AIWA HS PX390 Service Manual

HS-PX390

AH, D

HS-PX597

AE, AK

SERVICE MANUAL

STEREO CASSETTE PLAYER BASIC TAPE MECHANISM : 6ZM-2 P11NF

MODEL CODE : 8ZHK5-0134<S>

8ZHK5-0164<L>

S/M Code No. 09-998-416-0R1

REVISION

2

SPECIFICATIONS<EXCEPT 390D> SPECIFICATIONS<390D>

Maximum output: 4 mW + 4 mW (EIAJ 32 ohms)<390AH>

4 mW + 4 mW (EIAJ 16 ohms)<597>

Load impedance: 1632 ohms<597 only>
Power source: DC 1.2 V using supplied rechargeable battery NB-5G,

DC 1.5 V using an R6 (AA) dry cell battery,
AC house current using optional AC adaptor

Maximum dimensions 80.1 (W) x 110.2 (H) x 24.1 (D) mm (31/4 x 43/8 x 31/
Weight Approx. 164 g, 5.7 oz (including the rechargeable battery, excluding the battery case)

in.)

32

Supplied headphones HP-M041<597 only>
Type: In-ear type
Impedance: 32 ohms
Sensitivity: 105 dB/mW
Recommended commercially available headphones
Type: In-ear type/Vertical type/Headband type
Impedance: 1632 ohms
Sensitivity: 100109 dB/mW

<Battery charger RB-107>
Rated voltage: AC 230V, 50 Hz<597>

AC 115  230 V, 50/60 Hz<390AH>

 Design and specifications are subject to change without notice.

3 4

ELECTRICAL MAIN PARTS LIST

PART NO. KANRI

NO.

IC

87-A21-179-040 1H C-IC,TA2123AF
87-A20-818-040 -- C-IC,NJM2185AV<597>
87-A20-961-040 1E C-IC,MM1279XV
87-A21-277-010 -- C-IC,ML63512-122
87-A20-861-040 1A C-IC,S-80808ANNP

TRANSISTOR

89-111-624-080 0E TR,2SA1162Y
87-026-417-080 0E TR,RN1310
87-026-480-080 0E TR,RN4605
89-333-266-080 0E CHIP TR,2SC3326B
89-113-625-080 0E TR,2SA1362GR

89-341-165-080 0E CHIP TRANSISTOR 2SC4116GR
87-026-423-080 -- C-TR RN2305<597>

DIODE

87-A40-666-040 -- C-DIODE,HN2S01F

MAIN C.B

C101 87-012-273-080 0E C-CAP,U 820P-50 B
C102 87-012-273-080 0E C-CAP,U 820P-50 B
C103 87-012-273-080 0E C-CAP,U 820P-50 B
C104 87-012-273-080 0E C-CAP,U 820P-50 B
C105 87-A10-031-080 0E C-CAP,U 0.01-25 KB<390>

C105 87-016-114-080 -- C-CAP,U0.01-25B<597>
C106 87-A10-031-080 0E C-CAP,U 0.01-25 KB<390>
C106 87-016-114-080 -- C-CAP,U0.01-25B<597>
C107 87-A11-188-080 0E C-CAP,TN 22-4 AM004R
C108 87-A11-188-080 0E C-CAP,TN 22-4 AM004R

C109 87-A11-188-080 0E C-CAP,TN 22-4 AM004R
C110 87-A10-025-080 0E C-CAP,U 0.22-16Z F
C111 87-012-278-080 0E C-CAP,U 2200P-50 B
C112 87-A10-263-080 0E C-CAP,U 0.1-16ZF
C113 87-A11-188-080 0E C-CAP,TN 22-4 AM004R

C115 87-A10-707-080 0E C-CAP,U 0.47U-16 F Z
C116 87-A10-707-080 0E C-CAP,U 0.47U-16 F Z
C117 87-A10-707-080 0E C-CAP,U 0.47U-16 F Z
C118 87-016-562-080 0E C-CAP,TN 4.7-10
C119 87-A11-797-080 -- C-CAP,S 2.2-16 Z F

C120 87-A10-263-080 0E C-CAP,U 0.1-16ZF
C123 87-A10-263-080 0E C-CAP,U 0.1-16ZF
C124 87-A10-263-080 0E C-CAP,U 0.1-16ZF
C125 87-A10-706-080 0E C-CAP,U 0.33-16 ZF
C126 87-A10-707-080 0E C-CAP,U 0.47U-16 F Z

C127 87-A11-056-080 0E C-CAP,U 1-10 Z F
C128 87-A10-707-080 0E C-CAP,U 0.47U-16 F Z
C129 87-016-562-080 0E C-CAP,TN 4.7-10 SV A
C130 87-A10-260-080 0E C-CAP,U 0.1-16 K B
C131 87-A11-797-080 -- C-CAP,S 2.2-16 Z F

C132 87-A11-797-080 -- C-CAP,S 2.2-16 Z F
C133 87-016-317-080 0E C-CAP,TN 2.2-6.3
C134 87-A11-056-080 0E C-CAP,U 1-10 Z F
C135 87-A11-797-080 -- C-CAP,S 2.2-16 Z F<597>
C136 87-A11-797-080 -- C-CAP,S 2.2-16 Z F<597>

C137 87-010-805-080 0E CAP, S 1-16
C138 87-010-805-080 0E CAP, S 1-16
C141 87-010-828-080 0E CHIP CAPACITOR,U 0.033-25F
C142 87-010-828-080 0E CHIP CAPACITOR,U 0.033-25F
C143 87-010-674-080 0E CAP, ELECT 220-2

C144 87-010-674-080 0E CAP, ELECT 220-2
C148 87-A11-056-080 0E C-CAP,U 1-10 Z F
C149 87-A10-707-080 0E C-CAP,U 0.47U-16 F Z
C170 87-010-785-080 0E C-CAP,U 0.015-25 KB GRM
C201 87-010-805-080 -- CAP, S 1-16<597>

C202 87-010-805-080 -- CAP, S 1-16<597>

DESCRIPTIONREF. NO. KANRI

REF. NO. DESCRIPTIONPART NO.

NO.

C203 87-012-274-080 -- CHIP CAP,U 1000P-50B<597>
C204 87-A11-187-080 -- C-CAP,TN 10-4 AM004R<597>
C205 87-A11-188-080 -- C-CAP,TN 22-4 AM004R<597>
C207 87-A10-369-080 -- C-CAP,S 0.47-16 K B<597>
C208 87-A10-369-080 -- C-CAP,S 0.47-16 K B<597>

C209 87-016-460-080 -- C-CAP,S 0.22-16 B<597>
C210 87-016-460-080 -- C-CAP,S 0.22-16 B<597>
C301 87-A10-031-080 0E C-CAP,U 0.01-25 KB
C302 87-A10-260-080 0E C-CAP,U 0.1-16 K B
C303 87-A11-796-080 -- C-CAP,S 4.7-10 Z F

C304 87-A10-260-080 0E C-CAP,U 0.1-16 K B
C305 87-A10-025-080 0E C-CAP,U 0.22-16Z F
C306 87-A10-707-080 0E C-CAP,U 0.47U-16 F Z
C307 87-A11-056-080 0E C-CAP,U 1-10 ZF
C308 87-A10-031-080 0E C-CAP,U 0.01-25 KB

C309 87-A10-031-080 0E C-CAP,U 0.01-25 KB
C601 87-A11-189-080 0E C-CAP,TN 47-4 BM004R
C602 87-A11-188-080 0E C-CAP,TN 22-4 AM004R
C701 87-010-505-080 0E CAP,CHIP TANTALUM 1-16
C702 87-A10-263-080 0E C-CAP,U 0.1-16ZF

C703 87-A11-056-080 0E C-CAP,U 1-10 Z F
C704 87-A10-263-080 0E C-CAP,U 0.1-16ZF
C707 87-A11-056-080 0E C-CAP,U 1-10 Z F
C708 87-A10-263-080 0E C-CAP,U 0.1-16ZF

C709 87-A10-263-080 0E C-CAP,U 0.1-16ZF
C801 87-A11-812-080 -- C-CAP,E 220-4 MVS<597>
C903 87-010-831-080 0E C-CAP,U 0.1-16 ZF
C904 87-010-831-080 0E C-CAP,U 0.1-16 ZF
C907 87-012-274-080 0E CHIP CAP,U 1000P-50B

C910 87-010-831-080 0E C-CAP,U 0.1-16 ZF
C912 87-010-831-080 0E C-CAP,U 0.1-16 ZF
C980 87-010-831-080 0E C-CAP,U 0.1-16 ZF
C984 87-012-274-080 0E CHIP CAP,U 1000P-50B
J101 87-099-687-010 1A JACK,3.5BLK 4H

L901 87-A50-367-080 0E C-COIL, 10UH LQG21F
LED501 87-A90-278-080 0E C-LED,SML-210VT RED
PS401 87-A91-428-010 -- SNSR,PHOTO NJL5193K-F10
R105 87-022-281-080 -- CHIP RES U 680-1/6W F<597>
R106 87-022-281-080 -- CHIP RES U 680-1/6W F<597>

R107 87-022-281-080 -- CHIP RES U 680-1/6W F<597>
R108 87-022-281-080 -- CHIP RES U 680-1/6W F<597>
R203 87-022-252-080 -- C-RES,U36K-1/16WF<597>
R709 87-022-286-080 0E C-RES U 100K-1/16WF
R710 87-022-249-080 0E C-RES U27K 1/16WF

R983 87-012-274-080 0E CHIP CAP,U 1000P-50B
S101 87-036-379-180 0E C-SW,SL1-1-2 SS350
S102 87-A90-703-080 0E C-SW,SL 1-1-3 SSSS813-B-2B
S201 87-036-379-180 -- C-SW,SL1-1-2 SS350<597>
S701 87-A91-320-080 1A C-SW,SL 1-1-2 SSSS8A2-B-2B

S702 87-036-379-180 0E C-SW,SL1-1-2 SS350
S703 87-A90-665-280 0E C-SW,TACT LS7A2M
S704 87-A90-665-280 0E C-SW,TACT LS7A2M
S705 87-A90-665-280 0E C-SW,TACT LS7A2M
S706 87-A90-665-280 0E C-SW,TACT LS7A2M

S707 87-A91-421-010 -- SW,LEAF 6ZM-2(H)
S708 87-A91-365-080 1A C-SW,PUSH 1-1-1 SPVG21
S709 87-A91-461-010 -- SW,PUSH HXW4001
SFR301 87-A91-465-040 -- C-SFR,K 6.8K H RH03AEC
TH301 87-A90-855-080 0E C-THMS,SC20-3K102K

VR101 87-A90-116-080 1B C-VR,RTRY20KCX2V0103
X701 87-A70-151-110 1A VIB,XTAL 32.768KHZ VT-200

HEAD FLEX C.B

88-HK5-602-010 1H HEAD,ASSY 6ZM-2

CHIP RESISTOR PART CODE

Chip Resistor Part Coding

88

A

Resistor Code

Chip resistor

Wattage Type Tolerance
1/16W 1005 5% CJ

1/16W
1/10W

1/8W

1608
2125

3216

5%
5%

5%

Symbol

CJ
CJ

CJ

Figure

Value of resistor

Form

L

Dimensions (mm)

t

W

0.55

Resistor Code

108
118

128

LW t

1.0 0.5 0.35 104

1.6 0.8 0.45
2 1.25 0.45

3.2

1.6

: A
: A

5

6

IC BLOCK DIAGRAM- 1TRANSISTOR ILLUSTRATION

IC TA2123AF

B

2SA1363GR
2SC4116GR
RN1310

E

2SC3326B
RN2305
2SA1162Y

C

E1

B1

C2

C1

B2

E2

RN4605

7 8

WIRING (MAIN)

14 13 12 11 10 9 8 7 6 5 4 3 2 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14

AA

BB

CC

DD

EE

PH

FF

GG

HH

II

JJ

KK

LL

MM

NN

OO

PP

QQ

RR

SS

T T

UU

109

SCHEMATIC DIAGRAM (MAIN)

1211

IC BLOCK DIAGRAM- 2

IC NJM2185AV

IC DESCRIPTION

IC, ML63512-122

Pin No. Pin Name I/O Description

1 AF IN I H: exist music, L: no music.

2 SCLK I Input serial clock ( Not used) .

3 MUTE O H: mute OFF, L: mute ON.

4 SDATA O Output serial data (Not used).

5 F/R CONT O H: REV mode, L: FWD mode.

6 MS-SENS O H: FF/REW (include MS, BS), L: Other.

7 MOTDIR O H: counterclockwise, L: clockwise.

8 P-SNSRIN I Input photo sensor.

9 AF MOMITOR O H: when AF IN "L" level, L: when AF IN "H" level (Not used).

10 MOT ON O H: motor ON, L: motor OFF.

11 MOT BR O H: motor brake ON, L: motor brake OFF.

12 HOLD IN I H : hold OFF, L : hold ON.

13 NC - Not connected.

14 NC - Not connected.

IC MM1279XV

15 KEY MAIN I Main unit key input.

16 REMOTE I Remote controller key input.

17 P- SNSR K O Output for P-SNSR control.

18 LOAD CTL O Output for battery capacity checking.

19 LED K O Output for OPE, BATT LED control.

20 MOTOR ON L O H: when motor on "L" level, L: when motor on "H" level.

21 VDDI - Interface power supply for external equipment.

22 VSS - Power supply ( - ).

23 VDD - Power supply ( + ).

24 VDDH - Power supply booster for backup.

25 CB1 - Connected to capocitor for power supply booster.

26 CB2 - Connected to capocitor for power supply booster.

27 VDDL - Power supply ( + ) for internal logic.

28 XT0 - Connected to crystal oscillator for low speed.

29 XT1 - (32.768 kHz).

30 VDD - Test terminal.

31 VDD - Test terminal.

32 OSCM - Connected to capacitor for hi speed clock(Not used).

13

33 OSC0 - Connected to crystal oscillator for hi speed(Not used).

34 OSC1 - (Not used).

35 RESET I Input reset.

36 BEEP O Output beep sound.

37 CASS SW I H: not exist cassette, L: exist cassette.

38 MOTOR CH I Detect motor rotation.

39 LOAD CTL2 O Output for battery capacity checking.

40 TIMING SW I Input mechanism operation detection.

41 REMOTE DET I Switching level detector.

14

Pin No. Pin Name I/O Description

42 SET STOP I H: normal operation, L: stop mechanism.

43 P-CHECK O Output for photo sensor puls checking(Not used).

44 FF/REW O H: when MS-SENS. L level, L: when MS-SENS. H level.

45 POWER ON O H: power ON, L: power OFF.

46 P-SNSR DET I H: ignore input when existing play sound, L: always monitor photo sensor.

47 EJECT SW I Input for eject operation detection. H: normal, L: when EJECT is ON.

48 BS/MODE IN I H: continuns playback. enable BS, L: go&return playback. disable BS.

15

IC DESCRIPTION

IC, ML63512-122

161718

ADJUSTMENT

A

MAIN C.B

IC301

1

SFR 301

IC701

TP2

(L-CH)

2

2

VOLUME

VR101

GND

TP1
(R-CH)

1

2

3

4

PHONES

J101

2

2

1

<TAPE PLAYER SECTION>

1. Tape Speed Adjustment
Settings :  Test tape : TTA100 (Tape center)

 Test point : PHONES (J101)
 DSL : OFF
 Adjustment location : SFR301
 DOLBY SW : OFF<597 only>
 TAPE SELECTOR : NORM(auto)
 VOLUME : MA X

Method : Play back (FWD) the test tape and adjust

SFR301 so that the frequency becomes
3015Hz±10Hz. Then confirm WOW is less
than 0.50%.

2. Dolby level check<597 only>

Settings :  Test tape : TTA200

 Check point : TP1(RCH), TP2(LCH)
 DOLBY SW : OFF
 DSL : OFF
 TAPE SELECTOR : NORM
 VOLUME : MINI
 Adjustment points : Soldering patterns -

Precedure : Short the patterns via solder as showen in the table

so ghe Dollby NR level is 32mV ± 1.0dB. Adjust
so the specifications are satisfied in both theforward
ans reverse directions. Connect 10uF/16V coupling
capacetors between test points and test wquipment
(connect the positive terminals to the test points).

PRACTICAL SERVICE FIGURE

<TAPE SECTION>

Tape speed : 3015Hz ± 50Hz
Wow : Less than 0.52% (RMS)
Take-up torque : 20 ~ 30g-cm (FWD, RVS)
F.F torque : 70 ~ 150g-cm
REW torque : 70 ~ 150g-cm
S/N ratio : More than 42dB (PB, DC)
Distortion : Less than 3.0% (PB, DC)
Noise level : Less than 3.0mV

Frequency response : 63Hz + 3 /  5dB ~ 8kHz + 4 /  4dB

Test tape : TTA 100

4

1

(Vol MAX, PB, DC)
Less than 0.4mV
(Vol MIN, PB, DC)

(NORMAL)
63Hz + 3 /  5dB ~10kHz + 4 /  4dB
(CrO2)

TTA 200
TTA 210
TTA310(CrO2)
TTA320(NORMAL)

SODER POINT INCRESE LEVEL
only 0.8 dB
LCH only 1.5 dB

& 2.3 dB

only 0.8 dB
RCH only 1.5 dB
& 2.3 dB

1
2
2

1

3
4

4

3

19

MECHANICAL EXPLODED VIEW 1/1<390>

33

K

JACK

SPACER,PWB K

K

M

32

1

D

6

9

31

1

2

3

4

D

5

7

8

10

B

A

A

B

11

F

E

6ZM-2 P11NF

25

26

24

27

22

28

J

J

1

30

23

PCB

H

29

D

N

G

18

12

20

H

G

19

D

L

14

16

17

O

21

HS-PX390
(FileName:EXPLODED.EPS)
99/7/22

13

15

20

MECHANICAL PARTS LIST 1/1<390>

PART NO. KANRI

1 8Z-HK5-026-010 1H LID ASSY,CASS BLU<390L>
1 8Z-HK5-018-010 1H LID ASSY,CASS D<390S>
2 8Z-HK5-216-010 0E SPR-P,POP-UP
3 8Z-HK5-214-010 1C HLDR ASSY,CASS MOT
4 88-HK5-208-010 0E ARM,SLIDE

5 8Z-HK5-213-010 1A HLDR,CASS JACK
6 8Z-HK5-005-010 0E WINDOW,CASS
7 8Z-HK5-038-010 0E KNOB,SL BS SIL<390L>
8 8Z-HK5-012-010 0E KNOB,SL BS
9 8Z-HRB-207-010 0E SPR-P,CASS

10 8Z-HK5-016-010 1B FRAME,CENTER D<390S>
10 8Z-HK5-032-010 1B FRAME,CENTER SIL<390L>
11 8Z-HK5-202-010 0E PLATE,HINGE MOT
12 88-HK5-220-010 0E SPR-P,MECHA EARTH
13 8Z-HK5-006-010 0E LID,BATT<390S>

13 8Z-HK5-033-010 0E LID,BATT BLU<390L>
14 8Z-HK5-206-010 0 E BAT-CONTACT,P
15 88-HK5-216-010 0E SHAFT,BAT
16 8Z-HK5-209-010 0E HLDR,CONT B-BOX
17 8Z-HK5-207-010 0E BAT-CONTACT,BOX HEAD

18 8Z-HK5-224-010 0E SPR-E,OPEN
19 8Z-HK5-226-010 1 A BAT-CONTACT,M
20 8Z-HK5-204-010 1 A PLATE,B-BOX
21 8Z-HK5-029-010 1H CABI,REAR BLU<390L>
21 8Z-HK5-019-010 1H CABI,REAR D<390S>

22 8Z-HK5-009-010 1B KNOB,RTRY HOLD
23 8Z-HK5-008-010 0E LENS,LED
24 8Z-HK5-010-010 0E KNOB,SL OPEN
25 8Z-HK5-013-010 0E KNOB,SL DSL
26 8Z-HK5-210-010 0E HLDR,KNOB OPEN

NO.

DESCRIPTIONREF. NO. KANRI

REF. NO. DESCRIPTIONPART NO.

27 8Z-HK5-221-010 0 E SPR-T,CLICK
28 8Z-HK5-222-010 0 E JOINT,HOLD
29 8Z-HK5-004-010 1 A PANEL,CABI
30 8Z-HK5-007-010 1B KEY,CONT
31 8Z-HK5-203-010 1 A PLATE,OPEN

32 8Z-HK5-011-010 0 E KNOB,SL TP
33 8Z-HK5-201-010 1 A PLATE,HINGE JACK

A 87-HK5-238-010 0E S-SCRWE,1.4-1 BLK NL<390S>
B 87-HK5-240-010 0E S-SCREW,1.4-1 CR NL<390L>
C 87-067-588-010 0E SCREW,V+1.4-1.4

D 87-HK5-237-010 0E S-SCREW,1.4-2 CR NL
E 87-078-116-010 0E SCRW M1.4-2.5B NL<390S>
F 87-078-117-010 0E SCRW M1.4-2.5CR NL<390L>
G 87-067-746-010 0E SCREW,M 1.4-2(H0.5)
H 87-078-052-010 0E S-SCREW+1.4-3.5HL(B)

I 8Z-HK5-227-010 0E S-SCREW,+1.7-3.5 BLK HL
J 87-HK5-235-010 0E S-SCREW,1.4-0.6-2.5
K 87-067-385-010 0E SCREW,VT +1.4-2.5HL
L 88-HK5-228-010 0E S-SCREW,+1.4-2 CR
M 86-HK4-223-010 0E S-SCREW,SERR+1.4-3.5 B L

N 87-067-597-010 0E VT1.4-25HL
O 8Z-HK5-229-010 0E S-SCREW,+1.4-2.5 CR NL

NO.

COLOR NAME TABLE

Basic color Color Basic color Color Basic color Color

symbol symbol symbol

B Black C Cream D Orange
G Green H Gray L Blue

LT Transparent Blue N Gold P Pink

R Red S Silver ST Titan Silver
T Brown V Violet W White

WT Transparent White Y Yellow YT Transparent Yellow

LM Metallic Blue LL Light Blue GT Transparent Green
LD Dark Blue D T Transparent Orange

21

MECHANICAL EXPLODED VIEW 1/1<597>

8

K

JACK

SPACER,PWB K

K

M

32

1

D

6

9

31

1

2

3

4

D

5

7

10

A

A

11

F

E

6ZM-2 P11NF

25

26

24

27

22

28

J

J

1

30

23

PCB

H

29

D

B

G

18

12

20

H

G

19

D

L

14

16

17

F

21

HS-PX597
(FileName:EXPLODED.EPS)
99/7/22

13

15

22

MECHANICAL PARTS LIST 1/1<597>

PART NO. KANRI

1 8Z-HK5-015-010 LID ASSY,CASS<597AK,597AE>
1 8Z-HK5-018-010 LID ASSY,CASS D<597AH>
2 8Z-HK5-216-010 SPR-P,POP-UP
3 8Z-HK5-214-010 HLDR ASSY,CASS MOT

4 88-HK5-208-010 ARM,SLIDE
5 8Z-HK5-213-010 HLDR,CASS JACK
6 8Z-HK5-005-010 WINDOW,CASS
7 8Z-HK5-012-010 KNOB,SL BS
8 8Z-HK5-201-010 PLATE,HINGE JACK

9 8Z-HRB-207-010 SPR-P,CASS
10 8Z-HK5-003-010 FRAME,CENTER<597AK,597AE>
10 8Z-HK5-016-010 FRAME,CENTER D<597AH>
11 8Z-HK5-202-010 PLATE,HINGE MOT
12 88-HK5-220-010 SPR-P,MECHA EARTH

13 8Z-HK5-006-010 LID,BATT
14 8Z-HK5-206-010 BAT-CONTACT,P
15 88-HK5-216-010 SHAFT,BAT
16 8Z-HK5-209-010 HLDR,CONT B-BOX
17 8Z-HK5-207-010 BAT-CONTACT,BOX HEAD

18 8Z-HK5-224-010 SPR-E,OPEN
19 8Z-HK5-226-010 BAT-CONTACT,M
20 8Z-HK5-204-010 PLATE,B-BOX
21 8Z-HK5-002-010 CABI,REAR
22 8Z-HK5-009-010 KNOB,RTRY HOLD

87-HK5-236-010 S-SCREW,1.4-2.3

NO.

DESCRIPTIONREF. NO. KANRI

REF. NO. DESCRIPTIONPART NO.

23 8Z-HK5-008-010 LENS,LED
24 8Z-HK5-010-010 KNOB,SL OPEN
25 8Z-HK5-013-010 KNOB,SL DSL
26 8Z-HK5-210-010 HLDR,KNOB OPEN
27 8Z-HK5-221-010 SPR-T,CLICK

28 8Z-HK5-222-010 JOINT,HOLD
29 8Z-HK5-004-010 PANEL,CABI
30 8Z-HK5-007-010 KEY,CONT
31 8Z-HK5-203-010 PLATE,OPEN
32 8Z-HK5-011-010 KNOB,SL TP

A 87-HK5-238-010 S-SCRWE,1.4-1 BLK NL
B 87-067-597-010 VT1.4-25HL
C 87-067-588-010 SCREW,V+1.4-1.4
D 87-HK5-237-010 S-SCREW,1.4-2 CR NL
E 87-078-116-010 SCRW M1.4-2.5B NL

F 8Z-HK5-229-010 S-SCREW,+1.4-2.5 CR NL
G 87-067-746-010 SCREW,M 1.4-2(H0.5)
H 87-078-052-010 S-SCREW+1.4-3.5HL(B)
I 8Z-HK5-227-010 S-SCREW,+1.7-3.5 BLK HL
J 87-HK5-235-010 S-SCREW,1.4-0.6-2.5

K 87-067-385-010 SCREW,VT +1.4-2.5HL
L 88-HK5-228-010 S-SCREW,+1.4-2 CR
M 86-HK4-223-010 S-SCREW,SERR+1.4-3.5 B L

NO.

COLOR NAME TABLE

Basic color Color Basic color Color Basic color Color

symbol symbol symbol

B Black C Cream D Orange
G Green H Gray L Blue

LT Transparent Blue N Gold P Pink

R Red S Silver S T Titan Silver
T Brown V Violet W White

WT Transparent White Y Yellow YT Transparent Yellow

LM Metallic Blue LL Light Blue GT Transparent Green

LD Dark Blue D T Transparent Orange

23

TAPE MECHANISM EXPLIDED VIEW 1/1

F

HEAD FLEX C.B

6

42

5

SH,1.2-2.9-0.25SL

g

e

20

21

22

50

25

17

45

26

40

12

19

51

10

7

9

b

c

f

B

a

SH,1.2-2.9-0.25SL

43

c

b

a

24

C

35

34

49

54

A

39

17

11

15

20
23

50

44

22

48

52

53

HLDR,FP

H

E

PLATE,THRUST

2

41

1
8

13

30

14

27

31

54

f

38

46

47

33

D

4

6

43

G

28

29

B

49

37

18

3

d

e

d

g

C

16
32

36

24

TAPE MECHANISM PARTS LIST 1/1

PART NO. KANRI

1 86-ZM2-255-010 0E SPR-T,PIN BACK L
2 86-ZM2-252-610 0E GUIDE,TAPE
3 86-ZM2-220-210 0E SPR-T,HEAD
4 86-ZM2-219-510 0E LEVER,HEAD
5 86-ZM2-347-010 0E LEVER,MS EJECT

6 86-ZM2-368-110 0E ROLLER ASSY,PINCH L P11
7 86-ZM2-254-010 0E SPR-T,PIN BACK R
8 86-ZM2-370-110 0E SPR-T,PINCH L P11
9 86-ZM2-229-110 0E SPR-T,PINCH R

10 86-ZM2-240-110 0E CAP,REEL

11 86-ZM2-234-110 0E SHAFT,REEL R
12 86-ZM2-251-310 0E SHAFT,GEAR B
13 86-ZM2-201-E10 1B CHAS ASSY,OUT-SERT
14 86-ZM2-349-010 0E SPR-E,EJECT
15 86-ZM2-232-310 0E LEVER,REEL R

16 86-ZM2-268-310 0E SHAFT,PULLEY BELT 2
17 86-ZM2-243-310 0E SPR-C,BT
18 86-ZM2-329-210 0E BELT,P5
19 86-ZM2-209-310 0E GEAR,B
20 86-ZM2-238-710 0E GEAR,FF

21 86-ZM2-245-410 0E SPR-C,SLIP L
22 86-ZM2-237-010 0E GEAR,PLAY
23 86-ZM2-241-310 0E SPR-C,SLIP R
24 86-ZM2-272-010 0E LEVER,SW P 8.4
25 86-ZM2-236-510 0E CAP,SLIP

26 86-ZM2-235-210 0E SHAFT,REEL L
27 86-ZM2-223-310 0E LEVER,PIN UP L
28 86-ZM2-233-310 0E LEVER,REEL L
29 86-ZM2-208-310 0E GEAR,A
30 86-ZM2-217-210 0E SPR-E,CAM L

31 86-ZM2-216-510 0E LEVER,CAM L
32 86-ZM2-276-010 0E PULLEY,COUPLER
33 86-ZM2-212-310 0E SHAFT,FR
34 86-ZM2-214-510 0E LEVER,CAM R
35 86-ZM2-215-210 0E SPR-E,CAM R

NO.

DESCRIPTIONREF. NO. KANRI

REF. NO. DESCRIPTIONPART NO.

36 86-ZM2-222-410 0E LEVER,PIN UP R
37 86-ZM2-218-310 0E LEVER,HEAD UP
38 86-ZM2-205-410 1A FLY-WHL,L
39 86-ZM2-330-010 1A FLY-WHL,R2
40 86-ZM2-284-010 0E SH,AUTO 3

41 86-ZM2-225-310 0E ARM,PINCH L
42 86-ZM2-224-210 0E ARM,PINCH R
43 86-ZM2-283-210 0E CAP,SHAFT
44 86-ZM2-275-310 0E CAP,SLIP R
45 86-ZM2-210-710 0E LEVER,FR

46 86-ZM2-211-210 0E GEAR,FR
47 86-ZM2-213-210 0E SPR-C,FR
48 M8-7ZS-690-000 -- ABL-76 A
49 86-ZM2-221-010 0E CLR,BRG N
50 86-ZM2-239-010 0E FELT,

51 86-ZM2-342-010 1B LEVER ASSY,EJECT
52 86-ZS2-312-010 0E SPR-P,6A-MOT
53 87-ZS6-301-010 1D COIL,FP 7ZS6
54 86-ZM2-206-310 1A SHAFT,CAPSTAN

A 86-ZM2-278-010 0E W-P,1.36-4-0.2 SLT

B 86-ZM2-319-010 0E W-L,0.95-3-0.35

C 87-067-860-010 0E PW,3-0.95-0.4

D 87-067-516-010 0E PW,3-1.58-0.25,SLIT

E 87-067-430-010 0E VT1.4-5 BLK

F 86-ZM2-348-010 0E S-SCREW,+1.4-4.6

G 87-261-500-310 0E SCREW V+1.4-1.4 (BK)

H 87-067-815-110 0E VT+1.4-3(HL)

NO.

ACCESSORIES / PACKAGE LIST

REF. NO. KANRI

PART NO.

1 87-B30-038-010 -- BAT,NB-5G
2 8Z-HK5-952-010 -- BOX,BAT ASSY BLU<L>
2 88-HK5-952-110 1H BOX,BAT ASSY SIL<EXCEPT L>
3 82-HK3-951-010 1C CARRYING,CASE<AK,AE>
4 87-B30-039-010 2A CHARGER,RB-107 D<D,L>

!

4 87-B30-083-010 2M CHARGER,RB-107 E<AE>

!
!

4 87-B30-137-110 2A CHARGER,RB-107 H<AH>

!

4 87-B30-097-010 2A CHARGER,RB-107 K<AK>
5 87-B30-253-010 2M HEADPHONE,HP-M041
6 8Z-HK5-901-010 -- IB,D<D,L>

6 8Z-HK5-908-010 -- IB,E(EDPHNCZ)<AE>
6 8Z-HK5-907-010 -- IB,E(EGFSI) S<AK,AE>
6 8Z-HK5-905-010 -- IB,H(ECK)S<AH>
7 8Z-HK5-951-010 -- RC UNIT,RC390

NO.

DESCRIPTION

25

A4

L

931261 9820572

2-11, IKENOHATA 1-CHOME, TAITO-KU, TOKYO 110, JAPAN TEL:[phone]

211, IKENOHATA 1CHOME, TAITO-KU, TOKYO 110, JAPAN TEL:[phone]

Printed in Singapore