Whirlpool RHH 7630 User Manual

INSTALLATION and OPERATING INSTRUCTIONS

f

or

%hpool

VENTLESS RANGE HOOD

TO INSTALL

For an easier installation, remove the filters and the three
assemblies shown in Fig. 3. This reduces theweight about
40%. The blower cover and light frame assembly are held
into place by spring latches. To remove simply grasp and
pull as indicated in Figure 3. To remove the blower
assembly, first unplug the blower powersupply cord from

the junction box. Then pull the blower retaining rod to one
side, freeing it from between the bumps on the blower
housing.

Remove screw holding junction box cover.

1.

2.

Remove proper electrical knockout. See Figure 1
Lift the hood into position. Mark location of four

3.
mounting holes.

4. Remove hood and start all four screws in center of
narrow neck of keyhole slot marked on cabinet
bottom (Fig. 2).

Lift into position on four screws

5.
feeding electrical wire through knockout.

6. Complete electrical wiring in junction box according
to the National Electrical Code and applicable Local
Codes, NOTE: Thus Unit must be permanently
grounded.

simultaneously

RHH 7630

RANGE HOOD

L WIRING KNOCKOUTS

FIG. 1

Tighten screws to secure hood. Be sure screw head

7.
is in narrow neck of keyhole slot.

Replace junction box cover

8.
Replace blower cover, light frame assembly and

9.
filters.

Replace blower.

10.

KEYHOLE SLOT
IN CANOPY

SCREW1

(IN INSTALLATION

PARTS BAG)

LIGHT 7
SWITCH ’

-BLOUER
‘COVER

LIGHT FRAI\:E
ASSEMBLY

‘-mBL@,LEH

‘EILOhER CRADLE

FIG. 3

--FAN CONTROL
SWITCH

-BLOWER
RETAINING
ROD

- JUNCTlOh
@OX

OPERATION AND CARE OF UNIT

CORPORATION

BLOWER CONTROL’

This range hood has a solid state motor speed control.
After setting the control to a desired speed, it will take
approx. 15 seconds for the blower to respond to that
setting.

CARE OF BLOWER

Under normal operating conditions, this blower requires
no oiling for the first year. After the first year oil every 6
months with SAE 20 oil.

LIGHTING

Select two light bulbs up to 100 watts each to acheive
desired lighting level.

CARE OF FILTERS

A. ALUMINUM FILTER: For greatest efficiency, the

permanent type aluminum filter should be removed and
cleaned periodically. (Reverse of paragraph B.)
To clean, the filter should be soaked in hot water and
detergent. Aluminum filter can be cleaned in a
dishwasher.

B. CHARCOAL FILTER: This filter should be

inspected periodically and when it becomes saturated,
should be replaced. There are no effective means of

reactivating charcoal filters.

CARE OF EXTERIOR SURFACES

Your range hood is a beautifully finished addition to your

kitchen. To preserve its lasting beauty, clean with a mild

detergent.

Replacement filters and repair parts may be obtatned

from Whirlpool Corporation Parts Distribution Center,

La Porte, lndrana 46350. For most effective removal of

smoke & odors, turn on fan at beginning of cooking

operation & allow to run until smoke & odors are removed

from room.

DO NOT

use abrasive cleaners.

Whirlpool lranchised TECH-CARE * service

If your WHIRLPOOL

In the Unlted States, help IS just a phone call away
nearest TECH-CARE service representative.

WhIrlpool maIntams a natronwtde network of franchised

TECH-CARE servrce

provide after-warranty service and maintenance to keep your

WHIRLPOOL appliance In peak condmon

You’ll find your nearest TECH-CARE servrcecompany lrsted
In your local telephone book Yellow Pages under
Washers/Dryers-Reparrrng or Servicmg. Should you not find a
listrng. dial free, the WhIrlpool COOL-LINE@ servrce assrstance
telephone number [phone] When callrng from

Mrchrgan Dral(800) 632-2243

Alaska& Hawall.. Dral(600) 253-l 121
If you move..

Call the TECH-CARE servrce representalrve rn your local
area He’ll see to the rnstallatron of WHIRLPOOL appliances rn
your new home, promptly. expertly and farrly priced to you

Helpful hints.

You can help your TECH-CARE servrce representatrve grve
you faster servrce If you Include the model and serial number of
your applrance when requestrng servrce. Also, retarn your sales
slip and warranly to venfy your warranty status

Remember..

Your TECH-CARE servrce representatrve IS specrally trained

In the expert repaIrIng and servrcrng of your WHIRLPOOL

appliances. He can help you marntarn the quality orrgrnally burlt

Into your WHIRLPOOL applrance So why not takethe trme, now,

to look up his telephone number and jot it down rn the space

provided below

appliance ever needs servlceanywhere

to your

companies to futfrll your warranty and

My TECH-CARE service representatrve’s telephone number IS.

Range hood model number-

Range hood serral number

Purchase and/or rnstallallon date

Whirlpool

Benlon Harbor, Mlchlgan Aulomatlc Washers,
Clothes Dryers, Freezers, Refrlgeralor-Freezers.
Ice Makers, DIshwashers. Bullt-In Ovens and
Surface Un11s. Ranges, MIcrowave Ovens, Food
Waste Drsposers, Compaclors, Room Arr
Condltloners. Dehumldlflers. Central HealIngand
Air Condltlonmg Systems

A625828

5-29-79

Part No

830725