Page 1
848C2A93B1-E (709)
CHAIN SAW
September 2007
NOTE :
1. Use ZENOAH genuine parts specified in the parts list for repair and/or replacement.
2. ZENOAH does not warrant the machines, those which have been damaged by the use of any parts
other than those specified by the company.
3. When placing orders of parts for repair and/or replacement, check if the model name and the serial
number are suitable to those specified in the parts list, then use parts number described in the
parts list.
4. The contents described in the parts list may change due to improvement.
5. The parts for the machine shall be supplied within ten (10) years after the machine is discontinued.
[It is possible that some specific parts may be subject to change of their delivery term and list price
within the limit of ten (10) years after the machine is discontinued. And it is also possible that some
parts may be available even after the limit of ten (10) years.]
APPLICABLE SERIAL NUMBERS : 065242001 and up
G3200
PARTS LIST
Page 2
Fig.1 POWER UNIT
G3200
Page 3
Q'TY
Key# PART NUMBER DESCRIPTION NOTE
/UNIT
80 848C205421 • WEIGHT 1
81 2872-54230 • SPRING 1
82 2851-54270 • SPRING 1
83 01641-20510 • WASHER 1
84 3310-53331 • NUT(B) 1
85 2851-54301 • LEVER COMP. 1
86 2851-54350 • PIN 1
87 2670-54411 • ARM 1
88 2872-54510 • BAND 1
89 3356-24140 • PIN 1
90 2670-54610 • SPRING BRAKE 1
91 2872-54623 • COVER SPRING 1
92 2630-33610 • SCREW 3
93 – LABEL 1
94 3350-53410 NUT 1
95 2870-53310 PLATE(A) 1
96 2630-53330 SCREW 1
97 50032011 NUT(A) 1
98 2630-53412 CATCHER 1
99 2630-32170 SCREW 1
100 2630-55102 OIL PUMP ASSY 1
101 2630-55160 • GEAR WORM 1
102 0261-00416 SCREW 2
103 2630-55211 PLATE WORM 1
104 2630-55251 SEAL 1
105 2630-55312 COVER PUMP 1
106 2630-31950 SCREW 2
107 50030143 ROTOR ASSY 1
108 004000140 • PAWL 2
109 50030112 • SPRING 2
110 004000436 • PIN 2
111 2634-71110 MODULE 1
112 5500-72110 CAP 1
113 1900-72120 SPRING 1
114 T1512-71320 TUBE 1
115 2634-06711 SWITCH SET 1
116 2634-71120 • CORD EARTH 1
117 2630-72610 • WIRE SWITCH 1
118 5500-72150 SPACER 2
119 3310-72150 BOLT 2
120 3699-90030-10 SPARK PLUG 1
121 50042009 STARTER ASSY 1
122 50042010 • CASE COMP. 1
123 3330-75121 • • GUIDE 1
124 094000033A • REEL 1
125 1260-75151 • ROPE 1
126 072700091 • KNOB 1
127 004000132R • SPRING 1
128 2873-75410 • WASHER 1
129 094600041 • SCREW 1
130 50030161 • COVER FAN 1
131 2630-33610 • SCREW 1
132 2630-31950 SCREW 4
133 – LABEL 1
134 T2054-81000 CARBURETOR ASSY 1
135 3310-82110 WASHER 1
136 2875-82120 CHOKE PLATE 1
137 2630-82140 SCREW 2
138 2873-82151 THROTTLE ROD 1
139 2630-82160 GROMMET 1
140 2630-82210 GROMMET(A) 1
141 2875-82221 GROMMET(B) 1
142 2630-82311 CHOKE ROD 1
143 3320-33310 GROMMET 1
145 2630-98500 COVER ASSY 1
146 2630-83120 • KNOB 1
147 0308-00040 • SNAP RING 1
148 2630-83511 CLEANER 1
149 2870-83610 ELEMENT 1
150 – LABEL 1
151 – LABEL(CE) 1
152 T2052-31260 PIPE 2
153 2841-37150 JOINT 1
154 2850-81900 PUMP 1
Q'TY
Key# PART NUMBER DESCRIPTION NOTE
/UNIT
1 T2050-06050 SHORT BLOCK ASSY 1
2 T2050-12110 • CYLINDER 1
3 T2050-21110 • CRANKCASE 1
4 01252-30530 • BOLT 4
5 2870-41111 • PISTON 1
6 3319-41210 • RING 1
7 3304-41310 • PIN 1
8 3310-41320 • SNAP RING 2
9 3310-41410 • BEARING 1
10 1650-41510 • WASHER 2
11 2870-42002 • CRANKSHAFT COMP. 1
12 06030-06201 • BEARING 2
13 2630-43150 • OIL SEAL 1
14 04065-03212 • SNAP RING 1
15 2169-21210 • OIL SEAL 1
16 T2050-15100 MUFFLER ASSY 1
17 2630-15211 GASKET 1
18 3330-15220 BOLT 2
19 2870-22102 VALVE ASSY 1
20 2870-22211 GASKET 1
21 3330-14121 GASKET 1
22 5004024 ENGINE CASE COMP. 1
23 2870-31510 VALVE 1
24 T2052-31200 FUEL PIPE ASSY 1
25 1492-85410 • PIPE 1
26 1850-85300 • FILTER ASSY 1
27 1260-85460 • CLIP 2
28 3350-34320 • ELBOW 1
29 50030318 • GROMMET 1
30 3317-86100 BREATHER ASSY 1
31 50032019 OIL PIPE ASSY 1
32 2630-31321 • GROMMET 1
33 2873-31330 • JOINT 1
34 2630-31350 • FILTER 1
35 1492-85410 • PIPE 1
36 1492-85410 PIPE 1
37 3370-31210 PIN 1
38 2630-31510 VALVE ASSY 1
39 2870-22251 SEAL 1
40 2630-31650 CAP 1
41 2870-31750 SCREW M5x16 4
42 2841-31800 CAP ASSY 2
43 2630-31820 • GASKET 2
44 2630-31913 COVER FRONT 1
45 2630-31950 SCREW 2
46 50040056 FRONT HANDLE ASSY 1
47 2630-32121 • JOINT(A) 1
48 2630-32151 • STOPPER 1
49 2630-32170 • SCREW 1
50 2630-32170 SCREW 1
51 2630-32610 SCREW 2
52 50042011 REAR HANDLE COMP. 1
53 3330-33250 • STOPPER 1
54 3310-33262 • SPRING 1
55 3310-33271 • KNOB 1
56 2873-33312 THROTTLE LEVER 1
57 3356-33321 SPRING 1
58 04025-00524 PIN 1
59 848C3033E3 ARM 1
60 50040170 COVER GRIP 1
61 2630-31950 SCREW 1
62 2630-33511 JOINT(B)(HARD) 1
63 2873-33520 JOINT(C)(SOFT) 2
64 2640-33530 BOLT 3
65 2630-33610 SCREW 6
66 004000142 NUT 1
67 2873-43240 WASHER 1
68 005000361 WASHER 1
69 2872-51111 CLUTCH DRUM 1
70 50030089 BEARING 1
71 848C205121 CLUTCH ASSY 1
72 2870-51230 • SPRING 1
73 2873-98610 PLATE 1
74 50042007 CHAINBRAKE ASSY 1
75 50040174 • GUARD 1
76 2872-54120 • SPRING 1
77 0263-80530 • SCREW 1
78 2872-54140 • SPACER 1
79 2850-54211 • SPACER 1
Fig.1 POWER UNIT
G3200
Page 4
Fig. 2 CARBURETOR COMPONENTS & ACCESSORIES
G3200
Page 5
Q'TY
Key# PART NUMBER DESCRIPTION NOTE
/UNIT
Q'TY
Key# PART NUMBER DESCRIPTION NOTE
/UNIT
1 T2054-81000 CARBURETOR ASSY 1
2 3306-81380 • SCREEN 1
3 T2052-81120 • PUMP COVER 1
4 3310-81130 • SCREW 1
7 3310-81230 • METERING LEVER 1
8 3310-81240 • SCREW 1
9 3310-81250 • PIN 1
10 3310-81280 • COVER 1
11 2841-81270 • SPRING 1
12 3356-81310 • NEEDLE VALVE 1
13 2630-81330 • SCREW 1
14 3350-81380 • SPRING 1
15 2875-81370 • SHAFT ASSY 1
16 2670-81410 • SPRING 1
17 3310-81341 • THROTTLE VALVE 1
18 2880-81470 • SCREW 2
19 3310-81351 • SCREW 4
22 1480-81420 • PLUG 1
23 2630-81440 • LEVER 1
24 1148-81390 • RING 1
26 T2050-06020 GASKET/DIAPHRAGM KIT 1
27 3606-52113 BAR12" 1
28 3607-52112-50 BAR14" 1
29 2931-52210-50 CHAIN 91VG-52E 1 14”
30 3606-52211-50 CHAIN 91VG-45E 1 12”
31 3617-97110 PROTECTOR 1
32 2304073 WRENCH 1
Fig. 2 CARBURETOR COMPONENTS & ACCESSORIES
G3200
Loading...