Zebra Technologies RFD5500 User Manual

RFD5500

72-165189-01 Revision C — January 2013

Draft

REGULATORY GUIDE

Motorola reserves the right to make changes to any product
to improve reliability, function, or design. Motorola does not
assume any product liability arising out of, or in connection
with, the application or use of any product, circuit, or
application described herein. No license is granted, either
expressly or by implication, estoppel, or otherwise under any
patent right or patent, covering or relating to any
combination, system, apparatus, machine, material,
method, or process in which Motorola products might be
used. An implied license exists only for equipment, circuits,
and subsystems contained in Motorola products.

Motorola Solutions, Inc.
One Motorola Plaza
Holtsville, New York 11742, USA
1-800-927-9626

http://www.motorolasolutions.com

MOTOROLA, MOTO, MOTOROLA SOLUTIONS and the
Stylized M Logo are trademarks or registered trademarks of
Motorola Trademark Holdings, LLC and are used under
license. All other trademarks are the property of their
respective owners. © 2013 Motorola, Inc. All Rights Reserved.

Regulatory Information

This device is approved under Motorola Solutions, Inc.
This guide applies to Model Number RFD5500 and

accessories.
All Motorola Solutions devices are designed to be compliant

with rules and regulations in locations they are sold and will
be labeled as required.

Local language translations are available at the following
website:

www.motorolasolutions.com/support.

Any changes or modifications to Motorola Solutions
equipment, not expressly approved by Motorola Solutions,
could void the user’s authority to operate the equipment.

CAUTIONOnly use Motorola Solutions approved and UL

Listed accessories, battery packs and battery
chargers.

Do NOT attempt to charge damp/wet mobile
computers or batteries. All components must be
dry before connecting to an external power
source.

Declared maximum operating temperature: 50°C

.

Power Supply

Use ONLY a Motorola approved UL LISTED ITE (IEC/EN
60950-1, LPS) power supply with electrical ratings: Output

5.4 Vdc, min 3A, with a maximum ambient temperature of at
least 50 degrees C. Use of alternative Power Supply will
invalidate any approvals given to this unit and may be
dangerous.

Accessories

Use only a Motorola approved power supply with output rated
as follows:

Model Description PSU Rating

CRD5500-1000 Single Slot USB Cradle 12 VDC, minimum

3.33 A

CRD5500-4000XR Four Slot Charge Only

Cradle

25-108022-02R USB Charge Cable 5.4 VDC, minimum

25-112560-01R Charge Only Cable 5.4 VDC, minimum

SAC2000-4000CR Four Slot RFID Battery

Charger

12 VDC, minimum
9 A

3 A

3 A

12 VDC, minimum

3.33 A

Wireless Device Country Approvals

Regulatory markings, subject to certification, are applied to
the device signifying the radio(s) is/are approved for use in
the following countries: United States, Canada, and Europe

Please refer to the Motorola Declaration of Conformity (DoC)
for details of other country markings. This is available at:

www.motorola.com/doc.

Note1: Europe includes, Austria, Belgium, Bulgaria, Czech

Republic, Cyprus, Denmark, Estonia, Finland, France, Germany,
Greece, Hungary, Iceland, Ireland, Italy, Latvia, Liechtenstein,
Lithuania, Luxembourg, Malta, Netherlands, Norway, Poland,
Portugal, Romania, Slovak Republic, Slovenia, Spain, Sweden,
Switzerland and the United Kingdom.

Operation of the device without regulatory approval is illegal.

1

Health and Safety Recommendations

Ergonomic Recommendations

CAUTIONIn order to avoid or minimize the potential risk of

ergonomic injury follow the recommendations
below. Consult with your local Health & Safety
Manager to ensure that you are adhering to
your company's safety programs to prevent
employee injury.

•

Reduce or eliminate repetitive motion

•

Maintain a natural position

•

Reduce or eliminate excessive force

•

Keep objects that are used frequently within easy reach

•

Perform tasks at correct heights

•

Reduce or eliminate vibration

•

Reduce or eliminate direct pressure

•

Provide adjustable workstations

•

Provide adequate clearance

•

Provide a suitable working environment

•

Improve work procedures.

Warnings for Use of Wireless Devices

Please observe all warning notices with regard to the

usage of wireless devices.

Safety in Hospitals

Wireless devices transmit radio frequency energy and may
affect medical electrical equipment.

Wireless devices should be switched off wherever you are
requested to do so in hospitals, clinics or healthcare facilities.
These requests are designed to prevent possible interference
with sensitive medical equipment.

Pacemakers

Pacemaker manufacturers recommended that a minimum of
15 cm (6 inches) be maintained between a handheld wireless
device and a pacemaker to avoid potential interference with
the pacemaker. These recommendations are consistent with
independent research and recommendations by Wireless
Technology Research.

Persons with Pacemakers:
Should ALWAYS keep the device more than 15cm (6 inches)

from their pacemaker when turned ON.
Should not carry the device in a breast pocket.
Should use the ear furthest from the pacemaker to minimise

the potential for interference.
If you have any reason to suspect that interference is taking

place, turn OFF your device.

Other Medical Devices

Please consult your physician or the manufacturer of the
medical device, to determine if the operation of your wireless
product may interfere with the medical device.

RF Exposure Guidelines

Safety Information

Reducing RF Exposure – Use Properly

Only operate the device in accordance with the instructions
supplied.

Handheld Devices

International

The device complies with internationally recognized
standards covering human exposure to electromagnetic
fields from radio devices. For information on “International”
human exposure to electromagnetic fields refer to the
Motorola Solutions Declaration of Conformity (DoC) at:

www.motorola.com/doc.

Europe

To comply with EU RF exposure requirements, this device
must be operated in the hand with a minimum separation
distance of 23cm or more from a person's body. Other
operating configurations should be avoided.

Co-located Statement

To comply with FCC RF exposure compliance requirement,
the antenna used for this transmitter must not be co-located
or operating in conjunction with any other transmitter/antenna
except those already approved in this filling.

To comply with FCC RF exposure requirements, this device
must be operated in the hand with a minimum separation
distance of 23 cm or more from a person's body. Other
operating configurations should be avoided.

Radiation Exposure Statement

This equipment complies with IC radiation exposure limits set
forth for an uncontrolled environment. This equipment should
be installed and operated with minimum distance 23cm
between the radiator and your body.

NOTE IMPORTANTE: (Pour l'utilisation de dispositifs
mobiles)

Déclaration d'exposition aux radiations:

Cet équipement est conforme aux limites d'exposition aux
rayonnements IC établies pour un environnement non
contrôlé. Cet équipement doit être installé et utilisé avec un
minimum de 23 cm de distance entre la source de
rayonnement et votre corps.

Batteries

Taiwan - Recycling

EPA (Environmental Protection
Administration) requires dry battery
producing or importing firms in
accordance with Article 15 of the
Waste Disposal Act are required to
indicate the recycling marks on the batteries used in sales,
giveaway or promotion. Contact a qualified Taiwanese
recycler for proper battery disposal.

Batteries

Battery Information

Use only Motorola approved batteries. Accessories which
have battery charging capability are approved for use with the
following battery models:
Motorola 82-108066-01 (3.7 Vdc, 2400 mAh)

Motorola Solutions rechargeable battery packs are designed
and constructed to the highest standards within the industry.

However, there are limitations to how long a battery can
operate or be stored before needing replacement. Many
factors affect the actual life cycle of a battery pack, such as
heat, cold, harsh environmental conditions and severe drops.

When batteries are stored over six (6) months, some
irreversible deterioration in overall battery quality may occur.
Store batteries at half of full charge in a dry, cool place,
removed from the equipment to prevent loss of capacity,
rusting of metallic parts and electrolyte leakage. When storing
batteries for one year or longer, the charge level should be
verified at least once a year and charged to half of full charge.

Replace the battery when a significant loss of run time is
detected.

Standard warranty period for all Motorola Solutions batteries
is one year, regardless if the battery was purchased
separately or included as part of the mobile computer or bar
code scanner.

CAUTION Risk of explosion if battery is replaced by an

incorrect type.
Dispose of batteries according to instructions.

Battery Safety Guidelines

•

The area in which the units are charged should be clear of
debris and combustible materials or chemicals. Particular
care should be taken where the device is charged in a non
commercial environment.

•

Follow battery usage, storage, and charging guidelines
found in the user's guide.

•

Improper battery use may result in a fire, explosion, or
other hazard.

•

To charge the mobile device battery, the battery and
charger temperatures must be between +32 ºF and +104
ºF (0 ºC and +40 ºC)

•

Do not use incompatible batteries and chargers. Use of an
incompatible battery or charger may present a risk of fire,
explosion, leakage, or other hazard. If you have any
questions about the compatibility of a battery or a charger,
contact Motorola Solutions support.

•

For devices that utilize a USB port as a charging source,
the device shall only be connected to products that bear
the USB-IF logo or have completed the USB-IF compliance
program.

•

Do not disassemble or open, crush, bend or deform,
puncture, or shred.

•

Severe impact from dropping any battery-operated device
on a hard surface could cause the battery to overheat.

•

Do not short circuit a battery or allow metallic or conductive
objects to contact the battery terminals.

•

Do not modify or remanufacture, attempt to insert foreign
objects into the battery, immerse or expose to water or
other liquids, or expose to fire, explosion, or other hazard.

1 2 3 4

•

Draft

Do not leave or store the equipment in or near areas that
might get very hot, such as in a parked vehicle or near a
radiator or other heat source. Do not place battery into a
microwave oven or dryer.

•

Battery usage by children should be supervised.

•

Please follow local regulations to promptly dispose of used
re-chargeable batteries.

•

Do not dispose of batteries in fire.

•

Seek medical advice immediately if a battery has been
swallowed.

•

In the event of a battery leak, do not allow the liquid to
come in contact with the skin or eyes. If contact has been
made, wash the affected area with large amounts of water
and seek medical advice.

•

If you suspect damage to your equipment or battery,
contact Motorola Solutions support to arrange for
inspection.

Radio Frequency Interference Requirements­FCC

Note: This equipment has been tested and
found to comply with the limits for a Class
B digital device, pursuant to Part 15 of the

FCC rules. These limits are designed to
provide reasonable protection against harmful interference in
a residential installation. This equipment generates, uses and
can radiate radio frequency energy and, if not installed and
used in accordance with the instructions, may cause harmful
interference to radio communications. However there is no
guarantee that interference will not occur in a particular
installation. If this equipment does cause harmful interference
to radio or television reception, which can be determined by
turning the equipment off and on, the user is
try to correct the interference by one or more of the following
measures:

•

Reorient or relocate the receiving antenna

•

Increase the separation between the equipment and
receiver

•

Connect the equipment into an outlet on a circuit different
from that to which the receiver is connected

•

Consult the dealer or an experienced radio/TV technician
for help.

Radio Transmitters (Part 15)

This device complies with Part 15 of the FCC Rules.
Operation is subject to the following two conditions: (1) this
device may not cause harmful interference, and (2) this
device must accept any interference received, including
interference that may cause undesired operation.

Radio Frequency Interference Requirements­Canada

This Class B digital apparatus complies with Canadian ICES-

003.
Cet appareil numérique de la classe B est conforme à la

norme NMB-003 du Canada.

encouraged to

Radio Transmitters

This device complies with RSS 210 of Industry & Science
Canada. Operation is subject to the following two conditions:
(1) this device may not cause harmful interference and (2)
this device must accept any interference received, including
interference that may cause undesired operation.

Ce dispositif est conforme à la norme CNR-210 d'Industrie
Canada applicable aux appareils radio exempts de licence.
Son fonctionnement est sujet aux deux conditions suivantes:
(1) le dispositif ne doit pas produire de brouillage
préjudiciable, et (2) ce dispositif doit accepter tout brouillage
reçu, y compris un brouillage susceptible de provoquer un
fonctionnement indésirable.

Label Marking: The Term “IC:” before the radio certification
only signifies that Industry Canada technical specifications
were met.

Marking and European Economic Area (EEA)

Statement of Compliance

Motorola Solutions hereby, declares that this device is in
compliance with the essential requirements and other
relevant provisions of Directives 1999/5/EC. Declaration of
Conformities may be obtained from:
http://www.motorola.com/doc.

Korea Warning Statement for Class B ITE

韥눺ꙹ ꩡ끞녅껽驩ꓭ

% 鞾韥韥

閵뇊끞 ꗞꭖ뭪겕韥韥

넩韥韥鱉閵뇊끞 % 鞾  냱ꈑ놹녅볁놶뼞麦ꈒ냹

뼑韥韥ꈑ꫑늱ꈑ閵뇊꾅꫑ꩡ끞뼍鱉阸냹ꑞ놶
냱ꈑ뼍ꐥ ꑝ麕덵꾢꾅꫑ꩡ끞뼕ꯍ넽걪鱽鲙 

Other Countries

Brazil

Declarações Regulamentares para RFD5500 - Brasil

Nota: “A marca de certificação se aplica ao Transceptor,
modelo RFD5500. Este equipamento opera em caráter
secundário, isto é, não tem direito a proteção contra
interferência prejudicial, mesmo de estações do mesmo tipo,
e não pode causar interferência a sistemas operando em
caráter primário.”

Para maiores informações sobre ANATEL consulte o site:
www.anatel.gov.br

Chile

“Este equipo cumple con la Resolución No 403 de 2008, de
la Subsecretaria de telecomunicaciones, relativa a
radiaciones electromagnéticas.”

China

Taiwan

咉䋲
⇝┮䘖榊㽱懊⺓㊶榊㳮丰䚕戵㽤
䶻◐ℛ㬬
倢⨚㆞崜巘⚗㫋󱁻⇝┮䘖⺓櫊榊㳮᧨槭倢峀♾᧨⏻⚇ᇬ⟕壮㒥∎䞷

劔⧖ₜ㈦㝔呹帙㦃櫊䘖ᇬ┯⮶┮䘖㒥帙㦃☮岼岗󱁻䔈㊶♙┮厌ᇭ
䶻◐⥪㬬
⇝┮䘖⺓櫊榊㳮󱁻∎䞷ₜ㈦㈀檎歪咹⸘⏷♙㄁㞍⚗㽤抩≰᧷倢䤋䚍

㦘㄁㞍䚍廰㣑᧨㑘䵚☂⋫䞷᧨₵㟈⠓咂䎰㄁㞍㣑㡈㈦儋儛∎䞷ᇭ
ⓜ檔⚗㽤抩≰᧨㖖∬榊≰尞⸩⇫㯼󱁻䎰偩榊抩≰ᇭ
⇝┮䘖⺓櫊榊㳮檗㉜♦⚗㽤抩≰㒥ぴ㯼ᇬ䱠⸇♙携䣑䞷榊㽱懊⺓㊶

榊㳮岼⌨󱁻㄁㞍ᇭ

Korea

鲮뼩ꓩ꫕꫙ꟹ鱉끩끞닆놹볁뿱겕閵鱚ꫦ넩넽넁
鲮뼩ꓩ꫕꫙ꟹ鱉놹볁뿱겕閵鱚ꫦ넩넽냱ꕵꈑ넭ꐺ껽놹隱隵ꇝ鷑

꫑ꟹ걙鱉뼕ꯍ꽻걪鱽鲙 

Turkish WEEE Statement of Compliance

EEE Yönetmeliğine Uygundur.

Ukraine

Waste Electrical and Electronic
Equipment (WEEE)

English: For EU Customers: All products at the end of their

life must be returned to Motorola for recycling. For
information on how to return product, please go to:
http://www.motorola.com/recycling/weee.

Français: Clients de l'Union Européenne: Tous les produits
en fin de cycle de vie doivent être retournés à Motorola pour
recyclage. Pour de plus amples informations sur le retour de
produits, consultez :
http://www.motorola.com/recycling/weee.

Español: Para clientes en la Unión Europea: todos los
productos deberán entregarse a Motorola al final de su ciclo
de vida para que sean reciclados. Si desea más información
sobre cómo devolver un producto, visite:
http://www.motorola.com/recycling/weee.

Bulgarish: За клиенти от ЕС: След края на полезния им
живот всички продукти трябва да се връщат на Motorola
за рециклиране. За информация относно връщането на
продукти, моля отидете на адрес:

http://www.motorola.com/recycling/weee.

Deutsch: Für Kunden innerhalb der EU: Alle Produkte
müssen am Ende ihrer Lebensdauer zum Recycling an
Motorola zurückgesandt werden. Informationen zur
Rücksendung von Produkten finden Sie unter
http://www.motorola.com/recycling/weee.

Italiano: per i clienti dell'UE: tutti i prodotti che sono giunti al
termine del rispettivo ciclo di vita devono essere restituiti a
Motorola al fine di consentirne il riciclaggio. Per informazioni
sulle modalità di restituzione, visitare il seguente sito Web:
http://www.motorola.com/recycling/weee.

Português: Para clientes da UE: todos os produtos no fim de
vida devem ser devolvidos à Motorola para reciclagem. Para

obter informações sobre como devolver o produto, visite:
http://www.motorola.com/recycling/weee.

Nederlands: Voor klanten in de EU: alle producten dienen
aan het einde van hun levensduur naar Motorola te worden
teruggezonden voor recycling. Raadpleeg
http://www.motorola.com/recycling/weee voor meer
informatie over het terugzenden van producten.

Polski: Klienci z obszaru Unii Europejskiej: Produkty
wycofane z eksploatacji nale¿y zwróciæ do firmy Motorola w
celu ich utylizacji. Informacje na temat zwrotu produktów
znajduj¹ siê na stronie internetowej
http://www.motorola.com/recycling/weee.

Čeština: Pro zákazníky z EU: Všechny produkty je nutné po
skonèení jejich životnosti vrátit spoleènosti Motorola
k recyklaci. Informace o zpùsobu vrácení produktu najdete
na webové stránce: http://www.motorola.com/recycling/weee
.
Eesti: EL klientidele: kõik tooted tuleb nende eluea lõppedes
tagastada taaskasutamise eesmärgil Motorola'ile.
Lisainformatsiooni saamiseks toote tagastamise kohta
külastage palun aadressi:
http://www.motorola.com/recycling/weee.

Magyar: Az EU-ban vásárlóknak: Minden tönkrement
terméket a Motorola vállalathoz kell eljuttatni újrahasznosítás
céljából. A termék visszajuttatásának módjával kapcsolatos
tudnivalókért látogasson el a
http://www.motorola.com/recycling/weee weboldalra.

Svenska: För kunder inom EU: Alla produkter som uppnått sin
livslängd måste returneras till Motorola för återvinning.
Information om hur du returnerar produkten finns på
http://www.motorola.com/recycling/weee.

Suomi:

Asiakkaat Euroopan unionin alueella: Kaikki tuotteet
on palautettava kierrätettäväksi Motorola-yhtiöön, kun
tuotetta ei enää käytetä. Lisätietoja tuotteen palauttamisesta
on osoitteessa http://www.motorola.com/recycling/weee.

Dansk: Til kunder i EU: Alle produkter skal returneres til
Motorola til recirkulering, når de er udtjent. Læs
oplysningerne om returnering af produkter på:
http://www.motorola.com/recycling/weee.

Ελληνικά: Για πελάτες στην Ε.Ε.: Όλα τα προϊόντα, στο
τέλος της διάρκειας ζωής τους, πρέπει να επιστρέφονται στην
Motorola για ανακύκλωση. Για περισσότερες πληροφορίες
σχετικά με την επιστροφή ενός προϊόντος, επισκεφθείτε τη
διεύθυνση http://www.motorola.com/recycling/weee στο
Διαδίκτυο.

Malti: Għal klijenti fl-UE: il-prodotti kollha li jkunu waslu fl-
aħħar tal-ħajja ta' l-użu tagħhom, iridu jiġu rritornati għand
Motorola għar-riċiklaġġ. Għal aktar tagħrif dwar kif għandek
tirritorna l-prodott, jekk jogħġbok żur:
http://www.motorola.com/recycling/weee.

Românesc: Pentru clienţii din UE: Toate produsele, la
sfârşitul duratei lor de funcţionare, trebuie returnate la
Motorola pentru reciclare. Pentru informaţii despre returnarea
produsului, accesaţi:
http://www.motorola.com/recycling/weee.

Slovenski: Za kupce v EU: vsi izdelki se morajo po poteku
življenjske dobe vrniti podjetju Motorola za reciklažo. Za
informacije o vračilu izdelka obiščite:
http://www.motorola.com/recycling/weee.

Slovenčina: Pre zákazníkov z krajín EU: Všetky výrobky
musia byť po uplynutí doby ich životnosti vrátené spoločnosti

Motorola na recykláciu. Bližšie informácie o vrátení výrobkov
nájdete na: http://www.motorola.com/recycling/weee.

Lietuvių: ES vartotojams: visi gaminiai, pasibaigus jų
eksploatacijos laikui, turi būti grąžinti utilizuoti į kompaniją
„Motorola“. Daugiau informacijos, kaip grąžinti gaminį, rasite:
http://www.motorola.com/recycling/weee.

Latviešu: ES klientiem: visi produkti pēc to kalpošanas mūža
beigām ir jānogādā atpakaļ Motorola otrreizējai pārstrādei.
Lai iegūtu informāciju par produktu nogādāšanu Motorola,
lūdzu, skatiet: http://www.motorola.com/recycling/weee.

Türkçe: AB Müşterileri için: Kullanım süresi dolan tüm
ürünler geri dönüştürme için Motorola'ya iade edilmelidir
Ürünlerin nası

l iade edileceği hakkında bilgi için lütfen şu

.

adresi ziyaret edin: http://www.motorola.com/recycling/weee.

Service Information

Before you use the unit, it must be configured to operate in
your facility’s network and run your applications.

If you have a problem running your unit or using your
equipment, contact your facility’s Technical or Systems
Support. If there is a problem with the equipment, they will
contact the Motorola Support Center.

Warranty

For the complete Motorola hardware product warranty
statement, go to:
http://www.motorolasolutions.com//warranty.

For Australia Only:

This warranty is given by Motorola Solutions Australia Pty
Limited (ABN16 004 742 312) of Tally Ho Business Park, 10
Wesley Court. Burwood East, Victoria. Our goods come with
guarantees that cannot be excluded under the Australia
Consumer Law. You are entitled to a replacement or refund
for a major failure and compensation for any other
reasonably foreseeable loss or damage. You are also entitled
to have the goods repaired or replaced if the goods fail to be
of acceptable quality and the failure does not amount to a
major failure. Motorola Solutions Australia’s limited warranty
above is in addition to any rights and remedies you may have
under the Australian Consumer Law. If you have any queries,
please call Motorola Solutions Australia at 1800 457 439. For
the most updated warranty terms, visit our website at:

http://www.motorola.com/Business/XA-EN/Pages/Contact_Us

6 7 85 9