.710.810

73 067-2204002000R DIODE IN4002 4 D713-714.813-814

74 067-3300086000QR ZENER DIODE DIODE BZV86-2V0 STABLSTOR 1 D660

75 018-3200753115R transistor ZTX753 TO-92 5 Q709.912.809.812.944

76 018-3200653115R transistor ZTX653 TO-92 5 Q710-711.810-811.942

77 018-2700042115QR transistor TRAN ZTX457 NPN TO-92 6

Q713.813.931-932.935-

936
78 018-2800310115QR transistor TRAN J310 N-CH FET TO-92 1 Q947

79 018-2700092115QR transistor TRAN ZTX757 PNP E-Line 4 Q714.814.933-934

80 018-0304382111QR transistor 2SC4382 NPN TO-220F SANKEN 2 Q715.815

81 018-0101668111QR transistor

TRAN 2SA1668 PNP TO-220F

SANKEN

2 Q716.816

82 018-0101216110QR transistor TRAN 2SA1216 PNP MT-200 SANKEN 2 Q717.817

83 018-0302922110QR transistor TRAN 2SC2922 NPN MT-200 SANKEN 2 Q718.818

84 018-0301488111QR transistor 2SA1488 TO-220F(SANKEN) 1 Q908

85 034-1115003307QR rectifier DIODE B80C 5000/3300N BRIDGE 1 D901

86 029-0800000000QR CRYSTAL CER CSA400MG RESONATOR 1 X300

87 024-1050101017R relay TQ2-5V MATSUSHITA 9 RY860-865.880-882

88 080-0315000010QR inductor 1.5UH 2 L971-972
89 017-1380000000R IC

LM317T(1.5A) TO-220（ST

）

1 IC901

90 050-0400000000R transistor clip 10*6MM black TR-1 1 IC901

91 017-4140000000QR IC 74HC373N OCT3-ST PHILIPS 20PIN 1 IC965

92 017-4150000000QR IC SN74HC00N 4X 2-IN NAND 14PIN TI 1 IC300

93 017-4160000000QR IC 74HC08 DIP14 TI 1 IC301
94 017-4170000000QR IC IC 74HC30N 8-IN NAND Philips 1 IC962
95 017-4630000000QR IC L272M DIP8 :ST 2 IC305,306

96 017-4180000000QR IC TL7705ACP 5V SUPERVISOR DIP8 TI 1 IC303

97 089-1100000012QR switch SWITCH MOTORISED SRBAA2603A 1 SW660

98 001-0220205014QR resistor

2.2R，0.25W，1%

7

R313-314.318-

319.340.974.977

99 001-0000105050QR resistor 0R 1/4W 5% 1 WL901

ELECTRONIC PARTS LIST

8200A -Electron ic Bom-P4 /8

8200A

27

ELECTRONIC PARTS LIST

100 001-1001308050QR resistor 100R 2W 5% 2 R528.628
101 001-3301308050QR resistor

330R，2W，5%

2 R983.984
102 009-1031008110QR CAP 10NF/100V 20% 3 C900.902-903
103 016-1021132201QR CAP FKP2 1000PF/100V 2.5% WIMA PCM5 4 C707-708.807-808
104 324-0380250101QR insulation 38*25MM 4 transistor
105 071-2480000000QR tie wrap YJ-330 2

106 001-3902205010QR resistor 3K9 1/4W 1% 8

R524.624.729-

730.737.750.829-

830.837.850
107 001-2002205010QR resistor 2K 1/4W 1% 4 R833.733.837.737
108 060-4181480412QR 12AWG WIRE black L=148MM 1
109 318-1377000000R metal plate for encoder 29*9*1mm 1
110 060-4181030312QR 12AWG WIRE blue L=103MM 1
111 060-4181930712QR 12AWG WIRE yellow L=193MM 1
112 044-2910000000R PHONE JACK AST-6.35-006B 1 J977

113 013-3350120505QR CAP 3U3 10% 50V MKS2 WIMA 6

C502.505.602.605.717.8
17

114 018-0500369115R Transistor 2SK369GR TO-92 TOSHIBA 4

Q701.Q801(matched
pairs)

115 017-4200000000QR IC

IC PIC16C57-XT/P 8-BIT 28PIN

MICROCHIP

1 IC302

116 058-2842000000R IC SOCKET DIP 28PIN pitch:2.54MM round hole 1 IC302

117 056-4105221100R connector DJ2802-05 1 EC560

118 051-6100000001R connector 2PIN T6302-AABF 2 J860,J863
119 024-2240501025QR relay G2R-24 2PCO 24V OMRON 1 RY1

120 016-3320800001R CAP 3300P 5% 63V FKP2 WIMA PH5MM 10

C509-511.609-

611.701.703.801.803
121 013-8220210505R CAP 8200P 5% 63V WIMA PH5MM 2 C864.865

122 006-1034405003QR E-cap 10000U 71V AUDIO 40*50 2

123 020-5022121317R potentiometer 5K 25% BOURNS 3329H-1-502LF 2 RV701.801

124 089-0600000018QR switch SRS03-46B 15KC(MOD) 2 SW661.SW680

125 020-2031321123HR

motorize

potentiometer

20K ALPS RK16812MG 15A 1 VR660

126 017-1276000000R IC OPA2134PA 2X OP AMP DIP-8 TI 1 IC1

127 006-2204051153HR E-cap

ELNA 22U 20% 35V RE3-35V220ME3

5*11mm

4 C715-716.815-816

128 016-2240320504QR POLYSTYRENE CAP 0U22 10% 100V MKS2 2 C712.812
129 016-0141100001R POLYSTYRENE CAP 0U01 5% 100V MKS2 WIMA PH5MM 5 C660.718-719.818-819

8200A -Electron ic Bom-P5 /8

8200A

28

ELECTRONIC PARTS LIST

130 016-4740810001R POLYSTYRENE CAP 0U47 10% 63V MKS2 WIMA PH5MM 1 C938

131 016-1041300001R POLYSTYRENE CAP 0.10uf 250v 5% PH=10MM WIMA 1 C901

132 016-3331100001R POLYSTYRENE CAP 0U033 5% 100V MKS2 WIMA PH5MM 4 C931-934

133 016-1041100001R POLYSTYRENE CAP 0U1 5% 100V MKS2 wima ph5mm 24

C302.305-307.313-

318.506.606.709-

711.809-

811.907.910.915.935.96

2.964

134 006-1004051133HR E-cap

ELNA 10U 20% 16V RE3-16V100ME3

5*11mm

3 C308.309.911

135 006-4704051133HR E-cap

ELNA 47U 20% 16V RE3-16V470ME3

5*11mm

2 C704.C804

136 006-1014162552QR E-cap ELNA RE3-35V-101M F3 100UF 35V 4 C310.936.937.939

137 006-1014102053HR E-cap

100UF 35V 20% RFS-35V101MH5

10*20 ELNA

2 C508.C608

138 006-4714081133HR E-cap

ELNA 470U 20% 16V RE3-16V471MG3

8*11.5mm

3 C905.909.913

139 006-4714101653HR E-cap

ELNA 470U 20% 35V RE3--

35V471MH4 10*16mm

2 C906.914

140 006-4794051173HR E-cap

ELNA 4U7 20% 63V RE3-63V4.7ME3

5*11mm

7

C501.601.C661.713-

714.813-814

141 013-4730320504QR CAP CAP 47000P 20% 100V X7R CER 2 VR660

142 306-1003770011QR mian heatsink anodized 1
143 306-1003770001QR heatsink 1 anodized 1
144 306-1003770002QR heatsink 2 anodized 1
145 306-1003770003QR heatsink 3 anodized 2
146 306-1027410005R heatsink 5 anodized, black 4
147 306-1027410006R heatsink 6 anodized, black 4
148 306-1027410003R heatsink anodized, black 2
149 306-1027410001R heatsink 1a anodized, black 1
150 306-1027410002R heatsink 2a anodized, black 1
151 306-1027410000R T type heatsink anodized, black 1

152 588-3000256037R screw M3*25 4

transistor+mian
heatsink4

153 500-3050240300AR nut M3 NI 5

transistor+mian
heatsink4,T type

154 513-3007050080R washer φ3*φ7*0.5 Zn 4

transistor+mian
heatsink4

8200A -Electron ic Bom-P6 /8

8200A

29

ELECTRONIC PARTS LIST

155 517-3008080130AR washer Φ3.1*Φ4.7*0.8 4

transistor+mian
heatsink4

156 588-3000206037R screw M3*20 1 T type heatsink 1

157 016-1001120001R CAP 10P 20% 100V pitch:5MM length:11MM 2 C904.912

158 016-2201120001R CAP 22P 20% 100V pitch:5MM length:13MM 2 C507.607

159 001-4701205010QR resistor 470R 1/4W 1% 16

R941-

944.R709.710.727.728.7

55.809.810.827.828.855

.935.936

160 001-1502205010QR resistor 1K5 1/4W 1% 2 R967.968

161 013-1010310507R CAP 100pF 100V 5% 8

C705-706,805­806,C303,C908,C503,C

162 018-1400546115-1R transistor BC546BRL1G TO-92 ON 23

Q660-662.705-

706.708.719.721.805-

806.808.819.Q821.902-

903.905-906.910-

911.939.941.943.945

163 018-0303851111QR transistor 2SC3851 TO-220F(SANKEN) 2 Q904.Q912

164 223-0414210201R plastic standoff white ABS PW-6 height 2mm 2 X300
165 053-102741A000R 8200A-AMP PCB two layer 407.7*294.6*2.0MM 1

166 051-1006334035-1R SOCKET

SOCKET 4WAY PHONO GOLD

PLATED T6288-AABF up white/down

red

5 J860-863

167 060-4120210012R 12AWG WIRE red UL󰾯1617󰾯AWG L=215MM 1
168 060-4120120512R 12AWG WIRE white UL󰾯1617󰾯AWG L=125MM 1
169 060-4120150012R 12AWG WIRE red UL󰾯1617󰾯AWG L=155MM 1
170 060-4120180512R 12AWG WIRE white UL󰾯1617󰾯AWG L=185MM 1

171 588-3000086037R screw M3*8 6

heatsink 1a-1，heatsink
5 4，heatsink 2a-1，
heatsink

172 588-3000066037R screw M3*6 4

mian heatsink+AMP
PCB

8200A -Electron ic Bom-P7 /8

8200A

30

ELECTRONIC PARTS LIST

173 001-3002207010R resistor

nonflammable metal film H-FM 2WS

3K3 ±1% size11*4.5*0.8MM

4 R719-720.819-820

174 001-3002205010QR resistor 3K 1/4W 1% 1 R406

175 001-3002208010R resistor

nonflammable metal film L-MF1WS

3K0 1W ±1%

8

721-722.724-725.821-

822.824-825

176 018-1400550115-1R transistor BC550B NPN TO-92 FAIRCHILD 14

Q501-502.506-

509.511.601-602.606-

609.611

177 018-1400560115-1R transistor BC560B PNP TO-92 FAIRCHILD 10

Q503-505.510.512.603-

605.610.612

178 018-1400556115-1R transistor BC556B PNP TO-92 Fairchild 26

Q907.909.937~938.940.
946,Q400~407,702~704
,707,720,802~804,807,8
20,860,901

179 088-1027414200R IR PCBA PCBA 1

180 053-1027411046R 8200A IR PCB single layer,54*28*1.6MM,FR4 20Z 1

181 019-0011022000QR LED LED/ RED 2 D200.201

182 055-0305025344R FLAT WIRE 5P L=250MM UL2468 26AWG 1 EC02

183 052-2100000000R IR EMITER TSOP4836 1 IR

184 009-1040508110R CAP 100nF 50V 20% 1 C200

185 001-2200205010QR resistor 22R 1/4W 1% 2 R203.204

186 001-2209205010QR resistor 2R2 1/4W 1% 1 R202

187 001-8201205010QR resistor 820R 1/4W 1% 2 R200,R201

188 223-0532220301R plastic post 3-3 2 D200,D201

189 018-1400550115-1R transistor BC550B NPN TO-92 FAIRCHILD 2 Q201,Q202

8200A -Electron ic Bom-P8 /8

8200A

31