PATIO AND WALL CLEANER
Original instructions
User Manual
Spend a little Live a lot
Content
Introduction...................................................................................
General information and Safety instructions...............................
Assembly and Parts List.................................................................
Connect..........................................................................................
Features..........................................................................................
Instructions....................................................................................
FAQ..................................................................................................
Other Useful Information..............................................................
5
5
8
9
9
10
11
12
5
Introduction
This patio and wall cleaner is intended for private use only:
• For splash-proof pressure cleaning of floors and walls, rotating nozzles ensure that
cleaning is highly efficient.
• Cleaning the object according to its manufacturer’s information.
• The device is designed for use with the WORKZONE high pressure washer.
• The device is suitable for other pressure washers if the adaptor is used.
General information and safety
instruction
The following warning symbols appear throughout this assembly manual and
indicate the appropriate safety measures you should take when assembling and
operating the appliance.
This symbol indicates there is a danger of serious personal injury or death if you
do not observe the warning.
Attention! Read all the instructions before using the appliance.
Never reach under the patio cleaner when it is on.
CAUTION!
High pressure jets can be dangerous if subject to misuse. The jet must not
be directed at persons, live electrical equipment or the appliance itself.
wear safety gloves to prevent injury during using of this device.
Declaration of Conformity (see “Declaration of Conformity”): With
This icon labeled products meet the requirements of CE Directive.
Introduction
6
General notes on safety
• This appliance is not intended for use by persons
(including children) with reduced physical, sensory
or mental capabilities, or lack of experience and
knowledge, unless they have been given supervision
or instruction concerning use of the product by a
person responsible for their safety.
• Never allow children or people unfamiliar with these
instructions to use the appliance. Local regulations
may restrict the age of operator.
• This appliance is manufactured in accordance with
the relevant safety regulations. To avoid danger,
electrical appliances must only be repaired by qualified
technicians.
• This appliance has been designed for use with
the cleaning agent supplied or recommended by
the manufacturer. Do not use acids, solvents, or any
flammable material in this device. These products can
cause physical injuries to the operator and irreversible
damage to the device and may void the products
warranty.
• Before operation, carefully check the appliance for
damage. Do not use the tool if any parts are damaged or
defective. Have any damaged or defective parts repaired
or replaced by an authorized service agent. Never
attempt any repairs yourself.
• Wet surfaces can be slippery. Wear shoes and keep
both feet on the ground. Do not climb on items being
cleaned.
• Do not use the appliance within range of persons
unless they wear protective clothing.
• Do not direct the jet against yourself or others in
order to clean clothes and shoes.
• To ensure appliance safety, use only original spare
General notes on safety
7
parts from the manufacturer or approved by the
manufacturer.
• WARNING: High pressure hoses, fittings and couplings
are important for the safety of the appliance. Use only
hoses ,fittings and couplings recommended by the
manufacturer.
• Do not use the appliance if a supply cord or important
parts of the appliance are damaged, e.g. safety devices,
high pressure hoses , trigger gun.
• If an extension cord is used, the plug and socket must
be of watertight construction. The cross-section of the
power supply cable must not be less than 2x2.5mm
2
. Do
not abuse extension cord and do not yank on any cord to
disconnect.
• Do not operate the appliance when fatigued or under
the influence of alcohol or drugs.
• Do not stand on unstable surfaces. Keep good footing
and balance at all times.
• Spray gun can kick back .Hold with both hands on the
appliance.
• When the spray trigger is released, water pressure is
trapped in the discharge hose. Release trapped pressure
by triggering the spray gun after the washer is turned off.
• To reduce the risk of electrocution, keep all connections
dry and off the ground. Do not touch plug with wet
hands.
• Disconnect from the electrical power supply before
carrying out user maintenance.
• Store the appliance in a dry place and out of reach of
children.
Assembly and parts list
8
Technical specifications
Patio and wall cleaner Q1W1524
Max. permissible pressure P max. 15 MPa
Inlet flow temperature t in max. 60°C
The patio and wall cleaner is designed for pressure washers working at a nominal
pressure (p) of 90-150bar .
Assembly and Parts List
Fig.2
1. Extension tubes
2. Patio cleaner
3. Adaptor H
4. Adaptor E
5. 2 spare nozzles for patio cleaner
Assembling
• Connection of extension tube (1) and
cleaners (2):
Push the extension tube onto the pivoting
connector of cleaner(2), then rotate to
the fixing position.
Fig.3
Technical specifications
9
Connect
Fig.4
Assemble the extension tube (1) to your spray
gun, then start to work.
Spray gun can kick back .Always hold
with both hands on the appliance
When the spray trigger is released,
water pressure is trapped in the
discharge hose. Release trapped
pressure by triggering the spray gun
after the washer is turned off.
Features
This patio and wall cleaner can be
adjusted for different usage as below
description (refer to fig. 5)
Full cleaning power. Used for hard
surfaces like concrete. Always test on
a small area to find
Reduce cleaning power.
Fig.5
Connect
+
_
Avoid the patio cleaner going over free corners.
10
Instructions
WARNING! Before operation , make sure no obstacle (etc. stone) has blocked the
rotation device below.
• When cleaning horizontal surfaces, move nozzle wand from side to side. (Fig 6)
• When cleaning building interiors or exteriors , work from top to bottom. This will
help eliminate streaks. (Fig 7)
Note! Always hold the patio and wall cleaner by the handles when washing down walls .
Note! Avoid the patio and wall cleaner going over free corners
Fig.6 Fig.7
On sensitive surfaces, test the brush (2) initially on a location that is not visible,
in order to ensure compatibility.
Removal of the patio and wall cleaner is in the reverse order. Push and turn the patio
and wall cleaner in the opposite direction to separate adaptor from the spray gun.
Instructions
11
Frequently Asked Questions(FAQ)
WARNING! Only perform the steps described within these instructions!
All further inspection, maintenance and repair work must be performed
by an authorized service centre or a similarly qualified specialist if you
cannot solve the problem yourself!
Suspected malfunctions, disturbances or damages are often due to causes that
the user can find themselves. Therefore check the product using this section. In
most cases the problem can be solved quickly.
Symptom Problem Solution
No pressure or fluid
nozzle
Unit not properly primed.
Blocked water inlet screen.
Kink in water inlet hose.
Closed water supply.
Prime unit.
Clean or replace inlet screen.
Remove kink.
Turn on water supply. Check supply hose for leaks or blockage.
Low nozzle pressure
Unit not properly primed.
Insufficient inlet water
supply
Kink in water inlet hose
Worn pump components
Prime unit.
Check water supply conditions.
Clean inlet screen.
Check with service agent.
Appliance
does not
start
Not connected to power
supply
Power connection is loose.
Switch malfunction
Faulty motor
Connect with power supply.
Connect the unit with power.
supply well
Check with service agent.
Check with service agent.
FAQ
12
Other useful information
Adaptors
The enclosed adaptor H or adaptor E (3/4) may be helpful for use with other device.
Plug-in and twist to connect the adaptor (3/4) to the high pressure spray gun.
• Adaptor H (emboss marked “H”) can be connected to:
WORKZONE spray gun SINCE 2012
DURO spray gun SINCE 2012
Fig 8.
• Adaptor E (emboss marked “E”) can be connected to:
Gun of common used DIY market spray gun limited by 150bar
Fig.9
Other useful information
13
NOZZLES (5)
Enclosed 2 extra nozzles (5) could be replaced in case damaged or blocked. (Fig.10)
-Remove the clip
-Remove the nozzles
-Reinstall the high pressure nozzle.
-Re-insert the clip
Fig.10
Cleaning/Maintenance/ Storage
1. Disconnect all water connections.
2. Turn on the appliance for a few seconds, until the water which has remained in the
pump exits. Turn off immediately.
3. Keep the appliance in a frost-proof area
Other useful information
14
Waste disposal and environmental protection
Disposal
WARNING
Inspecting the device
Check all fastenings regularly. These can come loose over time because of the
vibration.
Do NOT DISPOSE OF THE PACKAGING IN YOUR HOUSEHOLD WASTE.
The packaging is entirely made from recyclable materials. Dispose of
the packaging in the appropriate recycling container.
Service/customer support
Only have your patio and wall cleaner serviced by a qualified specialist and use only
original spare parts. This will ensure that the safety of the patio cleaner is maintained.
Please contact our service partner if you have any queries or wish to order parts:
Sumec UK co. Ltd.
Trading as Core Service
Unit A & B, Escrick Business Park
Escrick, York
YO19 6FD
United Kingdom
Tel: (GB) +44 (0)1904 727501 (IRE) +353 (0)1 902 2605
E-mail: support@coreservice.co.uk
Web: www.coreservice.co.uk
Waste disposal and environmental protection
Declaration of Conformity
Original EU Declaration of Conformity
We,
MEROTEC GmbH
D-47877 Willich, Hanns-Martin-Schleyer Str. 18a, Germany
herewith declare under our own, sole responsibility that our product
Patio and wall cleaner
Modell Nr.: Q1W1524
complies with the following directives:
Machinery Directive 2006/42/EC
RoHS*) 2011/65/EU
*)
The object of the declaration described above is in conformity with Directive 2011/65/
EU of the European Parliamentand of the Council of 8 June 2011 on the restriction of the
use of certain hazardous substances in electrical and electronic equipment.
Document representative:
Dirk Wohlrab
MEROTEC GmbH
Hanns-Martin-Schleyer Str. 18a
D-47877 Willich
Place, date: Willich, 10.11.2017
Authorised Signature:
Roland Menken
General Managee
MEROTEC GmbH
Great care has gone into the manufacture of this product and it is
should therefore provide you with years of good service when used
properly. In the event of product failure within it‘s intended use over
the course of the first 3 years after date of purchase, we will remedy
the problem as quickly as possible once it has been brought to our
attention. In the unlikely event of such an occurrenece, or if you
require any information about the product, please contact us via our
helpline support services, details of which are to be found both in this
manual and on the product itself.
Spend a little Live a lot
PRODUCED IN CHINA FOR:
ALDI STORES LTD. PO BOX 26, ATHERSTONE
WARWICKSHIRE, CV9 2SH.
ALDI STORES (IRELAND) LTD.
PO BOX 726, NAAS, CO. KILDARE.
Visit us at www.aldi.com
N4
GB IRE
AFTER SALES SUPPORT
MODEL:
+44 (0)1904 727501
+353 (0)1 902 2605
www.coreservice.co.uk
Q1W1524
95614
04/2018
3
YEAR WARRANTY
IRE
GB
Loading...