Adcom GTP830 Schematic

SERVICE MANUAL

®

details you can hear

AC3/DTS RECEIVER PREAMPLIFIER

GTP-830

TABLE OF CONTENTS

Instrument Set Up . . . . . . . . . . . . . . . . . . . . . . . .2

Alignment Procedures . . . . . . . . . . . . . . . . . . . . .3

Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-25

Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . .26

PCB Layout . . . . . . . . . . . . . . . . . . . . . . . . .27-36

Schematic Diagrams . . . . . . . . . . . . . . . . . .37-48

IC Block Diagrams . . . . . . . . . . . . . . . . . . . .49-57

Technical Specification . . . . . . . . . . . . . . . . .58-62

®

10 TIMBER LANE

MARLBORD

N.J. 07746, USA

PHONE: [phone]

FAX: [phone]

WEB: http://www.adcom.com

INSTRUMENT SET UP GTP-830

1. FM MEASUREMENT

Fig.1

FM

SIGNAL

GENERATOR

ANTENNA

TERMINAL

UNIT

TP-141

DC

MILLIVOLT

METER

ANTENNA

TERMINAL

DISTORTION

ANALYZER

AC

VOLTMETER

OR

OSCILLOSCOPE

Fig.2

FM

STEREO

GENERATOR

2. RDS MEASUREMENT

Fig.3

RDS

GENERATOR

3. AM MEASUREMENT

Fig.4

AM

SIGNAL

GENERATOR

FM

SIGNAL

GENERATOR

FM

SIGNAL

GENERATOR

AM LOOP
ANTENNA

ANTENNA

TERMINAL

ANTENNA

TERMINAL

60cm

AM LOOP
ANTENNA

(Accessory)

UNIT

OSCILLOSCOPE

UNIT

ANTENNA

TERMINAL

OUTPUT

TERMINAL

L
R

UNIT

VT-J914

DISTORTION

ANALYZER

AC

VOLTMETER

OUTPUT

TERMINAL

AC

VOLTMETER

OR

OSCILLOSCOPE

- 2 -

DIGITAL

MILLIVOLT

METER

ALIGNMENT PROCEDURES GTP-830

FM/RDS SECTION

- FM mono: 1kHz, 75kHz devi., 60dB/µV

- FM stereo: 1kHz, 67.5kHz devi., 60dB/µV
Pilot signal 19kHz 7.5kHz devi.

OUTPUTS

- Connect the non-inductive type resistor of 8 ohms to the all speaker terminals unless otherwise noted.

Item

FM

IF/RF

Stereo

Distortion

Stereo

Separation

Connection

Step

of instrument

1

2 AC voltmeter

Fig.1 –

3

Fig.2

Fig.2

FM SG

output

99.0MHz
1kHz 75kHz devi.
65dBf (60dB)

99.0MHz Ext.
mod. 65dBf
(60dB)

99.0MHz Ext.
mod. 65dBf
(60dB)

Stereo modu-

lator output

Channel L
or R 1kHz

Channel L
or R 1kHz

Tuning

frequency

99.0MHz

99.0MHz

99.0MHz

Output

indicator

DC voltmeter L941

Distortion

analyzer

Distortion

analyzer

Oscilloscope

Adjustment

point

IFT on the

front end

L942

IFT on the

front end

R941

Adjust

for

0±100mV

Maximum

Minimum

Minimum

Maximum

separation

Remarks

FM MUTE/MODE
switch: ON/AUTO
Repeat the steps
1 to 3 until no fur­ther adjustment is
necessary.

FM MUTE/MODE
switch: ON/AUTO
Don’t turn more
than +/-180˚

Repeat stereo dis­tortion and stereo
separation align­ment until THD at
minimum and sepa­ration at maximum.

Muting

Level

RDS

Fig.1

Fig.3

99.0MHz 18dB

99.0MHz Ext.
mod.65dBf(60dB)
RDS 2% MOD

AM SECTION

AM Modulation: 400Hz, 30%
For AH Version

Step

1–

2

3

AM SG

output

600kHz
400Hz 30% mod.
60dB/m

600kHz
400Hz 30% mod.
60dB/m

For C Version

Step

1–

2

3

AM SG

output

600kHz
400Hz 30% mod.
60dB/m

600kHz
400Hz 30% mod.
60dB/m

Tuning

frequency

530kHz

600kHz

990kHz

Tuning

frequency

522kHz

or

531kHz

603kHz

999kHz

Output

indicator

Digital

DC

voltmeter

AC

voltmeter

AC

voltmeter

Output

indicator

Digital

DC

voltmeter

AC

voltmeter

AC

voltmeter

–

–

Adjustment

point

OSC coil

on RF

block L971

OSC coil

on RF

block L971

L972

Adjustment

point

OSC coil

on RF

block L971

OSC coil

on RF

block L971

L972

99.0MHz

99.0MHz

1.35±0.2V (531kHz)

Oscilloscope

Adjust

for

1.35±0.2V

Maximum

Maximum

Adjust

for

1.3±0.2V (522kHz)

Maximum

Maximum

R956

–

–

Signal
output

–

Decode the RDS­Program Station.

- 3 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

AC3 ASSEMBLY

1000 AC3 ASSEMBLY PCB-A0200C-AC3

PC BOARD

2701 PCB AC3/DTS A0200C 1725-303A-0000

METAL MATERIALS

2702 TAPPING 3X8MM B-TITE 2954-3008-0000
2703 INSULATION BUSHING 4151-9931-0
2704 SCREWS BT 2.6X6 2954-2606-0000
H-U121 HEATSINK 5400-0831-0
H-U123 HEAT SINK FOR 7805 2438- 5400-9130-0
S-U121 SI INSULATOR 12X18 3100-3551-0

CAPACITORS

C101 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C102 CC 25V 0.1F 20% 0805 150E-104M-J-BD
C103 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C104 CE 10V 1000µF 20% RL 157C-108M-5-S5
C105 CC 50V 0.01µF 10% 0805 150F-103K-J-BD
C106 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C107 CE 16V 2200µF 20% RL 157D-228M-5-W9
C108 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C114, C115 CE 16V 22µF 20% RL 4X7 157D-226M-5-GM
C117, C119 CE 16V 4.7µF 20% RL 3x5 157D-475M-5-EI
C120, C121 CE 16V 22µF 20% RL 4X7 157D-226M-5-GM
C122, C123 CC 50V 5600pF 5% 0805 1. 150F-562J-J-BD
C125 CC 25V 0.1F 20% 0805 150E-104M-J-BD
C126 CE 16V 220µF 20% RL 6x12 157D-227M-5-KW
C127 CC 25V 0.1F 20% 0805 150E-104M-J-BD
C128 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C129 CC 25V 0.1F 20% 0805 150E-104M-J-BD
C130 CE 25V 1µF 20% RL 3x5 157E-105M-5-EI
C132, C134 CE 16V 4.7µF 20% RL 3x5 157D-475M-5-EI
C135, C136 CC 50V 5600pF 5% 0805 1. 150F-562J-J-BD
C138 CC 25V 0.1F 20% 0805 150E-104M-J-BD
C139 CE 16V 220µF 20% RL 6x12 157D-227M-5-KW
C140 CC 25V 0.1F 20% 0805 150E-104M-J-BD
C141 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C142 CC 25V 0.1F 20% 0805 150E-104M-J-BD
C143 CE 25V 1µF 20% RL 3x5 157E-105M-5-EI
C145, C147 CE 16V 4.7µF 20% RL 3x5 157D-475M-5-EI
C148 CC 50V 5600pF 5% 0805 1. 150F-562J-J-BD
C149 CC 50V 0.01µF 10% 0805 150F-103K-J-BD
C150, C151 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C152 CC 50V 0.01µF 10% 0805 150F-103K-J-BD
C153 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C154 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C156 CC 50V 0.068µF 20% 0805 150F-683M-J-BD
C157 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C158 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU
C159 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C161, C162 CC 16V 1µF+80-20% 0805 15FD-105Z-J-BD
C163, C164 CC 50V 0.01µF 10% 0805 150F-103K-J-BD
C165 CE 16V 2.2µF 20% RL 4X7 157D-225M-5-GM

- 4 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

C166, C167 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C168 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C169 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C171 CC 50V 0.22µF +80/-20% 15FF-224Z-J-BD
C172 CM 50V 2.2µF RL 10X8 153F-225J-5-TOM
C173 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU
C174 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C175 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C176 CE 10V 100µF 20% RL 5x11 157C-107M-5-IU
C179, C180 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C183, C184, C193 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C194, C198 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C199 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C1101, C1104 CE 16V 4.7µF 20% RL 3x5 157D-475M-5-EI
C1102, C1105 CC 50V 0.22µF +80/-20% 15FF-224Z-J-BD
C1106, C1107 CE 16V 22µF 20% RL 4X7 157D-226M-5-GM
C1112-C1114 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C1115 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C1116 CE 25V 1µF 20% RL 3x5 157E-105M-5-EI
C1117 CE 16V 4.7µF 20% RL 3x5 157D-475M-5-EI
C1118 CE 16V 220µF 20% RL 6x12 157D-227M-5-KW
C1119-C1121 CE 16V 4.7µF 20% RL 3x5 157D-475M-5-EI
C1122, C1123 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C1131, C1132, C1134 CC 50V 0.1µF 10% 0805 150F-104K-J-BD
C1135 CC 50V 10pF 5% 0805 1.2x 150F-100J-J-BD
C1136, C1137 CC 50V 0.1µF 10% 0805 150F-104K-J-BD

DIODE

D101 BRIDGE RECTIFIER RB152 4840-0490-0

WAFERS

J101A WAFER 10P P2.5 ST. 2102-101S-004
J203B FLEXIBLE CONN. 35P 2101-1581-0
J601B 12P ST.WAFER 2102-121S-004
J604B 3 PIN ST. WAFER 2102-031S-004

COILS

L101-L104 COIL 10µH 10% BL7.0 1801-100K-M

CRYSTAL

M101 X'TAL 12.288MHZ +/-20PPM 2300-3060-0

TRANSISTOR

Q101 TR DTC114ES 485C-114E-5

RESISTORS

R101-R103 RMG 1/10W 10K 5% 0805 4720-103J-J
R104 RMG 1/10W 68R 5% 0805 4720-680J-J
R105-R109 RMG 1/10W 10K 5% 0805 4720-103J-J
R110 RCFA 1/2W 10K 2% RL 8 9P 4707-103C-5-8
R111, R112 RMG 1/10W 10K 5% 0805 4720-103J-J
R113 RMG 1/10W 47K 5% 0805 4720-473J-J
R114 RMG 1/10W 820R 5% 0805 4720-821J-J
R115 RMG 1/10W 75R 5% 0805 4720-750J-J
R116 RMG 1/10W 47K 5% 0805 4720-473J-J

- 5 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

R117 RMG 1/10W 820R 5% 0805 4720-821J-J
R118 RMG 1/10W 75R 5% 0805 4720-750J-J
R119 RMG 1/10W 0R 5% 0805 4720-000J-J
R122 RMG 1/10W 150R 5% 0805 4720-151J-J
R123 RMG 1/10W 10K 5% 0805 4720-103J-J
R125 RMG 1/10W 150R 5% 0805 4720-151J-J
R126 RMG 1/10W 10K 5% 0805 4720-103J-J
R127 RMG 1/10W 100K 5% 0805 4720-104J-J
R129 RMG 1/10W 0R 5% 0805 4720-000J-J
R130 RMG 1/10W 150R 5% 0805 4720-151J-J
R131 RMG 1/10W 10K 5% 0805 4720-103J-J
R133 RMG 1/10W 150R 5% 0805 4720-151J-J
R134 RMG 1/10W 10K 5% 0805 4720-103J-J
R135, R136 RMG 1/10W 1K 5% 0805 4720-102J-J
R137 RMG 1/10W 150R 5% 0805 4720-151J-J
R138 RMG 1/10W 10K 5% 0805 4720-103J-J
R139 RMG 1/10W 1K 5% 0805 4720-102J-J
R140 RMG 1/10W 100R 5% 0805 4720-101J-J
R150 RMG 1/10W 150R 5% 0805 4720-151J-J
R155 RMG 1/10W 15K 5% 0805 4720-153J-J
R156 RMG 1/10W 10K 5% 0805 4720-103J-J
R157 RMG 1/10W 10K 5% 0805 4720-103J-J
R158 RMG 1/10W 150R 5% 0805 4720-151J-J
R159 RMG 1/10W 15K 5% 0805 4720-153J-J
R160, R161 RMG 1/10W 10K 5% 0805 4720-103J-J
R162 RMG 1/10W 150R 5% 0805 4720-151J-J
R163, R164 RMG 1/10W 22K 5% 0805 4720-223J-J
R165 RMG 1/10W 120R 5% 0805 4720-121J-J
R166 RMG 1/10W 200R 5% 0805 4720-201J-J
R167, R168 RMG 1/10W 10K 5% 0805 4720-103J-J
R169 RMG 1/10W 1K 5% 0805 4720-102J-J
R171 RMG 1/10W 10K 5% 0805 4720-103J-J
R172 RMG 1/10W 470R 5% 0805 4720-471J-J
R173 RMG 1/10W 10K 5% 0805 4720-103J-J
R181 RMG 1/10W 0R 5% 0805 4720-000J-J
R184 RMG 1/10W 100K 5% 0805 4720-104J-J
R185 RMG 1/10W 100K 5% 0805 4720-104J-J
R186, R189 RMG 1/10W 0R 5% 0805 4720-000J-J
R190, R192 RMG 1/10W 100K 5% 0805 4720-104J-J
R193 RMG 1/10W 0R 5% 0805 4720-000J-J
R194 RMG 1/10W 3.3M 5% 0805 4720-335J-J

ICs

U101 IC 74HC153 QUAD 4-INPUT 3131-3980-0
U102 IC 74HC157 QUAD 2-INPUT 3131-3870-0
U103 IC CS5331A 18BIT A/D 3131-3700-0
U104 IC 7AA HIGH SPEED OP AMP 3130-7430-0
U105 IC CS4926 DSP CRYSTAL 3131-3720-0
U106, U107 IC 74HC574 8X D-TYPE 3130-8980-0
U108 IC AT27C020-70 256KX8 3131-9320-0
U109 IC 7AA HIGH SPEED OP AMP 3130-7430-0
U110 IC CS8414 DIR 96KHZ 3130-8890-0
U111-U113 IC CS4340 D/A CONVERTER 3131-3710-0
U114 IC 74HCU04 HEX INVERTERS 3131-9100-0
U115 IC 74HC74 DUAL D-TYPE 3130-6590-0

- 6 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

U116 IC 7AA HIGH SPEED OP AMP 3130-7430-0
U117 IC 74HC74 DUAL D-TYPE 3130-6590-0
U118, U119 IC 74HC00 QUAD 2I/P NAND 3131-9050-0
U120 IC 74HC74 DUAL D-TYPE 3130-6590-0
U121 IC LM317T+ADJ REGULATOR 3130-5610-0
U123 IC 7805 REG 5V 3130-2020-2
U125 IC 7805 REG 5V 1.5A 3130-2020-3
U131, U134 IC 7AA HIGH SPEED OP AMP 3130-7430-0

AUDIO ASSEMBLY

2000 AUDIO ASSEMBLY PCB-A0200C-AUD

PC BOARD

1201 PCB AUDIO/VIDEO/PSU/TONE/S-VIDEO/SW1 1725-304A-0102

CAPACITORS

C302 CC 50V 0.01µF 10% AT 3.5 150F-103K-2-FC
C303 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU
C304 CC 50V 0.01µF 10% AT 3.5 150F-103K-2-FC
C305, C306 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU
C319, C322 CC 50V 100pF 10% AT 3.5x 150F-101K-2-FC
C325-C332 CC 50V 100pF 10% AT 3.5x 150F-101K-2-FC
C333, C334 CE 16V 3.3µF 20% RL 5x5 157D-335M-5-II
C337, C338 CE 16V 3.3µF 20% RL 5x5 157D-335M-5-II
C361, C363 CE 16V 4.7µF 20% RL 3x5 157D-475M-5-EI
C364, C365 CC 50V 0.1µF +80/-20% RL 150F-104Z-5-IU
C366, C367 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C368 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU
C370, C371 CC 50V 100pF 10% AT 3.5x 150F-101K-2-FC
C372, C373 CE 16V 3.3µF 20% RL 5x5 157D-335M-5-II

DIODES

D310, D311 DZ 1/2W 5.0-5.2V AT 4837-4C20-2

JACKS

M303 RCA JACK 2P R/W/GOLD 2113-1742-0
M301, M302, M304 4P RCA JACK R/W GOLD 2113-1808-0

TRANSISTORS

Q302, Q303 TR DTA114ESA ROHM 485A-114E-5

RESISTORS

R302-R304 RMF 1/8W 1K 1% AT 4711-102A-2
R305 RMF 1/8W 10K 1% AT 4711-103A-2
R331 RMF 1/8W 330R 1% AT 4711-331A-2
R332 RMF 1/8W 1M 1% AT 4711-105A-2
R333 RMF 1/8W 330R 1% AT 4711-331A-2
R334 RMF 1/8W 1M 1% AT 4711-105A-2
R335 RMF 1/8W 330R 1% ATS 4711-331A-C
R336 RMF 1/8W 1M 1% AT 4711-105A-2
R337 RMF 1/8W 330R 1% AT 4711-331A-2
R338 RMF 1/8W 1M 1% AT 4711-105A-2
R339 RMF 1/8W 2.2K 1% AT 4711-222A-2
R340 RMF 1/8W 1M 1% AT 4711-105A-2

- 7 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

R341 RMF 1/8W 2.2K 1% AT 4711-222A-2
R342 RMF 1/8W 1M 1% AT 4711-105A-2
R343 RMF 1/8W 2.2K 1% AT 4711-222A-2
R344 RMF 1/8W 1M 1% AT 4711-105A-2
R345 RMF 1/8W 2.2K 1% AT 4711-222A-2
R346 RMF 1/8W 1M 1% AT 4711-105A-2
R347 RMF 1/8W 2.2K 1% AT 4711-222A-2
R348 RMF 1/8W 1M 1% AT 4711-105A-2
R349 RMF 1/8W 2.2K 1% AT 4711-222A-2
R350 RMF 1/8W 1M 1% AT 4711-105A-2
R351 RMF 1/8W 2.2K 1% AT 4711-222A-2
R352 RMF 1/8W 1M 1% AT 4711-105A-2
R353 RMF 1/8W 2.2K 1% AT 4711-222A-2
R354 RMF 1/8W 1M 1% AT 4711-105A-2
R361 RMF 1/8W 100R 1% AT 4711-101A-2
R362 RMF 1/8W 220K 1% AT 4711-224A-2
R363 RMF 1/8W 100R 1% AT 4711-101A-2
R366 RMF 1/8W 220K 1% AT 4711-224A-2
R367, R368 RMF 1/8W 2.2K 1% AT 4711-222A-2
R369, R370 RMF 1/8W 1M 1% AT 4711-105A-2
R371 RMF 1/8W 1K 1% AT 4711-102A-2

ICs

U301 IC TC9273N-004 ANALOG 3131-3570-0
U302 IC HCF4053BT 3130-3870-0
U303 IC 7AA HIGH SPEED OP AMP 3130-7430-0

BOARD ASSEMBLY

KEY

4000 KEY BOARD ASSEMBLY PCB-A0200C-KEY

PC BOARD

2101 PCB KEYBOARD/VOL/PRI/SEC 1725-306A-0102

METAL MATERIAL

CUSHION DAMPER 4152-0282-0

2118 HOLDER (FL) 4152-5741-0

LCD DISPLAY

2119 VFD 12-MT-79GNK FUTABA 2460-1890-1

CAPACITORS

C201 CE 6.3V 47µF 20% RL 4x7 157B-476M-5-GM
C202 CC 50V 0.01µF 10% AT 3.5 150F-103K-2-FC
C203, C204 CC 50V 22pF 10% RL 4x4 150F-220K-5-GG
C205 CC 50V 0.1µF +80/-20% RL 150F-104Z-5-IU
C206 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM
C207 CC 50V 0.1µF +80/-20% RL 150F-104Z-5-IU
C208 CE 10V 47µF 20% RL 4X7 157C-476M-5-GM
C210 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM
C211 CC 50V 0.1µF +80/-20% RL 150F-104Z-5-IU
C212 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM
C213 CC 50V 0.1µF +80/-20% RL 150F-104Z-5-IU
C221 CE 50V 3.3µF 20% RL 4x7 157F-335M-5-GM

- 8 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

DIODES

D201, D202 DIODE 1N4148 ATS 4804-1480-C
D203 DZ 1/2W 5.45-5.73 ROHM 4837-5B61-2
D205-D209 DIODE 1N4148 ATS 4804-1480-C
D210 DZ 1/2W 5.1V "TEMIC" AT 4837-5V16-2

COIL

L201 COIL 22µH 10% AL BL7 1801-220K-M

SWITCHES

M201 SWITCH, TACT SKHHBY 7MM 5200-3538-0
M202, M203 SWITCH TACT W/LED 5200-1041-0-01
M204 SWITCH, TACT SKHHBY 7MM 5200-3538-0
M205, M206 SWITCH TACT W/LED 5200-1041-0-01
M207 SWITCH, TACT SKHHBY 7MM 5200-3538-0
M208, M209 SWITCH TACT W/LED 5200-1041-0-01
M210 SWITCH, TACT SKHHBY 7MM 5200-3538-0
M211, M212 SWITCH TACT W/LED 5200-1041-0-01
M213 SWITCH, TACT SKHHBY 7MM 5200-3538-0
M214, M217, M222 SWITCH TACT W/LED 5200-1041-0-01
M215, M216 SWITCH, TACT SKHHBY 7MM 5200-3538-0

IR SENSOR

M218 IR SENSOR PIC-12043TE2 4814-3TE2-3
M301 ROTARY ENCODER 4750-6000-0

CRYSTAL

M219 CRYSTAL 10MHZ +/-30PPM 2300-3150-0

CONNECTORS / WAFERS

M221 SHUNT 2P P=2.54 2101-0661-0
M221 REDEPTACLE 8PIN DUAL 2101-1368-0
J203A, J206A FLEXIBLE CONN. 35P 2101-1581-0

3P WAFER P=2.54 2102-8003-0-100

RESISTORS

R286-R288 RMF 1/8W 10K 1% AT 4711-103A-2
R290, R299 RMF 1/8W 10K 1% AT 4711-103A-2

TRANSISTORS

Q204 TR DTA114ESA ROHM 485A-114E-5
Q202 TR DTC144ES ROHM 485C-144E-5
Q201 TR SS8050 C/D SAMSUNG RL 4860-0050-5

RESISTORS

R201-R203 RMF 1/8W 680R 1% ATS 4711-681A-C
R204-R206 RMF 1/8W 820R 1% AT 4711-821A-2
R207-R209 RMF 1/8W 1.8K 1% AT 4711-182A-2
R210-R212 RMF 1/8W 2.2K 1% AT 4711-222A-2
R213, R214 RMF 1/8W 4.7K 1% AT 4711-472A-2
R215-R218 RMF 1/8W 10K 1% AT 4711-103A-2
R219 RMF 1/8W 4.7K 1% AT 4711-472A-2
R220, R221 RMF 1/8W 470R 1% AT 4711-471A-2
R222 RMF 1/8W 47K 1% AT 4711-473A-2
R223 RMF 1/8W 470K 1% AT 4711-474A-2

- 9 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

R224 RMF 1/8W 560R 1% AT 4711-561A-2
R225, R226 RMF 1/8W 10K 1% AT 4711-103A-2
R230, R231 RMF 1/8W 22K 1% AT 4711-223A-2
R232 RMF 1/8W 10K 1% ATS 4711-103A-C
R233-R246 RMF 1/8W 10K 1% AT 4711-103A-2
R247-R250 RMF 1/8W 47K 1% AT 4711-473A-2
R251-R255 RMF 1/8W 10K 1% AT 4711-103A-2
R260 RMF 1/8W 4.7K 1% AT 4711-472A-2
R261 RMF 1/8W 10K 1% AT 4711-103A-2
R262 RMF 1/8W 22K 1% AT 4711-223A-2
R263-R274 RMF 100K 1/8W 1% AT 4711-104A-2
R275-R277 RMF 1/8W 560R 1% AT 4711-561A-2
R278, R280 RMF 1/8W 1K 1% AT 4711-102A-2
R281 RMF 1/8W 560R 1% AT 4711-561A-2
R282 RMF 1/8W 10K 1% AT 4711-103A-2
R283 RMF 1/8W 7.5K 1% AT 4711-752A-2
R285, R289, R291, R293 RMF 1/8W 560R 1% AT 4711-561A-2
R295-R298 RMF 1/8W 560R 1% AT 4711-561A-2
R301, R302 RMF 1/8W 22K 1% AT 4711-223A-2

ICs

U201 IC LC87F65C8A 8-BIT MCU 3131-3810-0
U202 IC EEPROM 24C02 2KBIT 3131-3920-0
U203, U204 IC 4094 8-BIT SIPO SR 3S 3130-3600-0

TI ASSEMBLY

MUL

PCB ASSY MULTI CH A0200C PCB-A0200C-MUTI

PC BOARD

PCB S-VID/PSU/PRI/SEC 1725-307A-0001

METAL MATERIALS

UL2547 AWG26 BLACK L100MM 7010-2351-0

JACKS

1105 6P RCA JACK R/W GOLD 2113-1805-0
1102 4P RCA JACK R/W GOLD 2113-1808-0
1103, 1106 2P RCA JACK BK/BK GOLD 2113-1809-0

CAPACITORS

C501-C504 CC 50V 100pF 10% AT 3.5x 150F-101K-2-FC
C505-C509 CE 16V 4.7µF 20% RL 3x5 157D-475M-5-EI
C510-C513 CC 50V 100pF 10% AT 3.5x 150F-101K-2-FC
C514, C515 CC 50V 220pF 10% RL 4x4 150F-221K-5-GG
C516-C520 CE 16V 4.7µF 20% RL 3x5 157D-475M-5-EI
C522, C523 CC 50V 22pF 5% AT 3.5x2 150F-220J-2-FC
C524, C525, C528, C529 CE 16V 4.7µF 20% RL 3x5 157D-475M-5-EI
C530, C531 CC 50V 22pF 5% AT 3.5x2 150F-220J-2-FC
C533, C534 CE 16V 3.3µF 20% RL 5x5 157D-335M-5-II
C553-C562 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C580, C581 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II
C601-C606 CC 50V 100pF 10% AT 3.5x 150F-101K-2-FC
C609, C610 CC 50V 0.022µF 10% AT 150F-223K-2-FD
C611-C616 CE 16V 3.3µF 20% RL 5x5 157D-335M-5-II

- 10 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

C617 CC 50V 0.1µF +80/-20% RL 150F-104Z-5-IU
C618, C619 CE 16V 3.3µF 20% RL 5x5 157D-335M-5-II
C620, C621 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU
C622-C629 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C630-C633 CC 50V 220pF 10% RL 4x4 150F-221K-5-GG
C634-C637 CM 100PF 50V RL (7X6) 153F-101K-5-MKN
C638-C641 CE 50V 2.2µF 10% RL 4X7 157F-225K-5-GM
C644 CC 50V 0.01µF 10% RL 5x5 150F-103K-5-II
C647-C649 CE 16V 22µF 20% RL 5x5 157D-226M-5-II
C654, C655 CE 16V 3.3µF 20% RL 5x5 157D-335M-5-II
C656, C657 CC 50V 100pF 5% RL 5x3.5 150F-101J-5-IF
C658, C659 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU
C660-C663 CM 100PF 50V RL (7X6) 153F-101K-5-MKN
C664-C667 CC 50V 100pF 5% RL 5x3.5 150F-101J-5-IF
C668, C669 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C670, C671 CM 50V 0.01µF 5% RL 5X7 153F-103J-5-IM
C672, C673 CM 100PF 50V RL (7X6) 153F-101K-5-MKN
C674 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU
C675, C676 CC 50V 220pF 10% AT 3.5x 150F-221K-2-FC
C679 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU
C680 CE 16V 220µF 20% RL 6x12 157D-227M-5-KW
C681, C682 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU
C683-C686 CE 25V 22µF 20% RL 5X11 157E-226M-5-IUN
C699 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU
R501, R506, R511, R516 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
R523 ,R527, R531, R536 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM

DIODES

D601, D602 DZ 1/2W 7.07~7.45V ROHM 4837-7B51-2
D603 DIODE 1N4148 AT 4804-1480-2
D604-D608 DIODE 1N4148 AT 4804-1480-2
D607 DZ 1/2W 5.45-5.73 ROHM 4837-5B61-2
D609 DZ 1/2W 6.2V TEMIC AT 4837-6V26-2

SOCKETS / WAFERS

J502A SOCKET (PCB/PCB) 10P 2101-1801-0
J601A 12P ST.WAFER 2102-121S-004
J605A WAFER 10P P2.5 ST. 2102-101S-004
J705B SOCKET (PCB/PCB) 10P 2101-1801-0
J706B SOCKET (PCB/PCB) 10P 2101-1801-0

COILS

L601, L602 COIL 100µH 10% 1801-101K-M

RELAYS

M611-M614 NAIS RELAY TQ2-5V 4500-8080-0

TRANSISTORS

Q601 TR RN1241-A 4851-241A-5
Q602, Q607 TR SS8550 C/D SAMSUNG RL 4860-0060-5
Q603, Q605 TR RN1241-A 4851-241A-5
Q607 TR SS8550 C/D SAMSUNG RL 4860-0060-5
Q608 TR 2SC2878 (A,B) RL 4860-0770-5
Q609, Q610 TR DTA114ESA ROHM 485A-114E-5
Q611, Q612 TR RN1241-A 4851-241A-5

- 11 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

Q613 TR 2SC2878 (A,B) RL 4860-0770-5
Q614, Q616, Q618 TR DTC114ES 485C-114E-5
Q620, Q628 TR DTA114ESA ROHM 485A-114E-5
Q621 TR DTC123JSA ROHM 485C-123J-5
Q622 TR SS8050 C/D SAMSUNG RL 4860-0050-5
Q623-Q625 TR DTC123JSA ROHM 485C-123J-5
Q626, Q627 TR RN1241-A 4851-241A-5

RESISTORS

R502 RMF 1/8W 7.5K 1% AT 4711-752A-2
R503 RMF 1/8W 22K 1% AT 4711-223A-2
R504 RMF 1/8W 12K 1% AT 4711-123A-2
R505 RMF 1/8W 220K 1% AT 4711-224A-2
R507 RMF 1/8W 22K 1% AT 4711-223A-2
R508 RMF 1/8W 7.5K 1% AT 4711-752A-2
R509 RMF 1/8W 12K 1% AT 4711-123A-2
R510 RMF 1/8W 220K 1% AT 4711-224A-2
R512 RMF 1/8W 22K 1% AT 4711-223A-2
R513 RMF 1/8W 6.8K 1% AT 4711-682A-2
R514 RMF 1/8W 12K 1% AT 4711-123A-2
R515 RMF 1/8W 220K 1% AT 4711-224A-2
R517 RMF 1/8W 22K 1% AT 4711-223A-2
R518 RMF 1/8W 6.8K 1% AT 4711-682A-2
R519 RMF 1/8W 12K 1% AT 4711-123A-2
R520 RMF 1/8W 220K 1% AT 4711-224A-2
R521 RMF 1/8W 22K 1% AT 4711-223A-2
R522 RMF 1/8W 6.8K 1% AT 4711-682A-2
R524 RMF 1/8W 12K 1% AT 4711-123A-2
R525 RMF 1/8W 220K 1% AT 4711-224A-2
R526 RMF 1/8W 22K 1% AT 4711-223A-2
R528 RMF 1/8W 6.8K 1% AT 4711-682A-2
R529 RMF 1/8W 12K 1% AT 4711-123A-2
R530 RMF 1/8W 220K 1% AT 4711-224A-2
R532 RMF 1/8W 22K 1% AT 4711-223A-2
R533 RMF 1/8W 6.8K 1% AT 4711-682A-2
R534 RMF 1/8W 12K 1% AT 4711-123A-2
R535 RMF 1/8W 220K 1% AT 4711-224A-2
R537 RMF 1/8W 22K 1% AT 4711-223A-2
R538 RMF 1/8W 6.8K 1% AT 4711-682A-2
R539 RMF 1/8W 12K 1% AT 4711-123A-2
R540 RMF 1/8W 220K 1% AT 4711-224A-2
R541, R542 RMF 1/8W 22K 1% AT 4711-223A-2
R543, R544 RMF 1/8W 1K 1% AT 4711-102A-2
R545, R546 RMF 39K 1/8W 1% AT 4711-393A-2
R547, R548 RMF 1/8W 10K 1% AT 4711-103A-2
R549 RMF 1/8W 47K 1% AT 4711-473A-2
R560 RMF 1/8W 10K 1% AT 4711-103A-2
R561, R562 RMF 1/8W 30K 1% AT 4711-303A-2
R563 RMF 1/8W 47K 1% AT 4711-473A-2
R564 RMF 1/8W 10K 1% AT 4711-103A-2
R567 RMF 1/8W 1.5K 1% AT 4711-152A-2
R568 RMF 100K 1/8W 1% AT 4711-104A-2
R569 RMF 1/8W 220R 1% AT 4711-221A-2
R570, R571 RMF 100K 1/8W 1% AT 4711-104A-2
R572 RMF 1/8W 220R 1% AT 4711-221A-2

- 12 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

R601-R606 RMF 1/8W 330R 1% ATS 4711-331A-C
R607-R612 RMF 1/8W 100K 1% ATS 4711-104A-C
R613 RMF 1/8W 33K 1% AT 4711-333A-2
R614, R615 RMF 1/8W 10K 1% ATS 4711-103A-C
R616 RMF 1/8W 33K 1% AT 4711-333A-2
R6164 RMF 1/8W 1K 1% AT 4711-102A-2
R617, R618 RMF 1/8W 10K 1% ATS 4711-103A-C
R620 RMF 1/8W 33K 1% AT 4711-333A-2
R621, R622 RMF 1/8W 10K 1% ATS 4711-103A-C
R623 RMF 1/8W 12K 1% AT 4711-123A-2
R624 RMF 39K 1/8W 1% AT 4711-393A-2
R626 RMF 1/8W 20K 1% AT 4711-203A-2
R627 RMF 1/8W 3.3K 1% ATS 4711-332A-C
R628 RMF 1/8W 20K 1% AT 4711-203A-2
R631 RMF 1/8W 1.5K 1% AT 4711-152A-2
R632, R633 RMF 1/8W 10K 1% ATS 4711-103A-C
R634-R643 RMF 100K 1/8W 1% AT 4711-104A-2
R644, R645 RMF 1/8W 1K 1% AT 4711-102A-2
R646-R649 RMF 1/8W 56K 1% AT 4711-563A-2
R650-R653 RMF 1/8W 2.7K 1% AT 4711-272A-2
R654 RMF 1/8W 10K 1% ATS 4711-103A-C
R655 RMF 1/8W 22K 1% AT 4711-223A-2
R656, R657 RMF 1/8W 10K 1% AT 4711-103A-2
R658 RMF 1/8W 1K 1% AT 4711-102A-2
R659 RMF 1/8W 470R 1% ATS 4711-471A-C
R660, R661 RMF 1/8W 1K 1% AT 4711-102A-2
R662-R664 RMF 1/8W 56K 1% AT 4711-563A-2
R665 RMF 100K 1/8W 1% AT 4711-104A-2
R666 RMF 1/8W 56K 1% AT 4711-563A-2
R667-R672 RMF 1/8W 220R 1% AT 4711-221A-2
R673-R678 RMF 100K 1/8W 1% AT 4711-104A-2
R679, R680 RMF 1/8W 56K 1% AT 4711-563A-2
R681, R682 RMF 1/8W 1K 1% AT 4711-102A-2
R682 RMF 1/8W 1K 1% AT 4711-102A-2
R683, R684 RMF 1/8W 100R 1% AT 4711-101A-2
R685, R686 RMF 1/8W 22K 1% AT 4711-223A-2
R687, R688 RMF 1/8W 4.7K 1% ATS 4711-472A-C
R689, R690 RMF 1/8W 56K 1% AT 4711-563A-2
R691, R692 RMF 1/8W 20K 1% AT 4711-203A-2
R693, R694 RMF 1/8W 1.5K 1% AT 4711-152A-2
R695, R696 RMF 1/8W 1.2K 1% AT 4711-122A-2
R697, R698 RMF 100K 1/8W 1% AT 4711-104A-2
R699, R700 RMF 1/8W 1K 1% AT 4711-102A-2
R704 RMF 1/8W 1.5K 1% AT 4711-152A-2
R705 RMF 1/8W 3.3K 1% ATS 4711-332A-C
J6123, J680 RMF 1/8W 6.8K 1% AT 4711-682A-2

ICs

U601 IC M62447SP ELECTRIC 3130-8120-0
U602 IC TC9164AN HV ANALOG SW 3130-3730-1
U605-U611 IC 7AA HIGH SPEED OP AMP 3130-7430-0
U618 IC TC9260P 3131-7200-0
U620-U625 IC 7AA HIGH SPEED OP AMP 3130-7430-0
U626 IC 7805 REG 5V 1.5A 3130-2020-3

- 13 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

S-VIDEO ASSEMBLY

7000 S-VIDEO ASSEMBLY PCB-A0200C-SVD

PC BOARD

PCB AUDIO/VIDEO/PSU/TONE 1725-304A-0102

CAPACITORS

C401 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C404 CE 50V 2.2µF 20% RL 4x7 157F-225M-5-GM
C405 CE 10V 470µF 20% RL 8X11 157C-477M-5-OU
C406 CE 50V 2.2µF 20% RL 4x7 157F-225M-5-GM
C407 CE 10V 470µF 20% RL 8X11 157C-477M-5-OU
C408-C413 CE 50V 2.2µF 20% RL 4x7 157F-225M-5-GM
C414 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU
C415 CE 10V 470µF 20% RL 8X11 157C-477M-5-OU
C416, C417 CE 50V 2.2µF 20% RL 4x7 157F-225M-5-GM
C418 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C419 CM 50V 0.022µF 5% RL 153F-223J-5-LQ
C420, C421 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C423, C424 CE 6.3V 220µF 20% RL 157B-227M-5-KW
C429 CTC 0/60 30pF 5% RL 5x4 15CH-300J-5-IG
C429A CTC 0/60 5pF 0.5pF RL 15CH-050D-5-GG
C430 CTC 0/60 30pF 5% RL 5x4 15CH-300J-5-IG
C430A CTC 0/60 5pF 0.5pF RL 15CH-050D-5-GG
C431, C432 CTC 0/60 27pF 5% RL 4x4 15CH-270J-5-GG
C433-C435 CC 50V 47pF 5% RL 5x3.5 150F-470J-5-IF
C436 CE 50V 1µF 20% RL 4x7 157F-105M-5-GM
C440 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU
C442 CE 6.3V 100µF 20% RL 6x7 157B-107M-5-KM
C443 CC 50V 0.01µF 10% RL 5x5 150F-103K-5-II
C444 CC 50V 0.47µF 20% RL 5X5 150F-474M-5-II
C445 CE 6.3V 100µF 20% RL 6x7 157B-107M-5-KM
C446 CE 50V 0.47µF 20% RL 4x7 157F-474M-5-GM
C447 CC 50V 47pF 5% RL 5x3.5 150F-470J-5-IF
C448 CC 50V 0.47µF 20% RL 5X5 150F-474M-5-II
C449 CC 50V 0.01µF 10% RL 5x5 150F-103K-5-II
C451 CC 50V 1200pF 10% RL 5x3 150F-122K-5-IF
C453 CE 50V 1µF 20% RL 4x7 157F-105M-5-GM
C454 TRIMCAP 5.2-30P 1551-0210-0
C456 CTC 0/60 22pF 5% RL 4X4 15CH-220J-5-GG
C457 CC 50V 6800pF 10% RL 10x 150F-682K-5-SF
C462 CE 50V 0.47µF 20% RL 4x7 157F-474M-5-GM
C463 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C465 CE 6.3V 100µF 20% RL 6x7 157B-107M-5-KM
C469 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG

DIODES

D401-D407, D413, D414 DIODE 1N4148 ATS 4804-1480-C

SOCKETS / CONNECTORS

J403, J404 1P DIN CONNECTOR HDC-050 2113-1183-0
J406-J408 1P DIN CONNECTOR HDC-050 2113-1183-0
J709B, J710B SOCKET (PCB/PCB) 10P 2101-1801-0
M401 X'TAL 14.318MHZ +-20PPM 2300-3020-0
M402 X'TAL 17.734MHZ +-20PPM 2300-3030-0

- 14 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

COILS

L401 COIL 22µH 10% AL BL7 1801-220K-M
L403 COIL 5.6µH 10% BL=7 1801-5R6K-M

TRANSISTORS

Q401, Q402 TR 2SC2878 (A,B) RL 4860-0770-5
Q403 TR 2SA933S HFE 120-560 485A-933S-5
Q404 TR 2SC2878 (A,B) RL 4860-0770-5
Q405 TR 2SA933S HFE 120-560 485A-933S-5
Q406 TR DTC123JSA ROHM 485C-123J-5
Q407 TR 2SA933S HFE 120-560 485A-933S-5
Q408 TR 2SC2878 (A,B) RL 4860-0770-5
Q409-Q411 TR 2SA933S HFE 120-560 485A-933S-5
Q412 TR DTC123JSA ROHM 485C-123J-5
Q413 TR 2SC2878 (A,B) RL 4860-0770-5
Q414, Q415 TR 2SC1740S 4860-1590-5
Q416, Q432 TR 2SA933S HFE 120-560 485A-933S-5
Q436 TR 2SC1740S 4860-1590-5
Q437 TR 2SC2878 (A,B) RL 4860-0770-5
Q438 TR DTC144ES ROHM 485C-144E-5

RESISTORS

R401-R406 RMF 1/8W 82R 1% AT 4711-820A-2
R407, R408 RMF 1/8W 68R 1% AT 4711-680A-2
R409 RMF 1/4W 470R 1% AT 4715-471A-2
R411, R412 RMF 1/8W 68R 1% AT 4711-680A-2
R414 RMF 1/8W 120R 1% AT 4711-121A-2
R415 RMF 1/8W 1K 1% AT 4711-102A-2
R416 RMF 1/8W 56K 1% AT 4711-563A-2
R417 RMF 1/8W 560R 1% AT 4711-561A-2
R418 RMF 1/8W 470R 1% AT 4711-471A-2
R419 RMF 1/8W 1K 1% AT 4711-102A-2
R420, R421 RMF 1/8W 470R 1% AT 4711-471A-2
R422 RMF 1/8W 1K 1% AT 4711-102A-2
R423 RMF 1/8W 68R 1% AT 4711-680A-2
R424 RMF 1/8W 220R 1% AT 4711-221A-2
R425, R426 RMF 1/8W 1K 1% AT 4711-102A-2
R427 RMF 1/8W 68R 1% AT 4711-680A-2
R428 RMF 1/8W 33K 1% AT 4711-333A-2
R429 RMF 100K 1/8W 1% AT 4711-104A-2
R430 RMF 1/8W 470R 1% AT 4711-471A-2
R431 RMF 1/8W 2.2K 1% AT 4711-222A-2
R441 RMF 1/8W 1K 1% AT 4711-102A-2
R442 RMF 1/8W 2.2K 1% AT 4711-222A-2
R443-R445 RMF 1/8W 1K 1% AT 4711-102A-2
R446-R449 RMF 1/8W 2.2K 1% AT 4711-222A-2
R450 RMF 1/8W 1.2K 1% AT 4711-122A-2
R451 RMF 1/8W 100R 1% AT 4711-101A-2
R452 RMF 100K 1/8W 1% AT 4711-104A-2
R453 RMF 1/8W 8.2K 1% AT 4711-822A-2
R454 RMF 1/8W 1.5K 1% AT 4711-152A-2
R456 RMF 1/8W 820K 1% AT 4711-824A-2
R457 RMF 1/8W 6.8K 1% AT 4711-682A-2
R458 RMF 1/8W 47K 1% AT 4711-473A-2

- 15 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

R459 RMF 1/8W 220R 1% AT 4711-221A-2
R462 RMF 1/8W 2.7K 1% AT 4711-272A-2
R463 RMF 1/8W 120R 1% AT 4711-121A-2
R467 RMF 1/8W 1K 1% AT 4711-102A-2
R468 RMF 100K 1/8W 1% AT 4711-104A-2
R469 RMF 1/8W 1K 1% AT 4711-102A-2
R473 RMF 1/8W 6.8K 1% AT 4711-682A-2
R474 RMF 1/8W 3.3K 1% AT 4711-332A-2
R475 RMF 1/8W 1K 1% AT 4711-102A-2
R476 RMF 1/8W 10K 1% AT 4711-103A-2

ICs

U401 IC LC74763-9012 OSD 3131-3750-0
U402, U403 IC BA7625 2X5CH 3131-3730-0

SWITCH

8000 PCB ASSY SWITCH A0200C PCB-A0200C-SW

PC BOARD

SWITCH

1702 ^ POWER SWITCH TV5 5200-3665-0

CAPACITOR

C761 CC 400V 0.01µF +-20% RL 8910-0091-0

TONE ASSEMBLY

9000 PCB ASSY TONE A0200C PCB-A0200C-TONE

PC BOARD

CAPACITORS

C321, C322 CM 50V 0.015µF 5% RL 153F-153J-5-KP

WAFER

J605B WAFER 10P P2.5 ST. 2102-101S-004

ASSEMBLY

PCB MAIN/AMP1/AMP2/LOAD 1725-305A-0003

PCB KEYBOARD/VOL/PRI/SEC 1725-306A-0102

RESISTORS

R321, R322 RMF 1/8W 1K 1% ATS 4711-102A-C
R323, R324 VR 100KWX2 W/CC RK16312 4750-9730-0

VIDEO

11000 VIDEO ASSEMBLY PCB-A0200C-VD

PC BOARD

SOCKETS / JACKS

1302 1P RCA JACK YL GOLD 2113-1810-0
1303 4P RCA JACK YL GOLD 2113-1811-0

ASSEMBLY

PCB AUDIO/VIDEO/PSU/TONE 1725-304A-0102

- 16 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

1304 2P RCA JACK YL GOLD 2113-1812-0
J708B SOCKET (PCB/PCB) 10P 2101-1801-0

CAPACITORS

C441 CC 50V 0.01µF 10% AT 3.5 150F-103K-2-FC
C450 CC 50V 0.022µF 10% AT 150F-223K-2-FD
C459-C461 CE 50V 2.2µF 20% RL 4x7 157F-225M-5-GM
C464 CC 50V 0.01µF 10% AT 3.5 150F-103K-2-FC
C466, C467 CE 10V 470µF 20% RL 8X11 157C-477M-5-OU
C468 CE 16V 1000µF 20% RL 157D-108M-5-S9
C470 CE 50V 2.2µF 20% RL 4x7 157F-225M-5-GM
C476 CE 10V 470µF 20% RL 8X11 157C-477M-5-OU

DIODES

D414, D415 DIODE 1N4148 ATS 4804-1480-C

TRANSISTORS

Q428, Q434, Q435 TR 2SA933S HFE 120-560 485A-933S-5

RESISTORS

R439 RMF 1/8W 470R 1% AT 4711-471A-2
R460, R461 RMF 1/8W 120R 1% AT 4711-121A-2
R464-R466 RMF 1/8W 68R 1% AT 4711-680A-2
R483, R491-R493 RMF 1/8W 82R 1% AT 4711-820A-2

IC

U404 IC BA7625 2X5CH 3131-3730-0

VIDEO-5

12000 VIDEO-5 ASSEMBLY PCB-A0200C-VD5

PC BOARD

JACKS / CONNECTORS

1902 1P RCA YL GOLD PLATED GN 2113-1290-0
1903 1P RCA WH GOLD PLATED GN 2113-1291-0
1904 1P RCA RD GOLD PLATED GN 2113-1292-0
1905 PHONE JACK 2113-1011-0
1906 1P DIN CONN. W/G PLATE 2113-1685-0
J4101A CONN.ASSY 13PIN P2.5 7713-1320-2004

CAPACITORS

C4101, C4102 CC 50V 100pF 5% RL 5x3.5 150F-101J-5-IF
C4103 CE 50V 2.2µF 10% RL 4X7 157F-225K-5-GM
C4105, C4106 CC 50V 1000pF 10% RL 5x3 150F-102K-5-IF
C4110, C4111 CE 50V 2.2µF 10% RL 4X7 157F-225K-5-GM

RESISTORS

R4101, R4102 RMF 1/8W 330R 1% AT 4711-331A-2
R4103, R4107, R4108 RMF 1/8W 82R 1% AT 4711-820A-2

ASSEMBLY

PCB MAIN/AMP1/AMP2/LOAD 1725-305A-0003

AL ASSEMBLY

DIGIT

- 17 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

DIG ASSEMBLY PCB-A0201C-DIG

PC BOARD

PCB MAIN/AMP1/AMP2/LOAD 1725-305A-0003

WAFERS / JACKS

1602 LIGHT RX UNIT GPIF32R 4811-F32R-3
1603, 1604 1P RCA JACK BK GOLD 2113-1806-0
1605 PHONE JACK D3.5 BK 2113-1179-0
J101B WAFER 10P P2.5 ST. 2102-101S-004
J713B 2P ST.WAFER 2102-021S-004

CAPACITORS

C763 CC 50V 0.1µF 10% AT 150F-104K-2-FC
C765 CC 50V 0.022µF 10% AT 150F-223K-2-FD

RESISTORS

R777, R778 RMF 1/8W 10K 1% AT 4711-103A-2

ASSEMBLY

MAIN

MAIN ASSEMBLY PCB-A0201C-MAIN

PCB BOARD

PCB MAIN/AMP1/AMP2/LOAD 1725-305A-0003

METAL MATERIALS

2302 TAPPING 3X8MM B-TITE 2954-3008-0000
2303 SCREWS BT 2.6X6 2954-2606-0000
2304 SOLDER TAG 4132-1061-0
2305 SCREW M3x8 PM BZ 2900-3008-3000
M701 HEATSINK 23.5X17X50 5400-1702-0
M702, M703 HEATSINK 5400-0831-0

UL2547 AWG26 BLACK L160MM 7010-2348-0
UL2547 AWG26 BLACK L100MM 7010-2349-0

CAPACITORS

C710 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II
C717 CE 25V 3300F 20% RL 157E-338M-5-5$
C718 CE 25V 1000µF 20% RL 157E-108M-5-X&
C720, C721 CC 50V 0.022µF 10% AT 150F-223K-2-FD
C722, C723 CE 25V 470µF 20% RL 85C 157E-477M-5-O4
C726 CE 50V 47µF 20% RL 157F-476M-5-LU
C727 CC 50V 0.022µF 10% AT 150F-223K-2-FD
C728 CE 50V 100µF 20% RL 8x12 157F-107M-5-OW
C730 CC 50V 0.022µF 10% AT 150F-223K-2-FD
C731 CC 50V 0.022µF 10% AT 150F-223K-2-FD
C732 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM
C734 CE 50V 47µF 20% RL 157F-476M-5-LU
C735 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C736 CC 50V 0.022µF 10% AT 150F-223K-2-FD
C741-C744 CE 10V 330µF 20% RL 8x12 157C-337M-5-OW
C745 CE 16V 1000µF 20% RL 157D-108M-5-S9
C748, C749 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM
C751, C752 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II
C753 CE 16V 1000µF 20% RL 157D-108M-5-S9

- 18 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

C757 CE 25V 22µF 20% RL 5X11 157E-226M-5-IUN
C758 CE 16V 1000µF 20% RL 157D-108M-5-S9
C931, C932 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II

DIODES

D715-D718 DIODE 1N5393 200V 1.5A 4805-3930-2
D719-D721 DIODE IN4004 AL 4804-0040-1
D722 DZ 1/2W 27V(26.2-27.6)AT 4837-27V0-2
D724, D725 DZ 1/2W 15V 5% TEMIC AT 4837-15V6-2
D726 DIODE 1N4148 ATS 4804-1480-C
D727 DZ 1/2W 5.0-5.2V AT 4837-4C20-2
D731-D734 DIODE 1N4148 ATS 4804-1480-C
J7159, J7160 DIODE 1N4001 AT 4804-0010-2

WAFERS

J201B, J202B 4P ST.WAFER 2102-041S-004
J206B FLEXIBLE CONN. 35P P1.25 2101-1591-0
J401B 13 PINS WAFER 2.5 PITCH 2102-131S-004
J502B WAFER (PCB/PCB) 10P P2.0 2101-1621-0
J7001 3 PIN ST. WAFER 2102-031S-004
J702B 7P PIN CONNECTOR P=3.96 2101-2041-0
J703A WAFER (PCB/PCB) 10P P2.0 2101-1621-0
J704A WAFER (PCB/PCB) 16P P2.0 2101-1641-0
J705A-J711A WAFER (PCB/PCB) 10P P2.0 2101-1621-0
J713A 2P ST.WAFER 2102-021S-004

TRANSISTORS

Q701, Q702 TR RN1241-A 4851-241A-5
Q703, Q704 TR DTA114ESA ROHM 485A-114E-5
Q724 TR 2SA1015 (G.R.) RL 4860-0660-5

RESISTORS

R769, R770 RMF 1/8W 56K 1% AT 4711-563A-2
R767, R768 RMF 1/8W 100R 1% AT 4711-101A-2
R731 RMF 1/8W 1K 1% AT 4711-102A-2
R757, R759 RMF 1/8W 10K 1% ATS 4711-103A-C
R764-R766 RMF 1/8W 100K 1% ATS 4711-104A-C
R756, R761 RMF 1/8W 3.3K 1% AT 4711-332A-2
R732 RMF 1/8W 33K 1% AT 4711-333A-2
R762, R763 RMF 1/8W 47R 1% AT 4711-470A-2
R741-R744 RMF 1/8W 4.7K 1% AT 4711-472A-2
R758 RMF 1/8W 47K 1% AT 4711-473A-2
R760 RMF 1/8W 47K 1% AT 4711-473A-2
J7120 RMF 1/4W 22R 1% AT 4715-220A-2
R755 RMF 1/2W 2.2R 5% AT 4717-2R2J-2
R751-R753 RMF 1W 0.22R 5% AT 4718-R22J-2
R771 RMF 1/8W 12K 5% AT 4711-123A-2
R772 RMF 1/8W 12K 5% AT 4711-123A-2
R773 RCF 1/4W 2K 5% ATS 4705-202J-C-M
R774 RMF 1/8W 4.7K 1% ATS 4711-472A-C

ICs

U721 IC 7812 12V REGULATOR 3130-2520-3
U722 IC UPC79M12HF REGULATOR 3130-3800-0
U723 IC NJM78M56FA 5.6V 3130-8190-0

- 19 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

U724 IC 7805 REG 5V 3130-2020-2
U725 IC 7AA HIGH SPEED OP AMP 3130-7430-0
U726 IC 74HC08 AND GATES(SOP) 3131-9110-0

POWER SUPPLY ASSEMBLY

6000 PCB ASSY POWER SUPPLY PCB-A0201C-PSU

PC BOARD

PCB AUDIO/VIDEO/PSU/TONE 1725-304A-0102

SWITCH

7001 SWITCH,110-220V DPDT 5200-3530-0

CAPACITORS

C758 CC 400V 0.01µF +-20% RL 8910-0091-0
C759 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C760 CE 25V 220µF 20% RL 157E-227M-5-PU

DIODES

D751 DIODE 1N4148 ATS 4804-1480-C
D752-D756 DIODE IN4004 AL 4804-0040-1

METAL MATERIALS

GND SOLDER TAG 4132-1061-0
M751, M752 FUSE HOLDER 4132-1011-0
M753 RELAY 12VDC,250VAC,10A 4500-0890-0
P753, P754 TERMINAL WRAP 4131-9321-0
J201A CN ASSY 4P P=2.5 L=200 7704-1200-2004

FUSES

M751 FU T1A 250V SEMKO/UDE 5120-0018-0
M752 FUSE T1.6A 250V 5X20MM 5120-0052-0

TRANSISTOR

Q751 TR DTC123JSA ROHM 485C-123J-5

RESISTORS

R754 RMF 1/2W 8.2R 5% AL 4717-8R2J-2-F
R758 RMF 1/2W 3.3M 5% AT UL 4717-335J-2-S

TRANSFORMER

T752 EI-35 TRANSFORMER GTP750 1806-2501-0

TUNER

10000 TUNER ASSEMBLY (CE) PCB-A0201C-TUNE

ASSEMBLY

PC BOARD

PCB AUDIO/VIDEO/PSU/TONE 1725-304A-0102

SOCKETS / JACKS

1002 6P RCA JACK R/W GOLD 2113-1805-0
1003 ANT-TERMINAL F-TYPE 2107-0641-0
J703B SOCKET (PCB/PCB) 10P 2101-1801-0

- 20 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

J704B SOCKET (PCB/PCB) 16P 2101-1601-0
P901 WAFER 2P ST. P=2.5 NH 2113-1160-0

CAPACITORS

C381-C386 CC 50V 100pF 10% AT 3.5x 150F-101K-2-FC
C901-C903 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C904 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C906 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU
C911 CC 50V 20pF 5% RL 4x4 150F-200J-5-GG
C912, C913 CC 50V 1000pF 10% RL 5x3 150F-102K-5-IF
C914, C915 CC 50V 100pF 5% RL 5x3.5 150F-101J-5-IF
C916 CC 50V 330pF 10% RL 4x3 150F-331K-5-GE
C924, C925 CTC 0/60 20pF 5% RL 4x4 15CH-200J-5-GG
C926 CM 50V 0.033µF 5% RL 7.5 153F-333J-5-NLM
C927 CE 50V 2.2µF 20% RL 4x7 157F-225M-5-GM
C928 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C929 CE 50V 0.22µF 20% RL 4x7 157F-224M-5-GM
C930 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C931 CE 6.3V 100µF 20% RL 6x7 157B-107M-5-KM
C932,C941 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C940 CC 50V 0.01µF 10% AT 3.5 150F-103K-2-FC
C942 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU
C943 CE 50V 2.2µF 20% RL 4x7 157F-225M-5-GM
C944 CE 50V 4.7µF 20% RL 4x7 157F-475M-5-GM
C945 CC 50V 100pF 5% RL 5x3.5 150F-101J-5-IF
C946 CE 50V 1µF 20% RL 4x7 157F-105M-5-GM
C947 CE 50V 0.47µF 20% RL 4x7 157F-474M-5-GM
C948 CE 50V 1µF 20% RL 4x7 157F-105M-5-GM
C949,C950 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C951 CE 50V 2.2µF 20% RL 4x7 157F-225M-5-GM
C953, C954 CM 50V 2700PF 5% RL 153F-272J-5-JM
C959, C960 CE 16V 22µF 20% RL 4X7 157D-226M-5-GM
C961, C962 CM 50V 1500pF 5% RL 6x12 153F-152J-5-KW
C963, C964 CE 16V 22µF 20% RL 4X7 157D-226M-5-GM
C965 CM 50V 2700PF 5% RL 153F-272J-5-JM
C967 CE 16V 0.47µF 20% RL 5x5 157D-474M-5-II
C968 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C969 CE 16V 47µF 20% RL 5X7 157D-476M-5-IM
C970 CM 50V 0.022µF 5% RL 153F-223J-5-LQ
C971 CTC 0/60 8pF 0.5pF RL 15CH-080D-5-GG
C973 CM 50V 0.047µF 5% RL 7.5 153F-473J-5-NLM
C974 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C975 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM
C976 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C977 CE 50V 2.2µF 20% RL 4x7 157F-225M-5-GM
C978 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C979 CE 16V 22µF 20% RL 4X7 157D-226M-5-GM
C981 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C982 CC 50V 100pF 5% RL 5x3.5 150F-101J-5-IF
C985 CC 50V 560pF 10% RL 4x4 150F-561K-5-GG
C986 CE 6.3V 100µF 20% RL 6x7 157B-107M-5-KM
C987 CC 50V 0.022µF +80/-20% 150F-223Z-5-UG
C988, C989 CTC 0/60 30pF 5% RL 5x4 15CH-300J-5-IG
C990 CE 6.3V 100µF 20% RL 6x7 157B-107M-5-KM
C991 CM 50V 1000PF 5% RL 5x7 153F-102J-5-IM

- 21 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

C992 CC 50V 0.01µF 10% RL 5x5 150F-103K-5-II
C995, C996 CM 50V 0.1µF 5% RL 153F-104J-5-PT

DIODES

D901 DZ 1/2W 5.0-5.2V AT 4837-4C20-2
D902 DZ 1/2W 9.1-9.5V AT 4837-7C20-2
D930 DIODE 1N4148 ATS 4804-1480-C

COILS

L901 COIL 22µH 10% AL BL7 1801-220K-M
L903, L904 COIL MPX LPF NMC-4085 5600-3386-S
L905 COIL 100UH 10% 1801-101K-M
L941 COIL FM DET-1 10.7MHZ 5600-3396-S
L942 COIL FM DET-2 10.7MHZ 5600-3406-S
L971 COIL MW RF BLOCK 5600-3280-G
L972 COIL AM IFT NMIF-4062 5600-3416-S
L985, R912 COIL 100µH 10% 1801-101K-M

TUNER

M901 TUNER ENV172D3G1 1300-0726-0

CRYSTALS

M905 CRYSTAL 7.2MHZ 20PPM 2300-0440-0
M985 CRYSTAL 4.332MHZ 2300-1220-0

CERAMIC FILTERS

M902, M904 CF10.7 +-30 SFE10.7MA5-A 2701-0010-1
M911 CF 450 +-1 SFZ450JL3 2701-0680-0

TRANSISTORS

Q901 TR 2SC945P HFE 200-400 485C-945P-5
Q902 TR 2SC1923-0 HFE 70-140 4851-9230-5
Q903 TR DTA114ESA ROHM 485A-114E-5
Q922, Q923 TR 2SC1740S 4860-1590-5
Q925-Q927 TR DTC144ES ROHM 485C-144E-5
Q930 TR 2SC1740S 4860-1590-5
Q931 TR 2SA1015 (G.R.) RL 4860-0660-5
Q932 TR N-JEET 2SK-363BL 4853-63BL-5
Q942 TR 2SC1740S 4860-1590-5
Q943, Q944 TR 2SD 1468 S 4860-8120-0
Q945 TR DTA114ESA ROHM 485A-114E-5

RESISTORS

R340 RMF 100K 1/8W 1% AT 4711-104A-2
R341 RMF 1/8W 330R 1% AT 4711-331A-2
R342 RMF 100K 1/8W 1% AT 4711-104A-2
R381 RMF 1/8W 330R 1% AT 4711-331A-2
R382 RMF 100K 1/8W 1% AT 4711-104A-2
R383 RMF 1/8W 330R 1% AT 4711-331A-2
R384 RMF 100K 1/8W 1% AT 4711-104A-2
R385 RMF 1/8W 330R 1% AT 4711-331A-2
R386 RMF 100K 1/8W 1% AT 4711-104A-2
R387 RMF 1/8W 330R 1% AT 4711-331A-2
R388 RMF 100K 1/8W 1% AT 4711-104A-2
R389 RMF 1/8W 330R 1% AT 4711-331A-2

- 22 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

R901 RMF 1/8W 33K 1% AT 4711-333A-2
R902 RMF 1/8W 22R 1% ATS 4711-220A-C
R903 RMF 1/8W 12K 1% AT 4711-123A-2
R904 RMF 1/8W 330R 1% AT 4711-331A-2
R905 RMF 1/8W 680R 1% ATS 4711-681A-C
R906 RMF 1/8W 10K 1% AT 4711-103A-2
R907 RMF 1/8W 3.3K 1% AT 4711-332A-2
R908 RMF 1/8W 470R 1% AT 4711-471A-2
R909, R910 RMF 1/8W 330R 1% AT 4711-331A-2
R911 RMF 1/8W 100R 1% AT 4711-101A-2
R913 RMF 1/8W 33R 1% AT 4711-330A-2
R915 RMF 1/8W 10K 1% AT 4711-103A-2
R916 RMF 1/8W 1K 1% AT 4711-102A-2
R918 RMF 1/8W 4.7K 1% AT 4711-472A-2
R919-R924 RMF 1/8W 1K 1% AT 4711-102A-2
R925, R926 RMF 1/8W 82R 1% AT 4711-820A-2
R927 RMF 1/8W 10K 1% AT 4711-103A-2
R928 RMF 1/8W 220R 1% AT 4711-221A-2
R929 RMF 1/8W 3.3K 1% AT 4711-332A-2
R931 RMF 1/8W 22R 1% ATS 4711-220A-C
R933 RMF 1/8W 10K 1% AT 4711-103A-2
R940 RMF 1/8W 10K 1% ATS 4711-103A-C
R941 SVR 22K H3 7X7.6 RH0615C 4756-2236-3-06
R942 RMF 1/8W 4.7K 1% AT 4711-472A-2
R943 RMF 1/8W 8.2K 1% AT 4711-822A-2
R944 RMF 100K 1/8W 1% AT 4711-104A-2
R945 RMF 1/8W 3.9K 1% AT 4711-392A-2
R946 RMF 1/8W 3.3K 1% AT 4711-332A-2
R947, R948 RMF 1/8W 10K 1% AT 4711-103A-2
R949 RMF 1/8W 3.3K 1% AT 4711-332A-2
R950 RMF 1/8W 680K 1% AT 4711-684A-2
R951 RMF 1/8W 1K 1% AT 4711-102A-2
R952, R953 RMF 1/8W 22K 1% AT 4711-223A-2
R954 RMF 1/8W 10K 1% AT 4711-103A-2
R955 RMF 1/8W 22R 1% ATS 4711-220A-C
R956 SVR 10K H3 7X7.6 RH0615C 4756-1036-3-06
R957, R958 RMF 1/8W 2.7K 1% AT 4711-272A-2
R959, R960 RMF 1/8W 330K 1% AT 4711-334A-2
R961, R962 RMF 1/8W 2.2K 1% AT 4711-222A-2
R963, R964 RMF 100K 1/8W 1% AT 4711-104A-2
R968 RMF 1/8W 1K 1% AT 4711-102A-2
R970 RMF 1/8W 100K 1% ATS 4711-104A-C
R972 RMF 1/8W 10K 1% AT 4711-103A-2
R973 RMF 1/8W 18K 1% AT 4711-183A-2
R974 RMF 100K 1/8W 1% AT 4711-104A-2
R975 RMF 1/8W 56K 1% AT 4711-563A-2
R978, R979 RMF 1/8W 100K 1% ATS 4711-104A-C
R980 RMF 1/8W 1M 1% ATS 4711-105A-C
R981 RMF 1/8W 470R 1% ATS 4711-471A-C
R982, R983 RMF 1/8W 10K 1% AT 4711-103A-2
R985-R987 RMF 1/8W 1K 1% AT 4711-102A-2
R988 RMF 1/8W 12K 1% AT 4711-123A-2

ICs

U901 IC LA1837 AM/FM IF 3130-8180-0

- 23 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

U903 IC LC7218 PLL FREQ 3131-3760-0
U902 IC LC72723M RDS 3131-9040-0

CASING ASSEMBLY

0101 FRONT PANEL A0200C 1403-6440-0
0102 SUB-FASCIA A0200C 1403-6450-0
0104 CHASSIS GTP-830 CE 1403-6471-0
0105 TOP COVER A0200C 1403-6480-0
0103 REAR PANEL GTP830 CE 1403-6730-0
0302 HIGH TEMP TAPE W=12 0 1635-0110-0
0181 TOROIDAL X'FORMER I/P 1806-2416-1
0155 AC INLET (PCB MOUNT) 2113-1345-0
0115 POWER KNOB 2438-8301-0
0116 POWER KNOB HOLDER 2438-8401-0
0117 POWER KNOB-LED CAP 2438-8501-0
0124 KNOB SPACER 2441-9500-0
0119 FUNCTION KNOB W/O LIGHT 2441-9600-0
0118 FUNCTION KNOB W/ LIGHT 2441-9700-0
0114 VOLUME KNOB 2444-4001-0

KNOB VOLUME GTP830 2444-4001-1
VOLUME KNOB CAP BLACK 4135-1311-0
VOLUME KNOB CAP.COLOUR: 4134-2631-0

VOLUME KNOB INSERT 4152-7370-0
0120 SPRING 2510-2031-0
0163 M9 WASHER BK ZINC 2600-9005-1403
0167 FIBRE WASHER 2601-3004-0801

SPRING WASHER 2607-3007-0550
0182 M3 NUT 2640-3022-0540
0183 M3 NUT 2640-3022-0540
0190 HEXAGON NUT M12X2.0X14.3 2640-C020-1434
0133 METAL WASHER 2842-3367-0
0159 SCREW M3X6 PAN HEAD 2900-3006-0000
0127 SCREW M3X6 2904-3006-0000
0189 SCREW M3X6 BINDING (BLK) 2904-3006-3000
0136 M3X8MM BINDING HEAD 2904-3008-0000
0154 SCREW M3X8 (BLK) 2904-3008-3000
0132 M3X8 C'SINK B-TITE FH,BK 2951-3008-3000
0131 SCREW B-TITE FLAT-CS M3X 2951-3010-3000

SCREW BT 2.6X8 BLACK 2954-2608-3000
0162 3X6MM B-TITE (YEL.ZN) 2954-3006-0000
0137 T3X8MM SELF TAPPING 2954-3008-3000
0201 PC SHEET 50X7X0.25 3100-5101-0
LED LED DUAL COLORS 3700-2500-RG
0121 POWER KNOB LENS 1 3714-4906-0
0123 REMOTE LENS 3715-4506-0
0122 LENS BUTTON ACTUATOR 3715-4800-0
0107 LENS W/SS GTP830 3716-5810-0

ANTENNA WASHER 4131-7701-0
0166 ANTENNA WASHER 4131-7701-0
0126 BRACKET AC3 BOARD T-760 4134-9041-0
0156 POWER SWITCH HOLDER 4135-0561-0
0180 SUPPORT, PHONE JACK 4135-1251-0
0181 BAFFLE, DIN JACK 4135-1261-0
0099 BRACKET 4135-1351-0

- 24 -

PARTS LIST GTP-830

REF NO. DESCRIPTION PART NO.

CUSHION 130X10X1MM 4151-9411-0
0202 CUSHION 130X10X1MM 4151-9411-0
0160 L-BRACKET 4152-0451-0
0125 PLASTIC FOOT 4152-0481-0
0188 RUBBER PIN 4152-0501-0
0106 LCD HOLDER A0200C 4154-1621-0
0108 TONE KNOB A0200C 4154-1641-0
0109 TONE KNOB HOLDER A0200C 4154-1651-0
0110 FUNCTION KNOB A0200C 4154-1661-0
0112 CAMCORDER A0200C 4154-1671-0
0113 CAMCORDER LID A0200C 4154-1681-0
0191 LEE FILTER #180 DARK 4154-3261-0
0301 PLASTIC CABLE TIE (BLK) 6360-0012-0
J713 CONN ASSY 2P P2.5 L=140 7010-1490-0
J206 FLEXIBLE CABLE 35P L220 7010-1660-0
J601 CONN.ASSY 12PIN 7010-2291-0
J101 CONN. SH. ASSY 10P P2.5 7012-5030-0
J604 CONN. SH. ASSY 3P P2.5 7012-5040-0
J203 FLEXIBLE CABLE 35P L110 7012-5050-0
J605 CONN. SH ASSY 10P P2.5 7012-5390-0

PACKING ASSEMBLY

0168 CARTON GTP-830 1435-5100-0-3
PACK CARTON SHT-PALLET 1450-1351-0
PACK ANGLE BOARD (L=1000MM) 0. 1450-1891-0
PACK PAPER PALLET (1200X1100X 0.0 1450-7350-0

POLYFORM 1490-3633-0
PACK POLYBAG 240X100X0.05X5 1497-0152-0
PACK POLYBAG 260X130X0.1 1497-0672-0
PACK POLYBAG 255X180X0.1X8 1497-1312-0
0171 POLYBAG 1497-1332-1
0173 300-OHM T ANTENNA 2107-0661-1
0174 AM LOOP ANTENNA 2113-1155-0
PACK DATE CODE LABEL 3000-3544-0
0175 SERIAL NUMBER LABEL FOR 3000-4861-0

RIBBON 60MMX300M 3005-0360-1

MODEL LABEL SET,BLANK 3005-0512-0
PACK LABEL "MADE IN PRC" 3000-9034-0
PACK CAMCORDER LID A0200C 4154-1681-0
PACK RCA CABLE YEL AU L=1.0M 7010-2010-0
PACK RCA CABLE W/R AU L=1.0M 7010-2020-0
PACK STRETCH FILM W=450 THK=0 3. 9500-1010-0

- 25 -

WIRING DIAGRAM GTP-830

J711B

J707B

AUDIO PCB

J708B

VIDEO PCB

J710B

J709B

S-VIDEO PCB

J713A

J703A

J707A

J710A

J708A

J711A

J709A

J703B

TUNER PCB

J502A

MULTI-CHANNEL PCB

J502B

J201B

J7188

J704A

J705A

J7211

MAIN PCB

J7001

J702B

J706A

J704B

J705B

J202B

J706B

J206B

J401B

J604A

SHOWN THE WAFERS

SHOWN THE SOLDER

END OF HARNESS

NOTES:

J605A

WIRE HARNESS

SHOWN THE PIN 1 OF

J605B

J206A

J202A

KEY BOARD

TONE PCB

J713B

DIGITAL PCB

J101B

SOCKET PCB

J201A

PSU PCB

751-1,2,3

754

753

- 26 -

J604B

AC3 BOARD

J203A

J401A

J101A

SWITCH PCB

J203A

J207

LED

J401A

PHONE&VIDEO5 PCB

PCB LAYOUT GTP-830

TUNER BOARD

- 27 -

PCB LAYOUT GTP-830

AUDIO BOARD

VIDEO BOARD

- 28 -

PCB LAYOUT GTP-830

PHONE&VIDEO5 BOARD

S-VIDEO BOARD

TONE BOARD

- 29 -

PCB LAYOUT GTP-830

AC3/DTS BOARD - Top View

- 30 -

PCB LAYOUT GTP-830

AC3/DTS BOARD - Bottom View

- 31 -

PCB LAYOUT GTP-830

MAIN BOARD

- 32 -

PCB LAYOUT GTP-830

MULTI-CHANNEL BOARD

PSU BOARD

SOCKET BOARD

DIGITAL BOARD

SWITCH BOARD

- 34 -- 33 -

PCB LAYOUT GTP-830

KEY BOARD - Top View

KEY BOARD - Bottom View

- 35 - - 36 -

SCHEMATIC DIAGRAMS GTP-830

AC3/DTS

- 38 -- 37 -

SCHEMATIC DIAGRAMS GTP-830

TUNER

- 39 - - 40 -

SCHEMATIC DIAGRAMS GTP-830

MULTI-CHANNEL

- 42 -- 41 -

SCHEMATIC DIAGRAMS GTP-830

S-VIDEO

- 43 - - 44 -

SCHEMATIC DIAGRAMS GTP-830

AUDIO

- 45 -

SCHEMATIC DIAGRAMS GTP-830

MAIN

- 46 -

SCHEMATIC DIAGRAMS GTP-830

KEY

- 47 -

SCHEMATIC DIAGRAMS GTP-830

PSU

- 48 -

IC BLOCK DIAGRAMS GTP-830

V

G

4

4

4

3

3

3

AC3/DTS BOARD
U101: 74HC153

AC3/DTS BOARD
U102: 74HC157

14

A

2

B

1

1G

6

1C0

5

1C1

4

1C2

3

1C3

15

2G

10

2C0

11

2C1

12

2C2

13

2C3

2

1A

3

1B

TG

TG

TG

TG

TG

TG

TG

TG

TG

TG

TG

TG

7

1Y

9

2Y

4

11G VCC16

2B 2G15

31C3 A14

41C2 2C313

51C1 2C212

61C0 2C111

71Y 2C010

8GND 2Y9

1Y

AC3/DTS BOARD
U103: CS5331A

AINL

AINR

AGND

5

2A

6

2B

11

3A

10

3B

14

4A

13

4B

15

G

1

A/B

Voltage Reference

8

+

-

S/H

5

+

-

S/H

6

7

LP Filter

DAC

LP Filter

DAC

+

-

Comparator

+

-

Comparator

7

2Y

9

3Y

12

4Y

MCLK SCLK LRCK

42 3

Serial Output Interface

Digital
Decimation
Filter

Digital
Decimation
Filter

High
Pass
Filter

High
Pass
Filter

1A/B

16

21A

15

31B

14

41Y

13

52A

12

62B

11

72Y

10

8GND

9

SD ATA

1

VA+

- 49 -

IC BLOCK DIAGRAMS GTP-830

AC3/DTS BOARD
U104, U109, U116,
U131, U134: 7AA

AMPLIFIER 1

OUTPUT

1

INVERTING

NON-INVERTING

INPUT

INPUT

2

3

4

V –

AC3/DTS BOARD
U105: CS4926

RESET

36 8-11,14-17 18 5 4 19 7 6 20 21

CMPDAT,

SDATAN2

CMPCLK,

SCLKN2

CMPREQ,

LRCLKN2

SCLKN1,

STCCLK2

LRCLKN1

SDATAN1

CLKSEL

CLK1N

27

28

29

25

26

22

30

31

Compressed
Data Input
Interface

Digital
Audio
Input
Interface

PLL
Clock Manager

AC3/DTS BOARD
U108: AT27C020-70

VCC(32)

AMPLIFIER 2

8

V +

7

+ – – +

OUTPUT

INVERTING

6

INPUT

NON-INVERTING

5

INPUT

DATA7-0,
EMAD7-0,
GPIO7-0

CS

RD,
R/W,
EMOE,
GPIO11

Framer
Shifter

Input
Buffer
Controller

RAM Input
Buffer

GND(16)

VPP(1)

OE(24)
CE(22)

PGM(31)

A0-A17

ADDRESS

INPUTS

(2-12, 25-30)

WR,
DS,
EMWR,
GPIO10

SCDIO,
SCDOUT,
PSEL,
GPIO9

OE, CE AND
PROGRAM LOGIC

Y DECODER

X DECODER

A0,
SCCLK

Parallel or Serial Host Interface

24-Bit
DSP Processing

RAM
Program
Memory
RAM
Program
Memory

RAM
Program
Memory
RAM
Program
Memory

STC

A1,
SCDIN

RAM
Output
Buffer

ABOOT,
INTREQ

EXTMEM,
GPIO8

Output
Formatter

DATA OUTPUTS

O0-O7

(13-15, 17-21)

OUTPUT
BUFFERS

Y-GATING

CELL MATRIX

IDENTIFICATION

37

DD

38

DC

44

MCLK

43

SCLK

42

LRCLK

41

AUDATA0

40

AUDATA1

39

AUDATA2

XMT958

3

32 33 34 35 2 13 24 1 12 23

FILT2 FILT1 VA AGND DGND[1-3] VD[1-3]

AC3/DTS BOARD
U106, U107: 74HC574

D0

DQ

CP

FF1

CP

OE

D1 D2 to D5

DQ

CP

FF2

Q0

Q1

- 50 -

D6

DQ

CP

FF7

D7

Q6

DQ

CP

FF8

Q7

IC BLOCK DIAGRAMS GTP-830

AC3/DTS BOARD
U110: CS8414

VD+ DGND VA+ VA+ FILT AGND MCK M3 M3 M2 M1 M0

RXP

RXN

9

10

RS422
Receiver

CS12/FCK SEL C0/E0 Ca/E1 Cb/E2 Cc/F0 Cd/F1 Ce/F2 REF CBL

AC3/DTS BOARD
U111-U113: CS4340

SCLK/DEM1

Clock & Data

Recovery

Mux

13 16 6 5 4 3 2 27 25 15

Mux

De-Mux

MUTECDEM0

Audio
Serial
Port

Registers

232418171921202287

26

SD ATA

SCK

12

FSYNC

11

1

C

14

U

VERF

28

RST

LRCK

SD ATA

AC3/DTS BOARD
U114: 74HCU04

11A 14 VAC

21Y 13 6A

32A 12 6Y

42Y 11 5A

53A 10 5Y

63Y 94A

De-emphasis

Interpolation
Filter

Interpolation
Filter

DIF0 DIF1 MCLK

External
Mute Control

DAC

DAC

Analog Filter

Analog Filter

AC3/DTS BOARD
U118, U119: 74HC00

A1

1

2

B1

3

Y1

4

A2

B2

5

AOUTL

AOUTR

VCC

14

B4

13

A4

12

Y4

11

B3

10

7GND 84Y

- 51 -

Y2

GND

6

7

A3

9

Y3

8

IC BLOCK DIAGRAMS GTP-830

AC3/DTS BOARD
U115, U117, U120: 74HC74

7

GND

SD

1SD

4

AUDIO BOARD
U301: TC9273N-004

V

SS

1

2S1

3S2 26 S2

4S3 25 S3

5S4 24 S4

6S5 23 S5

7S6 22 S6

8S7 21 S7

9S8 20 S8

10S9 19 S9

11S10 18 S10

12S11

LEVEL SHIFT + SHIFT RESISTER

(L-ch)

10bit

Latch

Circuit

CIRCUIT

V

DD

26

(R-ch)

10bit

Latch

Circuit

(Same

as L-ch

Circuit)

5

1Q

1D

2

6

1Q

Q

Q

FF1

RD

D

CP

1CP

3

1RD1

10

2SD

9

2Q

SD

Q

2D

12

8

2Q

Q

FF2

RD

D

CP

2CP

11

2RD

13

VCC

14

AUDIO BOARD
U302: HCF4053BT

16 V
15 Z
14 Z
13 Y
12 Y
11 S
10 S

9S

DD

B

A

1A

0A

A

B

C

Z

A

Y

1A

Y

0A

Z

B

Y

1B

27 S1

17 S11

1Y

1B

2Y

0B

3Y

1C

4Z

C

5Z

0C

6E
7V

EE

8V

SS

S

A

S

B

LEVEL

CONVERTER

13

GND14CK

AUDIO BOARD
U303: 7AA

AMPLIFIER 1

OUTPUT

1

INVERTING

NON-INVERTING

INPUT

INPUT

2

3

4

V –

15

DATA16RESISTER

AMPLIFIER 2

8

V +

7

+ – – +

OUTPUT

INVERTING

6

INPUT

NON-INVERTING

5

INPUT

S

C

E

- 52 -

Y

0B

Z

C

Y

1C

Y

0C

IC BLOCK DIAGRAMS GTP-830

KEY BOARD
U201: LC87F65C8A

PLA

Flash ROM

IR

CF

Interrupt Control

Stand-by Control

KEY BOARD
U202: EEPROM 24C02

PC

RC

Generator
Clock

X'tal

ACC

B Register

Port 0S100

Bus Interface

C Register

Port 1S101

Port 3Timer 0

ALU

Port 7Timer 1

PSW

Port 8Base Timer

RAR

RAM

ADCVFD Controller

Weak

Signal

Detector

INTO-3

Noise rejection

Filter

Stack Pointer

Watch Dog Timer

VCC

VSS

SDA

WP

SCL

A0
A1
A2

VCCA0 81

WPA1 72

SCLA2 63

SDAVSS 54

STATE COUNTERS

SLAVE
ADDRESS
COMPERATORS

DOUT
ACK

WORD ADDRESS
BUFFERS

START/STOP
LOGIC

CONTROL
LOGIC

SENSE AMPS
SHIFT REGISTERS

XDEC

DATA IN STORAGE

HIGH VOLTAGE/
TIMING CONTROL

COLUMN
DECODERS

2

E

PROM

- 53 -

IC BLOCK DIAGRAMS GTP-830

KEY BOARD
U203, U204: 4094

1STR

2D 15 EO

3CP 14 O

4O

0

5O

1

6O

2

7O

3

8V

ss

16 V

13 O

12 O

11 O

10 Os'

9O

DD

4

5

6

7

s

CP

STR

STAGE 0 STAGES 1 TO 6

D

DO O

FF

CP

1

DO

CP

latch

D

CP

STAGE 7

DO

FF

CP

8

DO

CP

latch

DO

CP

latch

O

Os'

s

D

CP

O

MULTI-CHANNEL BOARD
U602: TC9164AN

10L-S7 19 R-S7

11L-S8 18 R-S8

12L-COM3 17 R-COM3

13L-ST 16 DATA

EO

14

O1O2O3O4O5O

6

27 R-S1

O

0

GND28VDD

VSS

1

2L-S1

3L-S2 26 R-S2

4L-S3 25 R-S3

5L-S4 24 R-S4

6L-COM1 23 R-COM1

7L-S5 22 R-S5

8L-S6 21 R-S6

LATCH CIRCUIT

LEVEL SHIFTER

LATCH CIRCUIT

LEVEL SHIFTER

9L-COM2 20 R-COM2

SHIFT REGISTER

15 CK

O

7

MULTI-CHANNEL BOARD
U618: TC9260P

L-ch

Volume

A-GND

OUT

LD1

LD2

CS

CK

V

SS

1

2

3

IN

4

5

6

7

8

L-ch

LATCH

DATA DECODER STB GENERATOR

SHIFT REGISTER (16 Bit)

V

DD

16

R-ch

LATCH

15

14

13

12

11

10

9

OUT

IN

LD1

LD2

A-GND

STB

DATA

R-ch
Volume

- 54 -

IC BLOCK DIAGRAMS GTP-830

MULTI-CHANNEL BOARD
U601: M62447SP

O/P
PORT

VOLUME

VOLUME

VOLUME

VOLUME

VOLUME

VOLUME

MCU

I/F

MULTI-CHANNEL BOARD
U605-U611, U620-U625: 7AA

42 DVDD1OUT4

41 CLK2OUT3

40 DATA3OUT2

39 LATCH4OUT1

38 DGND5AVDD

37 AGND6SWin

OUTPUT

INVERTING

INPUT

NON-INVERTING

INPUT

V –

1

2

+ – – +

3

4

36 SWout7GNDS

35 SRout8SRin

34 SLout9SLin

AMPLIFIER 1

33 Cout10GNDG

32 Rout11Cin

S-VIDEO BOARD & VIDEO
U402, U403, U404: BA7625

31 Lout12GNDR1

30 AVSS113GNDR2

29 AVSS214GNDL1

28 NC15GNDL2

27 NC16Rin

26 NC17GNDLR

25 NC18Lin

24 NC19NC

23 NC20NC

22 NC21NC

1MONITOR OUT 16 IN1

2GND 15 CTL A

3IN5 14 VOUT1

6dB

LOGIC

4GND 13 VCC

5IN4 12 IN2

6CTL E 11 CTL B

6dB

LOGIC

7INT3 10 VOUT 2

8CTL D 9 CTL C

AMPLIFIER 2

8

V +

7

OUTPUT

INVERTING

6

INPUT

NON-INVERTING

5

INPUT

S-VIDEO BOARD
U401: LC74763-9012

8CS

Serial

9SIN

Parallel
Converter

10SCLK

15RST

11SECAM

Composite

12525/625

Synchron­ization

13NTSC/PAL

Singal
Control

143.58/4.42

30VDD1

17VDD2

22VSS

29SYNCDET

27VCOIN
28VCOOUT
26FC

AFC

24AMPIN

Circuit
25AMPOUT
23PDOUT

20SYNIN

Sync
Separator

21SEPC

8-bit Latch
and
Command
decoder

Sync
Separator

Horizontal
Display
Position
Detection

4

HSYNOUT

VSYNOUT

7

Horizontal
Character
Size Register

Horizontal
Size
Counter

Timing Generator

Vertical
Character
Size Register

Vertical
Size
Counter

2

XTALIN1

Horizontal
Display
Position
Register

Horizontal
Dot
Counter

Horizontal
Display
Position
Detection

Character
Control
Counter

Synchronization
Signal Generator

3

XTALOUT1

Vertical
Display
Position
Register

Vertical
Dot
Counter

Vertical
Display
Position
Detection

Line
Control
Counter

5

XTALIN2

6

XTALOUT2

Flashing/
Reversal
Control
Register

Flashing/
Reversal
Control
Circuit

Character Output Control
Background Control
Video Output Control

19

CVCR

Display
Control
Register

18

CVIN

16

CVOUT

RAM Write
Address
Counter

Decoder

Dispaly
RAM

Decoder

Font
RAM

Shift Register

- 55 -

IC BLOCK DIAGRAMS GTP-830

MAIN BOARD
U723: NJM78M56FA

1

INPUT

2

GND

TUNER BOARD
U901: LA1837

3

OUTPUT

MAIN BOARD
U725: 7AA

AMPLIFIER 1

OUTPUT

INVERTING

NON-INVERTING

INPUT

INPUT

V –

1

2

3

4

AMPLIFIER 2

8

V +

7

OUTPUT

+ – – +

INVERTING

6

INPUT

NON-INVERTING

5

INPUT

FM SD

ADJ

OSC

REG

AM RF

INPUT

AFC

AM AGC

AM DETECTOR

INPUT

FM DETECTOR

OUTPUT

MPX

IUTPUT

MPX

OUTPUT

MPX

OUTPUT

AM STEREO L

INPUT

AM STEREO R

INPUT

30 29 28 27 26 25 24 23 22 21 20 19 18 17 16

P-DET

Ø

304kHz

3 rd 5 th

DECODER

ANTI-BIRIDE

STEREO

VCO

SW

FF

38k

FF

19k

MUTE

FF

19k

ALC

BUFF

FM

S-METER

AM IF

AM

OSC

SD

COMP

S-CURVE

FM

DET

REG

AM
MIXAMRF.AMP

AM IF

AM

S-METER

AM/FM

IF-BUFF

AGC

DET

GND

TUNING

DRIVE

STEREO

DRIVE

V

CC

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

CC

V

ST LED

AM-IF OUTPUT

FM DETECTOR

OUTPUT

FM S-METER

AM NARROW CF

OUTPUT

AM S-METER

MUTE

AM MIXER

FM IF INPUT

OUTPUT

BYPASS

FM IF INPUT

GND

TU-LED

AM IF INPUT

L-OUT

FM/AM

SWITCH

PILOT

DET

R-OUT

CO

PILOT V

- 56 -

IC BLOCK DIAGRAMS GTP-830

TUNER BOARD
U902: LC72723M

Vdda

Vssa

MPXIN

TEST

3

4

2

7

REFERENCE

VOLTAGE

ANTIALIASING

FILTER

TEST

V
1

REF

57kHz

BPF

(SCF)

FLOUT5CIN

6

V

REF

SMOOTHING

FILTER

CLK(4.332MHz)

OSC

9

X

IN

8
X

+

_

OUT

PLL

(57kHz)

CLOCK

RECOVERY

(1187.5Hz)

DATA

DECODER

RAM

(128bits)

RDS-ID

DETECT

Vddd
11

Vssd
10

RDDA
14

RDCL
15

MODE
12

RST
13

RDS-ID/READY
16

TUNER BOARD
U903: LC7218

XIN

XOUT

FMIN

AMIN

CE

DI

CL

D0

SYC

6

1

24

19

18

2

3

4

5

REFERENCE

DIVIDER

1

SWALLOW COUNTER

2

1/16, 1/17 4 BIT

12-BIT PROGRAMMABLE

SHIFT REGISTER

LATCH

PHASE DETECTOR

CHARGE PUMP

DIVIDER

UNIVERSAL

COUNTER

21

PD1

PD2

22

HCTR

16

15

LCTR

V

20

DD

23

V

SS

OUT0 OUT1

871714131211109

OUT2 OUT3 OUT4 OUT5 OUT6 IN0 IN1

- 57 -

TECHNICAL SPECIFICATIONS GTP-830

AM BAND SPECIFICATION

Frequency Range
USA 530 - 1710 KHz Step 10 KHz
CE 531 - 1602 KHz Step 9 KHz

Specification Details

1. Usable sensitivity 999 KHz dBµV ≤ 30
(400Hz, -20dB, direct input) / 1000 KHz

2. S/N RATIO 999 KHz dB ≥ 38
(5mV input) / 1000 KHz

3. THD (5mV input) 999 KHz % ≤ 3

4. IF Rejection (450KHz) 603 KHz dB ≥ 36
(ref. to item 8) / 600 KHz

5. Image Rejection (F+2xIF) 1404 KHz dB ≥ 25
(ref. to item 8) / 1400 KHz

6. Selectivity 999 KHz dB ≥ 17
(ref. to item 8) / 1000 KHz

7. Output 999 KHz mV 120 +/- 20
(30%, 100mV) / 1000 KHz

8. Loop sensitivity 20dB S/N 999 KHz/ 1000 KHz dB ≤ 66

Freq. Unit Limit

/ 1000 KHz

603 KHz/ 600 KHz dB ≤ 66
1422 KHz/ 1420 KHz dB ≤ 66

9. Frequency response 100 - 2.3KHz 999 KHz dB +/- 6
(400 Hz, 5mV) / 1000 KHz

FM BAND SPECIFICATION

Frequency Range
USA 87.5 - 108MHz Step 100 KHz
CE 87.5 - 108MHz Step 50 KHz

Specification Details

1. Usable sensitivity MONO 98MHz dBµ ≤ 15
IHF (3% THD)

2. S/N RATIO MONO 98MHz dB ≥ 72
(60dBu IHF wtd) STEREO 98MHz dB ≥ 66

3. TH MONO 98MHz % ≤ 0.25
(60dBu IHF wtd) STEREO 98MHz % ≤ 0.35
L = R, CE=40KHz Dev.

4. IF Rejection (10.7MHz) CE 98MHz dB ≥ 78
(refer to item 1) USA 98MHz dB ≥ 65

5. Image Rejection (119.4 MHz) UL 98MHz dB ≥ 40
(refer to item 1) CE dB ≥ 85

Freq. Unit Limit

- 58 -

TECHNICAL SPECIFICATIONS GTP-830

6. Capture ratio (40dBu) dB ≤ 3

7. AM Suppression 98MHz dB ≥ 48
@ 60dBu 100% mod FM, 30% mod AM

8. Pilot suppression L 98 MHz dB ≥ 60

R 98 MHz dB ≥ 60

9. Frequency response In between 20Hz & 15KHz dB 0 ± 1.5
( 1KHz Ref ) USA = 75uS, CE = 50uS

10. Channel Separation @ 100 Hz dB ≥ 30
(60dBu IHF wtd) 1KHz dB ≥ 40

10KHz dB ≥ 30

11. Alternate channel selectivity +/-400KHz, IHF CE dB ≥ 60

USA dB ≥ 45

12. Muting level dBu 18 +3/-3.

13. Output 98MHz USA mV 500 +/- 15%

CE mV 750 +/- 15%

14, RDS decode sensitivity CE dBu ≤ 26

15. Auto-search sensitivity OFF dBu ≤ 15

ON dBu ≥ 24

PREAMPLIFIER/VIDEO SECTION

Specification Details

1. THD, Input 500mV, Output 2 V, 20KHz LPF /Audio LPF
@Multi-ch in FL/C/FR 20Hz-20KHz % ≤ 0.01

SL/SR 20Hz-20KHz % ≤ 0.01

Input: SL and SR --------> SBL/SBR 20Hz-20KHz % ≤ 0.05

2. Input Sensitivity ,
[a] Video in: Input 1Vp-p 75 ohm Vp-p 1.0 +/- 0.1
[b] Multi-ch in: Max. Volume, Output 2V

FL/C/FR/SL/SR 1KHz mV 280 +/- 50
SBL/SBR 1KHz mV 360 +/- 50

Input: SL and SR--> SBL/SBR 1KHz mV 280 +/- 50

3. S/N Ratio (A-wtd, 1Kohm termination)
500mV multi-ch in FL/FR/C 1KHz dB ≥ -75
Output 1V SL/SR 1KHz dB ≥ -75

SBL/SBR 1KHz dB ≥ -75

Freq. Unit Limit

4. Frequency Response
500mV @multi-ch in, 1V (20KHz) 1 KHz dB +/-0.8
(FL/FR/C/SL/SR/SBL/SBR) (20Hz) dB +0.8, -2.5

5. Tone Control Response
bass (at 500mV in, 1V out) boost/cut 100Hz dB +/-2
treble (at 500mV in, 1V out) boost/cut 10KHz dB +/-2

- 59 -

TECHNICAL SPECIFICATIONS GTP-830

6. Channel Balance
output ref. item 1 1KHz dB ≤ 0.5
1dB to -40dB 1KHz dB ≤ 2

-41dB to -50dB 1KHz dB ≤ 3

7. Audio muting at Multi-ch, FL/FR 1KHz dB ≥ 53
ref to item 1.

8. Subwoofer out, 500mV input
THD at 2V output 100 Hz % ≤ 0.5
S/N at 2V output 100 Hz dB ≥ 78

9. Crosstalk (2V Input, 2V Output) 1KHz dB ≥ -68

10. Noise level mV ≤ 0.7
(EXT5.1 input, volume=05, Audio LPF)

GENERAL AUDIO SPECIFICATION - 1

Specification Details

1. Headphone output in 0.1% Vp-p 7 >6
CD IN 500mV in 1 KHz,
(600 ohm load, audio LPF)

Unit Normal Lim./Tol.

2. Headphone Freq. Response dB 0 + 0.8, -1.8
CD IN 500mV in 1 KHz for ref.
(2V output, 600 ohm load, audio LPF)
(20Hz - 20KHz)

3. Remote control ( 30º max) meter 7 5

GENERAL AUDIO SPECIFICATION - 2

DVD ( DOLBY 1.0)
Input source : Digital input

Specification Details

1. Output level ( volume at 0 dB ) at PRESET 1
FL, FR, C, SL, SR 30 mV 100 ± 30

2. Channel difference, FL set ref. 30 dB +/- 1.5
(FR, C, SL, SR) at preset 1.

3. Frequency response (set 30) SL. 46 (200-20KHz) dB ± 0.8
at preset 1 (set 30) SR. 47 (200-20KHz) dB ± 0.8

(set 30) C. 44 (200-20KHz) dB ± 0.8
(set 30Hz) LFE. 48 (20-80) dB ± 4.0

Track Unit Limit

4. Harmonic distortion 1V FL. 65 ( 997Hz ) % ≤ 0.08
( insert Audio LPF ) at preset 1. FR. 67 ( 997Hz ) % ≤ 0.08

SL. 68 ( 997Hz ) % ≤ 0.08
SR. 69 ( 997Hz ) % ≤ 0.08
C. 66 ( 997Hz ) % ≤ 0.08
LFE. 70 ( 30Hz ) % ≤ 0.08

- 60 -

TECHNICAL SPECIFICATIONS GTP-830

5. Signal to noise ratio (31 for output CCIR/ARM, dB ≥ 68
100mV and play 35 preset 1 and 2.) 200Hz Notch
(FL, FR, C, SL, SR) and 400Hz HPF.
or play 63 A-Wtd dB ≥ 65

6. Channel separation 1V out 65 (997Hz) dB ≥ 55
( insert 20KHz L.P.F.)

7. Output at multi-ch FL on preset 2 65, 70 dB 4.5 +/-2.0
0 dB(track 65), change to track 70
center and rear delay set to 0ms

GENERAL AUDIO SPECIFICATION - 3

DTS ( CD Music Demonstration and Set-up Disc)
Input source: Digital input
Output : 1V
Volume: 0 dB

Specification Details

1. Output level ( Volume 0dB) 6 (1kHz) mV 100 + 30
(FL, FR, C, SL, SR) at preset 1

2. Channel difference, FL set ref. 6 (1kHz) dB +/- 1.5
(FR, C, SL, SR) at preset 1.

3. Harmonic distortion (audio filter)
(FL, FR, C, SL, SR) at preset 1 10 - 14 (1kHz) % ≤ 0.08

4. Frequency response (20Hz to 20kHz)
(FL, FR, C, SL, SR) at preset 1 26 - 30 (20Hz) dB +0.8, -2.5

5. Subwoofer output level
(set 1kHz as ref at multi - ch FL
at preset 3 and check track 15) 10, 15 dB 0 ± 1.5
center and rear delay set to 0ms

Track Unit Limit

26 - 30 (20KHz) dB +/-0.8

SURROUND MODES

Input source: CD input
Surround mode: Prologic (FL, FR, C, SL, SR)

Specification Details

1. CHANNEL SEPARATION ( with 80K Hz LPF )
Input mode: L, R
input level=1V
output level=1V 1kHz dB R, L ≥ 45
measure output at unexpected 1kHz dB C ≥ 30
output channel 1kHz dB SL, SR ≥ 35

Input mode: L= -R
input level=1V 1kHz dB R, L ≥ 25
measure output at unexpected 1kHz dB C ≥ 30

Freq. Unit Channel Spec.

- 61 -

TECHNICAL SPECIFICATIONS GTP-830

Input mode : L= R
input level=1V
output level=1V 1kHz dB L, R ≥ 45
measure output at unexpected 1kHz dB SL, SR ≥ 30

2. FREQUENCY RESPONSE
Input mode: L, R
input level=1V, 1V output 40Hz dB L, R 0 ± 1.5
(1kHz ref.) 20kHz dB L, R 0 ± 0.8

Input mode: L=R
input level=1V, 1V 300Hz dB C 0 ± 0.8

20kHz dB C 0 ± 0.8
Input mode: L= -R
input level=1V, 1V 30Hz dB SL, SR 0 ± 1.0

6.5KHz dB -3 ± 1.0

3. THD
Input voltage 2.2V, 1V
w/ 80kHz LPF 1kHz % ≤ 0.2

4. S/N RATIO
Input level=2V, 2V output (A-WTD w/ 1k termination)
Input mode: L, R 1kHz dB L, R ≥ 65
Input mode: L=R 1kHz dB C ≥ 65
Input mode: L=-R 1kHz dB SL, SR ≥ 64

GENERAL ITEMS

1. Destination
USA 120V - 60 Hz
Europe 230V - 50 Hz

2. Operating voltage in range from AC voltage +10 / -10%

3. Dimensions width x height x depth : 432mm x 349mm x 132mm

4. Operating Temperature : -5 to +45 ºC.

5. Standard input FM 75 KHz Deviation

AM 30% Modulation
RDS 57KHz 2% Deviation
Pilot 9% Deviation

- 62 -

P/N: A0200C-SM00A 05/01