INSTALLATION GUIDE FOR
EVOLUTION™ AIR BATHS
MODEL 2422V.068C |
5' x 32" |
MODEL 2771V.068C |
5' x 36" |
MODEL 2645V.068C |
OVAL |
MODEL 7236V.068C |
6' x 36" |
MODEL 2425V.168C |
5' x 32" IA-RHO |
MODEL 2425V.268C |
5' x 32" IA-LHO |
THANK YOU...
for selecting an American Standard bath. Your new bath is shipped to you after careful inspection. The air bath is completely assembled with air blower and system piping. All you need to finish the installation are your selected fittings and electrical connections.
To ensure maximum performance and pleasure from this product, please follow the instructions and cautions.
FOR AFTER-SALES SERVICE CALL 1 ( 00) 442-1 02 WEEKDAYS.
© AS Americas Inc. 200
All product names listed herein are trademarks of AS Americas Inc. unless otherwise noted.
754072-100
TABLE OF CONTENTS:
Safety Instructions............................................................................ |
Page |
General Information.......................................................................... |
Page 4 |
Optional Components....................................................................... |
Page 4 |
Specifications.................................................................................... |
Page 5 |
Roughing-in Reference..................................................................... |
Page |
Framing and Support Instructions..................................................... |
Page 7 |
Mounting Instructions........................................................................ |
Page |
Electrical Connections....................................................................... |
Page |
Drain Connection and System Test................................................... |
Page 10 |
Care and Cleaning............................................................................. |
Page 10 |
Remote Blower Location Option........................................................ |
Page 11 |
Warranty............................................................................................ |
Page 12 |
754072-100
IMPORTANT SAFETY INSTRUCTIONS
INSTRUCTIONS PERTAINING TO A RISK OF FIRE, ELECTRIC SHOCK OR INJURY TO PERSONS
READ AND FOLLOW ALL INSTRUCTIONS!
!WARNING: Risk of personal injury. Do not permit children to use this unit without adult supervision.
!WARNING: Risk of personal injury. Do not operate this unit without the guard over the suction fitting.
!WARNING: Risk of electric shock. Do not permit electrical appliances (hair dryer, telephone, radio, etc.) within
0 inches (1524mm) of this unit.
!WARNING: Risk of hyperthermia and possible drowning. People using medications and/or having adverse
medical history should consult a physician before using this product.
!WARNING: Risk of personal injury. Do not overfill unit before entering. Entering tub when filled more than 2/
can cause overflow and slippery conditions. Exercise caution when entering and exiting.
!WARNING: No Food or Alcoholic Beverages. Use of your bathtub immediately after meals is not
recommended. Avoid alcohol consumption before or during bathing. Alcoholic beverages can cause drowsiness or hyperthermia resulting in loss of consciousness or even drowning.
!WARNING: Pregnancy. If you are or think you may be pregnant, consult your physician before using the bathtub.
Never drop or insert any object into any opening.
Use this unit only for its intended use as described in this manual. Do not use any attachments not recommended by American Standard.
The unit must be connected only to a supply circuit that is properly protected by a ground-fault circuit-interrupter (GFCI). Such a GFCI should be provided by the installer and should be tested on a routine basis. To test the GFCI, push the test button. The GFCI should interrupt power. Push the reset button. Power should be restored. If the GFCI fails to operate in this manner, the GFCI is defective. If the GFCI interrupts power to the bathtub without the test button being pushed, a ground current is flowing, indicating the possibility of an electric shock. Do not use this air bath. Disconnect the air bath and have the problem corrected by a licensed electrician before using.
SAVE THESE INSTRUCTIONS
|
754072-100 |
General Installation Information
Carefully uncrate and inspect your new bath for any shipping damage. If such damage is found, report it to your vendor immediately. After inspection and during installation, protect the bath from construction damage. Before installation, and before enclosing with wallboard, tile, etc., the bath must be filled with water and operated to check for leaks that may have resulted from shipping damage or mishandling! Do not make unauthorized modifications to the air bath system. This could adversely affect the safety and performance of the air bath and void the warranty. Do not handle or move the air bath by the air blower or piping system. Fittings (bath filler, shower arm, etc.) are not provided with the bath and must be ordered separately. Framing and enclosing materials are provided by others.
For electrical requirements, refer to section titled “Air Bath Electrical Installation Instructions”.
Check for availability of optional American Standard wall tiling bead (required for recess installation). Protect all finished surfaces of the air bath during construction and installation using a drop cloth.
! WARNING: Do not lift air bath by the piping harness at any time.
List of Required Tools and Supplies:
Tools |
Supplies |
||
• |
Level |
• |
Nails |
• Tape Measure |
• Putty |
||
• |
Pipe Wrench |
• |
Caulking (waterproof) |
• |
Slip Joint Pliers |
• |
1 x 4 Stringers |
• |
Screw Driver |
• |
Drop Cloth |
• |
Standard Woodworking Tools |
• |
Cement, Plaster, Grout |
•Personal Safety Equipment
•Caulking Gun
LIST OF OPTIONAL COMPONENTS (NOT INCLUDED):
|
|
Optional Components |
Required Components |
|
|
|
(Not Included) |
(Not Included) |
|
Description |
Model Number |
|
|
|
Apron |
Tile Bead |
Drain |
||
|
|
Kit |
Kit |
(Specify Finish) |
|
|
|
|
|
Evolution™ 5' x 2" |
2422V.0 C |
2 1.01 |
751755-100 |
15 .205.XXX* |
|
|
|
|
|
Evolution™ 5' x " |
2771V.0 C |
2 1.01 |
751755-100 |
15 .205.XXX* |
|
|
|
|
|
Evolution™ ' x " |
72 V.0 C |
271.01 |
751755-100 |
15 .205.XXX* |
|
|
|
|
|
Evolution™ 5' x 2" IA |
2425V.1 C - RHO |
INTEGRAL |
NOT |
15 .205.XXX* |
|
2425V.2 C - LHO |
|
APPLICABLE |
|
Evolution™ Oval |
2 45V.0 C |
2 .01 |
751755-100 |
15 .470.XXX |
|
|
|
|
|
* These models require American Standard Deep Soak Max Drain 15 .205
754072-100