DH07, DH07A/DH08, DH08A CONVECTED AIR DISH HEATERS
(9" Dishware)
DH07 shown
INSTALLATION, OPERATION & MAINTENANCE MANUAL
Manual P/N 92448
Rev. G 04/02/2009
Copyright © 1998 Aladdin Temp-Rite
Changes may be made to the information in this document without notification.
DH07 / DH08 CONVECTED AIR DISH HEATERS
(9" Dishware)
CONTENTS
I. |
MODELS |
4 |
II. |
RECEIVING INSPECTIONS |
4 |
III. |
INSTALLATION |
5 |
IV. |
ELECTRICAL |
6 |
V. |
START-UP |
7 |
VI. CLEANING |
8 |
|
VII. TROUBLESHOOTING |
9 |
|
VIII. PARTS LIST / DIAGRAMS |
10 |
|
IX. PREVENTATIVE MAINTENANCE |
14 |
|
X. |
SERVICE |
15 |
XI. |
WARRANTY |
15 |
|
|
|
|
DH07 / DH08 |
(9" Dishware) |
|
CONVECTED AIR DISH HEATERS |
|
|
|
|
I. MODELS
TheAladdin ConvectedAir Dish Heaters are available in two capacities. These units are designed specifically for use with a wide variety of 9” china and Alacite® dishware only.
(Not recommended for any type of pellet bases.)
The Aladdin Convected Air Dish Heaters are mobile, modularly designed products which are able to be used independently or in conjunction with other units in a tray line arrangement.
Aladdin Sales Codes |
DH07 |
DH07A |
DH08 |
DH08A |
||||
Number of Stacks |
|
2 |
|
2 |
3 |
|
3 |
|
Capacity per Stack |
60 |
60 |
60 |
|
60 |
|
||
Capacity (Total) |
120 |
120 |
180 |
180 |
||||
Overall Dimensions: |
|
|
|
|
|
|
|
|
Length |
33 |
3/4" |
33 |
3/4" |
47 |
1/8" |
47 |
1/8" |
Width |
24 |
1/2" |
24 |
1/2" |
24 |
1/2" |
24 |
1/2" |
Height |
42 |
13/16" |
42 |
13/16" |
42 13/16" |
42 13/16" |
||
Electrical Requirements: |
|
|
|
|
|
|
|
|
Voltage / Phase |
208V /1 |
240V /1 |
208V /1 |
240V / 1 |
||||
Amperage |
|
16 |
|
14 |
16 |
14 |
||
Cycle |
|
60 |
|
60 |
60 |
60 |
||
NEMAPlug Configuration |
………………………6-20P……………………… |
|||||||
Approximate Shipping Weight |
270 lbs. |
270 lbs. |
300 lbs. |
300 lbs. |
II. RECEIVING INSPECTIONS
NOTE: All Aladdin® units are factory tested for performance and certified free from defects and customer
ready prior to shipment.
You should carefully inspect your Dish Heater to assure that no damage has occurred in transit. If however, damage is detected see the following damaged goods policy. Under no condition may a damaged unit be returned to Aladdin Temp-Rite without first obtaining written permission (return authorization). No credit will be issued for claims not reported to Aladdin within ten (10) business days from receipt of shipment.
4
ALADDIN DAMAGED GOODS POLICY
There are two types of damaged merchandise:
A.VISIBLE DAMAGE OR SHORTAGE
B.CONCEALED DAMAGE
A.VISIBLE DAMAGE OR SHORTAGE - (All claims should be reported within 10 business days)
1.Receiver should refuse the damaged portion of the shipment.
2.Receiver should sign the bill of lading indicating (delivery receipt) what merchandise is being “refused due to damage” and have the driver initial the notation.
3.Receiver should note any shortages on the bill of lading (delivery receipt) in the same manner.
4.Receiver should contact Aladdin Customer Service at 1-800-888-8018 and alert them to the situation.
B.CONCEALED DAMAGE- (All claims should be reported within 10 business days)
Any receiving operation should inspect for this type of damage.
IF PRODUCT IS DAMAGED
1.Receiver should hold the shipping container and its contents in the same condition as when the damage was discovered insofar as possible and call the delivering carrier to arrange
onsite inspection within 10 days of delivery.
2.Receiver should contact Aladdin Customer Service at 1-800-888-8018 for claims processing after inspection has been completed.
III. INSTALLATION
NOTE: The installation instructions are similar for all the heaters.
A.All models are equipped with a self-leveling mechanism that is removable through the top of the unit so that adjustments can be made to the tension springs. By adding or removing springs, the proper dispensing height can be obtained. Refer to the table on page 7 to adjust the DH07 or DH08 to dispense either 9" china or Alacite® dishes. (The heaters are factory preset for china dispensing) Adjustments should be done as part of the initial equipment set-up or when a change of dinnerware occurs.
5