AEM 30-2854-4PK CDI Pencil Coil 4 Pack User Manual

CDI COIL

30-2854

THIS PRODUCT IS LEGAL IN CALIFORNIA FOR RACING VEHICLES ONLY

AND SHOULD NEVER BE USED ON PUBLIC HIGHWAYS.

AEM Performance Electronics

AEM Performance Electronics, 2205 126th Street Unit A, Hawthorne, CA 90250

Phone: [phone] Fax: [phone]

http://www.aemelectronics.com

Instruction Part Number: 10-2854

Document Build 12/18/2013

Ignition SystemsI

Table of Contents

Part I
Part II
Part III
Part IV

Introduction - CDI Coils
Kit Contents - CDI Coils
Dimensions - CDI Coils
12 Month Limited Warranty

1
1
1
2

© AEM Performance Electronics

Introduction - CDI Coils

The 30-2854 kits contain:

1 CDI coil
1 Mating connector
1 mating connector lock
2 wire seals
2 terminals
1 Dielectric grease

The 30-2854-4PK kits contain:

4 CDI coil
4 Mating connectors
4 mating connector locks
8 wire seals
8 terminals
2 Dielectric grease

1

1Introduction - CDI Coils

The model 30-2854 CDI Pencil Coils are optimized for use with high energy CDI systems. The kit
includes all the necessary terminals and connectors to install your coils. Make sure to apply a liberal
amount of dielectric grease to the connector terminals and the tip of the body of the spark plugs. Failure
to do this may cause arcs to the cylinder head and cause a misfire.

2Kit Contents - CDI Coils

3Dimensions - CDI Coils

© AEM Performance Electronics

Ignition Systems2

412 Month Limited Warranty

Advanced Engine Management Inc. warrants to the consumer that all AEM High
Performance products will be free from defects in material and workmanship for a
period of twelve (12) months from date of the original purchase. Products that fail within
this 12-month warranty period will be repaired or replaced at AEM’s option, when
determined by AEM that the product failed due to defects in material or workmanship.
This warranty is limited to the repair or replacement of the AEM part. In no event shall
this warranty exceed the original purchase price of the AEM part nor shall AEM be
responsible for special, incidental or consequential damages or cost incurred due to the
failure of this product. Warranty claims to AEM must be transportation prepaid and
accompanied with dated proof of purchase. This warranty applies only to the original
purchaser of product and is non-transferable. All implied warranties shall be limited in
duration to the said 12-month warranty period. Improper use or installation, accident,
abuse, unauthorized repairs or alterations voids this warranty. AEM disclaims any
liability for consequential damages due to breach of any written or implied warranty on
all products manufactured by AEM. Warranty returns will only be accepted by AEM when
accompanied by a valid Return Merchandise Authorization (RMA) number. Product
must be received by AEM within 30 days of the date the RMA is issued.

Please note that before AEM can issue an RMA for any electronic product, it is first
necessary for the installer or end user to contact the EMS tech line at 1-800-423-0046
to discuss the problem. Most issues can be resolved over the phone. Under no
circumstances should a system be returned or a RMA requested before the above
process transpires.

AEM will not be responsible for electronic products that are installed incorrectly,
installed in a non-approved application, misused, or tampered with.

Any AEM electronics product can be returned for repair if it is out of the warranty period.
There is a minimum charge of $50.00 for inspection and diagnosis of AEM electronic
parts. Parts used in the repair of AEM electronic components will be extra. AEM will
provide an estimate of repairs and receive written or electronic authorization before
repairs are made to the product.

© AEM Performance Electronics