Adcom GTP-760 Service manual

Download

Page 1

SERVICE MANUAL

DTS/AC3 TUNER PRE-AMPLIFIER

GTP-760

TABLE OF CONTENTS

Alignment Procedures . . . . . . . . . . . . . . . . . . .2-3

Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-26

IC Block Diagram . . . . . . . . . . . . . . . . . . . . .27-40

Wiring Diagram . . . . . . . . . . . . . . . . . . . . . .41-42

PCB Layout . . . . . . . . . . . . . . . . . . . . . . . . .43-54

Schematic Diagram . . . . . . . . . . . . . . . . . . .55-68

Technical Specification . . . . . . . . . . . . . . . . .69-74

10 TIMBER LANE

MARLBORD

N.J. 07746, USA

PHONE: (732) 683-2356

FAX: (732) 683-2358

WEB: http://www.adcom.com

details you can hear

Page 2

ALIGNMENT PROCEDURES GTP-760

FM SECTION

AF Modulation: 1 kHz, 75kHz Deviation, MONO Mode Store Frequency: 98 MHz, 87.5 MHz, 108 MHz, 90 MHz, 106 MHz RF Level: 75-ohm Impedance, Open Circuit

OSCILLATION TUNING VOLTAGE

Connect DVM between M211 & GND. For A16 Front-end Module:

Tune to 87.5 MHz, adjust FE4 (osc coil) to read 3 ± 0.5 V. Tune to 108 MHz, adjust FE4 (osc coil) to read 20.5 ± 0.5 V.

For G55 or G58 Front-end Module:

Tune to 87.5 MHz, adjust FE4 (osc coil) to read 1.6 ± 0.5 V. Tune to 108 MHz, adjust FE4 (osc coil) to read 8.0 ± 0.5 V.

I.F.

Connect DVM between M213 & M214. Apply 10.7 MHz, 90 dBm via 1 kW resistor to M212. Adjust L208 for 0 ± 50mV reading on DVM. Adjust L209 for minimum distortion (THD). Repeat adjustment until no further improvement.

SYNTHESIZER I.F. TRACKING

Maintain connection of DVM across M213 & M214. Disconnect 10.7 MHz tap to M212. Apply 98 MHz, 60 dBm to antenna input. Tune to 98 MHz. Adjust C212 FOR 0 ± 20mV reading on DVM. Fine adjust L209 for minimum distortion. Repeat adjustment until no further improvement.

R.F.

Apply 98 MHz, 7 dBm for AH, or 21 dBm for C, to antenna input. Check THD. If THD > 3%, adjust FE1, FE2 & FE3 in the front-end module with non-metallic tool for minimum THD. Check THD at 90 MHz & 106 MHz with 8 dBm input for AH, or 22 dBm for C.

FM Stereo: 1 kHz, 67.5 kHz devi., 60 dBmV, Pilot signal 19 kHz, 7.5 kHz devi.

STEREO SEPARATION & PILOT SUPPRESSION

Set modulated signal to Left only. Adjust R263 for minimum output at right channel. Set modulated signal to Right only. Adjust R263 for minimum output at left channel. Repeat until readings are the same. Turn off modulating signal, leaving the pilot tone. Adjust L211 & L212 for minimum outputs on right and left channels respectively.

AM SECTION

AF Modulation: 400 Hz, 30%. For AH version, store frequencies 603, 999, 1404 kHz. For C & B versions, store frequencies 600, 1000, 1400 kHz. Connect 22 pF ceramic to capacitor between signal generator and antenna terminal.

Page 3

ALIGNMENT PROCEDURES GTP-760

OSCILLATION TUNING VOLTAGE

Connect DVM between M211 & GND. Tune to 603/600 kHz. Adjust L205 for 1.75 ± 0.05 V reading on DVM.

I.F.

Apply 999/1000 kHz, set 45 dBm to antenna input. Tune to 999/1000 kHz. Adjust L207 for maximum output.

R.F.

Apply 603/600 kHz, 45 dBm. tune to 603/600 kHz. Adjust L206 for maximum output. Apply 1404/1400 kHz, 45 dBm. Adjust C220 for maximum output. Repeat until no further improvement.

Page 4

TUNER ASSEMBLY

PC BOARD

* AH TUNER ASSEMBLY A0150C PCB-A0150C-TUN * C TUNER ASSEMBLY A0151C PCB-A0151C-TUN

PCB

1601 PCB TUNER 1722-890A-0102

WIRE

ANT. RF COAXIAL WIRE 100MM 8612-1000-0 COP.SI *C RF COAXIAL WIRE 100MM 8612-1000-0

CAPACITORS

C201 CE 50V 0.47µF 20% RL 5x11 157F-474M-5-IU C202 CC 50V 1000pF 10% RL 5x3.5 150F-102K-5-IF C203,C204 CC 50V 0.01µF 10% RL 11x11 150F-103K-5-UU C205 CE 35V 0.47µF 20% RL 5x11 157Q-474M-5-IU C206 CC 50V 100pF 10% RL 5x3.5 150F-101K-5-IF C207 CE 50V 3.3µF 20% RL 5x11 157F-335M-5-IU C208,C209 CE 50V 100µF 20% RL 8x12 157F-107M-5-OW C210 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C211 CC 50V 22pF 10% RL 4x4 150F-220K-5-GG C212 TRIMCAP 5.2-30P TZ03R300FR MUR 1551-0210-0 C213-C219 CC 50V 0.01µF 10% RL 11x11 150F-103K-5-UU C220 TRIMCAP 5.2-30P TZ03R300FR MUR 1551-0210-0 C221 CC 25V 0.022µF 10% RL 7x4 150E-223K-5-MG C222 CC 50V 22pF 10% RL 4x4 150F-220K-5-GG C223 CC 50V 470pF 10% RL 9.5x4 150F-471K-5-RG C224,C225 CC 25V 0.047µF 10% RL 8x4 150E-473K-5-OG C226 CC 50V 0.01µF 10% RL 11x11 150F-103K-5-UU C227,C228 CC 50V 100pF 10% RL 5x3.5 150F-101K-5-IF C229 CC 25V 0.047µF 10% RL 8x4 150E-473K-5-OG C230 CE 16V 10µF 20% RL 5x11 157D-106M-5-IU C231 CE 50V 4.7µF 20% RL 5x11 157F-475M-5-IU C232 CE 50V 3.3µF 20% RL 5x11 157F-335M-5-IU C233 CC 25V 0.047µF 10% RL 8x4 150E-473K-5-OG C234 CC 25V 0.022µF 10% RL 7x4 150E-223K-5-MG C235 CC 25V 0.047µF 10% RL 8x4 150E-473K-5-OG C236 CC 50V 47pF 5% RL 5x3.5 150F-470J-5-IF C237 CC 25V 0.047µF 10% RL 8x4 150E-473K-5-OG C238 CC 50V 100pF 10% RL 5x3.5 150F-101K-5-IF C239 CE 50V 3.3µF 20% RL 5x11 157F-335M-5-IU C240 CP 50V 100pF 5% RL 6x12 158F-101J-5-KW C241 CC 25V 0.022µF 10% RL 7x4 150E-223K-5-MG C242 CE 16V 100µF 20% RL 6x12 157D-107M-5-KW C243 CE 16V 10µF 20% RL 5x11 157D-106M-5-IU C244 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C245 CC 50V 0.01µF 10% RL 11x11 150F-103K-5-UU C245/CHA CC 50V 0.01µF 10% RL 5x5 150F-103K-5-II C246 CE 16V 100µF 20% RL 6x12 157D-107M-5-KW C247 CE 50V 1µF 20% RL 5x11 157F-105M-5-IU C248 CE 50V 0.22µF 20% RL 5x11 157F-224M-5-IU C249,C250 CE 50V 1µF 20% RL 5x11 157F-105M-5-IU C251 CC 25V 0.047µF 10% RL 8x4 150E-473K-5-OG C252 CP 50V 390pF 5% RL 6x12 158F-391J-5-KW C253 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU C254 CE 50V 0.1µF 20% RL 5x11 157F-104M-5-IU C255,C256 CE 16V 10µF 20% RL 5x11 157D-106M-5-IU C257,C258 *AH CP 50V 390pF 5% RL 6x12 158F-391J-5-KW C257,C258 *C CP 50V 270pF 5% RL 6x12 158F-271J-5-KW C259,C260 CE 16V 10µF 20% RL 5x11 157D-106M-5-IU C261,C262 CM 50V 1500pF 5% RL 6x12 153F-152J-5-KW C263 CC 50V 0.01µF 10% RL 5x5 150F-103K-5-II C264 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C265 CC 50V 0.01µF 10% RL 5x5 150F-103K-5-II C266 CC 50V 100pF 10% RL 5x3.5 150F-101K-5-IF C267 CC 50V 33pF 5% RL 4x4 150F-330J-5-GG C268 *C CC 50V 2pF 0.25pF RL 4x4 150F-020C-5-GG J202(1)/GND CC 50V 0.01µF 10% RL 11x11 150F-103K-5-UU

PARTS LIST GTP-760

REF NO. DESCRIPTION PART NO.

Page 5

PARTS LIST GTP-760

DIODES

D201 GERMANIUM DIODE 1N60P AL 4801-N60P-1 D202 GERMANIUM DIODE 1N60P AL 4801-N60P-1 D203,D204 SVC321-D AM CAR. DIODE 484C-321D-5 D205 DIODE 1N4148 ATS 4804-1480-C D206 *AH DIODE 1N4148 ATS 4804-1480-C

WAFERS

J201 9-PIN WAFER 2102-091S-004 J202 5P ST.WAFER P=2.5 COULOMB 2102-051S-004 J204 3 PIN ST. WAFER P=2.5 COULOMB 2102-031S-004

CONNECTOR

J206 *C DIN CONNECTOR FOR ANT 2113-1191-0

SOLDER TAG

J202(1)/GND *AH SOLDER TAG 4132-1061-0 TUN *C SOLDER TAG 4132-1061-0

COILS

L201 COIL 2.2µH 20% AL BL7 1801-2R2M-M L203 COIL 2.2µH 20% AL BL7 1801-2R2M-M L204 COIL 68µH 20% BL7 1801-680M-M L205 AM OSC COIL 5564312800 5600-2286-S L206 AM COIL 5564102600 5600-2276-S L207 AMZFT COIL (5565105200) 5600-2246-S L208 FM COIL PRIMARY (5565204300) 5600-2256-S L209 FM COIL SECONDARY (5565204400) 5600-2266-S L210 AM OSC COIL 5600-2296-S L211 19KHZ FILTER COIL 5600-2236-S L212 19KHZ FILTER COIL 5600-2236-S

FILTER

L202 *C BAND PASS FILTER 2701-0609-4

TRANSFORMER

L213 BALUN TRANSFORMER 300 TO 75 OHM 1806-2201-0

MODULE

M201 *AH TUNER MODULE MITSUMIFE407-A16 8910-0034-0 M201 *C FM TUNER MODULE 1300-0606-0

CERAMIC FILTERS

M202-M204 *AH CERAMIC FILTER 10.7MHZ 7ML-A 2701-0546-1-0 M202-M204 *C CF 10.7MHz SFE 10.7 MZ2 2701-0556-1-0 M205 CF 450.5+-1 SFZ450G3LI 2701-0066-0

CRYSTALS

M206 CRYSTAL 7.2MHZ 20PPM 2300-0440-0 M207 CR RESONATOR CSB 456FH 2703-0020-0

TERMINALS J205 PUSH TERMINAL 4P BK/BK/BK/BK 2113-1175-0 M211-M214 TERMINAL PIN 4132-1071-0

TRANSISTORS

Q201-Q203 TR 2SC1815 (G.R) RL 4860-0700-5 Q204 TR 2SC930E HFE 100-200 485C-930E-5 Q205 TR 2SC930E HFE 100-200 485C-930E-5 Q206-Q208 TR 2SC930E HFE 100-200 485C-930E-5 Q209 TR 2SA1015 (G.R.) RL 4860-0660-5 Q210-Q212 TR 2SC1815 (G.R) RL 4860-0700-5 Q213 TR 2SA1015 (G.R.) RL 4860-0660-5

RESISTORS

R201 RMF 1/4W 39K 1% AT 4715-393A-2 R202 RMF 1/4W 20K 1% AT 4715-203A-2 R203 RMF 1/4W 4.7K 1% AT 4715-472A-2 R204 RMF 1/4W 100K 1% AT 4715-104A-2

REF NO. DESCRIPTION PART NO.

Page 6

PARTS LIST GTP-760

R205 RMF 1/4W 4.7K 1% AT 4715-472A-2 R206 RMF 1/4W 2.2K 1% AT 4715-222A-2 R207 RMF 1/4W 10K 1% AT 4715-103A-2 R208 RMF 1/4W 100R 1% AT 4715-101A-2 R209 RMF 1/4W 150K 1% AT 4715-154A-2 R210 RMF 1/4W 10K 1% AT 4715-103A-2 R211 RMF 1/4W 390R 1% AT 4715-391A-2 R212 RMF 1/4W 220R 1% AT 4715-221A-2 R213 *AH RMF 1/4W 75R 1% AT 4715-750A-2 R213 *C RMF 1/4W 39R 1% AT 4715-390A-2 R214 RMF 1/4W 680R 1% AT 4715-681A-2 R215,R216 RMF 1/4W 330R 1% AT 4715-331A-2 R217 RMF 1/4W 680R 1% AT 4715-681A-2 R218 RMF 1/4W 75R 1% AT 4715-750A-2 R219 *AH RMF 1/4W 750R 1% AT 4715-751A-2 R219 *C RMF 1/4W 1.5K 1% AT 4715-152A-2 R220 RMF 1/4W 510R 1% AT 4715-511A-2 R221 RMF 1/4W 1K 1% AT 4715-102A-2 R222 RMF 1/4W 22R 1% AT 4715-220A-2 R223,R224 RMF 1/4W 330R 1% AT 4715-331A-2 R225 RMF 1/4W 680R 1% AT 4715-681A-2 R226 RMF 1/4W 75R 1% AT 4715-750A-2 R227 *AH RMF 1/4W 750R 1% AT 4715-751A-2 R227 *C RMF 1/4W 1.5K 1% AT 4715-152A-2 R228 RMF 1/4W 510R 1% AT 4715-511A-2 R229 RMF 1/4W 1K 1% AT 4715-102A-2 R230 RMF 1/4W 22R 1% AT 4715-220A-2 R231,R232 RMF 1/4W 100K 1% AT 4715-104A-2 R233 RMF 1/4W 10K 1% AT 4715-103A-2 R234 RMF 1/4W 2.7K 1% AT 4715-272A-2 R235 RMF 1/4W 5.1K 1% AT 4715-512A-2 R236,R237 RMF 1/4W 20K 1% AT 4715-203A-2 R238 RMF 1/4W 30K 1% AT 4715-303A-2 R239 RMF 1/4W 20R 1% AT 4715-200A-2 R240 RMF 1/4W 3.3K 1% AT 4715-332A-2 R241 RMF 1/4W 15K 1% AT 4715-153A-2 R242 RMF 1/4W 2.7K 1% AT 4715-272A-2 R243 RMF 1/4W 22R 1% AT 4715-220A-2 R244-R248 RMF 1/4W 10K 1% AT 4715-103A-2 R253,R254 RMF 1/4W 10K 1% AT 4715-103A-2 R255 RMF 1/4W 100K 1% AT 4715-104A-2 R256 RMF 1/4W 220R 1% AT 4715-221A-2 R257 RMF 1/4W 1.2K 1% AT 4715-122A-2 R259 RMF 1/4W 22R 1% AT 4715-220A-2 R260 RMF 1/4W 3.3K 1% AT 4715-332A-2 R261 RMF 1/4W 33k 1% AT 4715-333A-2 R262 RMF 1/4W 10K 1% AT 4715-103A-2 R263 SVR 47K H3 10X10 4756-4730-3-11 R264 RMF 1/4W 10K 1% AT 4715-103A-2 R265,R266 RMF 1/4W 180K 1% AT 4715-184A-2 R267,R268 RMF 1/4W 390K 1% AT 4715-394A-2 R269 RMF 1/4W 2.7K 1% AT 4715-272A-2 R270 RMF 1/4W 6.8K 1% AT 4715-682A-2 R271 RMF 1/4W 2.7K 1% AT 4715-272A-2 R272 RMF 1/4W 6.8K 1% AT 4715-682A-2 R273,R274 RMF 1/4W 820R 1% AT 4715-821A-2 R275,R276 RMF 1/4W 4.7K 1% AT 4715-472A-2 R277 RMF 1/4W 15K 1% AT 4715-153A-2 R278,R279 RMF 1/8W 2.7K 1% AT 4711-272A-2 R280 RMF 1/8W 10K 1% ATS 4711-103A-C R281 *AH RMF 1/8W 22K 1% AT 4711-223A-2

ICs

U201 IC LM7000 DTS SANYO 3130-3430-0 U202 IC LA1266 FM/AM TUNER SANYO 3130-3390-0 U204 IC LA3401 PLL MPX 3130-3400-0 U205 IC NJM78L05A 826 3130-0640-0

SOLDER TAG 4132-1061-0

REF NO. DESCRIPTION PART NO.

Page 7

PARTS LIST GTP-760

DSP ASSEMBLY

PC BOARD

DSP(DTS) ASSEMBLY PCB-A0160C-DTS

PCB

0000 PCB DSP A0160C 1723-540A-0000

SOCKETS

0001 DIP SOCKET 28PIN W0.60 2101-0931-0

AUGUT 528-AG11D-ES

0005 32 PIN DIP IC SOCKET DUAL ROW 2101-1971-0

HEATSINK

0002-0004 HEATSINK IC ANODISED BLACK 5400-4071-0

CAPACITORS

C053,C054 CM 50V 4700pF 5% RL 6x7 153F-472J-5-KM C060 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C3 CE 10V 47µF 20% RL 5x11 157C-476M-5-IU C4-C12 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C13 CC 50V 470pF 10% 0805 1.2X2.0 150F-471K-J-BD C14 CE 10V 47µF 20% RL 5x11 157C-476M-5-IU C17 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C18 CE 25V 1µF 20% RL 3x5 157E-105M-5-EI C19 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C20 CE 25V 1µF 20% RL 3x5 157E-105M-5-EI C21,C23,C25,C27,C29 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C30 CE 25V 1µF 20% RL 3x5 157E-105M-5-EI C31 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C32 CE 25V 1µF 20% RL 3x5 157E-105M-5-EI C33 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C159 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C161-C166 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C169 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C171,C172 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C178 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C179 CE 10V 330µF 20% RL 8x12 157C-337M-5-OW C188,C189 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C190-C194 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C195,C196 CE 10V 47µF 20% RL 5x11 157C-476M-5-IU C197 CE 25V 1µF 20% RL 3x5 157E-105M-5-EI

DIODE

D1 RLS-73 DIODE 4840-1080-3

CONNECTORS

J001B,J002B 10 PIN P2.54 CONNECTOR DUAL ROW 2101-0821-0

CRYSTAL

M151 CRYSTAL 8MHZ 2300-1420-0

TRANSISTOR

Q1 IC M51943A SYSTEM RESET 3130-5860-0

RESISTORS

R052,R053 RMG 1/10W 220R 5% 0805 4720-221J-J R057 RMG 1/10W 10K 5% 0805 4720-103J-J R062,R066 RMG 1/10W 1K 5% 0805 4720-102J-J R088 RMG 1/10W 220R 5% 0805 4720-221J-J R096-R099 RMG 1/10W 220R 5% 0805 4720-221J-J R3 RCFA 1/8W 20K 5% RL 7 4701-203J-5-07 R4-R6 RMG 1/10W 220R 5% 0805 4720-221J-J R7-R9 RMG 1/10W 47R 5% 0805 4720-470J-J R10-R12 RMG 1/10W 20K 5% 0805 4720-203J-J R13 RMG 1/10W 5.1K 5% 0805 4720-512J-J R133-R136 RMG 1/10W 220R 5% 0805 4720-221J-J R137,R146,R147 RMG 1/10W 0R 5% 0805 4720-000J-J R149 RMG 1/10W 220R 5% 0805 4720-221J-J R152 RMG 1/10W 10K 5% 0805 4720-103J-J R154,R157-R160 RMG 1/10W 220R 5% 0805 4720-221J-J

REF NO. DESCRIPTION PART NO.

Page 8

PARTS LIST GTP-760

R161 RMG 1/10W 10R 5% 0805 4720-100J-J R162-R164 RMG 1/10W 220R 5% 0805 4720-221J-J R165 RMG 1/10W 10K 5% 0805 4720-103J-J R167 RMG 1/10W 220R 5% 0805 4720-221J-J R170,R182,R185,R186 RMG 1/10W 10K 5% 0805 4720-103J-J

RUBBER PAD

RUBBER PAD 12X18X13MM 4152-9061-0

ICs

U003 LABEL-SILVER 10X10MM 3100-0601-0 U003 IC 27C512-12 512K OTP EPROM 3130-7440-0 U017 IC CY7C109A 128KX8 STATIC RAM 3130-6310-0 U018 IC MC56009/88 DSP 3130-6200-0 U020 IC MC56007/66 DSP (DSPB56007FJ66) 3130-6670-0 U023 IC TC74HC00AP DIGITAL 3130-4160-0 U024 IC 74HC74 DUAL D-TYPE FLIP-FLOP 3130-6590-0 U027-U028 IC TC74HC00AP DIGITAL 3130-4160-0 U2,U4 IC 74HC4053M SOP PACKAGE 3130-8700-0 U5 IC 74HC138 SOP PACKAGE 3130-8740-0 U6 IC 74HC4024 SOP PACKAGE 3130-8750-0 U7 IC MC56009/88 DTS 3130-8600-0 U8 IC 74HC14 SOP PACKAGE 3130-8680-0 U9 IC 74HC74 DUAL D-TYPE FLIP-FLOP 3130-6590-0 U10 IC AM27C010-120DC EPROM 3130-8620-0 U11 IC KM68257C-15 32KX8 STATIC RAM 3130-8610-0

KEY

ASSEMBLY

PC BOARD

*AH KEYBOARD ASSEMBLY A0160C PCB-A0160C-KEY *C KEYBOARD ASSEMBLY A0161C PCB-A0161C-KEY

PCB

PCB KEYBOARD A0160C 1722-901A-0000

MISCELLANEOUS

1501 EL LIGHT BLUE (A1 TYPE) A0150C 2450-1156-0 1501 WSER FIBRA 1103A D3.3 2848-0032-0 1502 LCD DISPLAY GTP-740 2460-1280-0 1503 LCD HOLDER 4152-4181-1 1504 HOLDER LED 4132-6601-0 1505 CUSHION 4152-4561-0

CAPACITORS

C501 CC 50V 0.01µF 10% RL 5x5 150F-103K-5-II C502 CC 25V 0.033µF 20% RL 8x4 150E-333M-5-OG C503 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C504 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C505,C511 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C512 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C513 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C514 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C515 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C516 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C517 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C518 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C519 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C520 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C521 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C522 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM

CHSHION

CHSHION D20x2 4152-1061-0

DIODES

D501-D511 LED RT 5X2X7MM RED 3700-5577-R D512-D515 LED SP 3X5.5 L0.5 RD 3700-2380-R D516 LED RT 5X2X7MM RED 3700-5577-R D517-D532 LED SP 3X5.5 L0.5 RD 3700-2380-R D533 IR SENSOR PIC-26043TM2 4816-043T-3

REF NO. DESCRIPTION PART NO.

Page 9

PARTS LIST GTP-760

D535 *AH DIODE 1N4148 AT 4804-1480-2 D536-D543 DIODE 1N4148 AT 4804-1480-2 D544 LED RT 5X2X7MM RED 3700-5577-R

SOLDER TAG

GROUND *AH SOLDER TAG 4132-1061-0

CONNECTOR

J502 CONN. ASSY 12P P2.5 L=70 7712-1070-2004

SWITCHES

M501-M527 SWITCH, TACT SKHHBY 7MM HIGH 5200-3538-0

TRANSISTORS

Q501 TR 9014C HFE 200-600 4859-014C-5 Q502 TR 9014C HFE 200-600 4859-014C-5 Q505 TR 9014C HFE 200-600 4859-014C-5

RESISTORS

R501-R532 RMF 1/8W 560R 1% ATS 4711-561A-C R534 RMF 1/8W 10K 1% ATS 4711-103A-C R535 RMF 1/8W 1K 1% AT 4711-102A-2 R536 RMF 1/8W 10K 1% ATS 4711-103A-C R538 RMF 1/8W 22K 1% AT 4711-223A-2 R539 RMF 1/8W 10K 1% ATS 4711-103A-C R543,R544 RMF 1/8W 560R 1% ATS 4711-561A-C R545 RMF 1/8W 10K 1% ATS 4711-103A-C R546 RMF 1/8W 1K 1% AT 4711-102A-2 R547,R548 RMF 1/8W 560R 1% ATS 4711-561A-C

ICs

U501-U507 IC MSM9006-02 LCD DRIVER 3130-6350-0

PHONE

ASSEMBLY

PC BOARD

PHONE ASSEMBLY PCB-A0160C-PHO

PCB

PCB PSU/JACK A0160C 1724-090A-0001

C401,C402 CC 50V 1800pF 10% RL 6.5x3.5 150F-182K-5-LF

JACK

J490 PHONE JACK 6312-03-070 W/CLIP 2113-1011-0

WAFER

J491 4P ST.WAFER P=2.5 COULOMB 2102-041S-004

POWER

ASSEMBLY

PC BOARD

*AH POWER ASSEMBLY A0160C PCB-A0160C-PWR *C POWER ASSEMBLY A0161C PCB-A0161C-PWR

PCB

PCB PSU/JACK A0160C 1724-090A-0103

SCREWS

0001 T3X8MM SELF TAPPING 2954-3008-3000 0002 SCREW M3X8 (BLK) 2904-3008-3000 1108 SCREW BH 2.6X6 BLACK 2954-2606-3000

MISCELLANEOUS

1102 FUSE HOLDER 4132-1011-0 1103 TERMINAL WRAP 4131-9321-0

HEATSINKS

1104 HEATSINK 23.5X17X50 5400-1702-0 1105 HEATSINK (214) 20MM-HIGH HOLE 5400-0831-0 1106 HEATSINK 23.5X17X50 5400-1702-0 1107 FIBRE WASHER M3X0.4X8 NA. 2601-3004-0801 1107 HEATSINK (214) 20MM-HIGH HOLE 5400-0831-0

REF NO. DESCRIPTION PART NO.

Page 10

PARTS LIST GTP-760

CONNECTORS

1120 *AH POWER CONNECTOR A 4P 7010-9480-0 1121 *AH POWER CONNECTOR B 2P 7010-9490-0

CAPACITORS

C801 CAP400V 4700P DE7150F472MVA1KC 8910-0049-0 C802 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C803 CE 50V 220µF 20% RL 10x16 157F-227M-5-S5 C804 CE 50V 330µF 20% RL 10x20 157F-337M-5-S9 C805 CE 35V 220µF 20% RL 8x11.5 157Q-227M-5-OV C806,C807 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C808 CE 3300µF 50V 20% RL 16X35.5 8910-0008-0 C809,C810 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C811 CE 35V 2200µF 20% RL 16x25 157Q-228M-5-5& C812 CE 50V 1000µF 20% RL 12.5x25 157F-108M-5-X& C813,C814 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C815 CE 25V 470µF +80/-20% RL 10x16 157E-477Z-5-S5 C816 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C817 CE 3300µF 50V 20% RL 16X35.5 8910-0008-0 C818 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C819 CAP400V 4700P DE7150F472MVA1KC 8910-0049-0 C820 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C821 CE 25V 2200µF 20% RL 12.5X25 ELMA 157E-228M-5-X&K C822 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C823 CE 25V 1000µF 20% RL 12.5x25 157E-108M-5-X& C824,C825 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C826 CE 16V 470µF 20% RL 10x13 157D-477M-5-SY C827 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C828 CE 25V 2200µF 20% RL 12.5X25 ELMA 157E-228M-5-X&K C829,C830 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C831 CE 16V 470µF 20% RL 10x13 157D-477M-5-SY C832 CE 16V 1000µF 20% RL 10x16 157D-108M-5-S5 C833 CE 16V 6800µF 20% RL 16X35.5 ELNA 8910-0222-0 C834-C836 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II

DIODES

D801-D803 DIODE RECT IN4002 AL 4804-0020-1 D804 BRIDGE RECTIFIER RB152 100V 1.5A 4840-0490-0 D805 BRIDGE RECTIFIER RS403L 4A 200V 4840-2040-0 D806-D808,D812 BRIDGE RECTIFIER RS102 100V 1A 4840-0470-0

WAFER

J808,J809 4 PIN HEADER W/HOOK JST 2101-1981-0 J829 12P ST.WAFER P=2.5 COULOMB 2102-121S-004 J851 4P ST.WAFER P=2.5 COULOMB 2102-041S-004

TRANSFORMERS

L801 TRANSFORMER GTP-750 EI-57 1806-2319-1

L802 EI-35 TRANSFORMER GTP750 1806-2501-0

RELAY

M801 RELAY 12V DC TAIKO DGX1-12M 4500-0110-0

FUSES

J857 *C FUSE T2A 250V UL/CSA 5120-0509-0 J860 *C FUSE T1.5A 250V UL/CSA 5120-0508-0 M802 *AH 500MA/250V UL/CSA SLOW BLOW 5100-5010-1A M802 *C 500MA/250V VDE/SEMKO 5100-5010-1B M804 *AH FU 1A 6.35X31.8 5100-1020-3 M804 *C FUSE F500MA/250V 5X20MM 5120-0059-0

SWITCH

M805 DPST PUSH SW.SDDFA3066A 5200-3181-0-01

TRANSISTOR

Q801 TR 2SC1815 (G.R) RL 4860-0700-5

REF NO. DESCRIPTION PART NO.

Page 11

PARTS LIST GTP-760

RESISTORS

R801 RMF 1/8W 5.1K 1% AT 4711-512A-2 R802 RMF 1/2W 10R 1% AT 4717-100A-2 R803 *AH RMF 1/2W 2.7M 1% AT 4717-275A-2

CONNECTORS

SW1 CN. ASSY L=250 AWG#18 BLK 7009-8880-0 SW2 CN. ASSY L=250 AWG#18 BLK 7009-8880-0

ICs

U801 IC LM78L24 REGL SMALL SIZE 3130-4810-0 U802 IC 7812 12V REGULATOR (SGS) 3130-2520-3 U803 IC L7912CV REG -12V T0220 3130-3520-1 U804 IC 7805 REG 5V 1.5A 3130-2020-3 U805 IC 7905 -5V REG 1.5A 3130-6360-0 U806-U807 IC 7805 REG 5V 1.5A 3130-2020-3

S-VIDEO

ASSEMBLY

PC BOARD

S.VIDEO PCB ASSY A0160C PCB-A0160C-SVDO

PCB

1301 PCB VIDEO/S-VIDEO/VOL 1722-791A-0002

CAPACITORS

C301-C315 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C316 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C317,C318 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C319 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C320-C323 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C324 CE 10V 100µF 20% RL 5x11 157C-107M-5-IU C325-C327 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C328 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C329,C330 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C331 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C332-C334 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C335 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C336 CE 25V 3.3µF 20% RL 4x7 157E-335M-5-GM C337 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C338 CE 50V 1µF 20% RL 4x7 157F-105M-5-GM C339,C340 CC 50V 22pF 5% RL 5x3.5 150F-220J-5-IF C341 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C342 CC 50V 680pF 10% RL 4x4 150F-681K-5-GG C343 CC 25V 0.068µF 10% RL 8x4 150E-683K-5-OG C344 CE 50V 2.2µF 20% RL 4x7 157F-225M-5-GM C345-C347 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C348 CC 50V 560pF 10% RL 4x4 150F-561K-5-GG C349 CM 50V 1000pF 10% RL 6x12 153F-102K-5-KW C350,C351 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C352 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C353 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C354 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C355 CE 10V 470µF 20% RL 8X11 157C-477M-5-OU C356,C357 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C358-C360,C381 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU C385 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C386 CE 16V 33µF 20% RL 5x11 157D-336M-5-IU C388 CE 10V 100µF 20% RL 5x11 157C-107M-5-IU C394 CE 10V 470µF 20% RL 8X11 157C-477M-5-OU C395 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C396 CE 10V 470µF 20% RL 8X11 157C-477M-5-OU C397-C399 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM

DIODES

D301-D307 DIODE 1N4148 AT 4804-1480-2

WAFERS

J316 WAFER 2P P2.5 RIGHT 2102-021R-004 J321 WAFER 4P P2.5 RIGHT 2102-041R-004

REF NO. DESCRIPTION PART NO.

Page 12

PARTS LIST GTP-760

J326 WAFER 9P P2.5 RIGHT 2102-091R-004 J346 WAFER 7P P2.5 RIGHT 2102-071R-004

SOLDER TAGS

J374,J375 SOLDER TAG 4132-1061-0

CONNECTORS

J701-J712 1P DIN CONNECTOR HDC-050 2113-1183-0

SWITCH

M311 DPDT SLIDE SW.SK-22F28-G9TS 5200-3171-0-01

CRYSTAL

M325 X'TAL 3.58MHZ HC-49/U 2300-0930-0

TRANSISTORS

Q301-Q303,Q306 TR 2SC930E HFE 100-200 485C-930E-5 Q308 TR 2SA1015-Y HFE120-240 4851-015Y-5 Q309,Q311 TR 2SC930E HFE 100-200 485C-930E-5 Q320-Q323 TR 2SC945P HFE 200-400 485C-945P-5

RESISTORS

R301-R314 RMF 1/8W 75R 1% ATS 4711-750A-C R316,R317 RMF 1/8W 10K 1% ATS 4711-103A-C R318 RMF 1/8W 2.2K 1% ATS 4711-222A-C R319 RMF 1/8W 12K 1% AT 4711-123A-2 R320 RMF 1/8W 30K 1% AT 4711-303A-2 R321 RMF 1/8W 2.2K 1% ATS 4711-222A-C R322 RMF 1/8W 1M 1% ATS 4711-105A-C R323 RMF 1/8W 560R 1% ATS 4711-561A-C R324 RMF 1/8W 10K 1% ATS 4711-103A-C R325 RMF 1/8W 2K 1% AT 4711-202A-2 R326 RMF 1/8W 1.2K 1% ATS 4711-122A-C R327 RMF 1/8W 3.3K 1% AT 4711-332A-2 R328 RMF 1/8W 3.9K 1% AT 4711-392A-2 R329 RMF 1/8W 4.7K 1% ATS 4711-472A-C R330 RMF 1/8W 6.8K 1% AT 4711-682A-2 R331 RMF 1/8W 10.7K 1% AT 4711-1072-2 R332 RMF 1/8W 10K 1% ATS 4711-103A-C R333 RMF 1/8W 2.2K 1% ATS 4711-222A-C R334 SVR 47K H3 10X10 4756-4730-3-11 R335,R336 RMF 1/8W 100K 1% ATS 4711-104A-C R337,R338 RMF 1/8W 10K 1% ATS 4711-103A-C R339 RMF 1/8W 5K 1% AT 4711-502A-2 R340 RMF 1/8W 47K 1% ATS 4711-473A-C R341 RMF 1/8W 1K 1% AT 4711-102A-2 R342 RMF 1/8W 7.5K 1% AT 4711-752A-2 R343 RMF 1/8W 47K 1% ATS 4711-473A-C R344 RMF 1/4W 150R 1% AT 4715-151A-2 R345 RMF 1/8W 7.5K 1% AT 4711-752A-2 R346 RMF 1/8W 47K 1% ATS 4711-473A-C R347 RMF 1/4W 150R 1% AT 4715-151A-2 R348 RMF 1/8W 2.2K 1% AT 4711-222A-2 R349 RMF 1/8W 2K 1% AT 4711-202A-2 R350 RMF 1/8W 10K 1% ATS 4711-103A-C R351 RMF 1/8W 2.7K 1% AT 4711-272A-2 R352,R353 RMF 1/8W 10K 1% ATS 4711-103A-C R358 RMF 1/8W 47R 1% AT 4711-470A-2 R359 RMF 1/8W 20K 1% AT 4711-203A-2 R360 RMF 1/8W 22K 1% AT 4711-223A-2 R383 RMF 1/8W 2.2K 1% AT 4711-222A-2 R384 RMF 1/8W 100K 1% ATS 4711-104A-C R387 RMF 1/8W 10K 1% ATS 4711-103A-C R388,R389 RMF 1/8W 75R 1% ATS 4711-750A-C R390,R391 RMF 1/8W 68R 1% AT 4711-680A-2 R395-R398 RMF 1/8W 10K 1% ATS 4711-103A-C R399 RMF 1/8W 4.7K 1% AT 4711-472A-2 R625 RMF 1/8W 7.5K 1% AT 4711-752A-2 R626 RMF 1/8W 1K 1% AT 4711-102A-2

REF NO. DESCRIPTION PART NO.

Page 13

PARTS LIST GTP-760

R627 RMF 1/8W 47R 1% AT 4711-470A-2 R628-R329 RMF 1/8W 47K 1% ATS 4711-473A-C R630 RMF 1/8W 470R 1% ATS 4711-471A-C R631 RMF 1/8W 56R 1% AT 4711-560A-2 R644 RMF 1/8W 47K 1% ATS 4711-473A-C R645 RMF 1/4W 150R 1% AT 4715-151A-2 R646 RMF 1/8W 68R 1% AT 4711-680A-2 R647 RMF 1/8W 7.5K 1% AT 4711-752A-2 R648 RMF 1/8W 47K 1% ATS 4711-473A-C R649 RMF 1/4W 150R 1% AT 4715-151A-2 R650 RMF 1/8W 68R 1% AT 4711-680A-2 R658 RMF 1/8W 7.5K 1% AT 4711-752A-2 R659 RMF 1/8W 47K 1% ATS 4711-473A-C R660 RMF 1/4W 150R 1% AT 4715-151A-2 R661 RMF 1/8W 68R 1% AT 4711-680A-2 R662 RMF 1/8W 7.5K 1% AT 4711-752A-2 R663 RMF 1/8W 47K 1% ATS 4711-473A-C R664 RMF 1/4W 150R 1% AT 4715-151A-2 R665 RMF 1/8W 68R 1% AT 4711-680A-2

ICs

U301 IC BA7645N VIDEO SIGNAL SW. 4-CH ANALOG MULTI 3130-6300-0 U302 IC BA7612N VIDEO SIGNAL SW. 3-CH MULTIPLEXER 3130-6290-0 U303 IC BA7645N VIDEO SIGNAL SW. 4-CH ANALOG MULTI 3130-6300-0 U304 IC BA7612N VIDEO SIGNAL SW. 3-CH MULTIPLEXER 3130-6290-0 U305 IC PCA8515P/009 OSD 3130-4130-0 U306 IC NJM2217 VIDEO SUPERIMPOSER 3130-3760-0 U307-U309 IC BA7602 VIDEO SW.3X2CH MPX. 3130-6450-0 U310-U313 IC BA7612N VIDEO SIGNAL SW. 3-CH MULTIPLEXER 3130-6290-0

VIDEO

ASSEMBLY

PC BOARD

VIDEO PCB ASSY A0160C PCB-A0160C-VDO

PCB

1201 PCB VIDEO/S-VIDEO/VOL 1722-791A-0002

CAPACITORS

C361-C368 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C369,C370 CE 10V 470µF 20% RL 8X11 157C-477M-5-OU C371 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C372 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C373,C375 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C376 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C377,C378 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C379 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C380,C382 CE 10V 100µF 20% RL 5x11 157C-107M-5-IU C383 CE 10V 47µF 20% RL 5x11 157C-476M-5-IU C384 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C387 CE 10V 100µF 20% RL 5x11 157C-107M-5-IU C389 CE 10V 330µF 20% RL 8x12 157C-337M-5-OW C390-C392 CE 10V 100µF 20% RL 5x11 157C-107M-5-IU C393 CE 10V 1000µF 20% RL 8x16 AVOX 157C-108M-5-O5A C611 CC 50V 2200pF 10% RL 6.5x3.5 150F-222K-5-LF C612 CE 50V 1µF 20% RL 5x11 157F-105M-5-IU C613 CE 10V 47µF 20% RL 5x11 157C-476M-5-IU C614 CC 50V 0.022µF +80/-20% RL 11x4 150F-223Z-5-UG C615 CE 50V 1µF 20% RL 5x11 157F-105M-5-IU C616,C617 CC 50V 1000pF 10% RL 5x5 150F-102K-5-II C618 CE 50V 3.3µF 20% RL 5x11 157F-335M-5-IU C619 CE 10V 47µF 20% RL 5x11 157C-476M-5-IU C620 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C621,C622 CTC 0/60 39pF 5% RL 5x4 15CH-390J-5-IG C623,C624 CC 50V 47pF 5% RL 5x3.5 150F-470J-5-IF C625 CE 50V 2.2µF 20% RL 5x11 157F-225M-5-IU C626 CE 50V 1µF 20% RL 5x11 157F-105M-5-IU C627 CE 10V 100µF 20% RL 5x11 157C-107M-5-IU C628 CC 50V 100pF 10% RL 5x3.5 150F-101K-5-IF C629 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C630 CC 50V 330PF 10% RL 5x3 150F-331K-5-IEA

REF NO. DESCRIPTION PART NO.

Page 14

PARTS LIST GTP-760

C631 CE 10V 47µF 20% RL 5x11 157C-476M-5-IU C632 CTC 0/60 56pF 5% RL 6x4 15CH-560J-5-KG C633 CE 50V 3.3µF 20% RL 4x7 157F-335M-5-GM C634 CE 50V 1µF 20% RL 4x7 157F-105M-5-GM

DIODES

D308 DZ 1/2W 12.2-12.7V AT 4837-9A30-2 D309-D312 DIODE 1N4148 AT 4804-1480-2 D313 DZ 1/2W 3.1-3.5V ROHM AT 4837-3V31-2 D322-D324 DIODE 1N4148 AT 4804-1480-2

WAFERS

J347 WAFER 9P P2.5 RIGHT 2102-091R-004 J348 WAFER 3P P2.5 RIGHT 2102-031R-004 J388 WF T8 DE 7PIN COULOMB 2102-071S-004 J726 WAFER 4P P2.5 RIGHT 2102-041R-004

JACKS

J713-J716 1P RCA JACK YL AU HTJ-032-09 2113-1170-0 J717 2P RCA JACK YL/YL AU HSP-252V 2113-1171-0 J718,J719 1P RCA JACK YL AU HTJ-032-09 2113-1170-0 J720,J721 2P RCA JACK YL/YL AU HSP-252V 2113-1171-0 J722-J724 PHONE JACK D3.5 BK JY-3537-01-140 2113-1179-0 J725 DIN CONNECTOR 5 PIN HDC-052-02 2113-1168-0 J728 PHONE JACK D3.5 BK JY-3537-01-140 2113-1179-0 J730 TERMINAL PIN 4132-1071-0

COIL

L301 FERRITE COIL 22UH BL8.5 1807-220J-P

BRACKET

M301 BRACKET, GROUNDING 4132-6221-0

CRYSTAL

M326 X'TAL 14.318MHZ +/-30PPM HC-49/U 2300-2680-0

TRANSISTORS

Q304,Q305,Q307,Q310,Q312 TR 2SC930E HFE 100-200 485C-930E-5 Q313 TR 2SA1015-Y HFE120-240 4851-015Y-5 Q314 TR 2SC930E HFE 100-200 485C-930E-5 Q316,Q317 TR 2SD1012F/G HFE 160~560 4851-012F-5 Q318,Q319 TR 2SC945P HFE 200-400 485C-945P-5 Q324 TR 2SA1015 (G.R.) RL 4860-0660-5

RESISTORS

R354 RMF 1/8W 470R 1% ATS 4711-471A-C R355 RMF 1/8W 20K 1% AT 4711-203A-2 R356 RMF 1/8W 22K 1% AT 4711-223A-2 R357 RMF 1/8W 2.2K 1% AT 4711-222A-2 R361-R367 RMF 1/8W 75R 1% ATS 4711-750A-C R368 RMF 1/8W 47R 1% AT 4711-470A-2 R369 RMF 1/8W 7.5K 1% AT 4711-752A-2 R370 RMF 1/8W 47K 1% ATS 4711-473A-C R371 RMF 1/4W 150R 1% AT 4715-151A-2 R372,R373 RMF 1/2W 10R 5% AL 4717-100J-1-P R374,R375 RMF 1/8W 10K 1% ATS 4711-103A-C R376 RMF 1/8W 1.5K 1% AT 4711-152A-2 R377 RMF 1/2W 10R 5% AL 4717-100J-1-P R378,R379 RMF 1/8W 150R 1% ATS 4711-151A-C R380 RMF 1/8W 6.8K 1% AT 4711-682A-2 R381,R382 RMF 1/8W 33K 1% AT 4711-333A-2 R385 RMF 1/4W 100R 1% AT 4715-101A-2 R386 RMF 1/4W 510R 1% AT 4715-511A-2 R392 RMF 1/8W 470R 1% ATS 4711-471A-C R393 RMF 1/8W 68R 1% AT 4711-680A-2 R394 RMF 1/8W 75R 1% ATS 4711-750A-C R611 RMF 1/8W 470K 1% AT 4711-474A-2 R612 RMF 1/8W 10K 1% ATS 4711-103A-C

REF NO. DESCRIPTION PART NO.

Page 15

PARTS LIST GTP-760

R613 RMF 1/8W 470K 1% AT 4711-474A-2 R614 RMF 1/8W 330R 1% ATS 4711-331A-C R615 RMF 1/8W 10K 1% ATS 4711-103A-C R616 RMF 1/8W 30K 1% AT 4711-303A-2 R617,R618 RMF 1/8W 2.7K 1% AT 4711-272A-2 R619 RMF 1/8W 470R 1% ATS 4711-471A-C R620 RMF 1/8W 330R 1% ATS 4711-331A-C R621 RMF 1/8W 220R 1% AT 4711-221A-2 R622 RMF 1/8W 20K 1% AT 4711-203A-2 R623 RMF 1/8W 68K 1% AT 4711-683A-2 R624 RMF 1/8W 130K 1% AT 4711-134A-2 R632 RMF 39K 1/8W 1% AT 4711-393A-2 R633,R634 RMF 1/8W 10K 1% AT 4711-103A-2 R635,R636 RMF 1/8W 2K 1% AT 4711-202A-2 R637 RMF 1/8W 4.7K 1% AT 4711-472A-2 R638 RMF 1/8W 1K 1% AT 4711-102A-2 R639 RMF 1/8W 10K 1% ATS 4711-103A-C R640 RMF 1/8W 470R 1% ATS 4711-471A-C R641 RMF 1/8W 100R 1% AT 4711-101A-2 R642 RMF 1/8W 10K 1% ATS 4711-103A-C R651 RMF 1/8W 12K 1% AT 4711-123A-2 R652 RMF 1/8W 47K 1% ATS 4711-473A-C R653 RMF 1/4W 150R 1% AT 4715-151A-2 R654 RMF 1/8W 47R 1% AT 4711-470A-2 R655 RMF 1/8W 12K 1% AT 4711-123A-2 R656 RMF 1/8W 47K 1% ATS 4711-473A-C R657 RMF 1/4W 150R 1% AT 4715-151A-2 R666 RMF 1/8W 22K 1% AT 4711-223A-2 R667 RMF 1/4W 180K 1% AT 4715-184A-2 R668 RMF 1/4W 4.75R 1% AT 4715-4R75-2 R669 RMF 1/8W 1K 1% AT 4711-102A-2 R670 RMF 1/8W 3.9K 1% AT 4711-392A-2 R671 RMF 1/8W 4.7K 1% AT 4711-472A-2

ICs

U314 IC BA7645N VIDEO SIGNAL SW. 4-CH ANALOG MULTI 3130-6300-0 U315-U317 IC BA7612N VIDEO SIGNAL SW. 3-CH MULTIPLEXER 3130-6290-0 U318 IC 4094 8-BIT SIPO SR 3S 3130-3600-0 U321 IC BA7046F VIDEO SIGNAL SEPARATOR 3130-9070-0 U322 IC NJM2220S VIDEO SYNCHRONOUS DETECTOR 3130-9090-0 U323 IC BU2762AL NTSC/PAL COLOR SIGNAL GENERATOR 3130-9080-0 U324 IC KA2184D REMOTE CONTROL PREAMP 3130-8990-0 U602 IC TLC2201P OP AMP 3131-6740-0

VOLUME

ASSEMBLY

PC BOARD

VOLUME PCB ASSY A0160C PCB-A0160C-VOL

PCB

1401 PCB VIDEO/S-VIDEO/VOL 1722-791A-0002

CAPACITORS

C601 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C602,C603 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C605,C606 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM

WAFERS

J601 WAFER 5 PIN P2.5 2102-051R-004 J602 3 PIN ST. WAFER P=2.5 COULOMB 2102-031S-004

VARIABLE RESISTOR

R601 VR RK16312MCL 50K STANDARD B TAPERS (RED) 4750-6196-0

U601 IC LB1642 MOTOR DRIVER SANYO 3130-3410-0

EXT

A ASSEMBLY

PC BOARD

PCB EXT.5.1 ASSY A0162C PCB-A0162C-EXTA

PCB

REF NO. DESCRIPTION PART NO.

Page 16

PARTS LIST GTP-760

PCB EXT.5.1 A0162C 1725-100A-0000

CAPACITORS

C202-C207 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC

JACK

J200 6P RCA JACK 2113-1820-0

WAFERS

J201A,J201B,J202A,J202B, 3 PIN ST. WAFER P=2.5 COULOMB 2102-031S-004 J203A,J203B WAFER 3P P2.5 RIGHT 2102-031R-004 J211B-J213B SOCKET (PCB/PCB) 10P P2.0 2101-1801-0 M201-M203 NAIS RELAY TQ2-5V 4500-8080-0

RESISTORS

R202 RMF 1/8W 1K 1% AT 4711-102A-2 R203 RMF 1/8W 20K 1% AT 4711-203A-2 R204 RMF 1/8W 1K 1% AT 4711-102A-2 R205 RMF 1/8W 20K 1% AT 4711-203A-2 R206 RMF 1/8W 1K 1% AT 4711-102A-2 R207 RMF 1/8W 20K 1% AT 4711-203A-2 R208 RMF 1/8W 1K 1% AT 4711-102A-2 R209 RMF 1/8W 20K 1% AT 4711-203A-2 R210 RMF 1/8W 1K 1% AT 4711-102A-2 R211 RMF 1/8W 20K 1% AT 4711-203A-2 R212 RMF 1/8W 1K 1% AT 4711-102A-2 R213 RMF 1/8W 20K 1% AT 4711-203A-2

MAIN

ASSEMBLY

PC BOARD

PCB MAIN ASSY A0162C PCB-A0162C-MAIN

PCB

PCB MAIN A0162C 1724-080A-0003

MISCELLANEOUS

WSER FIBRA 1103A D3.3 2848-0032-0 SOLDER TAG 4132-1061-0

HEX STANDOFF M3X11 4132-7131-0 J487/J ANTENNA WASHER 4131-7701-0 0001 EL TRANSFORMER SHIELD 4134-8451-0

CAPACITORS

C001,C002 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C003 CTC 0/60 10pF 5% 0805 1.2x2.5 SUN 15CH-100J-J-BDL C005,C006 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C007 CC 50V 100pF 5% 0805 1.2x2.0 150F-101J-J-BD C008-C012 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C013 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU C014 CE 10V 470µF 20% RL 8x12 157C-477M-5-OW C015,C016 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C016 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C017 CE 50V 1µF 20% RL 4x7 157F-105M-5-GM C018 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C019 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU C021 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C022 CE 16V 22µF 20% RL 5x5 157D-226M-5-II C036 CC 50V 100pF 5% 0805 1.2x2.0 150F-101J-J-BD C038 CE 50V 1µF 20% RL 4x7 157F-105M-5-GM C039 CC 50V 100pF 5% 0805 1.2x2.0 150F-101J-J-BD C046 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C047 CC 50V 2200pF 10% 0805 1.2x2.0 150F-222K-J-BD C048 CC 50V 330pF 10% 0805 1.2x2.0 150F-331K-J-BD C060-C062 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C063,C064 CC 50V 330pF 10% 0805 1.2x2.0 150F-331K-J-BD C065 CC 25V 0.47µF +80/-20% 0805 1.2x2.0 150E-474Z-J-BD C080 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C20 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C23 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C24 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD

REF NO. DESCRIPTION PART NO.

Page 17

PARTS LIST GTP-760

C25 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C26 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C27 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C28,C29 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C30 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C31 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C32 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C33 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C34 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C35,C37 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C40 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C41 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C42 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C43 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C44 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C45 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C49 CE 25V 1000µF 20% RL 12.5x25 157E-108M-5-X& C50 CE 10V 1000µF 20% RL 8x16 AVOX 157C-108M-5-O5A C51 CE 10V 100µF 20% RL 5x11 157C-107M-5-IU C53 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C54 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C55 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C56 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C57 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C58 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C66,C67 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C101 CC 50V 0.47µF 20% RM 5X5.5 150F-474M-7-IJ C102 CC 50V 82pF 5% 0805 1.2x2.0 150F-820J-J-BD C103 CC 50V 0.47µF 20% RM 5X5.5 150F-474M-7-IJ C104 CC 50V 0.01µF 10% 0805 1.2X2.0 150F-103K-J-BD C106 CC 50V 0.47µF 20% RM 5X5.5 150F-474M-7-IJ C107 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU C108 CE 10V 100µF 20% RL 5x11 157C-107M-5-IU C110 CC 50V 0.01µF 10% 0805 1.2X2.0 150F-103K-J-BD C111-C113,C115 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C116 CC 50V 0.01µF 10% 0805 1.2X2.0 150F-103K-J-BD C117,C120,C121 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C126,C127 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C128,C129 CC 50V 2700pF 10% 0805 1.2X2.0 150F-272K-J-BD C130 CC 50V 220pF 10% 0805 1.2x2.0 150F-221K-J-BD C131 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C132,C133 CC 50V 2700pF 10% 0805 1.2X2.0 150F-272K-J-BD C134 CC 50V 220pF 10% 0805 1.2x2.0 150F-221K-J-BD C135 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C136,C137 CC 50V 2700pF 10% 0805 1.2X2.0 150F-272K-J-BD C138 CC 50V 220pF 10% 0805 1.2x2.0 150F-221K-J-BD C139 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C140,C141 CC 50V 2700pF 10% 0805 1.2X2.0 150F-272K-J-BD C142 CC 50V 220pF 10% 0805 1.2x2.0 150F-221K-J-BD C143 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C144,C145 CC 50V 2700pF 10% 0805 1.2X2.0 150F-272K-J-BD C146 CC 50V 220pF 10% 0805 1.2x2.0 150F-221K-J-BD C147 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C148,C149 CC 50V 2700pF 10% 0805 1.2X2.0 150F-272K-J-BD C150 CC 50V 15pF 5% 0805 1.2x2.0 150F-150J-J-BD C151 CC 50V 33pF 5% 0805 1.2x2.0 150F-330J-J-BD C152 CC 50V 220pF 10% 0805 1.2x2.0 150F-221K-J-BD C154-C156 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C157 CE 16V 10µF 20% RL 4x7 157D-106M-5-GM C159 TRIMCAP 5.2-30P TZ03R300FR MUR 1551-0210-0 C160,C168,C170,C175,C177 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C178 CC 50V 0.022µF 10% 0805 1.2X2.0 150F-223K-J-BD C180,C181 CE 25V 47µF 20% RL 5x11 157E-476M-5-IU C197 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C198 CC 50V 0.01µF 10% 0805 1.2X2.0 150F-103K-J-BD C199-C201 CC 50V 0.1µF 20% 0805 1.2x2.0 150F-104M-J-BD C401-C410 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C411 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C412 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM

REF NO. DESCRIPTION PART NO.

Page 18

PARTS LIST GTP-760

C413 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C414 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C415 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C416 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C417 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C418,C419 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C420-C427 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C428 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C429 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C430-C433,C435 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C436 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C437 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C438 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C439 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C440 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C441 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C442 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C443-C453 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C454 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C455 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C456 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C457 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C458 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C459,C460 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C461 CM 50V 3900pF 10% RL 6x12 153F-392K-5-KW C462 CM 50V 2200PF 5% RL 5X7 153F-222J-5-IM C463 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C464 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C465,C466 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C467 CM 50V 3900pF 10% RL 6x12 153F-392K-5-KW C468 CM 50V 2200PF 5% RL 5X7 153F-222J-5-IM C469 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C470 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C471-C473 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C474 CM 50V 2200PF 5% RL 5X7 153F-222J-5-IM C475 CM 50V 3900pF 10% RL 6x12 153F-392K-5-KW C476 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C477 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C478 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C479 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C481 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C482 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C484 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C485 CC 50V 100pF 10% AT 3.5x2 150F-101K-2-FC C486 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C487 CC 50V 220pF 10% AT 3.5x2 150F-221K-2-FC C488 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU C489 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C490 CC 50V 220pF 10% AT 3.5x2 150F-221K-2-FC C491 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU C492 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C493 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C494-C499 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C506 CE 16V 47µF 20% RL 5x11 157D-476M-5-IU C507 CM 50V 0.01µF 5% RL 5X7 153F-103J-5-IM C508 CE 50V 0.47µF 20% RL 4x7 157F-474M-5-GM C523 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU C701-C708 CE 50V 10µF 20% RL 4x7 157F-106M-5-GM C709 CE 50V 1µF 20% RL 5x11 157F-105M-5-IU C710 CM 50V 0.012µF 5% RL 6x12 153F-123J-5-KW C711-C724 CE 50V 10µF 20% RL 5x11 157F-106M-5-IU C727 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C728 CE 25V 2200µF 20% RL 12.5X25 ELMA 157E-228M-5-X&K C731 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C732 CE 25V 2200µF 20% RL 12.5X25 ELMA 157E-228M-5-X&K C733,C734 CE 10V 1000µF 20% RL 10x16 157C-108M-5-S5 C735 CC 50V 0.01µF 10% RL 150F-103K-5-QUA C736 CE 10V 1000µF 20% RL 10x16 157C-108M-5-S5 c833 CE 50V 1µF 20% RL 4x7 157F-105M-5-GM

REF NO. DESCRIPTION PART NO.

Page 19

PARTS LIST GTP-760

C860 CE 25V 1000µF 20% RL 12.5x25 157E-108M-5-X& C861 CE 16V 470µF 20% RL 10x13 157D-477M-5-SY C862 CC 50V 0.1µF 10% RL 5x5 150F-104K-5-II C863 CE 16V 2200µF 20% RL 12x20 157D-228M-5-W9 C864 CE 16V 100µF 20% RL 5x11 157D-107M-5-IU

DIODES

D003 DZ 1/2W 5.6V ROHM AT 4837-5V61-2 D101 DIODE 1N4148 ATS 4804-1480-C D102 VARICAP DIODE BB729 4840-1490-0 D103,D104 RLS-73 DIODE 4840-1080-3 D105 DIODE 1N4001 AT 4804-0010-2 D106,D107 RLS-73 DIODE 4840-1080-3 D401,D403 DIODE 1N4001 AT 4804-0010-2 D404 DZ 1/2W 6.8V ROHM AT 4837-6V81-2 D407 DZ 1/2W 10V ROHM AT 4837-1001-2 D409,D410 DIODE 1N4148 AT 4804-1480-2 D411 DIODE 1N4001 AT 4804-0010-2 D534 DZ 1/2W 4.7V AT 4837-4V71-2 J111 LIGHT RX UNIT GPIF32R SHARP 4811-F32R-3

DZ 1/2W 4.55~4.80V ROHM AT (MTZJ4.7B) 4837-4B71-2 DZ 1/2W 5.45-5.73 ROHM AT (MTZJ5.6B) 4837-5B61-2 DZ 1/2W 6.49~6.83V ROHM AT (MTZJ6.8B) 4837-6B81-2

WAFERS

J001A,J002A WAFER 10PIN P2.54 DUAL ROW 2101-0831-0 J211A-J213A WAFER (PCB/PCB) 10P P2.0 ST 2101-1621-0 J477 3 PIN ST. WAFER P=2.5 COULOMB 2102-031S-004 J480 4P ST.WAFER P=2.5 COULOMB 2102-041S-004 J505 WAFER 5 PIN P2.5 2102-051R-004 J506 2P ST.WAFER P=2.5 COULOMB 2102-021S-004 J731,J732 12P ST.WAFER P=2.5 COULOMB 2102-121S-004 J733 4P ST.WAFER P=2.5 COULOMB 2102-041S-004 J735 5P ST.WAFER P=2.5 COULOMB 2102-051S-004 J737 4P ST.WAFER P=2.5 COULOMB 2102-041S-004 J743,J743 3 PIN ST. WAFER P=2.5 COULOMB 2102-031S-004 J763 2P ST.WAFER P=2.5 COULOMB 2102-021S-004 J765 9-PIN WAFER 2102-091S-004 J770,J795 4P ST.WAFER P=2.5 COULOMB 2102-041S-004

SWITCH

J109 DPDT SLIDE SW.SK-22F28-G9TS 5200-3171-0-01

JACKS

J110,J112 1P RCA JACK BK AU HTJ-032-09 2113-1169-0 J481 2P RCA R/W (GOLD PLATE) 2103-9202-0 J482 4P RCA R/W AU 14X14 PITCH 2113-0104-0 J483,J483 2P RCA R/W (GOLD PLATE) 2103-9202-0 J485 4P RCA R/W AU 14X14 PITCH 2113-0104-0 J486 2P RCA R/W (GOLD PLATE) 2103-9202-0 J487 4P RCA R/W AU 14X14 PITCH 2113-0104-0 J488 1P RCA JACK BK AU HTJ-032-09 2113-1169-0 J489 2P RCA JACK BK/BK AU HSP-202V 2113-1174-0

COILS

L002 COIL 10µH 10% BL7.0 1801-100K-M L100 COIL 68µH 20% BL7 1801-680M-M L101 COIL 4.7µH 10% AL BL7 1801-4R7K-M L502 COIL 100µH 10% 1801-101K-M

TRANSFORMER

L501 TRANSFORMER STEP-UP 5V TO 83.5V 1806-2320-0

CRYSTALS

M103 X'TAL 12.288MHZ +/- 30PPM 49U 2300-1520-0 M111 X'TAL 18.432MHZ +-30PPM LOAD 2300-2670-0

CAP 32P HC-49/U

M150 X'TAL 46.080MHZ +/-30PPM 49U 2300-1540-0

REF NO. DESCRIPTION PART NO.

Page 20

PARTS LIST GTP-760

RALAY

M401 RELAY 2P2T MIB-12H 4500-0200-0

TRANSISTORS

Q1 TR 2SB772P PNP POWER TR 485B-772P-5 Q2 TR SS8050 C/D SAMSUNG RL 4860-0050-5 Q100-Q107 TR 9014C HFE 200-600 4859-014C-5 Q108 TR SS8050 C/D SAMSUNG RL 4860-0050-5 Q109,Q110 TR SS8550 C/D SAMSUNG RL 4860-0060-5 Q111 IC M51943A SYSTEM RESET 3130-5860-0 Q112 TR SS8050 C/D SAMSUNG RL 4860-0050-5 Q201,Q401 TR 2SC1815 (G.R) RL 4860-0700-5 Q402 TR 2SA1015 (G.R.) RL 4860-0660-5 Q403-Q405 TR SS8050 C/D SAMSUNG RL 4860-0050-5 Q406 TR SS8550 C/D SAMSUNG RL 4860-0060-5 Q407-Q414 TR SS8050 C/D SAMSUNG RL 4860-0050-5 Q415,Q416 TR SS8550 C/D SAMSUNG RL 4860-0060-5 Q417,QQ418 TR 2SD1935 HFE 200-600 SANYO 4860-2520-3 Q503 TR SS8050 C/D SAMSUNG RL 4860-0050-5 Q504 TR KTC3228 'O' RANGE HFE 100-200 4853-228O-5

RESISTORS

//C199 RMG 1/10W 2.2K 5% 0805 4720-222J-J C004 RMG 1/10W 100K 1% 0805 4720-104A-J C020 RMG 1/10W 0R 5% 0805 4720-000J-J R000 RMG 1/10W 10K 5% 0805 4720-103J-J R001 RMG 1/10W 2.2K 5% 0805 4720-222J-J R002 RMG 1/10W 10K 5% 0805 4720-103J-J R003 RMG 1/10W 12K 5% 0805 4720-123J-J R004 RMG 1/10W 2.2K 5% 0805 4720-222J-J R005,R006 RMG 1/10W 47R 5% 0805 4720-470J-J R007 RMG 1/10W 100K 5% 0805 4720-104J-J R008 RMG 1/10W 2.2K 5% 0805 4720-222J-J R009 RMG 1/10W 10K 5% 0805 4720-103J-J R010 RMG 1/10W 12K 5% 0805 4720-123J-J R011 RMG 1/10W 2.2K 5% 0805 4720-222J-J R012,R013 RMG 1/10W 47R 5% 0805 4720-470J-J R014 RMG 1/10W 100K 5% 0805 4720-104J-J R015 RMG 1/10W 2.2K 5% 0805 4720-222J-J R016 RMG 1/10W 10K 5% 0805 4720-103J-J R017 RMG 1/10W 12K 5% 0805 4720-123J-J R018 RMG 1/10W 2.2K 5% 0805 4720-222J-J R019,R020 RMG 1/10W 47R 5% 0805 4720-470J-J R021 RMG 1/10W 100K 5% 0805 4720-104J-J R022 RMG 1/10W 2.2K 5% 0805 4720-222J-J R023 RMG 1/10W 10K 5% 0805 4720-103J-J R024 RMG 1/10W 12K 5% 0805 4720-123J-J R025 RMG 1/10W 2.2K 5% 0805 4720-222J-J R026,R027 RMG 1/10W 47R 5% 0805 4720-470J-J R028 RMG 1/10W 100K 5% 0805 4720-104J-J R029 RMG 1/10W 2.2K 5% 0805 4720-222J-J R030 RMG 1/10W 10K 5% 0805 4720-103J-J R031 RMG 1/10W 12K 5% 0805 4720-123J-J R032 RMG 1/10W 2.2K 5% 0805 4720-222J-J R033,R034 RMG 1/10W 47R 5% 0805 4720-470J-J R035 RMG 1/10W 100K 5% 0805 4720-104J-J R036 RMG 1/10W 2.2K 5% 0805 4720-222J-J R037 RMG 1/10W 10K 5% 0805 4720-103J-J R038 RMG 1/10W 12K 5% 0805 4720-123J-J R039 RMG 1/10W 2.2K 5% 0805 4720-222J-J R040,R041 RMG 1/10W 47R 5% 0805 4720-470J-J R042 RMG 1/10W 100K 5% 0805 4720-104J-J R043-R048 RMG 1/10W 2.2K 5% 0805 4720-222J-J R049 RMG 1/10W 22K 5% 0805 4720-223J-J R050 RMG 1/10W 47K 5% 0805 4720-473J-J R051 RMG 1/10W 4.7K 5% 0805 4720-472J-J R054 RMG 1/10W 10K 5% 0805 4720-103J-J R055 RMG 1/10W 47R 5% 0805 4720-470J-J

REF NO. DESCRIPTION PART NO.

Page 21

PARTS LIST GTP-760

R059 RMG 1/10W 10K 5% 0805 4720-103J-J R060 RMG 1/10W 47K 5% 0805 4720-473J-J R061 RMG 1/10W 75R 5% 0805 4720-750J-J R063 RMG 1/10W 47K 5% 0805 4720-473J-J R064 RMG 1/10W 75R 5% 0805 4720-750J-J R065,R067 RMG 1/10W 0R 5% 0805 4720-000J-J R068 RMG 1/10W 1K 5% 0805 4720-102J-J R071-R077 RMG 1/10W 5.1K 5% 0805 4720-512J-J R078 RMG 1/10W 0R 5% 0805 4720-000J-J R079 RMG 1/10W 470R 5% 0805 4720-471J-J R084,R086 RMG 1/10W 0R 5% 0805 4720-000J-J R088 RMG 1/10W 1.5K 5% 0805 4720-152J-J R089 RMG 1/10W 1K 5% 0805 4720-102J-J R090 RMG 1/10W 4.7K 5% 0805 4720-472J-J R092 RMG 1/10W 7.5K 5% 0805 4720-752J-J R093.R094 RMG 1/10W 4.7K 5% 0805 4720-472J-J R095 RMG 1/10W 47K 5% 0805 4720-473J-J R52 RMG 1/10W 10K 5% 0805 4720-103J-J R53 RMG 1/10W 47K 5% 0805 4720-473J-J R56 RMG 1/10W 10K 5% 0805 4720-103J-J R57 RMG 1/10W 47K 5% 0805 4720-473J-J R58,R62,R66 RMG 1/10W 4.7K 5% 0805 4720-472J-J R69,R70 RMG 1/10W 1K 5% 0805 4720-102J-J R80 RMG 1/10W 10K 5% 0805 4720-103J-J R100 RMG 1/10W 1K 5% 0805 4720-102J-J R101,R102 RMG 1/10W 10K 5% 0805 4720-103J-J R103 RMG 1/10W 220R 5% 0805 4720-221J-J R104 RMG 1/10W 82R 5% 0805 4720-820J-J R105 RMG 1/10W 1K 5% 0805 4720-102J-J R106 RMG 1/10W 4.7K 5% 0805 4720-472J-J R107 RMG 1/10W 150R 5% 0805 4720-151J-J R108 RMG 1/10W 2.2K 5% 0805 4720-222J-J R109 RMG 1/10W 330R 5% 0805 4720-331J-J R110 RMG 1/10W 1K 5% 0805 4720-102J-J R111-R113 RMG 1/10W 10K 5% 0805 4720-103J-J R114 RMG 1/10W 1K 5% 0805 4720-102J-J R115 RMG 1/10W 220R 5% 0805 4720-221J-J R116 RMG 1/10W 10K 5% 0805 4720-103J-J R117 RMG 1/10W 220R 5% 0805 4720-221J-J R118 RMG 1/10W 100R 5% 0805 4720-101J-J R119 RMG 1/10W 0R 5% 0805 4720-000J-J R120,R121 RMG 1/10W 220K 5% 0805 4720-224J-J R122 RMG 1/10W 12K 5% 0805 4720-123J-J R123 RMG 1/10W 10K 5% 0805 4720-103J-J R124 RMG 1/10W 2.2K 5% 0805 4720-222J-J R125 RMG 1/10W 0R 5% 0805 4720-000J-J R126 RMG 1/10W 47K 5% 0805 4720-473J-J R127 RMG 1/10W 100R 5% 0805 4720-101J-J R128 RMG 1/10W 1K 5% 0805 4720-102J-J R129 RMG 1/10W 7.5K 5% 0805 4720-752J-J R130 RMG 1/10W 1K 5% 0805 4720-102J-J R131,R132 RMG 1/10W 47K 5% 0805 4720-473J-J R138 RMG 1/10W 1K 5% 0805 4720-102J-J R139 RMG 1/10W 10K 5% 0805 4720-103J-J R140 RMG 1/10W 2.2K 5% 0805 4720-222J-J R141,R142 RMG 1/10W 10K 5% 0805 4720-103J-J R143 RMG 1/10W 10K 5% 0805 4720-103J-J R144 RMG 1/10W 68K 5% 0805 4720-683J-J R145 RMG 1/10W 47K 5% 0805 4720-473J-J R148 RMG 1/10W 10K 5% 0805 4720-103J-J R150 RMG 1/10W 22K 5% 0805 4720-223J-J R151 RMG 1/10W 1M 5% 0805 4720-105J-J R153 RMG 1/10W 10K 5% 0805 4720-103J-J R155 RMG 1/10W 1K 5% 0805 4720-102J-J R156 RMG 1/10W 10K 5% 0805 4720-103J-J R166 RMG 1/10W 1R 5% 0805 4720-010J-J R171 RMG 1/10W 1.5K 5% 0805 4720-152J-J R172 RMG 1/10W 100K 5% 0805 4720-104J-J R173 RMG 1/10W 470R 5% 0805 4720-471J-J

REF NO. DESCRIPTION PART NO.

Page 22

PARTS LIST GTP-760

R174,R175 RMG 1/10W 1K 5% 0805 4720-102J-J R176 RMG 1/10W 68R 5% 0805 4720-680J-J R177 RMG 1/10W 10K 5% 0805 4720-103J-J R178 RMG 1/10W 1K 5% 0805 4720-102J-J R179 RMG 1/10W 1R 5% 0805 4720-010J-J R180 RMG 1/10W 120R 5% 0805 4720-121J-J R181 RMG 1/10W 10K 5% 0805 4720-103J-J R182 RMG 1/10W 2.2K 5% 0805 4720-222J-J R183,R184 RMG 1/10W 2K 5% 0805 4720-202J-J R187 RMG 1/10W 24K 5% 0805 4720-243J-J R188 RMG 1/10W 6.8K 5% 0805 4720-682J-J R189 RMG 1/10W 24K 5% 0805 4720-243J-J R190 RMG 1/10W 4.7K 5% 0805 4720-472J-J R191 RMG 1/10W 470R 5% 0805 4720-471J-J R192 RMG 1/10W 47K 5% 0805 4720-473J-J R193-R197 RMG 1/10W 10K 5% 0805 4720-103J-J R198 RMG 1/10W 2.2K 5% 0805 4720-222J-J R199 RMG 1/10W 220K 5% 0805 4720-224J-J R200 RMG 1/10W 100K 5% 0805 4720-104J-J R201 RMG 1/10W 5.1K 5% 0805 4720-512J-J R401 RMF 1/8W 1K 1% AT 4711-102A-2 R402 RMF 1/8W 20K 1% AT 4711-203A-2 R403 RMF 1/8W 1K 1% AT 4711-102A-2 R404 RMF 1/8W 20K 1% AT 4711-203A-2 R405 RMF 1/8W 1K 1% AT 4711-102A-2 R406 RMF 1/8W 20K 1% AT 4711-203A-2 R407 RMF 1/8W 1K 1% AT 4711-102A-2 R408 RMF 1/8W 20K 1% AT 4711-203A-2 R409 RMF 1/8W 1K 1% AT 4711-102A-2 R410 RMF 1/8W 20K 1% AT 4711-203A-2 R411 RMF 1/8W 1K 1% AT 4711-102A-2 R412 RMF 1/8W 20K 1% AT 4711-203A-2 R413 RMF 1/8W 1K 1% AT 4711-102A-2 R414 RMF 1/8W 20K 1% AT 4711-203A-2 R415 RMF 1/8W 1K 1% AT 4711-102A-2 R416 RMF 1/8W 20K 1% AT 4711-203A-2 R417 RMF 1/8W 1K 1% AT 4711-102A-2 R418 RMF 1/8W 20K 1% AT 4711-203A-2 R419 RMF 1/8W 1K 1% AT 4711-102A-2 R420 RMF 1/8W 20K 1% AT 4711-203A-2 R421 RMF 1/8W 220K 1% AT 4711-224A-2 R422 RMF 1/8W 1K 1% AT 4711-102A-2 R423 RMF 1/8W 10K 1% ATS 4711-103A-C R424 RMF 1/8W 220K 1% AT 4711-224A-2 R425 RMF 1/8W 4.7K 1% ATS 4711-472A-C R427 RMF 1/8W 220K 1% AT 4711-224A-2 R428,R429 RMF 1/8W 1K 1% AT 4711-102A-2 R430 RMF 1/8W 220K 1% AT 4711-224A-2 R431,R432 RMF 1/8W 1K 1% AT 4711-102A-2 R433 RMF 1/8W 220K 1% AT 4711-224A-2 R434,R435 RMF 1/8W 1K 1% AT 4711-102A-2 R436 RMF 1/8W 220K 1% AT 4711-224A-2 R437,R438 RMF 1/8W 1K 1% AT 4711-102A-2 R439,R440 RMF 1/8W 220K 1% AT 4711-224A-2 R441,R442 RMF 1/8W 10K 1% ATS 4711-103A-C R443 RMF 1/8W 100K 1% ATS 4711-104A-C R444 RMF 1/8W 220K 1% AT 4711-224A-2 R445 RMF 1/8W 10K 1% ATS 4711-103A-C R446 RMF 1/8W 91K 1% AT 4711-913A-2 R447 RMF 1/8W 560R 1% ATS 4711-561A-C R448 RMF 1/8W 2.2K 1% ATS 4711-222A-C R449 RMF 1/8W 22K 1% AT 4711-223A-2 R450 RMF 1/8W 220K 1% AT 4711-224A-2 R451 RMF 1/8W 10K 1% ATS 4711-103A-C R452 RMF 1/8W 91K 1% AT 4711-913A-2 R453 RMF 1/8W 560R 1% ATS 4711-561A-C R454 RMF 1/8W 2.2K 1% ATS 4711-222A-C R455,R456 RMF 1/8W 22K 1% AT 4711-223A-2 R457 RMF 1/8W 10K 1% ATS 4711-103A-C

REF NO. DESCRIPTION PART NO.

Page 23

PARTS LIST GTP-760

R458 RMF 1/8W 22K 1% AT 4711-223A-2 R459,R460 RMF 1/8W 10K 1% ATS 4711-103A-C R461 RMF 1/8W 220K 1% AT 4711-224A-2 R462 RMF 1/8W 10K 1% ATS 4711-103A-C R463,R464 RMF 1/8W 68K 1% AT 4711-683A-2 R465 RMF 1/8W 100K 1% ATS 4711-104A-C R466 RMF 1/8W 220K 1% AT 4711-224A-2 R467 RMF 1/8W 3.9K 1% AT 4711-392A-2 R468 RMF 1/8W 10K 1% ATS 4711-103A-C R469 RMF 1/8W 560R 1% ATS 4711-561A-C R470,R471 RMF 1/8W 22K 1% AT 4711-223A-2 R472 RMF 1/8W 10K 1% ATS 4711-103A-C R473 RMF 1/8W 22K 1% AT 4711-223A-2 R474,R475 RMF 1/8W 10K 1% ATS 4711-103A-C R476 RMF 1/8W 560R 1% ATS 4711-561A-C R477 RMF 1/8W 22K 1% AT 4711-223A-2 R478 RMF 1/8W 220K 1% AT 4711-224A-2 R479 RMF 1/8W 10K 1% ATS 4711-103A-C R480 RMF 1/8W 68K 1% AT 4711-683A-2 R481 RMF 1/8W 100K 1% ATS 4711-104A-C R482 RMF 1/8W 56K 1% AT 4711-563A-2 R484 RMF 1/8W 220K 1% AT 4711-224A-2 R485 RMF 1/8W 3.9K 1% AT 4711-392A-2 R486 RMF 1/8W 10K 1% ATS 4711-103A-C R487 RMF 1/8W 22K 1% AT 4711-223A-2 R488 RMF 1/8W 10K 1% ATS 4711-103A-C R489 RMF 1/8W 22K 1% AT 4711-223A-2 R490 RMF 1/8W 10K 1% ATS 4711-103A-C R491 RMF 1/8W 10K 1% ATS 4711-103A-C R492 RMF 1/8W 560R 1% ATS 4711-561A-C R493 RMF 1/8W 22K 1% AT 4711-223A-2 R494 RMF 1/8W 68K 1% AT 4711-683A-2 R495 RMF 1/8W 100K 1% ATS 4711-104A-C R496 RMF 1/8W 56K 1% AT 4711-563A-2 R497 RMF 1/8W 220K 1% AT 4711-224A-2 R498 RMF 1/8W 3.9K 1% AT 4711-392A-2 R499 RMF 1/8W 10K 1% ATS 4711-103A-C R540 RMF 1/8W 10K 1% ATS 4711-103A-C R541 RMF 1/8W 27K 1% ATS 4711-273A-C R542 RMF 1/8W 150R 1% ATS 4711-151A-C R551-R581 RMG 1/10W 15K 5% 0805 4720-153J-J R701 RMF 1/8W 560R 1% ATS 4711-561A-C R702 RMF 1/8W 22K 1% AT 4711-223A-2 R703 RMF 1/8W 560R 1% ATS 4711-561A-C R704 RMF 1/8W 22K 1% AT 4711-223A-2 R705 RMF 1/8W 560R 1% ATS 4711-561A-C R706 RMF 1/8W 22K 1% AT 4711-223A-2 R707 RMF 1/8W 220K 1% AT 4711-224A-2 R710 RMF 1/8W 12K 1% AT 4711-123A-2 R711 RMF 1/8W 1K 1% AT 4711-102A-2 R712 RMF 1/8W 4.7K 1% ATS 4711-472A-C R713 RMF 1/8W 22K 1% AT 4711-223A-2 R714 RMF 1/2W 120R 1% AT 4717-121A-2 R715 RMF 1/8W 12K 1% AT 4711-123A-2 R716 RMF 1/8W 1K 1% AT 4711-102A-2 R717 RMF 1/8W 4.7K 1% ATS 4711-472A-C R718 RMF 1/8W 22K 1% AT 4711-223A-2 R719 RMF 1/2W 120R 1% AT 4717-121A-2 R720 RMF 1/8W 47K 1% ATS 4711-473A-C R721 RMF 1/8W 220K 1% AT 4711-224A-2 R722 RMF 1/8W 10K 1% ATS 4711-103A-C R723 RMF 1/8W 1K 1% AT 4711-102A-2 R724 RMF 1/8W 10K 1% ATS 4711-103A-C R725 RMF 1/8W 12K 1% AT 4711-123A-2 R727,R729 RMF 1/8W 10K 1% ATS 4711-103A-C R730 RMF 1/8W 12K 1% AT 4711-123A-2 R731 RMF 100K 1/8W 1% AT 4711-104A-2 R732 RMF 1/8W 2.2K 1% ATS 4711-222A-C R733,R734 RMF 1/8W 12K 1% AT 4711-123A-2

REF NO. DESCRIPTION PART NO.

Page 24

PARTS LIST GTP-760

R735 RMF 1/8W 10K 1% ATS 4711-103A-C R741 RMF 1/8W 22R 1% ATS 4711-220A-C R742-R747 RMF 1/8W 470R 1% ATS 4711-471A-C R748 RMF 1/8W 47K 1% ATS 4711-473A-C R749 RMF 1/8W 4.7K 1% ATS 4711-472A-C R750 RMF 1/8W 47K 1% ATS 4711-473A-C R751 RMF 1/8W 22K 1% AT 4711-223A-2 R752 RMF 1/8W 7.5K 1% AT 4711-752A-2 R753,R754 RMF 1/8W 4.7K 1% ATS 4711-472A-C R756-R767 RMF 1/8W 10K 1% ATS 4711-103A-C R768-R773 RMF 1/8W 22K 1% AT 4711-223A-2 R776,R777 RMF 1/8W 12K 1% AT 4711-123A-2 R778-R781 RMF 1/8W 22K 1% AT 4711-223A-2 R782 RMF 1/4W 220R 1% AT 4715-221A-2 R783-R794 RMG 1/10W 4.7K 5% 0805 4720-472J-J R804 RMF 1/8W 47K 1% ATS 4711-473A-C R805,R806 RMG 1/10W 470R 5% 0805 4720-471J-J

ICs

U010 IC CS4226 20 BITS AD & DA CONVERTER 3130-6280-0 U012,U013 IC SN74HC04 (T.I.) 3130-8720-0 U019 IC 74HC393 DUAL 4-BIT COUNTER 3130-6260-0 U021 IC MC68HC11A1 8-BIT HCMOS MICROCONTROLLER 3130-6220-0 U022 PLCC SOCKET 44 PIN (4X11PIN) 2101-0841-0 U022 IC PSD312 FIELD PGM UCOM PERIPHERAL (OTP) 3130-7890-0 U050 IC PD4606A AC3 RF DEMODULATOR 3130-6270-0 U051 IC CY7C188 32KX9 STATIC RAM 3130-6320-0 U090 IC 7AA HIGH SPEED OP AMP 3130-7430-0 U2 IC 74HCT04 HEX INVERTERS 3130-6000-0 U3,U4 IC 74HC574 8X D-TYPE LATCHES 3130-8980-0 U5 IC 74HC574 8X D-TYPE LATCHES 3130-8980-0 U6-U8 IC CS3310 STEREO DIGITAL VOL. CONTROL 3130-8860-0 U101 IC MAX903 HS VOLT. COMPARATOR 3130-6340-0 U104 IC MC14577 VIDEO OP AMP 3130-6230-0 U105 IC UPC4560C-DUAL OP. AMP 3130-2010-0 U107 IC 74HC04 HEX INVERTERS 3130-5840-0 U109 IC UPC4560C-DUAL OP. AMP 3130-2010-0 U110 BAND PASS FILTER ATF-7001-A 2704-0070-0 U111,U113 IC 7AA HIGH SPEED OP AMP 3130-7430-0 U401 IC TC9163AN HV ANALOG SW 3130-3710-1 U402 IC TC9164AN HV ANALOG SW 3130-3730-1 U403 IC TC9176 ELECTRONIC VOLUME 3130-3690-0 U404-R408 IC 7AA HIGH SPEED OP AMP 3130-7430-0 U411 IC TC9164AN HV ANALOG SW 3130-3730-1 U412-U418,U422-U425 IC 7AA HIGH SPEED OP AMP 3130-7430-0 U426 IC 7805 REG 5V 1.5A 3130-2020-3 U427 IC 7805 REG 5V 1.5A 3130-2020-3 U428 IC 7905 -5V REG 1.5A 3130-6360-0 U508 IC NJM78L05A 826 3130-0640-0

HEATSINKS

U426 HEATSINK 23.5X17X35 5400-1611-0 U427 HEATSINK 23.5X17X50 5400-1702-0 U428 HEATSINK (214) 20MM-HIGH HOLE 5400-0831-0

SCREWS

U426/427 SCREW M3X8 (BLK) 2904-3008-3000 U426/427 SCREW BH 2.6X6 BLACK 2954-2606-3000 U428 SCREW BH 2.6X6 BLACK 2954-2606-3000 U428 T3X8MM SELF TAPPING 2954-3008-3000

SCREW M3X6 BINDING (BLK) 2904-3006-3000

ACKING ASSEMBLY

*AH PACKING ASSEMBLY A0162C PKG-A0162C

*C PACKING ASSEMBLY A0163C PKG-A0163C

0001 GIFT BOX,A0162C 1476-3012-1 0002 POLYFOAM 1490-1753-2 0003 POLYBAG 240X100X0.05X5 1497-0152-0

REF NO. DESCRIPTION PART NO.

Page 25

PARTS LIST GTP-760

0004 POLYBAG UNIT 450X650 1497-1392-1 0009 DATE CODE LABEL 3000-3544-0 0013 *C LABEL- YELLOW 3000-3724-0 0015 *AH S/N LABEL SET A0162C 3000-9031-0 0015 *C S/N LABEL SET A0163C 3000-9032-0 0021 300-OHM T ANTENNA 2107-0661-1 0022 AM LOOP ANTENNA 2113-1155-0 0023 RCA CABLE YEL AU L=1.0M (1P) 7010-2010-0 0024 RCA CABLE W/R AU L=1.0M (2P) 7010-2020-0 0025 POLYBAG 255X180X0.1X8 (RECY) 1497-1312-0 0026 POLYBAG 240X100X0.05X5 1497-0152-0 0027 POLYBAG 260X130X0.1 OPEN END 1497-0672-0 PACK CARTON SHT-PALLET 1000X1200 1450-1351-0 PACK ANGLE BOARD (L=1000MM) 1450-1891-0 PACK CARD BOARD 1230x1130 DW 1450-5430-0 PACK PAPER PALLET (1200X1100X120mm) -WATER PROOF 1450-7350-0 PACK STRETCH FILM W=450 THK=0.018 9500-1010-0

CASING

ASSEMBLY

*AH SEMI-CASING ASSY A0162C SS-A0162C *C SEMI-CASING ASSY A0163C SS-A0163C

0101 FRONT PANEL A0162C 1402-6702-1 0102 BOTTOM A0160C 1402-6631-3 0103 *AH REAR PANEL,A0162C 1402-6697-1 0103 *C REAR PANEL,A0163C 1402-6698-1 0104 TOP COVER W/O VENT, GTP-740 1402-3541-0 0105 SUBFASCIA GTP-750 1402-6760-2 0106 TUNER BRACKET 1402-6710-1 0107 DISPLAY BEZEL GTP-740 4152-4191-0 0108 DISPLAY LENS GTP-740 3715-4700-0 0109 KNOB,VOLUME GTP-740 2441-8200-0 0110 LENS,VOLUME GTP-740 3715-4100-0 0113 POWER KNOB 2438-8301-0 0114 POWER KNOB HOLDER 2438-8401-0 0115 POWER KNOB-LED CAP 2438-8501-0 0116 SPRING 2510-2031-0 0117 POWER KNOB LENS 3714-4906-0 0118 LENS BUTTON ACTUATOR 3715-4800-0 0119 KNOB SPACER 2441-9500-0 0120 FUNCTION KNOB W/O LIGHT 2441-9600-0 0121 FUNCTION KNOB W/ LIGHT 2441-9700-0 0122 KNOB TUNER 2441-9800-0 0123 REMOTE LENS 3715-4506-0 0124 LENS,LEDX8 3715-4900-0 0125 LENS LEDX4 3715-5000-0 0126 LED DUAL COLORS 3700-2500-RG 0127 *AH STRAIN RELIEF BUSHING 4N-4 4151-9461-0 0127 *C AC CORD 10/16A 250V 3X 7009-5470-0 0128 *AH FUSE HOLDER (PANEL MOUNT) 4152-0491-0 0128 *C AC INLET SOCKET 2113-0300-0 0129 FOAM STRIP 80X10X1MM 4152-0661-0 0130 PLASTIC FOOT 4152-0481-0 0131 *AH AC CORD SPT2 AWG16X2 DOUBLE INSULATED 7010-9530-0 0132 M/C SCREW M3X8, CS SMALL HEAD 2901-3008-3001 0133 T3X8MM SELF TAPPING 2954-3008-3000 0134 3X6MM B-TITE (BLK.ZN) 2954-3006-3000 0135 T3X8MM SELF TAPPING 2954-3008-3000 0136 T3X8MM SELF TAPPING 2954-3008-3000 0137 SELF TAPPING SCREW 3X8MM 2941-3008-3000 0138 3X6MM B-TITE (BLK.ZN) 2954-3006-3000 0139 T3X8MM SELF TAPPING 2954-3008-3000 0141 SCREW M3X8 (BLK) 2904-3008-3000 0142 SCREW M3X8 (BLK) 2904-3008-3000 0143 T3X8MM SELF TAPPING 2954-3008-3000 0144 T3X8MM SELF TAPPING 2954-3008-3000 0145 T3X8MM SELF TAPPING 2954-3008-3000 0146 SCREW M3X8 (BLK) 2904-3008-3000 0147 T3X8MM SELF TAPPING 2954-3008-3000

REF NO. DESCRIPTION PART NO.

Page 26

GTP-760

0148 T3X8MM SELF TAPPING 2954-3008-3000 0149 T3X8MM SELF TAPPING 2954-3008-3000 0150 T3X8MM SELF TAPPING 2954-3008-3000 0151 HEX STANDOFF M3X30.4 MALE/FEMALE 4132-6691-0 0152 HEX STANDOFF M3X53.4 MALE/FEMALE 4132-6701-0 0153 SCREW M3X8 (BLK) 2904-3008-3000 0154 SCREW M3X8 (BLK) 2904-3008-3000 0155 *AH F CONNECTOR 2113-1172-0 0156 SCREW M3X6 BINDING (BLK) 2904-3006-3000 0157 *AH AC OUTLET 125V 15A UL SMK 2103-5802-0 0158 SCREW M3X6 BINDING (BLK) 2904-3006-3000 0159 T3X8MM SELF TAPPING 2954-3008-3000 0161 M4 NUT (BLK) 2640-4030-0703 0162 SELF TAPPING SCREW 3X6 2941-3006-3000 0163 RUBBER PIN 4152-0501-0 0164 SPRING WASHER 2607-3007-0550 0165 SPRING WASHER M4X1X7 BZ 2607-4010-0703 0166 SCREW M4X10 (BLK) 2904-4010-3000 0168 CONN ASSY 2P P2.5 L=140 -004 7010-1490-0 0170 CONN ASSY 3P P2.5 L=90 7010-1580-0 0171 CONN. ASSY 3P P2.5 L=110 7010-1050-0 0172 CONN. ASSY 4P P2.5 L=50 7704-1050-2004 0173 CONN ASSY 4P P2.5 L=150 -004 7010-1500-0 0174 SHIELD WIRE 3P P2.5 L=260MM 7012-5930-0 0176 CONN ASSY 4P P2.5 L=110 -004 7010-1590-0 0178 CONN ASSY 7P P2.5 L=70 -004 7010-1480-0 0179 CONN ASSY 9P P2.5 L=60 -004 TYPE 7010-1470-0 0180 CONN ASSY 9P P2.5 L=90 -004 7010-1570-0 0181 *C T3X8MM SELF TAPPING 2954-3008-3000 0182 CONN ASSY 12P P2.5 L=60 -004 7010-1560-0 0183 CONN. ASSY 4P P2.5 L=130 7010-1040-0 0185 UP/DOWN KNOB ADAPTOR 4134-0151-0 0186 SHRINKAGE TUBE ID=2.5MM UL 1661-0860-0 0189 CONN. ASSY 4P 2.5P L=50 004 7010-1510-0 0190 SHIELD PLATE 4132-8011-0 0191 RUBBER PAD 12X18X13MM 4152-9061-0 0192 CONN ASSY 5P P2.5 L=90 -004 7010-1550-0 0193 LCD COVER SHEET 4152-6111-0 0200 SHRINKAGE TUBE ID=5 UL/CSA 1660-0620-0 0201 SHRINKAGE TUBE ID=1MM UL 1660-0890-0 0205 SHIELD WIRE 2 PIN PITCH=2.54mm 7010-9520-0 0206 5 PIN CONNECTOR L=120mm 7010-9610-0 0220 FIBRE WASHER M3X0.4X8 NA. 2601-3004-0801 0220 I/T WASHER M3X0.5X6.4 WZ 2606-3005-0642 0221 *C FERRITE CODE D19xT10 1808-0130-0 0230 SCREW M3X10 (BLK) 2904-3010-3000 0231 M3 NUT 2640-3022-0540 0232 SPRING WASHER 2607-3007-0550 0233 EXT TOOTH WASHER M3X1X6MM BZ 2605-3010-0603 0234 GROUND WIRE, AWG#18, L=60mm RING TERMINAL 7012-5020-0 0235 GROUND WIRE, AWG#18, L=60mm RING TERMINAL 7012-5020-0 0236 *AH SCREW M3X8 (BLK) 2904-3008-3000 0237 *AH SCREW M3X6 BINDING (BLK) 2904-3006-3000 0238 *AH FIBRE WASHER M3X0.4X8 NA. 2601-3004-0801 162 METAL WASHER M3X0.4X8 BZ 2600-3004-0803 JACK SCREW BT 2.6X8 BLACK ZINC 2954-2608-3000 FUSE M3x8 C'SINK B-TITE FH,BK 2951-3008-3000 VR/BOTTOM T3X8MM SELF TAPPING 2954-3008-3000

PLASTIC CABLE TIE 97MM 6360-0011-0

REF NO. DESCRIPTION PART NO.

NOTE: - The components identified by

mark are critical for risk of fire and electrical shock.

Replace only with part number specified.

- US : USA model only.

- CE : European model only.

- Capacitors : CP-Polystyrere, CM-Mylar, CE-Electrolytic, CC-Ceramic.

- Resistors : RMF-Metal Film.

Page 27

IC BLOCK DIAGRAM GTP-760

TUNER ASSEMBLY U202: LA1266

TUNER ASSEMBLY U205: NJM78L05A

TUNER ASSEMBLY U204: LA3401

VOLUME ASSEMBLY U601: LB1642

Powe r supply

Loop filterOSC

Reg OSC

ButterIFButter

OSC

Butter

GND

22 23 24 14 19 17 164

Loop

filter

PLL

input

Pilot sync

VCO stop

detector

filter,

Pilot sync

detector

filter

FM - IF Q. D

AM - IFMIXRF

Narrow

S-Meter

Changeover

Det

AGC

muteMuting

Stereo

indicator

22 21 20 19 18 17 16 15 14 13 12

Vcc

S-Meter

GND

7653211013111820

Post Amp

LED

Driver

Vol Reg

OSC

Symmetrical

-Reactance Circuit

Muting

FM AM Change

inputFMinput

Phase

Comparator

VCO Stop

Pilot Det

Lamp Driver

Trigger

38kHz

19kH<90˚FF19kH<0˚

Decoder

Stereo Switch

Muting Control

FM AM Changeover

Muting Output

Vcc On Muting

2 3 4 5 6 7 8 9 10 11

Composite

amp

output

Separartion

adjust

Post amp

output

Post amp input

Post amp

output

Vcc-ON

muting

FM/AM

changeover

Muting output

OUT

GND

INput logic

IN1

OUT2

VCC1

VCC1'

GND5GND

IN2

OUT1

VCC2'

VCC2

Page 28

IC BLOCK DIAGRAM GTP-760

DSP ASSEMBLY U017: CY7C109A

DSP ASSEMBLY U018: MC56009/88 DSP

SOJ

Top Vie w

I/O

151718

GND

NC A

TSOP I

Top Vie w

(not to scale)

I/O

GND I/O

I/O

4 3

ROW DECODER

INPUT BUFFER

512 x 256 x 8

ARRAY

COLUMN DECODER

A13A

SENSE AMPS

POWER

DOWN

I/O

24-Bit

56000 DSP

Core

Internal

Switch

OnCE

Clock

PLL

Gen.

34 4

Data

Bus

Port

49529

General

Purpose

Input/

Output

Serial Audio

Interface

(SAI)

Serial

Host

Interface

(SHI)

External

Memory

Interface

(EMI)

Address

Generation

Unit

GDB PDB XDB YDB

Interrupt

Control

Program

Decode

Controller

Program Address

Generator

Program Control Unit

IRQ

Program Memory*

X Data

Memory*

PAB

XAB

YAB

Data ALU

24 x 24 + 56 56-Bit MAC

Two 56-Bit Accumulators

16-Bit Bus 24-Bit Bus

Y Data

Memory*

Page 29

IC BLOCK DIAGRAM GTP-760

DSP ASSEMBLY U020: MC56007/66 DSP

DSP ASSEMBLY U024: 74HC74

DSP ASSEMBLY U023, U027-U028: TC74HC00AP

49529

16-Bit Bus 24-Bit Bus

General

Purpose

Input/

Output

24-Bit

56000 DSP

Core

Internal

Data

Bus

Switch

OnCE

Port

Clock

PLL

Gen.

34 4

Serial Audio

Interface

(SAI)

Address

Generation

Interrupt

Control

Program Control Unit

IRQ

Interface

Unit

Program

Decode

Controller

Serial

Host

(SHI)

GDB PDB XDB YDB

External

Memory

Interface

Program Address

Generator

(EMI)

Program

Memory*

PAB

XAB

YAB

24 x 24 + 56 56-Bit MAC

Two 56-Bit Accumulators

X Data

Memory*

Data ALU

Y Data

Memory*

1SD

1CP

1RD1

2SD

2CP

2RD

VCC

FF1

FF2

GND

VCC

Page 30

IC BLOCK DIAGRAM GTP-760

DSP ASSEMBLY U5: 74HC138

DSP ASSEMBLY U6: 74HC4024

DSP

ASSEMBLY

U2, U4: 74HC74

1by 16 V

IN/OUT

2bx 15

3cy 14

OUT/IN

cx or cy

5IN/OUT cx 12 by

6INH 11 A

8GND 9C

1A 16 V

2B 15 Y0

3C 14 Y1

4G2A 13 Y2

5G2B 12 Y3

6G1 11 Y4

7Y7 10 Y5

8GND 9Y6

13 ay

10 B

OUT/IN bx or by

OUT/IN ax or ay

IN/OUT

LOGIC LEVEL CONVERSION

(11)

(10)

INH

VDD(16)

(9)

(6)

(7)VEE(8)

BINARY TO

1 OF 2

DECODER

WITH

INHIBIT

cy (3)cx(5)by(1)bx(2)ay(13)ax(12)

IN/OUT

OUT/IN ax or ay

(14)

OUT/IN bx orby

(15)

OUT/IN cx orcy

(4)

1CLOCK

2RESET

3Q7

4Q6

5Q5

6Q4

7GND

*N.C.=No Internal Connection

14 V

13 N.C.

12 Q1

11 Q2

10 N.C.

9Q3

N.C.8

G2A

G2B

CLOCK

CLEAR

CKRQ

Page 31

IC BLOCK DIAGRAM GTP-760

DSP ASSEMBLY U7: MC56009/88 DTS

CCQ

WSR

DR V

MD7 MODC/NMI

MD6 MODB/IRQB

MD5 MODA/IRQA

MD4 RESET

GNDD MISO/SDA

MD3 GNDS

MD2 V

MD1 PCAP

CCD

MD0 PINIT

GNDD GNDQ

GPIO3 V

GPIO2 EXTAL

GPIO1 SCK/SCL

GPIO0 MA0

MRD MA1

MWR MA2

MA17/MCS1/MRAS MA3

MA16/MCS2/MCAS

MCS0 DSI/OS0

GNDA DSCK/OS1

MA15/MCS3 DSO

MA14 SD10

MA13 SD11

CCA

MA12 GNDS

GNDQ

CCQ

GNDA V

GNDQ SCKR

MA11 WST

MA10 SCKT

CCS

MA9 V

MA8 SDO0

GNDA SDO1

MA7 SDO2

GNDS

CCA

MA6 HREQ

MA5 SS/HA2

MA4 MOSI/HAO

CCS

CCP

GNDP

CCQ

GNDA

S/PDIF

Input

IEC1937 (S/PDIF)

Receiver

DTS hitstream

SAI RX

SDI0

SDI1

SRAM

(32k x 8)

Host

Processor

EMI

MD0-MD7

MOSI/HA0 MISO/SDA

EPROM

(1M)

µC

(8-bit)

PLL

EXTAL

Crystal

(1MHz)

SAI TX

SDO0

SDO1

SDO2

L/R

LS/RS

C/Sub

D/A

Converter

L/R

LS/RS

C/Sub

Analog Outputs

Page 32

IC BLOCK DIAGRAM GTP-760

DSP ASSEMBLY U8: 74HC14

DSP ASSEMBLY U9: 74HC74

DSP ASSEMBLY U10: AM27C010-120DC

DSP ASSEMBLY U11: KM68257C-15

11A 21Y 32A 42Y 53A 63Y 7GND

14 V 13 6A 12 6Y 11 5 A 10 5Y

94A 84Y

2A16 31 PGM 3A15 30 NC 4A12 29 A14 5A7 28 A13 6A6 27 A8 7A5 26 A9 8A4 25 A11 9A3 24 OE

10A2 23 A10

11A1 22 CE 12A0 21 Q7 13Q0 20 Q6 14Q1 19 Q5 15Q2 18 Q4 16GND 17 Q3

32 V

GND

FF1

1SD

5A7 29 A14 6A6 28 A13 7A5 27 A8 8A4 26 A9

9A3 25 A11 10A2 24 OE 11A1 23 A10 12A0 22 CE 13Q0 21 Q7

1CP

16GND 2 A16

15Q2 3 A15

14Q1 4 A12

18Q4 32 VCC17Q3 1V

19Q5 31 PGM

FF2

1RD1

20Q6 30 NC

2SD

2CP

PGM

A16

. . .

GND

VCC

2RD

CONTROL

DECODER

OUTPUT BUFFER

CORE

ARRAY

. . .

1A14 28 VCC 2A12 27 WE 3A7 26 A13 4A6 25 A8 5A5 24 A9 6A4 23 A11 7A3 22 OE 8A2 21 A10

9A1 20 CE 10A0 19 I/O7 11I/O0 18 I/O6 12I/O1 17 I/O5 13I/O2 16 I/O4 14GND 15 I/O3

22OE 21 A10 23A11 20 CE 24A9 19 I/O7 25A8 18 I/O6 26A13 17 I/O5 27WE 16 I/O4 28VCC 15 I/O3

1A14 14 GND 2A12 13 I/O2 3A7 12 I/O1 4A6 11 I/O0 5A5 10 I/A0 6A4 9 I/A1 7A3 8 I/A2

VCC

GND

I/O0-I/O7

CE1

OE WE

DECODERA0-A14

I/O

DATA

CIRCUIT

CONTROL

CIRCUIT

256X1024

MEMORY ARRAY

COLUMN I/O

Page 33

IC BLOCK DIAGRAM GTP-760

KEY ASSEMBLY U501-U507: NSM9006-02

1SEG1 48 DATA I/O 2SEG2 47 INT 3SEG3 46 RESET 4SEG4 45 TEST 5SEG5 44 V 6SEG6 43 OSC 7SEG7 42 V 8SEG8 41 SEG41/LED

9SEG9 40 SEG40/P01 10SEG10 39 SEG39/P02 11SEG11 38 SEG38/P03 12SEG12 37 SEG37/P04 13SEG13 36 SEG36/P05 14SEG14 35 SEG35 15SEG15 34 SEG34 16SEG16 33 SEG33

17SEG17 64 COM1

18SEG18 63 COM2

19SEG19 62 COM3

20SEG20 61 COM4

21SEG21 60 C0

22SEG22 59 C1

3SEG23 58 C2

24SEG24 57 C3

25SEG25 56 C4

26SEG26 55 R0

27SEG27 54 R1

28SEG28 53 R2

29SEG29 52 R3

30SEG30 51 R4

31SEG31 50 LOAD

32SEG32 49 CLOCK

OSC

RESET

LOAD

DATAI/O

COM4

COMMON

DRIVER

TIMING

GEN

OSC

CONTROL

LOGIC

SEG1 SEG35

35 OUT SEGMENT DRIVER

41 BIT DATA SELECTOR

41 BIT

LATCH

C6 C5 C4 C3

41 BIT

LATCH

MODE

SELECTOR

(41+7) 48 BIT SHIFT REGISTER

41 BIT

LATCH

C2 C1 C0

41 BIT LATCH

SEG36/P05 SEG41/LEDCOM1

5 SEGMENT/PORT

& SEGMENT/LED

DRIVER

TEST

CLOCK

5X5 KEY SCANNER

C4 R0

R0 R0 R0 R0C3C2C1C0

INT

Page 34

IC BLOCK DIAGRAM GTP-760

POWER ASSEMBLY U801, U802, U804, U806, U807: 78XX

VIDEO ASSEMBLY & S-VIDEO ASSEMBLY U301, U303, U314: BA7645N

VIDEO ASSEMBLY & S-VIDEO ASSEMBLY U305: PCA8515P/009

VIDEO ASSEMBLY & S-VIDEO ASSEMBLY U302, U304, U310-U313: BA7612N

POWER ASSEMBLY U803, U805: 79XX

OUT

GND

MUTE

LOGIC

OUT

GND

MUTE

6dB Amp 75Ω Driver

LOGIC

123456789

IN1

CTLA

CTLB

IN2

CTLC

IN3

IN4

GND

VOUT

1I(VOW3) 24 AV

P04/ACM

(VOB2)

3TEST2 22 FB(VOB)

41TEST1 21 V

5C 20 B(VOW2)

6VSYNC 19 P01

7HSYNC 18 G(VOW1)

8SDA/SIN 17 P00

9SCK/SCLK 16 R(VOW0)

10ATAL1(IN) 15 HIO/I2C

11XTAL2(OUT) 14 E

12V

23 AV

13 RESET

RESET

SCL/SCLK

SDA/SIN

HIO/I2C

HSYNC VSYNC

EXTERNAL/INTERNAL

DATA SWITCHING

BUFFER

I2C SLAVE

RECEIVER OR

HIGH-SPPED I/O

RECEIVER

PLL

OSCILLATOR

VSYNC

HSYNC

CSYNC

SEPARATION

INSTRUCTION

SYNCHRONOUS

CHARACTER SIZE

DECODER

INTERNAL

CIRCUIT

CONTROL

HORIZONTAL

POSITION

COUNTER

CRYSTAL

OSCILLATOR

XTAL1(IN)

XTAL2(OUT)

WRITE ADDERSS

COUNTER

VERTICAL POSITION

COUNTER

12345678

IN2

CTLB

DISPLAY

CHARACTER

RAM

DISPLAY

ROM

DISPLAY CONTROL

AND OUTPUT STAGE

R(VOW0)

G(VOW1)

B(VOW2)

GND

FB(VOB)

I(VOW3)

CONTROL

TEST1

SIGNALS

TESTING

CIRCUITRY

TEST2

IN1

ADDERSS

BUFFER

SELECTOR

TI00 to TI11

CTLA

IN3

VCC

I/O

PORT

BUFFERS

ACM(VOB2)

OUT

P00

P01 P04/ACM (VOB2)

Page 35

IC BLOCK DIAGRAM GTP-760

VIDEO ASSEMBLY & S-VIDEO ASSEMBLY U318: 4094

VIDEO ASSEMBLY & S-VIDEO ASSEMBLY U321: BA7046F

VIDEO ASSEMBLY & S-VIDEO ASSEMBLY U322: NJM2220S

1STR

2D 15 EO

3CP 14 O

16 V

13 O

12 O

11 O

10 Os'

STAGE 0 STAGES 1 TO 6

STR

DO O

latch

STAGE 7

latch

Os'

Horizontal signal

oscillator resistor

HD output

SYNC output

(open collector)

VD output Ground

1 8

2 7

3 6

4 5

H.OSC

V.SEPA

O1O2O3O4O5O

PHASE COMP

Phase comparator output

Power supply

SYNC SEPA

Video input

Comparator

M.M LPF

Switch

GND SYNC DET

M.M Time2SYNC3SYNC4SSG SYNC

SYNC DET

Constant Input Output Input Output

Judgement Control

7 8

M.M

V '

Smoothing 5V~10V

Page 36

IC BLOCK DIAGRAM GTP-760

VIDEO ASSEMBLY & S-VIDEO ASSEMBLY U324: KA2184D

MAIN ASSEMBLY U010: CS4226

MAIN ASSEMBLY U012, U013: SN74HC04

MAIN ASSEMBLY U019: 74HC393

LIMITTER AMP

BPF

ABLC

DETECTOR

COMPARATOR

INTE-

GRATOR

WAVEFORM

SHAPER

3 4 85 6 7

C1 C2 C3 VOUT VCCGND f0

PDN

SDA/CDOUT

PDN

LRCK

SCLK

SDIN1

SDIN2

SDIN3

SDOUT1 SDOUT2

OVL/ERR

DEM

Serial Audio Data Interface

DEM

CLKOUT XTI XTO FILT HOLD/RUBIT

Control Port

MUX

Clock Osc/

Divider

AD1/CDIN AD0/CS SPI/I2C VD+

DAC#1

DAC#2

DAC#3

DAC#4

DAC#5

Volume Control

DAC#6

Mono

Volume Control

ADC

Left

ADC

Right

Digital Filters Digital Filters

ADC

PLL

S/PDIF RX/Auxiliary Input

DATAUX/RX4

Input

LRCKAUX/RX3 RX1 DGND1 DGND2

SCLKAUX/RX2

VA+

Output Stage

Analog Low pass and

Gain

Voltage

Reference

CMOUT

AOUT1

AOUT2

AOUT3

AOUT4

AOUT5

AOUT6

AINAUX AIN1L

AIN1R AIN2L/FREQ0

AIN2R/FREQ1

Input MUX

AIN3L/AUTODATA AIN3R/AUDIO

AGND1 AGND2

11A 21Y 32A 42Y 53A 63Y 7GND

14 V

13 6A 12 6Y

11 5 A

10 5Y

94A 84Y

11CK 14 Vcc

21CLR

31QA

41QB

51QC

61QD

7GND 8 2QD

13 2CK

12 2CLR

11 2QA

10 2QB

9 2QC 2QC

1CLR CT=0

1CK

2CLR

2CK

(12)

(13)

CTRDIV16

(2)

(1)

(3)

1QA

(4)

1QB

(5)

1QC

(6)

1QD

(11)

2QA

(10)

2QB

(9)

(8)

2QD

Page 37

IC BLOCK DIAGRAM GTP-760

MAIN ASSEMBLY U022: PSD312

MAIN ASSEMBLY U051: CY7C188

6 PB5

5 PB6

4 PB7

7PB4

8PB3

9PB2

10PB1

11PB0

12GND

13ALE or AS

14PA7

15PA6

16PA5

17PA4

18PA3

19PA2

20PA1

or R/W

3 RESET

2 V/R/V

21PA0

22RD/E/DS

1 PSEN

44 VCC43 A19/CSI

23AD0/A0

24AD1/A1

42 PC2

25AD2/A2

26AD3/A3

41 PC1

40 PC0

27AD4/A4

28AD5/A5

39 A15

38 A14

37 A13

36 A12

35 A11

34 GND

33 A10

32 A9

31 A8

30 AD7/A7

29 AD6/A6

AD8-AD15

AD0-AD7

ALE/AS

RD/E/DS

WR/R/W

BHE/PSEN

RESET

A19/CSI

L A T C H

ALE/AS

L A T C H

A11-A15

A8-A10

CONTROL

SIGNALS

A19/CSI

ALE/AS

RESET

D8-D15

PROG.

PAGE LOGIC

P3-P0 A16-A18

PAD A

13 P.T.

ES7 ES6 ES5 ES4 ES3 ES2 ES1 ES0

16/8

MUX

D0-D7

RS0

A0-A7 AD0-AD7/D0-D7

CSIOPORT

A19/CSI

ALE/AS

RESET

EPROM

256Kb TO 2Mb

SRAM

16K BIT

PROG. CHIP

CONFIGURATION

X8, X16 MUX or NON-MUX BUSSES SECURITY MODE

PAD B

27 P.T.

D8-D15

LOGIC IN

CSIOPORT

TRACK MODE SELECTS

CS8CS10

CS0CS7

PROG.

PORT

EXP.

PORT

PROG.

PORT

EXP.

PORT

PROG.

PORT

EXP.

PORT

PC0PC2

PB0PB7

PA0PA7

I/O

GND

25 24

OE A

22 21 20 19 18 17

CE I/O I/O I/O I/O I/O

A A

ROW DECODER

INPUT BUFFER

32K x 9

ARRAY

COLUMN

DECODER

SENSE AMPS

POWER

DOWN

A11A

I/O

Page 38

IC BLOCK DIAGRAM GTP-760

MAIN ASSEMBLY U090, U111, U113, U404-U408, U412-U418, U422-U425: 7AA

MAIN ASSEMBLY U3, U4, U5: 74HC574

MAIN ASSEMBLY U6-U8: CS3310

MAIN ASSEMBLY U101: MAX903

AMPLIFIER 1

OUTPUT

INVERTING

INPUT

NON-INVERTING

INPUT

V –

+ – – +

FF1

AMPLIFIER 2

V +

OUTPUT

INVERTING INPUT

NON-INVERTING INPUT

D1 D2 to D5

FF2

1VCC** 8VDD***

2IN+

3IN- 6 GND

4VEE* 5 LATCH

FF7

7 OUT

FF8

AINL

AGNDL

AGNDR

MUX

Control

Serial to

Parallel

AOUTL

MUTE

ZCEN

SD ATAI

SD ATAO

SCLK

AINR

VA+

VA-13VD+

DGND

AOUTR

Page 39

IC BLOCK DIAGRAM GTP-760

MAIN ASSEMBLY U105, U109: UPC4560C-DUAL

MAIN ASSEMBLY U402, U411: TC9164AN

MAIN ASSEMBLY U401: TC9163AN

MAIN ASSEMBLY U107: 74HC04

AMPLIFIER 1

OUTPUT

INVERTING

NON-INVERTING

INPUT

V –

+ – – +

L-COM1

L-S4

AMPLIFIER 2

V +

OUTPUT

INVERTING

INPUT

NON-INVERTING

INPUT

VSS

GND28VDD

2L-S1

3L-S2 26 R-S2

4L-S3 25 R-S3

7L-S5 22 R-S5

8L-S6 21 R-S6

9L-COM2 20 R-COM2

10L-S7 19 R-S7

11L-S8 18 R-S8

12L-COM3 17 R-COM3

13L-ST 16 DATA

LATCH CIRCUIT

LEVEL SHIFTER

SHIFT REGISTER

LATCH CIRCUIT

LEVEL SHIFTER

11A 14 Vcc

21Y 13 6A

32A 12 6Y

42Y 11 5A

53A 10 5Y

63Y 94A

7GND 84Y

27 R-S1

R-COM1

R-S4

15 CK

VSS

GND28VDD

2L-S1

3L-S2 26 R-S2

4L-S3 25 R-S3

5L-S4 24 R-S4

6L-COM1 23 R-COM1

7L-S5 22 R-S5

8L-S6 21 R-S6

9L-COM2 20 R-COM2

10L-S7 19 R-S7

11L-S8 18 R-S8

12L-COM3 17 R-COM3

13L-ST 16 DATA

LATCH CIRCUIT

LEVEL SHIFTER

SHIFT REGISTER

LATCH CIRCUIT

LEVEL SHIFTER

27 R-S1

15 CK

Page 40

IC BLOCK DIAGRAM GTP-760

MAIN ASSEMBLY U403: TC9176

MAIN ASSEMBLY U426, U427: 7805

MAIN ASSEMBLY U428: 7905

MAIN

ASSEMBLY

U508: NJM78L05A

DD 16

GND1V

A-SW

DATA

STB STB

LATCH CIRCUIT

STB STB

20bit SHIFT REGISTER

LEVEL SHIFTER

LATCH CIRCUIT

A-SWA-SW

A-SW

1234567891011121314151617181920

15 R-OUT

14 R-OUT

9D ATA

8CK

10STB

2L-OUT

3L-IN

4L-A-GND 13 R-A-GND

GND

OUT

A-SW

5L-IN

6L-OUT

A-SW

LATCH CIRCUIT

LEVEL SHIFTER

OUT

GND

A-SW

LATCH CIRCUIT

A-SW

12 R-IN

11 R-OUT

OUT

GND

Page 41

WIRING DIAGRAM

FUSE

BLUE

BROWN

S-VIDEO BOARD

VIDEO BOARD

MAIN BOARD

AC OUTLET BOARD

POWER BOARD

KEY BOARD

DTS BOARD

VOL BOARD

TUNER BOARD

EXT 5.1 BOARD_OUTPUT

EXT 5.1 BOARD _SUB&C

EXT 5.1 BOARD _SR&SL

EXT 5.1 BOARD _FR&FL

PHONE BOARD

RED

LED

GTP-760

Page 42

43 44

MAIN BOARD - TOP VIEW

PCB LAYOUT GTP-760

Page 43

4645

MAIN BOARD - BOTTOM VIEW

PCB LAYOUT GTP-760

Page 44

47 48

PCB LAYOUT GTP-760

VIDEO BOARD - TOP VIEW

VIDEO BOARD - BOTTOM VIEW

Page 45

PCB LAYOUT GTP-760

TUNER BOARD

Page 46

PCB LAYOUT GTP-760

S-VIDEO BOARD - TOP VIEW S-VIDEO BOARD - BOTTOM VIEW

Page 47

PCB LAYOUT GTP-760

KEY BOARD

- TOP VIEW

KEY BOARD

- BOTTOM VIEW

Page 48

PCB LAYOUT GTP-760

DTS BOARD - TOP VIEW DTS BOARD - TOP VIEW

Page 49

PCB LAYOUT GTP-760

POWER BOARD

EXT5.1 BOARD (OUTPUT)

EXT5.1 BOARD (FL, FR)

EXT5.1 BOARD (Sub, C)

EXT5.1 BOARD (SL, SR)

PHONE BOARD

Page 50

PCB LAYOUT GTP-760

VOLUME BOARD - TOP VIEW

VOLUME BOARD - BOTTOM VIEW

AC OUTLET BOARD - TOP VIEW (UL only) AC OUTLET BOARD - BOTTOM VIEW (UL only)

Page 51

SCHEMATIC DIAGRAM GTP-760

TUNER (AUDIO OUTPUTS)

Page 52

SCHEMATIC DIAGRAM GTP-760

S-VIDEO BALL SYSTEM ON/OFF SELECTOR

Page 53

SCHEMATIC DIAGRAM GTP-760

COMPOSITE VIDEO & REMOTE

Page 54

SCHEMATIC DIAGRAM GTP-760

AUDIO I/O

Page 55

SCHEMATIC DIAGRAM GTP-760

CHANNELS OUTPUT

Page 56

SCHEMATIC DIAGRAM GTP-760

AUDIO BOARD VOLUME MOTOR PORT

Page 57

GTP-760SCHEMATIC DIAGRAM

POWER SUPPLY

Page 58

SCHEMATIC DIAGRAM GTP-760

KEYBOARD

Page 59

6463

SCHEMATIC DIAGRAM GTP-760

ADD EXT. 5.1 INPUTS

Page 60

65 66

DTS INPUTS

SCHEMATIC DIAGRAM GTP-760

Page 61

SCHEMATIC DIAGRAM GTP-760

S_VIDEO INPUTS SELECTOR & OSD CONTROLLER

Page 62

GTP-760SCHEMATIC DIAGRAM

TUNER (FRONT END & DATA PORTS)

Page 63

TECHNICAL SPECIFICATION GTP-760

FM SPECIFICATION

Frequency Range: 87.5 to 108.1±0.02MHz

Specification Details Freq. Unit Limit(AH) Limit(C)

1. Input sensitivity (1KHz, 3% THD) 97.7MHz dBµ ≤17 ≤27 (U: mond. 75KHz) (C: mond. 40KHz)

2. 50dB quieting Stereo 97.7MHz dBµ ≤43 ≤437 (mod. 75KHz) Mono 97.7MHz dBµ ≤20 ≤28

3. S/N Ratio (mod. 75KHz) (60dBf IHF wtd) Stereo 97.7MHz dB ≥62 ≥57

Mono 97.7MHz dB ≥70 ≥70

4. THD (60dBµ IHF wtd) Stereo 97.7MHz % ≤0.40 ≤0.40 (U: Mod. 75KHz) L+R (C: Mod. 40KHz) L-R 97.7MHz % ≤0.70 ≤0.70

5. IF Rejection (10.7MHz) 97.7MHz dB ≥65 ≥75 (U: mod. 75KHz) (C: mod. 40KHz)

6. Image Rejection (119.4MHz) 97.7MHz dB ≥58 ≥65 (U: mond. 75KHz) (C: mond. 40KHz)

7. Capture ratio (45dBf) 97.7MHz dB ≤2 ≤1 (U: mod. 75KHz) (C: mod. 40KHz)

8. AM suppression 97.7MHz dB ≥55 ≥50 @60dBf mod. 75KHz

9. Pilot suppression L 97.7MHz dB ≥55 ≥55 (mod. 75KHz) R 97.7MHz dB ≥55 ≥55

10. Frequency response In In between 30Hz & 15kHz (1kHz Ref, 75usec). (U: mod 75KHz) dB 0±1 (1kHz Ref, 50usec). (U: mod 40KHz) dB 0±1.5

11. Channel Separation 30Hz 97.7MHz dB ≥30 ≥30 (@60dBµ) 1kHz dB ≥35 ≥32 (U: mod. 75KHz) 10kHz dB ≥30 ≥27 (C: mod. 40KHz)

12. Alternate channel selectivity. (@45dBf) (U: mod. 75KHz) +400KHz dB ≥55 ≥65 (C: mod. 40KHz) -400KHz ≥55 ≥65

13. Auto-search sensitivity dBµ 18 to 32 18 to 32 (U: mod. 75KHz) (C: mod. 40KHz) Remark: The TUNER measurement will be taken from the TAPE output for FM/AM.

2AM BAND SPECIFICATION

Frequency Range: 520KHz - 1720KHz Set 10KHz

Freq. Unit Limit

1. Input Sensitivity 1000kHz dBµ ≤24 (10% THD)

2. S/N Ratio 1000kHz dB ≥45 (@2mV 66dBµ input)

3. THD 1000kHz % ≤3 (30% mod@ 1KHz 66dBµ)

4. Image Rejection (LO + 2*IF) 1900KHz dB ≥30

Page 64

TECHNICAL SPECIFICATION GTP-760

5. IF Rejection 450KHz dB ≥35

6. Selectivity 1050KHz dB ≥20 (+/-10KHz avg2)

7. Search tuning Sensitivity 1000kHz dBµ 20±7

GENERAL AUDIO SPECIFICATION - 1

CD (SONY YEDS7) Surround Mode: FL /FR_2channel stereo Input source: Digital input

Specification Details T

rack Unit Limit

1. Output level (Vol max.) 19 (1KHz) Vrms 1.29±0.2 Input - 20dB signal

2. L/R channel difference 19 (1KHz) dB + / -0.5

3. Frequency response 2-13 dB + / -0.5 (Track 1, 1KHz 0dB for reference, 2Vrms output)

4. Volume control tracking 14 (0dB) dB 0±0.01 (Track 1, 1KHz 0dB for reference) 19 (-20dB) dB -20±0.1 2Vrms output, insert 20Khz LPF. 20 (-60dB) dB -60±0.3

5. Harmonic distortion (insert Audio LPF) 1 (1KHz) % ≤0.08 (2Vrms output) 4 (100hz0 % ≤0.08

10 (10Khz0 % ≤0.08

6. Signal to noise ratio STOP Audio LPF dB ≥85 Output level: 2Vrms A-WTD LPF dB ≥85

PAUSE Audio LPF dB ≥85

A-WTD LPF dB ≥85

Play 23 Audio LPF dB ≥85

A-WTD LPF dB ≥85 CCIR/ARM dB ≥85

Play 24 Audio LPF dB ≥85

A-WTD LPF dB ≥85 CCIR/ARM dB ≥85

8. Channel separation 30,34 (1KHz) dB ≥75 (insert 20 KHz L.P.F.), Output level: 2Vrms

GENERAL AUDIO SPECIFICATION - 2

LD (DOLBY ver. 2.0) Input source: Digital RF

Specification Details T

rack Unit Limit

1. Output level (Vol max.) B, 4 Vrms 1.29±0.2 (FL, FR, C, SL, SR) at config 1

2. Channel difference B, 4 dB ±1.2 (FL, FR, C, SL, SR) at config 1

3. Frequency response (set B4) SL. B34 (200-20KHz) dB ±0.8 at config 0 (set B4) SR. B36 (200-20KHz) dB ±0.8

(set B4) C. B30 (200-20KHz) dB ±0.8

at config 1 (set B4) LFE. B38 (20-80Hz) dB ±4.0

4. Harmonic distortion at 0.2Vrms SL. B4 (997Hz) % ≤0.08 (insert Audio LPF) at config 1. SR. B4 (997Hz) % ≤0.08

C. B4 (997Hz) % ≤0.08

at config 2 LFE. A41 (30Hz) % ≤0.03

Page 65

TECHNICAL SPECIFICATION GTP-760

5. Signal to noise ratio (B, 6 for output) CCIR/ARM dB ≥65 100mV and play A27 config 1 and 2.) 200Hz Notch (FL, FR, C, SL, SR) and 400Hz HPF.

PAUSE Audio LPF dB ≥70

A-Wtd dB ≥70

6. Channel separation A, 31 (997Hz) dB ≥75 (insert 20KHz L.P.F.)

7. Set config 2 at 1Vrms output (sub) A71 (30Hz) dB +10.5±1.0 as ref. and measure FL/FR output center and rear delay set to 0ms

GENERAL AUDIO SPECIFICATION - 3

DVD (DOLBY 1.0) Input source: Digital input

Specification Details T

rack Unit Limit

1. Output level (Vol max.) 30 Vrms 1.29±0.2 (FL, FR, C, SL, SR) at config 1

2. Channel difference, FL set ref. 30 dB ±1.2 (FL, FR, C, SL, SR) at config 1

3. Frequency response (set 30) SL. 46 (200-20KHz) dB ±0.8 at config 0 (set 30) SR. 47 (200-20KHz) dB ±0.8

(set 30) C. 44 (200-20KHz) dB ±0.8

at config 0 (set 30Hz) LFE. 48 (20-80) dB ±4.0

4. Harmonic distortion at 0.2Vrms SL. 30 (997Hz) % ≤0.08 (insert Audio LPF) at config 1. SR. 30 (997Hz) % ≤0.08

C. 30 (997Hz) % ≤0.08

at 2Vrms LFE. 70 (30Hz) % ≤0.03

5. Signal to noise ratio (31 for output) CCIR/ARM dB ≥65 100mV and play 63 config 1 and 2.) 200Hz Notch (FL, FR, C, SL, SR) and 400Hz HPF.

PAUSE Audio LPF dB ≥70

A-Wtd dB ≥70

6. Channel separation 65 (997Hz) dB ≥75 (insert 20KHz L.P.F.)

7. Set config 2 at 1Vrms output (sub) 70 (30Hz) dB +10.5±1.0 as ref. and measure FL/FR output center and rear delay set to 0ms

GENERAL AUDIO SPECIFICATION - 4

Surround mode: 2 channels (FL & FR channels) Input source: Analog input (audio analyser) Input level: 2.0V unless specified.

Specification Details Freq.

Unit Limit

1. THD w/ 20kHz LPF, output=2Vrms 1kHz % ≤0.08

2. S/N ratio A-wtd w/1K termination, output=2Vrms 1kHz db ≥70

3. Sensitivity input level=400mV, max vol. 1kHz V 2.25±0.2

4. Channel separation 80kHz LPF w/ 1K termination 1kHz dB ≥60 output=2Vrms 10kHz dB ≥40

Page 66

TECHNICAL SPECIFICATION GTP-760

5. Channel difference (L-ch & R-ch) 1kHz dB 0±0.65

6. Frequency response input=2V, output=2Vrms, 1kHz ref. 20Hz dB 0±0.8

20kHz dB 0±0.8

7. Headphone THD input=2Vrms, output=4Vrms 1kHz % ≤0.08 w/20KHz LPF

8. Headphone level output level (L-ch & R-ch) 1kHz V 2.0±0.2 max. vol input=150mV

GENERAL AUDIO SPECIFICATION - 5

DTS (CD Music Demonstration and Set-up Disc) Input source: Digital input Volume: Max. vol

Specification Details T

rack. Unit Limit

1. Output level 6 (1kHz) Vrms 2.0±0.2 (FL, FR, C, SL, SR) at config.1

2. Channel difference, FL set ref. 6 (1kHz) dB ±1.0 (FR, C, SL, SR) at config.1

3. Harmonic distortion (FL, FR, C, SL, SR) at config.1 6 (1kHz) % ≤0.06 W/ 20 KHz LPF

4. Frequency response (20Hz to 20kHz) (FL, FR, C, SL, SR) at config.0 15 dB ±0.08

5. Subwoofer output level (set 1kHz as ref at FL) at config.1 6 (1kHz) dB -1.2±0.5

SURROUND MODES

Surround mode: prologic (FL, FR, C, SL and SR channels) Input source: Analog input Speak size: preset 1 Input level: 2.0Vrms Output level: 4.0±0.5Vrms

Specification Details Freq.

Unit Channel Limit

1. Channel separation Input mode: L, R Measure output at unexpected 1kHz dB R, L ≥45 output channel 1kHz dB C ≥30

1kHz dB SL, SR ≥35 Input mode: L=-R Measure output at unexpected 1kHz dB R, L ≥30

1kHz dB C ≥30 Input mode: L=R Measure output at unexpected 1kHz dB L, R ≥20

1kHz dB SL, SR ≥30

2. Frequency Response Input mode: L, R input level=2V 20Hz dB L, R 0±0.8 (1kHz ref.) 20kHz dB L, R 0±0.8

Page 67

TECHNICAL SPECIFICATION GTP-760

Input mode: L=R input level=2V 300Hz dB C 0±0.8

20kHz dB C 0±0.8 Input mode: L=-R input level=2V 30Hz dB SL, SR -1.0±1.0

3. THD Input voltage 2.0V w/ 80kHz LPF 1kHz % ≤0.08

4. S/N ratio Input level=2.0V, (A-WTD w/1k termination) Input mode: L, R 1kHz dB L, R ≥70 Input mode: L=R 1kHz dB C ≥70 Input mode: L=-R 1kHz dB SL, SR ≥70

ROOM2 FUNCTION

Surround mode: 2 channels (FL & FR channels) Input source: Analog input (audio analyser) - CD input Room2 level: -10 unless specified Input level: 2.0V

Specification Details Freq.

Unit Limit

1. THD+N Adjust the input level, @5.0Vrms output w/ 80kHz LPF 1kHz % ≤0.08

2. S/N ratio A-wtd w/ 1K termination 1kHz dB ≥80

3. Sensitivity Input level=1V 1kHz V 5.4±0.5

4. Output level Adjust the input level, THD=0.1% 1kHz V ≥5.5

5. Channel difference 1kHz dB 0±1.0

6. Frequency response Input=2V, 1kHz ref. 20Hz dB 0±0.5

20kHz dB 0±0.5

EXT 5.1 CHANNEL MODES

Surround mode: (EXT 5.1 channels) Input source: Analog input Input level: 1.0Vrms Output level: 2.0±0.2Vrms

Specification Details Freq.

Unit Channel Limit

1. Channel separation Input mode: L, R Measure output at unexpected 1kHz dB R, L ≥75 output channel 1kHz dB C ≥75

1kHz dB SL, SR ≥75

1kHz dB Sub ≥75 Input mode: L=-R Measure output at unexpected 1kHz dB R, L ≥30

1kHz dB C ≥30

Page 68

TECHNICAL SPECIFICATION GTP-760

2. Frequency Response Input mode: L, R input level=1V 20Hz dB L, R 0±0.5 (1kHz ref.) 20kHz dB L, R 0±0.5 Input mode: Center input level=1V 20Hz dB C 0±0.5

20kHz dB C 0±0.5 Input mode: SL, SR input level=1V 20Hz dB SL, SR 0±0.5

20kHz dB SL, SR 0±0.5 Input mode: Sub input level=1V 20Hz dB Sub 0±0.5

20kHz dB Sub 0±0.5

3. Sensitivity Input mode: L, R Input level=100mV, Max vol 1kHz V L, R 1.2±0.2 Input mode: Center 1kHz V C 1.0±0.2 Input mode: SL, SR 1kHz V SL, SR 1.0±0.2 Input mode: Sub 1kHz V Sub 1.0±0.2

Mar2001

A0162C-SM00A

Adcom GTP-760 Service manual

Specifications and Main Features

Frequently Asked Questions

User Manual