Wells G-13 Service Manual

SERVICE PARTS LIST

PL101

COUNTERTOP ELECTRIC GRIDDLES

Models:

G-13, G-19

101

G-23, G-24, G-60

CONTENTS

Description page

Parts List ……………………………….………………….. 2 General Information ……………...…………….………… 3 Models: G-13 Heating Elements …………………….…….. 4 Cabinet & Electrical …..………….………… 5 G-19 Heating Elements …………………….……. 6 Cabinet & Electrical ………………..………. 7 G-23 Heating Elements …………………….…….. 8 Cabinet & Electrical …..………….………… 9 G-24 Heating Elements …………………….……. 10 Cabinet & Electrical ………………..…….…. 11 G-60 Heating Elements …………………….……. 12 Cabinet & Electrical ………………..…….… 13

p/n PL101 Rev.B 060203 cps

PART # DESCRIPTION

OPTIONAL ACCESSORIES

20314 FEET, ADJ 4” GRAY PLASTIC (pk4) 20563 FEET, ADJ 4” METAL (pk4) 20632 SPLASH GUARD ASSY G-13 20634 SPLASH GUARD ASSY G-19 20635 SPLASH GUARD ASSY G-23 20636 SPLASH GUARD ASSY G-24 20637 SPLASH GUARD ASSY G-60

ELECTRICAL

50131 TERMINAL BLOCK 3P 85 AMP 50527 THERMOSTAT, CONTROL 50496 ELEMENT 2250W 240V (G-13) 50507 ELEMENT 1000W 240V PERIM (G-24) 50508 50509 ELEMENT 3800W 240V (G-23, -60) 50510 ELEMENT 3800W 208V (G-23, -60) 50511 ELEMENT 3000W 208V (G-19) 50512 ELEMENT 3000W 240V (G-19) 50513 ELEMENT 2500W 208V (G-24) 50516 LIGHT SIGNAL AMBER 240V 50520 ELEMENT 2500W 240V (G-24) 51276 TERMINAL BLOCK 3P 125A 51428 ELEMENT 3800W 480V (G-23, -60) 51495 51498 ELEMENT, 1000W 480V PERIM (G-24) 52054 JUMPER, ELEM SHORT (pk10) 57465 TERMINAL BLOCK 3P 115A 60436 LIGHT SIGNAL AMBER 480V 68902 ELEMENT, 2500W 480V (G-19) 68903 ELEMENT, 2500W 480V (G-24) 68904 ELEMENT 2250W 480V (G-13)

ELEMENT 800W 240V PERIM (G-23, -60)

ELEMENT 800W 480V PERIM (G-23, -60)

PART # DESCRIPTION

MECHANICAL

50256 TRIM RING, THERMO 50259 KNOB, THERMO 50279 GREASE DRAWER ASSY COMPLETE 51968 CLAMP, ELEM CTR SMALL 51969 CLAMP, ELEM END SMALL 51971 TUBE, THERMO 24” 51972 TUBE, THERMO 18” 51973 HANDLE, GREASE DRAWER 51974 SHIELD, THERMO FISHPAPER 51989 SHROUD, GREASE DRAWER 51995 COVER, GREASE DRAWER 52025 CLAMP, ELEM PERIM 52026 CLAMP, ELEM RT 52027 CLAMP, ELEM LF 52028 CLAMP, THERMO BULB 52037 CLAMP, ELEM CTR LARGE 52038 CLAMP, ELEM END LARGE 53848 TRADEMARK DOMED LABEL 53948 PANEL, GREASE DRAWER FRONT 54436 SPLASHGUARD, REAR (G-19, -23) 54437 SPLASHGUARD, REAR (G-13) 54439 SPLASHGUARD, REAR (G-24) 55663 GRIDDLE PLATE ASSY (G-13) 55665 GRIDDLE PLATE ASSY (G-19) 55666 GRIDDLE PLATE ASSY (G-23) 55667 GRIDDLE PLATE ASSY (G-24) 55668 GRIDDLE PLATE ASSY (G-60) 55780 SPLASHGUARD, RT (G-13, -19) 55781 SPLASHGUARD, LF (G-13, -19) 55782 SPLASHGUARD, RT (G-23, -24, -60) 55783 SPLASHGUARD, LF (G-23, -24, -60)

PART # DESCRIPTION

HARDWARE, etc.

51040 BUSHING HEYCO 7/8” 51053 NUT 8-32 HEX MS KEPS Ni (pk100) 51253 NUT 1/4-20 HEX MS Ni (pk100) 51718 SCREW 6-32 x 3-16 PH TR MS Ni 53474 CLIP, INSULATION TIE-DOWN (pk12) 52040 SLEEVING, GLASS (pk 6 ft.) 53935 SCREW 6ABx5/16 PAN SMS Zi 54284 POP RIVET 3/32Dx1/8 55135 SCREW 6-32x1/4 FIL MS Ni (pk25) 57463 NUT, 8-32 LONG TNR (pk10) 55313 NUT 10-32 HEX MS Ni 55736 NUT 8-32 KEPS GREEN (pk10) 57407 INSULATION FG 1”x24”x48” 61974 NUT 8-32x7/8 LONG Alu

LITERATURE & DOCUMENTATION

31274 WIRING DI AGRAM G-19 31275 WIRING DI AGRAM G-23 32064 WIRING DI AGRAM G-60 48929 WIRING DI AGRAM G-13 48930 WIRING DI AGRAM G-24

303339 OPMANUAL ELECT GRIDDLE

FIELD CONVERSION FROM 3-PHASE TO SINGLE-PHASE

Griddles are shipped from the factory wired for 3-phase power, 208 volt and 240 volt griddles are field convertible to single-phase.

*NOTE: G-60 has 2 separate electrical supplies

CONTROL KNOB CONFIGURATION

For all models, control knob p/n 50259 is marked in degrees Fahrenheit from 200ºF to 450ºF. When the thermostat is OFF, the flat of the control shaft is positioned on the bottom.

3 3

COUNTERTOP ELECTRIC GRIDDLE MODEL G-13 - HEATING ELEMENTS 208/240V and 480V

COUNTERTOP ELECTRIC GRIDDLE MODEL G-13 - CABINET & ELECTRICAL 208/240V and 480V

+ 9 hidden pages