Antunes DST-200 Installation Manual

MANUFACTURING

NUMBERS:

9200800

DELI SANDWICH

P/N 1011001 Rev. B 03/09

TOASTER

Model DST-200

Owner’s Manual

Deli SanDwich ToaSTer (DST-200)

TABLE OF CONTENTS

Owner Information .....................................................2

General ......................................................................2

Warranty Information .................................................2

Service/Technical Assistance ....................................2

Specifications .............................................................3

Electrical Ratings & Plug Configurations ...................3

Dimensions ................................................................3

Important Safety Information ....................................4

Operation .....................................................................5

Operating Instructions ...............................................5

Changing Modes .......................................................6

Toasting Product ........................................................6

OWNER INFORMATION

General

The DST-200 Deli Sandwich Toaster uses infrared heat to evenly and quickly toast a variety of bread products.

This manual provides the safety, installation, and operating procedures for the Deli Sandwich Toaster. We recommend that all information contained in this manual be read prior to installing and operating the unit.

Your Deli Sandwich Toaster is manufactured from the finest materials available and assembled to Roundup’s strict quality standards. This unit has been tested at the factory to ensure dependable trouble-free operation.

Warranty Information

Please read the full text of the Limited Warranty in this manual.

If the unit arrives damaged, contact the carrier immediately and file a damage claim with them. Save all packing materials when filing a claim. Freight damage claims are the responsibility of the purchaser and are NOT covered under warranty.

Service/Technical Assistance

If you experience any problems with the installation or operation of your unit, contact your local Roundup Authorized Service Agency. They can be found in the service agency directory packaged with the equipment.

You may also contact the factory at 1-877-392-7854 (toll free in the U.S. and Canada) or 1-630-784-1000 if you have trouble locating your nearest Authorized Service Agency.

Adjusting Toasting Quality .........................................7

Programming the DST-200 ........................................8

DST-200 Default Settings ..........................................8

DST-200 Unit Status Mode ........................................9

Purging Products from the Toaster ............................9

Shutting Down the DST-200 ....................................10

Maintenance .............................................................. 11

DAILY: Cleaning the Accessories and Horizontal

Conveyor Belts ........................................................11

Troubleshooting .......................................................12

Notes..........................................................................14

Limited Warranty ......................................Back Cover

Fill in the information below and have it handy when calling your Authorized Service Agency for assistance. The serial number is on the specification plate located on the rear of the unit.

Purchased From:

Date of Purchase:

Model No.:

Serial No.:

Mfg. No.:

Refer to the service agency directory and fill in the information below:

Authorized Service Agency

Name:

Phone No.:

Address:

Use only genuine Roundup replacement parts in this unit. Use of replacement parts other than those supplied by the manufacturer will void the warranty. Your Authorized Service Agency has been factory trained and has a complete supply of parts for this unit.

IMPORTANT! Keep these instructions for future reference. If the unit changes

ownership, be sure this manual accompanies the equipment.

P/N 1011001 Rev. B 03/09

SPECIFICATIONS

21.08”

(535 mm)

19.10”

(485 mm)

20.50”

(521 mm)

24.39”

(620 mm)

19.34”

(491 mm)

13.75”

(349 mm)

8.51”

(216 mm)

12.89”

(327 mm)

Electrical Ratings & Plug Configurations

Deli SanDwich ToaSTer (DST-200)

Model &

Mfg. No.

DST-200 9200800

Voltage Watts Amps Hertz

208

1 phase

5000 24.0 60

CAUTION All electrical connections must be in accordance with local electrical codes and any other applicable codes.

Dimensions

Plug

Description

NEMA 6-30P Straight Blade (P/N 0700748)

Plug

Configuration

Shipping &

Operating Weight

95 lbs. (43 kg)

Operating

105 lbs. (48 kg)

Shipping

P/N 1011001 Rev. B 03/09

Deli SanDwich ToaSTer (DST-200)

IMPORTANT SAFETY INFORMATION

Throughout this manual, you will find the following safety words and symbols that signify important safety issues with regards to operating or maintaining the equipment.

WARNING

GENERAL WARNING. Indicates information important to the proper operation of the equipment. Failure to observe may result in damage to the equipment, severe bodily injury or even death.

CAUTION

GENERAL CAUTION. Indicates information important to the proper operation of the equipment. Failure to observe may result in damage to the equipment.

In addition to the warnings and cautions in this manual, use the following guidelines for safe operation of the unit.

 • Readallinstructionsbeforeusingequipment.

 • Foryoursafety,theequipmentisfurnishedwith

a properly grounded cord connector. Do NOT attempt to defeat the grounded connector.

 • Installorlocatetheequipmentonlyforitsintend-

ed use as described in this manual. Do NOT use corrosive chemicals in this equipment.

 • DoNOToperatethisequipmentifithasadam-

aged cord or plug, if it is not working properly, or if it has been damaged or dropped.

 • Thisequipmentshouldbeservicedbyqualified

personnel only. Contact the nearest Authorized Service Agency for adjustment or repair.

 • DoNOTblockorcoveranyopeningsontheunit.

 • DoNOTimmersecordorpluginwater.

 • Keepcordawayfromheatedsurfaces.

 • DoNOTallowcordtohangoveredgeoftableor

counter.

 • DoNOToperateunitonacombustiblecounter

top.

 • DoNOTcleanthisappliancewithawaterjet.

The following warnings and cautions appear throughout this manual and should be carefully observed.

 • Turnthepoweroff,waitforthecool-downpro-

cedure to complete its cycle (45 minutes), and unplug the power cord before performing any service or maintenance on the unit.

WARNING

ELECTRICAL WARNING. Indicates information relating to possible shock hazard. Failure to observe may result in damage to the equipment and/or severe bodily injury or death.

WARNING

HOT SURFACE WARNING. Indicates information important to the handling of equipment and parts. Failure to observe caution could result in personal injury.

NOTE: Turning off the Power Switch does NOT turn off all power to the unit. When the unit is plugged in and turned off, a LED light will flash to indicate that the power cord is plugged in.

 • Theproceduresinthischaptermayinclude

the use of chemical products. These chemical products will be highlighted with bold face letters followed by the abbreviated HCS (Hazard Communication Standard). See Hazard Communication Standard manual for the appropriated Material Safety Data Sheets (MSDS).

 • Theequipmentshouldbegroundedaccordingto

local electrical codes to prevent the possibility of electrical shock. It requires a grounded receptacle with separate electrical lines, protected by fuses or circuit breaker of the proper rating.

 • Breadmayburn.Thereforetoastersmustnotbe

used near or below curtains or other combustible walls and materials. Failure to maintain safe operating distances may cause discoloration or combustion.

This equipotentiality symbol shows

external functional grounding connection.

WARNING To avoid possible personal injury and/or damage to the unit, all inspections, tests, and repair of electrical equipment should be performed by QUALIFIED SERVICE PERSONNEL. The unit MUST be shut down and UNPLUGGED before any internal servicing, except when electrical tests are required. Use extreme care during electrical circuit tests. Live circuits will be exposed.

P/N 1011001 Rev. B 03/09

Deli SanDwich ToaSTer (DST-200)

PRGM SELECT

ADJUST

MODE

MOTOR

DST

NEXTPREV

UPPER I/R

LOWER I/R

PRGM SELECT

ADJUST

MODE

MOTOR

DST

NEXTPREV

UPPER I/R

LOWER I/R

Testing 20

#####, #####, #####

Antunes DST-200

#####, #####, #####

The unit displays this message for approximately 2 seconds.

The unit performs a 20-second system check.

The bottom line refers to the current software version.

PRGM SELECT

ADJUST

MODE

MOTOR

DST

NEXTPREV

UPPER I/R

LOWER I/R

Power ON

READY

PURGE

SELECT

PRGM SELECT

ADJUST

MODE

MOTOR

DST

NEXTPREV

UPPER I/R

LOWER I/R

Deli 1 Warm Up

Deli 1 Ready

PRGM SELECT

ADJUST

MODE

MOTOR

DST

NEXTPREV

UPPER I/R

LOWER I/R

OPERATION

Operating Instructions

NOTE: To ensure proper operation, toast some test product at the start of each day or whenever the unit mode is changed.

NOTE: The DST-200 has two operational modes: Deli 1 and Deli 2. The unit always starts up in Deli 1 Mode.

Turn the Power Switch on.

The unit clicks three times. This is normal.

After the system check, the unit displays “Deli 1 Warm

Up”. This stage lasts approximately 20 minutes.

The unit displays “Deli 1 Ready” when it reaches proper

operating temperature for toasting.

The unit’s start-up mode includes a 20-second system check.

P/N 1011001 Rev. B 03/09

NOTE: If any parts are missing or damaged, contact Technical Service IMMEDIATELY at 1-877-392-7854 (North America only), or 630-784-1000.

CAUTION

1. Provide at least 1 inch (25.4 mm) clearance on both sides of this unit from any combustible wall or surface.

2. Do NOT operate unit on a combustible surface or counter top.

WARNING Use caution while the unit is operating. The unit and accessories will be hot to the touch. Use Heat Resistant Gloves when removing any accessories while the unit is operating. Personal injury may result.

+ 11 hidden pages