Page 1
COMMERCIAL
GAS DRYER
MODEL
GCGM2991TQ0
2−07 Litho in U.S.A. (LT)
c
2007 WHIRLPOOL CORPORATION
Part No. W10119636 Rev. A
Page 2
TOP AND CONSOLE PARTS
For Model: GCGM2991TQ0
(White)
W10119636
2
Page 3
TOP AND CONSOLE PARTS
For Model: GCGM2991TQ0
(White)
Illus. Part
No. No. DESCRIPTION
1 Literature Parts
8527907 Use & Care Guide
8576818 Wiring Diagram
8577213 Instructions,
Installation
W10119636
2 8283378 Cover, Lint Screen
3 8316433 Pushbutton
4 8316437 Switch, Pushbutton
5 357572 Clip, Ground
6 3949737 End Cap (R.H.)
7 97787 Screw, 11−16 x 3/4
8 3949734 End Cap (L.H.)
9 8527826 Control Panel
10 349639 Handle & Lint
11 8527828 Bracket, Control
12 3978606 Hinge, L.H.
3978605 Hinge, R.H.
13 688983 Screw, 8−18 x 5/8
14 8066156 Panel, Rear
15 357213 Nut, Push−In (2)
16 8316630 Top
17 297535 Bumper, Lint Lid
18 303921 Screw, 8−32 x 3/8
19 3979596 Timer
20 8533971 Screw, 8−18 x 5/16
21 693995 Screw, Hex Head
22 339554 Screw
23 Wire, Jumper
3393811 Violet
3393812 Blue
24 3398893 Wire, Ground
25 8529317 Knob, Timer
26 8299876 Harness, Wiring
27 94614 Terminal
28 717252 Receptacle, 2−Way
29 3395683 Connector
30 689559 Nut, Push In
31 3403498 Connector,
32 3403499 Connector,
33 3936144 Connector
34 3394427 Clip, Harness
35 3397269 Connector, Timer
Repair Parts List
Screen Assembly
10−16 x 5/16
(Complete)
(Motor)
3−Position
2−Position
3
W10119636
Page 4
CABINET PARTS
For Model: GCGM2991TQ0
(White)
W10119636
4
Page 5
CABINET PARTS
For Model: GCGM2991TQ0
(White)
Illus. Part
No. No. DESCRIPTION
1 3396805 Panel, Rear
2 3394975 Plug, Front Panel
3 697776 Screw, Ground
10−32 x 5/8
4 3403630 Plug, Strike
5 388326 Screw,
8−18 x 1−1/4
6 8541400 Bracket, Cabinet
7 343641 Screw, 10−16 x 1/2
8 697773 Screw, 6−20 x 7/8
9 693995 Screw, Hex Head
8−18 x 3/8
10 3980175 Clamp−Elbow
14 3404413 Plug, Hinge Hole
15 3396795 Cover, Block
16 238088 Hinge, Top (2)
17 3406109 Door Switch
Assembly
18 3401401 Cord, Power
19 341029 Clamp, Pipe
(Rear)
21 98234 Clip, Ground (2)
Illus. Part
No. No. DESCRIPTION
22 3406129 Seal & Bearing
Assembly
23 3401771 Burner Assembly
(60 Hz.)
(Refer to Pages
8 & 9 For Further
Breakdown)
24 3403447 Front Panel
Assembly
25 3392100 Foot, Plastic
279810 Foot − Optional
(Extended Length
Package Of 2)
(Not Included)
28 8530603 Cabinet
(Includes
Illus. 6)
32 686590 Ignitor
33 690363 Lock, Front Top
34 685203 Clip, Felt Pad (2)
35 3393909 Screw & Washer
36 3394083 Clip, Front Panel
Illus. Part
No. No. DESCRIPTION
37 3389441 Catch, Door
Assembly
38 8066206 Motor Assembly,
60 Hz.
39 348780 Base, Motor
40 8066065 Belt, Drive
41 3400500 Bolt,
5/16−18 x 3/4
42 8281908 Valve, Gas
(Complete)
60 Hz.
44 691366 Idler & Pulley
Assembly
46 660658 Clip, Motor
47 3404162 Clamp, Motor
48 8066184 Pulley, 60 Hz.
52 3405246 Seal, Door
54 3403431 Strike, Door
58 3405514 Hinge, Door
60 342055 Screw, 8−18 x 1/2
61 3402341 Door, Rear
63 3402335 Door, Front
64 3405184 Handle, Door
5
W10119636
Page 6
BULKHEAD PARTS
For Model: GCGM2991TQ0
(White)
W10119636
6
Page 7
BULKHEAD PARTS
For Model: GCGM2991TQ0
(White)
Illus. Part
No. No. DESCRIPTION
1 348368 Lint Chute Assembly
2 3388703 Washer−Support
3 347139 Seal, Lint
Chute
4 3390647 Screw, 8−18 x 1/2
5 90767 Screw, 8−18 x 3/8
6 3392519 Fuse, Thermal
7 280010 Kit,
Thermal Cut−Off
(Includes
Illus. 15)
8 3387134 Thermostat,
Internal Bias
9 3406022 Bracket, Bulkhead
10 694089 Wheel, Blower
(Includes
Illus. 19)
11 8577230 Housing, Blower
Illus. Part
No. No. DESCRIPTION
12 3398161 Clip
13 343641 Screw, 10−16 x 1/2
14 8530285 Box, Heater
15 3403140 Thermostat,
High Limit
F
205
(96
C)
17 3401707 Wire, Jumper
18 8066049 Funnel, Burner
20 8066086 Drum Hole
Plug
23 339554 Screw, Sensor
To Funnel
41 690997 Ring, Tri
42 3399506 Shaft, L.H.
43 3399507 Shaft, R.H.
44 3397590 Roller, Support
Illus. Part
No. No. DESCRIPTION
46 348197 Washer, Support
47 3359452 Nut, 3/8−16
48 3403410 Bulkhead
49 338906 Sensor, Radiant
62 692526 Ring, Bearing
W10109200
63
66 3406130 Seal, Rear
67 695587 Drum Assembly
68 692490 Baffle, Drum
71 3403636 Baffle, Drum
73 339956 Seal
74 3976434 Bracket, Support
75 90296 Clip
76 489463 Screw, 8−18 x 5/8
77 696302 Shield, Exhaust
Screw, 11−16 x 3/4
(Wide)
(Narrow)
Shaft
7
W10119636
Page 8
3401771 BURNER ASSEMBLY
For Model: GCGM2991TQ0
(White)
USE WITH TYPE 1 − NATURAL, TYPE 2 − MIXED, TYPE 3 − MANUFACTURED
AND TYPE 4 − LIQUEFIED PROPANE AND BUTANE GASES
W10119636
BA−128−A
8
Page 9
3401771 BURNER ASSEMBLY
For Model: GCGM2991TQ0
(White)
USE WITH TYPE 1 − NATURAL, TYPE 2 − MIXED, TYPE 3 − MANUFACTURED
AND TYPE 4 − LIQUEFIED PROPANE AND BUTANE GASES
Illus. Part
No. No. DESCRIPTION
1 3401771 Burner Assembly
60 Hz.
(Type 1, 2 & 3)
(White Rodgers)
2 688617 Tube, Burner
3 694298 Bracket, Ignitor
4 686590 Ignitor
5 3393909 Screw & Washer
(8−32 x 5/8)
6 343641 Screw, 10−16 x 1/2
7 693986 Base, Burner
8 3387057 Screw,
8−18 x 3/8 (2)
9 Orifice, Burner
234826 Type 1
15775 Type 2
15419 Type 3
229742 Type 4 (Butane)
234868 Type 4 (Propane)
10 3401775 Valve, 60 Hz.
11 694421 Screw,
8−32 x 1/2 (2)
12 694538 Bracket, Coil
13 694540 Coil, 60 Hz.
(2 Terminal)
(Main)
14 694539 Coil, 60 Hz.
(Split)
(3 Terminal)
(Pilot Position)
15 694424 Leak Limiter
16 694423 Screw, Regulator
Adjustment
17 694422 Spring, Regulator
20 239822 Plug, Pipe
21 233273 Pipe, Gas Supply
22 3393658 Valve & Union,
Shut−Off
23 3393767 Pipe, Tail
24 233076 Nut, Compression
25 341029 Clamp, Pipe
Following Parts Not Illustrated
694572 Conversion Kit
(Type 1, 2 & 3)
to Type (4) L.P.G.
9
BA−128−A
W10119636
Page 10
OPTIONAL PARTS (NOT INCLUDED)
For Model: GCGM2991TQ0
(White)
Illus. Part
No. No. DESCRIPTION
ACCESSORY PARTS
279948 Kit,
Dryer Repair
8522199 Kit, Dryer
Vent Testing
PAINT, TOUCH−UP (1/2oz.)
72017 White
PAINT, PRESSURIZED SPRAY
(12 oz.)
350930 White
350938 Primer, Gray
PAINT, TOUCH−UP (1 qt.)
799344 White (Uncut)
W10119636
10
Loading...