West Bend 82416, L5792B User Manual

A

IR CRAZY™ HOT AIR POPCORN POPPER

Instruction Manual

Register this and other Focus Electrics products through our website:

www.registerfocus.com

Important Safeguards............................................................................................... 2

Before Using for the First Time ................................................................................ 3

Using Your Air Crazy™ Hot Air Popcorn Popper ..................................................... 4

Helpful Hints............................................................................................................. 5

Cleaning Your Air Crazy™ Hot Air Popcorn Popper................................................. 5

Warranty................................................................................................................... 6

SAVE THIS INSTRUCTION MANUAL FOR FUTURE REFERENCE

 2009 West Bend®, a Brand of Focus Electrics, LLC.

www.focuselectrics.com

IMPORTANT SAFEGUARDS

To prevent personal injury or property damage, read and follow all instructions
and warnings.

When using electrical appliances, basic safety precautions should always be
followed including:

• Read all instructions, including these important safeguards and the care and use
instructions in this manual.

• Do not touch hot surfaces. Use handles or knobs and hot pads or oven mitts.
Cover and measuring/butter cup become hot during operation.

• Always unplug from outlet when not in use and before cleaning. Allow to cool
before putting on or taking off parts and before cleaning.

• Close supervision is necessary when this appliance is used by or near children.

• Do not operate any appliance with a damaged cord or plug, after the appliance

malfunctions, or has been damaged in any manner. For service information see
warranty page.

• The use of accessory attachments not recommended by Focus Electrics may
cause injuries.

• Do not use this appliance outdoors.

• Do not let cord hang over the edge of the table or counter, or touch hot surfaces.

• Do not place on or near a hot gas or electric burner, or in a heated oven.

• To disconnect, turn any control to “OFF,” then remove plug from wall outlet.

• Do not use appliance for other than intended use.

• To protect against electric shock, do not immerse cord, plugs, or other electric

parts in water or other liquids.

• Do not attempt to repair this appliance yourself.

• A popper that is plugged into an outlet should not be left unattended.

• This popper will not shut off automatically. To avoid overheating, add popcorn

kernels before operating.

• A short power-supply cord is provided to reduce risks resulting from becoming
entangled in or tripping over a longer cord.

• Longer extension cords are available, but care must be excersized in their use.
While use of an extension cord is not recommended, if you must use one,
ensure that the marked electrical rating of the extension cord is equal to or
greater than that of the appliance. If the plug is of the grounded type, the
extension cord must be a grounding-type 3-wire cord. To avoid pulling, tripping
or entanglement, position the extension cord so that it does not hang over the
edge of the counter, table or other area where it can be pulled on by children or
tripped over.

2

• This appliance has a polarized plug (one blade is wider than the other). To
reduce the risk of electric shock, this plug is intended to fit into a polarized outlet
only one way. If the plug does not fit fully into the outlet, reverse the plug. If it
still does not fit, contact a qualified electrician. Do not attempt to modify the plug
in any way.

• Do not use an outlet or extension cord if the plug fits loosely or if the outlet or
extension cord feels hot.

• During use, do not remove cover. Do not remove cover or measuring/butter cup
from the appliance until you have not heard a kernel pop for at least 1 minute.

• For household use only.

SAVE THESE INSTRUCTIONS

½ Cup

Measuring/Butter Cup

Cover

Popper Base

“ON/OFF” Switch

B

EFORE USING FOR THE FIRST TIME

Wash the popper cover and measuring/butter cup with warm, soapy water. Rinse
thoroughly and dry. Wipe the exterior of the popper base and popcorn chute with a
soft, damp cloth and dry. It is not necessary to clean inside the popcorn chamber.
Note: DO NOT immerse the popper base in water or any other liquid. Once
removed, the measuring/butter cup and cover can be washed in a dishwasher, top
rack only. DO NOT put the popper base into the dishwasher. This will permanently
damage the product and will void the warranty.

3

U

SING YOUR AIR CRAZY™ HOT AIR POPCORN POPPER

This popper uses hot air to pop the corn. DO NOT place anything other
than popcorn kernels into the popping chamber.

1. Remove the cover and measuring/butter cup. Ensure that the vents are clear of
popcorn pieces before each use. Use the measuring/butter cup, or a standard
measuring cup, to measure a level ½ cup of popcorn kernels. DO NOT attempt
to pop more than  cup of popcorn kernels at one time.

2. Pour popcorn kernels into the popping chamber. DO NOT put oil, butter,
shortening, salt, or anything other than popcorn into the chamber. Place the
cover in position, then place the measuring/butter cup into the cover.

3. If buttered popcorn is desired, place 2-3 tablespoons of room temperature
butter, cut into 4 equally sized pats, into the measuring/butter cup. Note: Do not
use refrigerated butter as it will not melt completely in the short popping cycle.
DO NOT remove the measuring/butter cup during the popping cycle. If
unbuttered popcorn is desired, it is still necessary to place the measuring/butter
cup into the cover. Never run the Air Crazy™ popcorn popper without the

cover and measuring/butter cup in place.

4. Place a 4 quart, or larger, heat-resistant bowl below the popcorn chute to collect
popcorn as it pops. ½ cup of popcorn kernels will yield between 3 and 4 quarts
of popped popcorn.

5. Plug the cord into a 120 volt, AC outlet ONLY. With the cover and
measuring/butter cup in place, press the “ON/OFF” switch to the on position,
toward the “ l ” symbol.

6. Popcorn will begin to pop, and the cycle will be done within 3 - 4 minutes. After
popcorn has completed popping, turn the “ON/OFF” switch to the off position,
the “ O “ symbol. Popcorn cycle has completed when there is a gap of 5
seconds between kernels popping. Unplug the popper from the outlet. Let the
popper sit, with the lid and measuring/butter cup in place, for at least one minute
after completion of the popping cycle. Unpopped kernels may still pop
unexpectedly. Use caution when handling the Air Crazy™ popcorn popper, it
will be hot after popping cycle. Always use hot pads or oven mitts to handle the
hot appliance.

7. If butter was melted in the measuring/butter cup, pour over the top of the
popped corn and sprinkle with salt or other popcorn seasonings as desired.

8. If you wish to pop more batches of popcorn immediately, remove any unpopped
kernels and loose popcorn from the popper by inverting the popper. Use oven
mitts or hot pads when handling the hot popper. If butter was melted in the
butter cup, clean and dry the measuring/butter cup and replace in the cover.
Repeat steps 1-7 above.

• A small amount of smoke and/or odor may occur upon heating due to the
release of manufacturing oils – this is normal.

• Some minor expansion/contraction sounds may occur during heating and
cooling – this is normal.

4

H

ELPFUL HINTS

• Always use fresh popcorn. Dried out, stale, or old popcorn pops poorly as it has
lost its moisture content and may scorch.

• This popcorn popper can accommodate both regular and premium popcorns.
Premium and gourmet popcorns do not yield results as good as regular
popcorn. If premium or gourmet popcorn is used, you may notice an increase in
the number of unpopped kernels.

• This popper pops using hot air. It does not require any oils or fats to pop the
corn, and they should never be used in the popper. DO NOT use microwave
popcorn.

• If popcorn does not pop, it is usually the result of environmental factors such as
the freshness and moisture content of the popcorn, or variances by popcorn
type. Unpopped kernels do not necessarily indicate a defect in the appliance.

• To use the cord wrap, wind the cord around the post at the bottom of the
appliance for easy, tangle-free storage.

C

LEANING YOUR AIR CRAZY™ HOT AIR POPCORN POPPER

Your Air Crazy™ popcorn popper may be cleaned after every use. Note: Do not
immerse the popper base in water or any other liquid. Do not use any abrasive
cleansers or scrubbers on any part of the popper.

1. Unplug the appliance from the electrical outlet. Allow the entire appliance to
cool, with measuring/butter cup in place, before cleaning.

2. Remove the cover and measuring/butter cup from the popper base. Separate
the cover and measuring/butter cup. Wash in warm, soapy water. Rinse and dry
thoroughly. The measuring/butter cup and cover may be washed in a
dishwasher, top rack only.

3. Use a soft, damp cloth to wipe the exterior of the popper and the popcorn chute.
DO NOT wipe inside the popping chamber. Check during every cleaning that no
pieces of popcorn are lodged into the vents; ensure that the vents are clear
before each use.

This appliance has no user serviceable parts.

5

P

RODUCT WARRANTY

Appliance 1 Year Limited Warranty

Focus Electrics, LLC (“Focus Electrics”) warrants this appliance from failures in the material
and workmanship for one (1) year from the date of original purchase with proof of purchase,
provided the appliance is operated and maintained in conformity with the provided Instruction
Manual. Any failed part of the appliance will be repaired or replaced without charge at Focus
Electrics’ discretion. This warranty applies to indoor household use only.

This warranty does not cover any damage, including discoloration, to any non-stick surface of
the appliance. This warranty is null and void, as determined solely by Focus Electrics if the
appliance is damaged through accident, misuse, abuse, negligence, scratching, or if the
appliance is altered in any way.

THIS WARRANTY IS IN LIEU OF ALL IMPLIED WARRANTIES, INCLUDING WARRANTIES
OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE, PERFORMANCE, OR
OTHERWISE, WHICH ARE HEREBY EXCLUDED. IN NO EVENT SHALL FOCUS
ELECTRICS BE LIABLE FOR ANY DAMAGES, WHETHER DIRECT, INDIRECT,
INCIDENTAL, FORSEEABLE, CONSEQUENTIAL, OR SPECIAL, ARISING OUT OF OR IN
CONNECTION WITH THIS APPLIANCE.

If you think the appliance has failed or requires service within its warranty period, please
contact the Focus Electrics Customer Service Department at [phone], or e-mail us at
[e-mail]. A receipt proving the original purchase date will be required for all
warranty claims, hand written receipts are not accepted. You may also be required to return
the appliance for inspection and evaluation. Return shipping costs are not refundable. Focus
Electrics is not responsible for returns lost in transit.

Replacement parts, if available, may be ordered directly from Focus Electrics, LLC several
ways. Order online at www.focuselectrics.com, e-mail [e-mail], over the
phone by calling [phone], or by writing to:

Focus Electrics, LLC
Attn: Customer Service
P. O. Box 2780
West Bend, WI 53095

To order with a check or money order, please first contact Customer Service for an order total.
Mail your payment along with a letter stating the model or catalog number of your appliance,
which can be found on the bottom or back of the unit, a description of the part or parts you are
ordering, and the quantity you would like. Your check should be made payable to Focus
Electrics, LLC.

Your state/province’s sales tax and a shipping fee will be added to your total charge. Please
allow two weeks for processing and delivery.

This manual contains important and helpful information regarding the safe use and care of your
new Focus Electrics product. For future reference, attach dated sales receipt for warranty proof
of purchase and record the following information:

Date purchased or received as gift: _______________________________________________
Where purchased and price, if known: _____________________________________________
Item number and Date Code (shown bottom/back of product):___________________________

L5792B 10/09 West Bend®, a Brand of Focus Electrics, LLC. Printed in China

Valid only in USA and Canada

R

EPLACEMENT PARTS

6