Specifications and Main Features
- Electrical requirements :
- Voltage: 208V, 240V, 380V, 416V, 460V
- Phase: 3 phase – main supply and single phase for sprinkler circuit
- Integral electrics service:
- Supply current: Between 39A and 86 A depending on Voltage
- Container fuse ratings: Between 70A and 200A depending on Voltage
- Circuit breakers: Between 70A and 150A depending on Voltage
- Electrical requirements for sprinkler circuit :
- Supply current: Between 11 A and 24 A depending on voltage
- Container fuse ratings: 5A
- Breaker ratings: 5A
- Airflow: 4500 CFM exhaust during the drying cycle
- Compressed air supply: 80P.S.I. bang on a minimum of 20 cubic/metres/h per hour
- Gas requirements in regard with gas dryers:
- N.G. gas pressure: 7 to 13 inches water column
- Gas pressure L.P: 10 to 11 inches water column
- Steam requirements in regard with steam dryers:
- Working steam pressure: 125 psi
- Boiler hp: 23
- Appliance features: Dryers incorporate a sprinkler system to be used during a fire by washing out the fire and disabling the dryer during the cooling process
- Appliance features:
- Control box: Primary control box/unit, which carries an electrical panel where the main switch is installed
- Control system: Interface boxes most of which are connected to input and output sensors
- Description of functional blocks: PLC controller programmable for operational set functions
Frequently Asked Questions
Q: How much does the AD-400 dryer weigh?
A: The dryer comes with a control console which weighs approximately 3200 pounds, and the basket/base weighs 6600 pounds.
Q: What are the different electric voltage options available for the AD-400?
A: Some of the voltages the AD-400 has an option for are 208, 240, 380, 416, and 460.
Q: What is the air exhausted during the operation of the dryer?
A: The dryer discharges 4500 cfm air at the time of drying process.
Q: What is the needed supply pressure level for natural gas dryers?
A: The water column supply pressure for natural gas should range between 7 to 13 inches.
Q: What about the safety of AD-400? Any features?
A: There is a sprinkling system which gets activated if there is a fire to shut the dryer off which is included in the device.
Q: What is the range of working steam pressure using steam dryers?
A: The working steam pressure range in which the steam dryer should work should not exceed 125 psi.
Q: What is the need of supply compressed air?
A: The supply compressed air required for the dryer is around 80 psi with minimum flow rate of 20 cubic feet/hour.
User Manual
Loading...