Zanussi ZCE7700G, ZCE7700C User Manual
ELECTRIC
DOUBLE OVEN
AND GRILL
ZCE 7700X
INSTRUCTION BOOKLET
TECHNICAL DETAILS
MODEL NO. ZCE 7700X
Voltage: 230/240 Volts AC 50 Hz
Wattage: 10.0/10.9 k W
Height: 900mm
Width: 600mm
Depth: 598mm
Weight: 59kg
This appliance complies with: European Council Directive 73/23/EEC.
EMC Directive 89/336/EEC.
CE Marking Directive 93/68/EEC.
2
CONTENTS
Technical Details
Contents
Preface
Safety
Introduction ...................................................................................... 8
Getting to Know your Cooker
The Ceramic Hob
.........................................................................................
...........................................................................................
.............................................................................................
Before Installation ........................................................................... 6
During Operation ........................................................................... 6
After Use ................................................................................... 7
General .................................................................................... 7
Rating Plate
Installation .................................................................................. 8
General Notes on Using Your Cooker ........................................................ 9
About Condensation and Steam ............................................................. 9
The Cooling Fan for the Controls ............................................................ 9
Control Panel Indicator Neons ............................................................... 9
Cookware .................................................................................. 9
Grill and Oven Furniture .................................................................... 10
The Control Panel ......................................................................... 11
The Automatic Timer ...................................................................... 12
Using the Hob ............................................................................. 16
Recommended Saucepans ................................................................. 16
Hints and Tips ............................................................................. 17
Hot Hob Indicator .......................................................................... 17
Deep Fat Frying ........................................................................... 17
Preserving ................................................................................. 18
.................................................................................
................................................................................
...................................................................
...............................................................................
11
16
2
3
5
6
8
The Dual Grill
Uses of the Dual Grill ...................................................................... 19
Selecting the Grill .......................................................................... 19
Things to Note ............................................................................. 19
The Grill Pan and Handle ................................................................... 19
Hints and Tips ............................................................................. 20
Grilling Chart .............................................................................. 20
The Top Oven
Uses of the Top Oven ...................................................................... 21
Selecting the Top Oven .................................................................... 21
Things to Note ............................................................................. 21
To Fit the Top Oven Shelf .................................................................. 21
Hints and Tips ............................................................................. 22
The Fan Oven
Uses of the Fan Oven ...................................................................... 23
Selecting the Fan Oven .................................................................... 23
Things to Note ............................................................................. 23
To Fit the Fan Oven Shelves ............................................................... 23
Hints and Tips ............................................................................. 24
Oven Cooking Chart
Roasting chart
....................................................................................
...................................................................................
...................................................................................
..................................................................................
.............................................................................
19
21
23
25
26
3
CONTENTS
Defrosting ....................................................................................... 27
Uses of Defrost Feature ................................................................... 27
Selecting Defrost ......................................................................... 27
Things to Note ............................................................................ 27
Hints and Tips ............................................................................ 27
Care and Cleaning
Cleaning Materials ........................................................................ 28
Cleaning the Ceramic Hob ................................................................. 28
Hints and Tips ............................................................................ 29
Cleaning the Outside of the Cooker ........................................................ 29
Cleaning the Control Knobs and Handles .................................................. 29
Cleaning the Meat Tin, Grill Pan, Grill Pan Grid and Oven Shelves .......................... 29
Cleaning Inside the Oven and Grill Compartments .......................................... 29
Care of Stayclean Surfaces ................................................................ 30
Hints and Tips ............................................................................ 30
Cleaning between the Outer and Inner Door Panels ......................................... 30
Replacing an Oven Light Bulb .............................................................. 31
Something Not Working? ....................................................................... 32
Service and Spare Parts
Customer Service Centres ...................................................................... 34
Guarantee Conditions
...............................................................................
.........................................................................
...........................................................................
28
33
36
4
PREFACE
Dear Customer,
Thank you for buying a Zanussi cooker. With our experience in developing
and manufacturing the very best in U.K. cookers, you can be assured that you
have purchased a hard working, reliable, quality product.
Zanussi cookers comply with British Standard safety and performance
requirements. They have been approved by BEAB (British Electrotechnical
Approvals Board) and are covered by a 12 month parts and labour guarantee.
To get the best from your new Zanussi cooker, we ask that you PLEASE
READ THESE INSTRUCTIONS CAREFULLY. Particular attention should be
made to cooking times and temperatures which may differ from your previous
cooker.
It is most important that this instruction book is retained with the cooker for
future reference. Should the cooker be sold, or if you move house and leave
the cooker, always ensure that the book remains with the cooker. This will
enable the new owner to be acquainted with the functioning of the cooker and
the relevant warnings.
Please read the whole instruction book before attempting to use the cooker
ensuring you follow the recommendations given.
5
SAFETY
THESE WARNINGS ARE PROVIDED IN
THE INTERESTS OF YOUR SAFETY.
ENSURE THAT YOU UNDERSTAND THEM
ALL BEFORE INSTALLING OR USING
THE COOKER.
PLEASE
READ
CAREFULLY
BEFORE INSTALLATION
This cooker is heavy and care must
be taken when moving it.
Ensure that all packaging, both
inside and outside the cooker has
been removed before the appliance is
used.
If the cooker is to be placed on a
base, measures must be taken to
prevent the cooker slipping from the
base.
Do not try to lift or move the cooker
by pulling the door handles.
After installation, please dispose of
the packaging with due regard to
safety and the environment, your
local authority can arrange this.
DURING OPERATION
Do not use this cooker if it is in
contact with water. Never operate it
with wet hands.
This cooker is designed to be
operated by adults. Young children
must not be allowed to tamper with
the cooker or play with the controls.
During use the cooker becomes Hot.
Care should be taken to avoid
touching heating elements inside the
oven.
Accessible parts especially around
the grill area may become hot when
the cooker is in use. Children should
be kept away until it has cooled.
Take great care when heating fats
and oils as they will ignite if they
become too hot.
The electrical installation work must
be undertaken by a qualified
electrician / competent person.
It is dangerous to alter or modify the
specifications of the cooker in any
way.
Do not use the cooker if the ceramic
glass is damaged. If a fault or crack
becomes visible during cooking,
disconnect the cooker immediately
from the electricity supply and contact
your local Service Force Centre. Do
not place silver foil or plastic
containers on ceramic glass.
Do not allow young childen to play
with any part of the packaging.
This cooker has been designed for
cooking edible foodstuffs only, and
must not be used for any other
purposes.
Never place plastic or any other
material which may melt in the oven
or on the hob.
Ensure cooking utensils are large
enough to contain foods to prevent
spillages and boil overs.
The handles of saucepans which are
smaller than the heated area on the
hob will become hot. Ensure your
hand is protected before handling the
pan.
6
Take care to follow the recommendations
given for tending the food when grilling.
Ensure that you support the grill pan
when it is in the withdrawn or partially
withdrawn position.
Ensure that all vents are left
unobstructed to ensure ventilation of
the oven.
Ensure that the anti-tilt shelves are
put in place correctly. Refer to
instructions on pages 21 and 23.
Never line any part of the cooker
with aluminium foil. Do not allow
heatproof cooking materials, e.g.
roasting bags, to come into contact
with oven elements.
Do not leave utensils containing
foodstuffs, e.g. fat or oil in or on the
cooker in case it is inadvertently
switched ON.
Cookers and hobs become very hot,
and retain their heat for a long period
of time after use. Children should be
kept well away from the cooker until
it has cooled.
GENERAL
Under no circumstances should
repairs be carried out by
inexperienced persons as this may
cause injury or serious malfunction.
This cooker should be serviced by
an authorised Service Engineer and
only genuine approved spare parts
should be used.
Always stand back from the cooker
when opening the oven door to allow
any build up of steam or heat to
release.
Never leave the cooker
unattended when the oven doors
are open.
Do not place sealed cans or
aerosols inside the oven. They may
explode if they are heated.
Do not leave the hotplates switched
ON for long periods when not covered
by a saucepan. The controls may
overheat.
AFTER USE
Ensure that all control knobs are in
the OFF position when not in use.
Do not stand on the cooker or on
the open oven doors.
Do not hang towels, dishcloths or
clothes from the cooker or its handle.
They are a safety hazard.
Always allow the cooling fan to cool
the cooker down before switching off
at the wall prior to carrying out any
cleaning or maintenance work.
Only clean this cooker in accordance
with the instructions given in this
book.
Extreme care must be taken when
using a razor on the ceramic hob.
Your safety is of paramount importance.
For hygiene and safety reasons
this cooker should be kept clean at
all times. A build-up of fats or
other foodstuffs could result in a
fire, especially in the grill pan.
Therefore, if you are unsure about any of the
meanings of these WARNINGS contact the:
Customer Care Department
Telephone 0870 5 727727
7
INTRODUCTION
WARNING: THIS COOKER MUST BE
EARTHED
RATING PLATE
This is situated on the lower front frame of the cooker
and can be seen upon opening the top cavity door.
Alternatively the rating plate may also be found on the
back or top of some models (where applicable).
The cooker must be protected by a suitably rated fuse
or circuit breaker. The rating of the cooker is given on
the rating plate.
The cable should be routed away from potentially hot
areas marked by X in the diagram below.
Do not remove the rating plate from the cooker as
this may invalidate the guarantee.
INSTALLATION
If your cooker has been damaged in transit, contact
your supplier immediately. DO NOT attempt to install
it.
Your cooker left the factory fully packaged to protect
it from damage. If it is delivered without packaging
and damage has occurred the manufacturer cannot
accept responsibility. Contact your supplier for advice.
Once the packaging has been removed the cooker
should only be moved by hand. DO NOT use a sack
barrow or any other aid to lift the cooker as damage
may occur.
Connection to the electricity supply must be carried
out by a qualified electrician/competent person.
The electrical connection should be made using a
double pole isolating switch (cooker socket) with at
least 3mm contact separation. The cable must have
conductors of sufficiently high cross-sectional area to
prevent overheating and deterioration.
The recommended cross-section area is six square
millimetres (6.00mm²).
REAR VIEW
To move the cooker, open the fan oven door, and lift
the cooker by holding inside the top of the
compartment.
This is a type Y cooker which means it is
free-standing and can be fitted with cabinets on one
or both sides. It may also be fitted in a corner setting.
Ensure that the cooker is standing level.
Side walls which are above hob level should be
protected by heat resistant non-combustible material
and MUST NOT be nearer than 40mm to the hob
side.
A nominal air gap of 2mm all around the cooker is
required to enable the cooker to be moved into
position.
Always ensure an air gap is maintained at hotplate
level. Tiles or other forms of deep wall covering
should not obscure this gap.
Air gap
8
Note: Vapours from the oven vents may in time
cause discoloration of wallcoverings behind the
cooker. For ease of cleaning it may be preferable to
tile behind the cooker.
Overhanging surfaces or a cooker hood should be a
minimum of 685mm above the hob.
It is important to ensure that the cooker is level after
installation. Levelling feet are fitted to the cooker to
accommodate uneven floors.
GENERAL NOTES ON USING YOUR
COOKER
We suggest that you run the oven elements for 10 15 minutes at 220°C to burn off any residue from their
surfaces.
The procedure should be repeated with the grill for
approximately 5 - 10 minutes.
During this period an odour may be emitted, it is
therefore advisable to open a window for ventilation.
ABOUT CONDENSATION AND STEAM
THE COOLING FAN FOR THE CONTROLS
The cooling fan operates immediately when the grill
or top oven is switched on. It may run on after the
controls are switched off until the appliance has
cooled. If an automatic programme has been set for
the top oven, the cooling fan does not switch on until
the cooktime begins.
The cooling fan may operate after a time when the
fan oven is in use. This will depend on the
temperature setting and the length of time the oven
has been in use.
CONTROL PANEL INDICATOR NEONS
These lights indicate whether the ovens are switched
on.
The neons also indicate when the set temperature
has been reached. They will turn on and off during
use to show that the temperature is being
maintained.
If the neons do not operate as the instructions
indicate the controls have been incorrectly set.
Return all controls to zero and re-set following the
instructions for the required setting.
When the oven has been set for automatic cooking
the neon should remain unlit during OFF periods.
COOKWARE
Baking trays, oven dishes etc., should not be placed
directly against the grid covering the fan at the back
of the oven.
When food is heated it produces steam similar to a
boiling kettle. The ovens are vented to allow some of
this steam to escape. However, always stand back
from the cooker when opening the oven door to allow
any build up of steam or heat to release.
If the steam comes into contact with a cool surface on
the outside of the cooker, e.g. a trim, it will condense
and produce water droplets. This is quite normal and
is not caused by a fault on the appliance.
To prevent discoloration, regularly wipe away
condensation and also soilage from surfaces
including the vent at the rear of the hob. See note
at the top of this page.
For your safety wallcoverings at the rear of the cooker
should be securely fixed to the wall.
Do not use baking trays larger than 30cm x 35cm
(12" x 14") as they will restrict the circulation of heat
and may affect performance.
9
GRILL AND OVEN FURNITURE
The following items of grill and oven furniture have
been supplied with the cooker. If you require
replacements of any of the items listed below, please
contact your local Service Force Centre quoting the
relevant part number.
1 grill pan
(311409401)
1 grill pan handle
(311468100)
Note
If you require an additional handle for your grill pan,
this can be ordered from your local Service Force
Centre by quoting part number 311479800\6.
Scuffing of the Stayclean panel/s by the oven
furniture pack may occur during transit. These marks
will disappear after the oven elements have been
burnt off for the first time.
1 grill pan grid
(311419801)
1 meat tin
(311409401)
1 straight shelf
for grilling and top
oven cooking only
2 straight shelves
for fan oven cooking
10
GETTING TO KNOW YOUR COOKER
THE CONTROL PANEL
A
B
C
D
E
F
G
FEATURES
A - Automatic Timer
B - Fan Oven Temperature Control
C - Top Oven Temperature Control
D - Fan Oven Indicator Neon
E - Selector Control
F - Top Oven Indicator Neon
G - Hotplate Controls
11
THE AUTOMATIC TIMER
KEY
A AUTO DISPLAY
B MINUTE MINDER BUTTON
C COOKING HOURS BUTTON
D STOP TIME BUTTON
E COOKING SYMBOL
F MANUAL SELECTOR BUTTON
G DECREASE CONTROL
H INCREASE CONTROL
NOTE:
THE TIME OF DAY MUST BE SET
BEFORE THE OVEN WILL OPERATE
MANUALLY.
1. SET THE TIME OF DAY
When the electricity supply is first switched ON,
the display will flash both 0.00 and AUTO. See
Fig. 1.
Press the two buttons marked ( ) and ( )
press the increase control button (+) and if
necessary, the decrease control button (-) until
the correct time on the 24 hour clock is reached,
e.g. 10.00am as Fig. 2.
Note: The increase and decrease control
buttons operate slowly at first, and then more
rapidly. They should be pressed separately.
The AUTO symbol will go out when the correct
time of day is set. See Fig 2.
2. THE MINUTE MINDER
The minute minder gives an audible reminder at
the end of any period of cooking up to 23 hrs 59
mins. It is not part of the automatic control.
To set, press the minute minder button ( ) and
the digital display will read 0.00 and the bell
symbol will glow, as Fig. 3.
Press the increase control (+) until the display
indicates the interval to be timed, e.g. 1 hr 45
mins as Fig. 4.
Fig 1.
Fig 2.
Fig 3.
NOTE: This must be completed within 4
seconds of first pressing the minute minder
button.
Fig 4.
12
Release the minute minder button and the
display will return to the time of day after 5
seconds.
During the operation of the minute minder the
remaining time period can be shown in the
display by pressing the minute minder button
( ). See Fig. 5.
The minute minder will sound intermittently, for
up to 2 minutes and the bell symbol will flash at
the end of the timed period. The sound can be
stopped by pressing any of the 4 left hand side
buttons.
3. HOW TO SET THE OVEN TIMER
CONTROL
The automatic control can be used to control
either oven but you can only use the control for
both ovens at the same time if the cooking time is
the same.
When you use the automatic controls for the first
time it's probably best to choose a time when you
are at home. That way you can check to make
sure you've set everything correctly and you'll
feel much more confident when you are away
from home in the future.
Fig 5.
A) TO SET THE TIMER TO SWITCH ON AND
OFF AUTOMATICALLY
i) Ensure the electricity supply is switched ON
and that the correct time of day is displayed,
e.g. 9 a.m. as Fig. 6.
ii) Place food in oven.
iii) To set the length of Cooking Time, press the
cooking hours button (----), press the
increase control ( + ) until the cooking time is
displayed, e.g. 2 hrs 15 mins. Fig 7.
iv) Release the buttons. The AUTO display and
cooking symbols will glow.
Remember, this must be completed within 4
seconds of first pressing the cooking hours
button.
v) Set the STOP time. Press the stop time
button ( ) press the increase control ( + ),
until the required stop time is displayed. e.g.
12.15p.m. Fig. 8.
vi) Release the buttons. The cooking symbol
will go out and the time of day will be
displayed after 5 seconds.
Fig 6.
Fig 7.
A
U
T
O
A
U
T
O
vii) Set the oven control to the required
temperature. The oven indicator neon
should be OFF and the AUTO display will
glow.
Fig 8.
13
Loading...