Worx WG504E Safety And Operating Manual

2500W Blower WG504E

SAFETY AND OPERATING MANUAL

1

2

3

6

7

8

9

10

11

12

5

4

Click!

A B1

Click!

ON

OFF

E1 E2

C2 D

B2 C1

Click!

G3 H1

G1 G2

F

2

1

Click!

2

1

13

J1 J2

I2 I3

H2 I1

7

2500W Blower WG504E

1. HANDLE

2. ON/OFF SWITCH

3. RELEASE BUTTON

4. UPPER VACUUM TUBE

5. LOWER VACUUM TUBE

6. LEAF COLLECTION BAG

7. BLOWER TUBE

8. VARIABLE BLOWER SPEED KNOB

9. BLOWER/VACUUM SELECTOR LEVER

10. QUICK RELEASE BAG COLLAR

11. MOTOR HOUSING

12. EXTENSION CORD HOLDER

13. QUICK RELEASE BUTTON (See Fig. I1)

TECHNICAL DATA

2500W 220-240V~50/60Hz

Power input 2500W

No load speed 15000/min

Air capacity 10m

3

/min

Air speed 128-335km/h

Mulching rate 16:1

Collection bag capacity 45L

Machine weight 4.1kg

Protection class

/II

ACCESSORIES

Leaf collection bag 1

We recommend that you purchase your accessories from a WORX authorized dealer or
service center. Only use use WORX parts and accessories marked with a well-known brand
name. Choose the type according to the work you intend to undertake. Refer to the accessory
packaging for further details. Store personnel can assist you and offer advice.

8

2500W Blower WG504E

GENERAL SAFETY WARNINGS

WARNING: Read all safety
warnings and all instructions.

Failure to follow the warnings and instructions
may result in electric shock, fire and/or serious
injury.

Save all warnings and instructions for
future reference.

-

This appliance is not intended for use by
persons (including children) with reduced
physical, sensory or mental capabilities, or
lack of experience and knowledge, unless
they have been given supervision or
instruction concerning use of the appliance
by a person responsible for their safety.

- Children should be supervised to ensure
that they do not play with the appliance.

If the supply cord is damaged, it must be
replaced by the manufacturer, its service
agent or similarly qualified persons in order to
avoid a hazard.

INTENDED PURPOSE

WARNING! A garden vacuum-blower

is not a wet suction device!
Please avoid the suction of wet materials
(leaves and dirt), since this can lead to
blockage of the shredder chamber and
reduced performance.

The device is designed only for the suction
and blowing of dry leaves in private
households and as a hobby device in the
garden. Any other utilization, which is not
explicitly approved in these directions, can
lead to damage to the device and represent a
serious danger to the user.

• The device MUST NOT be employed in

areas where there is health endangering
dusts or as a wet suction device.

• The device is designed for use by adults.

Young people over 16 years may use the
device under supervision only.

• The use of the device in the rain or in a

humid environment is forbidden.

• The manufacturer is not liable for damage

which is caused through inappropriate use
or incorrect operation.

NOTE: For the protection of the operator, the
device can be operated only with assembled
vacuum tube and collection bag.
NOTE: Do not employ and low power
machines for heavy work. DO NOT use your
device for purposes for which it has not been
designed.

WARNING! To reduce the risk of
injury, user must read and understand

instruction manual.

1) TRAINING

a) Read the instructions carefully. Be familiar

with the controls and the proper use of the

appliance;
b) Never allow children to use the appliance.
c) Never allow people unfamiliar with these

instructions to use the appliance. Local

regulations may restrict the age of the

operator;
d) Never operate the appliance while people,

especially children, or pets are nearby;
e) The operator or user is responsible for

accidents or hazards occurring to other

people or their property.

2) PREPARATION

a) While operating the appliance, always

wear substantial footwear and long

trousers. Do not operate the equipment

when barefoot or wearing open sandals;
b) Do not wear loose clothing or jewellery

that can be drawn into the air inlet. Keep

long hair away from the air inlets.
c) Wear protective goggles while operating
d) To prevent dust irritation the wearing of a

face mask is recommended
e) Before using, check the supply and

extension cord for signs of damage and

aging. Do not use the appliance if the cord

is damaged or worn.
f) Never operate the appliance with defective

guards or shields, or without safety

devices, for example debris collector in

place
g) Only use a weather proof extension cable

fitted with a coupler according to IEC

60320-2-3.
h) It is recommended that the appliance

9

2500W Blower WG504E

should be supplied via a residual current
device (RCD) with a tripping current of not
more than 30 mA.

i) If an extension cord is used make sure it is

for outdoor use and marked as such. The
recommended size of extension cord is
not lighter than 1 mm2.

3) OPERATION

a) Always direct the cord to the rear away

from the appliance.

b) If the cord becomes damaged during use,

disconnect the supply cord from the mains
immediately. DO NOT TOUCH THE CORD

BEFORE DISCONNECTING THE SUPPLY.
c) Do not carry the appliance by the cord.
d) Disconnect the appliance from the mains

supply

- Whenever you leave the machine;

- Before clearing a blockage;

- Before checking, cleaning or working on

the appliance;

- If the appliance starts to vibrate

abnormally.
e) Operate the appliance only in daylight or

in good artificial light.
f) Do not overreach and keep your balance at

all times.
g) Always be sure of your footing on slopes.
h) Walk, never run;
i) Keep all cooling air inlets clear of debris.
j) Never blow debris in the direction of

bystanders.
k) Do not put hands or feet near or under

rotating parts.

4) MAINTENANCE AND STORAGE

a) Keep all nuts, bolts and screws tight to

be sure the appliance is in safe working

condition;
b) Check the debris collector frequently for

wear or deterioration.
c) Replace worn or damaged parts.
d) Use only genuine replacement parts and

accessories.
e) Store the appliance only in a dry place.

10

2500W Blower WG504E

WARNING: Read the operator’s
manual.

Wear eye protection

Double insulation

SWITCH OFF: Remove plug
from mains before cleaning or
maintenance.

Keep bystanders away

Warning of hazard

Do not use in the rain or leave
outdoors while it is raining.

Blow mode

Vacuum mode

Impeller continues to rotate after
the machine is switched off. Wait
until all machine components
have completely stopped before
touching them.

Waste electrical products
must not be disposed of with
household waste. Please recycle
where facilities exist. Check with
your local authorities or retailer
for recycling advice.

RCM approval mark

ABN: Australian Business
Number. By this number,
business information such as
entity type, status, business
location etc. can be found at
website http://abr.business.gov.
au.
ABN of Positec Australia Pty
Limited is 14 101 682 357

SYMBOLS

11

2500W Blower WG504E

OPERATION
ASSEMBLY AND OPERATION

ACTION FIGURE

Blow mode

Assembling the Blower/ Vacumm Tube See Fig. A & B1& B2

Attaching the Extension Cord

See Fig. C1 & C2

Starting & Stopping See Fig. D

Using the Blower See Fig. E1 & E2

Adjusting the Blowing Speed See Fig. F

Vaccumming

Attaching the Leaf Collection Bag See Fig. G1& G2& G3

Attaching the Extension Cord

See Fig. C1 & C2

Starting & Stopping See Fig. D

Using the Vacuum See Fig. H1 &H2

Emptying the Leaf Collection Bag See Fig. I1& I2& I3

Removing Clogged Debris from the Impeller(no tool included) See Fig. J1&J2

STORAGE

Store the Blower/Vacuum and extension cord indoors, in a cool dry location, out of reach of
children and animals.

TROUBLE SHOOTING

Problems Possible Causes Corrective Action

The Blower/Vac does
not operate.

The Blower/Vacuum Tube is not
attached to the Motor Housing.

Attach the Blower/ Vacuum
Tube to the Motor Housing.

Power cord is not connected to the
power source.

Connect the power cord to a
power source.

The Blower/Vac
jammed or clogged.

Debris blocking in the Impeller

Remove clogged debris from
the Impeller.

Debris blocking in the Blower/
Vacuum Tube or the connection of the
Leaf Collection Bag.

Remove clogged debris from
the Blower /Vacuum Tube or
the connection of the Leaf
Collection Bag.

Copyright © 2014, Positec. All Rights Reserved.

2GBV06DPK11000A0

www.worx.com