Whirlpool CGM2761KQ1 User Manual

Page 1
CORPORATION
COMMERCIAL
GAS DRYER
MODEL
9−01 Litho in U.S.A. (djc)
c
2001 WHIRLPOOL CORPORATION
Part No. 8528103
Page 2
TOP AND CONSOLE PARTS
For Model: CGM2761KQ1
(Designer White)
8528103
2
Page 3
TOP AND CONSOLE PARTS
For Model: CGM2761KQ1
(Designer White)
Illus. Part
No. No. DESCRIPTION
1 Literature Parts
LIT8527795 LIT8316259 LIT8528103
2 357213 Nut, Push−In 3 3361029 Bracket, Control 4 8316634 Panel, Control 5 8316516 Cap, End (R.H.) 6 3949734 Cap, End (L.H.) 7 97787 Screw, 11−16 x 3/4 8 8316437 Switch, Pushbutton
9 8316433 Pushbutton 10 693995 Screw, 8−18 x 3/8 11 3954665 Top 12 3393918 Screw,
13 3348109 Lens, Amber (3) 14 689559 Nut, Push−In 15 3390646 Screw, 8−18 x 5/16 16 343641 Screw, 10−16 x 1/2 17 8316238 Meter Case
18 3978608 Panel, Rear 19 3390647 Screw, 8−18 x 1/2
20 351297 Plug, Harness 21 8318255 Strap, Console 22 8283166 Harness, Main 23 717252 Receptacle
24 3954807 Kit, Vertical 25 385421 Funnel, Coin
26 717315 Receptacle 27 3395683 Housing, 28 357572 Clip, Ground
Instructions, Installation Label, Wiring Diagram Repair Parts List
8−18 x 11/32
Conversion Kit (Upper)
(2−Way) Coin Slide
(4−Way) Connector
Illus. Part
No. No. DESCRIPTION
29 3391018 Tie, Cable 30 3954812 Cushion, Case 31 3406994 Case, Meter 32 3401126 Harness, Timer 33 3936144 Connector,
3−Circuit
34 3349065 Bolt,
5/16−24 x 1
35 3387975 Timer
(Includes 4−Pin Cam)
36 Timing Cam
3387974 3−Pin
339855 4−Pin
343777 6−Pin 37 387371 Lock, Plug 39 8316640 Lights, Indicator 43 3351136 Door, Service 45 339805 Screw,
10−32 x 3/16 46 3398893 Ground Wire 47 3394427 Clip, Harness 51 8317340 Cover, Terminal
Block 52 3390814 Screw, 8−18 x 3/8 53 3401850 Harness, Gas
53A 697779 Plug, 3−Way 53B 3403498 Connector,
3 Position
53C 3403499 Connector,
2 Position 54 3347825 Plate−Mounting (2) 55 98445 Screw, 10−16 x 3/4 56 90406 Nut, Cage
Coin Mechanism Parts, May Be Ordered from The Vendor(s) Listed Below.
8316526 Security Lock &
59 60 Slide &
Whirlpool Or
Cam Assembly
Extension
Illus. Part
No. No. DESCRIPTION
8316521 Bolt, Slide
61
Mechanism
8316520 Slide Mechanism
62
(Vertical 8−Coin) Inserts
(Not Shown) 8316264 Blank 8316265 25¢
63
8316525 Money Box W/Lock
64 Key (Money Box)
(When Ordering,
Specify Vendor
of Money Box Lock)
65 Slide Extension
Bag Assembly
66 Key (Service Door)
8316523 Extension
67 68
8316524 Kit, Decal 8316532 Installation
69
Instructions
Coin Kit 3400086 Screw, 10−32 x 3/8
70
GREENWALD 212 Middlesex Ave. Chester, CT 06412−1254
1−800−221−0982 sales greenwaldindustries.com
@
ESD 270 New Jersey Dr. Fort Washington, PA 19034
1−800−523−1510 info esdcoin.com
@
3
8528103
Page 4
CABINET PARTS
For Model: CGM2761KQ1
(Designer White)
8528103
4
Page 5
CABINET PARTS
For Model: CGM2761KQ1
(Designer White)
Illus. Part
No. No. DESCRIPTION
1 3391943 Boot, Foot 2 356674 Cone, Wedge 3 3393258 Screw, 10−16 x 1/2 4 3391846 Clip, Front
Panel (2)
5 3394881 Switch, Broken
Belt
6 691581 Lever, Door
Switch 7 8310656 Cabinet 8 3392100 Foot, Dryer
(Plastic)
279810 Foot − Optional
(Extended Length
Package Of 2)
(Not Included) 9 660658 Clamp, Motor (2)
10 3387374 Spring, Idler 11 3389420 Retainer, Idler 12 697750 Plug, Multivent 13 3388672 Pulley Assembly 14 3391915 Screw, 10−16 x 1 15 3394331 Plate, Cover 16 3394081 Wire, Belt Switch 17 90406 Nut, Cage 18 233520 Washer, Thurst 19 297092 Clip (2) 20 690997 Tri−Ring 21 3389247 Hinge And Pin (2) 22 3353948 Bracket, Lock 23 3390663 Screw, 10−16 x 1/2 24 3393657 Restrainer, Belt
Illus. Part
No. No. DESCRIPTION
25 63554 Rivet (2) 26 3389249 Nut, "U" (4) 27 661656 Motor Assembly
(60 Hz.) 29 3389627 Pulley 60 Hz 30 3387610 Belt, Drive 31 3390902 Clip, Door
Hinge (2) 32 3387118 Bracket, Motor 33 3392186 Washer 36 3401401 Cord, Power 39 3388674 Bracket, Idler 40 3388600 Clip, Lint Duct 41 347207 Switch, Door 42 98129 Screw,
6/20 x 1 1/16 44 3387242 Seal, Front Panel 45 342055 Screw, 8−18 x 1/2 46 3388229 Retainer 47 3392563 Door, Rear 48 694091 Screw, 8−18 x 3/8 49 3387872 Door, Front 51 3393081 Lower Front Panel 52 696144 Strike, Door 53 697776 Screw, Ground
10−16 x 1/2 55 3391408 Lever, Snap
Switch 57 3390735 Seal, Door 58 3392538 Catch, Door
Assembly
59 3398948 Wire, Jumper
Illus. Part
No. No. DESCRIPTION
60 3389522 Handle, Door 61 697215 Panel, Toe 64 3401797 Burner Assembly
60 Hz. (Refer To Pages 8 & 9 For Further
Breakdown) 65 3390647 Screw, 8−18 x 1/2 66 3401775 Valve, Gas
(Complete)
60 Hz 67 3387561 Clamp, Pipe 68 3393909 Screw, 8−32 x 5/8 69 686590 Ignitor 70 3387057 Screw, 8−18 x 3/8 71 279731 4" − 90
Elbow
Optional Parts Not Included
Dryer Exhaust Kit
(For Side & Bottom Venting)
72 279818 White
5
8528103
Page 6
BULKHEAD PARTS
For Model: CGM2761KQ1
(Designer White)
8528103
6
Page 7
BULKHEAD PARTS
For Model: CGM2761KQ1
(Designer White)
Illus. Part
No. No. DESCRIPTION
1 3399508 Shaft, R.H. Thread 2 8066086 Drum Hole
Plug 3 3390646 Screw, 8−18 x 5/16 4 90767 Screw, 8−18 x 3/8 5 3394346 Air Duct Assembly 6 697813 Seal, Outlet
Housing 7 697814 Seal, Drum Front 8 3359452 Nut,
3/8 x 16 (R.H.) 9 8318486 Exhaust Pipe
10 3388229 Clip 12 3394986 Spring, Lint
Door
13 3390647 Screw, 8−18 x 1/2
Illus. Part
No. No. DESCRIPTION
16 3387709 Nut,
3/8−16 (L.H.) 17 3387809 Bulkhead, Rear 18 3387459 Washer, Support 19 3399509 Shaft, L.H. Thread 20 690997 Ring, Tri 21 3396801 Roller, Support 23 3394985 Housing, Outlet 25 8318215 Drum Complete 26 97787 Screw, 11−16 x 3/4 27 697694 Seal, Drum 30 3394984 Door, Lint Screen 31 487909 Screw, 8−15 x 1/2 37 697772 Wheel, Blower 42 3387138 Thermostat 44 8530038 Housing, Blower 45 8530036 Lint Duct Assembly
Illus. Part
No. No. DESCRIPTION
46 8066047 Funnel, Burner 47 338906 Sensor, Radiant 48 3391912 Thermostat 255
(124 C) 51 3357011 Screw, 10−16 x 1/2 52 697771 Cover, Blower
(Includes Illus.
Nos. 60 & 62) 53 697693 Baffle, Drum (3) 54 697557 Bulkhead, Front 58 8299979 Grill, Outlet 59 3390719 Thermal Fuse 60 697770 Seal, Cover Plate 62 697769 Seal, Lint Duct 64 3390721 Screen, Lint
OPTIONAL PARTS (NOT INCLUDED)
Illus. Part
No. No. DESCRIPTION
PAINT, TOUCH−UP (1/2oz.)
72017 White
PAINT, PRESSURIZED SPRAY (12 oz.)
350930 White 350938 Primer, Gray
PAINT, BULK (1 qt.)
799344 White (Uncut)
7
8528103
Page 8

3401797 BURNER ASSEMBLY

For Model: CGM2761KQ1
(Designer White)
USE WITH TYPE 1 − NATURAL, TYPE 2 − MIXED,
AND TYPE 4 − LIQUEFIED PROPANE AND BUTANE GASES
8528103
BA−133−A
8
Page 9
3401797 BURNER ASSEMBLY
For Model: CGM2761KQ1
(Designer White)
USE WITH TYPE 1 − NATURAL, TYPE 2 − MIXED,
AND TYPE 4 − LIQUEFIED PROPANE AND BUTANE GASES
Illus. Part No. No. DESCRIPTION
10 11 12
13
14
15 16
17 20 21 22
23 24 25 26
1
2 3 4 5
6 7 8
9
3401797
688617 694298 686590
3393909
343641 3389871 3387057
3397656
15775
3401775
694421
694538
694540
694539
694424
694423
694422
239822 3387224
697441 3393767
233076 3387561 3389889
Burner Assembly 60 Hz. (Type 1, 2 & 3) (White Rodgers) Tube, Burner Bracket, Ignitor Ignitor Screw & Washer (8−32 x 5/8) Screw, 10−16 x 1/2 Base, Burner Screw, 10−16 x 1/2 (3) Orifice, Burner Type 1 Type 2 Valve, Gas 60 Hz. (Complete) Screw, 8−32 x 1/2 (2) Bracket, Coil Coil, 60 Hz. (2 Terminal) (Main) Coil, 60 Hz. (Split) (3 Terminal) (Pilot Position) Leak, Limiter Screw, Regulator Adjustment Spring, Regulator Plug, Pipe Pipe, Gas Supply
Valve & Union
Shut−Off Pipe, Tail Nut, Compression
Clamp, Pipe Bracket, Support
Following Parts Not Illustrated
694572
Conversion Kit (Type 1 and 2)
to Type (4) L.P.G.
9
BA−133−A
8528103
Loading...