Vulcan VSX10EC User Manual

Item # __________________________

C.S.I. Section 11420

VSX7 & VSX10 SERIES

ELECTRIC CONVECTION STEAMER ON CABINET BASE

■■ VSX7EC 7 pan capacity

■■ VSX10EC 10 pan capacity

STANDARD FEATURES

■ 304 series stainless steel exterior.

■ Two stainless steel cooking compartments with coved

interior corners.

■ Two high output stainless steel steam generators.

■ Separate manual controls for each compartment.

■ Heavy duty "slammable" doors and door latch mechanisms.

■ Stainless steel cabinet base with door for storage.

■ 6" adjustable stainless steel legs with flanged rear feet.

■ Single point power connection requires 208 or 240 volt, 60 Hz,

3 phase power supply.

■ Split water line connection.

■ One year limited parts and labor warranty.

Vulcan-Hart Co.

ISO9001

A2780

MODEL: VSX7 & VSX10

SPECIFICATIONS:

Two compartment electric convection steamer on cabinet base,
Vulcan-Hart Model No. (VSX7E, 7 pan capacity, 17.5 KW)
(VSX10E, 10 pan capacity, 30 KW.) 304 series stainless steel
exterior. Two stainless steel cooking compartments with coved
interior corners. Two high output stainless steel steam genera­tors. Separate manual controls for each compartment. Heavy
duty "slammable" doors and door latch mechanisms. Stainless
steel cabinet base with door for storage. Single point power
connection requires 208 or 240 volt, 60 Hz, 3 phase power supply.
Split water line connection.

Exterior dimensions: 24"w x 33"d x (64") (69")h on 6" legs.
NSF listed. U L listed. U L listed to Canadian safety standards.

OPTIONS

■■ 480 volt, 50/60 Hz, 3 phase.

■■ Second year extended limited parts and labor warranty

contract.

ACCESSORIES

■■ 12" x 20" stainless steel pans:

- 1" deep (solid)(perforated) Qty.___.

1

/2" deep (solid)(perforated) Qty.___.

- 2

- 4" deep (solid)(perforated) Qty.___.

■■ Stainless steel pan cover. Qty.___.

■■ Removable sliding self. Qty.___.

■■ 12" x 20" pan guides for cabinet base.

■■ Water treatment system.

Electric Convection Steamer on Cabinet Base

F-32286 (8-04)

VULCAN-HART COMPANY, P.O. BOX 696, LOUISVILLE, KY 40201, TEL. [phone]

502-778-2791 QUOTE & ORDER FAX: [phone]

VSX7 & VSX10 SERIES

ELECTRIC CONVECTION STEAMER ON CABINET BASE

SERVICE CONNECTIONS:

ELECTRICAL CONNECTION: Single point supply 1
(29 mm) dia. (3/4" conduit).

DRAIN: 2 req'd. 1" male pipe thread no solid connection
to open floor drain.

COLD WATER - GENERATOR: 3/8" (10 mm) tubing at
25-50 PSI (170-345 kPa).

COLD WATER - CONDENSING:
25-50 PSI (170-345 kPa).

3

/8" (10 mm) tubing at

WATER QUALITY STATEMENT:

1

/8"

The fact that a water supply is potable is no guarantee that it is suitable for
steam generation. Your water supply must be within these general
guidelines:

SUPPLY PRESSURE 20 - 60 psig
HARDNESS* less than 3 grains
SILICA less than 13 ppm
TOTAL CHLORIDE less than 4.0 ppm
pH RANGE 7-8
UN-DISSOLVED SOLIDS less than 5 microns

* 17.1 ppm = 1 grain of hardness

Other factors affecting steam generation are iron content, amount of
chloridation and dissolved gases. Water supplies vary from state to state
and from locations within a state. Therefore it is necessary that the local
water treatment specialist be consulted before the installation of any steam
generating equipment.

NOTE:

• Dimensions which locate the above connections have a tolerance of
+ or -3" (+ or -75 mm).

• Installation of backflow preventers, vacuum breakers and other specific
code requirements is the responsibility of the owner and installer. It is the
responsibility of the owner and installer to comply with local codes.

• Plastic drains are not recommended due to inherent limited tempera­tures of the plastic. Boiler purge temperatures may exceed 180°F. The
installer may be required to provide means to reduce boiler purge water
temperature to be that of the condensate temperature of 140°F or less.

• This appliance is manufactured for commercial installation only and is not
intended for home use.

NOTE: Max. door swing 17" (432 mm).

208V 240V 480V

MODEL PH KW AMP KW AMP KW AMP

VSX7EC 3 17.5 49.0 17.5 42 17.5 21

VSX10EC 3 30 83.3 30 72.2 30 36.1

NOTE: In line with its policy to continually improve its products, Vulcan-Hart Company reserves the right to change materials and

specifications without notice.

F-32286 (8-04)

VULCAN-HART COMPANY, P.O. BOX 696, LOUISVILLE, KY 40201, TEL. [phone]

502-778-2791 QUOTE & ORDER FAX: [phone]

Printed On Recycled Paper