Vulcan Hart VFRY18F General Manual
HEAVY DUTY COOKING
HEAVY DUTY GAS RANGE
VFRY18 F
SPECIFICATIONS
Heavy Duty range match fryers, Vulcan model No. ___VFRY18F
(Single Fryer with Filter). Fryers with solid state, behind the
door controls (120V/60/1), electronic pilot ignition. Four heat
exchanger tubes and burners per fryer. Hi-limit shut-off and
combination gas shut-off valve. Drain valve interlock switch.
Stainless steel front, font top ledge, sides, fry tank (12 year
tank warranty), base, and stub back. For lter units, lter
vessel constructed of 18 gauge stainless steel.
pump circulates frying compound at a rate of 8 gallons per
minute, activated by a solenoid push button switch. System
provided standard with paperless stainless steel mesh
lter screen. A complimentary package of KleenScreen PLUS
Fabric Envelopes is also included. Units are standard on 6"
1
legs. 1
⁄4" front gas manifold, and 3⁄4" rear gas connection,
capped. 120,000 BTU’s/hr. input. Requires 120 volt, 60 Hz, 1
phase power supply. (NEMA 5-15P)
1
⁄3 H.P. motor/
Item # C.S.I. Section 11420
RANGE MATCH FRYERS
VFRY18 F 18" Single Fryer with Filter
STANDARD FEATURES
Stainless steel front, front top ledge, sides, fry tank, base, ■
and stub back
1
1 ■
⁄4" Diameter front gas manifold
3
■
⁄4" Rear gas connection (capped)
120,000 BTU/hr. input ■
Four heat exchanger tubes per fryer ■
Solid State behind the door controls ■
Hi-limit shut off ■
Combination gas shut-off valve and pilot ignition system ■
Drain valve interlock switch ■
Electronic ignition (120 volt/60/1) (NEMA 5-15P) ■
Drawn 18 gauge stainless steel lter pan (for lter models) ■
Paperless stainless steel lter screen lters and micro ■
ltration fabric ltration envelope
Boil Out ByPass™ ■
6" adjustable stainless steel legs ■
1
■
⁄3 H.P. motor and pump for lter, at a rate of 8 gal/minute
One touch push button switch to engage pump and motor ■
One year limited parts and labor warranty & 5 year limited ■
fry tank warranty
Optional Features (Factory Installed)
Cap and cover front manifold
Stainless steel tank cover, doubles as work-top surface
Micro-Filtration Fabric Envelopes (6 lters per pack)
10" High Side Splash (removable)
Flanged Feet
Set of 4 casters, 6" high (two locking)
ACCESSORIES (Packaged & Sold Separately)
®
Extra set of twin Baskets
Single Bulk Baskets
Common condiment type, telescoping plate rails (starting
at 24" length)
10", 22", or 34" high back risers (no shelf )
22" single deck solid or flo-thru high shelf risers
34" double deck solid or flo-thru high shelf risers
Flexible gas hose with quick disconnect & restraining
device
a divisi on of IT W Food Equ ipme nt Group L LC
P.O. Box 696 ■ Louisville, KY 40201 ■ Toll-free: 1-800-814-2028 ■ Local: 502-778-2791 ■ Quote & Order Fax: 1-800-444-0602
F45307 (05/10)
INSTALLATION INSTRUCTIONS
18"
HEAVY DUTY COOKING
HEAVY DUTY GAS RANGE
RANGE MATCH FRYERS
A combination valve with pressure regulator is provided with 1.
this unit. Natural Gas: 4.0" (102mm) W.C. Propane Gas: 10.0"
(254mm) W.C.
An adequate ventilation system is required for commercial 2.
cooking equipment. Information may be obtained by writing
to the National Fire Protection Association, 1 Batterymarch
Park, Quincy, MA 02269. When writing refer to NFPA No.96.
These units are manufactured for installation in accordance 3.
with ANSZ223.1A (latest edition), National Fuel Gas Code.
Copies may be obtained from The American Gas Association,
400 N Capitol St., N.W., Washington, DC 20001, www.AGA.org.
For proper combustion, install equipment on adjustable legs or 4.
casters. On curb or platform, all 3
with leveling bolts are required for curb installation. Specify
when ordering.
1
⁄2" front overhang. Toe base
Clearances5. Rear Sides
Combustible 10" 10"
Noncombustible 0" 0"
Open Top Models 16" 16"
Cannot be batteried with GH series equipment.6.
This appliance is manufactured for commercial installation only 7.
and is not intended for home use.
NOTE: In line with its policy to continually improve its product,
Vulcan reserves the right to change materials and specication
without notice.
Specif y type of gas when ordering.
Specif y altitude when above 2,000 feet.
SHIPPI NG
MODEL
NUMBER DESCRIPTION
VFRY18 F
P.O. Box 696 ■ Louisville, KY 40201 ■ Toll-free: 1-800-814-2028 ■ Local: 502-778-2791 ■ Quote & Order Fax: 1-800-444-0602
F45307 (05/10)
18" Wide, Range Match, Heavy-Duty Fryer with Filter.
This appliance is manufactured for commercial use only and is not intended for home use.
a divisi on of IT W Food Equ ipme nt Group L LC
NOTE: In line w ith its p olicy to c ontinu ally improve its p roduc ts, Vulc an res erve s the right to chan ge materials a nd specications wi thout n otice.
TOTAL INPUT
BTU / HR
120,000 215 / 98
WEIGHT
LBS / KG
Loading...