Antunes ESDZ-1200 Service Manual

EGG STATION DUAL ZONE

Antunes

MODEL ESDZ-1200

Mfg. No. 9300624 & 9300625

Place this manual in the Small Equipment/

Miscellaneous section of your Equipment Manual.

Manufactured exclusively for

McDONALD’S®

ANTUNES

180 KEHOE BLVD.

CAROL STREAM, ILLINOIS 60188, U.S.A.

PHONE: 1-630-784-1000

TOLL FREE: +1-877-392-7854

FAX: 1-630-784-1650

www.antunes.com

Owner Information .....................................................2

General ......................................................................2

Warranty Information .................................................2

Service/Technical Assistance ....................................2

Important Safety Information ....................................3

Specifications .............................................................4

Electrical Ratings .......................................................4

Dimensions ................................................................4

Electrical Cord & Plug Configurations .......................4

Installation ...................................................................5

Unpacking ..................................................................5

Leveling the Unit ........................................................5

Operation .....................................................................6

Preparing Unit ............................................................6

Control Panel .............................................................6

Scan with mobile device or enter URL

for product and service information.

http://tiny.cc/ajaESDZ

TABLE OF CONTENTS

IMPORTANT

ESDZ-1200

Egg Cooking Procedure ............................................7

Programming ..............................................................8

Factory Default Cooking Times .................................8

Turning cooking surfaces on or off ............................8

Manager Mode ..........................................................8

Maintenance ................................................................9

Daily Cleaning ...........................................................9

Troubleshooting .......................................................10

Error Codes .............................................................11

Factory Reset ..........................................................11

Hi Limit Control ........................................................11

Replacement Parts ...................................................12

Wiring Diagram .........................................................15

LIMITED WARRANTY .........................................................16

The unit must be level before use. Before using the unit, adjust the legs of the unit as needed and use a level (if available) to ensure the unit is level. If a level is not available, pour a small amount of water directly onto the center of the cool grill surface. If the unit is level, the water should pool in the middle and not drain toward a certain section of the unit. Make adjustments as required. Turn legs clockwise to shorten or counter-clockwise to lengthen. See image (Side view of unit).

Turn Leg

Clockwise

See back cover for important warranty information.

P/N 1011401 Rev. E 05/17 McDonald’s

to shorten.

Turn Leg

Counter-clockwise

to lengthen.

EGG STATION DUAL ZONE

OWNER INFORMATION

General

This manual provides the safety, installation, and operating procedures. We recommend that all information contained in this manual be read prior to installing and operating the unit.

This unit is manufactured from the finest materials available, assembled to strict quality standards, and tested at the factory to ensure dependable trouble-free operation.

Warranty Information

Please read the full text of the Limited Warranty printed on the front cover of this manual.

If the unit arrives damaged, contact the carrier immediately and file a damage claim with them. Save all packing materials when filing a claim. Freight damage claims are the responsibility of the purchaser and NOT covered under warranty.

The warranty does NOT extend to:

• Damages caused in shipment or damage as result of improper use.

• Installation of electrical service.

• Installation, calibration, or adjustment.

• Normal maintenance outlined in this manual.

• Consumable parts such as Egg Rings, gaskets, rubber feet, labels, O-rings, light bulbs, etc.

• Malfunction resulting from improper service or maintenance.

• Damage caused by improper installation, abuse, or careless handling.

• Damage from moisture getting into electrical components.

Service/Technical Assistance

If you experience any problems with the installation or operation of your unit, contact Antunes Technical Service at +1-877-392-7854 (toll free).

Fill in the information below and have it handy when calling Antunes Technical Service for assistance. The serial number is on the specification plate located on the side of the unit.

Purchased From:

Date of Purchase:

Model No.:

Serial No.:

Mfg. No.:

Use only genuine Antunes replacement parts in this unit. Use of replacement parts other than those supplied by the manufacturer will void the warranty.

• Damage from tampering with, removal of, or changing any preset control or safety device.

• Damage caused by parts or components not provided by Antunes.

IMPORTANT! Keep these instructions for future reference. If the unit changes

ownership, be sure this manual accompanies the equipment.

P/N 1011401 Rev. E 05/17

McDonald’s

EGG STATION DUAL ZONE

IMPORTANT SAFETY INFORMATION

In addition to the warnings and cautions in this manual, use the following guidelines for safe operation of the unit.

• Read all instructions before using equipment.

• Install or locate the equipment only for its intended use as described in this manual.

• Do NOT use corrosive chemicals in this equipment.

• Do NOT operate this equipment if it has a damaged cord or plug; if it is not working properly; or if it has been damaged or dropped. If the power cord is damaged, it must be replaced by a qualified service technician.

• This equipment should be serviced by qualified personnel only. Contact Antunes Technical Service at +1-877-3927854 (toll free).

• Do NOT block or cover any openings on the unit.

• Do NOT immerse cord or plug in water. There is a possibility of slippery floor adjacent to this equipment.

• Keep cord away from heated surfaces.

• Do NOT allow cord to hang over edge of table or counter.

• This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved. Children should not play with this appliance. Cleaning and user maintenance shall not be made by children without supervision.

The following warnings and cautions appear throughout this manual and should be carefully observed.

• Turn the power off, unplug the power cord, and allow the unit to cool down before performing any service or maintenance.

• The equipment should be grounded according to local electrical codes to prevent the possibility of electrical shock. This requires a grounded receptacle with separate electrical lines to be protected by fuse(s) or circuit breaker(s) of the proper rating.

• All electrical service connections must be in accordance with local and/or other applicable electrical codes.

• Do NOT clean this appliance with a water jet.

• Do NOT use a sanitizing solution or abrasive materials. The use of these may cause damage to the stainless steel finish.

• Chlorides or phosphates in cleaning agents (e.g. bleach, sanitizers, degreasers, or detergents) could cause permanent damage to stainless steel equipment. The damage is usually in the form of discoloration, dulling of metal surface finish, pits, voids, holes, or cracks. This damage is permanent and not covered by warranty. The following tips are recommended for maintenance of your stainless steel equipment,

- Always use soft, damp cloth for cleaning, rinse with clear water and wipe dry. When required, always rub in direction of metal polish lines.

- Finger marks and smears should be rubbed off using soap and water.

- Hard water spots should be removed using a vinegar solution.

WARNING

ELECTRICAL SHOCK HAZARD.

FAILURE TO FOLLOW THE INSTRUCTIONS IN THIS MANUAL COULD RESULT IN SERIOUS INJURY OR DEATH.

• Electrical ground is required on this appliance.

• Do NOT modify the power supply cord plug. If it does not fit the outlet, have a proper outlet installed by a qualified electrician.

• Do NOT use an extension cord with this appliance.

• The unit should be grounded according to local electrical codes to prevent the possibility of electrical shock. It requires a grounded receptacle with separate electrical lines, protected by fuses or circuit breaker of the proper rating.

• Check with a qualified electrician if you are unsure if the appliance is properly grounded.

CAUTION All electrical connections must be in accordance with local electrical codes and any other applicable codes.

CAUTION Do NOT plug any personal or unauthorized USB device into the USB port of this unit. Doing so may cause damage to the unit.

IMPORTANT

Antunes reserves the right to change specifications and product design without notice. Such revisions do

not entitle the buyer to corresponding changes, improvements, additions, or replacements for previously

purchased equipment.

P/N 1011401 Rev. E 05/17 McDonald’s

EGG STATION DUAL ZONE

SPECIFICATIONS

Electrical Ratings

Model & Mfg. No.

ESDZ-1200

9300624

ESDZ-1200

9300625

Volts Watts Amp Hertz

200-240~ 3000 15/

Dimensions

12.5

50/60

Electrical Cord & Plug Configurations

Model & Mfg. No.

ESDZ-120 0

9300624

ESDZ-120 0

9300625

Description Configuration

250 VAC., 20 Amp.

Pin and Sleeve

L6-20P, 20 Amp.,

250 VAC., Straight

Twist Lock.

Model & Mfg. No.

ESDZ-1200

9300624

ESDZ-1200

9300625

Width

(A)

18"

(457 mm)

18"

(457 mm)

Depth

(B)

18 29/32" (480 mm)

Height

(C)

8 15/16"

(227 mm)

8 15/16"

(227 mm)

P/N 1011401 Rev. E 05/17

McDonald’s

INSTALLATION

Unpacking

1. Remove unit and all packing materials from shipping carton.

NOTE: If any parts are missing or damaged, contact Antunes Technical Service IMMEDIATELY at +1-877-392-7854 (toll free).

2. Remove information packet.

3. Remove all packing materials and protective coverings from the unit.

4. Wipe all surfaces of the unit with a hot damp cloth.

NOTE: Do NOT use a dripping wet cloth. Wring it out before use.

5. Clean the Egg Rings, Egg Rack, Top Cover, and Scrap Pans in hot, soapy water. Rinse in clear water and allow to air dry.

6. Reassemble all parts to unit.

Leveling the Unit

EGG STATION DUAL ZONE

Figure 1. Next Generation Egg Cooker

Rear Top Cover

The unit must be placed on a level surface. The unit comes with 4 individually adjustable legs to assist in leveling. Be sure to place the unit on a sturdy flat surface and adjust the legs as needed to ensure the unit is level. Turn legs clockwise to shorten or counter- clockwise to lengthen.

To verify if the unit is level, use a level (if available). If a level is not available, open the Top Cover and Egg Rack and pour a small amount of water directly onto the cool grill surface. If the unit is level, the water should pool in the middle and not drain toward a certain section of the unit. Make adjustments as required.

Turn Leg

Clockwise

to shorten.

Turn Leg

Counter-clockwise

to lengthen.

Front Top Cover

Front Egg Rack and Rings

Pivot Rod

Rear Egg Rack and Rings

Front Grill Surface

Rear Grill Surface

Figure 2. Components

Egg Ring

IMPORTANT Failure to level the unit may result in unevenly cooked product.

P/N 1011401 Rev. E 05/17 McDonald’s

+ 11 hidden pages