Alto DPA-4000, DPA-2500 Service Manual

MODEL:DPA 2500/4000

www.altoproaudio.com

Version 2.0

CONTENTS

1. Introduction…………………………………………………………….2

2. Specification…………………………………………………………....3

3. Schematic Diagram……………………………………………………4

4. Wiring Diagram………………………………………………………..17

5. PCB Layout…………………………………………………………….19

6. Test Procedure & Test Result………………………………………25

7. Exploded Views & Mechanical Part List………………………….30

8. BOM…………………..…………………………………………………33

1. Introduction

ALTO MISTRAL amplifiers are series of innovative design power amplifiers. This series work

under high stability with great power supply in just 2-rack spaces. Air flow is from back to front

panel to keep in a nice air circulation inside the Rack. The automatic fan, which affects machines’

temperature includes various kinds of speed, therefore, this low-noise fan makes a good result in

cooling the heat from machines.

MISTRAL amplifiers include 2 independent channels with separate protection system and

power supply. The independent protection system avoids opening circuit, short, wrong loading or

over-heating. The special-designed protective system applies automatically restarting functions

upon the default status and then goes back to normal.

All electronic inputs equip standard power connectors. And all inputs are electronic balanced,

with hi-quality transformer, MISTRAL amplifiers provide an outstanding performance in any

conditions.

z Innovative design and high stability power amplifiers.

z Fan-cooled AB class high power amplifier in 19”rack, 2Usize

z Rugged amplifiers in a strong, compact chassis.

z 2 independent channels with separate protection system and power supply

z smart-designed protection system for auto re-operation after fault.

z Auto-adjusting speed fan.

z 4LEDs for operation/protection, limit, power on and clip

z HIGH-CURRENT TOROIDAL TRANSFORMER DESIGNED FOR HIGH POWER AT 2

Ohms with low noise.

z Independent DC and thermal overload protection on each channel.

z IEC standard power connectors.

z Binding post and NEUTRIK® SPEAKON outputs power connectors.

z Balanced XLR inputs/ parallel outputs.

2

2. Specification

Output power DPA2500 DPA 4000

20Hz-20KHz @0.1% THD, SCD MODE

8Ohms per channel(EIAJ) 450W 625W

4Ohms per channel (EIAJ) 700W 1000W

Bridge MONO mode

8Ohms ,1KHz, 0.1% THD 1400W 2000W

Distortion (SMPTE-IM) <0.05%

Frequency response 20Hz-20KHz=/-0.1dB, -3dB points:10Hz-60Hz

Damping factor ,1 kHz and below >300 at 8 Ohms

Signal to noise ,20Hz`20KHz 102dB

Voltage Gain 40 Χ(32dB)

Input sensitivity @4Ohms 1Vrms

Input clipping 10Vrms(+22dB)

Input impedance 10kOhms unbalanced, 20k Ohms balanced 56(36dB)

Controls

Front :AC switch ,CH1&CH2 Gain knobs
Rear :Limiter bridge selector

Power-on : Blue LED

Indicators (1per channel)

Operation/Protection: Dual Color(green/red LED)
Limit: Red LED
Clip: Red LED

Input: Active balanced XLR

Connectors, each channel

Parallel output: XLR
Output: NEUTRIK speaker and binding posts

Cooling Continuously variable-speed fan, rear-to front air flow

Load protection

On/off muting, DC-fault load grounding relay, internal
fault fuses.

Power requirements 200-240(100-120)VAC 50-60Hz

Dimensions

19”(48.3cm) rack mounting, 3.5”(8.9cm) tall (2rackspaces)

15.9”(40cm)deep (rack mounting to rear support ears

weight 18.1kg (Net) 20.5kg (Net)

3

)

7654321

8

D

C

XLR FEMALE90

XLR MALE90

(PARALLEL OUTPUT)

B

A

R1_58
68K 1/2W

CH1 BILED2

CH1 CLI P-

+15V

D1_1

ZD15V1.3W

GND1

7

C1_12

N/C

GND1

D1_4

-15V

R1_11

15K SPEAKERS BUS

C1_9
0R

3
2
1

C1_8

220uF/25V

C1_11

560pF/50 cer

R1_17

NTC 50R

C1_45

220uF/25V

R1_64

15K

1

4

3

R1_15
3K3 10W

R1_14
820R

D1_7

ZD5V6 1/2W

D1_5

1N4936

D1_6

1N4936

R1_16

TRIMMER 100R

R1_18
820R

D1_8

ZD5V6 1/2W

R1_19
3K3 10W

V1+

84

V1-

VAC FAN1-CH1

D1_27

(1.5A 200V)

W2 -0 4

2

-V_FAN_CH1

VAC FAN2-CH1

D1_9

1N4148

MJE15032

D1_11
0R

R1_21

TRIMMER 1K

R1_20

TRIMMER 1K

D1_12
0R

Q1_2

MJE15033

D1_10
1N4148

U1_1C

NJM4580L

C1_42

470uF/35V

Q1_1

R1_62

5R6 1W

R1_22

5R6 1W

R1_1

1K8

V1+

84

V1-

R1_25
22R 1W

TP1_3

TP1_6

R1_32
22R 1W

U1_2C

NJM4580L

U1_4

LM317T

12

R1_28

0.22 5W

Q1_5 Q1_6

4xTR-93P(ALTO)

12x1000uF/100V

C1_15

C1_17

D1_13

C1_13

3.3nF/50 cer

GND1

C1_14

3.3nF/50 cer

1000uF/100V

C1_16

1N4148

C1_40

22nF/100V poly

D1_14

1N4148

C1_18

4xTR-94N(ALTO)

Q1_9 Q1_10 Q1_11 Q1_12

R1_33

R1_34

0.22 5W

C1_44

100nF/50 cer

R1_35

0.22 5W

C1_43

10uF/63

0.22 5W

R1_3

NTC 100R

R1_2
150R

R1_29

0.22 5W

C1_19

C1_20

R1_36

0.22 5W

D1_28
1N4004

R1_30

0.22 5W

Q1_7 Q1_8

C1_21

C1_23

R1_23

1K 5W

R1_24

1K 5W

C1_22

C1_24

FAN OUT CH1

12V

JP1_14

2P2.5

2
1

FAN

C1_25

C1_26

GND1

D1_15
1N5402

GND1

D1_16
1N5402

R1_31

0.22 5W

OUTPUT STAGE_A

+83V_A

1 2

1 2

-83V_A

GND1

K1_1

R1_39
5R6 2W

L1_1

2uH 10A

R1_40
12R 5W

GND1

5mm RED LED

Q1_15

MPSA92

D1_19
W2 -0 4

(1.5A 200V)

R1_44
6K8 1W

R1_41
12R 5W

C1_31
68nF/250V poly

CH1 BILED1

D1_17

R1_42

330K

Q1_16

MPSA92

R1_43

100K

RELAY VBS SERI ES

D1_23
1N4004

ON/PROTECTION

R1_46

100K

R1_47 47K

D1_20

1N4004

R1_48

330K

C1_32
10uF/63

R1_45
1K5

RELAY POWER1

CH1 OUTPUT

GND1

D1_18

ZD7V5 1/2W

CH1 BILED2

C1_33
47uF/63V

C1_ 34

220uF/16V NP

D1_22

1N4004

GND1

R1_63

1K 3W

CN-P CB6. 3

CH1 OUTPUT

SPEAKON PCB

JP1_2

CN-P CB6. 3

+83V_A

R1_49
10K 5W

R1_50
PTC 65R

100R/10K

Q1_17

MPSA42

TURN ON DELAY

D1_21

ZD36V 1W

JP1_1

MISTRAL2500 Schematic Diagram 1 of 2

CH2 AMPLIFIER
MIS25-CH2.S CH

Titel

ALTO MISTRAL2500-CH1 DRIVE

PCB# MIS4000.PCB

Size

Date:
File:

A2

MISTRAL2500

9-Apr-2004
MIS25-CH1 Sch

Sheet
Drawn By:

1
2

TO

1
2

RevisionModel No:

KEVIN LIN

D

1+

1-

C

B

A

VER031212

21of

CH1 INPUT

J1_1

J1_2

R1_53

8K2

(CH1 LIMITER MODE)

1
3
2

2
3
1

GND1

V1+

C1_35

56pF/50 cer

2

3

GND1

NJM4560L

(1.5A 200V)

S1_1A

3

1

GND1

2 1

SW 2C_2P

CH1 I N-

CH1 I N+

FCT TAUD6 00

(OPTION)

D1_25

1N4004

2

5

4

T1_1

GND1 GND1

CH1 INSERT CONNECTOR

R1_54

10K

1

U1_2A

D1_24

W2 -0 4

2

J1_4
3P2.5

GND1

1

3

J1_5
3P2.5

1 2
3 4
5 6
7 8
9 10

JP1_3

HEADER 5X2

-V_FAN_CH1

VAC FAN1-CH1

6

5

GND1

U1_2B

NJM4560L

R1_52

47R

C1_37

220uF/16V

CH1 CLI P+

R1_9
100R

GND1

CH1 CLI P-

C1_1

RB1_1A

6
9
7

8

22uF/50V

22uF/50V

4x10K

RB1_1C

4x10K

C1_2

C1_4

100pF/50 cer

CH1 INSERT IN

CH1 I NSE RT OUT

D1_26

2 1

1N4004

BRIDGED

6

4

NORMAL

GND1 GND1

HEADER 5X2

7

R1_55

330R

(FTR VT90N1 VACTEC+)

CH1 PHOTO COUPLER

D1_2

W2 -0 4

(1 5A 200V)

2

3

RB1_1D
4x10K

GND1

GND1

47uF/35V

V1-

S1_1B

SWITCH 2C_2P

5

1 2
3 4
5 6
7 8
9 10

JP1_15

-83V_A

+83V_A

CH1 BILED1

CH1 CLI P+

R1_57

100R

U1_5

VTL5C2

41

2 3

GND1

C1_3

100pF/50 cer

RB1_1B

4x10K

1

U1_1A
NJM4560L

C1_6

R1_5

3P-2.5

CH1 GAIN

CH1 BR IDGE S WITCH

FAN OUT CH1

VAC FAN2-CH1

56pF/50 cer

C1_5

47uF/35V

3
2
1

C1_36

GND1

GND1

R1_7 4K7

R1_6
4K7

R1_56

82K 1/2W

R1_51

100K

GND1

R1_8

10K

1 2
3 4
5 6
7 8
9 10

JP1_16

HEADER 5X2

CH1 P ILOTLIM

56pF/50 cer

6

5

U1_1B

NJM4560L

R1_10

V1+

C1_7

R1_13
68R

C1_38

1.5nF/250 cer

ZD15V1.3W

V1-

C1_10

27pF/50 cer

330R

GND1

TO USE ONLY CH2 PUT JUMPER ON PIN 6&8

JP1_5

CN-P CB6. 3

2
1

RECTIFIER BRIDGE1+

JP1_6
CN-P CB6. 3

2
1

COM1

JP1_7

CN-P CB6. 3

2
1

RECTIFIER BRIDGE1-

JP1_8

CN-P CB6. 3

2
1

AC INPUT

1 2 3 4 5 6 78

OUTPUT STAGE A

RELAY POWER1

JP1_9
JEF-505

1
2

JP1_11
JEF-505

1
2

FUSE1-1

FUSE1-2

6.3x32 FUSE HOLDER

16AT

16AT

JP1_10
JEF-505

1
2

JP1_12
JEF-505

1
2

+83V_A

-83V_A

JP1_13

HEADER 3

7654321

8

D

C

XLR FEMALE90

XLR MALE90

(PARALLEL OUTPUT)

B

A

R2_58
68K 1/2W

CH2 BILED2

CH2 CLI P-

+15V

D2_1

ZD15V1.3W

GND2

7

C2_12

N/C

GND2

D2_4

-15V

R2_11

15K SPEAKERS BUS

C2_9

0R

3
2
1

C2_8

220uF/25V

C2_11

560pF/50 cer

R2_17

NTC 50R

C2_45

220uF/25V

1

4

3

R2_15
3K3 10W

R2_14
820R

D2_7

ZD5V6 1/2W

D2_5

1N4936

D2_6

1N4936

R2_16

TRIMMER 100R

R2_18
820R

D2_8

ZD5V6 1/2W

R2_19
3K3 10W

V2+

84

V2-

VAC FAN1

D2_27

W2 -0 4

(1 5A 200V)

2

-V_FAN_CH2

VAC FAN2

D2_9

1N4148

MJE15032

D2_11

0R

R2_21

TRIMMER 1K

R2_20

TRIMMER 1K

D2_12

0R

Q2_2

MJE15033

D2_10
1N4148

U2_1C

NJM4580L

C2_42

470uF/35V

Q2_1

R2_62

5R6 1W

R2_22

5R6 1W

R2_1

1K8

V2+

84

V2-

R2_25
22R 1W

TP2_3

TP2_6

R2_32
22R 1W

U2_2C

NJM4580L

U2_4

LM317T

12

R2_28

0.22 5W

Q2_5

4xTR-93P(ALTO)

12x1000uF/100V

C2_15

C2_17

D2_13

C2_13

3.3nF/50 cer

GND2

C2_14

3.3nF/50 cer

1000uF/100V

C2_16

1N4148

C2_40

22nF/100V poly

D2_14

1N4148

C2_18

4xTR-94N(ALTO)

Q2_9 Q2_10 Q2_11 Q2_12

R2_33

R2_34

0.22 5W

C2_44

100nF/50 cer

R2_35

0.22 5W

C2_43

10uF/63

0.22 5W

R2_3

NTC 100R

R2_2
150R

R2_29

0.22 5W

Q2_6

C2_19

C2_20

R2_36

0.22 5W

D2_28
1N4004

R2_30

0.22 5W

Q2_7

C2_21

C2_23

R2_23

1K 5W

R2_24

1K 5W

C2_22

C2_24

FAN OUT CH2

12V

JP2_14

2P2.5

2
1

FAN

R2_31

0.22 5W

Q2_8

GND2

C2_25

OUTPUT STAGE_B

C2_26

D2_15
1N5402

GND2

D2_16
1N5402

+83V_B

K2_1

RELAY VBS SERI ES

CH2 OUTPUT

R2_39
5R6 2W

1 2

L2_1

1 2

-83V_B

2uH 10A

MPSA92

D2_19
W2 -0 4

(1.5A 200V)

GND2

R2_40
12R 5W

C2_31
68nF/250V poly

GND2

CH2 BILED1

D2_17

5mm RED LED

Q2_15

MPSA92

R2_44
6K8 1W

R2_41
12R 5W

R2_42

330K

Q2_16

R2_43

100K

D2_23
1N4004

ON/PROTECTION

R2_46

100K

D2_20

1N4004

C2_32
10uF/63

R2_45
1K5

RELAY POWER2

R2_47 47K

R2_48

330K

GND2

D2_18

ZD7V5 1/2W

CH2 BILED2

C2_33
47uF/63V

C2_ 34

220uF/16V NP

D2_22

1N4004

GND2

+83V_B

Q2_17

MPSA42

TURN ON DELAY

D2_21

ZD36V 1W

R2_63

1K 3W

MISTRAL2500 Schematic Diagram 2 of 2

Titel

ALTO MISTRAL2500-CH2 DRIVE

PCB# MIS4000.PCB

Size

Date:
File:

A2

MISTRAL2500

9-Apr-2004
MIS25-CH2 Sch

Sheet
Drawn By:

JP2_1

CN-P CB6. 3

1

2+

2

CH2 OUTPUT

TO

SPEAKON PCB

1

2-

2

JP2_2

CN-P CB6. 3

R2_49
10K 5W

R2_50
PTC 65R

100R/10K

RevisionModel No:

VER031212

21of

KEVIN LIN

D

C

B

A

CH2 LIMITER MODE

CH2 INPUT

1
3
2

J2_1

2
3
1

J2_2

V2+

R2_53

8K2

GND2

(CH1 LIMITER MODE)

CH2 I N-

CH2 I N+

FCT TAUD6 00

(OPTION)

GND2

2 1

D2_25

1N4004

GND2

R2_54

10K

R2_52

47R

1

2

GND2

1

6
9
7

8

3

1 2
3 4
5 6
7 8
9 10

JP2_3

HEADER 5X2

CH2 BR IDGE

-V_FAN_CH2

VAC FAN1

6

5

22uF/50V

22uF/50V

C2_35

56pF/50 cer

2

3

U2_2A

NJM4560L

D2_24
W2 -0 4

(1 5A 200V)

S2_1A

3

1

SW 2C_2P

J2_4
3P2.5

GND2

2

5

4

T2_1

J2_5
3P2.5

GND2 GND2

CH2 INSERT CONNECTOR

7

U2_2B

NJM4560L

R2_55

330R

C2_37

220uF/16V

(FTR VT90N1 VACTEC+)

CH2 PHOTO COUPLER

CH2 CLI P+

R2_9
100R

GND2

1 2
3 4
5 6
7 8
9 10

JP2_15

W2 -0 4

(1 5A 200V)

2

3

RB2_1D
4x10K

GND2

V2-

S2_1B

SWITCH 2C_2P

5

CH2 CLI P-

C2_1

RB2_1A

4x10K

RB2_1C

4x10K

C2_2

C2_4

100pF/50 cer

CH2 INSERT IN

CH2 I NSE RT OUT

D2_26

2 1

1N4004

BRIDGED

6

4

NORMAL

GND2 GND2

HEADER 5X2

-83V_B

+83V_B

R2_57

100R

U2_5

VTL5C2

41

D2_2

C2_3

100pF/50 cer

RB2_1B

4x10K

C2_6

47uF/35V

CH2 GAIN

CH2 BILED1

CH2 CLI P+

56pF/50 cer

2 3

GND2

C2_5

47uF/35V

1

U2_1A
NJM4560L

3
2
1

R2_5

3P-2.5

CH2 LIMITER MODE

FAN OUT CH2

VAC FAN2

C2_36

GND2

GND2

R2_7 4K7

R2_6
4K7

R2_56

82K 1/2W

R2_51

100K

GND2

R2_8

10K

1 2
3 4
5 6
7 8
9 10

JP2_16

HEADER 5X2

CH2 P ILOTLIM

56pF/50 cer

6

5

U2_1B

NJM4560L

R2_10

V2+

C2_7

R2_13
68R

C2_38

1.5nF/250 cer

ZD15V1.3W

V2-

C2_10

27pF/50 cer

330R

GND2

TO USE ONLY CH2 PUT JUMPER ON PIN 6&8

JP2_5

CN-P CB6. 3

2
1

RECTIFIER BRIDGE2+

JP2_6
CN-P CB6. 3

2
1

COM2

JP2_7

CN-P CB6. 3

2
1

RECTIFIER BRIDGE2-

JP2_8

CN-P CB6. 3

2
1

AC INPUT

1 2 3 4 5 6 78

OUTPUT STAGE B

RELAY POWER2

JP2_9
JEF-505

1
2

JP2_11
JEF-505

1
2

FUSE2-1

16AT

FUSE2-2

6.3x32 FUSE HOLDER

16AT

JP2_10
JEF-505

1
2

JP2_12
JEF-505

1
2

+83V_B

-83V_B

JP2_13

HEADER 3

7654321

8

D

C

XLR FEMALE90

XLR MALE90

(PARALLEL OUTPUT)

B

A

R1_58
68K 1/2W

CH1 BILED2

CH1 CLI P-

+15V

D1_1

ZD15V1.3W

GND1

7

C1_12

N/C

GND1

D1_4

-15V

C1_10

27pF/50 cer

R1_11

15K SPEAKERS BUS

C1_9
0R

3
2
1

C1_8

220uF/25V

C1_11

560pF/50 cer

R1_17

NTC 50R

C1_45

220uF/25V

R1_64

15K

1

4

3

R1_15
4K8 10W

R1_14
820R

D1_7

ZD5V6 1/2W

D1_5

1N4936

D1_6

1N4936

R1_16

TRIMMER 100R

R1_18
820R

D1_8

ZD5V6 1/2W

R1_19
4K8 10W

V1+

84

V1-

VAC FAN1-CH1

D1_27

(1.5A 200V)

W2 -0 4

2

-V_FAN_CH1

VAC FAN2-CH1

D1_9

1N4148

MJE15032

D1_11

0R

5R6 1W

R1_21

TRIMMER 2K2

5R6 1W

R1_20

TRIMMER 2K2

D1_12

0R

Q1_2

MJE15033

D1_10
1N4148

U1_1C

NJM4580L

C1_42

470uF/35V

Q1_1

R1_62

R1_22

R1_1

1K8

V1+

84

V1-

R1_25
22R 1W

TP1_3

TP1_6

R1_32
22R 1W

U1_2C

NJM4580L

U1_4

LM317T

12

R1_26

0.22 5W

Q2_3

Q2_4

0.22 5W

0.22 5W

Q1_5 Q1_6 Q1_7 Q1_8

R1_28

R1_27

5xTR-93P(ALTO)

16x470uF/160V

C1_15

C1_17

D1_13

C1_13

3.3nF/50 cer

GND1

C1_14

3.3nF/50 cer

470uF/160V

C1_16

1N4148

C1_40

22nF/100V poly

D1_14

1N4148

C1_18

5xTR-94N(ALTO)

Q1_9 Q1_10 Q1_11 Q1_12

R1_33

R1_34

0.22 5W

C1_44

100nF/50 cer

R1_35

0.22 5W

C1_43

10uF/63

0.22 5W

R1_3

NTC 100R

R1_2
150R

R1_29

0.22 5W

C1_19

C1_20

R1_36

0.22 5W

D1_28
1N4004

R1_30

0.22 5W

C1_21

C1_23

R1_23

1K5 5W

R1_24

1K5 5W

C1_22

C1_24

Q1_13

R2_37

0.22 5W

FAN OUT CH1

12V

JP1_14

2P2.5

2
1

FAN

R1_31

0.22 5W

GND1

C1_25

OUTPUT STAGE_A

C1_26

Q1_14

R2_38

0.22 5W

D1_15
1N5402

C1_27 C1_29

C1_28 C1_30

GND1

D1_16
1N5402

+83V_A

1 2

1 2

-83V_A

GND1

K1_1

R1_39
5R6 2W

L1_1

2uH 10A

R1_40
12R 5W

GND1

5mm RED LED

Q1_15

MPSA92

D1_19
W2 -0 4

(1.5A 200V)

R1_44
6K8 1W

R1_41
12R 5W

C1_31
68nF/250V poly

CH1 BILED1

D1_17

R1_42

330K

Q1_16

MPSA92

R1_43

100K

RELAY VBS SERI ES

D1_23
1N4004

ON/PROTECTION

R1_46

100K

R1_47 47K

D1_20

1N4004

R1_48

330K

C1_32
10uF/63

R1_45
1K5

RELAY POWER1

CH1 OUTPUT

GND1

D1_18

ZD7V5 1/2W

CH1 BILED2

C1_33
47uF/63V

C1_ 34

220uF/16V NP

D1_22

1N4004

GND1

R1_63

1K 3W

CN-P CB6. 3

CH1 OUTPUT

SPEAKON PCB

JP1_2

CN-P CB6. 3

+83V_A

R1_49
10K 5W

R1_50
PTC 65R

100R/10K

Q1_17

MPSA42

TURN ON DELAY

D1_21

ZD36V 1W

JP1_1

MISTRAL4000 Schematic Diagram 1 of 2

CH2 AMPLIFIER
MIS40-CH2.S CH

Titel

ALTO MISTRAL4000-CH1 DRIVE

PCB# MIS4000.PCB

Size

A2

MISTRAL4000

9-Apr-2004

Date:
File:

MIS40-CH1 Sch

Sheet
Drawn By:

1
2

TO

1
2

RevisionModel No:

KEVIN LIN

D

1+

1-

C

B

A

VER031212

21of

CH1 INPUT

J1_1

J1_2

R1_53

8K2

(CH1 LIMITER MODE)

1
3
2

2
3
1

GND1

V1+

C1_35

56pF/50 cer

2

3

GND1

NJM4560L

(1.5A 200V)

S1_1A

3

1

GND1

2 1

SW 2C_2P

CH1 I N-

CH1 I N+

FCT TAUD6 00

(OPTION)

D1_25

1N4004

2

5

4

T1_1

GND1 GND1

CH1 INSERT CONNECTOR

R1_54

10K

1

U1_2A

D1_24

W2 -0 4

2

J1_4
3P2.5

GND1

1

3

J1_5
3P2.5

1 2
3 4
5 6
7 8
9 10

JP1_3

HEADER 5X2

-V_FAN_CH1

VAC FAN1-CH1

6

5

GND1

U1_2B

NJM4560L

R1_52

47R

C1_37

220uF/16V

CH1 CLI P+

R1_9
100R

GND1

CH1 CLI P-

C1_1

RB1_1A

6
9
7

8

22uF/50V

22uF/50V

4x10K

RB1_1C

4x10K

C1_2

C1_4

100pF/50 cer

CH1 INSERT IN

CH1 I NSE RT OUT

D1_26

2 1

1N4004

BRIDGED

6

4

NORMAL

GND1 GND1

HEADER 5X2

7

R1_55

330R

(FTR VT90N1 VACTEC+)

CH1 PHOTO COUPLER

D1_2

W2 -0 4

(1 5A 200V)

2

3

RB1_1D
4x10K

GND1

GND1

47uF/35V

V1-

S1_1B

SWITCH 2C_2P

5

1 2
3 4
5 6
7 8
9 10

JP1_15

-83V_A

+83V_A

CH1 BILED1

CH1 CLI P+

R1_57

100R

U1_5

VTL5C2

41

2 3

GND1

C1_3

100pF/50 cer

RB1_1B

4x10K

1

U1_1A
NJM4560L

C1_6

R1_5

3P-2.5

CH1 GAIN

CH1 BR IDGE S WITCH

FAN OUT CH1

VAC FAN2-CH1

56pF/50 cer

C1_5

47uF/35V

3
2
1

C1_36

GND1

GND1

R1_7 4K7

R1_6
4K7

R1_56

82K 1/2W

R1_51

100K

GND1

R1_8

10K

1 2
3 4
5 6
7 8
9 10

JP1_16

HEADER 5X2

CH1 P ILOTLIM

56pF/50 cer

6

5

U1_1B

NJM4560L

R1_10

V1+

C1_7

R1_13
68R

C1_38

1.5nF/250 cer

ZD15V1.3W

V1-

330R

GND1

TO USE ONLY CH2 PUT JUMPER ON PIN 6&8

JP1_5

CN-P CB6. 3

2
1

RECTIFIER BRIDGE1+

JP1_6
CN-P CB6. 3

2
1

COM1

JP1_7

CN-P CB6. 3

2
1

RECTIFIER BRIDGE1-

JP1_8

CN-P CB6. 3

2
1

AC INPUT

1 2 3 4 5 6 78

OUTPUT STAGE A

RELAY POWER1

JP1_9
JEF-505

1
2

JP1_11
JEF-505

1
2

FUSE1-1

FUSE1-2

6.3x32 FUSE HOLDER

10AT

10AT

JP1_10
JEF-505

1
2

JP1_12
JEF-505

1
2

+83V_A

-83V_A

JP1_13

HEADER 3

7654321

8

D

C

XLR FEMALE90

XLR MALE90

(PARALLEL OUTPUT)

B

A

R2_58
68K 1/2W

CH2 BILED2

CH2 CLI P-

+15V

D2_1

ZD15V1.3W

GND2

7

C2_12

N/C

GND2

D2_4

-15V

C2_10

27pF/50 cer

R2_11

15K SPEAKERS BUS

C2_9
0R

3
2
1

C2_8

220uF/25V

C2_11

560pF/50 cer

R2_17

NTC 50R

C2_45

220uF/25V

1

4

3

R2_15
4K8 10W

R2_14
820R

D2_7

ZD5V6 1/2W

D2_5

1N4936

D2_6

1N4936

R2_16

TRIMMER 100R

R2_18
820R

D2_8

ZD5V6 1/2W

R2_19
4K8 10W

V2+

84

V2-

VAC FAN1

D2_27

W2 -0 4

(1 5A 200V)

2

-V_FAN_CH2

VAC FAN2

D2_9

1N4148

MJE15032

D2_11

0R

5R6 1W

R2_21

TRIMMER 2K2

5R6 1W

R2_20

TRIMMER 2K2

D2_12

0R

Q2_2

MJE15033

D2_10
1N4148

U2_1C

NJM4580L

C2_42

470uF/35V

Q2_1

R2_62

R2_22

R2_1

1K8

V2+

84

V2-

R2_25
22R 1W

TP2_3

TP2_6

R2_32
22R 1W

U2_2C

NJM4580L

U2_4

LM317T

12

R2_26

0.22 5W

Q2_3

Q2_4

0.22 5W

0.22 5W

Q2_5 Q2_6 Q2_7 Q2_8

R2_28

R2_27

5xTR-93P(ALTO)

12x470uF/160V

C2_15

C2_17

D2_13

C2_13

3.3nF/50 cer

GND2

C2_14

3.3nF/50 cer

470uF/160V

C2_16

1N4148

C2_40

22nF/100V poly

D2_14

1N4148

C2_18

5xTR-94N(ALTO)

Q2_9 Q2_10 Q2_11 Q2_12

R2_33

R2_34

0.22 5W

C2_44

100nF/50 cer

R2_35

0.22 5W

C2_43

10uF/63

0.22 5W

R2_3

NTC 100R

R2_2
150R

R2_29

0.22 5W

C2_19

C2_20

R2_36

0.22 5W

D2_28
1N4004

R2_30

0.22 5W

C2_21

C2_23

R2_23

1K5 5W

R2_24

1K5 5W

C2_22

C2_24

Q2_13

R2_37

0.22 5W

FAN OUT CH2

12V

JP2_14

2P2.5

2
1

FAN

R2_31

0.22 5W

GND2

C2_25

OUTPUT STAGE_B

C2_26

Q2_14

R2_38

0.22 5W

D2_15
1N5402

C2_27 C2_29

C2_28 C2_30

GND2

D2_16
1N5402

+83V_B

K2_1

RELAY VBS SERI ES

CH2 OUTPUT

R2_39
5R6 2W

1 2

L2_1

1 2

-83V_B

2uH 10A

MPSA92

D2_19
W2 -0 4

(1.5A 200V)

GND2

R2_40
12R 5W

C2_31
68nF/250V poly

GND2

CH2 BILED1

D2_17

5mm RED LED

Q2_15

MPSA92

R2_44
6K8 1W

R2_41
12R 5W

R2_42

330K

Q2_16

R2_43

100K

D2_23
1N4004

ON/PROTECTION

R2_46

100K

D2_20

1N4004

C2_32
10uF/63

R2_45
1K5

RELAY POWER2

R2_47 47K

R2_48

330K

GND2

D2_18

ZD7V5 1/2W

CH2 BILED2

C2_33
47uF/63V

C2_ 34

220uF/16V NP

D2_22

1N4004

GND2

+83V_B

Q2_17

MPSA42

TURN ON DELAY

D2_21

ZD36V 1W

R2_63

1K 3W

MISTRAL4000 Schematic Diagram 2 of 2

Titel

ALTO MISTRAL4000-CH2 DRIVE

PCB# MIS4000.PCB

Size

Date:
File:

A2

MISTRAL4000

9-Apr-2004
MIS40-CH2 Sch

Sheet
Drawn By:

JP2_1

CN-P CB6. 3

1

2+

2

CH2 OUTPUT

TO

SPEAKON PCB

1

2-

2

JP2_2

CN-P CB6. 3

R2_49
10K 5W

R2_50
PTC 65R

100R/10K

RevisionModel No:

VER031212

21of

KEVIN LIN

D

C

B

A

CH2 LIMITER MODE

CH2 INPUT

1
3
2

J2_1

2
3
1

J2_2

V2+

R2_53

8K2

GND2

(CH1 LIMITER MODE)

CH2 I N-

CH2 I N+

FCT TAUD6 00

(OPTION)

GND2

2 1

D2_25

1N4004

GND2

R2_54

10K

R2_52

47R

1

2

GND2

1

6
9
7

8

3

1 2
3 4
5 6
7 8
9 10

JP2_3

HEADER 5X2

CH2 BR IDGE

-V_FAN_CH2

VAC FAN1

6

5

22uF/50V

22uF/50V

C2_35

56pF/50 cer

2

3

U2_2A

NJM4560L

D2_24
W2 -0 4

(1 5A 200V)

S2_1A

3

1

SW 2C_2P

J2_4
3P2.5

GND2

2

5

4

T2_1

J2_5
3P2.5

GND2 GND2

CH2 INSERT CONNECTOR

7

U2_2B

NJM4560L

R2_55

330R

C2_37

220uF/16V

(FTR VT90N1 VACTEC+)

CH2 PHOTO COUPLER

CH2 CLI P+

R2_9
100R

GND2

1 2
3 4
5 6
7 8
9 10

JP2_15

W2 -0 4

(1 5A 200V)

2

3

RB2_1D
4x10K

GND2

V2-

S2_1B

SWITCH 2C_2P

5

CH2 CLI P-

C2_1

RB2_1A

4x10K

RB2_1C

4x10K

C2_2

C2_4

100pF/50 cer

CH2 INSERT IN

CH2 I NSE RT OUT

D2_26

2 1

1N4004

BRIDGED

6

4

NORMAL

GND2 GND2

HEADER 5X2

-83V_B

+83V_B

R2_57

100R

U2_5

VTL5C2

41

D2_2

C2_3

100pF/50 cer

RB2_1B

4x10K

C2_6

47uF/35V

CH2 GAIN

CH2 BILED1

CH2 CLI P+

56pF/50 cer

2 3

GND2

C2_5

47uF/35V

1

U2_1A
NJM4560L

3
2
1

R2_5

3P-2.5

CH2 LIMITER MODE

FAN OUT CH2

VAC FAN2

C2_36

GND2

GND2

R2_7 4K7

R2_6
4K7

R2_56

82K 1/2W

R2_51

100K

GND2

R2_8

10K

1 2
3 4
5 6
7 8
9 10

JP2_16

HEADER 5X2

CH2 P ILOTLIM

56pF/50 cer

6

5

U2_1B

NJM4560L

R2_10

V2+

C2_7

R2_13
68R

C2_38

1.5nF/250 cer

ZD15V1.3W

V2-

330R

GND2

TO USE ONLY CH2 PUT JUMPER ON PIN 6&8

JP2_5

CN-P CB6. 3

2
1

RECTIFIER BRIDGE2+

JP2_6
CN-P CB6. 3

2
1

COM2

JP2_7

CN-P CB6. 3

2
1

RECTIFIER BRIDGE2-

JP2_8

CN-P CB6. 3

2
1

AC INPUT

1 2 3 4 5 6 78

OUTPUT STAGE B

RELAY POWER2

JP2_9
JEF-505

1
2

JP2_11
JEF-505

1
2

FUSE2-1

10AT

FUSE2-2

6.3x32 FUSE HOLDER

10AT

JP2_10
JEF-505

1
2

JP2_12
JEF-505

1
2

+83V_B

-83V_B

JP2_13

HEADER 3

D

C

B

A

VER030710

11of

C.C.LIN

RevisionModel No:

4

Drawn By:

Sheet

2

MISTRAL4000

2

D1_30

1 2

321

D2_30

1 2

3mm YELLOW LED

3mm YELLOW LED

D1_3

LIMITER

LIMITER

1 2

D2_3

1 2

D1_29

CLIP

3mm RE D LED

D2_29

CLIP

3mm RE D LED

POWER ON

3mm BL UE LED

1 2

POWER ON

3mm BL UE LED

1 2

RED

D1_1

RED

D2_1

GREEN

1

1

2

2

GREEN

1

1

JP1_22

1 2

3 4

5 6

7 8

9 10

3mm R/G BLCOL LED

ON/PROTECTION

JP2_22

1 2

3mm R/G BLCOL LED

ON/PROTECTION

3 4

HEADER 5X2

5 6

7 8

9 10

HEADER 5X2

ALTO : MIST RAL4000 FP

9-Apr -2004

MIS40FP.Sch

A4

Titel

Size

File:

Date:

VR1_1

B50K

123

CN1_1

D

3P2.5

CN2_1

C

VR2_1

B50K

123

3P2.5

B

A

1 2 34

D

C

B

A

VER031206

11of

C.C.LIN

RevisionModel No:

4

Drawn By:

Sheet

MISTRAL4000

ALTO : MIST RAL4000 INPUT

9-Apr -2004

MIS40IN.Sch

A4

Titel

Size

File:

Date:

321

CN4

123

CN2

CON3

CN3

12345

CON5

123

CON3

123

CN1

CON3

PJ1

PHONEJACK2

1 2 34

D

C

B

A

D

C

B

A

VER030504

11of

KEVIN LIN

RevisionModel No:

4

Drawn By:

Sheet

K2 2

3 4

5 6

7 8

RELAY-2-24

1 2

C2_46

470uF/35V

12

MISTRAL4000

R2_67

R2_69

12R 5W

12R 5W

R2_68

R2_70

12R 5W

12R 5W

(AC 2)

COM1

BRIDGE1+

321

BD1

35A/200V

BRIDGE1-

BD2

BRIDGE2+

35A/200V

COM2

COM

BRIDGE2-

AC 1

R2_72

12R 5W

R2_71

12R 5W

TRANS-IN

D2_31

1N4004

R2_74

2K7 5W

R2_73

2K7 5W

SWITCH

1

2

P7

CN-PCB6.3

NEUTRAL

2

P8

ALTO MISTRAL4000 POWER BOARD

PCB# MIS40PWR.PCB

9-Apr-2004

MIS40PWR.Sch

A4

Titel

Size

File:

Date:

1

CN-PCB6.3

63V

P1

115V or 120V

1

2

P2

CN-PCB6.3

63V0V63V

1

2

CN-PCB6.3

TRANS-IN

0V

0V

63V

13.5V

0V

1. COMPONENTS WITH ARE SAFETY CRITICAL PARTS.

PT-MIS4000-E

T130℃

115V or 120V

1

2

1

P3

2

P4

CN-PCB6.3

P5

CN-PCB6.3

T130℃

0V

1

2

1

2

P6

CN-PCB6.3

CN-PCB6.3

CIRCUIT BRE AKER

USA:15A-125V

NEUTRAL

EUROPE:8A-230V

POWER SWITCH

1 2 3 4

LINE

GND

NEUT

IEC AC INLET

D

C

B

A

D

C

B

A

11of

VER030728

C C LIN

RevisionModel No:

4

Drawn By:

Sheet

CN2

9

1011121314151617181920

R2

4K7

R4

10K

TR2

BC560

5
4
3
2
1

CN3

CON5

5

321

R1

4K7

R3

+5VD

10K

TR1

BC560

4
3
2
1

CN4

CON5

+5VD

R6

10K

R5

10K

R7

10K

+5VD

R8

10K

2345678

GND

CN-HD10X2

DPA4000

DL11

SIGNAL

ALTO : DPA4000 Display Board 1

Titel

12-Apr-2004

DPA-DIS S ch

A4

Size

File:

Date:

RED GR

SW2

ENTER

SW1

UP

SW3

DOWN

GND

SW4

SELECT

C1

100N

+5VD

GND 1

DL1

DL4

DL5

DL6

DL7

DL10

VOL UME

HUM CANCEL

NOISE GATE

MULTICOMP

PRESETS

COMM

14

CN1

12345678910111213

DL8

DL9

EDIT

CH SEL

CN-HD7X2

GND

C2

10uF/16V

1 2 34

D

C

B

A

D

C

B

A

11of

VER030728

C C LIN

RevisionModel No:

4

Drawn By:

Sheet

DPA4000

12-Apr-2004

DPA-DIS2 Sch

ALTO : DPA4000 Display Board 2

A4

Titel

Size

File:

Date:

5
4
3
2

321

1

CN1

CON5

5
4
3
2
1

CN2

CON5

DL3

LED-7SEG-2

dp

5

g

A2

8

A1

3

DL2

LED-7SEG-2

A2

8

A1

3

10

f

9

e

1

d

2

c

4

b

6

a

7

dp

5

g

10

f

9

e

1

d

2

c

4

b

6

a

7

1 2 34

D

C

B

A

A

VER030728

11of

C C LIN

Revisio nModel No

Drawn By

Sheet

135

4

6

B

7291113

8

10

RELE

J7

12

16234

14

5

D

8

135791113

J3

2144106128

151719

182016

R12

1K5

R14

1K5

R16

1K5

C

R19

1K5

R22

1K5

R24

1K5

R26

J5

1K5

R28

1K5

DPA4000

R21

7654321

TO DSP Board

R13

1K5

R15

1K5

R17

1K5

R18

1K5

1K5

12-Apr-2004

TO DSP Board

TO DSP Board

R20

1K5

R23

1K5

R25

1K5

R27

1K5

R29

1K5

Titel

DPA PWR.Sch

ALTO DPA4000 -DSP_PWR

A4

Size

File

Date

TO RS-XXX Board

TO Display Board

2144106128

J2

13579

GND

5VD

182016

11

13

151719

TO Display Board

J4

135

8

4

10

6

729

GND

12

14

1627384

11

J6

13

GND

5VD

5

123

CN2

CON3

GND

D3

SF1BD4SF1B

D5

7805

Vin

Vout

GND

CN3

5VD

C8

C10

C12

-5VD

12345

SF1BD2SF1B

1000/25C91000/25

10/16

C11

10/16

100N

C13

100N

GND

5VD

6

CN-6P-90

GND

C14

100N

C15

100N

4 8

U1C

MC33078

4 8

U2C

MC33078

U4

7905

Vin

GND

Vout

-5VD

GND

TO DSP Board

-5VD

1 2 3 4 5 6 78

J1

TO DSP Board

1

U1A

22P

C2

R2

750R

2

R1

10K

C1

10/16

TO AMP Board

D8

1627384

5

AGND

R5

2K2

7

U1B

22P

MC33078

C4

R4

AGND

CN1

750R

6

R3

C3

10/16

1 2

3 4

5 6

7 8

3

10K

9 10

5

MC33078

HEADER 5X2

C5

AGND

AGND AGND

3

2

U2A

AGND

MC33078

1

RL1

R9

1K

22P

R6

10K

5VD

RELAY-2-24

D1

C7

C6

1N4148

100N

R7

2K2

5

6

U2B

7

AGND

AGND

MC33078

RELE

R10

10K

R11

10K

GND

Q2

BR15

GND

22P

R8

10K

U3

5VD

D

C

B

A

D

C

B

A

12345678910

VER030728

11of

C C LIN

CN1

4

S1

RS485-LINK

S2

213

4

RS485

213

4

R1R2

+5VD+5VD

L4

HEADER 5X2

C1

100N

L3

INDU1

INDU1

L5

INDU1

DGND

RevisionModel No:

Drawn By:

Sheet

DPA4000

L1

INDU1

L2

INDU1

IC2A

R3

10R0

R4

10R0

D1

1N4740/6V8/1W

D3

1N4740/6V8/1W

S3

TP-2

D2

1N4740/6V8/1W

D4

1N4740/6V8/1W

CN2

1234567

+5VD

6

74

321

Ro

IC1A

De

3

1

2 Re

TRANSCEIVER

Di

MAX485E

1312

MAX202E

MAX202E

R

T

IC2C

11 14

T

IC2B

10 7

CN-HD4X2

8

MAX202E

IC2D

DGND

98

R

MAX202E

ALTO : DPA4000 RS_BOARD

Titel

DGND

12-Apr-2004

DPA-RS Sch

A4

Size

File:

Date:

C3

47u/16V

C5

100N

C4

100N

C8

100N

C7

100N

45

6

16

IC2E

MAX202E

13

C6

100N

C2

100N

85

C1B

MAX485E

2

15

1 2 34

D

C

B

A

DPA2500/4000 Chassis Wiring Drawing (100V-130V)

7654321

8

D

D

OUT1GND1OUT2GND2

GRAY

HA01258
HA02471

RED

PURPLE

BLACK

HA02449

WHITE
WHITE

GRAY

BLUE

BLACK

HA01198

HA01244

HA01239
HA01237

JP1_1

(CH1_OUT)

JP1_2

(GND1)

JP1_13

JP1_14
JP1_7

R1_5

R2_5

JP2_1

(CH2_OUT)

JP2_2

(GND2)

JP2_13

JP2_14
JP2_7

C

HA01247

HA01333

P8
P6

AC

AC

CN2

J6

P5

J4

P4

C

P3

AC

P1
P2

P7

AC

J2

RED

HA02488

GREEN

WHITE

HA01321

HA01243

YELLOW

PURPLE

B

JP1_5

PT-DPA4000-E

HA02469

HA02470

HA02451

HA02450

A

CN1_1 CN2_1

JP1_22 JP2_22

CN1CN2

(BRIDGE+)

JP1_6

(COM1)

JP1_8

(AC_1)

JP1_16 JP2_16

JP2_5

(BRIDGE+)

JP2_6

(COM2)

JP2_8

(AC_2)

B

A

1 2 3 4 5 6 78

DPA2500/4000 Chassis Wiring Drawing (210V-240V)

7654321

8

D

D

OUT1GND1OUT2GND2

GRAY

HA01258
HA02471

RED

PURPLE

BLACK

HA02449

WHITE
WHITE

GRAY

BLUE

BLACK

HA01198

HA01244

HA01239
HA01237

JP1_1

(CH1_OUT)

JP1_2

(GND1)

JP1_13

JP1_14
JP1_7

R1_5

R2_5

JP2_1

(CH2_OUT)

JP2_2

(GND2)

JP2_13

JP2_14
JP2_7

C

HA01247

HA01333

P8
P6

AC

AC

CN2

J6

P5

J4

P4

C

P3

AC

P1
P2

P7

AC

J2

RED

HA02488

GREEN

WHITE

HA01321

HA01243

YELLOW

PURPLE

B

JP1_5

PT-DPA4000-E

HA02469

HA02470

HA02451

HA02450

A

CN1_1 CN2_1

JP1_22 JP2_22

CN1CN2

(BRIDGE+)

JP1_6

(COM1)

JP1_8

(AC_1)

JP1_16 JP2_16

JP2_5

(BRIDGE+)

JP2_6

(COM2)

JP2_8

(AC_2)

B

A

1 2 3 4 5 6 78

5. PCB Layout

MIS40 FP2

6. Test Procedure & Test Result

DPA2500/4000 TEST PROCEDURE

DSP Test
Instruments

1. DMM

2. Audio Analyze unit (VP-7724)

3. Oscillograph

4. PC with RS232 port

Test Procedure

Step1: Visual check

Visually check if the cosmetic of the amplifier and assembly are OK.

Step 2: Power supply test

z Rated power
z Make sure all the voltage values are correct, then turn off power.

Step 3: DSP Test

3.1 press the “ENTER” and “SEL” at the same time. The unit will enter the test modal and

check as following:

a. All LEDs will light up in sequence.
b. The display will show “8.8” .

3.2 Press the “ENTER” and “SEL” at the same time.

a. Press “UP”, the display will show “1”.
b. Press “DOWN”, the display will show “2”.
c. Press “ENTER”, the display will show “3”.
d. Press “SEL”, the display will show “4”.

Step4: Test EEPROM

4.1 Press “ENTER” and “SEL” again, the LED (HUM CANCEL) should be light up. After wait

about 50 seconds, check as following:

a. If the display show “01” , the test is ok
b. If the display show “E1”, the test fails.

Step5: Test RAM

5.1 Press “ENTER” and “SEL” at the same time again, the LED(NOISE GATE) will light up,

wait a few seconds, check as following:

a. If the display show “02”, the test is ok.
b. If the display show “E2”, the test fails .

Step 6. RS232 Port Test

6.1 Turn off the unit, then connect the computer and the amplifier via RS232 port, then turn on

the unit.

1. If the panel shows”56”, the Connection is ok.

2. Done.

PCB Test
Instruments

1. DMM

2. Audio Analyzer unit

3. Oscillograph

4. 8Ω(400W) load

1) Test procedures and specification

1.Set LIMITER and BRIDGE switches in the position OFF. Turn VR of CH1 and CH2 to

maximum, then turn on the power switch and the blue power LED lights up, and

OPERATING/PROTECTION LED shows red, then it turns green after 2-5 seconds or so.

a. Without signal input, adjust R1-16(CH1) and R2-16(CH2) so that the voltage of R1-17/2-17 is

132±2Mv. Connect a 4Ω load at output. Input a 5KHz –3/-0.5dB signal into CH1 or CH2

(output 2V). Verify the curve on oscilloscope and there should be no crossover distortion, then

the oscillograph shows curve distortion should be 2-3%. Adjust the R1-20, R1-21 (CH1); R2-20,

R2-21 (CH2) make sure that the crossover distortion reaches its peak. (NOTE: maintain the

power is 230V).

b. Set the output is short circuit, then adjust the LED for the LIMITER on the panel will be

illuminated and the power consumption of the short circuit protection should be less than 485W.

c. S/N: more than 88dB (A weighted is more than 100dB).

d. Compressor function test: Turn on LIMITER switch. Input a 1KHz / +10dB signal, the

LIMITER LED is lit yellow and there is no clipped signal.

e. Adjust the VR on front panel so that the output is :2V(4Ω). The measured frequency

response is more than 28Hz to 20 kHz+/-1dB (CH1/CH2)

f. The output is more than 59V.

i. Release the BRIDGE switch. Input a 1KHz signal into CH1(the level control of CH2 is turn to

minimum). Connect a 8Ωload with output terminal. Measure the bridged output voltage is

more than about 110V, the distortion is less than 1%. (This measurement shall be done in a

minute).

j. Turn off the input signal, the power consumption shall be less than 80W.

k. Done.

5. Test result

SEKAKU ELECTRON INDUSTRY CO., LTD.

Model No DPA2500 (Amplifier) USER OF VP-7724A

Test Item Test Conditions Spec

1 Power Source

AC:

115/120/230/240V

Test

Result

AC: V

Remark

Motionless State

2

3

4 Rated Output

5 Signal/Noise

6 Hum or Noise VR Max

Current

Power

Consumption

Load 4Ω

Rated Output. Input

at 1KHz,6dBV

Load 4Ω(CHA,B) 46V+46V↑

Load 8Ω

Input 1KHz 6dB

Load 4Ω

TP1_3(CH1)/T
P2_3(CH2):13

8±2mV

8A A

1800W W

VV

90dB↑

102dB↑(A)

2mV↓

0.2%↓(10W)

%

V

dB

mV VR MAX

%

R1-16(CH1)/R2-

16(CH2)

VR MAX(CLIP ON)

INPUT 1KHz (CLIP

ON)

VR MAX (CLIP

ON)

7

Distortion

8

9 BRIDGED SW A T BRIDGED

10

11

12

INPUT

SENSITIVITY

OUTPUT SHORT

TEST

PUNCTURE

VOLTAGE

FREQUENCY

RESPONSE

Input 1KHz 6dB

BAL

STEREO

IN 1khz/0dB <500W CHA CHB

5mA 5Sec 1800V

Input 6dB , 1KHz

Load 4Ω (BAL OR

STEREO)

0.15%↓(100W)

0.3%↓(400W)

-3.5±1dB

0/+5 ±1dB

80V↑(8Ω)

＜30Hz-＞

20KHz

%

dB CHA,CHB

dB CHA,CHB

V

Hz OUTPUT

6.8V(10W)

SEKAKU ELECTRON INDUSTRY CO., LTD.

Test Result

Model No DPA4000 (Amplifier) USER OF ATS-1

Tester: Test Date: 2004 , 11 , 06

Test Item Test Conditions Spec Test Result Remark

1 Power Source 230V

Motionless

2

State Current

3

4 Ra ted Output

5 Signal/Noise

6 Hum or Noise VR Max

Power

Consumption

Load 4Ω

Rated Output.
Input at 1KHz,

3dBV

Load 4Ω

Load 8Ω

Input 1KHz

3dB Load 4Ω

AC:

115/120/230/240V

CH1 TP1-3

CH2 TP2-3

A

W

CH1 V
CH2 V

V

CH1

dB

CH2

dB

CH1 mV

CH2 mv

AC:229~243

V
135mv
135mv

11 A

2563 W

59V
59V

66V

100dB↑
100dB↑

9mV

9 mV

Load 4Ω

ADJGUST

VR MAX(CLIP ON)

INPUT 1KHz (CLIP ON)

VR MAX (CLIP ON)

VR MAX

7

Distortion

8

9 BRIDGED

10

11

INPUT

SENSITIVITY

PUNCTURE

VOLTAGE

FREQUENCY

RESPONSE

Input 1KHz

3 dB

BAL dB

STEREO

SW A T

BRIDGED

5mA 5Sec 1800V

Input 6dB ,

1KHz Load 4Ω

(BAL OR

STEREO)

CH1 %
CH2 %

CH1 dB

CH2 dB

V(8Ω)

Hz

0.15%

0.15%

3.7dB

3.75dB

3.75 dB
112V

20Hz~20khz

CHA,CHB

CHA,CHB

-2DB

OUTPUT V( 10W-1dB)

DPA2500

y

)

)

AC j

A

A

A

No. Part No. descriptions Specification Qt

1 MA04096 panel MISTRAL4000 1
2 MA04165 panel MISTRAL2500 ALTO 1
3 MB03071 chassis MISTRAL2500 1
4 MC00559 Top DPA1500 1
5 MI01744 Handle MISTRAL4000 20*25.5*80 2
6 MI01900 Fixed DPA1500-05 DPA1500 1.0t* 112*81*15mm 1
7 MI01746 Rear board MISTRAL4000 14*81*89 1
8 MJ01227 cushion MISTRAL2500 2

9 MI02025 Fixed panel MISTRAL900(left
10 MI02027 Fixed panel MISTRAL900(right
11 MI02029 Barrier board 1.0t*176.5*15*16*83mm 1
12 MI02030 Barrier board 1.0t*144.4*15*9*83mm 1
13 MJ00031 Barrier board 1.0t*83*40mm 1
14 NI02650 Plastic knob
15 NI02651 Knob glove
16 HC00005
17 HI00031 Power switch R415KKETOF 1
18 SA00011 Bridge rectifier 25A/200v 2
19 MG00247 cropper M3*10*0.5PH 4
20 MG00061 screw M3*10 10
21 MG00295 screw M4*6 4
22 MG00042 screw M3*6 34
23 MG00042 screw M3*10 6
24 MF00037 Spring washer
25 ME00015 Color nut 3mm 6
26 MF00038 washer
27 ME00016 Color nut 4mm 3
28 MF00018 Color washer
29 MF00048 washer
30 HI00140 switch
31 NI00389 Plastic washer
32 MG00041 screw M3*6 12
33 MG00075 screw M4*16 4
34 ME00006 Nut
35 MF00004 Color washer
36 NI00437 rubber
37 MG00215 screw M8*80 1
38 ME00026 Nut M8 1
39 MF00026 Color washer
40 MF0041 washer
41 MH00766 Iron
42 TD00182 transformer PT-MIS2500-E 1
43 HE00010 fan DC24V/0.16A 80*80*25mm200mm 1
44 MD00444 Fan cover 80*80mm 1
45 MG00065 screw M5*10 4
46 NI00312 Switch knob 5*5*9 2
47 HA00871 wire LT-312+1.5*3C 1
48 NI01867 cushion 20.5*14*7.6mm 4
49 NC00182 Insulation 1.6*130*16 2
50 Mi01956 Fixed frame 130*5*6*1.5 2
51 MI02014 Heat sink 9*83*40*260 1

ack

∮18*18mm
10*∮22.5 A600.2

C-008 1

∮3*∮5*1t
∮4*∮7*1t
∮4*∮10*1t

∮4*∮8*0.5t

0701HM-6

∮12*∮16*0.5

∮9
∮9*∮14*0.5t
∮20*∮120*2tB

∮8*∮18*1.5t
∮8*∮13.5*2t
∮11*∮90*2

1
1

2
2

12

7

3
1
1
1

2
1
1

2
1
1

DPA4000

y

)

)

AC j

A

A

A

No. Part No. descriptions Specification Qt

1 MA04096 panel MISTRAL4000 1

2 MA04165 panel MISTRAL4000 ALTO 1

3 MB03071 chassis MISTRAL4000 1

4 MC00559 Top DPA1500 1

5 MI01744 Handle MISTRAL4000 20*25.5*80 2

6 MI01900 Fixed DPA1500-05 DPA1500 1.0t* 112*81*15mm 1

7 MI01746 Rear board MISTRAL4000 14*81*89 1

8 MJ01227 cushion MISTRAL2500 2

9 MI02025 Fixed panel MISTRAL900(left
10 MI02027 Fixed panel MISTRAL900(right
11 MI02029 Barrier board 1.0t*176.5*15*16*83mm 1
12 MI02030 Barrier board 1.0t*144.4*15*9*83mm 1
13 MJ00031 Barrier board 1.0t*83*40mm 1
14 NI02650 Plastic knob
15 NI02651 Knob glove
16 HC00005
17 HI00031 Power switch R415KKETOF 1
18 SA00011 Bridge rectifier 25A/240v 2
19 MG00247 cropper M3*10*0.5PH 4
20 MG00061 screw M3*10 10
21 MG00295 screw M4*6 4
22 MG00042 screw M3*6 34
23 MG00042 screw M3*10 6
24 MF00037 Spring washer
25 ME00015 Color nut 3mm 6
26 MF00038 washer
27 ME00016 Color nut 4mm 3
28 MF00018 Color washer
29 MF00048 washer
30 HI00140 switch
31 NI00389 Plastic washer
32 MG00041 screw M3*6 12
33 MG00075 screw M4*16 4
34 ME00006 Nut
35 MF00004 Color washer
36 NI00437 rubber
37 MG00215 screw M8*80 1
38 ME00026 Nut M8 1
39 MF00026 Color washer
40 MF0041 washer
41 MH00766 Iron
42 TD00182 transformer PT-MIS4000-E 1
43 HE00010 fan DC24V/0.16A 80*80*25mm200mm 1
44 MD00444 Fan cover 80*80mm 1
45 MG00065 screw M5*10 4
46 NI00312 Switch knob 5*5*9 2
47 HA00871 wire LT-312+1.5*3C 1
48 NI01867 cushion 20.5*14*7.6mm 4
49 NC00182 Insulation 1.6*130*16 2
50 Mi01956 Fixed frame 130*5*6*1.5 2
51 MI02014 Heat sink 9*83*40*260 1

ack

∮18*18mm
10*∮22.5 A600.2

C-008 1

∮3*∮5*1t
∮4*∮7*1t
∮4*∮10*1t

∮4*∮8*0.5t

0701HM-6

∮12*∮16*0.5

∮9
∮9*∮14*0.5t
∮20*∮120*2tB

∮8*∮18*1.5t
∮8*∮13.5*2t
∮11*∮90*2

1
1

2
2

12

7

3
1
1
1

2
1
1

2
1
1

8. BOM

DPA2500 part list

No. Part No. Descriptions Specification Remark

1 MA04096 panel MISTRAL4000

2 MA04097 panel MISTRAL4000

3 MA04098 panel MISTRAL4000 3.1*88.8*25.5*483

4 MI01309 panel 3.1*88.8*25.5*483

5 MA04398 panel DPA2500 ALTO_V1.0

6 MA04395 panel DPA4000

7 MA04396 panel DPA4000 1.5t*22.4*81.4*422

8 MJ00088 single light board 1.5*2135*1220 30.67kg

9 MB02959 rear board DPA4000_V1.0

10 MB02960 rear board DPA4000_V1.2

11 MB02961 rear board DPA4000 1.5t*85.5*370*430_V1.2

12 MJ00088 single light board 1.5*2135*1220 30.67kg

13 ME00051 iron pillar M3*12

14 MI01516 barrier MISTRAL4000 57*177*195

15 MJ00058 single light board 1*2135*1220 20.45kg

16 ME00001 screw pillar M4*10*0.7PH

17 ME00002 screw pillar M4*20*0.7PH

18 MC00517 top cover MISTRAL4000_V1.0

19 MC00622 top cover MISTRAL2500_V1.0

20 MC00621 top cover MISTRAL2500_V1.0

21 MJ00088 single light board 1.5*2135*1220 30.67kg

22 MI01744 handle MISTRAL4000 20*25.5*80

23 MI01745 handle MISTRAL4000 20*25.5*80

24 MI01750 fixed bracket MISTRAL4000 left L type

25 MI01751 fixed bracket

26 MJ01154 single light board 2.0t*1850*950mm 27.6kg

27 MI02452 fixed bracket DPA2500 right L type_V1.0

28 MI02781 fixed bracket MISTRAL4000 right

29 MI01753 fixed bracket

30 MJ01154 single light board 2.0t*1850*950mm 27.6kg

31 MI01746 front board MISTRAL4000 14*81*89

32 MJ00061 Zn-plated board 1*2135*1220 20.45kg

33 MI01759 barrier MISTRAL4000 0.8t*53.5*78_V1.1

34 MJ00067 single light board 1.0t*2440*1220 18.69kg

35 MI01756 barrier MISTRAL4000 0.8t*53.5*78_V1.1

36 MJ00067 single light board 1.0t*2440*1220 18.69kg

37 NI02145 acrylic panel DPA series ALTO_V1.1

38 NI02146 acrylic panel DPA4000 (3t*40*47mm)

39 NI01863 key

40 ME00015 nut 3m/m

MISTRAL4000 left L type

26.5*88.8*400mm

MISTRAL4000 right Type 26.5*88.8*400mm

φ5.5*W10*7.5

No. Part No. Descriptions Specification Remark

41 NI02650 knob

42 NI02651 knob fix sheath

φ18*18mm
10*φ22.5

43 HC00005 AC socket AC-008

44 HI00031 power switch R415KKETOF

45 SA00013 bridge rectifier 35A/200V

46 HA01243 wire 300mm UL1015 14AWG brown

47 HA01333

single terminal wiring CF:W76

150mm UL1015 18AWG green/yellow

48 HA01247 single terminal wiring 180mm UL1015 14AWG blue

49 HA02469 wire 3P-3P 480mm 28AWG blue

50 HA02470 wire 3P-3P 600mm 28AWG blue

51 HA02452 wire

10Pfema*3 415mm UL2651 28AWG PH1.27mm

52 HA02448 wire 530mm UL1015 14AWG red

53 HA02449 wire 700mm UL1015 14AWG black

54 HA01244 2 terminal wiring 380mm UL1015 14AWG red

55 HA01198 wire 180mm UL1015 14AWG black

56 MG00247 copper pillar M3*10*0.5PHsingle length16

57 MG00295 screw M4*6

58 MG00025 screw M3*6

59 MG00042 screw M3*10

60 MF00037 washer

61 MF00038 washer

φ3*φ5*1t
φ4*φ7*1t

62 ME00016 nut 4m/m

63 MF00048 washer

64 MF00018 washer

φ4*φ8*0.5t
φ4*φ10*1t

65 MG00268 screw M5*12

66 MG00041 screw M3*6

67 MG00075 screw M4*16

68 ME00006 nut

69 MF00004 washer

70 NI00437 rubber coil

9φ

φ9*φ14*0.5t
φ20*φ120*2tB

71 MG00556 screw M8*82.5*1.25PH_V1.0

72 ME00026 nut 8m/m

73 MF00026 washer

74 MF00041 washer

75 MH00766 iron piece

76 MH00768 iron piece

φ8*φ18*1.5t
φ8*φ13.5*2t
φ11* φ90*2_V1.1
φ11* φ90*2_V1.1

77 MJ01154 single light board 2.0t*1850*950mm 27.6kg

78 TD00207 loop transformer PT-DPA2500_115/230V

79 NI00252 sleeve

80 NI00248 sleeve

81 HE00050 fan

φ4*20mm
φ4*1000mm

DV12V/0.37A 80*80*25 360mm JST2P

82 NI00312 power switch button square 5*5*9 hole 2.8*2.8 black

83 HA00871 power cord(Europe 3P) LT-322+1.5*3C(H05VV-F) 6FT+LT-501

No. Part No. Descriptions Specification Remark

84 NI00218 cable tie-black ALT-102SB

85 HJ00006 desiccant 30g

86 NA00135 PE bag 0.05t*610*500mm

87 NF01663 instruction DPA2500/4000 ALTO_V1.0

88 NH00149 paper 889*640mm

89 NB01791 box DPA2500 ALTO_V1.1

90 NB01944 barrier PSA-3000_V1.1

91 NB02086 box MACRO

92 NE08281 label DPA2500 220-240V_V1.0

93 NI00015 membrane 0.04*1M

94 NI00014 membrane 0.035*1M

95 NF00061 assurance card ALTO

96 NE12198 label DPA2500

97 NH00012 bond paper 0.04*1M

98 NI00014 membrane 0.035*1M

99 NE11347 label ALTO PI

100 NH00334 cone paper 0.040*1m

101 NC00059 fixed board 1*46*46(Sax-2000)

102 NC00175 insulator 1.0t*51mm*100M

103 HK04155 PC board P-MIS40MN CH2(MISTRAL2500)

104 HB01395 PCB MIS60MNCH2_VER050203

105 RA00211 fixed resistor 1/4W

106 RA00239 fixed resistor 1/4W

107 RA00266 fixed resistor 1/4W

108 RA00174 fixed resistor 1/4W

109 RA00299 fixed resistor 1/4W

110 RA00200 fixed resistor 1/4W

111 RA00616 fixed resistor 1/4W

112 RA00217 fixed resistor 1/4W

113 RA00158 fixed resistor 1/4W

114 RA00246 fixed resistor 1/4W

115 RA00219 fixed resistor 1/4W

116 RA00282 fixed resistor 1/4W

117 RA00184 fixed resistor 1/4W

118 RA00242 fixed resistor 1/4W

119 RA00908 fixed resistor 1/2W

120 RA00909 fixed resistor 1/2W

121 RB00010 resistor networks 1/8W

122 RA00027

123 RA00007

124 RA00020

125 RA00051

126 RA00953

metal-oxide-film resistor 1W

metal-oxide-film resistor 1W

metal-oxide-film resistor 1W

metal-oxide-film resistor 2W

metal-oxide-film resistor 5W

820Ω M type

8.2KΩ M type
47KΩ M type
47Ω M type
330KΩ M type
330Ω M type
470Ω M type

1.5KΩ M type

0.0Ω M type
15KΩ M type

1.8KΩ M type
100KΩ M type
100Ω M type
10KΩ M type
68KΩ P type
82KΩ P type
10KΩ 8P C Type

5.6Ω P type
22Ω P type

6.8KΩ P type

5.6Ω P type
10KΩ P type

R2_14,R2_18

R2_53

R2_47

R2_52

R2_42,R2_48

R2_10,R2_55

R2_9

R2_45

R2_2

R2_11

R2_1

R2_43,R2_46,R2_51

R2_57

R2_54,R2_8

R2_58

R2_56

RB2_1

R2_22,R2_62

R2_25,R2_32

R2_44

R2_39

R2_49

No. Part No. Descriptions Specification Remark

127 RA00062

metal-oxide-film resistor 3W

128 RA00880 cement resistor 5W

129 RA00870 cement resistor 5W

130 RA00869 cement resistor 5W

131 RA00981 cement resistor 10W

1.0KΩ RSS P type

0.22Ω SQM type
12Ω SQM type

1KΩ SQM type

3.3KΩ SQM type

R2_63

R2_28,R2_29,R2_30,R2_31,
R2_33,R2_34,R2_36,R2-35

R2_41,R2_40

R2_23,R2_24

R2_15,R2_19

132 CA00010 ceramic capacitor 27PF NPO C2_10

133 CA00018 ceramic capacitor 56PF NPO C2_35,C2_36,C2_7

134 CA00024 ceramic capacitor 100PF SL C2_3,C2_4

135 CA00043 ceramic capacitor 0.0033uF C2_13,C2_14

136 CA00070 ceramic capacitor 0.022uF/50V±20% Y5U C2_11

137 CA00047 ceramic capacitor 0.033uF C2_12

138 CA00053 ceramic capacitor 0.1uF SL C2_44

139 CF00022 metal-film capacitor MSC 0.022uF/100V 5% CASE01 C2_40

140 CF00013 metal-film capacitor MEF 0.068uF/250V C2_31

141 CB00143 electrolytic capacitor

142 CB00177 electrolytic capacitor

143 CB00169 electrolytic capacitor

144 CB00039 electrolytic capacitor

145 CB00149 electrolytic capacitor

146 CB00055 electrolytic capacitor

147 CB00171 electrolytic capacitor

148 CB00057 electrolytic capacitor

149 CB00067 electrolytic capacitor

150 CB00170 electrolytic capacitor

151 SA00167 bridge rectifier 2A W2-04

10uF/63V φ5*11mm
22uF/50V φ5*11mm
47uF/16V NP φ6.3*11mm
47uF/25V φ5*11mm
47uF/63V φ6*11mm
220uF/16V φ8*11mm
220uF/16V NP φ10*12.5mm
220uF/25V φ8*11mm
470uF/35V φ10*20mm

1000uF/100V φ18*35.5mm

C2_32,C2_43

C2_1,C2_2,R2-43

C2_9

C2_5

C2_33

C2_37

C2_34

C2_8,C2_45

C2_42

C2_15,C2_16,C2_17,C2_18,
C2_19,C2_20,C2_21,C2_22,
C2_23,C2_24,C2_25,C2_26

D2_2,D2_19,D2_24,D2_27

152 SA00093 rectifier diode 1N4148 0.5A D2_11,D2_12

D2_10,D2_13,D2_14,D2_20,

153 SA00098 rectifier diode 1A/400V IN4004

D2_22,D2_23,D2_25,D2_26,
D2_28,D2_9

154 SA00187 rectifier diode IN5404 D2_15,D2_16

155 SA00002 high speed diode 1A/600V 1N4937 D2_5,D2_6

156 SA00107 zener diode 1W 15V 1N4744 D2_1,D2_4

157 SA00197 zener diode 1W 36V 1N4753 D2_21

158 SA00117 zener diode 1/2W 5.6V 6B1 D2_7,D2_8

159 SA00188 zener diode 1/2W 7.5V D2_18

160 SA00026 L.E.D

φ5 circle red B1115

D2_17

161 SB00042 transistor MJE15032 Q2_1

162 SB00044 transistor MJE15033 Q2_2

163 SB00130 transistor MPSA42/(PHILIPS) Q2_17

164 SB00129 transistor MPSA92(TO92)/(PHI) Q2_15,Q2_16

165 SB00023 power transistor 2SA1943-O

166 SB00021 power transistor 2SC5200

Q2_5,Q2_6,Q2_7,Q2_8

Q2_9,Q2_10,Q2_11,Q2_12

167 SD00032 integrated circuit LM317T U2_4

168 SD00173 integrated circuit NJM4580L(JRC) U2_1,U2_2

No. Part No. Descriptions Specification Remark

169 CN00060 fixed inductance

170 RH00021 thermistor

171 RH00017 thermistor

172 RH00025 thermistor

173 RC00319 semi-fixed resistor

174 RC00348 semi-fixed resistor

2uH 10A(CSAF-302824)(φ1.5mm*12

1/2T)

500Ω(TDC5C150L)
50Ω(TDC05A050J)
100Ω(PAS7101ZF)
B100Ω PT1030-V1B101-C1-H10
B1KΩ PT1030-V1B102-C1-H10

L2_1

R2_3

R2_17

R2_50

R2_16

R2_20,R2_21

175 HI00211 rarely 8P 24VDC/16A 881H-1CC-C K2_1

176 HI00039 push-button switch SP70300-0202-11F1-N S2_1

177 HK02231 Photodiode

P-photosensitive resistanceφ5LLED

U2_5

178 RH00020 photosensitive resistance VT90N1

179 SA00201 L.E.D

180 NI02779 sleeve

181 NI00274 sleeve

182 HC00324 terminal 6.5m/m (PC250)

183 HC00056 FUSE holder 8*10.6*1.5 JEF-505

φ5 red(LI3330/A)
φ9*30mm
φ9*1000mm

JP2_1,JP2_2,JP2_5,JP2_6,
JP2_7,JP2_8
JP2_9,JP2_10,JP2_11,
JP2_12

184 HC00112 balance MIC jack 99M-107SP-1-2 90° PUSH J2_1

185 HC00111 balance MIC jack 99M-108SP1 J2_2

186 HC00504 row-wire header 10P 2.54mm 180° JP2_15,JP2_16,JP2_3

187 HC00172 row-wire header 3P 3.96mm 180° JP2_13

188 HC00077 row-wire header 3P 2.5mm 180° R2_5

189 HC00076 row-wire header 2P 2.5mm 180° JP2_14

190 HA01933 jumper wire 2.5mm J2_4,J2_5

191 HC00034 short circuit connector NO.2700 2.54mm/6mm OPEN

192 HD00029 ceramic tube fuse

15A φ6*32mm UL

193 MJ01200 spacer MISTRAL4000 14.5*30.5*2t

194 MJ01201 spacer MISTRAL4000 14.5*30.5*2t

195 MJ01154 single light board 2.0t*1850*950mm 27.6kg

196 MF00030 washer

197 MF00037 washer

φ3*φ8*0.8t
φ3*φ5*1t

198 NC00005 silicone insulator TO-220 square type

199 MG00171 screw M3*14

200 ND00182 silicone sleeve

201 ND00171 silicone sleeve

φ1*30mm
φ1*1000mm

202 NC00181 insulator MISTRAL4000 1.6t*136*16mm

203 NC00041 red foil white board 1.6t*0.65M*70M

204 MI01954 fixed bracket MISTRAL4000 1.5t*136*16mm right

205 MJ00069 iron board 1.5*2135*1220 30.67kg

206 HA02759 wire 5P-5P 120mm UL1007 24AWG

207 CA00088 ceramic capacitor 100PF/1000V Q2-1,Q2-2

208 MI02325 heat-sink 9*83*70*309 right_V1.0

209 MI02359 heat sink 9*83*70*4400 +5/-0 18.8320KG_V1.0

210 RA00713 fixed resistor 1/4W

1.0KΩ F type

C2-6

No. Part No. Descriptions Specification Remark

211 AC00002 solder wire 63/37%

212 HK03958 PC board P-MIS40PWR

213 HB00946 PCB MIS40PWR_VER030710

214 HC00324 terminal 6.5m/m (PC250)

P1,P2,P3,P4,P5,P6,P7,P8

215 CG00044 metal oxide varsities NP35L-Y2 K2-2

216 AC00002 solder wire 63/37%

217 HK03959 PC board P-MIS40FP2

218 HB00947 PCB MIS40FP2_VER030710

219 SA00191 L.E.D

220 SA00053 L.E.D

φ3 (LEG2062)
φ3 round(red)long foot 26mm

D1_1,D2_1

D1+3,D2_3

221 SA00054 L.E.D 3m/m round(yellow)long foot 26 D1_30,D2_30

222 HC00066 row-wire header 3P 2.5mm 90° CN1_1,CN2_1

223 RC00209 PPBC239

224 SA00194 L.E.D

A10KΩ RV110-40E1-225A-A14
φ3

VR1_1,VR2_1

D1_29,D2_29

225 NI01765 LED spacer support LEDS-10 10mm

226 HA02450 wire

227 HA02451 wire

10P-10P 350mm UL2651 28AWG PH1.27mm

10P-10P 250mm UL2651 28AWG PH1.27mm

JP2_22

JP1_22

228 AC00002 solder wire 63/37%

229 HK04608 PC board P-MIS60SP

230 HC00442 speaker socket NL4MP (NEUTRIK) SPK1,SPK2

231 MJ00942 fixed bracket CS12/600

232 MJ00061 Zn-plated board 1*2135*1220 20.45kg

233 HA01239

234 HA01237

single terminal wiring CF:W209

single terminal wiring CF:W207

180mm UL1015 14AWG white JP5

200mm UL1015 14AWG gray JP2

235 HA02471 single terminal wiring 360mm UL1015 14AWG white JP7

236 HA01258 single terminal wiring 380mm UL1015 14AWG gray JP8

237 HA03432 single terminal wiring 100mm UL1015 14AWG JP1,JP3

238 HA03433 single terminal wiring 100mm UL1015 14AWG JP6,JP4

239 HB01396 PCB MIS60SP(2*4)_VER040922

240 AC00002 solder wire 63/37%

241 HK03847 PC board P-DPA2500-RS-DIP

242 HK00603 PC board P-DPA2500-RS-SMD

243 HB01073 PCB DPA-RS_VER031103

244 CI00075

245 RD00372

SMD ceramic capacitor 0603

SMD precise resistor 1/8W

0.1uF/50V Y5V +80,-20% C1,C2,C4,C5,C6,C7,C8

10.7Ω ±1% 0805

R3,R4

246 SG00047 SMD integrated circuit MAX485EESA IC1

247 CO00006 SMD chip inductance BLM21A102SPT/(MURATA) L1,L2,L3,L4,L5

248 AE00221 tin soldering paste SJ-617

249 HC00324 terminal 6.5m/m (PC250)

250 CB00040 electrolytic capacitor

47uF/25V φ5*11mm

C3

251 SA00101 zener diode 1W 6.8V 1N4736 D1,D2

252 SA00104 zener diode 1W 10V 1N4740 D3,D4

No. Part No. Descriptions Specification Remark

253 SD00019 integrated circuit MAX202ECPE IC2

254 HA02503 wire

9P-10P 50mm UL2651 28AWG PH1.27mm

CN1

255 HC00048 row-wire header 8PIN A28b-8B.T.6 CN2

256 HC00111 balance MIC jack 99M-108SP1 S1

257 HC00112 balance MIC jack 99M-107SP-1-2 90° PUSH S2

258 AC00002 solder wire 63/37%

259 HK03846 PC board P-DPA2500-DISPLAY

260 HB01071 PCB DPA-DIS-1(2*2)_VER050120

261 CH00017 laminated capacitor 0.1uF/50V Y5V PH5 C1

262 CB00026 electrolytic capacitor

263 RA00647 fixed resistor 1/8W

264 RA00651 fixed resistor 1/8W

10uF/50V φ6*7mm

4.7KΩ M type
10KΩ M type

C2

R1,R2

R3,R4,R5,R6,R7,R8

265 HB01070 PCB DPA-DIS-2_VER030916

266 HH00005 seven paragraph monitor LSD3561-10 DL2,DL3

267 HC00435 row pin (single)#1100 2.54 180° 5P6/11.6mm CN3,CN4

268 SA00051 L.E.D

269 SA00072 L.E.D

φ3 orange, green BOG303b
φ3 red LI2340/A

DL11

DL1,DL4,DL5,DL6,DL7,

270 SB00072 transistor BC559C,126 TR1,TR2

271 HI00238 push-button switch 2 stage 6P PS-9226A(NON-LOCK) SW1,SW2,SW3,SW4

272 HC00050 row-wire header 14PIN A28b-14B.T.6 CN1

273 HC00051 row-wire header 20PIN A28b-20B.T.6 CN2

274 HA01919 jumper wire 5mm J1,J2,J3,J6,J9

275 HA02249 wire

φ0.6

276 HA01917 jumper wire 3mm J4,J8,J10

277 HA01920 jumper wire 6mm J5,J7,J3

278 HA02249 wire

279 NI01771 LED spacer support LEDS-5 5mm

φ0.6

DL1,DL10,DL11,DL4,DL5,

280 MG00269 screw M3*6

281 NI01876 LED spacer support 7.6*4.5*184

282 AC00002 solder wire 63/37%

283 HK03845 PC board P-DPA2500-PWR-DIP

284 CB00024 electrolytic capacitor

285 CB00072 electrolytic capacitor

10uF/16V φ4*7mm
1000uF/25V φ10*20mm

C1,C3,C10,C11

C9,C8

286 SD00074 integrated circuit L7805CV(TO-220)(ST) U3

287 SD00169 integrated circuit L7905CV(TO-220)(ST) U4

288 HC00066 row-wire header 3P 2.5mm 90° CN2

289 HC00560 row pin (single)#2200 2.54 180° 2*5P 6/11.6mm CN1

290 HC00070 row-wire header 6P 2.5mm 90° CN3

291 HI00161 relay RY-5W-K,5V REL1

292 HC00047 row-wire header 6PIN A28b-6B.T.6 J7

293 HC00048 row-wire header 8PIN A28b-8B.T.6 J1,J6

294 HC00051 row-wire header 20PIN A28b-20B.T.6 J2,J3

No. Part No. Descriptions Specification Remark

295 HC00050 row-wire header 14PIN A28b-14B.T.6 J5,J4

296 NC00005 silicone insulator TO-220 square type

297 NI00863 insulate bean TO220B

298 MG00270 screw M3*10

299 MI01820 fixed bracket DPA4000 2.5t*42.5*83.8*102.5

300 MJ00093 AL plate 2.5*2000*1000 13.6kg

301 MG00252 copper pole M3*6.2*0.5PHsingle,length12

302 MG00363 copper pillar M3*14*0.5PH

303 MG00269 screw M3*6

304 HK00602 PC board P-DPA2500-PWR-SMD

305 HB01072 PCB DPA-PWR_VER030916

306 CI00075

307 CI00051

308 RD00101 SMD fixed resistor 1/10W

309 RD00081 SMD fixed resistor 1/10W

310 RD00085 SMD fixed resistor 1/10W

311 RD00059 SMD fixed resistor 1/10W

SMD ceramic capacitor 0603

SMD ceramic capacitor 0603

0.1uF/50V Y5V +80,-20% C7,C12,C13,C14,C15

22PF/50V NPO ±5% C2,C4,C5,C6

10KΩ ±5% 0603
750Ω ±5% 0603

1.5KΩ ±5% 0603

0.0Ω ±5% 0603

R1,R3,R6,R8,R10,R11

R2,R4

R12,R13,R14,R15,R16,R17,
R18,R19,R20,R21,R22,R23,
R24,R25,R26,R27,R28,R29

R30,R9

312 SE00011 SMD rectifier diode RLS4148 0.5A (LL-34) D1

313 SF00056 transistor MMBT3904(SOT-23)/(PHI) Q2

314 SG00040 SMD integrated circuit MC33078DT(ST)MC33078D(ON) U1,U2

315 SE00030 SMD rectifier diode SFS1B D2,D3,D4,D5

316 RD00088 SMD fixed resistor 1/10W

2.2KΩ ±5% 0603

R5,R7

317 AE00221 tin soldering paste SJ-617

318 AC00002 solder wire 63/37%

319 HK03830 PC board P-313089-4-DIP

320 CB00048 electrolytic capacitor

321 CB00069 electrolytic capacitor

322 RA00515 precise resistor 1/4W

100uF/25V φ6*11mm
1000uF/6.3V φ8*11mm

10.0KΩ M type

C2

C4

R12,R13

323 HC00080 row-wire header 6P 2.5mm 180°

324 HC00047 row-wire header 6PIN A28b-6B.T.6 CN4

325 HC00048 row-wire header 8PIN A28b-8B.T.6 CN1

326 HC00050 row-wire header 14PIN A28b-14B.T.6 CN6

327 HC00051 row-wire header 20PIN A28b-20B.T.6 CN5

328 SC00319 crystal oscillator 12.288MHZ XT1

329 HC00162 row pin (single)#6100

1.27 180°14P(gold-plated))6.0/11.54mm

CN2,CN7

330 ND00098 EV bubble sponge 40*14*5

331 HK03831 PC board P-313089-4-SMD

332 HB00400 PCB 313089 (90*77.5)_VER020507

333 CI00046

334 CI00049

SMD ceramic capacitor 1206

SMD ceramic capacitor 0603

1uF/16V Y5V-1206(3216) C28

15PF/50V NPO ±5% C12,C14

No. Part No. Descriptions Specification Remark

,

335 CI00051

336 CI00075

SMD ceramic capacitor 0603

SMD ceramic capacitor 0603

22PF/50V NPO ±5% C29

C1,C10,C11,C13,C15,C17,

C16,C18,C19,C20,C21,

0.1uF/50V Y5V +80,-20%

C22,C23,C24,C25,C27,

C3,C30,C31,C32,C33,C34,
C35,C6,C7

,C8,C9

337 CL00006 SMD tantalum capacitor 10uF/16V case B2 C26,C5

338 RD00068 SMD fixed resistor 1/10W

339 RD00073 SMD fixed resistor 1/10W

340 RD00076 SMD fixed resistor 1/10W

341 RD00079 SMD fixed resistor 1/10W

342 RD00082 SMD fixed resistor 1/10W

343 RD00085 SMD fixed resistor 1/10W

344 RD00086 SMD fixed resistor 1/10W

345 RD00093 SMD fixed resistor 1/10W

346 RD00101 SMD fixed resistor 1/10W

347 RD00125 SMD fixed resistor 1/10W

348 RE00006

349 RE00008

350 RE00007

SMD resistor networks 1/16W

SMD resistor networks 1/16W

SMD resistor networks 1/16W

100Ω ±5% 0603
220Ω ±5% 0603

330Ω ±5% 0603
560Ω ±5% 0603
820Ω ±5% 0603

1.5KΩ ±5% 0603

1.8KΩ ±5% 0603

4.7KΩ ±5% 0603
10KΩ ±5% 0603

1.0MΩ ±5% 0603
100Ω*4 ±5% 8P 0603

4.7KΩ*4 ±5% 8P 0603
470Ω*4 ±5% 8P 0603

R14,R15,R2,R27,R29,R30,
R32,R39,R40,R6,R7,R8

R19,R20,R22,R35,R36,R37,
R38,R5

R28

R25

R16,R17

R18

R21

R3,R33,R34

R11,R24,R26,R9

R23

AR1,AR10,AR13,AR14,AR16,
AR18,AR2,AR3,AR4,AR5,AR8

AR11,AR15,AR17,AR6,AR7

AR9

351 SE00011 SMD rectifier diode RLS4148 0.5A (LL-34) D1

352 SG00068 SMD integrated circuit 74HC14DT(SO-14)/(PHI) IC5

353 SG00049 SMD integrated circuit AS4C256K16F0-60JC IC1

354 SG00025 SMD integrated circuit 24LC64I/SN IC6

355 SG00184 SMD integrated circuit EN29F040A-70JC/DPA IC3

356 SG00217 SMD integrated circuit EN29F040A-70JC(PL032)/(E-ON)

357 SG00335 SMD integrated circuit TY-1 ALTO(LEM NO#105008)_V1.1 IC2

358 SG00128 SMD integrated circuit RED 208(LEM NO#105008)

359 SG00069 SMD integrated circuit MAX709L-CSA IC4

360 CO00006 SMD chip inductance BLM21A102SPT/(MURATA) L1,L2,L3,L4,L5,L6

361 HC00233 IC socket (PCB) PLCC32 (D03-32T.A.4) IC3

362 AE00221 tin soldering paste SJ-617

363 HK01289 PC board P-313111-SMD

364 HB00401 PCB 313111 (37*75)_VER020507

365 CI00064

366 CI00067

367 CI00071

368 CI00075

SMD ceramic capacitor 0603

SMD ceramic capacitor 0603

SMD ceramic capacitor 0603

SMD ceramic capacitor 0603

369 CL00006 SMD tantalum capacitor 10uF/16V case B2

370 RD00063 SMD fixed resistor 1/10W

371 RD00088 SMD fixed resistor 1/10W

372 RD00091 SMD fixed resistor 1/10W

680PF/50V NPO ±5﹪

C32,C33,C43,C45

0.0022uF/50V X7R ±10% C31,C46

0.01uF/50V X7R ±10% C15,C19

C18,C25,C3,C34,C35,C36,

0.1uF/50V Y5V +80,-20%

22Ω ±5% 0603

2.2KΩ ±5% 0603

3.3KΩ ±5% 0603

C37,C38,C39,C4,C41,C42,
C7,C8,C9
C1,C10,C11,C12,C13,C14,
C16,C17,C2,C20,C21,C22,
C23,C24,C26,C27,C28,C29,

C40,C44,C5,C6

C30

R10,R3,R7,R9

R12,R17,R18,R19,R21,R23,
R24,R27

R16,R20,R22,R28

No. Part No. Descriptions Specification Remark

373 RD00093 SMD fixed resistor 1/10W

374 RD00101 SMD fixed resistor 1/10W

4.7KΩ ±5% 0603
10KΩ ±5% 0603

R1,R13,R4,R6

R25,R26

375 SG00054 SMD integrated circuit AK4393VF AKM IC2

376 SG00061 SMD integrated circuit AK5383VS AKM IC1

377 SG00040 SMD integrated circuit MC33078DT(ST)MC33078D(ON) IC3,IC4,IC5,IC6

378 AE00221 tin soldering paste SJ-617

379 AC00002 solder wire 63/37%

380 HI00143 manual reposition switch A0701HM-8A

381 HA02659 wire

382 HA02660 wire

383 HA02661 wire

384 HA02678 wire

8P-8P 160mm UL2651 28AWG PH1.27mm

14P-14P 460mm UL2651 28AWG PH1.27mm

20P-20P 460mm UL2651 28AWG PH1.27mm

10P *3 540mm UL2651 28AWG PH1.27mm

385 HA01502 header wiring 6P-6P 120

386 HA01661

387 HA01660

388 HA01659

389 HA01658

header wiring FL-0464A

header wiring FL-0464A

header wiring FL-0464A

header wiring FL-0464A

20P-20P PH1.27 65

14P-14P PH1.27mm 65mm

8P-8P PH1.27 75

6P-6P PH1.27 65

390 HA01241 wire 480mm UL1015 14AWG brown

391 HA01248 single terminal wiring 150mm UL1015 14AWG brown

392 NA00116 PE bag 0.04t*170*100mm

393 NI01867 self-adhere foot cushion 20.5*14*7.6mm(SF-006)

394 NI00389 washer

φ12*φ16*0.5

395 NI00375 film 45*60.5*0.5mm

396 MJ01227 cushion MISTRAL2500

397 MJ01228 cushion MISTRAL2500 2.0t*422*15

398 MJ01154 single light board 2.0t*1850*950mm 27.6kg

399 HK04156 PC board P-MIS40MN CH1(MISTRAL2500)

400 HB01394 PCB MIS60MNCH1_VER041020

401 RA00211 fixed resistor 1/4W

402 RA00239 fixed resistor 1/4W

403 RA00266 fixed resistor 1/4W

404 RA00174 fixed resistor 1/4W

405 RA00299 fixed resistor 1/4W

406 RA00200 fixed resistor 1/4W

407 RA00616 fixed resistor 1/4W

408 RA00217 fixed resistor 1/4W

409 RA00158 fixed resistor 1/4W

410 RA00246 fixed resistor 1/4W

411 RA00219 fixed resistor 1/4W

412 RA00282 fixed resistor 1/4W

413 RA00184 fixed resistor 1/4W

414 RA00242 fixed resistor 1/4W

415 RA00908 fixed resistor 1/2W

820Ω M type

8.2KΩ M type
47KΩ M type
47Ω M type
330KΩ M type
330Ω M type
470Ω M type

1.5KΩ M type

0.0Ω M type
15KΩ M type

1.8KΩ M type
100KΩ M type
100Ω M type
10KΩ M type
68KΩ P type

R1_14,R1_18

R1_53

R1_47

R1_52

R1_42,R1_48

R1_10,R1_55

R1_9

R1_45

R1_2

R1_11,R1_64

R1_1

R1_43,R1_46,R1_51

R1_57

R1_54,R1_8

R1_58

No. Part No. Descriptions Specification Remark

416 RA00909 fixed resistor 1/2W

417 RB00010 resistor networks 1/8W

418 RA00027

419 RA00007

420 RA00020

421 RA00051

422 RA00953

423 RA00062

metal-oxide-film resistor 1W

metal-oxide-film resistor 1W

metal-oxide-film resistor 1W

metal-oxide-film resistor 2W

metal-oxide-film resistor 5W

metal-oxide-film resistor 3W

424 RA00880 cement resistor 5W

425 RA00870 cement resistor 5W

426 RA00869 cement resistor 5W

427 RA00981 cement resistor 10W

82KΩ P type
10KΩ 8P C Type

5.6Ω P type
22Ω P type

6.8KΩ P type

5.6Ω P type
10KΩ P type

1.0KΩ RSS P type

0.22Ω SQM type
12Ω SQM type

1KΩ SQM type

3.3KΩ SQM type

R1_56

RB1_1

R1_22,R1_62

R1_25,R1_32

R1_44

R1_39

R1_49

R1_63

R1_28,R1_29,R1_30,R1_31,
R1_33,R1_34,R1_36,R1-35

R1_40,R1_41

R1_23,R1_24

R1_15,R1_19

428 CA00010 ceramic capacitor 27PF NPO C1_10

429 CA00018 ceramic capacitor 56PF NPO C1_36,C1_35,C1_7

430 CA00024 ceramic capacitor 100PF SL C1_3,C1_4

431 CA00043 ceramic capacitor 0.0033uF C1_13,C1_14

432 CA00070 ceramic capacitor 0.022uF/50V±20% Y5U C1_11

433 CA00047 ceramic capacitor 0.033uF C1_12

434 CA00053 ceramic capacitor 0.1uF SL C1_44

435 CF00022 metal-film capacitor MSC 0.022uF/100V 5% CASE01 C1_40

436 CF00013 metal-film capacitor MEF 0.068uF/250V C1_31

437 CB00185 electrolytic capacitor

438 CB00177 electrolytic capacitor

439 CB00169 electrolytic capacitor

440 CB00039 electrolytic capacitor

441 CB00149 electrolytic capacitor

442 CB00055 electrolytic capacitor

443 CB00171 electrolytic capacitor

444 CB00057 electrolytic capacitor

445 CB00067 electrolytic capacitor

446 CB00170 electrolytic capacitor

447 SA00167 bridge rectifier 2A W2-04

10uF/63V φ5*11mm
22uF/50V φ5*11mm
47uF/16V NP φ6.3*11mm
47uF/25V φ5*11mm
47uF/63V φ6*11mm
220uF/16V φ8*11mm
220uF/16V NP φ10*12.5mm
220uF/25V φ8*11mm
470uF/35V φ10*20mm

1000uF/100V φ18*35.5mm

C1_32,C1_43

C1_2,C1_1,R1-43

C1_9

C1_5

C1_33

C1_37

C1_34

C1_8,C1_45

C1_42

C1_15,C1_16,C1_17,C1_18,
C1_19,C1_20,C1_21,C1_22,
C1_23,C1_24,C1_25,C1_26

D1_19,D1_2,D1_24,D1_27

448 SA00093 rectifier diode 1N4148 0.5A D1_11,D1_12

D1_10,D1_13,D1_14,D1_20,

449 SA00098 rectifier diode 1A/400V IN4004

D1_22,D1_23,D1_25,D1_26,
D1_28,D1_9

450 SA00187 rectifier diode IN5404 D1_15,D1_16

451 SA00002 high speed diode 1A/600V 1N4937 D1_5,D1_6

452 SA00107 zener diode 1W 15V 1N4744 D1_1,D1_4

453 SA00197 zener diode 1W 36V 1N4753 D1_21

454 SA00117 zener diode 1/2W 5.6V 6B1 D1_7,D1_8

455 SA00188 zener diode 1/2W 7.5V D1_18

456 SA00026 L.E.D

φ5 circle red B1115

D1_17

457 SB00042 transistor MJE15032 Q1_1

No. Part No. Descriptions Specification Remark

458 SB00044 transistor MJE15033 Q1_2

459 SB00130 transistor MPSA42/(PHILIPS) Q1_17

460 SB00129 transistor MPSA92(TO92)/(PHI) Q1_15,Q1_16

461 SB00023 power transistor 2SA1943-O

462 SB00021 power transistor 2SC5200

Q1_6,Q1_7,Q1_8,Q1_5

Q1_10,Q1_11,Q1_12,Q1_9

463 SD00032 integrated circuit LM317T U1_4

464 SD00173 integrated circuit NJM4580L(JRC) U1_1,U1_2

465 CN00060 fixed inductance

466 RH00021 thermistor

467 RH00017 thermistor

468 RH00025 thermistor

469 RC00319 semi-fixed resistor

470 RC00348 semi-fixed resistor

2uH 10A(CSAF-302824)(φ1.5mm*12 1/2T)

500Ω(TDC5C150L)
50Ω(TDC05A050J)
100Ω(PAS7101ZF)
B100Ω PT1030-V1B101-C1-H10
B1KΩ PT1030-V1B102-C1-H10

L1_1

R1_3

R1_17

R1_50

R1_16

R1_20,R1_21

471 HI00211 rarely 8P 24VDC/16A 881H-1CC-C K1_1

472 HI00039 push-button switch SP70300-0202-11F1-N S1_1

473 HK02231 Photodiode

P-photosensitive resistanceφ5LLED

U1_5

474 RH00020 photosensitive resistance VT90N1

475 SA00201 L.E.D

476 NI02779 sleeve

477 NI00274 sleeve

478 HC00324 terminal 6.5m/m (PC250)

479 HC00056 FUSE holder 8*10.6*1.5 JEF-505

φ5 red(LI3330/A)
φ9*30mm
φ9*1000mm

JP1_1,JP1_2,JP1_5,JP1_6,
JP1_7,JP1_8

JP1_10,JP1_11,JP1_12,
JP1_9

480 HC00112 balance MIC jack 99M-107SP-1-2 90° PUSH J1_1

481 HC00111 balance MIC jack 99M-108SP1 J1_2

482 HC00504 row-wire header 10P 2.54mm 180° JP1_15,JP1_16,JP1_3

483 HC00172 row-wire header 3P 3.96mm 180° JP1_13

484 HC00077 row-wire header 3P 2.5mm 180° R1_5

485 HC00076 row-wire header 2P 2.5mm 180° JP1_14

486 HA01933 jumper wire 2.5mm J1_4,J1_5

487 HC00034 short circuit connector NO.2700 2.54mm/6mm OPEN

488 HD00029 ceramic tube fuse

15A φ6*32mm UL

489 MJ01200 spacer MISTRAL4000 14.5*30.5*2t

490 MJ01201 spacer MISTRAL4000 14.5*30.5*2t

491 MJ01154 single light board 2.0t*1850*950mm 27.6kg

492 MF00030 washer

493 MF00037 washer

494 NI00279 sleeve

495 NI00278 sleeve

φ3*φ8*0.8t
φ3*φ5*1t
φ15*20mm
φ15*1000mm

U1_4

496 NC00005 silicone insulator TO-220 square type

497 MG00171 screw M3*14

498 ND00182 silicone sleeve

499 ND00171 silicone sleeve

φ1*30mm
φ1*1000mm

500 NC00181 insulator MISTRAL4000 1.6t*136*16mm

No. Part No. Descriptions Specification Remark

501 NC00041 red foil white board 1.6t*0.65M*70M

502 MI01954 fixed bracket MISTRAL4000 1.5t*136*16mm right

503 MJ00069 iron board 1.5*2135*1220 30.67kg

504 HA02759 wire 5P-5P 120mm UL1007 24AWG

505 CA00088 ceramic capacitor 100PF/1000V Q1-1,Q1-2

506 MI02324 heat-sink 9*83*70*309 left_V1.0

507 MI02359 heat sink 9*83*70*4400 +5/-0 18.8320KG_V1.0

508 RA00713 fixed resistor 1/4W

1.0KΩ F type

C2-6

509 AC00002 solder wire 63/37%

510 AD00012 twin adhesive 90*120mm_V1.0

511 NA00279 clip-chain bag 0.04t*100*150mm_V1.0

512 HA01394 row-wire connector wiring 3P-3P 120

513 HC00295 terminal JS205-110

514 MF00020 washer

515 MF00039 washer

φ5*φ12*1t
φ5*φ8*1t

516 MD00444 protective cover 80*80mm(K-G08A05-4HA)

517 MG00128 screw M3*16

518 MI00237 heat-sink FX22 4*34.5*16.5*34.5mm

519 MI00409 fixed piece FX22

520 NI02245 heat conduction rubber 25*25*0.25 white (3M #9890)

521 HA02621 computer connect wire

9P(female)-9P(female) UL2464 28AWG 5000m

522 HK00787 PC board P-MIS2500-INPUT(MIC jack)

523 HB01104 PCB MIS40IN-2_VER031206

524 HC00077 row-wire header 3P 2.5mm 180° CN1

525 HC00110 MIC jack JY-6314-02-340 JP1

526 AC00002 solder wire 63/37%

527 HK00793 PC board P-MIS2500-INPUT

528 HB01105 PCB MIS40IN-1_VER031206

529 HC00297 terminal block DT-55-A14W-03(3PH) CN1

530 HC00077 row-wire header 3P 2.5mm 180° CN3

531 HC00079 row-wire header 5P 2.5mm 180° CN4

532 AC00002 solder wire 63/37%

533 MG00061 screw M3*10

534 MG00027 screw M3*12

535 NE02717 label MADE IN CHINA

536 NH00038 paper 0.115*1M

537 NI00028 membrane 0.110*1M

538 MG00588 screw 4.75*11.8mm

DPA4000 part list

No. Part No. Descriptions Specification Remark

1 MA04096 panel MISTRAL4000

2 MA04097 panel MISTRAL4000

3 MA04098 panel MISTRAL4000 3.1*88.8*25.5*483

4 MI01309 panel 3.1*88.8*25.5*483

5 MA04394 panel DPA4000 ALTO_V1.0

6 MA04395 panel DPA4000

7 MA04396 panel DPA4000 1.5t*22.4*81.4*422

8 MJ00088 single light board 1.5*2135*1220 30.67kg

9 MB02959 rear board DPA4000_V1.0

10 MB02960 rear board DPA4000_V1.2

11 MB02961 rear board DPA4000 1.5t*85.5*370*430_V1.2

12 MJ00088 single light board 1.5*2135*1220 30.67kg

13 ME00051 iron pillar M3*12

14 MI01516 barrier MISTRAL4000 57*177*195

15 MJ00058 single light board 1*2135*1220 20.45kg

16 ME00001 screw pillar M4*10*0.7PH

17 ME00002 screw pillar M4*20*0.7PH

18 MC00517 top cover MISTRAL4000_V1.0

19 MC00622 top cover MISTRAL2500_V1.0

20 MC00621 top cover MISTRAL2500_V1.0

21 MJ00088 single light board 1.5*2135*1220 30.67kg

22 MI01744 handle MISTRAL4000 20*25.5*80

23 MI01745 handle MISTRAL4000 20*25.5*80

24 MI01750 fixed bracket MISTRAL4000 left L type

25 MI01751 fixed bracket

26 MJ01154 single light board 2.0t*1850*950mm 27.6kg

27 MI02452 fixed bracket DPA2500 right L type_V1.0

28 MI02781 fixed bracket MISTRAL4000 right

29 MI01753 fixed bracket

30 MJ01154 single light board 2.0t*1850*950mm 27.6kg

31 MI01746 front board MISTRAL4000 14*81*89

32 MJ00061 Zn-plated board 1*2135*1220 20.45kg

33 MI01759 barrier MISTRAL4000 0.8t*53.5*78_V1.1

34 MJ00067 single light board 1.0t*2440*1220 18.69kg

35 MI01756 barrier MISTRAL4000 0.8t*53.5*78_V1.1

36 MJ00067 single light board 1.0t*2440*1220 18.69kg

37 NI02650 knob

38 NI02651 knob fix sheath

39 NI01863 key

40 NI02145 acrylic panel DPA series ALTO_V1.1

41 NI02146 acrylic panel DPA4000 (3t*40*47mm)

MISTRAL4000 left L type

MISTRAL4000 right Type

φ18*18mm
10*φ22.5
φ5.5*W10*7.5

No.

Part No. Descriptions Specification Remark

42 HC00005 AC socket AC-008

43 HI00031 power switch R415KKETOF

44 SA00200 bridge rectifier 40A/400V BP40-04

45 HA01243 wire 300mm UL1015 14AWG brown

46 HA01333

single terminal wiring

150mm UL1015 18AWG green/yellow

47 HA01247 single terminal wiring 180mm UL1015 14AWG blue

48 HA02469 wire 3P-3P 480mm 28AWG blue

49 HA02470 wire 3P-3P 600mm 28AWG blue

50 HA02452 wire

10Pfema*3 415mm UL2651 28AWG PH1.27mm

51 HA02448 wire 530mm UL1015 14AWG red

52 HA02449 wire 700mm UL1015 14AWG black

53 HA01244 2 terminal wiring 380mm UL1015 14AWG red

54 HA01198 wire 180mm UL1015 14AWG black

55 MG00247 copper pillar M3*10*0.5PHsingle length16

56 MG00061 screw M3*10

57 MG00295 screw M4*6

58 MG00025 screw M3*6

59 MG00042 screw M3*10

60 MF00037 washer

φ3*φ5*1t

61 ME00015 nut 3m/m

62 MF00038 washer

φ4*φ7*1t

63 ME00016 nut 4m/m

64 MF00048 washer

65 MF00018 washer

φ4*φ8*0.5t
φ4*φ10*1t

66 MG00268 screw M5*12

67 MG00041 screw M3*6

68 MG00075 screw M4*16

69 ME00006 nut

70 MF00004 washer

71 NI00437 rubber coil

9φ

φ9*φ14*0.5t
φ20*φ120*2tB

72 MG00556 screw M8*82.5*1.25PH_V1.0

73 ME00026 nut 8m/m

74 MF00026 washer

75 MF00041 washer

76 MH00766 iron piece

77 MH00768 iron piece

φ8*φ18*1.5t
φ8*φ13.5*2t
φ11* φ90*2_V1.1
φ11* φ90*2_V1.1

78 MJ01154 single light board 2.0t*1850*950mm 27.6kg

79 TD00263 transformer PT-DPA4000_115/230V

80 NI00252 sleeve

81 NI00248 sleeve

82 HE00050 fan

φ4*20mm
φ4*1000mm

DV12V/0.37A 80*80*25 360mm JST2P

83 NI00312 power switch button square 5*5*9 hole 2.8*2.8 black

No. Part No. Descriptions Specification Remark

84 HA00871 power cord(Europe 3P) LT-322+1.5*3C(H05VV-F) 6FT+LT-501

85 NI00218 cable tie-black ALT-102SB

86 HJ00006 desiccant 30g

87 NA00135 PE bag 0.05t*610*500mm

88 NB01944 barrier PSA-3000_V1.1

89 NE08281 label DPA2500 220-240V_V1.0

90 NI00015 membrane 0.04*1M

91 NI00014 membrane 0.035*1M

92 NF00061 assurance card ALTO

93 NE12928 label DPA4000_V1.0

94 NH00012 bond paper 0.04*1M

95 NI00014 membrane 0.035*1M

96 NE11347 label ALTO PI

97 NH00334 cone paper 0.040*1m

98 NC00059 fixed board 1*46*46(Sax-2000)

99 NC00175 insulator 1.0t*51mm*100M

100 HI00141 manual reposition switch A0701HM-10A

101 HA01241 wire 480mm UL1015 14AWG brown

102 HA01248 single terminal wiring 150mm UL1015 14AWG brown

103 NA00116 PE bag 0.04t*170*100mm

104 NI01867 self-adhere foot cushion 20.5*14*7.6mm(SF-006)

105 NI00389 washer

φ12*φ16*0.5

106 NI00375 film 45*60.5*0.5mm

107 MJ01227 cushion MISTRAL2500

108 MJ01228 cushion MISTRAL2500 2.0t*422*15

109 MJ01154 single light board 2.0t*1850*950mm 27.6kg

110 HA01394 row-wire connector wiring 3P-3P 120

111 MD00444 protective cover 80*80mm(K-G08A05-4HA)

112 HA02659 wire

113 HA02660 wire

114 HA02661 wire

115 HA02678 wire

8P-8P 160mm UL2651 28AWG PH1.27mm

14P-14P 460mm UL2651 28AWG PH1.27mm

20P-20P 460mm UL2651 28AWG PH1.27mm

10P fema*3 540mm UL2651 28AWGPH1.27mm

116 HA01502 header wiring 6P-6P 120

117 HK04178 PC board P-MIS40MN CH2(MISTRAL4000)

118 HB01395 PCB MIS60MNCH2_VER050203

119 RA00211 fixed resistor 1/4W

120 RA00239 fixed resistor 1/4W

121 RA00266 fixed resistor 1/4W

122 RA00174 fixed resistor 1/4W

123 RA00299 fixed resistor 1/4W

124 RA00200 fixed resistor 1/4W

125 RA00616 fixed resistor 1/4W

126 RA00217 fixed resistor 1/4W

820Ω M type

8.2KΩ M type
47KΩ M type
47Ω M type
330KΩ M type
330Ω M type
470Ω M type

1.5KΩ M type

R2_14,R2_18

R2_53

R2_47

R2_52

R2_42,R2_48

R2_10,R2_55

R2_9

R2_45

No. Part No. Descriptions Specification Remark

127 RA00158 fixed resistor 1/4W

128 RA00246 fixed resistor 1/4W

129 RA00219 fixed resistor 1/4W

130 RA00282 fixed resistor 1/4W

131 RA00184 fixed resistor 1/4W

132 RA00242 fixed resistor 1/4W

133 RA00908 fixed resistor 1/2W

134 RA00909 fixed resistor 1/2W

135 RB00010 resistor networks 1/8W

136 RA00027 metal-oxide-film resistor 1W

137 RA00007 metal-oxide-film resistor 1W

138 RA00020 metal-oxide-film resistor 1W

139 RA00051 metal-oxide-film resistor 2W

140 RA00953 metal-oxide-film resistor 5W

141 RA00062 metal-oxide-film resistor 3W

142 RA00880 cement resistor 5W

143 RA00870 cement resistor 5W

144 RA01016 cement resistor 5W

145 RA01017 cement resistor 10W

0.0Ω M type
15KΩ M type

1.8KΩ M type
100KΩ M type
100Ω M type
10KΩ M type
68KΩ P type
82KΩ P type
10KΩ 8P C Type

5.6Ω P type
22Ω P type

6.8KΩ P type

5.6Ω P type
10KΩ P type

1.0KΩ RSS P type

0.22Ω SQM type
12Ω SQM type

2.2KΩ SQM type

4.7KΩ SQM type

R2_2

R2_11

R2_1

R2_43,R2_46,R2_51

R2_57

R2_54,R2_8

R2_58

R2_56

RB2_1

R2_22,R2_62

R2_25,R2_32

R2_44

R2_39

R2_49

R2_63

R2_27,R2_28,R2_29,R2_30,
R2_31,R2_33,R2_34,R237,
R2_36,R2-26,R2-35,R2-38

R2_41,R2_40

R2_23,R2_24

R2_15,R2_19

146 CA00010 ceramic capacitor 27PF NPO C2_10

147 CA00018 ceramic capacitor 56PF NPO C2_35,C2_36,C2_7

148 CA00024 ceramic capacitor 100PF SL C2_3,C2_4

149 CA00043 ceramic capacitor 0.0033uF C2_13,C2_14

150 CA00070 ceramic capacitor 0.022uF/50V±20% Y5U C2_11

151 CA00047 ceramic capacitor 0.033uF C2_12

152 CA00053 ceramic capacitor 0.1uF SL C2_44

153 CF00022 metal-film capacitor MSC 0.022uF/100V 5% CASE01 C2_40

154 CF00013 metal-film capacitor MEF 0.068uF/250V C2_31

155 CB00185 electrolytic capacitor

156 CB00177 electrolytic capacitor

157 CB00169 electrolytic capacitor

158 CB00039 electrolytic capacitor

159 CB00149 electrolytic capacitor

160 CB00055 electrolytic capacitor

161 CB00171 electrolytic capacitor

162 CB00057 electrolytic capacitor

163 CB00067 electrolytic capacitor

164 CB00180 electrolytic capacitor

165 SA00167 bridge rectifier 2A W2-04

10uF/63V φ5*11mm
22uF/50V φ5*11mm
47uF/16V NP φ6.3*11mm
47uF/25V φ5*11mm
47uF/63V φ6*11mm
220uF/16V φ8*11mm
220uF/16V NP φ10*12.5mm
220uF/25V φ8*11mm
470uF/35V φ10*20mm

470uF/160V φ18*45mm

C2_32,C2_43

C2_1,C2_2,R2-43

C2_9

C2_5

C2_33

C2_37

C2_34

C2_8,C2_45

C2_42

C2_15,C2_16,C2_17,C2_18,
C2_19,C2_20,C2_21,C2_22,
C2_23,C2_24,C2_25,C2_26,
C2_27,C2_28,C2_29,C2_30

D2_2,D2_19,D2_24,D2_27

166 SA00093 rectifier diode 1N4148 0.5A D2_11,D2_12

D2_10,D2_13,D2_14,D2_20,

167 SA00098 rectifier diode 1A/400V IN4004

D2_22,D2_23,D2_25,D2_26,
D2_28,D2_9

No. Part No. Descriptions Specification Remark

168 SA00187 rectifier diode IN5404 D2_15,D2_16

169 SA00002 high speed diode 1A/600V 1N4937 D2_5,D2_6

170 SA00107 zener diode 1W 15V 1N4744 D2_1,D2_4

171 SA00197 zener diode 1W 36V 1N4753 D2_21

172 SA00117 zener diode 1/2W 5.6V 6B1 D2_7,D2_8

173 SA00188 zener diode 1/2W 7.5V D2_18

174 SA00026 L.E.D

φ5 circle red B1115

D2_17

175 SB00042 transistor MJE15032 Q2_1

176 SB00044 transistor MJE15033 Q2_2

177 SB00130 transistor MPSA42/(PHILIPS) Q2_17

178 SB00129 transistor MPSA92(TO92)/(PHI) Q2_15,Q2_16

179 SB00023 power transistor 2SA1943-O

180 SB00021 power transistor 2SC5200

Q2_5,Q2_6,Q2_7,Q2_8,
Q2_4,Q2_3
Q2_9,Q2_10,Q2_11,Q2_12,
Q2_13,Q2_14

181 SD00032 integrated circuit LM317T U2_4

182 SD00173 integrated circuit NJM4580L(JRC) U2_1,U2_2

183 CN00060 fixed inductance

184 RH00021 thermistor

185 RH00017 thermistor

186 RH00025 thermistor

187 RC00319 semi-fixed resistor

188 RC00348 semi-fixed resistor

2uH 10A(CSAF-302824)(φ1.5mm*12

1/2T)

500Ω(TDC5C150L)
50Ω(TDC05A050J)
100Ω(PAS7101ZF)
B100Ω PT1030-V1B101-C1-H10
B1KΩ PT1030-V1B102-C1-H10

L2_1

R2_3

R2_17

R2_50

R2_16

R2_20,R2_21

189 HI00211 relay 8P 24VDC/16A 881H-1CC-C K2_1

190 HI00039 push-button switch SP70300-0202-11F1-N S2_1

191 HK02231 Photodiode

P-photosensitive resistanceφ5LLED

U2_5

192 RH00020 photosensitive resistance VT90N1

193 SA00201 L.E.D

194 NI02779 sleeve

195 NI00274 sleeve

196 HC00324 terminal 6.5m/m (PC250)

197 HC00056 FUSE holder 8*10.6*1.5 JEF-505

φ5 red(LI3330/A)
φ9*30mm
φ9*1000mm

JP2_1,JP2_2,JP2_5,JP2_6,
JP2_7,JP2_8
JP2_9,JP2_10,JP2_11,
JP2_12

198 HC00112 balance MIC jack 99M-107SP-1-2 90° PUSH J2_1

199 HC00111 balance MIC jack 99M-108SP1 J2_2

200 HC00504 row-wire header 10P 2.54mm 180° JP2_15,JP2_16,JP2_3

201 HC00172 row-wire header 3P 3.96mm 180° JP2_13

202 HC00077 row-wire header 3P 2.5mm 180° R2_5

203 HC00076 row-wire header 2P 2.5mm 180° JP2_14

204 HA01933 jumper wire 2.5mm J2_4,J2_5

205 HC00034 short circuit connector NO.2700 2.54mm/6mm OPEN

206 HD00029 ceramic tube fuse

15A φ6*32mm UL

207 MI02325 heat-sink 9*83*70*309 right_V1.0

208 MI02359 heat sink 9*83*70*4400 +5/-0 18.8320KG_V1.0

209 MJ01200 spacer MISTRAL4000 14.5*30.5*2t

No. Part No. Descriptions Specification Remark

210 MJ01201 spacer MISTRAL4000 14.5*30.5*2t

211 MJ01154 single light board 2.0t*1850*950mm 27.6kg

212 MF00030 washer

213 MF00037 washer

φ3*φ8*0.8t
φ3*φ5*1t

214 NC00005 silicone insulator TO-220 square type

215 MG00171 screw M3*14

216 ND00182 silicone sleeve

217 ND00171 silicone sleeve

φ1*30mm
φ1*1000mm

218 NC00181 insulator MISTRAL4000 1.6t*136*16mm

219 NC00041 red foil white board 1.6t*0.65M*70M

220 MI01954 fixed bracket MISTRAL4000 1.5t*136*16mm right

221 MJ00069 iron board 1.5*2135*1220 30.67kg

222 HA02759 wire 5P-5P 120mm UL1007 24AWG

223 CA00088 ceramic capacitor 100PF/1000V Q2-1,Q2-2

224 RA00713 fixed resistor 1/4W

1.0KΩ F type

C2-6

225 AC00002 solder wire 63/37%

226 HK00793 PC board P-MIS2500-INPUT

227 HB01105 PCB MIS40IN-1_VER031206

228 HC00297 terminal block DT-55-A14W-03(3PH) CN1

229 HC00077 row-wire header 3P 2.5mm 180° CN3

230 HC00079 row-wire header 5P 2.5mm 180° CN4

231 AC00002 solder wire 63/37%

232 HK00787 PC board P-MIS2500-INPUT(MIC jack)

233 HB01104 PCB MIS40IN-2_VER031206

234 HC00077 row-wire header 3P 2.5mm 180° CN1

235 HC00110 MIC jack JY-6314-02-340 JP1

236 AC00002 solder wire 63/37%

237 HK04177 PC board P-MIS40MN CH1(MISTRAL4000)

238 HB01394 PCB MIS60MNCH1_VER041020

239 RA00211 fixed resistor 1/4W

240 RA00239 fixed resistor 1/4W

241 RA00266 fixed resistor 1/4W

242 RA00174 fixed resistor 1/4W

243 RA00299 fixed resistor 1/4W

244 RA00200 fixed resistor 1/4W

245 RA00616 fixed resistor 1/4W

246 RA00217 fixed resistor 1/4W

247 RA00158 fixed resistor 1/4W

248 RA00246 fixed resistor 1/4W

249 RA00219 fixed resistor 1/4W

250 RA00282 fixed resistor 1/4W

251 RA00184 fixed resistor 1/4W

252 RA00242 fixed resistor 1/4W

820Ω M type

8.2KΩ M type
47KΩ M type
47Ω M type
330KΩ M type
330Ω M type
470Ω M type

1.5KΩ M type

0.0Ω M type
15KΩ M type

1.8KΩ M type
100KΩ M type
100Ω M type
10KΩ M type

R1_14,R1_18

R1_53

R1_47

R1_52

R1_42,R1_48

R1_10,R1_55

R1_9

R1_45

R1_2

R1_11,R1_64

R1_1

R1_43,R1_46,R1_51

R1_57

R1_54,R1_8

No. Part No. Descriptions Specification Remark

253 RA00908 fixed resistor 1/2W

254 RA00909 fixed resistor 1/2W

255 RB00010 resistor networks 1/8W

256 RA00027 metal-oxide-film resistor 1W

257 RA00007 metal-oxide-film resistor 1W

258 RA00020 metal-oxide-film resistor 1W

259 RA00051 metal-oxide-film resistor 2W

260 RA00953 metal-oxide-film resistor 5W

261 RA00062 metal-oxide-film resistor 3W

262 RA00880 cement resistor 5W

263 RA00870 cement resistor 5W

264 RA01016 cement resistor 5W

265 RA01017 cement resistor 10W

68KΩ P type
82KΩ P type
10KΩ 8P C Type

5.6Ω P type
22Ω P type

6.8KΩ P type

5.6Ω P type
10KΩ P type

1.0KΩ RSS P type

0.22Ω SQM type
12Ω SQM type

2.2KΩ SQM type

4.7KΩ SQM type

R1_58

R1_56

RB1_1

R1_22,R1_62

R1_25,R1_32

R1_44

R1_39

R1_49

R1_63

R1_27,R1_28,R1_29,R1_30,
R1_31,R1_33,R1_34,R1_36,
R1_37,R1-26,R1-35,R1-38

R1_40,R1_41

R1_23,R1_24

R1_15,R1_19

266 CA00010 ceramic capacitor 27PF NPO C1_10

267 CA00018 ceramic capacitor 56PF NPO C1_36,C1_35,C1_7

268 CA00024 ceramic capacitor 100PF SL C1_3,C1_4

269 CA00043 ceramic capacitor 0.0033uF C1_13,C1_14

270 CA00070 ceramic capacitor 0.022uF/50V±20% Y5U C1_11

271 CA00047 ceramic capacitor 0.033uF C1_12

272 CA00053 ceramic capacitor 0.1uF SL C1_44

273 CF00022 metal-film capacitor MSC 0.022uF/100V 5% CASE01 C1_40

274 CF00013 metal-film capacitor MEF 0.068uF/250V C1_31

275 CB00185 electrolytic capacitor

276 CB00177 electrolytic capacitor

277 CB00169 electrolytic capacitor

278 CB00039 electrolytic capacitor

279 CB00149 electrolytic capacitor

280 CB00055 electrolytic capacitor

281 CB00171 electrolytic capacitor

282 CB00057 electrolytic capacitor

283 CB00067 electrolytic capacitor

284 CB00180 electrolytic capacitor

285 SA00167 bridge rectifier 2A W2-04

10uF/63V φ5*11mm
22uF/50V φ5*11mm
47uF/16V NP φ6.3*11mm
47uF/25V φ5*11mm
47uF/63V φ6*11mm
220uF/16V φ8*11mm
220uF/16V NP φ10*12.5mm
220uF/25V φ8*11mm
470uF/35V φ10*20mm

470uF/160V φ18*45mm

C1_32,C1_43

C1_2,C1_1,R1-43

C1_9

C1_5

C1_33

C1_37

C1_34

C1_8,C1_45

C1_42

C1_15,C1_16,C1_17,C1_18,
C1_19,C1_20,C1_21,C1_22,
C1_23,C1_24,C1_25,C1_26,
C1_27,C1_28,C1_29,C1_30

D1_19,D1_24,D1_27,D1_2

286 SA00093 rectifier diode 1N4148 0.5A D1_11,D1_12

D1_10,D1_13,D1_14,D1_20,

287 SA00098 rectifier diode 1A/400V IN4004

D1_22,D1_23,D1_25,D1_26,
D1_28,D1_9

288 SA00187 rectifier diode IN5404 D1_15,D1_16

289 SA00002 high speed diode 1A/600V 1N4937 D1_5,D1_6

290 SA00107 zener diode 1W 15V 1N4744 D1_1,D1_4

291 SA00197 zener diode 1W 36V 1N4753 D1_21

292 SA00117 zener diode 1/2W 5.6V 6B1 D1_7,D1_8

No. Part No. Descriptions Specification Remark

293 SA00188 zener diode 1/2W 7.5V D1_18

294 SA00026 L.E.D

φ5 circle red B1115

D1_17

295 SB00042 transistor MJE15032 Q1_1

296 SB00044 transistor MJE15033 Q1_2

297 SB00130 transistor MPSA42/(PHILIPS) Q1_17

298 SB00129 transistor MPSA92(TO92)/(PHI) Q1_15,Q1_16

299 SB00023 power transistor 2SA1943-O

300 SB00021 power transistor 2SC5200

Q1_6,Q1_7,Q1_8,Q1_5,
Q1_4,Q1_3

Q1_10,Q1_11,Q1_12,Q1_9,
Q1_13,Q1_14

301 SD00032 integrated circuit LM317T U1_4

302 SD00173 integrated circuit NJM4580L(JRC) U1_1,U1_2

303 CN00060 fixed inductance

304 RH00021 thermistor

305 RH00017 thermistor

306 RH00025 thermistor

307 RC00319 semi-fixed resistor

308 RC00348 semi-fixed resistor

2uH 10A(CSAF-302824)(φ1.5mm*12

1/2T)

500Ω(TDC5C150L)
50Ω(TDC05A050J)
100Ω(PAS7101ZF)
B100Ω PT1030-V1B101-C1-H10
B1KΩ PT1030-V1B102-C1-H10

L1_1

R1_3

R1_17

R1_50

R1_16

R1_20,R1_21

309 HI00211 relay 8P 24VDC/16A 881H-1CC-C K1_1

310 HI00039 push-button switch SP70300-0202-11F1-N S1_1

311 HK02231 Photodiode

P-photosensitive resistanceφ5LLED

U1_5

312 RH00020 photosensitive resistance VT90N1

313 SA00201 L.E.D

314 NI02779 sleeve

315 NI00274 sleeve

316 HC00324 terminal 6.5m/m (PC250)

317 HC00056 FUSE holder 8*10.6*1.5 JEF-505

φ5 red(LI3330/A)
φ9*30mm
φ9*1000mm

JP1_1,JP1_2,JP1_5,JP1_6,
JP1_7,JP1_8

JP1_10,JP1_11,JP1_12,
JP1_9

318 HC00112 balance MIC jack 99M-107SP-1-2 90° PUSH J1_1

319 HC00111 balance MIC jack 99M-108SP1 J1_2

320 HC00504 row-wire header 10P 2.54mm 180° JP1_15,JP1_16,JP1_3

321 HC00172 row-wire header 3P 3.96mm 180° JP1_13

322 HC00077 row-wire header 3P 2.5mm 180° R1_5

323 HC00076 row-wire header 2P 2.5mm 180° JP1_14

324 HA01933 jumper wire 2.5mm J1_4,J1_5

325 HC00034 short circuit connector NO.2700 2.54mm/6mm OPEN

326 HD00029 ceramic tube fuse

15A φ6*32mm UL

327 MI02324 heat-sink 9*83*70*309 left_V1.0

328 MI02359 heat sink 9*83*70*4400 +5/-0 18.8320KG_V1.0

329 MJ01200 spacer MISTRAL4000 14.5*30.5*2t

330 MJ01201 spacer MISTRAL4000 14.5*30.5*2t

331 MJ01154 single light board 2.0t*1850*950mm 27.6kg

332 MF00030 washer

333 MF00037 washer

334 NI00279 sleeve

φ3*φ8*0.8t
φ3*φ5*1t
φ15*20mm

U1_4

No. Part No. Descriptions Specification Remark

335 NI00278 sleeve

φ15*1000mm

336 NC00005 silicone insulator TO-220 square type

337 MG00171 screw M3*14

338 ND00182 silicone sleeve

339 ND00171 silicone sleeve

φ1*30mm
φ1*1000mm

340 NC00181 insulator MISTRAL4000 1.6t*136*16mm

341 NC00041 red foil white board 1.6t*0.65M*70M

342 MI01954 fixed bracket MISTRAL4000 1.5t*136*16mm right

343 MJ00069 iron board 1.5*2135*1220 30.67kg

344 HA02759 wire 5P-5P 120mm UL1007 24AWG

345 CA00088 ceramic capacitor 100PF/1000V Q1-1,Q1-2

346 RA00713 fixed resistor 1/4W

1.0KΩ F type

C2-6

347 AC00002 solder wire 63/37%

348 HK01708 PC board P-MIS40PWR(MIS4000)

349 HB00946 PCB MIS40PWR_VER030710

350 HC00324 terminal 6.5m/m (PC250)

P1,P2,P3,P4,P5,P6,P7,P8

351 CG00044 metal oxide varsities NP35L-Y2 K2-2

352 AC00002 solder wire 63/37%

353 HK03959 PC board P-MIS40FP2

354 HB00947 PCB MIS40FP2_VER030710

355 SA00191 L.E.D

356 SA00053 L.E.D

φ3 (LEG2062)
φ3 round(red)long foot 26mm

D1_1,D2_1

D1+3,D2_3

357 SA00054 L.E.D 3m/m round(yellow)long foot 26 D1_30,D2_30

358 HC00066 row-wire header 3P 2.5mm 90° CN1_1,CN2_1

359 RC00209 PPBC239

360 SA00194 L.E.D

A10KΩ RV110-40E1-225A-A14
φ3

VR1_1,VR2_1

D1_29,D2_29

361 NI01765 LED spacer support LEDS-10 10mm

362 HA02450 wire

363 HA02451 wire

10P-10P 350mm UL2651 28AWG PH1.27mm

10P-10P 250mm UL2651 28AWG PH1.27mm

JP2_22

JP1_22

364 AC00002 solder wire 63/37%

365 HK04608 PC board P-MIS60SP

366 HC00442 speaker socket NL4MP (NEUTRIK) SPK1,SPK2

367 MJ00942 fixed bracket CS12/600

368 MJ00061 Zn-plated board 1*2135*1220 20.45kg

369 HA01239

370 HA01237

single terminal wiring CF:W209

single terminal wiring CF:W207

180mm UL1015 14AWG white JP5

200mm UL1015 14AWG gray JP2

371 HA02471 single terminal wiring 360mm UL1015 14AWG white JP7

372 HA01258 single terminal wiring 380mm UL1015 14AWG gray JP8

373 HA03432 single terminal wiring 100mm UL1015 14AWG JP1,JP3

374 HA03433 single terminal wiring 100mm UL1015 14AWG JP6,JP4

375 HB01396 PCB MIS60SP(2*4)_VER040922

376 AC00002 solder wire 63/37%

377 HK03845 PC board P-DPA2500-PWR-DIP

No. Part No. Descriptions Specification Remark

378 CB00024 electrolytic capacitor

379 CB00072 electrolytic capacitor

10uF/16V φ4*7mm
1000uF/25V φ10*20mm

C1,C3,C10,C11

C9,C8

380 SD00074 integrated circuit L7805CV(TO-220)(ST) U3

381 SD00169 integrated circuit L7905CV(TO-220)(ST) U4

382 HC00066 row-wire header 3P 2.5mm 90° CN2

383 HC00560 row pin (single)#2200 2.54 180° 2*5P 6/11.6mm CN1

384 HC00070 row-wire header 6P 2.5mm 90° CN3

385 HI00161 relay RY-5W-K,5V REL1

386 HC00047 row-wire header 6PIN A28b-6B.T.6 J7

387 HC00048 row-wire header 8PIN A28b-8B.T.6 J1,J6

388 HC00051 row-wire header 20PIN A28b-20B.T.6 J2,J3

389 HC00050 row-wire header 14PIN A28b-14B.T.6 J5,J4

390 NC00005 silicone insulator TO-220 square type

391 NI00863 insulate bean TO220B

392 MG00270 screw M3*10

393 MI01820 fixed bracket DPA4000 2.5t*42.5*83.8*102.5

394 MJ00093 AL plate 2.5*2000*1000 13.6kg

395 MG00252 copper pole M3*6.2*0.5PHsingle,length12

396 MG00363 copper pillar M3*14*0.5PH

397 MG00269 screw M3*6

398 HK00602 PC board P-DPA2500-PWR-SMD

399 HB01072 PCB DPA-PWR_VER030916

400 CI00075

401 CI00051

SMD ceramic capacitor
0603
SMD ceramic capacitor
0603

402 RD00101 SMD fixed resistor 1/10W

403 RD00081 SMD fixed resistor 1/10W

404 RD00085 SMD fixed resistor 1/10W

405 RD00059 SMD fixed resistor 1/10W

0.1uF/50V Y5V +80,-20% C7,C12,C13,C14,C15

22PF/50V NPO ±5% C2,C4,C5,C6

10KΩ ±5% 0603
750Ω ±5% 0603

1.5KΩ ±5% 0603

0.0Ω ±5% 0603

R1,R3,R6,R8,R10,R11

R2,R4

R12,R13,R14,R15,R16,R17,
R18,R19,R20,R21,R22,R23,
R24,R25,R26,R27,R28,R29

R30,R9

406 SE00011 SMD rectifier diode RLS4148 0.5A (LL-34) D1

407 SF00056 transistor MMBT3904(SOT-23)/(PHI) Q2

408 SG00040 SMD integrated circuit MC33078DT(ST)MC33078D(ON) U1,U2

409 SE00030 SMD rectifier diode SFS1B D2,D3,D4,D5

410 RD00088 SMD fixed resistor 1/10W

2.2KΩ ±5% 0603

R5,R7

411 AE00221 tin soldering paste SJ-617

412 AC00002 solder wire 63/37%

413 HK03846 PC board P-DPA2500-DISPLAY

414 HB01071 PCB DPA-DIS-1(2*2)_VER050120

415 CH00017 laminated capacitor 0.1uF/50V Y5V PH5 C1

416 CB00026 electrolytic capacitor

417 RA00647 fixed resistor 1/8W

418 RA00651 fixed resistor 1/8W

10uF/50V φ6*7mm

4.7KΩ M type
10KΩ M type

C2

R1,R2

R3,R4,R5,R6,R7,R8

No. Part No. Descriptions Specification Remark

419 HB01070 PCB DPA-DIS-2_VER030916

420 HH00005 seven paragraph monitor LSD3561-10 DL2,DL3

421 HC00435 row pin (single)#1100 2.54 180° 5P6/11.6mm CN3,CN4

422 SA00051 L.E.D

423 SA00072 L.E.D

φ3 orange, green BOG303b
φ3 red LI2340/A

DL11

DL1,DL4,DL5,DL6,DL7,DL8,
DL9,DL10

424 SB00072 transistor BC559C,126 TR1,TR2

425 HI00238 push-button switch 2 stage 6P PS-9226A(NON-LOCK) SW1,SW2,SW3,SW4

426 HC00050 row-wire header 14PIN A28b-14B.T.6 CN1

427 HC00051 row-wire header 20PIN A28b-20B.T.6 CN2

428 HA01919 jumper wire 5mm J1,J2,J3,J6,J9

429 HA02249 wire

φ0.6

430 HA01917 jumper wire 3mm J4,J8,J10

431 HA01920 jumper wire 6mm J5,J7,J3

432 HA02249 wire

433 NI01771 LED spacer support LEDS-5 5mm

φ0.6

DL1,DL10,DL11,DL4,DL5,
DL6,DL7,DL8,DL9

434 MG00269 screw M3*6

435 NI01876 LED spacer support 7.6*4.5*184

436 AC00002 solder wire 63/37%

437 HK03847 PC board P-DPA2500-RS-DIP

438 HK00603 PC board P-DPA2500-RS-SMD

439 HB01073 PCB DPA-RS_VER031103

440 CI00075

SMD ceramic capacitor 0603

441 RD00372 SMD precise resistor 1/8W

0.1uF/50V Y5V +80,-20%

10.7Ω ±1% 0805

C1,C2,C4,C5,C6,C7,C8

R3,R4

442 SG00047 SMD integrated circuit MAX485EESA IC1

443 CO00006 SMD chip inductance BLM21A102SPT/(MURATA) L1,L2,L3,L4,L5

444 AE00221 tin soldering paste SJ-617

445 HC00324 terminal 6.5m/m (PC250)

446 CB00040 electrolytic capacitor

47uF/25V φ5*11mm

C3

447 SA00101 zener diode 1W 6.8V 1N4736 D1,D2

448 SA00104 zener diode 1W 10V 1N4740 D3,D4

449 SD00019 integrated circuit MAX202ECPE IC2

450 HA02503 wire

9P-10P 50mm UL2651 28AWG
PH1.27mm

CN1

451 HC00048 row-wire header 8PIN A28b-8B.T.6 CN2

452 HC00111 balance MIC jack 99M-108SP1 S1

453 HC00112 balance MIC jack 99M-107SP-1-2 90° PUSH S2

454 AC00002 solder wire 63/37%

455 HK03830 PC board P-313089-4-DIP

456 CB00048 electrolytic capacitor

457 CB00069 electrolytic capacitor

458 RA00515 precise resistor 1/4W

100uF/25V φ6*11mm
1000uF/6.3V φ8*11mm

10.0KΩ M type

C2

C4

R12,R13

459 HC00080 row-wire header 6P 2.5mm 180°

460 HC00047 row-wire header 6PIN A28b-6B.T.6 CN4

No. Part No. Descriptions Specification Remark

,C8,

461 HC00048 row-wire header 8PIN A28b-8B.T.6 CN1

462 HC00050 row-wire header 14PIN A28b-14B.T.6 CN6

463 HC00051 row-wire header 20PIN A28b-20B.T.6 CN5

464 SC00319 crystal oscillator 12.288MHZ XT1

465 HC00162 row pin (single)#6100

1.27 180°14P(gold-plated) 6.0/11.54mm

CN2,CN7

466 ND00098 EV bubble sponge 40*14*5

467 HK03831 PC board P-313089-4-SMD

468 HB00400 PCB 313089 (90*77.5)_VER020507

469 CI00046

470 CI00049

471 CI00051

472 CI00075

SMD ceramic capacitor 1206

SMD ceramic capacitor 0603

SMD ceramic capacitor 0603

SMD ceramic capacitor 0603

1uF/16V Y5V-1206(3216) C28

15PF/50V NPO ±5% C12,C14

22PF/50V NPO ±5% C29

C1,C10,C11,C13,C15,C17,
C16,C18,C19,C20,C21,C22,

0.1uF/50V Y5V +80,-20%

C23,C24,C25,C27,C3,C30,
C31,C32,C33,C34,C35,C6,

C9

C7

473 CL00006 SMD tantalum capacitor 10uF/16V case B2 C26,C5

474 RD00068 SMD fixed resistor 1/10W

475 RD00073 SMD fixed resistor 1/10W

476 RD00076 SMD fixed resistor 1/10W

477 RD00079 SMD fixed resistor 1/10W

478 RD00082 SMD fixed resistor 1/10W

479 RD00085 SMD fixed resistor 1/10W

480 RD00086 SMD fixed resistor 1/10W

481 RD00093 SMD fixed resistor 1/10W

482 RD00101 SMD fixed resistor 1/10W

483 RD00125 SMD fixed resistor 1/10W

484 RE00006

485 RE00008

486 RE00007

SMD resistor networks 1/16W

SMD resistor networks 1/16W

SMD resistor networks 1/16W

100Ω ±5% 0603
220Ω ±5% 0603

330Ω ±5% 0603
560Ω ±5% 0603
820Ω ±5% 0603

1.5KΩ ±5% 0603

1.8KΩ ±5% 0603

4.7KΩ ±5% 0603
10KΩ ±5% 0603

1.0MΩ ±5% 0603
100Ω*4 ±5% 8P 0603

4.7KΩ*4 ±5% 8P 0603
470Ω*4 ±5% 8P 0603

R14,R15,R2,R27,R29,R30,
R32,R39,R40,R6,R7,R8

R19,R20,R22,R35,R36,R37,
R38,R5

R28

R25

R16,R17

R18

R21

R3,R33,R34

R11,R24,R26,R9

R23

AR1,AR10,AR13,AR14,AR16,
AR18,AR2,AR3,AR4,AR5,
AR8

AR11,AR15,AR17,AR6,AR7

AR9

487 SE00011 SMD rectifier diode RLS4148 0.5A (LL-34) D1

488 SG00068 SMD integrated circuit 74HC14DT(SO-14)/(PHI) IC5

489 SG00049 SMD integrated circuit AS4C256K16F0-60JC IC1

490 SG00025 SMD integrated circuit 24LC64I/SN IC6

491 SG00184 SMD integrated circuit EN29F040A-70JC/DPA IC3

492 SG00217 SMD integrated circuit EN29F040A-70JC(PL032)/(E-ON)

493 SG00335 SMD integrated circuit TY-1 ALTO(LEM NO#105008)_V1.1 IC2

494 SG00128 SMD integrated circuit RED 208(LEM NO#105008)

495 SG00069 SMD integrated circuit MAX709L-CSA IC4

496 CO00006 SMD chip inductance BLM21A102SPT/(MURATA) L1,L2,L3,L4,L5,L6

497 HC00233 IC socket (PCB) PLCC32 (D03-32T.A.4) IC3

498 AE00221 tin soldering paste SJ-617

499 HK01289 PC board P-313111-SMD

500 HB00401 PCB 313111 (37*75)_VER020507

No. Part No. Descriptions Specification Remark

,

501 CI00064

502 CI00067

503 CI00071

504 CI00075

SMD ceramic capacitor 0603

SMD ceramic capacitor 0603

SMD ceramic capacitor 0603

SMD ceramic capacitor 0603

505 CL00006 SMD tantalum capacitor 10uF/16V case B2

506 RD00063 SMD fixed resistor 1/10W

507 RD00088 SMD fixed resistor 1/10W

508 RD00091 SMD fixed resistor 1/10W

509 RD00093 SMD fixed resistor 1/10W

510 RD00101 SMD fixed resistor 1/10W

680PF/50V NPO ±5﹪

C32,C33,C43,C45

0.0022uF/50V X7R ±10% C31,C46

0.01uF/50V X7R ±10% C15,C19

C18,C25,C3,C34,C35,C36,

0.1uF/50V Y5V +80,-20%

22Ω ±5% 0603

2.2KΩ ±5% 0603

3.3KΩ ±5% 0603

4.7KΩ ±5% 0603
10KΩ ±5% 0603

C37,C38,C39,C4,C41,C42,
C7,C8,C9

C1,C10,C11,C12,C13,C14,
C16,C17,C2,C20,C21,C22,
C23,C24,C26,C27,C28,C29,

C40,C44,C5,C6

C30

R10,R3,R7,R9

R12,R17,R18,R19,R21,R23,
R24,R27

R16,R20,R22,R28

R1,R13,R4,R6

R25,R26

511 SG00054 SMD integrated circuit AK4393VF AKM IC2

512 SG00061 SMD integrated circuit AK5383VS AKM IC1

513 SG00040 SMD integrated circuit MC33078DT(ST)MC33078D(ON) IC3,IC4,IC5,IC6

514 AE00221 tin soldering paste SJ-617

515 AC00002 solder wire 63/37%

516 HC00295 terminal JS205-110

517 MF00020 washer

518 MF00039 washer

φ5*φ12*1t
φ5*φ8*1t

519 HA01661 header wiring FL-0464A 20P-20P PH1.27 65

520 HA01660 header wiring FL-0464A 14P-14P PH1.27mm 65mm

521 HA01659 header wiring FL-0464A 8P-8P PH1.27 75

522 HA01658 header wiring FL-0464A 6P-6P PH1.27 65

523 MG00128 screw M3*16

524 MI00237 heat-sink FX22 4*34.5*16.5*34.5mm

525 MI00409 fixed piece FX22

526 NI02245 heat conduction rubber 25*25*0.25 white (3M #9890)

527 HA02621 computer connect wire

9P(female)-9P(female) UL2464 28AWG 5000m

528 MG00027 screw M3*12

529 NB02938 box DPA 4000 ALTO_V1.1

530 NB02086 box MACRO

531 NF01663 instruction DPA2500/4000 ALTO_V1.0

532 NH00149 paper 889*640mm

533 MG00588 screw 4.75*11.8mm

534 NE02717 label MADE IN CHINA

535 NH00038 paper 0.115*1M

536 NI00028 membrane 0.110*1M