Aiwa CDCX-2179, CDCX-417 Service manual
CDC-X417
YC
CDC-X2179
YL
SERVICE MANUAL
STEREO CAR CD RECEIVER
• This Service Manual contains information about the difference between
CDC-X417<YC> / CDC-X2179<YL> and CDC-X4170 <YL> / CDC-X2170<YL>.
If requiring the other information,see Service Manual of CDC-X217 / X2170 /
X3170 / X4170<YZ,YL>, (S/M Code No. 09-012-441-1R2).
BASIC CD MECHANISM: BZG-3 ANF
S/M Code No. 09-018-441-1S2
SUPPLEMENT
DATA
SPECIFICATIONS
RADIO SECTION
(FM)
Frequency Range 87.5 MHz –108 MHz (100-kHz steps)*
87.5 MHz –108 MHz (50-kHz steps)*
Usable Sensitivity 12.7 dBf
50 dB Quieting Sensitivity 17.2 dBf
IF Rejection 80 dB
Frequency Response 30 Hz – 15,000 Hz
S/N Ratio 63 dB
Stereo Separation 35 dB at 1 kHz
Alternate Channel Selectivity
70 dB
Capture Ratio 3 dB
(AM)
Frequency Range 530 kHz – 1,710 kHz (10-kHz steps)*
531 kHz – 1,602 kHz (9-kHz steps)*
Usable Sensitivity 30 µV (30 dB)
9K 10K
* Set the frequency increment for your area using the switch on the bottom
of the unit.
(The switch is set at the factory to the 10k position [for the U.S.A.])
CD SECTION
Frequency Response 17 Hz – 20 kHz +0/–3 dB
Dynamic Range More than 80 dB
Channel Separation More than 65 dB
S/N Ratio More than 85 dB
Wow/Flutter Unmeasurable
AUDIO SECTION
Max. Power Output 45 W x 4 channels
AUX IN input
Input Sensitivity (Load Impedance)
AUX IN 300 mV (10 kΩ)
GENERAL
Power Supply Voltage 14.4 V (11 to 16 V allowable),
Load Impedance 4 Ω
Tone Control Bass ± 10 dB at 100 Hz
Preamp Output Voltage (Load Impedance)
Installation Size 182 (W) x 53 (H) x 155 (D) mm
STEERING-WHEEL-MOUNTED REMOTE CONTROL UNIT <CDCX417 only>
Dimensions Approx. 67 (W) x 26 (H) x 27 (D) mm
Weight Approx. 38g (1.33 oz.)
• Design and specifications are subject to change without notice.
DC, negative ground
Treble ± 10 dB at 10 kHz
2.2 V (10 kΩ)
1
(7
/4 (W) x 21/8 (H) x 61/8 (D) inches)
(23/4 (W) x 11/16 (H) x 11/8 (D) inches)
(excluding holder)
(including holder, battery)
– 2 –
ELECTRICAL MAIN PARTS LIST
REF. NO. DESCRIPTIONPART NO.
NO.
IC
87-A20-446-010 C-IC,LA9241ML
87-A21-319-010 C-IC,LC78622NE
87-A21-488-040 C-IC,LA6556
8Z-KT1-622-010 C-IC,LC75374E
87-A21-562-010 IC,LA4743B
88-KT1-606-080 IC,PST994D
87-A22-064-030 C-IC,LC72358N-9A44
87-A21-489-030 C-IC,LC75853NW
87-A90-951-010 RCR UNIT,SBX1971-52<X417>
TRANSISTOR
89-324-122-040 C-TR,2SC2412KR
87-A30-289-040 C-TR,2SA1037AK(Q)
87-A30-288-040 C-TR,DTC114YKA
87-A30-287-040 C-TR,DTC114TKA
87-A30-435-040 C-TR,DTC144EKA
87-A30-299-080 TR,2SB1326
87-A30-282-040 C-TR,DTA114TKA
89-213-750-010 TR,2SB1375 (25W)
89-420-120-010 TR,2SD2012 (25W)
87-A30-427-040 C-TR,DTC114EKA
87-A30-301-080 TR,2SD1862
DIODE
87-A40-250-040 C-DIODE,DAN217
87-001-783-080 DIODE,1N4002
87-020-331-080 CHIP-DIODE,DAN202K
87-A40-650-080 ZENER,MTZJ6.8A
87-A40-523-080 ZENER,MTZJ9.1B
87-070-136-080 ZENER,MTZJ5.1B
87-017-932-080 ZENER,MTZJ6.2B
87-070-334-080 ZENER,MTZJ10B
87-A40-798-010 DIODE,1N5402 (3A/200V)
87-A40-817-040 C-ZENER,STZ6.8N
87-020-465-080 DIODE,1SS133
MAIN C.B
C101 87-012-274-080 CHIP CAP,U 1000P-50B
C102 87-012-286-080 CAP, U 0.01-25
C103 87-010-495-040 CAP,E 2.2-50 GAS
C106 87-012-282-080 CAP, U 4700P-50
C107 87-010-552-040 CAP,E 22-16 GAS
C108 87-012-195-080 C-CAP,U 100P-50CH
C109 87-010-553-040 CAP,E 47-16 GAS
C110 87-010-787-080 CAP, U 0.022-25
C111 87-010-553-040 CAP,E 47-16 GAS
C112 87-012-281-080 C-CAP,U 3900P-50 B
C113 87-012-286-080 CAP, U 0.01-25
C114 87-010-759-080 C-CAP,U, 0.1-25F
C115 87-010-759-080 C-CAP,U, 0.1-25F
C116 87-010-759-080 C-CAP,U, 0.1-25F
C131 87-A11-228-080 C-CAP,U 0.027-25 K B
C132 87-A11-228-080 C-CAP,U 0.027-25 K B
C133 87-A10-707-080 C-CAP,U 0.47U-16 F Z
C134 87-A10-707-080 C-CAP,U 0.47U-16 F Z
C140 87-012-282-080 CAP, U 4700P-50
C173 87-012-195-080 C-CAP,U 100P-50CH
C176 87-012-286-080 CAP, U 0.01-25
C201 87-010-553-040 CAP,E 47-16 GAS
C202 87-010-553-040 CAP,E 47-16 GAS
C203 87-012-274-080 CHIP CAP,U 1000P-50B
C204 87-A10-260-080 C-CAP,U 0.1-16 K B
C205 87-A10-353-080 C-CAP,U0.22-10KB
C206 87-010-492-040 CAP,E 0.33-50 GAS
C207 87-010-956-080 CHIP-CAP,S 0.068-25B
REF. NO. DESCRIPTIONPART NO.KANRI
C208 87-012-272-080 C-CAP,U 680P-50 B
C209 87-A10-504-080 C-CAP,U 0.047-16 K B
C210 87-A10-260-080 C-CAP,U 0.1-16 K B
C211 87-010-498-040 CAP,E 10-16 GAS
C212 87-012-276-080 CAP, CHIP SS 1500 PBK
C213 87-A10-504-080 C-CAP,U 0.047-16 K B
C214 87-A10-260-080 C-CAP,U 0.1-16 K B
C215 87-012-278-080 C-CAP,U 2200P-50 B
C216 87-A10-353-080 C-CAP,U 0.22-10 K B
C217 87-A10-260-080 C-CAP,U 0.1-16 K B
C218 87-010-787-080 CAP, U 0.022-25
C219 87-012-268-080 C-CAP,U 330P-50 B
C220 87-012-280-080 CAP, U 3300P-50
C221 87-012-195-080 C-CAP,U 100P-50CH
C222 87-010-492-040 CAP,E 0.33-50 GAS
C223 87-010-067-040 CAP,E 0.1-50 5L
C224 87-010-553-040 CAP,E 47-16 GAS
C225 87-012-280-080 CAP, U 3300P-50
C226 87-010-497-040 CAP,E 4.7-35 GAS
C227 87-010-555-040 CAP,E 100-10 GAS
C228 87-A10-260-080 C-CAP,U 0.1-16 K B
C229 87-010-498-040 CAP,E 10-16 GAS
C230 87-A10-260-080 C-CAP,U 0.1-16 K B
C231 87-010-555-040 CAP,E 100-10 GAS
C232 87-A10-260-080 C-CAP,U 0.1-16 K B
C233 87-010-555-040 CAP,E 100-10 GAS
C234 87-010-828-080 CHIP CAPACITOR,U 0.033-25F
C235 87-A10-504-080 C-CAP,U 0.047-16 K B
C236 87-010-067-040 CAP,E 0.1-50 5L
C237 87-010-553-040 CAP,E 47-16 GAS
C238 87-012-286-080 CAP, U 0.01-25
C240 87-A10-260-080 C-CAP,U 0.1-16 K B
C250 87-A10-047-080 C-CAP,U 1-10 Z F
C251 87-010-555-040 CAP,E 100-10 GAS
C252 87-A10-260-080 C-CAP,U 0.1-16 K B
C253 87-A10-260-080 C-CAP,U 0.1-16 K B
C254 87-A10-260-080 C-CAP,U 0.1-16 K B
C256 87-012-282-080 CAP, U 4700P-50
C258 87-012-168-080 C-CAP,U 6P-50 CH
C259 87-012-184-080 C-CAP,U 33P-50 CH
C261 87-012-199-080 CAP 220P
C262 87-A10-260-080 C-CAP,U 0.1-16 K B
C263 87-010-555-040 CAP,E 100-10 GAS
C264 87-010-555-040 CAP,E 100-10 GAS
C265 87-A10-260-080 C-CAP,U 0.1-16 K B
C266 87-A10-260-080 C-CAP,U 0.1-16 K B
C267 87-010-498-040 CAP,E 10-16 GAS
C268 87-010-498-040 CAP,E 10-16 GAS
C269 87-012-276-080 CAP, CHIP SS 1500 PBK
C270 87-012-276-080 CAP, CHIP SS 1500 PBK
C271 87-012-172-080 CAPACITOR CHIP U 10P CH
C272 87-012-172-080 CAPACITOR CHIP U 10P CH
C273 87-010-494-040 CAP,E 1-50 GAS
C274 87-010-494-040 CAP,E 1-50 GAS
C280 87-A10-189-040 CAP,E 220-10
C281 87-010-555-040 CAP,E 100-10 GAS
C282 87-A10-260-080 C-CAP,U 0.1-16 K B
C301 87-010-498-040 CAP,E 10-16 GAS
C302 87-010-498-040 CAP,E 10-16 GAS
C303 87-010-494-040 CAP,E 1-50 GAS
C304 87-010-494-040 CAP,E 1-50 GAS
C305 87-012-280-080 CAP, U 3300P-50
C306 87-012-280-080 CAP, U 3300P-50
C307 87-010-198-080 CAP, CHIP 0.022
C308 87-010-198-080 CAP, CHIP 0.022
C309 87-010-498-040 CAP,E 10-16 GAS
C310 87-010-498-040 CAP,E 10-16 GAS
C311 87-A10-781-080 C-CAP,U 0.15-10 K B
C312 87-A10-781-080 C-CAP,U 0.15-10 K B
C313 87-A10-781-080 C-CAP,U 0.15-10 K B
KANRI
NO.
– 3 –
REF. NO. DESCRIPTIONPART NO.
NO.
C314 87-A10-781-080 C-CAP,U 0.15-10 K B
C315 87-010-498-040 CAP,E 10-16 GAS
C316 87-010-498-040 CAP,E 10-16 GAS
C321 87-010-759-080 C-CAP,U, 0.1-25F
C322 87-010-555-040 CAP,E 100-10 GAS
C323 87-010-759-080 C-CAP,U, 0.1-25F
C324 87-010-498-040 CAP,E 10-16 GAS
C331 87-A10-707-080 C-CAP,U 0.47U-16 F Z
C332 87-A10-707-080 C-CAP,U 0.47U-16 F Z
C333 87-010-759-080 C-CAP,U, 0.1-25F
C334 87-010-759-080 C-CAP,U, 0.1-25F
C351 87-010-494-040 CAP,E 1-50 GAS
C352 87-010-494-040 CAP,E 1-50 GAS
C353 87-010-494-040 CAP,E 1-50 GAS
C354 87-010-494-040 CAP,E 1-50 GAS
C361 87-A10-707-080 C-CAP,U 0.47U-16 F Z
C362 87-A10-707-080 C-CAP,U 0.47U-16 F Z
C363 87-A10-707-080 C-CAP,U 0.47U-16 F Z
C364 87-A10-707-080 C-CAP,U 0.47U-16 F Z
C365 87-012-271-080 CAP, U 560P-50
C366 87-012-271-080 CAP, U 560P-50
C367 87-012-271-080 CAP, U 560P-50
C368 87-012-271-080 CAP, U 560P-50
C451 87-010-498-040 CAP,E 10-16 GAS<X417>
C452 87-010-498-040 CAP,E 10-16 GAS<X417>
C453 87-010-498-040 CAP,E 10-16 GAS
C454 87-010-498-040 CAP,E 10-16 GAS
C455 87-012-270-080 CAP, U 470P-50<X417>
C456 87-012-270-080 CAP, U 470P-50<X417>
C457 87-012-270-080 CAP, U 470P-50
C458 87-012-270-080 CAP, U 470P-50
C511 8A-KC7-623-000 CAP,E 2200U-16 BT(125C)
C512 87-010-759-080 C-CAP,U, 0.1-25F
C513 87-010-759-080 C-CAP,U, 0.1-25F
C514 87-010-553-040 CAP,E 47-16 GAS
C515 87-010-552-040 CAP,E 22-16 GAS
C516 87-012-274-080 CHIP CAP,U 1000P-50B
C519 87-010-494-040 CAP,E 1-50 GAS
C531 87-A12-317-080 C-CAP,U 0.1-50 Z F
C532 87-A12-317-080 C-CAP,U 0.1-50 Z F
C533 87-A12-317-080 C-CAP,U 0.1-50 Z F
C534 87-A12-317-080 C-CAP,U 0.1-50 Z F
C551 87-010-553-040 CAP,E 47-16 GAS
C590 87-012-274-080 CHIP CAP,U 1000P-50B
C621 87-010-553-040 CAP,E 47-16 GAS
C622 87-010-553-040 CAP,E 47-16 GAS
C641 87-010-759-080 C-CAP,U, 0.1-25F
C642 87-010-759-080 C-CAP,U, 0.1-25F
C671 87-010-787-080 CAP, U 0.022-25
C672 87-010-498-040 CAP,E 10-16 M 5L SRE
C673 87-010-498-040 CAP,E 10-16 M 5L SRE
C674 87-010-787-080 CAP, U 0.022-25
C681 87-010-553-040 CAP,E 47-16 GAS
C682 87-010-787-080 CAP, U 0.022-25
C701 87-012-182-080 C-CAP,U 27P-50 CH
C702 87-012-180-080 C-CAP,U 22P-50 CH
C706 87-010-497-040 CAP,E 4.7-35 GAS
C711 87-012-195-080 C-CAP,U 100P-50CH
C712 87-012-195-080 C-CAP,U 100P-50CH
C761 87-010-555-040 CAP,E 100-10 GAS
C763 87-010-759-080 C-CAP,U, 0.1-25F
C765 87-016-039-090 CAP,DL 0.022F-5.5 Z 70 FM
C771 87-012-199-080 CAP 220P
C831 87-010-494-040 CAP,E 1-50 GAS
C832 87-010-494-040 CAP,E 1-50 GAS
C835 87-012-278-080 C-CAP,U 2200P-50 B
C836 87-012-278-080 C-CAP,U 2200P-50 B
C881 87-012-278-080 C-CAP,U 2200P-50 B
C882 87-012-278-080 C-CAP,U 2200P-50 B
C883 87-012-278-080 C-CAP,U 2200P-50 B
REF. NO. DESCRIPTIONPART NO.KANRI
C884 87-012-278-080 C-CAP,U 2200P-50 B
C885 87-010-759-080 C-CAP,U, 0.1-25F
CON201 87-A61-507-010 CONN,26P TKC-W26P-A1
CON851 88-KTA-603-010 CONN,15P CAM-B68
CON881 8Z-KT1-611-010 CONN,16P CAM-B51
!
F881 8Z-KC1-621-010 FUSE,15A 32V
FC201 8B-KCF-611-010 F-CABLE,2P 55MM
J101 8Z-KT1-614-010 ANT,AW-002
J451 87-A61-225-110 JACK,PIN 2P XR-401<X2179>
J451 87-A61-224-110 JACK,PIN 4P XR-401<X417>
L101 87-003-143-080 COIL 4.7 UH
L102 8Z-KT1-619-010 COIL,68MH K7-D
L461 87-003-143-080 COIL 4.7 UH
L671 87-003-149-080 COIL,47UH
L831 87-003-143-080 COIL 4.7 UH
L881 8B-KCF-615-010 FLTR,AMORPHOUS -CHOKE
LED702 87-027-262-010 LED,TLR-124(RED)
SW701 87-A91-070-010 SW,TACT SKHHLV
SW702 87-A91-152-010 SW,SL 1-1-2 SSSS212-11-A
TU101 8B-KCF-621-110 TU UNIT, FAE347-A26<X417>
TU101 8B-KCF-621-010 TU UNIT, FAE347-A22<X2179>
X201 81-592-641-010 VIB,CER 16.93MHZ
X701 87-A70-175-010 VIB,XTAL 4.5MHZ AT-49
FRONT C.B
C901 87-A10-047-080 C-CAP,U 1-10 Z F
C902 87-A10-504-080 C-CAP,U 0.047-16 K B
C903 87-A10-504-080 C-CAP,U 0.047-16 K B
C904 87-012-273-080 C-CAP,U 820P-50 B
C905 87-A10-260-080 C-CAP,U 0.1-16 K B
C971 87-A10-260-080 C-CAP,U 0.1-16 K B<X417>
CON901 88-KTA-602-010 CONN,15P CAM-B67
LCD901 8B-KCF-610-010 LCD,BKC-F-G-H
LED951 87-A91-355-040 C-LED,BR1112H-TR-RED
LED952 87-A91-355-040 C-LED,BR1112H-TR-RED
LED961 87-A40-813-240 C-LED,SEC1E01C BLU
LED962 87-A40-813-240 C-LED,SEC1E01C BLU
LED963 87-A40-813-240 C-LED,SEC1E01C BLU
LED981 87-A91-355-040 C-LED,BR1112H-TR-RED
LED982 87-A91-355-040 C-LED,BR1112H-TR-RED
LED983 87-A91-355-040 C-LED,BR1112H-TR-RED
PL901 8B-KCF-631-010 LAMP,9V-65MA
PL902 8B-KCF-631-010 LAMP,9V-65MA
SW901 87-A91-987-080 SW,TACT SKQCAB
SW902 87-A91-987-080 SW,TACT SKQCAB
SW903 87-A91-987-080 SW,TACT SKQCAB
SW904 87-A91-987-080 SW,TACT SKQCAB
SW905 87-036-339-080 C-SW,TACT SKQMAH
SW906 87-A91-987-080 SW,TACT SKQCAB
SW907 87-A91-987-080 SW,TACT SKQCAB
SW908 87-036-339-080 C-SW,TACT SKQMAH
SW910 87-036-339-080 C-SW,TACT SKQMAH
SW911 87-A91-987-080 SW,TACT SKQCAB
SW913 87-036-339-080 C-SW,TACT SKQMAH
SW914 87-A91-987-080 SW,TACT SKQCAB
SW915 87-036-339-080 C-SW,TACT SKQMAH
SW916 87-A91-987-080 SW,TACT SKQCAB
SW917 87-036-339-080 C-SW,TACT SKQMAH
SW918 87-A91-987-080 SW,TACT SKQCAB
SW921 87-A91-986-010 SW,RTRY EC12E24504-15MM
AUX C.B
FFC901 8A-KC7-611-010 F-CABLE,3P (AUX)
J901 85-HRL-623-010 JACK,3.5 ST BLK
CONN.C.B
C1 87-A11-062-080 C-CAP,S 2.2-16 ZF
KANRI
NO.
– 4 –
REF. NO. DESCRIPTIONPART NO.
NO.
CN1 87-A61-718-080 C-CONN,26P V TKC-W26X-A1
SW C.B
S1 87-A92-279-080 C-SW,PUSH 2-1 ESE22MH22XQ
S2 87-A92-279-080 C-SW,PUSH 2-1 ESE22MH22XQ
FLEX.C.B
8B-ZG3-603-010 PWB,FLEX PIC
CHIP RESISTOR PART CODE
Chip Resistor Part Coding
88
REF. NO. DESCRIPTIONPART NO.KANRI
KANRI
NO.
A
Resistor Code
Chip resistor
Wattage Type Tolerance
1/16W 1005 5% CJ
1/16W
1/10W
1/8W
1608
2125
3216
5%
5%
5%
TRANSISTOR ILLUSTRATION
C
B
E
E C B
Symbol
CJ
CJ
CJ
B C E
Figure
Value of resistor
Form
L
Dimensions (mm)
t
W
0.55
Resistor Code
108
118
128
LW t
1.0 0.5 0.35 104
1.6 0.8 0.45
2 1.25 0.45
3.2
1.6
: A
: A
2SA1037
2SC2412
DTA114TKA
DTC114EKA
DTC114YKA
DTC114TKA
DTC144EKA
2SB1326
2SD1862
2SB1375
2SD2012
– 5 –
WIRING – 1 (MAIN) <1 / 2>
32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
A
B
C
D
E
F
G
H
I
J
K
L
M
N
O
P
Q
– 6 –
R
S
T
U
Loading...