Vulcan VSX5 Specifications
Item # __________________________
C.S.I. Section 11420
VSX5
ELECTRIC COUNTER CONVECTION STEAMER
STANDARD FEATURES
■ 304 series stainless steel exterior.
■ Stainless steel cooking compartment with coved interior
corners.
■ High output stainless steel steam generator.
■ Manual control with 60 minute timer.
■ Heavy duty "slammable" door.
■ Stainless steel drip trough integrally connected to the drain.
■ 208 or 240 volt, 60 Hz, 1 or 3 phase.
■ Split water line connection.
■ One year limited parts and labor warranty.
Vulcan-Hart Co.
ISO9001
A2780
Model VSX5 Shown
SPECIFICATIONS:
Single compartment electric convection steamer, Vulcan-Hart
Model No. VSX5, 5 pan capacity, 15 KW. 304 series stainless
steel exterior. Cooking compartment with coved interior corners.
High output stainless steel steam generator. Heavy duty
"slammable" door and door latch mechanisms. Stainless steel
drip trough integrally connected to the drain. Power connection
requires 208 or 240 volt, 60 Hz, 1 or 3 phase. Split water line
connection.
Exterior dimensions: VSX5 - 24"w x 27
NSF listed. U L listed. U L listed to Canadian safety standards.
1
/2"d x 215/8"h.
OPTIONS
■■ 480 volt, 60 Hz, 3 phase power supply, includes step down
transformer.
■■ 120 minute timer.
■■ Constant steam feature, not timed.
■■ Second year extended limited parts and labor warranty.
ACCESSORIES
■■ 4" legs.
■■ 12" x 20" stainless steel pans:
- 1" deep (solid) (perforated) Qty.____.
1
-2
/2" deep (solid) (perforated) Qty.____.
- 4" deep (solid) (perforated) Qty.____.
■■ Stainless steel pan cover. Qty.____.
■■ Removable sliding shelf. Qty.____.
■■ 28" open leg stand with pan slides 24"w x 28"h.
■■ 34" open leg stand with pan slides 24"w x 34"h.
■■ Set of two universal pan slides.
■■ Water treatment system.
MODEL: VSX5
Electric Counter Convection Steamer
F-32020 (8-04)
VULCAN-HART COMPANY, P.O. BOX 696, LOUISVILLE, KY 40201, TEL. 1-800-814-2028
502-778-2791 QUOTE & ORDER FAX: 1-800-444-0602
VSX5
ELECTRIC COUNTER CONVECTION STEAMER
SERVICE CONNECTIONS:
ELECTRIC CONNECTION: 1
connection to electrical box.
DRAIN: 1
solid connection. 24" length before open air gap opening
(no bends or elbows.)
COLD WATER - CONDENSING: 3/8" (10 mm) at 25-50
PSI.
COLD WATER - GENERATOR:
25-50 PSI (170 - 345 kPa).
1
/4" (32 mm) IPS piped to open floor drain. No
1
/8" (29 mm) conduit
3
/8" (10 mm) tubing at
WATER QUALITY STATEMENT:
The fact that a water supply is potable is no guarantee that it is suitable
for steam generation. Your water supply must be within these general
guidelines:
SUPPLY PRESSURE 20 - 60 psig
HARDNESS* less than 3 grains
SILICA less than 13 ppm
TOTAL CHLORIDE less than 4.0 ppm
pH RANGE 7-8
UN-DISSOLVED SOLIDS less than 5 microns
* 17.1 ppm = 1 grain of hardness
Other factors affecting steam generation are iron content, amount of
chloridation and dissolved gases. Water supplies vary from state to state
and from locations within a state. Therefore it is necessary that the local
water treatment specialist be consulted before the installation of any
steam generating equipment.
NOTE:
• Dimensions which locate the above connections have a tolerance of
+ or -3" (+ or -75 mm).
• Installation of backflow preventers, vacuum breakers and other specific code requirements is the responsibility of the owner and installer.
It is the responsibility of the owner and installer to comply with local
codes.
• Plastic drains are not recommended due to inherent limited temperatures of the plastic. Boiler purge temperatures may exceed 180°F. The
installer may be required to provide means to reduce boiler purge
water temperature to be that of the condensate temperature of 140°F
or less.
• This appliance is manufactured for commercial installation only and is
not intended for home use.
PAN CAPACITIES
MODEL 1" 21/2"4"6"
VSX5 10 5 3 2
NOTE: Max. door swing 17" (432)
SINGLE PHASE THREE PHASE
MODEL KW 208V 240V 208V 240V 480V
VSX5 15.0 Std. 72 63 42 36 18
NOTE: In line with its policy to continually improve its products, Vulcan-Hart Company reserves the right to change materials and
specifications without notice.
F-32020 (8-04)
VULCAN-HART COMPANY, P.O. BOX 696, LOUISVILLE, KY 40201, TEL. 1-800-814-2028
502-778-2791 QUOTE & ORDER FAX: 1-800-444-0602
Printed On Recycled Paper
Loading...