Waldorf CHL8600G, CHL8300G, CHL8450G, CH8600G, CH8900G Installation And Operation Manual

Installation and Operation Manual

Chargrill

CH8300G CHL8300G
CH8450G CHL8450G
CH8600G CHL8600G
CH8900G CHL8900G
CH8120G CHL8120G

Date Purchased

Serial Number

Dealer

Service Provider

228592-38

For use in GB, IE & DK

CHB8300G CHLB8300G
CHB8450G CHLB8450G
CHB8600G CHLB8600G
CHB8900G CHLB8900G
CHB8120G CHLB8120G

The reproduction or copying of any part of this manual by any means whatsoever is strictly forbidden unless authorized previously in
writing by the manufacturer.

In line with policy to continually develop and improve its products, Moffat Ltd. reserves the right to change the specifications and
design without prior notice.

© Copyright Moffat Ltd. November 2014.

MANUFACTURED BY

Moffat Limited

Rolleston 7675
New Zealand

INTERNATIONAL CONTACTS

AUSTRALIA

Moffat Pty Limited
Web: www.moffat.com.au
E.Mail: [e-mail]
Main Office: (tel) [phone]

(fax) [phone]

Service: (tel): 1800 622 216
Spares: (tel): 1800 337 963
Customer Service: (tel): 1800 335 315
(fax): 1800 350 281

CANADA

Serve Canada
Web: www.servecanada.com
E.Mail: [e-mail]
Sales: (tel): 800 551 8795 (Toll Free)
Service: (tel): 800 263 1455 (Toll Free)

NEW ZEALAND

Moffat Limited
Web: www.moffat.co.nz
E.Mail: [e-mail]
Main Office: (tel): 0800 663328

UNITED KINGDOM

Blue Seal
Web: www.blue-seal.co.uk
E.Mail: [e-mail]
Sales: (tel): [phone]

(fax): [phone]
Spares: (tel): [phone]
(fax): [phone]
Service: (tel): [phone]
(fax): [phone]

UNITED STATES

Moffat
Web: www.moffat.com
Sales: (tel): 800 551 8795 (Toll Free)

(tel): [phone]
(fax): [phone]
Service: (tel): 800 858 4477 (Toll Free)
(tel): [phone]
(fax): [phone]

REST OF WORLD

Moffat Limited
Web: www.moffat.co.nz
E.Mail: [e-mail]

Contents

CH(L)8300G-(B) Gas Chargrill, 300mm wide - Bench Model Only.
CH(L)8450G-(B) Gas Chargrill, 450mm wide.
CH(L)8600G-(B) Gas Chargrill, 600mm wide.
CH(L)8900G-(B) Gas Chargrill, 900mm wide.
CH(L)8120G-(B) Gas Chargrill, 1200mm wide.

Introduction ............................................................................................................ 2

Specification ........................................................................................................... 3

Model Numbers Covered in this Specification
Gas Supply Requirements

Dimensions ............................................................................................................. 5

Installation ............................................................................................................. 8

Installation Requirements
Unpacking
Location
Clearances
Assembly
Fitting Adjustable Feet / Rear Rollers to Leg Stand Units
Gas Connection
Commissioning

Operation .............................................................................................................. 13

Operation Guide
Description of Controls
Lighting Pilot Burners
Lighting Main Burners
Griddle Plate Fitting
Chargrill Grate Reversal

Cleaning and Maintenance ................................................................................... 16

General
Daily Cleaning
Weekly Cleaning
Periodic Maintenance

Fault Finding ......................................................................................................... 19

Gas Conversion and Specifications ....................................................................... 20

Conversion Procedure
Gas Specifications

Replacement Parts List ......................................................................................... 25

2

Introduction

We are confident that you will be delighted with your WALDORF CHARGRILL, and it will become a most
valued appliance in your commercial kitchen.
To ensure you receive the utmost benefit from your new Waldorf CHARGRILL, there are two important
things you can do.

Firstly:

Please read the instruction book carefully and follow directions given. Time taken will be well spent.

Secondly:

If you are unsure of any aspect of installation, instructions or performance of your appliance, contact
your WALDORF dealer promptly. In many cases a phone call could answer your question.

CE Only:

These instructions are only valid if the country code appears on appliance. If code does not appear on
appliance, refer to supplier of this appliance to obtain technical instructions for adapting appliance to
conditions for use in that country.

GREAT CARE MUST BE TAKEN BY THE OPERATOR TO USE THE EQUIPMENT SAFELY TO GUARD IT AGAINST RISK OF

FIRE.



APPLIANCE MUST NOT BE LEFT ON UNATTENDED.

 I

T IS RECOMMENDED THAT A REGULAR INSPECTION IS MADE BY A COMPETENT SERVICE PERSON TO

ENSURE CORRECT AND SAFE OPERATION OF YOUR APPLIANCE IS MAINTAINED.

 DO NOT

STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPOURS OR LIQUIDS IN THE VICINITY OF

THIS OR ANY OTHER APPLIANCE.



DO NOT SPRAY AEROSOLS IN THE VICINITY OF THIS APPLIANCE WHILE IT IS IN OPERATION.

Warning



This appliance is for professional use and is only to be used by qualified
persons.



Only authorised service persons are to carry out installation, servicing or gas
conversion operations.



Components having adjustments protected (e.g. paint sealed) by the
manufacturer should not be adjusted by the user / operator.



DO NOT operate appliance without the legs supplied fitted.

Caution

IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CA N CAUSE PROPERTY

DAMAGE, INJURY OR DEATH. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS
THOROUGHLY BEFORE INSTALLING OR SERVICING THIS APPLIANCE.

Warning

INSTRUCTIONS

TO BE FOLLOWED IN THE EVENT THE USER SMELLS GAS ARE TO BE POSTED IN A PROMINENT

LOCATION. THIS INFORMATION SHALL BE OBTAINED BY CONSULTING THE LOCAL GAS SUPPLIER.

Warning

3

Model Numbers Covered in this Specification

CH8300G- Gas Chargrill, 300mm wide.
CH[1]8450G-[2] Gas Chargrill, 450mm wide.
CH[1]8600G-[2] Gas Chargrill, 600mm wide.
CH[1]8900G-[2] Gas Chargrill, 900mm wide.
CH[1]8120G-[2] Gas Chargrill, 1200mm wide.

NOTE:

[1]: - Model Options;

- - Standard Models.
L - Low Back Models.
B - Bold Front.
LB - Low Back and Bold Front.

[2] - Base Stand Options;

B - Bench Mount.
CB - Cabinet Base (excluding RN8200G Series).
LS - Leg Stand (excluding RN8200G Series).
RB - Refrigerated Base (RN8600G and RN8800G Series only).

Gas Supply Requirements

- Australia:

- New Zealand):

* - Measure burner operating pressure at the manifold test point with one burner for CH8300G and

CH8450G models or two burners for other models operating at full setting. Operating pressure is
ex-factory set and not to be adjusted, apart from when converting between gases, if required.
(Refer to ‘Gas Conversion’ section for details).

Specifications

Natural Gas LP Gas (Propane)

CH8300G CH8450G CH8600G CH8900G CH1200G CH8300G CH8450G CH8600G CH8900G CH1200G

Input Rating (N.H.G.C.)

33.0 MJ/hr 48.0 MJ/hr 66.0 MJ/hr 100.0 MJ/hr 133 MJ/hr 33.0 MJ/hr 48.0 MJ/hr 66.0 MJ/hr 100.0 MJ/hr 133 MJ/hr

Supply Pressure

1.13 - 3.40 kPa 2.75 - 4.50 kPa

Burner Operating
Pressure (*)

1.0 kPa 0.95 kPa 2.5 kPa 2.6 kPa

Gas Connection

1

/2” BSP

Male

3

/

4

” BSP Male

1

/2” BSP

Male

3

/4” BSP Male

Natural Gas LP Gas

CH8300G CH8450G CH8600G CH8900G CH1200G CH8300G CH8450G CH8600G CH8900G CH1200G

Input Rating (N.H.G.C.)

33.0 MJ/hr 48.0 MJ/hr 66.0 MJ/hr 100.0 MJ/hr 133 MJ/hr 34.5 MJ/hr 50.4 MJ/hr 69.1 MJ/hr 103.6 MJ/hr 138.2MJ/hr

Supply Pressure

1.13 - 3.40 kPa 2.75 - 4.50 kPa

Burner Operating
Pressure (*)

1.0 kPa 0.95 kPa 2.5 kPa 2.6 kPa

Gas Connection

1

/2” BSP

Male

3

/

4

” BSP Male

1

/2” BSP

Male

3

/4” BSP Male

4

Specifications

- United Kingdom

Category: II

2H3P

(20, 30 / 37).

Flue Type: A

1.

* - Measure burner operating pressure at the manifold test point with one burner for CH8300G and

CH8450G models or two burners for other models operating at full setting. Operating pressure is
ex-factory set and not to be adjusted, apart from when converting between gases, if required. (Refer
to ‘Gas Conversion’ section for details).

- All Other Markets:

NOTE:

 (*) - Measure burner operating pressure at the manifold test point with one burner

for CH8300G and CH8450G Models or two burners for other models, operating at the
high setting.

 NAT, LPG & Butane Only - Operating pressure is ex-factory set and is not to be

adjusted, unless when converting between gases, if required.

 (**) - TOWN GAS Only - Adjust burner operating pressure using adjustable gas

regulator supplied.

 Refer to ‘Gas Conversion and Specifications' section in this manual for further details.

Natural Gas (G20) Propane (G31)

CH8300G CH8450G CH8600G CH8900G CH1200G CH8300G CH8450G CH8600G CH8900G CH1200G

Heat Input

(nett)

Nominal 8.8 kW 13.0 kW 18.0 kW 27.0 kW 36.0 kW 8.8 kW 13.0 kW 18.0 kW 27.0 kW 36.0 kW
Reduced 3.5 kW 4.2 kW 6.0 kW 9.0 kW 18.0 kW 3.7 kW 4.3 kW 6.4 kW 9.6 kW 12.8 kW

Gas Rate

(nett)

Nominal 0.93 m3/hr 1.38 m3/hr 1.90 m3/hr 2.86 m3/hr 3.81 m3/hr 0.68 kg/hr 1.01 kg/hr 1.40 kg/hr 2.10 kg/hr 2.80 kg/hr
Reduced 0.37 m3/hr 0.40 m3/hr 0.63 m3/hr 0.95 m3/hr 1.27 m3/hr 0.29 kg/hr 0.33 kg/hr 0.50 kg/hr 0.75 kg/hr 0.99 kg/hr

Supply Pressure

20 mbar 30 / 37 mbar

Burner Operating
Pressure (*)

10.6 mbar 10 mbar 25 mbar 26 mbar

Gas Connection

1

/2” BSP

Male

¾” BSP Male

1

/2” BSP

Male

¾” BSP Male

Natural Gas Town Gas (**)

CH8300G CH8450G CH8600G CH8900G CH1200G CH8300G CH8450G CH8600G CH8900G CH1200G

Input Rating (N.H.G.C.)

33.0 MJ/hr 48.0 MJ/hr 66.0 MJ/hr 100.0 MJ/hr 133 MJ/hr 33.0 MJ/hr 48.0 MJ/hr 66.0 MJ/hr 100.0 MJ/hr 133 MJ/hr

Supply Pressure

1.13 - 3.40 kPa 0.75 - 1.50kPa

Burner Operating
Pressure (*)

1.0 kPa 0.95 kPa 0.63kPa

Gas Connection

1

/2” BSP

Male

3

/

4

” BSP Male

1

/2” BSP

Male

3

/

4

” BSP Male

LP Gas (Propane) Butane

CH8300G CH8450G CH8600G CH8900G CH1200G CH8300G CH8450G CH8600G CH8900G CH1200G

Input Rating (N.H.G.C.)

33.0 MJ/hr 48.0 MJ/hr 66.0 MJ/hr 100.0 MJ/hr 133 MJ/hr 33.0 MJ/hr 48.0 MJ/hr 66.0 MJ/hr 100.0 MJ/hr 133 MJ/hr

Supply Pressure

2.75 - 4.50 kPa 2.75 - 4.50 kPa

Burner Operating
Pressure (*)

2.5 kPa 2.6 kPa 2.5 kPa 2.6 kPa

Gas Connection

1

/2” BSP

Male

3

/4” BSP Male

1

/2” BSP

Male

3

/4” BSP Male

5

Dimensions

CH

(L)

8120G-B

CH

(L)

8600G-B

CH

(L)

8900G-B

CH

(L)

8450G-B

CH

(L)

8300G-B

NOTE: The CH8300G are available in Bench Model (- B) Option Only.

6

Dimensions

CH

(L)

8600G-LS

CH

(L)

8450G-LS

7

Dimensions

CH

(L)

8900G-LS

CH

(L)

8120G-LS

R