Aiwa CDCR-927-M Service manual

CDC-R927M

YZ(ST)

SERVICE MANUAL

STEREO CAR CD RECEIVER

BASIC CD MECHANISM : BZG-3 CNF

S/M Code No. 09-026-458-9N1

DATA

SPECIFICATION -1/1

RADIO SECTION
(FM)

Frequency Range: 87.5 MHz - 108 MHz (50-KHz steps)
Usable Sensitivity: 12.7 dBf
50 dB Quieting Sensitivity: 17.2 dBf
IF Rejection: 100 dB
Frequency Response: 30 Hz - 15,000 Hz
S/N Ratio: 67 dB
Stereo Separation: 35 dB at 1 kHz
Alternate Channel Selectivity: 98 dB
Capture Ratio: 3 dB

(MW)

Frequency Range: 531 kHz - 1,602 kHz (9-KHz steps)
Usable Sensitivity: 30 µV (30 dB)

(LW)

Frequency Range: 144 kHz - 288 kHz (1-kHz/9-kHz steps)
Usable Sensitivity: 30 µV (30 dB)

CD SECTION

Frequency Response: 17 Hz - 20 kHz +0/-3 dB
Dynamic Range: More than 92 dB
Channel Separation: More than 60 dB
S/N Ratio: More than 90 dB
Wow/Flutter: Unmeasurable

AUDIO SECTION

Max. Power Output: 45 W x 4 channels
AUX IN input
Input sensitivity (load impedance) AUX IN: 300 mV (10 kΩ)

GENERAL

Power-Supply Voltage: 14.4 V (11 to 16 V allowable), DC, negative ground
Load Impedance: 4 Ω
Tone Control: Bass ± 10 dB at 100 Hz, Treble ± 10 dB at 10 kHz
Preamp Output Voltage (load impedance): 2.2 V (10 kΩ)
Installed size: 182 (W) x 53 (H) x 155 (D) mm

CARD REMOTE CONTROL

Dimensions: Approx. 33 (W) x 85 (H) x 7.5 (D) mm
Weight: Approx. 20 g (including battery)

Specifications and external appearance are subject to
change without notice due to product improvement.

-2-

PROTECTION OF EYES FROM LASER BEAM DURING SERVICING -1/1

This set employs laser. Therefore, be sure to follow carefully the instructions
below when servicing.

WARNING!

WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE
EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER
BEAM EMISSION. BE SURE TO OBSERVE FROM A DISTANCE OF
MORE THAN 30cm FROM THE SURFACE OF THE OBJECTIVE LENS
ON THE OPTICAL

Caution: Invisible laser radiation when open
and interlocks defeated avoid exposure to
beam.
Advarsel:Usynling laserståling ved åbning,
når sikkerhedsafbrydere er ude af funktion.
Undgå udsættelse for stråling.

VAROITUS!

Laiteen Käyttäminen muulla kuin tässä käyttöohjeessa mainitulla tavalla
saattaa altistaa käyt-täjän turvallisuusluokan 1 ylittävälle näkymättömälle
lasersäteilylle.

VARNING!

Om apparaten används på annat sätt än vad som specificeras i denna
bruksanvising, kan användaren utsättas för osynling laserstrålning, som
överskrider gränsen för laserklass 1.

CAUTION

Use of controls or adjustments or performance of procedures other than
those specified herein may result in hazardousradiation exposure.

ATTENTION

L'utilisation de commandes, réglages ou procédures autres que ceux
spécifiés peut entraîner une dangereuse exposition aux radiations.

ADVARSEL!

Usynlig laserståling ved åbning, når sikkerhedsafbrydereer ude af funktion.
Undgå udsættelse for stråling.

This Compact Disc player is classified as a CLASS 1 LASER product.
The CLASS 1 LASER PRODUCT label is located on the rear exterior.

CLASS 1
KLASSE 1
LUOKAN 1
KLASS 1

LASER PRODUCT
LASER PRODUKT
LASER LAITE
LASER APPARAT

Precaution to replace Optical block
(PICK720)

Body or clothes electrostatic potential could ruin
laser diode in the optical block. Be sure ground
body and workbench, and use care the clothes
do not touch the diode.

1) After the connection, remove solder shown in
the right figure.

PICK-UP ASSY . P .C.B

Solder

-3-

ACCESSORIES PARTS LIST -1/1

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
O AS1001 8C-KC2-901-010 IB,YZ(9L)F R927M a
O AS1002 8C-KCG-913-010 IB,INST YZ,YV (9L,R)F a
O AS1003 87-B10-141-010 NUT,5 TYPE-2 a
O AS1004 87-B10-143-010 UT1+5-15 W/O SLOT a
O AS1005 87-B10-144-010 W,5.2-10-0.5 a
O AS1006 87-B10-145-010 W-SPR,5.3-8.5-1.5 a
O AS1007 8C-KCG-651-010 RC UNIT,CD1B a
O AS1008 8Z-KC1-231-110 HLDR,HALF -C a
O AS1009 8Z-KC1-232-010 KEY,REMOVE -C a
O AS1010 8Z-KC1-235-010 HLDR,REAR MTG a

O AS1011 8Z-KC1-244-010 S-SCREW,5*6 TH+ TAPPING ST a
O AS1012 8Z-KC1-250-010 S-SCREW,HEXAGON a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-4-

DISASSEMBLY INSTRUCTION - 1/2

DISASSMBLY PROCEDURE

1) Remove top and bottom cover.

2) Remove CD mechanism.

3) Remove FFC.

4) Remove wire solder.

5) Remove the screw of MAIN BOARD.

6) Remove the connector of the motor.

Notes

7) Remove CABI BASE AROUND and remove the screw of FRAME SUB assy right and left.

8) Move FRONT PANEL assy.

Each FFC shoud be passed the bottom of SHAFT Assy.

-5-

DISASSEMBLY INSTRUCTION - 1/2

9) Remove MOTOR assy.

10) Remove FRONT assy.

11) Remove Panel SW assy.
(Extend FRAME SUB assy lightly and remove it at front side)

Reassemble MOTOR assy at the position that is arranged with hole of GEAR CAM and hole of FRAME SUB assy like the figure)

Put the tip of a lever Assy gear at between the marks of GEAR CAM and reassemble FRONT assy.
(Extend FRAME SUB assy lightly.)

12) Remove SHAFT assy.
(Remove the washer. See figure)

Put GEAR CAM at the position that hole of FRAME SUB assy can be seen from the left and right side hole of GEAR CAM, and reassemble SHAFT assy.

-6-

ELECTRICAL PARTS LIST - 1/10

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
CD O C 0201 87-010-552-040 CAP,E 22-16 M 5L SRE a
CD O C 0202 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
CD O C 0203 87-A10-189-040 CAP,E 220-10 M 5L a
CD O C 0221 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
CD O C 0222 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
CD O C 0223 87-012-337-080 C-CAP,U 56P-50 J CH GRM a
CD O C 0224 87-012-162-080 C-CAP,U 1P-50 C CH GRM a
CD O C 0225 87-A10-260-080 C-CAP,U 0.1-16 K B a
CD O C 0226 87-010-555-040 CAP,E 100-10 M 5L SRE a
CD O C 0227 87-012-286-080 C-CAP,U 0.01-25 K B GRM a

CD O C 0228 87-A10-260-080 C-CAP,U 0.1-16 K B a
CD O C 0229 87-A10-353-080 C-CAP,U 0.22-10 K B a
CD O C 0230 87-A10-353-080 C-CAP,U 0.22-10 K B a
CD O C 0232 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
CD O C 0233 87-010-555-040 CAP,E 100-10 M 5L SRE a
CD O C 0234 87-010-555-040 CAP,E 100-10 M 5L SRE a
CD O C 0235 87-010-555-040 CAP,E 100-10 M 5L SRE a
CD O C 0237 87-012-285-080 C-CAP,U 8200P-50 K B GRM a
CD O C 0241 87-010-555-040 CAP,E 100-10 M 5L SRE a
CD O C 0242 87-010-555-040 CAP,E 100-10 M 5L SRE a

CDC-R927M
YZSTF
CD O C 0245 87-012-270-080 C-CAP,U 470P-50 K B GRM a
CD O C 0246 87-012-270-080 C-CAP,U 470P-50 K B GRM a
CD O C 0247 87-A10-504-080 C-CAP,U 0.047-16 K B a
CD O C 0248 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
CD O C 0250 87-010-555-040 CAP,E 100-10 M 5L SRE a
CD O C 0251 87-010-555-040 CAP,E 100-10 M 5L SRE a
CD O C 0252 87-012-274-080 C-CAP,U 1000P-50 K B GRM a
CD O C 0253 87-012-274-080 C-CAP,U 1000P-50 K B GRM a
CD O C 0254 87-012-274-080 C-CAP,U 1000P-50 K B GRM a
CD O C 0258 87-A10-504-080 C-CAP,U 0.047-16 K B a

CD O C 0259 87-A10-504-080 C-CAP,U 0.047-16 K B a
CD O C 0260 87-A10-504-080 C-CAP,U 0.047-16 K B a
CD O C 0261 87-012-282-080 C-CAP,U 4700P-50 K B GRM a
CD O C 0262 87-012-279-080 C-CAP,U 2700P-50 K B GRM a
CD O C 0263 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
CD O C 0264 87-010-785-080 C-CAP,U 0.015-25 K B GRM a
CD O C 0265 87-010-553-040 CAP,E 47-16 M 5L SRE a
CD O C 0268 87-012-188-080 C-CAP,U 47P-50 J CH GRM a
CD O C 0269 87-010-553-040 CAP,E 47-16 M 5L SRE a
CD O C 0270 87-010-553-040 CAP,E 47-16 M 5L SRE a

CDC-R927M
YZSTF
CD O C 0271 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
CD O C 0272 87-012-195-080 C-CAP,U 100P-50 J CH GRM a
CD O C 0273 87-012-199-080 C-CAP,U 220P-50 J CH GRM a
CD O C 0274 87-012-199-080 C-CAP,U 220P-50 J CH GRM a
CD O C 0276 87-010-555-040 CAP,E 100-10 M 5L SRE a
CD O C 0278 87-010-555-040 CAP,E 100-10 M 5L SRE a
CD O C 0279 87-A10-260-080 C-CAP,U 0.1-16 K B a
CD O C 0281 87-012-275-080 C-CAP,U 1200P-50 K B GRM a
CD O C 0282 87-012-275-080 C-CAP,U 1200P-50 K B GRM a
CD O C 0283 87-010-498-040 CAP,E 10-16 M 5L SRE a

CD O C 0284 87-010-498-040 CAP,E 10-16 M 5L SRE a
CD O C 0298 87-010-555-040 CAP,E 100-10 M 5L SRE a
CD O C 0299 87-012-195-080 C-CAP,U 100P-50 J CH GRM a
CD O CON0201 87-A61-220-080 C-CONN,20P H 52271-2090 a
CD O FFC0201 8C-KCG-661-010 FF-CABLE,20P 1.0 90MM a
CD S IC 0201 87-A22-080-040 C-IC,LA6557H a
CD S IC 0221 87-A22-081-040 C-IC,TA2153FN a
CD S IC 0241 8C-ZA5-611-030 C-IC,TC94A09F-301 a
CD X JR 0102 88-108-000-080 C-JUMPER,U a
CD X JR 0201 88-108-000-080 C-JUMPER,U a

CDC-R927M
YZSTF
CD X JR 0203 88-108-000-080 C-JUMPER,U a
CD O L 0221 87-003-102-080 COIL,10UH J LAL02 a
CD O L 0241 87-003-143-080 COIL,4.7UH K LAL02 a
CD O L 0242 87-003-143-080 COIL,4.7UH K LAL02 a
CD S Q 0201 87-A30-299-080 TR,2SB1326 a
CD S Q 0202 87-A30-287-040 C-TR,DTC114TKA a
CD S Q 0221 87-A30-289-040 C-TR,2SA1037AK(Q) a
CD X R 0201 88-108-000-080 C-JUMPER,U a
CD X R 0202 88-108-683-080 C-RES,U 68K-1/16W J a
CD O R 0203 88-108-822-080 C-RES,U 8.2K-1/16W J a

CD O R 0204 88-108-822-080 C-RES,U 8.2K-1/16W J a
CD X R 0205 88-108-000-080 C-JUMPER,U a
CD X R 0206 88-108-561-080 C-RES,U 560-1/16W J a
CD X R 0207 88-108-000-080 C-JUMPER,U a
CD O R 0208 88-108-101-080 C-RES,U 100-1/16W J a
CD O R 0209 88-108-562-080 C-RES,U 5.6K-1/16W J a
CD X R 0210 88-108-000-080 C-JUMPER,U a
CD X R 0211 88-108-820-080 C-RES,U 82-1/16W J a
CD X R 0212 88-108-393-080 C-RES,U 39K-1/16W J a
CD X R 0213 88-108-000-080 C-JUMPER,U a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-7-

ELECTRICAL PARTS LIST - 2/10

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
CD X R 0214 88-108-000-080 C-JUMPER,U a
CD X R 0215 88-108-154-080 C-RES,U 150K-1/16W J a
CD O R 0221 88-108-102-080 C-RES,U 1K-1/16W J a
CD X R 0222 88-108-683-080 C-RES,U 68K-1/16W J a
CD O R 0223 88-108-473-080 C-RES,U 47K-1/16W J a
CD X R 0224 88-108-222-080 C-RES,U 2.2K-1/16W J a
CD X R 0225 88-108-221-080 C-RES,U 220-1/16W J a
CD X R 0226 88-108-000-080 C-JUMPER,U a
CD X R 0227 88-108-104-080 C-RES,U 100K-1/16W J a
CD O R 0228 88-108-103-080 C-RES,U 10K-1/16W J a

CD O R 0229 88-108-103-080 C-RES,U 10K-1/16W J a
CD O R 0230 88-108-103-080 C-RES,U 10K-1/16W J a
CD O R 0231 88-108-563-080 C-RES,U 56K-1/16W J a
CD O R 0232 88-108-563-080 C-RES,U 56K-1/16W J a
CD O R 0233 88-108-563-080 C-RES,U 56K-1/16W J a
CD O R 0234 88-108-563-080 C-RES,U 56K-1/16W J a
CD X R 0235 88-108-273-080 C-RES,U 27K-1/16W J a
CD X R 0236 88-108-273-080 C-RES,U 27K-1/16W J a
CD X R 0237 88-108-683-080 C-RES,U 68K-1/16W J a
CD O R 0238 88-108-102-080 C-RES,U 1K-1/16W J a

CDC-R927M
YZSTF
CD X R 0239 88-108-000-080 C-JUMPER,U a
CD X R 0240 88-118-100-080 C-RES,S 10-1/10W J a
CD O R 0241 88-108-101-080 C-RES,U 100-1/16W J a
CD X R 0243 88-108-000-080 C-JUMPER,U a
CD X R 0244 88-108-333-080 C-RES,U 33K-1/16W J a
CD X R 0245 88-108-474-080 C-RES,U 470K-1/16W J a
CD O R 0246 88-108-473-080 C-RES,U 47K-1/16W J a
CD O R 0247 88-108-103-080 C-RES,U 10K-1/16W J a
CD O R 0249 88-108-102-080 C-RES,U 1K-1/16W J a
CD O R 0250 88-108-102-080 C-RES,U 1K-1/16W J a

CD X R 0251 88-108-000-080 C-JUMPER,U a
CD O R 0253 88-108-103-080 C-RES,U 10K-1/16W J a
CD X R 0254 88-108-474-080 C-RES,U 470K-1/16W J a
CD X R 0255 88-108-474-080 C-RES,U 470K-1/16W J a
CD X R 0256 88-108-104-080 C-RES,U 100K-1/16W J a
CD X R 0281 88-108-222-080 C-RES,U 2.2K-1/16W J a
CD X R 0282 88-108-222-080 C-RES,U 2.2K-1/16W J a
CD X R 0298 88-108-472-080 C-RES,U 4.7K-1/16W J a
CD X R 0299 88-108-472-080 C-RES,U 4.7K-1/16W J a
CD O X 0241 87-A70-376-080 VIB,CER 16.934MHZ CSTLS16M9X55 a

CDC-R927M
YZSTF
FRONT O C 0602 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
FRONT O C 0603 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
FRONT O C 0604 87-A10-504-080 C-CAP,U 0.047-16 K B a
FRONT O C 0605 87-012-199-080 C-CAP,U 220P-50 J CH GRM a
FRONT O C 0606 87-A10-504-080 C-CAP,U 0.047-16 K B a
FRONT O C 0607 87-A10-504-080 C-CAP,U 0.047-16 K B a
FRONT O C 0608 87-A10-504-080 C-CAP,U 0.047-16 K B a
FRONT O C 0609 87-A10-504-080 C-CAP,U 0.047-16 K B a
FRONT O C 0610 87-A10-047-080 C-CAP,U 1-10 Z F a
FRONT O C 0611 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a

FRONT O C 0612 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
FRONT O C 0613 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
FRONT O C 0614 87-010-787-080 C-CAP,U 0.022-25 K B GRM a
FRONT O C 0615 87-010-787-080 C-CAP,U 0.022-25 K B GRM a
FRONT O C 0617 87-012-270-080 C-CAP,U 470P-50 K B GRM a
FRONT O C 0619 87-012-274-080 C-CAP,U 1000P-50 K B GRM a
FRONT O C 0620 87-012-274-080 C-CAP,U 1000P-50 K B GRM a
FRONT O CON0601 87-A61-585-080 C-CONN,24P H 54548-2490 a
FRONT S D 0601 87-A40-250-040 C-DIODE,DAN217 a
FRONT S D 0602 87-A40-817-040 C-ZENER,STZ6.8N a

CDC-R927M
YZSTF
FRONT S D 0603 87-A40-817-040 C-ZENER,STZ6.8N a
FRONT S IC 0601 87-A21-532-030 C-IC,LC75817W-8720 a
FRONT O IC 0602 87-A90-951-010 RCR UNIT,SBX1971-52 a
FRONT O LCD0601 8C-KC4-620-010 LCD,CKC-4 a
FRONT O LED0601 87-A91-355-040 C-LED,BR1112H-TR-RED a
FRONT O LED0602 87-A91-355-040 C-LED,BR1112H-TR-RED a
FRONT O LED0603 87-A91-355-040 C-LED,BR1112H-TR-RED a
FRONT O LED0604 87-A91-355-040 C-LED,BR1112H-TR-RED a
FRONT O LED0605 87-A41-085-010 LED,NSPW315BS WHT a
FRONT O LED0606 87-A91-355-040 C-LED,BR1112H-TR-RED a

FRONT O LED0607 87-A91-355-040 C-LED,BR1112H-TR-RED a
FRONT O LED0608 87-A41-118-040 C-LED,SEC1E01C-1 BLU a
FRONT O LED0609 87-A41-118-040 C-LED,SEC1E01C-1 BLU a
FRONT S Q 0610 89-324-122-040 C-TR,2SC2412KR a
FRONT S Q 0611 87-A30-287-040 C-TR,DTC114TKA a
FRONT S Q 0612 89-324-122-040 C-TR,2SC2412KR a
FRONT O R 0601 88-108-102-080 C-RES,U 1K-1/16W J a
FRONT O R 0602 88-108-102-080 C-RES,U 1K-1/16W J a
FRONT O R 0603 88-108-102-080 C-RES,U 1K-1/16W J a
FRONT O R 0604 88-108-102-080 C-RES,U 1K-1/16W J a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-8-

ELECTRICAL PARTS LIST - 3/10

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
FRONT X R 0605 88-108-333-080 C-RES,U 33K-1/16W J a
FRONT O R 0606 88-108-103-080 C-RES,U 10K-1/16W J a
FRONT O R 0607 88-108-103-080 C-RES,U 10K-1/16W J a
FRONT O R 0608 88-108-103-080 C-RES,U 10K-1/16W J a
FRONT O R 0609 88-108-103-080 C-RES,U 10K-1/16W J a
FRONT O R 0610 88-108-332-080 C-RES,U 3.3K-1/16W J a
FRONT X R 0611 88-118-331-080 C-RES,S 330-1/10W J a
FRONT O R 0612 88-108-102-080 C-RES,U 1K-1/16W J a
FRONT X R 0613 88-108-180-080 C-RES,U 18-1/16W J a
FRONT O R 0614 88-108-102-080 C-RES,U 1K-1/16W J a

FRONT X R 0615 88-118-681-080 C-RES,S 680-1/10W J a
FRONT X R 0616 88-118-681-080 C-RES,S 680-1/10W J a
FRONT X R 0617 88-118-221-080 C-RES,S 220-1/10W J a
FRONT O R 0618 88-108-102-080 C-RES,U 1K-1/16W J a
FRONT O R 0619 88-108-223-080 C-RES,U 22K-1/16W J a
FRONT X R 0620 88-118-681-080 C-RES,S 680-1/10W J a
FRONT O R 0621 88-108-223-080 C-RES,U 22K-1/16W J a
FRONT X R 0622 88-118-331-080 C-RES,S 330-1/10W J a
FRONT X R 0623 88-118-331-080 C-RES,S 330-1/10W J a
FRONT O R 0624 88-108-473-080 C-RES,U 47K-1/16W J a

CDC-R927M
YZSTF
FRONT O R 0625 88-108-473-080 C-RES,U 47K-1/16W J a
FRONT X R 0626 88-108-152-080 C-RES,U 1.5K-1/16W J a
FRONT O SW 0601 87-A90-001-080 C-SW,TACT SKQMAL a
FRONT O SW 0602 87-A90-001-080 C-SW,TACT SKQMAL a
FRONT O SW 0603 87-A90-001-080 C-SW,TACT SKQMAL a
FRONT O SW 0604 87-A90-001-080 C-SW,TACT SKQMAL a
FRONT O SW 0620 87-A90-001-080 C-SW,TACT SKQMAL a
FRONT O SW 0621 87-A92-330-010 SW,RTRY SRP-1211VE a
JACK O J 0601 87-A61-753-010 JACK,3.6 BLK HSJ1494-01 -020 a
KEY O C 0616 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a

KEY O C 0618 87-012-274-080 C-CAP,U 1000P-50 K B GRM a
KEY O CON0603 87-A61-586-080 C-CONN,16P V FLZT-SM1 a
KEY O L 0601 87-005-906-080 C-COIL,S 10UH K LK2125 a
KEY O L 0602 87-005-906-080 C-COIL,S 10UH K LK2125 a
KEY O LED0611 87-A91-355-040 C-LED,BR1112H-TR-RED a
KEY O LED0612 87-A91-355-040 C-LED,BR1112H-TR-RED a
KEY O LED0613 87-A91-355-040 C-LED,BR1112H-TR-RED a
KEY O LED0614 87-A91-355-040 C-LED,BR1112H-TR-RED a
KEY O LED0615 87-A91-355-040 C-LED,BR1112H-TR-RED a
KEY O LED0616 87-A91-355-040 C-LED,BR1112H-TR-RED a

CDC-R927M
YZSTF
KEY O LED0617 87-A91-355-040 C-LED,BR1112H-TR-RED a
KEY O LED0618 87-A91-355-040 C-LED,BR1112H-TR-RED a
KEY O LED0619 87-A41-118-040 C-LED,SEC1E01C-1 BLU a
KEY O LED0620 87-A41-118-040 C-LED,SEC1E01C-1 BLU a
KEY O LED0621 87-A41-118-040 C-LED,SEC1E01C-1 BLU a
KEY S Q 0614 87-A30-287-040 C-TR,DTC114TKA a
KEY S Q 0615 89-324-122-040 C-TR,2SC2412KR a
KEY S Q 0616 87-A30-287-040 C-TR,DTC114TKA a
KEY X R 0651 88-118-471-080 C-RES,S 470-1/10W J a
KEY X R 0652 88-118-681-080 C-RES,S 680-1/10W J a

KEY X R 0653 88-118-331-080 C-RES,S 330-1/10W J a
KEY X R 0654 88-118-331-080 C-RES,S 330-1/10W J a
KEY X R 0655 88-118-331-080 C-RES,S 330-1/10W J a
KEY X R 0656 88-118-331-080 C-RES,S 330-1/10W J a
KEY O R 0657 88-108-103-080 C-RES,U 10K-1/16W J a
KEY O SW 0606 87-A91-780-180 C-SW,TACT LS15B3T a
KEY O SW 0607 87-A91-780-180 C-SW,TACT LS15B3T a
KEY O SW 0608 87-A91-780-180 C-SW,TACT LS15B3T a
KEY O SW 0609 87-A91-780-180 C-SW,TACT LS15B3T a
KEY O SW 0610 87-A91-780-180 C-SW,TACT LS15B3T a

CDC-R927M
YZSTF
KEY O SW 0611 87-A91-780-180 C-SW,TACT LS15B3T a
KEY O SW 0612 87-A91-780-180 C-SW,TACT LS15B3T a
KEY O SW 0613 87-A91-780-180 C-SW,TACT LS15B3T a
KEY O SW 0614 87-A91-780-180 C-SW,TACT LS15B3T a
KEY O SW 0615 87-A91-780-180 C-SW,TACT LS15B3T a
KEY O SW 0616 87-A91-780-180 C-SW,TACT LS15B3T a
KEY O SW 0617 87-A91-780-180 C-SW,TACT LS15B3T a
KEY O SW 0618 87-A91-780-180 C-SW,TACT LS15B3T a
LED O FFC0731 8B-KC1-603-010 F-CABLE,2P (PWB LED) a
LED O LED0731 87-A40-228-010 LED,SLR-342MG T31 GREEN a

MAIN O ANT0101 8Z-KT1-614-010 ANT,AW-002 a
MAIN O C 0101 87-012-274-080 C-CAP,U 1000P-50 K B GRM a
MAIN O C 0102 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
MAIN O C 0103 87-012-282-080 C-CAP,U 4700P-50 K B GRM a
MAIN O C 0104 87-010-498-040 CAP,E 10-16 M 5L SRE a
MAIN O C 0105 87-010-787-080 C-CAP,U 0.022-25 K B GRM a
MAIN O C 0106 87-010-787-080 C-CAP,U 0.022-25 K B GRM a
MAIN O C 0107 87-012-274-080 C-CAP,U 1000P-50 K B GRM a
MAIN O C 0108 87-010-498-040 CAP,E 10-16 M 5L SRE a
MAIN O C 0109 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-9-

ELECTRICAL PARTS LIST - 4/10

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
MAIN O C 0110 87-012-281-080 C-CAP,U 3900P-50 K B GRM a
MAIN O C 0111 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
MAIN O C 0112 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0113 87-010-555-040 CAP,E 100-10 M 5L SRE a
MAIN O C 0114 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0115 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0116 87-010-495-040 CAP,E 2.2-50 M 5L SRE a
MAIN O C 0117 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
MAIN O C 0118 87-012-278-080 C-CAP,U 2200P-50 K B GRM a
MAIN O C 0119 87-A10-248-080 C-CAP,U 0.1-16 K BR a

MAIN O C 0120 87-012-282-080 C-CAP,U 4700P-50 K B GRM a
MAIN O C 0121 87-012-278-080 C-CAP,U 2200P-50 K B GRM a
MAIN O C 0123 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
MAIN O C 0125 87-010-786-080 C-CAP,U 0.018-25 K B GRM a
MAIN O C 0126 87-010-786-080 C-CAP,U 0.018-25 K B GRM a
MAIN O C 0127 87-010-805-080 C-CAP,S 1-16 Z F GRM a
MAIN O C 0128 87-010-805-080 C-CAP,S 1-16 Z F GRM a
MAIN O C 0131 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
MAIN O C 0132 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
MAIN O C 0151 87-012-336-080 C-CAP,U 330P-50 J SL GRM a

CDC-R927M
YZSTF
MAIN O C 0152 87-010-495-040 CAP,E 2.2-50 M 5L SRE a
MAIN O C 0153 87-012-271-080 C-CAP,U 560P-50 K B GRM a
MAIN O C 0154 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0155 87-012-182-080 C-CAP,U 27P-50 J CH GRM a
MAIN O C 0156 87-012-183-080 C-CAP,U 30P-50 J CH GRM a
MAIN O C 0157 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0158 87-010-553-040 CAP,E 47-16 M 5L SRE a
MAIN O C 0401 87-A11-062-080 C-CAP,S 2.2-16 Z F a
MAIN O C 0402 87-A11-062-080 C-CAP,S 2.2-16 Z F a
MAIN O C 0403 87-010-805-080 C-CAP,S 1-16 Z F GRM a

MAIN O C 0404 87-010-805-080 C-CAP,S 1-16 Z F GRM a
MAIN O C 0405 87-012-188-080 C-CAP,U 47P-50 J CH GRM a
MAIN O C 0406 87-012-188-080 C-CAP,U 47P-50 J CH GRM a
MAIN O C 0407 87-012-276-080 C-CAP,U 1500P-50 K B GRM a
MAIN O C 0408 87-012-276-080 C-CAP,U 1500P-50 K B GRM a
MAIN O C 0409 87-A11-062-080 C-CAP,S 2.2-16 Z F a
MAIN O C 0410 87-A11-062-080 C-CAP,S 2.2-16 Z F a
MAIN O C 0411 87-010-786-080 C-CAP,U 0.018-25 K B GRM a
MAIN O C 0412 87-010-786-080 C-CAP,U 0.018-25 K B GRM a
MAIN O C 0413 87-A10-781-080 C-CAP,U 0.15-10 K B a

CDC-R927M
YZSTF
MAIN O C 0414 87-A10-781-080 C-CAP,U 0.15-10 K B a
MAIN O C 0415 87-A10-781-080 C-CAP,U 0.15-10 K B a
MAIN O C 0416 87-A10-781-080 C-CAP,U 0.15-10 K B a
MAIN O C 0417 87-010-805-080 C-CAP,S 1-16 Z F GRM a
MAIN O C 0418 87-010-805-080 C-CAP,S 1-16 Z F GRM a
MAIN O C 0419 87-012-280-080 C-CAP,U 3300P-50 K B GRM a
MAIN O C 0420 87-012-280-080 C-CAP,U 3300P-50 K B GRM a
MAIN O C 0421 87-A11-070-080 C-CAP,U 0.033-16 K B a
MAIN O C 0422 87-A11-070-080 C-CAP,U 0.033-16 K B a
MAIN O C 0423 87-010-555-040 CAP,E 100-10 M 5L SRE a

MAIN O C 0424 87-010-497-040 CAP,E 4.7-35 M 5L SRE a
MAIN O C 0426 87-010-552-040 CAP,E 22-16 M 5L SRE a
MAIN O C 0427 87-010-555-040 CAP,E 100-10 M 5L SRE a
MAIN O C 0428 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0429 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0435 87-010-805-080 C-CAP,S 1-16 Z F GRM a
MAIN O C 0436 87-010-805-080 C-CAP,S 1-16 Z F GRM a
MAIN O C 0437 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0438 87-012-286-080 C-CAP,U 0.01-25 K B GRM a
MAIN O C 0439 87-010-494-040 CAP,E 1-50 M 5L SRE a

CDC-R927M
YZSTF
MAIN O C 0441 87-010-498-040 CAP,E 10-16 M 5L SRE a
MAIN O C 0442 87-010-498-040 CAP,E 10-16 M 5L SRE a
MAIN O C 0443 87-010-498-040 CAP,E 10-16 M 5L SRE a
MAIN O C 0444 87-010-498-040 CAP,E 10-16 M 5L SRE a
MAIN O C 0445 87-010-491-040 CAP,E 0.22-50 M 5L SRE a
MAIN O C 0446 87-010-491-040 CAP,E 0.22-50 M 5L SRE a
MAIN O C 0453 87-010-498-040 CAP,E 10-16 M 5L SRE a
MAIN O C 0454 87-010-498-040 CAP,E 10-16 M 5L SRE a
MAIN O C 0457 87-012-270-080 C-CAP,U 470P-50 K B GRM a
MAIN O C 0458 87-012-270-080 C-CAP,U 470P-50 K B GRM a

MAIN O C 0461 87-012-281-080 C-CAP,U 3900P-50 K B GRM a
MAIN O C 0501 87-010-495-040 CAP,E 2.2-50 M 5L SRE a
MAIN O C 0502 87-010-495-040 CAP,E 2.2-50 M 5L SRE a
MAIN O C 0503 87-010-495-040 CAP,E 2.2-50 M 5L SRE a
MAIN O C 0504 87-010-495-040 CAP,E 2.2-50 M 5L SRE a
MAIN O C 0505 87-012-271-080 C-CAP,U 560P-50 K B GRM a
MAIN O C 0506 87-012-271-080 C-CAP,U 560P-50 K B GRM a
MAIN O C 0507 87-012-271-080 C-CAP,U 560P-50 K B GRM a
MAIN O C 0508 87-012-271-080 C-CAP,U 560P-50 K B GRM a
MAIN O C 0509 87-A12-390-080 C-CAP,S 1-25 Z F GRM40 a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-10-

ELECTRICAL PARTS LIST - 5/10

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
MAIN O C 0510 87-010-553-040 CAP,E 47-16 M 5L SRE a
MAIN O C 0511 87-012-368-080 C-CAP,S 0.1-50 Z F GRM a
MAIN O C 0512 87-012-368-080 C-CAP,S 0.1-50 Z F GRM a
MAIN O C 0513 87-012-368-080 C-CAP,S 0.1-50 Z F GRM a
MAIN O C 0514 87-012-368-080 C-CAP,S 0.1-50 Z F GRM a
MAIN O C 0518 87-012-278-080 C-CAP,U 2200P-50 K B GRM a
MAIN O C 0519 87-010-497-040 CAP,E 4.7-35 M 5L SRE a
MAIN O C 0520 87-012-368-080 C-CAP,S 0.1-50 Z F GRM a
MAIN O C 0521 87-012-368-080 C-CAP,S 0.1-50 Z F GRM a
MAIN O C 0522 87-010-552-040 CAP,E 22-16 M 5L SRE a

MAIN O C 0525 8A-KC7-623-000 CAP,E 2200-16 125 BT a
MAIN O C 0531 87-012-368-080 C-CAP,S 0.1-50 Z F GRM a
MAIN O C 0701 87-010-495-040 CAP,E 2.2-50 M 5L SRE a
MAIN O C 0702 87-010-495-040 CAP,E 2.2-50 M 5L SRE a
MAIN O C 0705 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0707 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0721 87-010-196-080 C-CAP,S 0.1-25 Z F C2012 a
MAIN O C 0722 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0723 87-010-553-040 CAP,E 47-16 M 5L SRE a
MAIN O C 0724 87-010-196-080 C-CAP,S 0.1-25 Z F C2012 a

CDC-R927M
YZSTF
MAIN O C 0725 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0726 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0751 87-010-805-080 C-CAP,S 1-16 Z F GRM a
MAIN O C 0752 87-010-805-080 C-CAP,S 1-16 Z F GRM a
MAIN O C 0753 87-010-787-080 C-CAP,U 0.022-25 K B GRM a
MAIN O C 0754 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0755 87-010-787-080 C-CAP,U 0.022-25 K B GRM a
MAIN O C 0771 87-010-805-080 C-CAP,S 1-16 Z F GRM a
MAIN O C 0772 87-010-805-080 C-CAP,S 1-16 Z F GRM a
MAIN O C 0801 87-012-278-080 C-CAP,U 2200P-50 K B GRM a

MAIN O C 0802 87-012-278-080 C-CAP,U 2200P-50 K B GRM a
MAIN O C 0811 87-010-553-040 CAP,E 47-16 M 5L SRE a
MAIN O C 0812 87-010-787-080 C-CAP,U 0.022-25 K B GRM a
MAIN O C 0813 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0814 87-010-553-040 CAP,E 47-16 M 5L SRE a
MAIN O C 0821 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0822 87-010-787-080 C-CAP,U 0.022-25 K B GRM a
MAIN O C 0831 87-010-553-040 CAP,E 47-16 M 5L SRE a
MAIN O C 0832 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0834 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a

CDC-R927M
YZSTF
MAIN O C 0838 87-A12-390-080 C-CAP,S 1-25 Z F GRM40 a
MAIN O C 0901 87-012-172-080 C-CAP,U 10P-50 D CH GRM a
MAIN O C 0902 87-012-172-080 C-CAP,U 10P-50 D CH GRM a
MAIN O C 0903 87-012-195-080 C-CAP,U 100P-50 J CH GRM a
MAIN O C 0904 87-012-195-080 C-CAP,U 100P-50 J CH GRM a
MAIN O C 0906 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0907 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0908 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0910 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a
MAIN O C 0915 87-016-039-090 CAP,DL 0.022F-5.5 Z 70 FM a

MAIN O C 0971 87-A12-307-080 C-CAP,S 0.1-50 K B a
MAIN O C 0972 87-010-787-080 C-CAP,U 0.022-25 K B GRM a
MAIN O C 0981 87-A10-260-080 C-CAP,U 0.1-16 K B a
MAIN O CNA0801 8A-KT1-645-010 CONN ASSY,8P ISO-BLACK-B X a
MAIN O CNA0802 8A-KT1-646-010 CONN ASSY,8P ISO-WHITE-B X a
MAIN O CON0701 87-A61-584-010 CONN,24P H 52089-2420 a
MAIN O CON0702 87-A61-583-010 CONN,16P H 52089-1620 a
MAIN O CON0721 87-A60-670-010 CONN,6P H 2MM JMT a
MAIN O CON0771 87-A61-219-010 CONN,20P H 52089-2020 a
MAIN S D 0101 87-A40-250-040 C-DIODE,DAN217 a

CDC-R927M
YZSTF
MAIN S D 0151 87-070-136-080 ZENER,MTZJ5.1B a
MAIN S D 0421 87-017-365-040 C-DIODE,DA204U a
MAIN S D 0422 87-017-366-040 C-DIODE,DAN202U a
MAIN S D 0501 87-001-783-080 DIODE,1N4002 a
MAIN S D 0502 87-001-783-080 DIODE,1N4002 a
MAIN S D 0503 87-001-783-080 DIODE,1N4002 a
MAIN S D 0504 87-001-783-080 DIODE,1N4002 a
MAIN S D 0505 87-001-783-080 DIODE,1N4002 a
MAIN S D 0506 87-001-783-080 DIODE,1N4002 a
MAIN S D 0507 87-001-783-080 DIODE,1N4002 a

MAIN S D 0508 87-001-783-080 DIODE,1N4002 a
MAIN S D 0509 87-020-465-080 DIODE,1SS133 a
MAIN S D 0510 87-A40-650-080 ZENER,MTZJ6.8A a
MAIN S D 0531 87-070-334-080 ZENER,MTZJ10B a
MAIN S D 0751 87-A40-817-040 C-ZENER,STZ6.8N a
MAIN S D 0752 87-A40-817-040 C-ZENER,STZ6.8N a
MAIN S D 0753 87-A40-817-040 C-ZENER,STZ6.8N a
MAIN S D 0801 87-A40-798-010 DIODE,1N5402 (3A/200V) a
MAIN S D 0811 87-A40-624-080 ZENER,MTZJ10A a
MAIN S D 0821 87-A40-344-080 ZENER,MTZJ6.2C a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-11-

ELECTRICAL PARTS LIST - 6/10

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
MAIN S D 0822 87-017-367-040 C-DIODE,DAP202U a
MAIN S D 0831 87-A40-624-080 ZENER,MTZJ10A a
MAIN S D 0832 87-017-366-040 C-DIODE,DAN202U a
MAIN S D 0841 87-070-136-080 ZENER,MTZJ5.1B a
MAIN S D 0901 87-017-366-040 C-DIODE,DAN202U a
MAIN S D 0905 87-017-366-040 C-DIODE,DAN202U a
MAIN S D 0971 87-070-136-080 ZENER,MTZJ5.1B a
MAIN S D 0981 87-A40-620-080 ZENER,MTZJ6.2A a
MAIN S D 0982 87-070-136-080 ZENER,MTZJ5.1B a
MAIN ! S F 0801 8B-KC1-621-010 FUSE,15A 32V a

MAIN S IC 0151 88-KT1-607-080 C-IC,SAA6579T a
MAIN S IC 0401 87-A22-225-030 C-IC,LA2657M a
MAIN S IC 0402 87-017-917-040 C-IC,BU4066BCF a
MAIN S IC 0501 87-A22-157-010 IC,LA4743J a
MAIN S IC 0721 87-A20-712-040 C-IC,BA6417F a
MAIN S IC 0901 8C-KC2-611-030 C-IC,UPD178078GF-567-3BA a
MAIN S IC 0971 88-KT1-606-080 IC,PST994D a
MAIN O J 0401 87-A61-225-110 JACK,PIN 2P XR-401 a
MAIN O J 0751 8A-KC7-620-010 JACK,DIN 13P SKDS1302 a
MAIN O L 0101 87-003-143-080 COIL,4.7UH K LAL02 a

CDC-R927M
YZSTF
MAIN O L 0102 8Z-KT1-619-010 COIL,68MH K7-D a
MAIN X L 0151 88-100-000-010 PLATING-JW, 0.58 SN95 a
MAIN O L 0451 87-003-102-080 COIL,10UH J LAL02 a
MAIN O L 0701 87-003-102-080 COIL,10UH J LAL02 a
MAIN O L 0702 87-005-906-080 C-COIL,S 10UH K LK2125 a
MAIN O L 0721 87-005-121-080 COIL,2.2UH M LAL04 a
MAIN O L 0801 8B-KCF-615-010 FLTR,AMORPHOUS -CHOKE a
MAIN O L 0901 87-005-906-080 C-COIL,S 10UH K LK2125 a
MAIN S Q 0101 87-A30-405-040 C-TR,DTC114TUA a
MAIN S Q 0102 87-A30-143-040 C-TR,2SA1576A a

MAIN S Q 0103 87-A30-144-040 C-TR,2SC4081 a
MAIN S Q 0105 87-A30-144-040 C-TR,2SC4081 a
MAIN S Q 0106 87-A30-144-040 C-TR,2SC4081 a
MAIN S Q 0107 87-A30-144-040 C-TR,2SC4081 a
MAIN S Q 0108 87-A30-144-040 C-TR,2SC4081 a
MAIN S Q 0405 87-A30-405-040 C-TR,DTC114TUA a
MAIN S Q 0406 87-A30-405-040 C-TR,DTC114TUA a
MAIN S Q 0407 87-A30-405-040 C-TR,DTC114TUA a
MAIN S Q 0408 87-A30-405-040 C-TR,DTC114TUA a
MAIN S Q 0409 87-A30-405-040 C-TR,DTC114TUA a

CDC-R927M
YZSTF
MAIN S Q 0410 87-A30-405-040 C-TR,DTC114TUA a
MAIN S Q 0411 87-A30-405-040 C-TR,DTC114TUA a
MAIN S Q 0421 87-A30-144-040 C-TR,2SC4081 a
MAIN S Q 0422 87-A30-385-040 C-TR,DTA114YUA a
MAIN S Q 0423 87-A30-144-040 C-TR,2SC4081 a
MAIN S Q 0521 87-A30-294-040 C-TR,DTB123YK a
MAIN S Q 0731 87-A30-385-040 C-TR,DTA114YUA a
MAIN S Q 0751 87-A30-385-040 C-TR,DTA114YUA a
MAIN S Q 0752 87-A30-404-040 C-TR,DTC114YUA a
MAIN S Q 0811 89-213-750-010 TR,2SB1375 a

MAIN S Q 0812 87-A30-405-040 C-TR,DTC114TUA a
MAIN S Q 0813 89-420-120-010 TR,2SD2012 a
MAIN O Q 0821 89-418-580-080 TR,2SD1858TV2 a
MAIN S Q 0831 89-420-120-010 TR,2SD2012 a
MAIN S Q 0832 87-A30-144-040 C-TR,2SC4081 a
MAIN S Q 0833 87-A30-143-040 C-TR,2SA1576A a
MAIN S Q 0834 87-A30-405-040 C-TR,DTC114TUA a
MAIN S Q 0901 87-A30-405-040 C-TR,DTC114TUA a
MAIN X R 0101 88-108-105-080 C-RES,U 1M-1/16W J a
MAIN O R 0102 88-108-102-080 C-RES,U 1K-1/16W J a

CDC-R927M
YZSTF
MAIN O R 0103 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0104 88-108-103-080 C-RES,U 10K-1/16W J a
MAIN X R 0105 88-108-222-080 C-RES,U 2.2K-1/16W J a
MAIN X R 0106 88-108-181-080 C-RES,U 180-1/16W J a
MAIN O R 0107 88-108-223-080 C-RES,U 22K-1/16W J a
MAIN X R 0108 88-108-821-080 C-RES,U 820-1/16W J a
MAIN O R 0109 88-108-103-080 C-RES,U 10K-1/16W J a
MAIN O R 0110 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN X R 0111 88-108-333-080 C-RES,U 33K-1/16W J a
MAIN O R 0112 88-108-473-080 C-RES,U 47K-1/16W J a

MAIN X R 0113 88-108-184-080 C-RES,U 180K-1/16W J a
MAIN X R 0114 88-118-100-080 C-RES,S 10-1/10W J a
MAIN X R 0115 88-108-330-080 C-RES,U 33-1/16W J a
MAIN X R 0116 88-108-100-080 C-RES,U 10-1/16W J a
MAIN X R 0117 88-108-472-080 C-RES,U 4.7K-1/16W J a
MAIN O R 0118 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0119 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN X R 0120 88-121-102-080 RES,1K-1/8W J a
MAIN O R 0121 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0122 88-108-473-080 C-RES,U 47K-1/16W J a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-12-

ELECTRICAL PARTS LIST - 7/10

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
MAIN O R 0123 88-108-123-080 C-RES,U 12K-1/16W J a
MAIN X R 0124 88-121-123-080 RES,12K-1/8W J a
MAIN X R 0125 88-121-473-080 RES,47K-1/8W J a
MAIN X R 0131 88-118-000-080 C-JUMPER,S a
MAIN X R 0151 88-108-331-080 C-RES,U 330-1/16W J a
MAIN X R 0152 88-108-222-080 C-RES,U 2.2K-1/16W J a
MAIN X R 0401 88-108-682-080 C-RES,U 6.8K-1/16W J a
MAIN X R 0402 88-108-682-080 C-RES,U 6.8K-1/16W J a
MAIN O R 0403 88-108-153-080 C-RES,U 15K-1/16W J a
MAIN O R 0404 88-108-153-080 C-RES,U 15K-1/16W J a

MAIN X R 0405 88-108-392-080 C-RES,U 3.9K-1/16W J a
MAIN X R 0406 88-108-392-080 C-RES,U 3.9K-1/16W J a
MAIN O R 0407 88-108-473-080 C-RES,U 47K-1/16W J a
MAIN O R 0408 88-108-473-080 C-RES,U 47K-1/16W J a
MAIN X R 0409 88-108-683-080 C-RES,U 68K-1/16W J a
MAIN X R 0410 88-108-683-080 C-RES,U 68K-1/16W J a
MAIN X R 0411 88-108-333-080 C-RES,U 33K-1/16W J a
MAIN X R 0412 88-108-333-080 C-RES,U 33K-1/16W J a
MAIN X R 0413 88-108-683-080 C-RES,U 68K-1/16W J a
MAIN X R 0414 88-108-683-080 C-RES,U 68K-1/16W J a

CDC-R927M
YZSTF
MAIN X R 0415 88-118-470-080 C-RES,S 47-1/10W J a
MAIN X R 0418 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0419 88-118-270-080 C-RES,S 27-1/10W J a
MAIN X R 0421 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0422 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0423 88-121-472-080 RES,4.7K-1/8W J a
MAIN X R 0424 88-108-105-080 C-RES,U 1M-1/16W J a
MAIN O R 0425 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0426 88-108-103-080 C-RES,U 10K-1/16W J a
MAIN X R 0427 88-108-105-080 C-RES,U 1M-1/16W J a

MAIN O R 0428 88-108-562-080 C-RES,U 5.6K-1/16W J a
MAIN X R 0429 88-108-222-080 C-RES,U 2.2K-1/16W J a
MAIN O R 0431 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0432 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0433 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0434 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0435 88-108-223-080 C-RES,U 22K-1/16W J a
MAIN O R 0436 88-108-223-080 C-RES,U 22K-1/16W J a
MAIN O R 0437 88-108-223-080 C-RES,U 22K-1/16W J a
MAIN O R 0438 88-108-223-080 C-RES,U 22K-1/16W J a

CDC-R927M
YZSTF
MAIN X R 0439 88-108-335-080 C-RES,U 3.3M-1/16W J a
MAIN X R 0440 88-108-335-080 C-RES,U 3.3M-1/16W J a
MAIN O R 0441 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0442 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0443 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0444 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN X R 0446 88-108-000-080 C-JUMPER,U a
MAIN O R 0447 88-108-103-080 C-RES,U 10K-1/16W J a
MAIN X R 0448 88-108-000-080 C-JUMPER,U a
MAIN X R 0455 88-108-104-080 C-RES,U 100K-1/16W J a

MAIN X R 0456 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0457 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0458 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0461 88-121-222-080 RES,2.2K-1/8W J a
MAIN X R 0462 88-108-122-080 C-RES,U 1.2K-1/16W J a
MAIN X R 0471 88-108-393-080 C-RES,U 39K-1/16W J a
MAIN X R 0472 88-108-393-080 C-RES,U 39K-1/16W J a
MAIN O R 0473 88-108-563-080 C-RES,U 56K-1/16W J a
MAIN O R 0474 88-108-563-080 C-RES,U 56K-1/16W J a
MAIN O R 0501 88-108-123-080 C-RES,U 12K-1/16W J a

CDC-R927M
YZSTF
MAIN O R 0502 88-108-123-080 C-RES,U 12K-1/16W J a
MAIN X R 0503 88-121-123-080 RES,12K-1/8W J a
MAIN X R 0504 88-121-123-080 RES,12K-1/8W J a
MAIN X R 0505 88-108-183-080 C-RES,U 18K-1/16W J a
MAIN X R 0506 88-108-183-080 C-RES,U 18K-1/16W J a
MAIN X R 0507 88-108-183-080 C-RES,U 18K-1/16W J a
MAIN X R 0508 88-108-183-080 C-RES,U 18K-1/16W J a
MAIN X R 0509 88-108-684-080 C-RES,U 680K-1/16W J a
MAIN X R 0510 88-108-684-080 C-RES,U 680K-1/16W J a
MAIN X R 0511 88-108-684-080 C-RES,U 680K-1/16W J a

MAIN X R 0512 88-108-684-080 C-RES,U 680K-1/16W J a
MAIN X R 0513 88-121-822-080 RES,8.2K-1/8W J a
MAIN X R 0514 88-108-105-080 C-RES,U 1M-1/16W J a
MAIN O R 0522 87-A10-260-080 C-CAP,U 0.1-16 K B a
MAIN X R 0523 88-108-000-080 C-JUMPER,U a
MAIN X R 0531 88-118-100-080 C-RES,S 10-1/10W J a
MAIN X R 0541 88-118-000-080 C-JUMPER,S a
MAIN X R 0542 88-118-000-080 C-JUMPER,S a
MAIN O R 0701 88-108-562-080 C-RES,U 5.6K-1/16W J a
MAIN O R 0702 88-108-562-080 C-RES,U 5.6K-1/16W J a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-13-

ELECTRICAL PARTS LIST - 8/10

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
MAIN X R 0703 88-108-472-080 C-RES,U 4.7K-1/16W J a
MAIN X R 0704 88-108-472-080 C-RES,U 4.7K-1/16W J a
MAIN O R 0706 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN X R 0707 88-121-102-080 RES,1K-1/8W J a
MAIN X R 0711 88-118-330-080 C-RES,S 33-1/10W J a
MAIN X R 0721 88-118-000-080 C-JUMPER,S a
MAIN O R 0722 88-108-103-080 C-RES,U 10K-1/16W J a
MAIN O R 0723 88-108-103-080 C-RES,U 10K-1/16W J a
MAIN O R 0724 88-108-153-080 C-RES,U 15K-1/16W J a
MAIN O R 0725 88-108-123-080 C-RES,U 12K-1/16W J a

MAIN O R 0726 88-108-473-080 C-RES,U 47K-1/16W J a
MAIN X R 0727 88-108-683-080 C-RES,U 68K-1/16W J a
MAIN X R 0728 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0732 88-118-181-080 C-RES,S 180-1/10W J a
MAIN X R 0751 88-121-562-080 RES,5.6K-1/8W J a
MAIN X R 0752 88-121-562-080 RES,5.6K-1/8W J a
MAIN X R 0753 88-108-472-080 C-RES,U 4.7K-1/16W J a
MAIN X R 0754 88-108-472-080 C-RES,U 4.7K-1/16W J a
MAIN O R 0755 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0756 88-108-102-080 C-RES,U 1K-1/16W J a

CDC-R927M
YZSTF
MAIN O R 0757 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0758 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0759 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0760 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0761 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0762 88-108-224-080 C-RES,U 220K-1/16W J a
MAIN O R 0763 88-108-224-080 C-RES,U 220K-1/16W J a
MAIN X R 0771 88-121-562-080 RES,5.6K-1/8W J a
MAIN X R 0772 88-121-562-080 RES,5.6K-1/8W J a
MAIN X R 0773 88-108-392-080 C-RES,U 3.9K-1/16W J a

MAIN X R 0774 88-108-392-080 C-RES,U 3.9K-1/16W J a
MAIN O R 0811 88-108-103-080 C-RES,U 10K-1/16W J a
MAIN X R 0812 88-148-681-080 C-RES, 680-1/2W J a
MAIN X R 0814 88-118-391-080 C-RES,S 390-1/10W J a
MAIN X R 0815 88-118-391-080 C-RES,S 390-1/10W J a
MAIN X R 0816 88-140-229-080 RES,2.2-1/2W J a
MAIN X R 0817 88-118-102-080 C-RES,S 1K-1/10W J a
MAIN X R 0821 88-108-680-080 C-RES,U 68-1/16W J a
MAIN X R 0822 88-108-682-080 C-RES,U 6.8K-1/16W J a
MAIN X R 0831 88-118-102-080 C-RES,S 1K-1/10W J a

CDC-R927M
YZSTF
MAIN X R 0832 88-108-273-080 C-RES,U 27K-1/16W J a
MAIN O R 0833 88-108-103-080 C-RES,U 10K-1/16W J a
MAIN O R 0834 88-108-473-080 C-RES,U 47K-1/16W J a
MAIN X R 0841 88-108-222-080 C-RES,U 2.2K-1/16W J a
MAIN X R 0901 88-121-102-080 RES,1K-1/8W J a
MAIN X R 0902 88-121-102-080 RES,1K-1/8W J a
MAIN X R 0903 88-121-102-080 RES,1K-1/8W J a
MAIN O R 0904 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN X R 0905 88-121-102-080 RES,1K-1/8W J a
MAIN X R 0906 88-121-102-080 RES,1K-1/8W J a

MAIN X R 0907 88-121-102-080 RES,1K-1/8W J a
MAIN X R 0908 88-121-102-080 RES,1K-1/8W J a
MAIN O R 0909 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0910 88-108-103-080 C-RES,U 10K-1/16W J a
MAIN O R 0911 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN X R 0912 88-121-102-080 RES,1K-1/8W J a
MAIN X R 0913 88-121-102-080 RES,1K-1/8W J a
MAIN X R 0914 88-121-102-080 RES,1K-1/8W J a
MAIN X R 0915 88-121-563-080 RES,56K-1/8W J a
MAIN O R 0916 88-108-102-080 C-RES,U 1K-1/16W J a

CDC-R927M
YZSTF
MAIN O R 0917 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN X R 0918 88-121-102-080 RES,1K-1/8W J a
MAIN X R 0921 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN O R 0922 88-108-224-080 C-RES,U 220K-1/16W J a
MAIN X R 0923 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0924 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN O R 0925 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0926 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0927 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN X R 0928 88-108-222-080 C-RES,U 2.2K-1/16W J a

MAIN X R 0929 88-108-222-080 C-RES,U 2.2K-1/16W J a
MAIN O R 0932 88-108-473-080 C-RES,U 47K-1/16W J a
MAIN X R 0933 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN O R 0934 88-108-473-080 C-RES,U 47K-1/16W J a
MAIN X R 0935 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN O R 0936 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN X R 0937 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN O R 0943 88-108-224-080 C-RES,U 220K-1/16W J a
MAIN X R 0944 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0945 88-108-104-080 C-RES,U 100K-1/16W J a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-14-

ELECTRICAL PARTS LIST - 9/10

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
MAIN X R 0946 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0947 88-121-104-080 RES,100K-1/8W J a
MAIN X R 0948 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0949 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0950 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0951 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0952 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0956 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0957 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN X R 0958 88-108-104-080 C-RES,U 100K-1/16W J a

MAIN X R 0959 88-108-104-080 C-RES,U 100K-1/16W J a
MAIN O R 0961 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0962 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0963 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN O R 0964 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN X R 0965 88-121-102-080 RES,1K-1/8W J a
MAIN O R 0967 88-108-102-080 C-RES,U 1K-1/16W J a
MAIN X R 0968 88-121-473-080 RES,47K-1/8W J a
MAIN O R 0969 88-108-473-080 C-RES,U 47K-1/16W J a
MAIN O R 0971 88-108-153-080 C-RES,U 15K-1/16W J a

CDC-R927M
YZSTF
MAIN O R 0973 88-108-563-080 C-RES,U 56K-1/16W J a
MAIN O R 0981 88-108-223-080 C-RES,U 22K-1/16W J a
MAIN O R 0982 88-108-473-080 C-RES,U 47K-1/16W J a
MAIN O R 0992 88-108-473-080 C-RES,U 47K-1/16W J a
MAIN X R 0994 88-108-000-080 C-JUMPER,U a
MAIN O SFR0101 87-024-437-080 SFR,100K H RH063MC a
MAIN O TU 0101 8C-KTA-621-010 TU UNIT, FAE347-E30 a
MAIN X W 0101 8Z-KC1-614-010 WIRE,ANT a
MAIN X W 0801 8A-KCG-615-010 WIRE,400 P-MUTE a
MAIN O X 0151 87-A70-091-010 VIB,XTAL 4.332MHZ CSA-309 a

MAIN O X 0901 87-A70-372-080 VIB,XTAL 6.3MHZ HC-49/U-S a
SENSOR O CNA0671 8B-KC7-617-010 CONN ASSY,6P EMP a
SENSOR O FFC0671 8B-KC7-618-010 F-CABLE,2P MOT a
SENSOR O PS 0671 87-A92-061-080 C-SNSR,GP1S092 HCPI a
SENSOR X R 0671 88-118-331-080 C-RES,S 330-1/10W J a
SENSOR O SW 0671 87-A92-039-080 C-SW,PUSH ESE22MH24XQ a
SW O SW 0001 87-A92-279-080 C-SW,PUSH 2-1 ESE22MH22XQ a
SW O SW 0002 87-A92-279-080 C-SW,PUSH 2-1 ESE22MH22XQ a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-15-

ELECTRICAL PARTS LIST - 10/10

• Regarding connectors, they are not stocked as they are not the initial order items.
The connectors are available after they are supplied from connector manufacturers upon the order is received.

CHIP RESISTOR PART CODE

Chip Resistor Part Coding

88

A

Resistor Code

Chip resistor

Wattage Type Tolerance
1/16W 1005 5% CJ

1/16W
1/10W

1/8W

1608
2125

3216

5%
5%

5%

Symbol

CJ
CJ

CJ

Figure

Value of resistor

Form

L

Dimensions (mm)

t

W

0.55

Resistor Code

108
118

128

LW t

1.0 0.5 0.35 104

1.6 0.8 0.45
2 1.25 0.45

3.2

1.6

: A
: A

-16-

TRANSISTOR ILLUSTRATION -1/1

E C B

2SB1326
2SD1858

B C E

2SB1375
2SD2012

C

B

E

2SA1037
2SA1576
2SC2412
2SC4081
DTA114YUA
DTB123YK
DTC114TKA
DTC114TUA
DTC114YUA

-17-

BLOCK DIAGRAM - 1/1 (OVERALL)

MAIN C.B

IC151

SAA6579T

CD C.B

TU101

Q101

IC401

IC901

IC402

Q405,406

BU4066BCF

Q407-410

Q422,423

IC501

J401

REAR

L,R

CNA802

CNA801

CNA671

SENSOR C.B

FRONT C.B

LCD601

LCD,CKC-4

SW601-604,620

CON721

IC721

BA6417F

CON701

CON601

IC601

LC75817W

-8720
SW621

AUDIO

CONTROL

CON702

CON603

SW606-618

KEY C.B

J751

FFC601

J601

AUX IN

JACK C.B

-18-

SCHEMATIC DIAGRAM - 1/3 (MAIN/SENSOR/LED SECTION)

MAIN C.B

(ANTENNA)

AM/FM OSC

IF REQ/OUT

SENSOR C.B

FFC671

LO/DX SW

180K

100K

Q108

RDS

VOLTAGE

ADJ.

QUAL

SAA6579T

4.332MHz

BU4066BCF

2SD1858TV2

LEVEL-M

330

R671

TO KEY C.B CON603TO FRONT C.B CON601

LED731

SLR-342MG T31

GREEN

(ILLUMINATION)

FFC731

LED C.B

MOTOR DRIVER

47/16

U-COM

LM SW

AUX IN

CDS IN

1/25(S)

TO CD CHANGER

D841

MTZJ5.1B

!

F802

0.5A

!

15A 32V

CNA802

TO POWER SUPPLY TO SPEAKER

CNA801

W801

TO CD C.B CON201

: AUDIO (PB) SIGNAL

-19-

WIRING - 1/3 (MAIN C.B/SENSOR C.B/LED C.B )

J401

C453

R437
Q409

R102

B
E

C105

R114

R113

C116

C151

R457

C

C104

C108

C107

C127

L

C457

R443

B
E

C106

BE

R104

R116

R106

R120

SFR101

C157

REAR

L451

C454

R458

R444

R438

B

C

C

E

Q410 Q408

C445

Q405

C

R439

R105

B
E

R151

D151

C152

C153

C113

R

C458

R436

R440

Q103

C

R456

B
E

C446

C

BE

1

8

R703

R442

C

Q422

Q406

R131

J401

R455

R435

B
E

C

BE

R448

C701

C

L151

IC151

R704
R701

R509

R501

R441

R462

Q407

R446

R431

R946

R508

C439

C501

R512

C504

16

D422

C702

R505

C444

9

C156

C158

C154

C522

R461

R122

C123

C

Q901

X151

R428

R429

R702

(ANTENNA)

W101

C119

C120
R103

Q108

C131

C118

R121

EB

C

Q106
C117

C132

ANT101

ANT101

D101

R118

CBEC

R117

R109

C110

R107

R110

Q105

EB

C

R101

TU101

C102

EB

C

C103

BE

Q107

C125

C111

R108

C114

L102

L101

C101

1

Q101

Q102

R115

R119
C121

C109

C128

C126

C112

R112
R111
C115

26

MAIN C.B

C508

C521

C505

24 2

25 1

R522

C519

C

Q521

BE

R506

C510

R523

E
B

C155

R152

EB

C

R513

R125

Q423

R447

R511

R434

R504

C903
C904

R945

R944

R961

C503

R433

X901

C461

D905

L701

R507

C441

R503

C443

R936

C908

C902

50

51

R947

R951

BLK

115

216

C506

C502

R510

R405

R401
C403

C435

R123
C426

R421

C771

R124

C772 R402

L901

C901

R948

R949

R952

R950

R732

BRN

CON702

IC501

R502

R403

C407

R422

64

C915

C906

31

Q731

C507

C413

C411

C409

1

E

C

B

C415

C436

R957

C417

C408

R404

C907

30

IC901

80

R962

49

16
C410
C412

R406

R933

R963

R432

IC401

C402

R964

C401

81

C981

17

C414

R925

R915

C520

48

D531

C416

C707

R923

C418

R914

R904

R926

C442

R910

1

100

C518

C419

C424

R921

R927

C421

R473

33

32

R912

R471

C422

C420

R472

R958

C705

D507

C752

R913

R968

R922

D503

R407

C405

C404

R909
R916

R965

R707

C423

R474

C406

Q421

R424

R932

R771

R924

R706

C801

C531

C525

R542

C511

D506

D509

R411

R413

R409

1

IC402

7

R408

R412

R410

C427

B

C

E

R423

R773

R901

R928

R929

R959

R956

CON701

123

224

R425

R772

R917

R902

C429

C437

R774

D832

TO FRONT C.B CON601TO KEY C.B CON603

14

8

R414

R754

R426

R903

D502

C514

R419

C

BE

R753
C438

R427

D421
C751

R711

R418

C428

R531

7531
8642

D505

C513

D501

D508

D504

R973

R541

1

IC971

R415

Q411

D971

3

R752

R751

R907

R918

R908

R906

R967

R937

L702

C512

C802

D841

R971

C971

C972

D981 R981

R911

C723

C721
R724

1

4

R992

R969

D982

R841

D510

D822

R721

R725

IC721

R722

R935

D901

-20-

R816

C722

R762

C509

8

5

R723

R934

C910

R982

L721

D831

R905

876

D801

C

BE

Q812

C725

C726

C724

R943

3

D752

D753

R514

D821
C822

ECB

C814

C813

R728

R994

CON771

20

19

1

C832

C831

R726

R727

C834

2

101112131415161718192021222324

R763

R759

D751

C821

Q821

D811

C812

CON721

6

1

TO CD CHANGER

J751

R758

R761

13

85

R760

41

R756

C811

R817

Q833

C

Q752

R811

R821

E
B

BE

R822

B

C

E

Q831

FFC201

C

R831
R832

C838

R833

Q832

EB

R812

B
C
E

Q813

B
C
E

R757

C

C755

C754

Q751
R755

BE

C753

912

L801

R815
R814

B
C

Q811

E

C

Q834

R834

TO CD C.B

CON201

FFC731

BRN
BLK

CNA802
(WHITE)

TO SPEAKER

CNA801
(BLACK)

TO POWER SUPPLY

PH.MUTE

W801

F801

BRN

M601

(MOTOR)

+

-

FFC671

R672

PS671

BRN

R671

R673

SW671

CNA671

1

6

BLK
BRN
RED
ORG
YEL
GRN

SENSOR C.B

LED C.B

LED731

(ILLUMINATION)

AUTO

F802

BLK

ANT+B

1234567892526272829303132

A

B

C

D

E

F

G

H

I

J

K

L

M

N

O

P

Q

R

S

T

U

SCHEMATIC DIAGRAM - 2/3 (FRONT/KEY/JACK SECTION)

FRONT C.B

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.33

3.32

3.33

3.33

3.33

0.018

3.35

3.35

3.35

3.35

3.35

3.35

3.35

3.35

0.01

0.01
5

5
5

DISPRAY

LCD,CKC-4

5

3.36

3.36

3.36

3.36

3.36

3.36

3.36

LC75817W-8720

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.36

3.35

3.35

3.35

3.35

3.35

3.35

3.35

3.36

3.36

3.35

3.35

3.35

3.35

3.35

3.36

(RED) (RED)

REMOTE SENSOR

(RED)(RED)

(WHITE)

2SC2412KR

(RED) (RED) (RED)

(RED)(RED)

(RED)

(RED)

(RED) (RED) (RED)

(BLUE)

SEC1E01C-1

2SC2412KR

(BLUE)

SEC1E01C-1

2SC2412KR

(BLUE)

SEC1E01C-1

(BLUE)

SEC1E01C-1

JACK C.B

FFC601

4
3
2
1

(BLUE)

SEC1E01C-1

TU-DOWN/ TU-UP/

AUX IN

0.01

0.01

0.01

0.01

0.01

0.01

5

0.01

8.39

6.62

3.36

1.71

0.01

0.01

5

5

5

0.01

2.55

2.54

5

10UH

10UH

2/DISC UP

TO MAIN C.B CON701

AUDIO CONTROL

1/

DISC DOWN

4/REP 5/REP1 6/RNDM

3/INT

TO MAIN C.B CON702

PS/A.ME AF TA

-

-

-

5

KEY C.B

-21-

WIRING - 2/3 (FRONT C.B/KEY C.B/JACK C.B)

JACK C.B
(Top View)

J601

AUX IN

C682

SW604

SRC

SW620
RESET

SW603

EJECT

KEY C.B
(Top View)

C618

L602

L601

FRONT C.B (Top View)

SW604

LED604

SW620

SW603

LED603

IC602 SW621LCD601

FRONT C.B (Bottom View)

SW617 SW616 SW618 SW615 SW614 SW613 SW612 SW611 SW610 SW607 SW608 SW606 SW609

SW617

LED615

PS

/A.ME

SW616

2223242526272829303132

2223242526272829303132

LED614

TAAF

SW618

6

/RNDM

SW615

LED616

LED619

4

5

/REP

/REP1

LED617

SW614 SW613 SW612 SW611

LED620

3

/INT

161718192021

161718192021

/DISC

2

LED618

LED621

/DISC

SW610

1

LED611 LED612 LED613

SW608 SW606

SW607

SW602

TUNE

/

LED602

SW602

LED601

SW601

SW601

TUNE

/

SELBANDDISP

LED607

AUDIO CONTROLDISPLAYREMOTE SENSOR

LED609

LED606

LED608

PWR

/MUTE

SW609

J

I

H

G

F

E

D

C

B

A

123456789101112131415

123456789101112131415

A

JACK C.B
(Bottom View)

BLK
BRN
RED

ORG

41

3

1

C611

IC602

R613

BLK

BRN

RED

14

ORG

63

R615
R612

C613

R611

50

51

C610

D601

KEY C.B (Bottom View)

25

26

IC601

75

76

CON603

216

115

C606

C616

1
100

R654

R609

R608

R607

C605

C607

BE

R605

R606

C

LCD601

C608

C609

R655

C604

R657

R610

R601

D602

D603

C

BE
Q614Q615

R603

C

BE

Q616

CON601

R653

R626

R656

C603

R651

C602

R614

124

R602

R604

TO MAIN C.B CON701

R652

R625

R624

Q612

R621

1

C

BE
Q611

C

BE

R619

C612

R618

BE
Q610

B

R622

R620

R617

C615

C614

R623

SW621

C617

2

1

3

C

D

R616

C620

LED605

C

C619

E

F

G

H

I

J

-22-

SCHEMATIC DIAGRAM - 3/3 (CD SECTION)

CD C.B

SW C.B

SW4

VCC

16.9344MHz

0.01

TO MAIN C.B CON771 VIA FFC201

220P

220P

TC94A09F-301

(Q)

-23-

WIRING - 3/3 (CD C.B/SW C.B)

2

A

A

876543211345678

9 10111213141516910111213141516

CD C.B

(Top View)

C201

Q201

B

B

C

C

D

D

E

E

F

F

G

G

H

H

M1

SW3

(RST SW)

YEL

GRN

SW4

M2

CD C.B

(Bottom View)

I

I

SW C.B

J

J

B
C
E

K

K

L

L

GRY

WHT

ORG

BLU

R205

R206

14 1

87

SW1

SW2

C278

C276

C270

C235

C233

C234

C226

C269

C298

L221

C265

C203

X241

C250

L241

L242

C241

C251

C242

C283

C284

R203

R207

R243

C279

IC241

C262

R254

IC201

R202
R201

C263

R212

R244

51

301

Q221

C268

31

C202

C264

R245

50

R249

R250

E

C

B

R239

R246

C253

C221

R240

R247

R253

C271

C273 C272

R256

C237

R226

C274

R211

R237

R236

R233

15

R238

C261

R255

R234

16

R208

B
E

R282

R281

C

R209

C248

C252

BLK
RED

C247

100

C259

81

C260

80

R214

C246

C258

15 2821 22

R204

R213

R210

C245

C254

M

M

N

N

YEL

O

O

P

P

Q

Q

R

R

S

S

T

T

U

U

GRN

R215

Q202

C282

R241

C281

R251

R228

R227

R299

20

1

R229

R232

IC221

CON201

R230

C228

C230

R298

115

R231

C229

C222

R235

1

C299

C232

R222

30

R225

C225

R203

C224

R221

R224

R223

C223

FFC201

C227

BLU
BRN
BLK

TO MAIN C.B CON771

-24-

VOLTAGE CHART -1/9

IC201 LA6557H

PIN NO. PIN NAME CD TUNER AUX CD-CHANGER

1 VCC2 8.13 0.62 0.64 0.65
2 VO5- 0.26 0 0 0
3 VO5+ 0.26 0 0 0
4 VO4+ 3.72 0 0 0
5 VO4- 3.72 0 0 0
6 VO3+ 3.67 0 0 0
7 VO3- 3.84 0 0 0
8 VO2+ 4.05 0 0 0

9 VO2- 3.45 0 0 0
10 VO1+ 3.64 0 0 0
11 VO1- 4.13 0 0 0
12 VCC1 8.19 0.62 0.63 0.64
13 VIN1 2.12 0 0 0

14 VIN1G 2.12 0 0 0
15 VIN2 2.17 0 0 0
16 VIN2G 2.12 0 0 0
17 VIN3 2.12 0.71 0.8 1
18 VIN3G 2.12 0.71 0.8 1
19 REG-IN 7.73 0.62 0.63 0.64
20 REG-OUT 2.13 1 1 1

21 VREF-IN 2.12 0 0 0
22 VCC-S 8.33 0.6 0.6 0.6
23 VIN4G 2.12 0 0 0
24 VIN4 2.12 0 0 0
25 MUTE 5.06 0 0 0
26 S-GND 0.03 0 0 0
27 FWD 0.03 0 0 0
28 REV 0.05 0 0 0
29 GND 0.03 0 0 0
30

GND 0.05 0 0 0

IC221 TA2153FN

PIN NO. PIN NAME CD TUNER AUX CD-CHANGER

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30

1

2

3

4

5

6

7

8

9

VCC 5.11
RFGC 0.99
GMAD 2.13

FNI 2.24
FPI 2.24
TPI 2.16

TNI 2.16
MDI 0.2

LDD 4.04
SEL 2.57

TEB 1.96
2VRO 4.23
TEN
TEO
SBAD
FEO
FEN
SEB
VRO
RFRP
BTC
RFCT
PKC 2.63
RFRPIN 2.12
RFGO 2.11
GVSW 2.12
AGCIN 2.12
RFO
GND 0.03
RFN2

2.13

2.15

2.53

2.14

2.12

0.03

2.13

3.34

3.94

3.28

1.65

2.12

1.07
0
0

0
0
0

0
0

0.5
0

0
0

0.2

0.2
0

0.5

0.4
0

0

0.6
0
0
0

0
0

0.5
0

0
0
0

1.06
0
0

0
0
0

0
0

0.5
0

0
0

0.2

0.2
0

0.5

0.4
0

0

0.6
0
0
0

0
0

0.5
0

0
0
0

1.07
0
0

0
0
0

0
0

0.5
0

0
0

0.17

0.22
0

0.5

0.4
0

0

0.6
0
0
0

0
0

0.5
0

0
0
0

-25-

VOLTAGE CHART -2/9

IC241 TC94A09F

PIN NO. PIN NAME CD TUNER AUX CD-CHANGER

1 S1 (OT5) 0 0 0 0
2 S2 (OT6) 0 0 0 0
3 S3 (OT7) 0 0 0 0
4 S4 (OT8) 0 0 0 0
5 S5 (OT9) 0 0 0 0
6 S6 (OT10) 0 0 0 0
7 S7 (OT11) 0 0 0 0
8 S8 (OT12) 0 0 0 0
9 S9 (OT13) 0 0 0 0

10

S10(OT14/ZDET)
S11(OT15/CLCK)

11
12

S12(OT16/DATA)

13

S13(OT17/SFSY)

14

S14(DT18/LRCK)
P8-0(S15/BCK)

15

P8-1(S16/AOUT)

16
17

P8-2(S17/MBOV)

18

P8-3(S18/IPF)

19 MVDD1 5.06 0 0 0
20 MVSS1 0 0 0 0

21 P1-0 (K0) 5.11 0.97 0.97 0.97
22 P1-1 (K1) 4.92 0.91 0.91 0.91
23 P1-2 (K2) 4.92 0.91 0.91 0.91
24 SW3 5.13 1 1 1

25 SRQ 5.06 0 0 0
26 LM SW 0 0 0 0
27 P3-2 (ADIN2) 0.24 0 0 0
28 P3-3 (ADIN3) 5.05 0 0 0

P4-0(BUZR/AD4)

29
30 DATA-IN DATA 0 0 0
31 DATA-OUT DATA 0 0 0
32 CLOCK 5.15 1.7 1.7 1.78

33 P2-0/EMPH 5.05 0.2 0.5 0.53
34 P2-1/HSO 0 0 0 0
35 P2-2/LRCK 0 0 0 0
36 P2-3/DATA 0 0 0 0
37 IN1/BCK 0 0 0 0
38 TESTC 0 0 0 0
39 OT19 (/HSO) 0 0 0 0
40 OT20 (SPCK) 0 0 0 0
41 OT21 (SPDA) 0 0 0 0
42 OT22 (COFS) 0 0 0 0
43 DOUT 2.52 0 0 0
44 SBSY 0 0 0 0
45 SBOK 5.06 0 0 0
46 VDD1 5.07 1 1 1
47 VSS1 0 0 0 0
48 P2VREF 4.23 0 0 0
49 PDO 2.13 0 0 0
50 TMAX 2.04 0 0 0
51 LPFN 0 0 0 0
52 LPFO 2.06 0 0 0
53 PVREF 2.13 0 0 0
54 VCOF 1.49 0 0 0
55 AVSS 0 0 0 0
56 SLCO 0 0 0 0
57 RFI 2.13 0 0 0
58 AVDD 5.06 1 1 1
59 RFCT 3.25 0 0 0
60 RFZI 3.33 0 0.6 0.6
61 RFRP 3.33 0 0.6 0.6
62 FEI 2.14 0 0 0
63 SBAD 2.5 0 0 0

0000
0000
0000
0000
0000

0.28 0 0 0
0000
0000

0.27 0 0 0

0000

-26-

VOLTAGE CHART -3/9

IC241 TC94A09F

PIN NO. PIN NAME CD TUNER AUX CD-CHANGER

64 TEI 2.14 0 0 0
65 TEZI 2.12 0 0 0
66 FOO 2.12 1 1 1
67 TRO 2.15 0 0 0
68 VREF 2.13 0 0 0
69 RFGC 0.99 0 0 0
70 TEBC 1.93 0 0 0
71 FMO 2.08 0 0 0
72 DMO 2.16 0 0 0
73 2VREF 4.23 0 0 0
74 SEL 2.56 0 0 0
75 VDD2 5.07 1 1 1
76 VSS2 0 0 0 0
77 XVSS 0 0 0 0
78 XI 2.34 0 0 0

79 XO 2.65 1 1 1
80 XVDD 5.09 1 1 1
81 DVSR 0 0 0 0
82 RO 2.57 0 0 0
83 DVRR 2.44 0 0 0
84 DVDD 4.87 1 1 1
85 DVRL 2.44 0 0 0
86 LO 2.57 0 0 1
87 DVSL 0 0 0 0
88 TESTM 0 0 0 0
89 IN2/(VPP) 0 0 0 0
90 RESET 5.15 0 0 0
91 /HOLD 5.07 1 1 1
92 CS 5.15 0 0 0
93 MXO 5.07 0 0 0
94 MXI 0 0 0 0
95 MVSS2 0 0 0 0
96 MVDD2 5.07 1 1 1
97 COM1 (OT1) 0 0 0 0
98 COM2 (OT2) 0 0 0 0
99 COM3 (OT3) 0 0 0 0

100 COM4 (OT4) 0 0 0 0

-27-

VOLTAGE CHART -4/9

IC401 LA2657M

PIN NO. PIN NAME CD TUNER AUX CD-CHANGER

1 AUX(L) 4.11 4.13 4.12 4.1
2 CDC(L) 4.12 4.13 4.12 4.1

3 TUN(L) 4.12 4.13 4.12 4.1
4 SD(L) 4.12 4.13 4.12 4.1
5 VREF 4.14 4.15 4.13 4.12
6 CD(R) 4.13 4.13 4.12 4.1

7 TUNE(R) 4.13 4.13 4.12 4.1
8 CH(R) 4.13 4.13 4.12 4.1

9 AUX(R) 4.13 4.13 4.12 4.1

10 NC 0 0 0 0
11 RSELO 4.15 4.15 4.14 4.13

12 RIN 4.13 4.12 4.12 4.11
13 RTRE 4.13 4.12 4.12 4.11

14 RBASS1 4.13 4.13 4.12 4.11
15 NC 1.52 1.45 1.41 1.48

16 RBASS2 4.15 4.14 4.14 4.13
17 NC 0 0 0 0
18 RSB 4.15 4.14 4.13 4.12

19 ROUT 4.15 4.14 4.14 4.13
20 R FAD IN 4.13 4.12 4.12 4.11

21 VCC (BBE) 8.89 8.86 8.86 8.82
22 VREF 4.49 4.48 4.48 4.46

23 CONT 0 0 0 0
24 GND 0 0 0 0

25 BBE IN (R) 4.49 4.48 4.48 4.46
26 NC 1.51 1.45 1.41 1.48

27 CBPR 4.5 4.49 4.49 4.47
28 RC3 4.5 4.49 4.49 4.47

29 HPOR 4.5 4.49 4.49 4.47
30 CLPR 4.5 4.49 4.49 4.47
31 LPOR 4.5 4.48 4.49 4.47

32 NC 1.51 1.45 1.42 1.42
33 NC 1.51 1.45 1.41 1.42
34 MIXR 4.5 4.48 4.48 4.47

35 BBE OUT (R) 4.5 4.48 4.49 4.47
36 BBE OUT (L) 4.5 4.48 4.48 4.47

37 MIXL 4.5 4.48 4.48 4.47
38 LPOL 4.5 4.48 4.48 4.47

39 NC 0 1.42 1.39 1.39
40 CLPL 4.5 4.48 4.48 4.47

41 HPOL 4.5 4.49 4.48 4.47
42 LC3 4.51 4.49 4.48 4.47
43 CBPL 4.51 4.49 4.48 4.47

44 BBE IN (L) 4.48 4.48 4.48 4.46
45 FROUT 4.16 4.14 4.14 4.13

46 RROUT 4.16 4.14 4.14 4.13
47 VDD 8.32 8.29 8.28 8.26

48 NC 0 0 0 0
49 CL 0 0 0 0
50 DI 0 0 0 0

51 CE 0 0 0 0
52 VSS 0 0 0 0

53 RLOUT 4.16 4.15 4.14 4.13
54 FLOUT 4.16 4.15 4.14 4.13

55 NC 1.47 1.43 1.4 1.39
56 L FAD IN 4.14 4.12 4.12 4.11

57 LOUT 4.16 4.15 4.14 4.13
58 LSB 4.15 4.14 4.13 4.12
59 LBASS2 4.16 4.14 4.14 4.13
60 LBASS1 4.14 4.13 4.12 4.11
61 LTRE 4.14 4.12 4.12 4.11
62 LIN 4.14 4.12 4.12 4.11

63 LSELO 4.16 4.14 4.14 4.13
64 NC 0 0 0 0

-28-

VOLTAGE CHART -5/9

IC402 BU4066BC

PIN NO. PIN NAME CD TUNER AUX CD-CHANGER

1 I/O 1 4.48 4.4 4.44 4.47
2 O/I 1 4.48 4.41 4.44 4.47
3 O/I 2 4.48 4.41 4.45 4.47
4 I/O 2 4.48 4.41 4.45 4.47
5 C2 8.63/0 8.64/0 8.7/0 8.74/0

6 C3 8.63/0 8.64/0 8.7/0 8.74/0
7 VSS 0 0 0 0
8 I/O 3 4.43 4.42 4.45 4.47

9 O/I 3 4.43 4.42 4.45 4.47
10 O/I 4 4.44 4.42 4.45 4.47
11 I/O 4 4.44 4.42 4.45 4.47
12 C4 8.69/0 8.66/0 8.71/0 8.74/0
13 C1 8.69/0 8.66/0 8.71/0 8.74/0
14 VDD 8.78 8.74 8.79 8.83

IC501 LA4743J

PIN NO. PIN NAME CD TUNER AUX CD-CHANGER

1 TAB 0 0 0 0

2 GND 0 0 0 0

3 FL- 2.73 2.73 2.73 2.72

4 ST/BY 4.52 4.55 4.55 4.55

5 FL+ 2.72 2.71 2.71 2.71

6 VDD 14.28 14.32 14.32 14.17

7 RL- 2.72 2.72 2.72 2.71

8 GND 0 0 0 0

9 RL+ 2.72 2.71 2.71 2.71
10
11 RL 3.08 3.06 3.05 3.04
12 FL 3.1 3.08 3.07 3.06
13 PREGND 0 0 0 0

14 RR 3.06 3.08 3.07 3.06
15 FR 3.07 3.06 3.05 3.04
16 ON TIME 2.49 2.5 2.51 2.51
17 FR+ 2.75 2.75 2.75 2.74
18 GND 0 0 0 0
19 FR- 2.71 2.71 2.71 2.71
20 VDD 14.28 14.32 14.32 14.17

21 RR+ 2.74 2.74 2.74 2.73
22 MUTE 4.05 4.05 4.06 4.06
23 RR- 2.75 2.74 2.74 2.74
24 GND 0 0 0 0
25 NC 0 0 0 0

RIPPLE FILTER 13.05 13.09 13.09 12.95

IC721 BA6417

PIN NO. PIN NAME CD TUNER AUX CD-CHANGER

1 OUT1 0 0 0 0

2 VM 8.25 0.64 0.65 0.62

3 VCC 8.26 0.63 0.65 0.62

4 FIN 0 0 0 0

5 RIN 0 0 0 0

6 VREF 3.66 0.27 0.27 0.28

7 OUT2 0 0 0 0

8 GND 0 0 0 0

-29-

VOLTAGE CHART -6/9

IC901 UPD178078GF-550-3BA

PIN NO. PIN NAME CD TUNER AUX CD-CHANGER

1 BATT IN 4.12 4.1 4.1 4.11
2 NC (DFP IN) 5.05 5.09 5.09 5.06

3 LCD DI 5.07 5.1 5.1 5.07
4 LCD DO DATA DATA DATA DATA
5 LCD CLO DATA DATA DATA DATA
6 LCD CE DATA DATA DATA DATA
7 BBE SW1 0 0 0 0
8 CDS DI DATA 0 0 0

9 CDS DO 0.04 0.01 0.01 0.01
10 CDS CLO 5.01 4.9 4.9 4.9
11 <SI> CD DI 0 0 0 DATA

12 <SO> CD DO 0 0 0 5.12
13 <SCL> CD CLI 0 0 0 5.11
14 CD DISP SEL 5.14 5.13 5.13 DATA
15 CD CONNECT 0 0 0 4.76
16 BBE SW2 0 0 0 0
17 CD CLO 0 0 0 0
18 E-VOL CL 0 0 0 0
19 E-VOL DO 0 0 0 0
20 E-VOL CE 0 0 0 0
21 LOC/DX 0 0 0 0
22 DSSA CONT 0 0 0 0
23 (NC) 0 0 0 0
24 NC (PH MUTE) 3.46 3.45 3.45 3.45

25 LEV.IND. 0 0 0 0

NC (A-VOL CONT)

26
27 AVDD 5.14 5.14 5.11 5.13
28 TEST 5.09 5.08 5.08 5.07
29 NC (DIMMER) 0 0 0 0
30 (NC) 0 0 0 0
31 FM/AM S-M DATA DATA DATA DATA
32 AVSS 0 0 0 0
33 REG CPU 3.44 3.44 3.44 3.44
34 VDD 5.13 5.13 5.13 5.12
35 REG OSC 5.03 5.03 5.03 5.02
36 X-OUT 1.92 1.92 1.9 1.92
37 X-IN 2.21 2.21 2.21 2.2
38 GND0 0 0 0 0
39 IF REQ 0 0 0 0
40 GND2 0 0 0 0
41 AM IF 0 0 0 0
42 FM IF 0 0 0 0
43 VDD PLL 5.13 5.13 5.13 5.12
44 FM OSC 0 2.74/0 0 0
45 AM OSC 0 0/2.72 0 0
46 GND PLL 0 0 0 0
47 (NC) (EO0) 0 0.16 0 0
48 EO1 0 1.04 0 0
49 IC <VPP> 0 0 0 0

50 RESET 5.12 5.11 5.11 5.1
51 RDS CL IN 0 0 0 0

52 ACC IN 4.09 4.09 4.09 4.1
53 RMT IN 5.24 5.16 5.18 5.09

54 ST IN/SD IN 4.88 4.87 4.88 4.78
55 ST 0 0 0 0
56 ST-BY MUTE 5.09 5.08 5.08 5
57

58 RDS DI 0 0 0 0
59 BEEP 0 0 0 0
60 (NC) 0 0 0 0
61 (LED) (NC) 0.07 0.07 0.08 0.06
62 BAND CONT 8.91 8.91/0.79 8.91 8.82
63 CD ACC CONT 0.01 0.01 0.01 1.01

POWER CONT

00 00

5.07 5.06 5.07 5

-30-

VOLTAGE CHART -7/9

IC901 UPD178078GF-550-3BA

PIN NO. PIN NAME CD TUNER AUX CD-CHANGER

64 RDS MODE 0 0 0 0
65 POWER MUTE 4.05 4.06 4.06 4.03

66 (NC) (CONT2) 0 0 0 0
67 (NC) (CONT1) 0 0 0 0
68 MUTE 0.69 0.69 0.14 0.7

69 (NC) (RXDO) 0 0 0 0
70 (NC) (TXDO) 0 0 0 0
71 MI-1 0 0 0 0

72 MI-2 0 0 0 0
73 MI-3 0 0 0 0
74 MO-1 0 0 0 0
75 MO-2 0 0 0 0

76 MO-3 0 0 0 0
77 MO-4 0 0 0 0
78 JACK IN 0/4.89 0/4.89 0/4.89 0/4.89
79 CDS SREQ DATA 0 0 0
80 RE1 IN 0 0 0 0
81 RE2 IN 5.24 5.19 5.23 5.19
82 GND1 0 0 0 0
83 HOLD 0 0 0 0
84 PANCON1 0 0 0 0
85 PANCON2 0 0 0 0
86 SW1 5.12 4.79 4.79 4.77
87 SW2 5.13 4.8 4.79 4.78
88 SW3 0 0 0 0
89 (FLAP IN) (NC) 0 0 0 0
90 MF.CONT 0 0 0 0
91 SEN1 0.13 5.11 5.11 5.09
92 SEN2 0 0 0 0

93 LMT SW 0 0 0 0
94 CDS RESET 5.15 0 0 0

95 CDS SLEEP 5.09 0 0 0
96 CDS CS 5.15 0 0 0
97 (CDS STOP) 0 0 0 0
98 RADIO CONT 0 5.13 0 0

99 VDD PORT 5.15 5.13 5.13 5.12

100 GND PORT 0 0 0 0

-31-

VOLTAGE CHART -8/9

TRANSISTOR

Q101

DTC114TUA

Q102

2SA1576A(R)

Q103

2SC4081(R)

Q105

2SC4081(R)

Q106

2SC4081(R)

Q405

DTC114TUA

Q406

DTC114TUA

Q407

DTC114TUA

Q408

DTC114TUA

Q409

DTC114TUA

Q410

DTC114TUA

Q411

DTC114TUA

Q421

2SC4081(R)

Q422

DTA114YUA

Q423

2SC4081(R)

Q521

DTB123YK

Q731

DTA114YUA

Q751

DTA114YUA

Q752

DTC114YUA

Q811

2SB1375

Q812

DTC114TUA

B 0 0 0.02 0 0
C 7.55 7.54 0.28 7.49 7.54

E0 0 0 0 0

B 8.9 8.89 8.37 8.84 8.88
C 0.35 0.21 9.01 0.15 0.24

E 9.12 9.08 9.08 9.07 9.08
B 8.94 8.9 0.78 8.89 8.89
C 9.13 9.08 9.09 9.07 9.08

E 8.24 8.2 0.2 8.19 8.2
B 0 1.02 1.03 0 0
C 9.11 3.41 2.82 9.06 9.07

E 0.01 0.59 0.59 0 0
B 0.07 0.59 0.59 0 0
C 9.12 3.41 2.82 9.07 9.07

E0 0 0 0 0
B0 0 0 0 0
C0 0 0 0 0

E0 0 0 0 0
B0 0 0 0 0
C0 0 0 0 0

E0 0 0 0 0
B 0 0 0 4.24/0 0

C0 0 0 0 0

E0 0 0 0 0
B 0 0 0 4.24/0 0
C0 0 0 0 0

E0 0 0 0 0
B 0 0 0 4.24/0 0
C0 0 0 0 0

E0 0 0 0 0
B 0 0 0 4.24/0 0
C0 0 0 0 0

E0 0 0 0 0
B0 0 0 0 0

C 8.8 8.75 8.76 8.76 8.75

E0 0 0 0 0
B 1.56 1.55 1.54 1.56 1.56

C 4.68 4.69 4.74 4.66 4.65

E 0.97 0.96 0.95 0.96 0.97
B0 0 0 0 0

C 0 0 0 4.24/0 0

E 0.02 0.02 0.02 4.27/0.02 0.02
B 0.69 0.69 0.69 0.14/0.69 0.69

C 0.02 0.02 0.02 4.86/0.02 0.02

E0 0 0 0 0
B 4.05 4.05 4.05 4.05 4.06

C0 0 0 0 0

E 4.06 4.06 4.06 4.06 4.06
B 0.07 0.07 0.08 0.07 0.07

C 5.02 5 5 5.01 5.01

E 5.15 5.12 5.12 5.13 5.13
B 14.19 14.29 14.33 14.25 0.05

C 0 0 0 0 14.14

E 14.24 14.36 14.4 14.32 14.17
B 0.01 0.01 0.02 0.01 1

C 14.19 14.29 14.33 14.25 0.05

E0 0 0 0 0
B 13.56 13.66 13.7 13.62 13.48

C 14.21 14.33 14.37 14.28 14.13

E 14.24 14.36 14.4 14.31 14.16
B 5.07 5.04 5.04 5.05 5.05

C 0.08 0.08 0.08 0.08 0.08

E0 0 0 0 0

CD AMFM AUX CD-CHANGER

-32-

VOLTAGE CHART -9/9

TRANSISTOR

Q813

2SD2012

Q821

2SD1858

Q831

2SD2012

Q832

2SC4081(R)

Q833

2SA1576A(R)

Q834

DTC114TUA

Q901

DTC114TUA

B 9.8 9.77 9.78 9.78 9.77
C 14.25 14.35 14.4 14.31 14.16

E 9.15 9.1 9.11 9.11 9.11
B 6.37 6.36 6.36 6.36 6.36

C 12.59 12.57 12.64 12.52 12.44
E 5.8 5.79 5.78 5.79 5.79

B 9.05 0.62 0.65 0.75 0.78
C 14.24 14.35 14.4 14.31 14.17
E 8.41 0.62 0.61 0.62 0.62

B 9.59 0 0 0 0
C 14.24 14.35 14.4 14.31 14.17
E 9.03 0 0 0 0
B 8.97 14.32 14.36 14.28 14.13
C 9.58 0 0 0 0
E 9.62 14.35 14.4 14.31 14.17

B 3.68 0 0 0 0
C 0.01 14.3 14.35 14.26 14.12
E0 0 0 0 0

B0 0 0 0 0
C 4.89 4.86 4.78 4.87 4.86
E0 0 0 0 0

CD AMFM AUX CD-CHANGER

TU101 FAE347-A30

Antenna input opening Antenna standard input

PIN NO. PIN NAME FM

1 AM ANT 0 0 0 0
2 FM ANT 0 0 0 0

3 AM DX/LOC 0 0 0 0
4 FM DX/LOC 7.4 0.18 7.5 0.19
5 GND 0 0 0 0

6 FM VT 3.37 2.81 3.4 2.81
7 GND 0 0 0 0
8 GND 0 0 0 0
9 AM+B 0 8.52 0.05 8.54

10 GND 0 0 0 0
11 AM/FM OSC 0 0 0 0

12 FM+B 7.85 0.18 7.91 0
13 TU+B 8.16 8.12 8.23 8.14
14 AM VT 3.37 2.81 3.39 2.81
15 GND 0 0 0 0
16 L ch 3.39 3.43 3.39 3.43
17 R ch 3.4 3.44 3.39 3.43
18 GND 0 0 0 0
19 NC 0 0 0 0
20 IF REQ/OUT 0 0 0 0
21 S-METER 0.45 0.01 5.6 5.1
22 SD/ST 4.84 4.78 4.87 4.79
23 SNC 0.06 0.04 0.91 0.81
24 DET OUT 3.99 1.21 4.03 1.2
25 TU+B 8.21 8.12 8.23 8.14
26 MUTE 2.32 0.03 0.85 0.03

AM FM AM

Antenna standard
input

FM:1mV(60dBuV) 75kHz(100%) 1kHz
AM:5mV(75dBuV) 30% 400kHz

Abnormal
conditions

Abnormai connditions
frequency

Received
frequency

98MHz
1000kHz

-33-

IC BLOCK DIAGRAM -1/3

IC, BU4066BCF IC, LA4743J

FR

RR

ON TIME

VDD VDD

21

23

FR+

FR-

RR+

MUTE

RR-

IC, BA6417F

RL

FL

PRE GND

R.F GND

NC

RL+

RL-

FL+

STBY

FL-

GND

-34-

IC BLOCK DIAGRAM -2/3

IC, SAA6579T

MUX

SCOUT

SIN

VDD

VREF

IC, LA6557H

VCC2

VO5—

VO5+

VO4+

VO4—

VSS

1

2

3

4

5

CH3,4,5
POWER

CH5

CH4

Thermal shutdown

MUTE is as follows :

High : Output ON
Low : Output OFF

22k 11k

XOUTXIN

Input

MUTE

DGNDTESTMODEAGND

28

27

26

25

24

DVDD

QUAL

DATA

CL

T57

VSS

REV

FWD

S-GND

MUTE

VIN4

VO3+

VO3—

GND

VO2+

VO2—

VO1+

VO1—

VCC1

VIN1

VINIG

6

CH3

7

29

8

CH2

9

10

CH1

11

CH1,2

12

13

14

POWER

11k

Level Shift Level Shift Level Shift Output ControlLevel Shift

22k

Signal System Power

5VREG
(External PNPTr)

22k

22k

11k

11k

23

VING4

22

VCC-S

30

GND

VREF-IN

21

20

REG-OUT

19

REG-IN

18

VIN3G

VIN3

17

16

VIN2G

VIN2

15

-35-

IC BLOCK DIAGRAM -3/3

IC, LA2657H

AUX(L)

1

CH(L)

2

CD(L)

VREF

CD(R)

CH(R)

AUX(R)

NC

RSELO

RIN

RTRE

NC

3

4

5

6

7

8

9

10

11

12

13

14

15

16

TUNE(L)

TUNE(R)

RBASS1

RBASS2

LSELO

NC

64

63 62 61 60 59 58 57 56 55 54 53 52 51 50 49

F.

SW

LIN LTRE

E
V
R

LBASS1

TONE

S-BASS

LBASS2

LSB

LOUT

L FAD INNCFLOUT

FADER

RLOUT

VSS

CE DI CL

CCB

INTERFACE

FADER

Vref

F.

SW

BBE

EVR

BBE

Vref

SW

BBE

TONE

S-BASS

17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32

NC

R5B

ROUT

VCC(BBE)

R FAD IN

VREF

COUT

GND

BBE IN(R)NCCBPR

RC3

HPOR

CLPR

LPOR NC

NC

48

47

VDD

46

RROUT

45

FROUT

44

BBE IN(L)

43

CBPL

42

LC3

HPOL

41

40

CLPL

39

NC

38

LPOL

37

MIXL

36

BBE OUT(L)

35

BBE OUT(R)

34

MIXR

33

NC

IC, TA2153FN

FEO

FEN

SEB

VRO

RFRP

BTC

RFCT

PKC

RFRP

RFGO

GVSW

AGCIN

RFO

36pF

10k‰

10k‰

48k‰

238k‰

15pF

60k‰

2.9k‰

20k‰

50k‰10k‰

3pF

30k‰

20k‰

3pF

30k‰

3 STATE

DET.

83k‰

SW1

1k‰

SW2

1.4k‰

SW3

13k‰

2.26k‰

150k‰

1k‰

1k‰

40pF

150k‰

10pF

15

SBAD

14

TEO

13

TEN

12

2VRO

11

TEB

10

SEL

9

LDD

MDI

8

1-1

7

TNI

1-1

6

TPI

5

FPI

FNI

4

3

GMAD

90k‰
60k‰

15k‰

15k‰

21.82k‰

238k‰

15pF

16

10pF

17

18

19

20

21

22

23

24

IN

25

26

27

28

20k‰

11k‰

11k‰

60k‰

20k‰

100k‰

100k‰

100k‰

AGC Amp

20k‰

20k‰

20k‰

BOTTOM

PEAK

12k‰
12k‰

GND

RFN2

29

30

2

RFGC

VCC

1

-36-

IC DESCRIPTION -1/3 (µPD178078GF-567-3BA)-1/3

Pin No.

1 BATT IN I BATT ON/OFF input
2 DFP IN I Detects whether DFP (front panel) is provided or not.
3 LCD DI I/O LCD DRV data input
4 LCD DO O Open when not used. LCD DRV data output.
5 LCD CLO O LCD DRV clock output.
6 LCD CE O LCD DRV CE output.
7 BBE 1 O BBE select output. Open when not used.
8 CDS DI I CDS DATA input.

9 CDS DO O CDS DATA output.
10 CDS CLO O CDS CLOCK output.
11 CD DI I Data input from CD changer. Pulled down when not used.
12 CD DO O Data output to CD changer. Open when not used.
13 CD CLI I Clock input from CD changer. Open when not used.

14 CD DISP SEL O

15 CD CONNECT I CD changer connection check. Pulled down when not used.

Pin Name I/O

Description

Determines the timing with which data is transferred to the head unit. Open when not
used.

16 BBE 2 O BBE select output. Open when not used.
17 CD CLO O Clock output to CD changer. Open when not used.
18 E-VOL CLO O Clock output to electronic VR
19 E-VOL DO O Data putput to electronic VR
20 E-VOL CE O CE output to electronic VR
21 LOC/DX O LOC/DX switching output during radio seek (LOC: “H”, DX: “L”). Open when not used.
22 DSSA O Outputs “H” only when DSSA L/R are operating.
23 NC - NC Pulled down.
24 PHONE MUTE I Muting control input -20dB. Mute: “L”.
25 LEVEL-M I Level meter signal input
26 A-VOL CONT I Detects microphone input for auto volume operation. Pulled down when not used.
27 VDD - Power supply
28 TEST I Pulled up when TEST MODE.
29 NC - NC Pulled down.
30 NC - NC Pulled down.
31 AM/FM S-M I AF signal input during RDS AF operation and FM S meter signal input
32 GND - Ground
33 REG CPU - CPU power regulator
34 VDD - Power supply for port
35 REG OSC - Regulator for oscillator circuit
36 X-OUT - System clock oscillator
37 X-IN I System clock oscillator
38 GND - Ground for port

-37-

IC DESCRIPTION -1/3 (µPD178078GF-567-3BA)-2/3

Pin No.

39 IF REQ O Output to request IF count signal.

40 GND - Ground

41 AM IF I AM IF count signal input

42 FM IF I FM IF count signal input

43 VDD - Power supply for PLL

44 FM OSC I FM local oscillation input

45 AM OSC I AM local oscillation input

46 GND - Ground for PLL

47 EO 0 - NC

48 EO 1 O Error output from charge pump

49 IC - NC Pulled down.

50 RESET I System reset input

51 RDS CLI I RDS clock input Pulled down when not used.

52 ACC IN I ACC(accessory power supply) on/off input

53 RMT IN I Remote control input. Pulled up when not used

54 ST IN/SD IN I Stop pulse input during FM/AM seek.

Pin Name I/O Description

55 NC - NC Pulled down.

56 ST-BY MUTE O Standby/muting output to power amp

57 POWER CONT O Unit power control output

58 RDS DI I RDS data input. Pulled down when not used.

59 BEEP O Beep output (3kHz, 50ms)

60 NC - NC Pulled down.

61 NC - NC
62 BAND CONT O AM/FM power switching output AM: “H”, FM: “L”

63 CD ACC CONT O Transmits the power on/off status of head unit to changer. Open when not used.
64 RDS MODE O Outputs “H” during RDS AF operation. Open when not used.

65 POWER MUTE O Muting output to power amp

66 NC(CONT 2 O LCD DRV power control 2 Open when not used.

67 NC(CONT 1) O LCD DRV power control 1 Open when not used.

68 MUTE O Audio muting output

69 NC - NC Pulled down.

70 NC - NC Pulled down.

71 MI-1

72 MI-2 I Diode matrix input for initial setting

73 MI-3

74 MO-1

75 MO-2

76 MO-3

77 MO-4

O Diode matrix output for initial setting

-38-

IC DESCRIPTION -1/3 (µPD178078GF-567-3BA)-3/3

Pin No.

78 AUX IN I AUX JACK SW detect input.

79 CDS SREQ I CDS SREQ output.

80 RE1 IN I Rotary encoder input 1

81 RE2 IN I Rotary encoder input 2

82 GND - Ground

83 LM SW O FEED MOTER GAIN SW output

84 PANCON1 O Panel open/close control output

85 PANCON2 O Panel open/close control output

86 SW1 I SW1 detect input

87 SW2 I SW2 detect input

88 NC - NC

89 FLAP IN - NC Pulled up

90 MF CONT O Panel Drive VDD control output

91 SEN1 I Panel detect input

92 SEN2 I Panel detect input

93 CDS IN I DISC IN detect input

Pin Name I/O Description

94 CDS RESET O CDS RESET output

95 CDS SLEEP O CDS SLEEP output

96 CDS CS O CDS CS output

97 CDS STOP - Pulled down
98 RADIO CONT O Radio ON/OFF. Power switching output. Radio on: “H”

99 VDD PORT - VDD

100 GND - GND

-39-

IC DESCRIPTION -2/3 (LC75817W-8720)-1/3

Pin No.

1 S1 O Segment driver output pin.

2 S2 O Segment driver output pin.

3 S3 O Segment driver output pin.

4 S4 O Segment driver output pin.

5 S5 O Segment driver output pin.

6 S6 O Segment driver output pin.

7 S7 O Segment driver output pin.

8 S8 O Segment driver output pin.

9 S9 O Segment driver output pin.

10 S10 Çn Segment driver output pin.

11 S11 O Segment driver output pin.

12 S12 O Segment driver output pin.

13 S13 O Segment driver output pin.

14 S14 O Segment driver output pin.

15 S15 O Segment driver output pin.

16 S16 O Segment driver output pin.

Pin Name I/O

Description

17 S17 O Segment driver output pin.

18 S18 O Segment driver output pin.

19 S19 O Segment driver output pin.

20 S20 O Segment driver output pin.

21 S21 O Segment driver output pin.

22 S22 O Segment driver output pin.

23 S23 O Segment driver output pin.

24 S24 O Segment driver output pin.

25 S25 O Segment driver output pin.

26 S26 O Segment driver output pin.

27 S27 O Segment driver output pin.

28 S28 O Segment driver output pin.

29 S29 O Segment driver output pin.

30 S30 O Segment driver output pin.

31 S31 O Segment driver output pin.

32 S32 O Segment driver output pin.

33 S33 O Segment driver output pin.

34 S34 O Segment driver output pin.

35 S35 O Segment driver output pin.

36 S36 O Segment driver output pin.

37 S37 O Segment driver output pin.

38 S38 O Segment driver output pin.

39 S39 O Segment driver output pin.

-40-

IC DESCRIPTION -2/3 (LC75817W-8720)-2/3

Pin No.

40 S40 O Segment driver output pin.

41 S41 O Segment driver output pin.

42 S42 O Segment driver output pin.

43 S43 O Segment driver output pin.

44 S44 O Segment driver output pin.

45 S45 O Segment driver output pin.

46 S46 O Segment driver output pin.

47 S47 O Segment driver output pin.

48 S48 O Segment driver output pin.

49 S49 O Segment driver output pin.

50 S50 O Segment driver output pin.

51 S51 O Segment driver output pin.

52 S52 O Segment driver output pin.

53 S53 O Segment driver output pin.

54 S54 O Segment driver output pin.

55 S55 O Segment driver output pin.

Pin Name I/O

Description

56 S56 - NC

57 S57 - NC

58 S58 - NC

59 S59 - NC

60 S60/COM10 - NC

61 COM9 - NC

62 COM8

63 COM7

64 COM6

65 COM5

66 COM4

67 COM3

68 COM2

69 COM1

70 KS1 - NC

71 KS2 - NC

72 KS3

O Common driver output pin.

73 KS4

74 KS5

75 KS6

O Key scan output pin.

-41-

IC DESCRIPTION -2/3 (LC75817W-8720)-3/3

Pin No.

76 K11

77 K12

78 K13 I Key scan input pin.

79 K14

80 K15

81 P-1 O Change illmination(BLUE)

82 P-2 O Change illmination(RED)

83 P-3 O Dimmer control pin.

84 P-4 - NC

85 VDD I LOAD/EJECT GAIN Switching Output..

86 VLCD I LCD driver power supply pin.

87 VLCD0 O LCD driver bias 4/4 voltage (H-level) power pin.

88 VKCD1 I LCD driver bias 3/4 voltage (Intermediate level) power pin.

89 VKCD2 I LCD driver bias 2/4 voltage (Intermediate level) power pin.

90 VKCD3 I LCD driver bias 1/4 voltage (Intermediate level) power pin.

91 VKCD4 I LCD driver bias 0/4 voltage (Intermediate level) power pin.

Pin Name I/O

Description

92 VSS - Ground

93 TEST I connect to ground.

94 OSC-OUT O Oscillator pin.

95 OSC-IN I Oscillator pin.

96 INT O Display on.

97 DO O Output data.

98 CE I Chip enable.

99 CL I synchronization clock.

100 DI I Transfer data.

-42-

IC DESCRIPTION -3/3 (TC94A09F-301)-1/3

Pin No.

1 S1 - NC (Open)

2 S2 - NC (Open)

3 S3 - NC (Open)

4 S4 - NC (Open)

5 S5 - NC (Open)

6 S6 - NC (Open)

7 S7 - NC (Open)

8 S8 - NC (Open)

9 S9 - NC (Open)
10 S10 - NC (Open)
11 S11 - NC (Open)
12 S12 - NC (Open)
13 S13 - NC (Open)
14 S14 - NC (Open)
15 P8-0 - NC (Open)
16 P8-1 - NC (Open)

Pin Name I/O

Description

17 P8-2 - NC (Open)
18 P8-3 - NC (Open)
19 MVDD1 - Power supply for port
20 MVSS1 - GND
21 P1-0 I RST SW BZG-3 Mecha Inside SW input port.
22 P1-1 I SW1 detect input
23 P1-2 I SW2 detect input
24 SW3 I SW3 detect input
25 SRQ O output SRQ signal
26 LM SW O FEED MOTER GAIN SW output
27 P3-2 - NC(open)
28 P3-3 O M-DRIV MUTE output
29 P4-0 - NC(open)
30 DATA-IN I CDS DATA INPUT
31 DATA-OUT O CDS DATA OUTPUT
32 CLOCK I CDS CLOCK INPUT
33 P2-0 O CD-DA/RE GAIN SWITCHING OUTPUT
34 P2-1 - NC(open)
35 P2-2 - NC(open)
36 P2-3 - NC(open)
37 IN1 - GND
38 TESTC - NC(open)
39 OT19 - NC(open)

-43-

IC DESCRIPTION -3/3 (TC94A09F-301)-2/3

Pin No.

40 OT20 - NC(open)
41 OT21 - NC(open)
42 OT22 - NC(open)
43 DOUT - NC(open)
44 SBSY - NC(open)
45 SBOK - NC(open)
46 VDDÇP - VDD
47 Vss 1 - GND
48 P2VREF - FOR PLL 2 VREF
49 PDO O EFM to PLCK difference error signal output
50 TMAX O TMAX DETECT output
51 LPFN I FOR LOW PASS filter AMP reverse input
52 LPFO I FOR LOW PASS filter AMP OUTPUT
53 PVREF I FOR PLL VREF
54 VCOF O VCO FILTER OUTPUT
55 AVSS - ANALOG GND

Pin Name I/O

Description

56 SLCO O DATA SLICE LEVEL DAC Output
57 RFI I RF SIGNAL Input
58 AVDD - ANALOG VDD
59 RFCT I RFRP SIGNAL CENTER LEVEL INPUT
60 RFZI I RFRP ZEROCROSS INPUT
61 RFRP I RF RIPPLE SIGNAL INPUT
62 FEI I FOCUS ERROR SIGNAL INPUT
63 SBAD I SUB BEAM INCLUDE SIGNAL INPUT
64 TEI I TRACKING ERROR INPUT
65 TEZI I TRACKING ERROR ZERO CROSS INPUT
66 FOO O FOCUS EQUALIZER OUTPUT
67 TRO O TRACKING EQUALIZER OUTPUT
68 VREF - ANALOG Reference VDD
69 RFGC O RF APLITUDE CONTROL SIGNAL OUTPUT
70 TEBC O TRACKING BALANCE CONTROL SIGNAL OUTPUT
71 FMO O FOCUS EQUALIZER OUTPUT
72 DMO O DISC EQUALIZER OUTPUT
73 2VREF - ANALOG Reference VDD
74 SEL O APC CIRCUIT ON/OFF SIGNAL OUTPUT
75 VDD2 - VDD2
76 VSS2 - GND2
77 XVSS - For XTAL GND
78 XI I XTAL INPUT

-44-

IC DESCRIPTION -3/3 (TC94A09F-301)-3/3

Pin No.

79 XO O XTAL OUTPUT

80 XVDD - For XTAL VDD

81 DVSR - Rch D/A CONVERTER GND

82 RO O Rch DATA OUTUT

83 DVRR - Rch Reference VDD

84 DVDD - D/A CONVERTER VDD

85 DVRL - Lch Reference VDD

86 LO O Lch DATA OUTUT

87 DVSL - Lch D/A CONVERTER GND

88 TESTM - GND

89 VPP - GND

90 RESET I RESET SIGNAL INPUT

91 HOLD I Pulled UP

92 CS I COMMUNICATION CONTROL INPUT

93 MXO - NC(open)

94 MXI - PULL DOWN

Pin Name I/O

Description

95 MVSS2 - GND

96 MVDD2 - VDD

97 COM1 - NC(open)

98 COM2 - NC(open)

99 COM3 - NC(open)

100 COM4 - NC(open)

-45-

LCD DISPLAY - 1/1 (CKC-4)

SEGMENT

COMMON

-46-

ELECTRICAL ADJUSTMENT -1/1

1. RDS Voltage Adjustment
Settings:Test point:IC901 pin 31
Adjustment location:SFR101
Method:Set AM/FM Signal generation to 98MHz,31dBuV(EMF) and
adjust SFR101 so that the output becames 2.0V 0.1V.

MAIN C.B

L201

TU101

FRONT SIDE

IC901

31

SFR101

1

-47-

MECHANICAL EXPLODED VIEW -1/1

7

6

10

9

5

3

2

1

20

4

19

22

13

12

11

26

27

21

14

25

52

39

35

36

E

E

H

49

43

53

59

A

15

17

15

18

8

29

B

D

24

23

28

J

G

A

13

33

16

31

34

E

42

45

F

44

51

32

37

F

17

33

C

G

30

L

F

46

47

I

I

50

E

41

40
H

H

H

38

G

48

61

M

63

64

D

N

65

73

L

K

K

K

75

R

68

74

Q

K

69

D

62

66

J

O

P

J

67

J

L

60

70

54

55

56

57

J

72

71

M

S

K

58

G

-48-

MECHANICAL PARTS LIST -1/2

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
O MC1001 8C-KC6-011-010 CAP, RTRY VOL a
O MC1002 8C-KC6-012-010 RING,RTRY VOL a
O MC1003 8C-KC6-010-010 LENS,RTRY VOL a
O MC1004 8C-KC2-001-110 WINDOW,LCD R927M a
O MC1005 8C-KC6-001-010 CABI,FRONT a
O MC1006 8C-KC6-009-010 BTN,UP/DOWN a
O MC1007 8C-KC6-201-010 LENS,LED VOL a
O MC1008 8C-KC6-008-010 BTN,EJECT a
O MC1009 8C-KC4-620-010 LCD,CKC-4 a
X MC1010 8C-KC6-203-010 BASE,LCD a

X MC1011 8C-KC6-202-010 LENS,LCD a
X MC1012 8C-KC4-603-110 PWB,DISP a
O MC1013 8B-KC7-215-010 SHAFT,FLAP L/R a
O MC1014 8C-KC6-002-010 CABI,REAR a
O MC1015 8B-KC7-222-010 PLATE,MAGNET a
O MC1016 8C-KC6-014-010 PANEL,BOARD-C a
O MC1017 8C-KC6-223-010 SHAFT,BOARD a
O MC1018 8B-KC7-611-010 PWB,FLEX DISP a
O MC1019 8C-KC6-005-010 LENS,BAR a
O MC1020 8C-KC4-002-010 CABI,BTN a

CDC-R927M
YZSTF
O MC1021 8C-KC2-002-010 BTN,PRESET RDS a
X MC1022 8C-KC4-604-110 PWB,KEY a
X MC1023 8C-KC4-605-110 PWB,AUX a
O MC1024 8B-KC1-602-010 F-CABLE,4P (AUX-W/S) a
O MC1025 87-A61-753-010 JACK,3.6 BLK HSJ1494-01 -020 a
O MC1026 8C-KC6-212-010 CHAS,BTN ASSY a
X MC1026a 8C-KC6-207-010 CHAS,BTN a
X MC1026b 8B-KC7-206-010 SHAFT,PANEL-SW a
X MC1027 8C-KC6-213-010 SH,L-C a
O MC1028 8B-KC7-612-010 PWB,FLEX KEY a

O MC1029 8C-KC6-006-010 CABI,BASE a
O MC1030 8B-KC7-022-010 LENS,CD a
X MC1031 8C-KC4-607-110 PWB,LED a
O MC1032 8B-KC1-603-010 F-CABLE,2P (PWB LED) a
O MC1033 85-ZL3-203-010 MAGNET,ACU a
O MC1034 8B-KC7-208-010 COVER, DUST a
O MC1035 87-A91-054-010 MOT,FF-050SK a
O MC1036 8A-ZL2-211-310 HLDR ASSY,MOT a
X MC1036a 8A-ZL2-212-210 HLDR,MOT a
X MC1036b 8A-ZL2-213-110 SHAFT,HLDR MOT-1 a

CDC-R927M
YZSTF
X MC1036c 8A-ZL2-214-110 SHAFT,HLDR MOT-2 a
X MC1037 8C-KC4-606-110 PWB,SENS a
O MC1038 8A-ZL2-241-010 GEAR,WORM a
O MC1039 8B-KC7-618-010 F-CABLE,2P MOT a
O MC1040 8A-ZL2-243-010 GEAR,L-1 a
O MC1041 8A-ZL2-242-010 WORM-WHL, a
O MC1042 8B-KC7-209-010 HLDR,SP-L a
O MC1043 8B-KC7-210-010 HLDR,SP-R a
O MC1044 8A-ZL2-201-210 FRAME ASSY,MAIN a
X MC1044a 8A-ZL2-202-110 FRAME,MAIN a

X MC1044b 8A-ZL2-203-110 SHAFT,FRAME CAM a
X MC1044c 8A-ZL2-204-110 SHAFT,FRAME LEVER a
O MC1045 8A-ZL2-231-110 LEVER ASSY,GEAR L a
X MC1045a 8A-ZL2-232-010 LEVER,GEAR L-R a
X MC1045b 8A-ZL2-233-110 SHAFT,LEVER GEAR L-R a
O MC1046 8A-ZL2-221-110 LEVER ASSY,L a
X MC1046a 8A-ZL2-222-010 LEVER,L-R a
X MC1046b 8A-ZL2-223-110 SHAFT,LEVER L-R a
O MC1047 8A-ZL2-246-010 GEAR,CAM L a
O MC1048 8A-ZL2-226-110 LEVER ASSY,R a

CDC-R927M
YZSTF
X MC1048a 8A-ZL2-222-010 LEVER,L-R a
X MC1048b 8A-ZL2-223-110 SHAFT,LEVER L-R a
O MC1049 8A-ZL2-236-110 LEVER ASSY,GEAR R a
X MC1049a 8A-ZL2-232-010 LEVER,GEAR L-R a
X MC1049b 8A-ZL2-233-110 SHAFT,LEVER GEAR L-R a
O MC1050 8A-ZL2-247-010 GEAR,CAM R a
O MC1051 8A-ZL2-244-010 GEAR,L-2 a
O MC1052 8A-ZL2-251-110 SHAFT,COUNTER a
O MC1053 8A-ZL2-245-010 GEAR,R a
O MC1054 8B-KC7-024-110 CABI,TRIM a

O MC1055 8Z-KC1-231-110 HLDR,HALF -C a
O MC1056 8B-KC7-023-110 CABI,BASE AROUND a
O MC1057 8B-KC1-213-110 CHAS,SIDE L-BC a
O MC1058 8B-KC1-214-110 CHAS,SIDE R-BC a
O MC1059 8B-KC9-207-010 HLDR,TR3-B9 a
X MC1060 8C-KC4-201-010 HLDR,MECHA FR a
X MC1061 8C-KC4-203-010 COVER, BOTTOM KC4 a
X MC1062 M8-BZG-393-040 BZG-3 CNF a
X MC1063 A8-CZA-590-040 CZA-5 TOSNF a
O MC1064 8B-KCG-247-010 HLDR,MECHA AS-BC a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-49-

MECHANICAL PARTS LIST -2/2

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
O MC1065 8B-ZG3-607-010 PWB,FLEX PIC 2 a
O MC1066 8C-KCG-661-010 FF-CABLE,20P 1.0 90MM a
X MC1067 8A-KC7-225-110 HLDR,CD-AC a
X MC1068 8A-KC7-224-010 HLDR,P-IC -AC a
X MC1069 8C-KCG-251-010 PANEL,HT-SINK Z2C a
X MC1070 8C-KC4-601-010 PWB,MAIN (CKC-4) a
X MC1071 8C-KC6-204-010 COVER, PWB FLEX a
O MC1072 8B-KC1-201-010 COVER, BT RDS a
! S MC1073 8B-KC1-621-010 FUSE,15A 32V a
X MC1074 8C-KCG-254-010 HLDR,ISO-WIRE a

X MC1075 8C-KCG-255-010 TUBE,ISO WIRE D12 a
O MC1A 8Z-KC1-253-010 S-SCREW,PT 2*8 BH+ BLK a
O MC1B 8C-KC6-219-010 S-SCREW,H2-1.4-5 a
O MC1C 8Z-KC1-254-010 S-SCREW,PT 2*5 BH+ BLK a
O MC1D 87-B10-216-010 U+2.6-4.0 ZINC BLK (BH M2.6) a
O MC1E 87-261-032-210 V+2-3 a
O MC1F 87-067-800-010 W-P,1.5-3.5-0.25 SLT a
O MC1G 87-251-070-410 U+2.6-3 a
O MC1H 87-078-018-010 W-P,1.55-3.5-0.25 C-CUT a
O MC1I 87-067-272-010 W-P,2.1-4-0.25 SLIT a

CDC-R927M
YZSTF
O MC1J 8Z-KC1-251-010 S-SCREW,TH2.6-4.0-0.8 a
O MC1K 87-251-073-410 U+2.6-6 a
O MC1L 87-B10-336-010 VTT+2.6-6 W/O a
O MC1M 87-B10-397-010 UTT2+2.6-4 W/O SLOT a
O MC1N 87-081-501-010 VTT+2.6-4 a
O MC1O 87-571-032-410 VIT+2-3 a
O MC1P 8B-ZG3-287-010 S-SCREW,TH1.7-4 0.5 a
O MC1Q 87-B10-259-010 UT2+3.0-10.0 W/O SLOT (BH TAP) a
O MC1R 87-251-097-410 U+3-12 a
O MC1S 87-432-903-010 WTE,2.6 a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-50-

COLOR NAME TABLE -1/1

Basic color symbol Color Basic color symbol Color Basic color symbol Color

B Black C Cream D Orange
G Green H Gray L Blue

LT Transparent Blue N Gold P Pink

R Red S Silver ST Titan Silver

T Brown V Violet W White
WT Transparent White Y Yellow YT Transparent Yellow
LM Metallic Blue LL Light Blue GT Transparent Green
LD Dark Blue DT Transparent Orange GM Metallic Green
YM Metallic Yellow DM Metallic Orange PT Transparent Pink

LA Aqua Blue GL Light Green HT Transparent Gray

HM Metallic Gray NH Champagne Gold M Wood Pattern

-51-

CD MECHANISM EXPLODED VIEW -1/1 (BZG-3CNF)

A

1

51

50

A

A

7

45

52

5

4

6

30

F

27

C

8

10

48

31

2

12

13

D

14

D

28

29

26

20

22

3

B

16

15

A

18

54

19

21

49

32

32

11

23

10

24

47

53

44

56

J

39

43

17

E

52

9

46

38

25

34

H

42

41

35

33

40

37

B

I

CZA-5

55

G

36

-52-

CD MECHANISM PARTS LIST -1/2 (BZG-3CNF)

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

BZG-3
CNF
O SC1001 8B-ZG3-261-110 SPR-P,CD HOLDER SUPORT a
O SC1002 8B-ZG3-232-210 CLAMP,BZG-3 a
O SC1003 8B-ZG3-213-010 LEVER,CD HOLDER a
O SC1004 8B-ZG3-215-210 LEVER,CD L a
O SC1005 8B-ZG3-256-310 SPR-E,CD LEVER a
O SC1006 8B-ZG3-214-010 LEVER,CD R a
O SC1007 8B-ZG3-303-010 LEVER,CD UP HOLDER CNF a
O SC1008 8B-ZG3-212-110 LEVER,CD ROLLER a
O SC1009 8B-ZG3-225-010 GEAR,ROLLER a
O SC1010 8A-ZGA-261-010 ROLLER,RUBBER a

O SC1011 8B-ZG3-241-110 SHAFT,ROLLER a
O SC1012 8B-ZG3-252-010 SPR-T,ROLLER a
O SC1013 8B-ZG3-231-010 TURN TABLE,BZG-3 a
O SC1014 8B-ZG3-201-210 CHAS ASSY,BZG-3 a
X SC1014a 8B-ZG3-284-010 SHAFT,FLOAT FRONT a
X SC1014b 8B-ZG3-202-210 CHAS ASSY,OUT-SERT a
X SC1014c 8B-ZG3-203-210 CHAS,MAIN a
X SC1014d 8B-ZG3-285-010 SHAFT,GEAR DIR a
O SC1015 8B-ZG3-250-010 SPR-T,CLAMP a
O SC1016 8B-ZG3-253-010 SPR-T,CD SENSOR a

BZG-3
CNF
O SC1017 87-A92-091-010 MOT,M25E-4 a
O SC1018 8B-ZG3-220-010 GEAR,MOT a
O SC1019 87-A92-092-010 MOT,M25E-10 a
O SC1020 8B-ZG3-209-110 LEVER ASSY,MODE CH a
X SC1020a 8B-ZG3-210-110 LEVER,MODE CH a
X SC1020b 8B-ZG3-283-010 SHAFT,GEAR 3 DIR a
O SC1021 8B-ZG3-216-010 LEVER ASSY,GEAR HOLDER a
X SC1021a 8B-ZG3-217-010 LEVER,GEAR HOLDER a
X SC1021b 8B-ZG3-224-010 GEAR,SIDE a
X SC1021c 8B-ZG3-226-010 GEAR,WORM ROLLER a

X SC1021d 8B-ZG3-227-010 GEAR,WORM WHL ROLLER a
X SC1021e 8B-ZG3-280-010 SHAFT,GEAR WORM ROLLER a
X SC1021f 8B-ZG3-281-010 SHAFT,GEAR W WHL ROLLER a
X SC1021g 8B-ZG3-282-010 SHAFT,GEAR SIDE a
O SC1022 8B-ZG3-221-010 GEAR,CONNECT a
O SC1023 8B-ZG3-223-010 GEAR,IDL DIR a
O SC1024 8B-ZG3-222-010 GEAR,3 DIR a
O SC1025 8B-ZG3-230-010 GEAR,CAM a
O SC1026 8B-ZG3-251-210 SPR-T,CAM a
O SC1027 8B-ZG3-207-010 LEVER,DIR DOWN a

BZG-3
CNF
O SC1028 87-A92-094-010 SW,PUSH 2-1 ESE11SF1XQ a
O SC1029 8B-ZG3-229-010 GEAR,WHL SLD a
O SC1030 8B-ZG3-218-010 HLDR,FLOAT REAR a
O SC1031 8B-ZG3-246-010 OIL-DMPR,BZG-3 R a
O SC1032 8B-ZG3-243-010 OIL-DMPR,BZG-3 a
O SC1033 8B-ZG3-206-110 LEVER,DIR UP a
O SC1034 8B-ZG3-205-110 LEVER,DIR a
O SC1035 8B-ZG3-255-010 SPR-E,DIR a
O SC1036 8B-ZG3-260-010 SPR-P,LEAD STOP a
O SC1037 8B-ZG3-228-010 GEAR,SLD a

O SC1038 8B-ZG3-240-010 SHAFT,LEAD JVC a
O SC1039 87-A92-093-010 PICKUP,OPTIMA720 JVC a
O SC1040 8B-ZG3-242-210 HLDR,LEAD a
O SC1041 8B-ZG3-263-010 SPR-P,LEAD a
O SC1042 8B-ZG3-247-110 LEVER,LEAD a
O SC1043 8B-ZG3-262-010 SPR-P,PIC UP a
O SC1044 8B-ZG3-607-010 PWB,FLEX PIC 2 a
O SC1045 8B-ZG3-258-010 SPR-E,FLOAT FL a
O SC1046 8B-ZG3-266-010 SPR-E,FLOAT RR a
O SC1047 8B-ZG3-267-010 SPR-E,FLOAT RL a

BZG-3
CNF
O SC1048 8B-ZG3-257-010 SPR-E,FLOAT FR a
O SC1049 8B-ZG3-301-110 CHAS ASSY,HOLDER CNF a
X SC1049a 8B-ZG3-302-010 CHAS,HOLDER CNF a
X SC1049b 8B-ZG3-291-110 SHAFT,SUPPORT A a
X SC1049c 8B-ZG3-292-110 SHAFT,SUPPORT B a
X SC1050 8B-ZG3-602-010 PWB,SUB 35M a
X SC1051 8B-ZG3-605-010 WIRE,CD SENSOR 3P a
O SC1052 8A-ZGA-265-010 SH, 4.5-2.1-0.25 W/O ADH a
O SC1053 8B-ZG3-268-010 SPR-E,PULL FRONT a
X SC1054 8B-ZG3-604-110 WIRE,LIMT 2P a

O SC1055 87-B10-379-010 W-P,1.785-3-0.5 a
O SC1056 87-A92-368-010 SW,PUSH 2-1 MPU10420MLB0 a
O SC1A 87-357-503-310 VT2+1.4-2 a
O SC1B 8B-ZG3-245-010 S-SCREW,CD HLDR a
O SC1C 87-067-393-010 S-SCREW,+1.4-1.4 a
O SC1D 87-267-523-310 V+1.7-2 a
O SC1E 87-B10-361-010 W-P,1.43-3-0.25 SLIT a
O SC1F 87-571-032-410 VIT+2-3 a
O SC1G 87-067-430-010 VT2+1.4-5 SWCH/CR BLK HL a
O SC1H 87-351-527-310 VT2+1.7-3 a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-53-

CD MECHANISM PARTS LIST -2/2 (BZG-3CNF)

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

BZG-3
CNF
O SC1I 88-ZG8-435-010 S-SCREW,VIT+2-4 PREC a
O SC1J 87-B10-400-010 VIT+2-6 W/O SLOT a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-54-

OTHER PARTS LIST -1/1

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

CDC-R927M
YZSTF
X 8A-ZL2-252-010 SH, 6-8-1.6 W/ADH a
X 87-B40-087-010 BAG,PV 0.04-250-350 PL a
X 8C-KC4-851-010 CUSHION,LEFT AIS a
X 8C-KC4-852-010 CUSHION,RIGHT AIS a
X 8C-KCH-854-010 PAD,B a
X 87-B40-085-010 BAG,PV 0.04-200-350 PL a
X 8C-KTF-907-010 SH,DEMO (14L)F 432 a
X 8B-KCF-914-010 SH,MFP (14L)-I a
X 8C-KC4-920-010 SH,STOPPER (14L)F a
X 8C-KC4-970-010 LBL,POP YU a

X 87-B40-178-010 BAG,PV 0.04-100-250 a
X 87-B40-179-010 BAG,PV 0.04-50-100 a
X 87-B40-154-010 LBL,BAR-CODE CU a
X 8C-KC4-205-010 SH, 2-10-0.05 BLK a
X 8C-KC6-215-010 SH, 8.4-4.4-0.3 W/ADH a
X 8C-KC6-214-010 SH, 9.5-8.2-0.95 W/ADH a
X 8C-KC6-210-010 SH,ADH WINDOW a
X 8B-KC7-214-010 SH,CABI REAR a
X 8C-KC4-204-010 SH,CD MECHA a
X 8C-KC6-211-010 SH,CHAS BTN a

CDC-R927M
YZSTF
X 8C-KC6-206-010 SH,LCD a
X 8C-KC4-202-010 SH,LCD PIN a
X 8C-KC6-205-010 SH,LENS LCD a
X 8C-KC6-209-010 SH,MAGNET a
X 8C-KC6-218-010 SH,PWB C a
X 8Z-KC1-239-010 SH,SBX 1971 -F a
X 87-B50-079-010 LIST,FACILITY(B)-0007 a
X 87-B40-281-010 LBL,BAR-CODE A 35X8 a
X 8Z-HC4-028-010 LBL,CLASS 1 & TRIANGLE-G a
X 8C-KC2-852-010 CTN,OUTER 927M YZSTF a

X 8C-KC2-851-010 CTN,PRINTED 927M YZSTF a
X 87-056-168-010 SH,CAUTION INF-WARR(EC) a
X 8B-KCF-907-110 SH,CD-R/RW YZ,YV (9L,R)-I a
X 8C-KC2-020-010 LBL,SPEC YZ R927M a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-55-

OTHER PARTS LIST -2/2 (CD MECHANISM BZG-3CNF)

! = ! SAFTY PARTS
C = Components marked

UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL

BZG-3
CNF
X M8-BZG-393-040 BZG-3 CNF a
X 8B-ZG3-248-110 SH,CLAMP a
X 8B-ZG3-270-010 SH,DUMP a
X 8B-ZG3-244-310 SH,LVR CD HLDR a

All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.

-56-

H251941

2–11, IKENOHATA 1–CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:[phone]