Page 1
GSM PHONE
SERVICE MANUAL
MODEL : SC100
1st version
(2004,02,27)
Page 2
Rev. 1.00
Page 3
I
Table Of Contents
1. Introduction ........................................................................................................ 1-1
2. Specification ....................................................................................................... 2-1
2.1 HW Features ................................................................................................................................................ 2-1
2.2 SW Features ................................................................................................................................................. 2-2
3. Disassembly Instruction ................................................................................................................. 3-1
3.1 Before Disassembly .................................................................................................................................... 3-1
3.2 Main Frame .................................................................................................................................................. 3-2
3.3 Folder ............................................................................................................................................................ 3-3
3.4 Exploded View and Parts List ....................................................................................................................3-5
3.4.1 Exploded View .....................................................................................................................................3-5
3.4.2 Mechanical Parts List...........................................................................................................................3-6
4. Data Kit & Download Procedure) .............................................................................................. 4-1
4.1 Data Kit ......................................................................................................................................................... 4-1
4.1.1 Download Equipment ....................................................................................................................... 4-1
4.1.2 Download Procedure ......................................................................................................................... 4-1
5. Troubleshooting ................................................................................................................................... 5-1
5.1 Power-On Trouble ....................................................................................................................................... 5-1
5.2 MIC Trouble ................................................................................................................................................. 5-2
5.3 Receiver Trouble .......................................................................................................................................... 5-3
5.4 Melody Trouble ........................................................................................................................................... 5-4
5.5 LCD Trouble ................................................................................................................................................ 5-5
5.6 Charge Trouble ............................................................................................................................................ 5-6
5.7 Vibrator Trouble .......................................................................................................................................... 5-7
5.8 Backlight Trouble ........................................................................................................................................ 5-8
5.9 SIM Detection Trouble ................................................................................................................................ 5-9
5.10 Ear Phone Trouble ................................................................................................................................... 5-10
5.11 7-LED Trouble ...........................................................................................................................................5-11
5.12 TX Power Trouble(E-GSM) .....................................................................................................................5-12
5.13 TX Power Trouble(DCS) ..........................................................................................................................5-14
5.14 RX Sensitivity Trouble(E-GSM) ............................................................................................................ 5-16
5.15 RX Sensitivity Trouble(DCS) ..................................................................................................................5-18
Page 4
II
Ta ble of Contets
6. Block Diagram ...................................................................................................................................... 6-1
6.1 BB Block Diagram ....................................................................................................................................... 6-1
6.2 RF Block Diagram ....................................................................................................................................... 6-2
7. Schematic Diagram ............................................................................................................................ 7-1
7.1 RF PAM ........................................................................................................................................................ 7-1
7.2 RF Main Chip .................................................................................................................................................. 7-2
7.3 Connectors ................................................................................................................................................... 7-3
7.4 Memory & Melody ..................................................................................................................................... 7-4
7.5 Main Chip(Ulysse/Omega) ....................................................................................................................... 7-5
7.6 Audio & SIM Connector ............................................................................................................................ 7-6
7.7 Key & Backlight ........................................................................................................................................... 7-7
7.8 LCD Module ................................................................................................................................................ 7-6
8. PCB Diagram ......................................................................................................................................... 8-1
8.1 Main PCB ..................................................................................................................................................... 8-1
9. Electrical Part List .............................................................................................................................. 9-1
8 .2 LCD Module ................................................................................................................................................. 8-2
9.1 Main Part ......................................................................................................................................................... 9-1
9.2 LCD Module ................................................................................................................................................... 9-2 1
9
Page 5
1. Introduction
SC100 is a folder type mobile phone operated in the GSM Digital Cellular Mobile Radio System, which is the
Pan-European mobile cellular standard. SC100 has the operation band of GSM 900 and DCS 1800. GSM Phase
II features are fully supported and parts of the GSM Phase II+ features are also supported. About the SIM
Toolkit, SC100 supports up to Class 3 including Class 1, 2. For speech communication, SC100 supports Full
Rate(FR), Enhanced Full Rate(EFR) and Half Rate(HR). For easy text, eZi Text is implemented and WAP
protocol is adopted for internet connection.
1-1
Page 6
1-2
Introduction
Memo
Page 7
2. Specification
2.1 HW Features
Item Description Remark
Supporting standard GSM 900/DCS 1800 Dual Band
E-GSM
Phase 2 and Phase 2+
SIM Toolkit : Class 1,2,3
Frequency range E-GSM TX : 880 - 915 MHz
E-GSM RX : 925 - 960 MHz
DCS 1800 TX : 1710 - 1785 MHz
DCS 1800 RX : 1805 - 1880 MHz
Battery Capacity
Standard : Li-ion, 720 mAh
Slim : Li-ion, 600 mAh
Display Full graphic type
Dual LCD
Main LCD(Dither 65K)
Pixels : 128 x 96
Ext. LCD(Black & White)
Pixels : 96 x 32
7 Color LED Indicator
Antenna Fixed type
PC synchronization Applied
Speech coding FR, EFR, HR
Data & Fax Built-in
Vibrator Built-in
Dual Speaker Applied (40 poly)
Portable Handsfree (Ear-Phone) Built-in
Travel charger Built-in
2-1
Page 8
2-2
Specification
2.2 SW Features
Function Detail Item Comments
Normal features Last dialed number 10 entry
Last received number 10 entry
Last missed number 10 entry
Dial memo 1
Call Call waiting Yes(network dependent)
Audio Earpiece volume 5 level
Mute on& Mute off Yes
Cell broadcast CB option On / Off
Read topics SIM / Phone
Languages Same as number of language
Supplementary services Call barring All calls
All outgoing calls
All outgoing international calls
All outgoing int. calls except to home country
All incoming calls
All incoming calls when roaming
Short Message Write message Send/Store
Output message Send/Save/Extract Number/
Delete/Delete All
Input message Reply/Forward/Extract number/
Delete/Delete All
Status report Delete/Delete All
Call voicemail
Cell broadcast CB Option(On/Off)/Read
Topics(SIM/Phone)/Languages
Page 9
2-3
Specification
Function Detail Item Comments
Memory status
Settings Status report/Message type
Expiry period/SMS center
Voice center/Alert
Multi-band Support of multi-band & mode GSM 900
EGSM
DCS1800
Miscellaneous function Development & test facility
Field test facility
Display software version
Text input Language English
Simplified chinese
Traditional chinese
eZi text Predictive word input
Scheduler View
Make Schedule
Call
Memo
Anniversary
Delete
View all Delete All Go Today
WAP WAP
World time Setting local time
Number of selectable cities 61 Cities
Page 10
2-4
Specification
Function Detail Item Comments
PhoneBook Search All
Number Search
Name Search
Add New Entry
management
Game 2EA Eggaman
Honey
(
(
Page 11
3. Disassembly Instruction
3.1 Before Disassembly
② Remove the SIM card as shown.
3-1
①
②
2. Remove the SIM card. To do so:
① Slide the metal lock in the direction of arrow.
1. Remove the battery. To do so:
① Pull the battery lock above the battery toward the
top of the phone and hold it in the position.
② Lift the battery away.
Page 12
3-2
Disassembly Instruction
3.2 Main Frame
1. Remove the three screws on the back of the phone.
2. Insert a small ‘ - ‘ type driver between the front case
and the rear case, and lift up the front case.
Front case
Rear case
Main PCB
Key Pad
3. Now, you can replace the PCBs and the other
components.
Page 13
3-3
Disassembly Instruction
1. Remove the rear case as described at Steps 1 and 2
under Main Frame Disassembly on page 3-2.
2. Unplug the connector shown at right from the main
PCB.
3. Unhook the folder from the main frame.
3.3 Folder
4. Remove the three screws from the folder.
Connector
Main PCB
Page 14
3-4
Disassembly Instruction
6. Now, you can remove the LCD ass’y and the other
components.
LCD ass’y
5. Insert a small ‘ - ‘ type driver between the folder
upper and the folder lower, and lift up the folder
upper.
Folder upper
Folder lower
Page 15
3.4. Exploded View and Parts List
3.4.1 Exploded View
3-5
3-6
Page 16
Exploded View and Parts List
NO. DESCRIPTION Q’TY
1BATTERY 1
2 KNOB SLIDE 1
3 SPRING 1
4 CASE REAR 1
5RURRER EAR MIC 1
6 ANTENNA 1
7 BRACKET ANTENNA 1
8RUBBER R/F 1
9 LOCKER SIM 1
10 SCREW 4
11 PCB MAIN ASS’Y 1
12 RUBBER I/O 1
13 KEY PAD 1
14 SIDE KEY 1
15 RUBBER MIC 1
16 CASE FRONT 1
17 SCREW 3
18 WINDOW MAIN 1
19 DECO WINDOW 1
20 INDICATOR-R 1
21 WINDOW SUB 1
22 BEZEL 1
23 FOLDER UPPER 1
24 PCB FOLDER ASS’Y 1
25 HINGE 1
26 FOLDER LOWER 1
3.4.2 Mechanical Parts List
Page 17
4. Data Kit & Download Procedure
4.1 Data Kit
4.1.1 Download Equipment
1. Download Cable
2. Desktop or Notebook PC
3. Download monitor program
4. SC100 mobile phone
4.1.2 Download Procedure
DOWNLOAD ENVIRONMENT
To download software of SC100, the following working environments should be
prepared:
• SC100 download cable, Interface JIG, is connected to only COM1 serial port of the desktop or notebook PC.
• SC100 download monitor program is copied to the desktop PC or notebook PC.
• Target software is downloaded to the SC100 mobile phone.
Warning
You MUST use the download cable kit (Interface JIG) and UART download monitor program. Otherwise,
downloading process won’t work properly.
4-1
Page 18
4-2
DOWNLOAD PROCEDURE
1. Unzip SC100 UART Download monitor program (monitor662.zip) in the PC.
2. Execute monitor662.exe. And then select Target menu. Then, choose Connect from the Target menu.
3. A table will be displayed as shown in <Figure 2>. Then press the arrow-button and choose a correct serial
port. And press OK button.
Data Kit &Download Procedure
<Figure 1>
<Figure 2>
Page 19
4-3
Data Kit & Download Procedure
4. As the following window shown in <Figure 3> is displayed, connect SC100 phone to the download cable,
(Interface JIG) and press power on key of SC100. If the connection is succeeded, the following screen will
show the contents as shown in <Figure 4>.
<Figure 3>
<Figure 4>
Page 20
4-4
Data Kit & Download Procedure
5. Click on Flash on the top menu and select Erase and Program Appli only item as shown in <Figure 5>.
6. Choose the target SW that you want to download. And then you can see the following window in
<Fingure 6>.
<Figure 5>
<Figure 6>
Page 21
7. If the downloading procedure is succeeded, then the following window is shown.
8. Press the Disconnect of Target menu, and seperate the phone from Download cable.
4-5
Data Kit & Download Procedure
<Figure 7>
<Figure 8>
Page 22
5-1
Troubleshooting
5. Troubleshooting
5.1 Power-on Trouble
Check the voltage level of battery.
Power-on button is not working.
YES
Check the level of TP515
(ON/OFF).
YES
Then the phone is powered-on
properly. Check the LCD module.
The level of battery
voltage is higher
than 3.4V
The level of TP515 as
high as 3V.
Check the battery
Charge the battery.
Power-on sequence is not
executed properly. Try again.
If the result is same, change
U501 chipset.
END
NO
NO
Page 23
5.2 MIC Trouble
5-2
Troubleshooting
YES
Check the signal level at the
U612 Pin 5,6
after putting audio signal in MIC.
YES
Check the MIC.
The voltage is 2.4V?
MIC is not working.
Connect the Phone to
Wireless Communication Test Set
(8960 or CMU 200).
Check the R612 voltage.
A few hundreds
mV of AC signal levels
are measured?
Check the connectivity
of R610 and R612.
Replace U612 which does not
have proper level.
END
NO
NO
Page 24
5.3 Receiver Trouble
5-3
Troubleshooting
YES
Check the receiver.
Replace U603,U604
which does not have
proper level.
A few hundreds
mV of AC signal levels
are measured?
NO
YES
Check the signal level at the U603,
U604 pin 5,6 after
putting audio signal.
Receiver is not working.
Connect the Phone to
Wireless Communication Test Set.
Check the signal level
at the EAR 600 Pin 2,3 after
putting audio signal in MIC.
A few hundreds
mV of AC signal levels
are measured?
Replace U501.
END
NO
Page 25
5.4 Melody Trouble
5-4
Troubleshooting
YES
The connection
is OK?
Melody is not heard.
END
Check the connectivity
of Speaker.
YES
Check whether the
melody signal is out from
Pin 17, 18 of U402?
Connect the Speaker to
the phone properly.
NO
Check the signal level of
SPK+ and SPK-
while the melody
is being played.
Check the level of C416.
Level is VBAT.
Replace U402.
NO
Page 26
5.5 LCD Trouble
5-5
Troubleshooting
LCD module is connected
propery to the LCD connector
on the PCB?
LCD connector is
well soldered onto
PCB?
The LCD driver
source voltage is about 2.8V
(U622:PIN5)?
YES
LCD display is not working.
Replace LCD module.
Reassemble LCD module
with LCD connector.
NO
Re-solder the LCD connector.
NO
YES
Replace U622.
END
YES
NO
Page 27
5.6 Charge Trouble
5-6
Troubleshooting
YES
NO
YES
YES
YES
YES
The battery
pack is well contacted to
the phone?
The battery
voltage is between
3.4V~4.2V?
TA voltage is
equal to 5.2V/
600mA?
Q600(Pin1~Pin2)
voltage is between
0.65~0.9V?
D601
voltage is lower
than 0.3V?
R605
voltage is lower
than 0.12V?
Reassemble
bettery pack.
Re-download S/W.
Replace Q600.
NO
Replace D601.
NO
Replace R 605.
Case 1 Case 2
NO
Replace the
bettery pack.
NO
Replace
the defective TA.
NO
SATRT
END
YES
CON301 is
well connected
to PCB?
NO
Re-mount CON301.
Charging is
not working.
Page 28
5.7 Vibrator Trouble
Note: To enter the Test mode, press 0718 #
on the phone, then hold down * key.
5-7
Troubleshooting
U8(Pin3) at LCD module
voltage level is higher
than Approx: 3V?
CN602 pin 3 voltage
level is higher
than 2.8V?
Re-soldering pin 3.
START
In the Test mode, select
'Function Test' then
select 'Vibrator Test'.
Check/Replace
Vibrator.
Replace U8.
END
YES
NO
YES
NO
Page 29
5.8 Backlight Trouble
5-8
Troubleshooting
Note: To enter the Test mode, press 0718 # on the phone,
then hold down * key.
In the Test mode,
select 'Baseband Test'
then 'LED Test' then
'Backlight ON/OFF'.
SATRT
NO
YES
YES
YES YES
Re-solder U3,U4,U6.
NO
NONO
NO
NO
NO
NO
NO
Re-mount R711 or
R716.
Re-mount
R2/4.
Re-mount
R6/7.
Re-mount
R15/16.
Replace Q701
Q702.
Replace battery.
YES
YES
YES
YES
YES
R711 or R716 is
well connected?
Voltage level
of Q701/702 pin 5 is higher
than Approx:2.5V?
Voltage value
of LED Pin1 is same
as the voltage value
of battery?
Replace
D700~D707
Replace
the LCD module.
Voltage level
of C19 Pin 1 is
6.5V?
L1,D5,D6 are
well connected?
Replace U5.
Check the 2 point LEDs
in the Lightguide.
Re-solder
L1,D5,D6.
R2/4 is well
connected?
R6/7 is well
connected?
R15/16 is well
connected?
Defected key
backlight.
Defected LCD
7 LED backlight.
U3,U4,U6
(PIN2) voltages level are
higher than
normal vaule?
END
END
at LCD Module
END
at LCD Module
Page 30
5.9 SIM Detection Trouble
5-9
Troubleshooting
Check the voltage of CN 600.
(Pin 1,7)
SIM Detection is not working.
YES
Check the voltage level of
CN600(Pin3) when power is ON.
YES
Check the SIM.
Level is 3V or 5V?
Level is 3V or 5V?
Replace U501.
Replace U501.
END
NO
NO
Page 31
5.10 Ear Phone Trouble
5-10
Troubleshooting
Replace U501.
Check each Resistance value of
F600,F601,F603 and F604.
Ear Phone is not working.
YES
Connect the phone to
Wireless communication Test set.
Check the Ear phone.
Each Ressisitance value
is Below 3Ω?
Replace that.
END
NO
Page 32
5.11 7-LED Trouble
5-11
Troubleshooting
7-LED is not working.
YES
Check the voltage level.
Pin2 or Pin 5 of U3 (Orange), U4 (Green)
U6 (Blue).
YES
Replace 7-LED.
Green On : R5 voltage is 2.8V?
Orange On : R1 voltage is 2.8V?
Blue On : R11 voltage is 2.8V?
The level is higher
than 0.7V?
Replace U500 when the solder
state of R5 (Green)
R1 (Orange)
R11(Blue) is ok.
Re-solder R3,R8,R17.
Replace U3,U4,U6.
END
NO
NO
Page 33
5.12 TX Power Trouble (E-GSM)
5-12
Troubleshooting
Check
RF2 VCO
U206 pin 23,24
frequency & power.
Frequency = 1301.4 MHz?
Power -25dBm?
Check :
• U206 soldering.
• U206 pin 5,25,28 = DC 2.85V
Replace U206 if defective.
YES
START
NO
YES
YES
NO
NO
NO
Check
VC-TCXO
U204 pin 3.
Frequency= 13.00MHz?
Power -15dBm?
Set
• Phone : Test mode
62CH, 7level setting (TCH)
62CH, -60dBm setting (BCCH)
• Spectrum analyzer as shown in Remarks.
• Oscilloscope as shown in Remark.
Check :
• U204 soldering.
• U204 pin 3 DC 1.4V + - 0.1V
• U204 pin 4 DC 2.85V + - 5%
Replace U204 if defective.
Check :
• U202 soldering.
• Ulysse-Nausica.
• S/W.
Check :
• U206 soldering
• U206 pin 5,25,28 = DC 2.85V
Replace U206 if defective.
Check RF Main Chip
U202 pin 5,6,7,8
I/Q signal DC 1.35V & 0.5Vp-p?
Check
IF VCO
U206 pin 26,27
frequency & power.
Frequency =798MHz?
Power -25dBm?
=
>
=
>
=
>
=
>
Go to A
Remarks
1. Spectrum analyzer : SPAN = 1MHz
VBW = 1MHz
RBW = 3MHz
Press the trace button of spectrum analyzer on checking test
point and press the max hold of spectrum analyzer
2. Oscilloscope : 500mV/div, 2ms/div
Page 34
5-13
Troubleshooting
YES
YES
NO
YES
YES
NO
NO
Check
TX VCO U202 pin 25
frequency & power.
Frequency = 902.4 MHz?
Power -8dBm?
Check :
• RF connector Ant101 soldering.
• Matching network C121, L100 soldering.
Check :
• U202 soldering
• U202 pin 14,23,26,32 = DC 2.85V
Replace U202 if defective.
Check :
• U101 soldering
• U101 pin 4 VBAT DC voltage (>3.3V)
• U101 pin 3 PA_ON high voltage
• U101 pin 2 BSW low voltage
• U101 pin 6 PA_LEVEL signal
• U101 pin 7 902.4MHz freq & power check
Replace U101 if defective.
Check :
• U110 soldering
• U110 pin 2 low voltage
• U110 pin 11 high voltage
Replace U110 if defective.
Check
Power Amp U101 pin 9(C106)
frequency & power.
Frequency = 902.4MHz?
Power 15dBm?
Check
ANT switch U110 pin 8
frequency & power.
Frequency = 902.4MHz?
Power 13dBm?
END
=
>
=
>
=
>
A
Page 35
5.13 TX Power Trouble (DCS)
5-14
Troubleshooting
YES
NO
YES
NO
NO
Check
VC-TCXO
U204 pin 3 .
Frequency = 13.00 MHz?
Power -15dBm?
Set
• Phone : Test mode
700CH, 2level (TCH)
700CH, -60dBm (BCCH)
•Spectrum analyzser as shown in Remarks.
•Oscilloscope as shown in Remarks.
Check :
• U204 soldering
• U204 pin 4 = DC 2.85V + - 5%
• U204 pin 3 = DC 1.4V + - 0.1V
Replace U204 if defective.
Check :
• U202 soldering
• Ulysse-Nausica
• S/W
Check :
• U206 soldering
• U206 pin 5,25,28 = DC 2.85 V
Replace U206 if defective.
Check RF Main Chip
U202 pin 5,6,7,8
I/Q signal DC 1.35V & 0.5Vp-p?
Check
IF VCO U206 pin 26,27
frequency & power.
Freuency = 766MHz?
Power -26dBm?
YES
NO
Check :
• U206 soldering
• U206 pin 5,25,28 = DC 2.85V
Replace U206 if defective.
Check
RF 2 VCO U206 pin 23,24
frequency & power.
Frequency = 1364.8 MHz?
Power -26dBm?
=
>
=
>
=
>
=
>
START
Go to B
Remarks
1. Spectrum analyzer : SPAN = 1MHz
VBW = 1MHz
RBW = 3MHz
Press the trace button of spectrum analyzer on checking test
point and press the max hold of spectrum analyzer
2. Oscilloscope : 500mV/div, 2ms/div
Page 36
5-15
Troubleshooting
YES
YES
END
NO
YES
NO
NO
Check
TX VCO U202 pin 24
frequency & power.
Frequency = 1747.8 MHz?
Power -12dBm?
Check :
• U202 soldering
• U202 pin 14,23,26,32 = DC 2.85V
Replace U202 if defective.
Check :
• U101 soldering
• U101 pin 4 VBAT = DC voltage ( > 3.3V)
• U101 pin 3 PA_ON = high voltage
• U101 pin 2 BSW = high voltage
• U101 pin 6 PA_LEVEL signal
• U101 pin 7 1747.8 MHz freq & power check
Replace U101 if defective.
Check :
• U110 soldering
• U110 pin 2 = high voltage
• U110 pin 11 = low voltage
Replace U110 if defective.
Check
Power Amp U101 pin11(C122)
frequency & power.
Frequency = 1747.8 MHz?
Power 11dBm?
Check
ANT switch U110 pin 8
frequency & power.
Frequency = 1747.8 MHz?
Power 9dBm?
YES
YES
Check :
• RF connector ANT101 soldering.
• Matching network C121, L100 soldering.
=
>
=
>
=
>
B
Page 37
5.14 RX Sensitivity Trouble (E-GSM)
5-16
Troubleshooting
YES
START
NO
YES
NO
NO
Check
RF connector ANT101 pin 2
frequency & power.
Frequency = 947.4 MHz?
Power -72dBm?
Set
• Phone : Test mode
62CH, 7level (TCH)
62CH, -60dBm (BCCH)
•Spectrum analyzer as shown in Remarks.
•Oscilloscope as shown in Remarks.
Check ANT101 soldering and short.
Replace ANT101 if defective.
Check :
• U110 soldering
• U110 pin 2 = Low voltage
• U110 pin 11 = Low voltage
Replace U110 if defective.
Check U201 soldering.
Replace U201 if defective.
Check
ANT switch U110 pin 10
frequency & power.
Frequency =947.4MHz?
Power -72dBm?
Check
RF 1'st SAW Filter U201 pin3,4
frequency & power.
Frequency = 947.4MHz?
Power -77dBm?
YES
NO
Check U206 soldering.
Replace U206 if defective.
Check
RFLO VCO U206 pin23,24
frequency & power.
Freuency =1894.6MHz?
Power -40dBm?
=
>
=
>
=
>
=
>
Go to C
Remarks
1. Spectrum analyzer : SPAN = 1MHz
VBW = 1MHz
RBW = 3MHz
Press the trace button of spectrum analyzer on checking test
point and press the max hold of spectrum analyzer
2. Oscilloscope : 500mV/div, 2ms/div
Page 38
5-17
Troubleshooting
END
YES
NO
Check :
• U200 soldering
• Ulysse-Nausica
• S/W
• VC-TCXO U204 pin3 output path
YES
.
.
Check
RF Main Chip
U200 pin 2,3,4,5
I/Q signal DC 1.35V & 0.5
Vp-p?
U200 Pin 7 Freguency=13.00MHz?
Power -15dBm?
>
=
>
=
C
Page 39
5.15 RX Sensitivity Trouble (DCS)
5-18
Troubleshooting
START
Go to D
YES
YES
NO
NO
Set
• Phone : Test mode
700CH, 2 level (TCH)
700CH, -60dBm setting (BCCH)
• Spectrum analyzer as shown in Remarks.
• Oscilloscope as shown in Remarks.
Check ANT101 soldering and short.
Replace ANT101 if defective.
Check :
• U110 soldering
• U110 pin 2 = Low voltage
• U110 pin 11 = Low voltage
Replace U110 if defective.
Check
RF connector ANT101 pin 2
frequency & power
Frequency = 1842.8 MHz?
Power -76
dBm?
Check
ANT Switch U110 pin 1
frequency & power.
Frequency = 1842.8MHz?
Power -76dBm?
YES
NO
Check U203 soldering.
Replace U203 if defective.
Check
RF 1'st SAW Filter U203 pin 4,6
frequency & power.
Frequency = 1842.8 MHz?
Power -79dBm?
YES
NO
Check U206 soldering
Replace U206 if defective.
Check
RFLO VCO U206 pin 23,24
frequency & power.
Frequency = 1842.7 MHz?
Power -30dBm?
=
>
=
>
=
>
=
>
Remarks
1. Spectrum analyzer : SPAN = 1MHz
VBW = 1MHz
RBW = 3MHz
Press the trace button of spectrum analyzer on checking test
point and press the max hold of spectrum analyzer
2. Oscilloscope : 500mV/div, 2ms/div
3. RF Cable Loss : about 10dB
Page 40
5-19
Troubleshooting
END
YES
NO
Check :
• U200 pin soldering
• Ulysse-Nausica
• S/W
• VC-TCXO U204 pin 3 output path
Check
RF Main Chip
U200 pin 2,3,4,5
I/Q signal DC 1.35V & 0.5Vp-p?
U200 pin 7 Freguency 13.00 MHz
Power -15dBm?
=
>
.
.
>
=
D
Page 41
Troubleshooting
Memo
5-20
Page 42
6. Block Diagram
6.1 BB Block Diagram
128xRGBx96(4096)
DITER 65K COLOR
VIBRATOR
DATA
(16bit)
POWER TIP
1.37 inch
STN LCD
MAIN LCD
Indicator LED
MCP( Flash+SRAM)
PICVUE
0.8 inch
96 X32
MONO
LCD
SUB LCD
DC-DC
CONVERTOR
(64M+32M)
Key Button
L∧R
S
<
>
∧
S
∨
∨
1 2 3
4 5 6
7 8 9
* 0 #
MELODY RST
MELODY LED
EAR HOOK
KEY LED
REED
JACK DET
7 COLOR LED
18-Pin I/O Connector
- JTAG : 4 Pin
- UART1 : 2 Pin
- UART2 : 5 Pin
- GND : 1Pin
CS/
A1
Reset
Data[0:7]
I/O
Addr[01:22]
Data[00:15]
CS/
KBC 5
KBR 5
I/O 6
3
11
From TCXO in
RF Part
MCLK
13MHz
Interface
LCD
Memory Interface Key Matrix
GPIO
Interface
MCSI
URAT & Serial
Interface
VR1
Herc core
Internal SRAM
RTC
XO32KHz
32.768KHz
RTC
(32KHz)
Internal
SRAM(1Mbit)
Data[15:00]
Add[14:00]
Rnw, EZ, CLK
Memory Interface
ARM7 CORE
Glue Interface
SP
80k RAM
Program/data
CPU Core
PLL+Timer
VR2
CLK13MHz OUT
I/O Memory
interface
Power Supply
ULYSSE
OMERGA Interrupt
ARM Serial Port(SPI)
JTAG PORT
TIME Serial Port
Data[31:16]
XIO
IRQ
API
CLK TCXO 13MHz
DSP(LEAD2)
VR2B
I/O to OMEGA
I/O to 3V periph
Base band Serial Port
Voiceband Serial Port
SIM Interface
3
4
2
2
2
VDX
VDR
VFSRX
VCLKRX
3
VR1(1.8Vx120mA)
VR2(2.85Vx120mA)
VR2B(2.85Vx50mA)
VR1B(2.0Vx50mA)
OMEGA Digital
VR3(2.85Vx80mA)
OMEGA Analog
ON/OFF Button
••
ON/OFF Interrupt
Control
MCU Serial Port
JTAG & Debug
Time Serial Port
From TSP
Burst
Buffer1
Burst
Buffer2
From BSP
CKUSP,CKIBIC,CKBSP,CKTSP(13MHz)
CKBDL(13MHz), CKBUL ( 4.3MHz)
CKMADC,CKAP C( 13 MH z), CKAFC(4.3MHz)
CKSIM(SCLK3 externel clock)
Timing
Control
GMSK
Modulator
270KHz
Baseband Codec Uplink Block
to BSP
+
+
-
Vol.
Con.
Fs3=8KHz
Voiceband Codec
SRST3
oscas
SCLK3
simsel
SIO3
Offset
Reg.
Offset
Reg.
PGA
Fs3=8KHz
0dB, +12dB, -12dB : STEP 1dB4
Downlink Block
FIR
Flter
Fs=270.8KHz Fs=1.08MHz Fs=6.5MHz
FIR
Flter
Sin
IIR
Filter
Filter
Fs2=40KHz
Side Tone
Fs1=1MHz
DL
Vol.
Con.
Filter
Fs2=40KHz Fs1=1MHz
SIM Card Shift
VRPC_STAT
RSTZ
ON_OFF
RESPWRONZ
VRx,VREF,
IREF,UVLO
OP,IPTAT
Debounce
VR2B VR2 VR1B VR3
VR2BBUVR2BUVR1
WDT
UPR
Voltage Regulation & Battery Management
OMERGA
CKVBC(13MHz)
CKCP(406KHz)
CKVREG(13MHz)
Cos
Table
Sine
Table
Sigma-Delta
SINC
Filter
SINC
Sigma-Delta
Filter
ADC
2.5dB
Digital
Mod.
VR1
BU
CLK13M
6-Bit
DAC
10-Bit
DAC
16 × 270KHz
10-Bit
DAC
6-Bit
DAC
Modulator
Modulator
DAC
& Filter
SRST5
SCLK5
SIO5
Controlled by
BUMODE
Serial interfaces
Bus controller
Base band codec
Auxiliary function
Voice codec
Charge pump clock
Sim card clock
Vreg clock
Offset
Reg.
Low-pass
Filter
Low-pass
Filter
Offset
Reg.
Anti-aliasing
Anti-aliasing
4.6dB
28.2dB
25.6dB
REG
VBB
BB-Switch
From TCXO in
RF Part
(ADCs)
Bias
gener
-5dB
1dB
VAUX
3V/5V
REG
Charge
Pump
DC-DC
CONVERTOR
VMB
MISC. I/O INPUT
Batt_ID
LCD_Temp
PRECHARGE
AFC
APC
BULIP
BULIN
BULQP
BULQN
Tx
Rx
BDLIP
BDLIN
BDLQP
BDLQN
4
VBAT
BATTERY PACK
To Ulysse &
RF CHIPSET
CONTROL
MIC
SIM CARD
RF INTERFACE
JACK
RECEIVER
Backup Battery
Batt_ID
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
SPEAKER
Omerga MCLK(13MHz)
JACK_DETECT & EAR HOOK
EARPHONE
(Li-Ion, 3.3V/1mAh)
GND
RF_ENA
AFC
APC(PA_LEVEL)
CLK
DATA
PA_ON
SYN_EN
PDB
BSW
BULIP
BULIN
BULQP
BULQN
BDLIP
BDLIN
BDLQP
BDLQN
Page 43
6.2 RF Block Diagram
<AERO Transceiver(Si4200+Si4201+Si4133T)>
EGSM/DCS Antenna S/W
RX
DIP
LMG002S-5047A
SW
SW
TX
RX
TX
LPF
LPF
B7706
EGSM SAW Filter
DCS SAW Filter
LF90A
VBAT
RF2V85
Si4200
LNA
LNA
Power Amp Module
π /2
PA_LEVEL(OMEGA)
PA_ON(ULYSSE)
BSW (ULYSSE)
Low-IF Receiver
Si4200
Si4200
Si4200
PGA
PGA
RF2V85
ADC
ADC
Universal Baseband Interface
Si4201
100kHz
RF2V85
Dual RF Synthesizer
Si4133T
RF
PLL
Φ
DET
CHANNEL
IF
PLL
FILTER
PGA
PGA
RF2V85
DAC
DAC
VCTCXO
TTS17V
BULIP (OMEGA)
I
BULIN (OMEGA)
BULQP (OMEGA)
Q
BULQN (OMEGA)
13 MHz (ULYSSE)
PLL_CLK (ULYSSE)
PLL_DATA (ULYSSE)
PLL_SYN_EN (ULYSSE)
AFC (OMEGA)
BDLIP (OMEGA)
I
BDLIN (OMEGA)
BDLQP (OMEGA)
Q
BDLQN (OMEGA)
BASEBAND
VBAT
RF_ENA
LDO
LDO
MIC5245
RF2V85
RF3110
Offset –PLL Transmitter
Si4200
RF2V85
BSW (ULYSSE)
PA_ON (ULYSSE)
PBD (ULYSSE)
PA_LEVEL(OMEGA)
RF_ENA(ULYSSE)
Page 44
47k
10k
47k
10k
47k
10k
47k
10k
8
RF PAM
10
Size:
10
4
15
13
D
5
TITLE:
L
D
K
9
G
6
5
I
HLL
I
A
E
J
Date Changed:
15
SC100
11
Changed by:
B
Page:
GSM_TX
7
E
8
Time Changed:
GSM,DCS_RX
11 14
F
7
Engineer:
H
L
16
DOC CTRL CHK:
9
REV:
H
L
14
Drawn by:
2003.11.05
K
13
VC116VC2
21
L
12
H
J
F
G
A
1 of 7
1.0
A3
DCS_TX
1
12
R&D CHK:
3
3
C
2
B
6
C
4
Drawing Number:
C106
47p
C102
10n
C109
ANT1
ANT_BW
C108
22p
C113
27p
C107
22p
VBAT
RF2V85
RF2V85
N.C
56
R101
C114
47p
33p
C103
UMD9N
U108
1
2
3 4
5
6
47p
C104
430
R105
R112
10K
ANT101
3
G1G2
4
IN
1
2
OUT
10n
C117
2.7p
C122
10K
R119
4
5
6
Q101
DTC114YE
GND
IN
OUT
RF2V85
220u/6.3V
C101
U105
UMD9N
1
2
3
R104
430
C112
47p
C123
G7
G817G9
13
7
GSM_IN
GSM_OUT
9
8
GVCC
TX_EN
3
VBATT
4
6
VRAMP
VREG
5
Vccout
10
10nF
1
11
DCS_OUT
12
DVCC
G1
23
G1014G11
18
25
G12
24
G13
G14
19
15
G15
28
G1627G2
22
G3
21
G4
G516G6
26
20
150p
RF3110
U101
2
BAND
DCS_IN
NC
C126
R113
10K
C130
L110
2.7N
180pF
C125
U110
ANT
8
DCS_RX
1
3
DCS_TX
4G16G27G39
G4
G5
12
10
GSM_RX
5
GSM_TX
2
VC1
VC2
11
C121
5.6nH
LMG002S-5047A
C100
2.2u
(1608)
12
R106
11K
R103
56n
L103
RX_1800
RF2V85
L100
5.6pF
GSM_OUT
BSW
DCS_OUT
PA_ON
PA_LEVEL
RX_900
7.1 RF PAM
Page 45
K
H
6
167
L
I
5
Date Changed:
15
Time Changed:
1
G
Size:
12
C
11
Date:
Drawn by:
16
Approved by:
C
F95/P
9
SC100
10
2003.11.05
10
H
B
14
G
RF1-STRIPLINE
2
RF MAIN IC
14
I
J
TITLE:
11
E
D
1
F
12
Sheet:Drawing Number:
F
K
5
Engineer:
13
RF2-STRIPLINE
13
REV:
6
J
7
2 of 7
1.0
A3
A
3
4 83
158
2
E
4
B
A
9
D
L
Changed by:
C200
22n
10u/6.3V
C222
R202
10K
RF2V85
RF2V85
C214
100n
10n
C207
RF2V85
100p
C209
L200
1pC204
C212
27n
10K
R201
1.5p
TTS17V
U204
1
CTL
2
GND3OUT
4
VCC
C213
10n
2KR721
U205
MIC5245
Cbyp4EN
3
G
2
Vin
1
Vout
5
1.5pC210
C216
100p
RF2V85
3.9n
L202
RF2V85
L201
7.5n
(COILCRAFT)
SENB
5
VDDD
28
VDDI
VDDR
25
XIN
7
1pC206
21
GND9
22
3
IFLA
IFLB
2
26
IFLON
IFLOP
27
9
PDNB
20
RFLA
RFLB
19
RFLC
17
RFLD
16
23
RFLON
24
RFLOP
12
SCLK13SDI10SDO
11
6
OUT+
4
OUT-
SI4133T
U206
1
GND1
GND2
4
6
GND3
8
GND414GND5
15
GND6
18
GND7
GND8
SCLK
17
18
SDI
SDO
15
16
SENB
VDCC
6
20
VDDA
XEN
13
7
XIN XOUT
19
LF90A
U203
1
G1
G23G3
5
2
IN
SI4201
U200
10
CKN9CKP
GND
8
1
GND1
12
ION
IOP
11
14
PDNB
5
RXIN
RXIP
4
3
RXQN
RXQP
2
22n
C701
R722
1K
RF2V85
100
R203
C250
220p
VDD1
14
VDD2
32
VDD3
VDD4
26
RF2V85
NC2
PDNB
31
RFIDN
20
RFIDP
19
RFIGN
22
21
RFIGP
18
RFIPN
RFIPP
17
13
RFLON12RFLOP
RFOD
24
25
RFOG
6
TXIN
5
TXIP
8
TXQN
TXQP
7
23
SI4200
U202
3
CKN
CKP
4
16
DIAG1
DIAG2
15
11
GND1
30
GND227GND3
10
IFLON9IFLOP
1
ION
IOP
2
NC1
29
28
C205
100p
RF2V85
RF2V85
C219
22n
C208
RF2V85
22n
22n
C218
G1
2 5
G2
IN
1
OUT+
3
OUT-
4
10n
C221C220
10n
U201
B7706
PDB
RX_1800
RX_900
13MHZ
RF_ENA
SYN_EN
CLK
AFC
CLK
GSM_OUT
DATA
DCS_OUT
TXIN
TXQN
DATA
SYN_EN
TXQP
TXIP
RXQP
RXIP
VBAT
RF2V85
RXIN
RXQN
7.2 RF Main Chip
Page 46
19
J
1
Time Changed:
10
16
H
2 11
- IO Connector -
21
13
G
F
3
E
146
A A
I
1 16
Date Changed:
B
G
12
K
2003.11.05
J
Approved by:
B
6 74
4 5
L
TITLE:
2
C
D
Date:
12
C
7 8
K
I
5
15
CONNECTOR
D
11
Drawing Number:
H
Sheet:
8
Drawn by:
13
22
L
3 9
2
1.0 3 of 7
A3
x 7 EA
E
14 15
Engineer:
SC100
9
F
10
REV:
Size:
Changed by:
20
V308
1234567
8
V301
1
R303
10
V302
1
2
10
R307
R305
1K
V300
1
2
R302
10
R355
VR2B
AVLC5S02050(50PF)
100
27pC308
27pC307
V306
121
2
R304
10
R357
VR3
V305
100
100
R351
R356
100
100
LED_EN
29
26
LED_G
LED_O
27
LED_RES
5
14
MAIN_V4
16
SPK+
SPK-
17
20
SUB_V1
VBAT1
1
2
VBAT2
WR
23
R350
22
CS_SUB
6
D0
D1
7
8
D2
D3
9
10
D4
D5
11
12
D6
D7
13
28
DIMMINGEN_VIB
3
18
GND1
4
LCD_TEMP
LCD_VDD
15
LED_B
25
LED_CHG
19
1M
CN602
02-5602-030-000-829
24
A1
30
BACKUP_BATT
CS_MAIN
21
R358
R359
123456
78
200K
R301
MNR04-10K
27p
27p
C306
34567
8
LCD_VDD
C305
8
TXD
12
VBAT1
18
VBAT2
9
TP316
V307
1
2
CTS
15
17
DCVOLT1
16
DCVOLT2
DSR
13
GND1
1
GND2
2
POWER_ON
10
RTS
14
RX
7
RXD
11
TCK
3
TDI
5
TDO
6
TMS
4
TX
10R306
1005-0018-307
CON301
VBAT
V304
1
2
100
VR2B
VR2
R353
R354
100
100
100R336
R352
V303
1
2
D(0)
D(1)
D(2)
D(3)
D(4)
D(5)
D(6)
D(7)
LCD_TEMP
MELODY_VIB
VBAT
A(1)
BACKUP_BATT
CS_MAIN
CS_SUB
DIMMING
LED_B
LED_G
LED_O
SPK+
SPK-
WR
LCD_RES
TDO
TDI
TCK
TMS
DEBUG_RX
DEBUG_TX
DC_VOLT
CTS
RTS
TXD
RXD
VR2
VR2B
VR3
RPWRON
DSR
7.3 Connectors
Page 47
L
D
I
J
2 3 10
10
1511
F
13
Engineer:
Drawn by:
Size:
2003.11.05
SC100
L
3
Approved by:
REV:
16
1
Drawing Number:
4
11
Date:
14
2 16
A
Sheet:
MEMORY & MELODY
12
E
Time Changed:
7
B
TITLE:
1565
B
8
G
Date Changed:
H
C
D
J
K
F
C
14
(YMU759)
A
E
G
K
4 of 7
1.0
A3
I
7 8 9
1394
H
61 125
Changed by:
VBAT
VR2
100n
C409
100n
180p
C404
C411
27KR402
82K
4.7K
R403
R404
C412
2.2u
(1608)
(1608)
1u
C416
29
~CS
~IRQ
3
31
~RD
4
~RST
~WR
28
VR2B
EQ2
13
14
EQ3
EXTX1
2
EXTX2
19
HPOUT-L
10
11
HPOUT-R
IFSEL
5
6
PLLC
SDOUT
32
17
SPOUT1
SPOUT2
18
15
SPVDD
SPVSS
16
VDD
7
VREF
9
8
VSS
YMU762
U402
A0
30
CLK1
1
27
D0
D1
26
25
D2
D3
24
23
D4
D5
22
21
D6
D7
20
12
EQ1
1000p
VR2B
C417
VR2B
R409
10k
10K
R430
C403
47n
R451 10K
10K
R450
R413 NC
NC8
L1
C2
NC9
OE
H3
RESET
D5
RY_BY
E5
SA
G8
UBS
D4
VCC-F
J5
VCC-S
J6
VSS1
J9
G3
VSS2
WE
C6
WP_ACC
C5
VR2
L6
NC13
NC14
F9
L2
NC15
NC16
B10
NC17
L3
L8
NC18
NC19 L10
A9
NC2
L9NC20
NC21M2NC22 M9
B2
NC3
NC4
B1
B3
NC5
NC6B8NC7
B9
H7
DQ13
K8
DQ14
H8
DQ15
K4
DQ2
H5
DQ3
H6
DQ4
K7
DQ5
G7
DQ6
J8
DQ7
K3
DQ8
H4
DQ9
C4
LBS
A2
NC1
NC10
B5
B6
NC11
L5
NC12
F3
A4
E3
A5
D3
A6
C3
A7
C7
A8
E7
A9
CE1S
J2
D6
CE2S
CEF
H2
CIOF
H9
CIOS
K6
J3
DQ0
G4
DQ1
J4
DQ10
K5
DQ11
J7
DQ12
G2
A0
F2
A1
F7
A10
C8
A11
D8
A12
E8
A13
F8
A14
D9
A15
G9
A16
F4
A17
E4
A18
D7
A19
E2
A2
E6
A20
A22
E9
D2
A3
A(22)
A(1:22)
TH50VSF3680AASB
U401
RD
A(1)
D(0:7)
D(0)
D(1)
D(2)
D(3)
D(4)
D(5)
D(6)
D(7)
CS2
SPKSPK+
MELODY_LED
MELODY_VIB
A(16)
A(17)
A(18)
A(19)
A(20)
A(21)
13MHz_OUT
MELODY_IRQ
MELODY_RST
WR
A(5)
A(6)
A(7)
A(8)
A(9)
A(10)
A(11)
A(12)
A(13)
A(14)
A(15)
D(12)
D(13)
D(14)
D(15)
A(1)
WR
-BLE
-BHE
FDP
A(2)
A(3)
A(4)
D(0)
RD
CS0
CS1
D(0:15)
D(1)
D(2)
D(3)
D(4)
D(5)
D(6)
D(7)
D(8)
D(9)
D(10)
D(11)
7.4 Memory & Melody
Page 48
interface
4
BACK UP
Time
F
interface
C
Voiceband
Serial port
manegement
G
APPLY
V/I
baseband
1
E
serial port
interface
Bat
C
OUT VOLTAGE
6
omega digital core
VR2
PERMANT
Page:
Size:
load max
120mA
F95/P
CODEC
7 8
TITLE:
reference
MCU
level shifter
LMK212BJ225MG-T
Omega
50mA
interrrupt
2.85V
Drawn by:
LDO
VR1
VR1B
Generic
80mA
12
D
misc
VR2B
SIM
VR3
Serial
SIM
CODEC
(1608)
H
1 3 4
2
IrDA
port
H
A
120mA
B
2003.11.06
ulysse digital core
test
interface
ARM
Serial port
LDOs
R&D CHK:
11
E
2.0V
9
manegement
10 11
F95/A
ON/OFF
LCDSYNC
debug &
F95/P
2.85V
I/O
ON/OFF
1.0
PERMANT
misc
voiceband
5
Changed by: Date Changed: Time Changed:
Power Supply
omega analog
interrupt
ulysse memory
TSP
F
control
2
Mwire
2.85V
A
DOC CTRL CHK:
TSCYM
(1608)
G
MCSI
F95/P
5
PERMANT
A3
8
CHIPSET
F95/P
109
interface
6
Memory interface
B
Baseband
ulysse,omega I/O
7
Debug
F95/P
interface
SC100
Engineer:
F741529AGHHR
3
Keybd interface
D
on/off
analog I/O
Power
12
Drawing Number:REV:
JTAG &
50mA
1.8V
TWL3011GGMR
5 of 7
12 1 8 A
100p
C500
TP500
VR1
10u/10V
UPR
100n
C521
C516
C515
220K
R505
LMK107BJ224KA-T(1608)
220n
VDX
H11
VFSRX
D501
RB520S
1
2
VBAT_2
VDD4
VDDA1
G12
P12
VDDARM
VDDLMM1
B8
A3
VDDLMM2
VDDLMM3
M5
L6
VDDS11
VDDS12
N9
J10
VDDS13
VDDS14
P14
K3
VDDS15
K12
VDDS21
VDDS22
D10
A14
VDDS23
VDDS24
C3
H13
VDR
H12
C6
E6
TSPACT9_MAS1
TSPCLKX
E14
C14
TSPDI_I_O4
D14
TSPDO
TSPEN0
D13
D12
TSPEN1
TSPEN2
B14
C12
TSPEN3_NSCS2
TXIR_IRDA_X_A4
F1
F2
TX_IRDA
TX_MODEM
D2
VCLKRX
G11
VDD1
A13
P8
VDD2
F10
VDD3
J5
K14
G1
TCK
TCXOEN
E11
H2
TDI
TDO
H3
TMS
H1
TSPACT0
C13
B13
TSPACT1
TSPACT10_NWAIT
H10
K13
TSPACT11_MCLK
TSPACT2
B12
D11
TSPACT3
TSPACT4
B10
E9
TSPACT5
TSPACT6_NCS6
E8
E7
TSPACT7_CLKX_SPI
TSPACT8_NMREQ
E10
A11
OSC32K_OUT
A10
RFEN_NOPC
RNW
N8
E4
RTS_MODEM_TOUT
F3
RXIR_IRDA_X_A1
RX_IRDA
E1
D3
RX_MODEM
SCLK_INT1N
E3
C4
SDI_SDA
C1
SDO_INT10N
D1
SD_IRDA_CLKOUT_DSP
J11
SIM_CD_MAS0
J14
SIM_CLK
SIM_IO
J13
SIM_PWCTRL_I_O5
J12
SIM_RST
NBHE_I_O14
NBLE_I_O15
K8
NBSCAN
H4
P6
NCS0
NCS1
L7
P7
NCS2
NCS3
M7
NEMU0
G2
G4
NEMU1
L8
NFOE_X_A3L9NFWE_X_A0
NRESET_OUT_I_O7
K11
NRESPWRON
G3
F4
NSCS0_SCL
NSCS1_X_A2
G5
D6
ON_OFF
OSC32K_IN
KBC4_XDI_02
KBR0_XDI_03
A4
B4
KBR1_XDI_04
KBR2_XDI_05
D4
B3
KBR3_XDI_06
KBR4_XDI_07
A2
LT_PWL
B1
MCSI_CLK_I_O11
D9
D8
MCSI_FSYNCH_I_O12
MCSI_RXD_I_O10
B9
A9
MCSI_TXD_I_O9
A8
MCUDI
C8
MCUDO
MCUEN0
C7
MCUEN1_I_O8
B7
A7
MCUEN2_I_O13
K7
H14
B11
GNDA2
GNDARM
N11
P3
GNDLMM1
GNDLMM2
N7
C5
GNDLMM3
IDDQ
C9
B6
IT_WAKEUP_INT4N
I_O0_TPU_WAIT
J1
J3
I_O1_TPU_IDLE
I_O2_IRQ4
M4
M6
I_O3_SIM_RNW
KBC0_NFIQA6KBC1_NIRQA5KBC2_XDI_00B5KBC3_XDI_01
D5
E5
DATA9
DSR_MODEM_LPG
F5
H5
EN_LMM_PWR_X_IOSTRB
EXT_FIQ
D7
E13
EXT_IRQ
M9
FDP_NIACK
C10
GND1
GND10
L10
GND2
N6
M10
GND3
GND4
B2
L12
GND5
E12
GND6P1GND7
GND8
A12
J2
GND9
GNDA1
E2
DATA0
P9
DATA1
K9
DATA10
N13
M13
DATA11
DATA12
M12
N14
DATA13
DATA14
M14
L13
DATA15
DATA2
P10
N10
DATA3
DATA4
K10
P11
DATA5
M11
DATA6
L11
DATA7
DATA8
N12
P13
L2
L3
ADD6
ADD7
M1
N1
ADD8
ADD9
M3
F11
BCLKR_ARMCLK
G10
BCLKX_I_O6
BDR
F13
BDX
G13
F12
BFSR
F14
BFSX
C2
BU_PWT
CLK13M_OUT_START_BIT
L14
CLK32K_OUT
C11
CLKTCXO
G14
M8
CS4_ADD22
CTS_MODEM_XF
K1
M2
ADD10
ADD11
N2
P2
ADD12
ADD13
N3
L4
ADD14
ADD15
N4
P4
ADD16
ADD17
K5
L5
ADD18
ADD19
N5
K2
ADD2
P5
ADD20
ADD21_CK16X_IRDA
K6
ADD3
K4
ADD4
L1
ADD5
U500
ULYSSE_179BGA
J4
ADD0
ADD1
R504
10K
VR2B
C527
10u/10V
R500 0
10K
R507
TP522
TP523
TP524
C526
10u/10V
10u/10V
C525
TP518
20K
R511
27p
C502
TP520
TP521
UPR
100n
C512
TP519
TP526
VR1B
UPR
VR1
VR2B
100n
C530
(2012)
2.2u
C518
EMK107BJ104KA-T
100n
C528
47u/4.0V
C588
R510
UPR
20K
EMK107BJ104KA-T
100n
C517
15p
C503
C504
VR1B
VR2
VBAT
1n
SN74LVC1G19DCK
U503
1
2
3
4
5
6
TP530
C531
10u/10V
100n
CC5V
X501
C540
R519
120K
UPR
TP528
TP527
R506
10K
C513
100n
VR3
0R501
C510
100n
TP515
10K
R508
27p
VR2
UPR
H1
D1
VR2BOUT
E2
VR2IN
VR2OUT
E1
VR2SEL
D3
VR3OUT
H10
VREF
F4
VS1
B1
A1
VS2
C501
UDR
UDX
J6
UEN
F5
UPR
C3
A3
VAUX
VBACKUP
J3
E5
VBAT
VCC1
K3
VCC2
D2
VCC3
G9 E4
VCHG
VCK
H6
K7
VDR
VDX
G6
G7
VFS
C1
VR1BOUT
VR1OUT
SRST5
A2
SVDD
K2
SWITCH
B7
TCK
A7
TDI
TDO
C7
J4
TDR
TEN
K4
TEST1
C8
TEST2
B8
TEST3
A9
B9
TEST4
F2
TESTRESETZ
A8
TMS
B6
TSCXM
A6
K6
K9
MCIBIAS
J8
MICIN
MICIP
K8
ONNOFF
D10
OSCAS
F1
PWON
B10
F3
REFGND
F6
RESPWRONZ
RPWON
A10
RTC_ALARM
D7
C4
SCLK3
SCLK5
B4
B2
SIO3
D4
SIO5
B3
SRST3
D5
D9
BULQP
D8
K10
BUZZOP
A4
CK13M
H3
COMP
F10
DAC
EARN
H8
H9
EARP
J1
FDBK
K1
GRND1C2GRND2
GRND3
G10
G1
IBIAS
ICTL
E3
INT1
F7
H4
INT2
C5
J9
BDLIM
E8
BDLIP
E7
E10
BDLQM
BDLQP
E9
H5
BDR
K5
BDX
BFSR
G5
BFSX
J5
BGTR1
G4
BGTR2
G3
BGTR3
G2
H2
BGTR4
BGTR5
J2
BULIM
C10
BULIP
C9
BULQM
OMEGA_VER2_0
U501
ADIN1
B5
ADIN2
A5
ADIN3
E6
D6
ADIN4_TSCXP
C6
ADIN5_TSCYP
AFC
F8
J7
AGNDA1
F9
APC
G8
AUXGND
H7
AUXI
J10
AUXON
AUXOP
0R503
R502 0
TP516
(1608)
1u
C507
C519
100n
TP525
0
R509
LED_B
DIMMING
CS3
CS_MAIN
CS_SUB CS3
A(21)
LCD_TEMP
KEY_LED
MICIN
MICIP
EARN
EARP
MELODY_LED
MELODY_RST
RF_ENA
TDO
LED_O
LED_G
A(17)
A(18)
A(19)
A(20)
A(21)
RECEIVER_ON
SYN_EN
BSW
PDB
PRECHARGE
-BHE
A(1)
A(2)
A(3)
A(4)
A(5)
A(6)
A(7)
A(8)
A(9)
A(10)
A(11)
A(12)
A(13)
A(14)
A(15)
A(16)
D(6)
D(7)
D(8)
D(9)
D(10)
D(11)
D(12)
D(13)
D(14)
D(15)
A(1:21)
PA_ON
13MHZ BATT_ID
AFC
PA_LEVEL
RXQN
RXQP
RXIN
RXIP
TXQN
TXQP
TXIN
TXIP
CLK
D(0:15)
D(1)
D(2)
D(3)
D(4)
D(5)
KBR(0:4)
KBC(0:4)
KBR(1)
KBR(2)
KBR(3)
KBR(4)
KBC(0)
KBC(1)
KBC(2)
KBC(3)
KBC(4)
CS0
CS1
CS2
RD
FWE
LCD_RES
WR
RTS
DEBUG_RX
RXD
TDI
DEBUG_TX
TXD
EAR_HOOK
A(22)
CTS
D(0)
DSR
FDP
JACK_DET
REED
KBR(0)
MELODY_IRQ
-BLE
TCK
DATA
TMS
BACKUP_BATT
DC_VOLT
13MHZ_OUT
ICTL
ON_OFF
END_ON_OFF
RPWRON
SIM_CLK
SIM_I-O
SIM_RST
SIM_VDD
7.5 Main Chip(Ulysse/Omega)
Page 49
47k
10k
47k
10k
1
E
A
F
(330)
(100K)
VPP
BLM11P300SPTM
TITLE:
D
4
RECEIVER-
8
SC100
1.0
F95/A
6
C
8
7
CLK
- SIM Card -
X6 EA(V605,V606,V607,V608,V609,V610)
5
H
3
Engineer:
Charger
RECEIVER+
65
C
S-
BLM11P300SPTM
Page:
10
SI9411DL LOGIC TABLE
ON
2
Time Changed:
SWITCH-PRESSED = 1.2V
Size:
F
2
1 2
F95/A
B
0
- LCD LDO -
20K
B
DMJBRK32D
1
(1K)
Date Changed:
OFF
(NC)
H
(MAX9075)
H
11
(330)
6
G
L
62K
slim
S+
Changed by:
ON
switch_pressed
4
JACK_OUT
LOGIC
GND
SWITCH-RELESE = 0.4V
Vref = 1.0V
11
RST
BAT_ID_Res
E
7
- Battery-connector -
(1K)
R&D CHK:
CON605
F95/P
9
switch_release
L
D
H
Drawn by:
5
NC(#4)
JACK_IN
OFF
12
6 of 7
12 1 8 A
A3
VCC
M+
2003.11.05
I-O
DOC CTRL CHK:
X2 EA
A
12
Drawing Number:
3
REV:
standard
(100K)
9 10
M-
1
4
3
G
NO(#6)
C617
C623
(1608)
15p
VR3
(1608)
39p
NC
C606
180K
R614
C600
33u/10V
V609
C615
V608
47u/4.0V
123
4
5 6
100KR607
DG9411DL-T1
U603
123
4
5 6
DG9411DL-T1
U604
AVLC5S02050(50pF)
V605
VR3
V606
VR3
470p
C605
8
VR3
R616
180K
02-828D0-53BKA
EAR600
1
2
3
4
5
67
U623
C624
39p
(1608)
22n
C601
15p
(1608)
VR3
LCD_VDD
VR3
C622
C661
10u/6.3V
7
8
CN601
AGK3370
1
1
2
2
3
3
R601
10K
BLM11HB102SD
F601
Q600
SI6459DQ-T1
1
2 3
4
5
6
R618
VBAT
100K
120K
150p
C603
R617
BLM15BD102PN1
F604
F603
BLM15BD102PN1
R613
1.8K
4
5
6
U624
VR3
UMH9N
Q604
1
2
3
100K-1%
1/10W(1608)
R648
24
VR3
R615
VBAT
(1608)
2.2u
C609
15p
C625
R653
10K
3
1
100n
C612
6
OUT
7
2SA1576FRT106
Q605
2
1K
R666
U608-B
TC75W56FK(TE85L)
+
5
-
V601 V602
VBAT_2
MIC
MIC
V610
AVLC5S02050(50pF)
CN600
SIM_SOCKET
1318-723-6
CLK
3
GND
8
I-O
6
RST
2
VCC
1
VPP
7
V607
C618
15p
(1608)
C616
NC
(1608)
VBAT
0R2_1%
F600
BLM11HB102SD
R605
R604
R600
7.5K
R608
47K
1K
U600
NC
+
3
-
4
2
1
5
(2012)
2.2u
C602
2
3
4
5
6
SN74LVC1G3157DCK
U612
1
2
3
4
5
6
C608
100n
U601
SN74LVC1G3157DCK
1
NC
R609
1K
R610
C663
100p
CRS08
D601
C634
100n
1.8K
R612
BLM10A102SG
F602
R663
0
TA_VCC
HVD142
D621
C604
NC
R611
1K
R606 NC
TC75W56FK(TE85L)
U608-A
3
+
2
-
4
1
OUT
8
SPK-
U622
TPS793285DBV
BYP43EN
2
GND
IN1OUT
5
REED
LED_O
BACKUP_BATT
ON_OFF
SPK+
RECEIVER_ON
EARP
EARN
MIC+
TA_VCC
ICTL
DC_VOLT
PRECHARGE
JACK_DET
MIC-
SIM_RST
BATT_ID
SIM_CLK
SIM_I-O
MICIP
MICIN
SIM_VDD
EAR_HOOK
7.6 Audio & SIM connector
Page 50
B
C
E
A
B
C
4
2 3
52
QA CHK:
UP
DOWN
Engineer:
Drawn by:
D
6 7
TITLE:
E
3
Size:
Changed by:
Drawing Number:
6
Page:
X4 EA
x 8EA
DOM SHEET GUIDE HOLE
R&D CHK:
8
1
- SIDE KEY -
54
REV:
7
1.0
D
X10 EA
1
F
A
8
DOC CTRL CHK:
[END_ON/OFF]
SW700
2003.011.05
7 of 7
SC100
A3
MFG ENGR CHK:
F
1
RIGHT
STAR
C700
100n
CENTER
V707 V708
VBAT
AVLC5S02050(50pF)
V701
V703
8
AVLC5S02050(50pF)
V700
D702
1
2
47K
R703
TPOP
BOTTOM
SEND09
V710
V713
3.9K
R711
AVLC5S02050(50pF)
V711
Q702
EMX1T2R
1
2
3
4
5
6
F1
7
D703
1
2
V715
V704
R713
33R
V702
LEFT
V706
D705
1
2
D707
HL005-B11
1
2
23
V712
1
2
V705
V716
AVLC5S02050(50pF)
AVLC5S02050(50pF)
V714
D706D701
1
2
33R
R715 R718
33R
45
D700
1
2
SIDE1
VR3
1
2
3
4
5
6
F2 SHARP
EMX1T2R
Q701
100K
R717
D704
1
2
R716
3.9K
33R
R719
6
V709
RD700
12
3
R712
100K
KEY_LED
A3212ELH
KBC(4)
KBR(1)
KBR(2)
KBR(1)
KBC(0)
KBR(2)
KBC(1)
KBC(2)
KBC(3)
KBR(0)
KBC(4)
KBR(3)
KBR(4)
END_ON_OFF
REED
7.7 Key & Backlight
Page 51
5
4
3
2
1
7.8 LCD Module
VDD
R12 1M
D D
C C
MAIN_V1
1005
C26 1uF/25V/1608
C2 1uF/25V/1608
C5 1uF/6.3V/1005
C8 1uF/6.3V/1005
C10 1uF/25V/1608
C14 1uF/25V/1608
C15 1uF/25V/1608
C16 1uF/25V/1608
C25 1uF/6.3V/1005
C17 1uF/25V/1608
C20 1uF/6.3V/1005
C21 1uF/6.3V/1005
C22 1uF/16V/1608
C23 1uF/16V/1608
C27 1uF/16V/1608
C24 1uF/16V/1608
C41 1uF/16V/1608
U2
1
VOUT
VDD
2
C6-
LCD_RES
3
C6+
CSB
4
C5-
A1
5
C5+
VSS
6
C4-
TEST2
7
C4+
P/S
8
C3-
SEL68
9
C3+
WR
10
C2-
RD
11
C2+
VDD
12
C1-
D0
13
C1+
D1
14
VSSH
D2
15
VEE
D3
16
VBA
D4
17
VREF
D5
18
VREG
D6
19
V4
D7
20
V3
VSS
21
V2
OSC1
22
V1
OSC2
23 24
VLCD VSSH
HM17CM4096
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
MAIN_LCM
LCD_RES
CS_MAIN
A1
WR
D0
D1
D2
D3
D4
D5
D6
D7
VDD
C39
0.1uF/16V/1005
C43
27P/1005
SUB_V1
C42
27P/1005
VDD
C40
0.1uF/16V/1005
C18
1uF/6.3V/TANTAL/1608
DIMMING
C1 0.1uF/16V/1005
C3 0.1uF/16V/1005
C4 0.1uF/16V/1005
C6 0.1uF/16V/1005
C7 0.1uF/16V/1005
C9 1uF/6.3V/1005
C11 1uF/6.3V/1005
C13 1uF/6.3V/1005
C12 1uF/25V/1608
VBAT
+
CON2
1
V0
2
V4
3
V3
4
V2
5
V1
6
C2-
7
C2+
8
C1+
9
C1-
10
C3+
11
VOUT
12
VSS
13 14
VDD D7
BW_TC100_SUB
SUB_LCM
L1
RB551V-30
22uH
U5
1
5
SW
VIN
4
FB
SHDN
GND
2
LT1937
CS1B
RESETB
D5
D6
KDZ12EV
3
ORANGE
LED2
orange
1
GREEN
R1 18K/1005
R3
47K/1005
R5 18K/1005
R8
47K/1005
R11 18K/1005
R17
47K/1005
VBAT
FAGB1313CE-12-TR(1.0T)
4
VBAT
green
blue
2
3
BLUE
LED_O
LED_G
LED_B
LED_CHG
VBAT
25
24
23
RS
22
RW
21
D0
20
D1
19
D2
18
D3
17
D4
16
D5
15
D6
R9 1K/1005
LED B/L
D1,D2
R10
6.2/1005
LED
CS_SUB
LCD_RES
A1
WR
D0
D1
D2
D3
D4
D5
D6
D7
+
C19
1uF/6.3V/TANTAL/1608
4
blue
2
3
GREEN
BLUE
VBAT
green
LED1
FAGB1313CE-12-TR(1.0T)
orange
1
ORANGE
R4
220/1005
R6
100/1005
R15
68/1005
14
O G B VBAT
U3
3
5
4
6
2
1
5
6
1
5
6
1
KTC801E
U4
KTC801E
U6
KTC801E
R2
220/1005
3
4
2
R7
100/1005
3
4
2
R16
68/1005
RING
INDICATOR
CON1
VBAT
1
VBAT
2
VBAT
C38
1uF/6.3V/1005
1005*9
3
EN_VIB
4
LCD_TEMP
5
LCD_RES
6
D0
7
D1
8
D2
9
D3
10
D4
11
D5
12
D6
13
D7
14
MAIN_V4
15 16
LCD_VDD SPK+
AXK5F30345J
B B
D0
D1
D2
D3
D4
D5
D6
D7
C31
C30
27P
27P
A A
C34
C33
C32
27P
27P
27P
EN_VIB
LCD_TEMP
LCD_RES
MAIN_V1
VDD
C37
C36
C35
27P
27P
27P
5
BACKUP_BATT
DIMMING
LED_O
LED_G
LED_B
CS_SUB
CS_MAIN
SUB_V1
LED_CHG
30
29
GND
28
27
26
25
24
A1
23
WR
22
21
20
19
18
GND
17
SPK-
BACKUP_BATT
DIMMING
LED_O
LED_G
LED_B
A1
WR
CS_SUB
CS_MAIN
SUB_V1
LED_CHG
SPK-
SPK+
4
EN_VIB
VBAT
C28
1uF/6.3V/1005
3
U8 MUD3105LT1
1
2
V1
AVLC5S02050(50pF)/1005
R13
15/1608
MOTOR
+
-
MG1
MOTOR
DMIBRK32S
VDD
U7
1
4
VDD
VOUT
NC
BT1
MS412FFL26E
LCD_TEMP
2
SPK+
SPK-
INDUCTOR FERRITE/1005
INDUCTOR FERRITE/1005
F2
F4
AVLC5S02050(50pF)/1005
SPEAKER
V3
F3
INDUCTOR FERRITE/1005
F1
INDUCTOR FERRITE/1005
SPK1
+|
SPKEAR
V4
AVLC5S02050(50pF)/1005
Title
SC100 LCD(REV1.3)
Size Document Number Rev
<Doc>
A2
Date: Sheet
1
of
11Friday, November 28, 2003
0.2
2 3
GND
S-8120CNB
TEMP SENSOR
BACKUP_BATT
V2
AVLC5S02050(50pF)/1005
C29
1uF/6.3V/1005
BACKUP_BATT
BACKUP BATTERY
3
Page 52
8. PCB Diagram
8.1 Main PCB
Comment:
Page 53
Page 54
8.2 LCD Module
Page 55
9. Electrical Part List
9.1 Main Part
REF.NO. Q’tyITEM NAME
PCB ASSY MAIN 1
ANT101 COAXIAL CONNECTORS WITH SWITCH CRS5001-1702 SMK 1
U110 ANTENNA SWITCH MODULE LMG002S-5047A NTK 1
U101 POWER AMP MODULE RF3110TR13 RFMD 1
U105 U108 TRANSISTOR DUAL TYPE UMD9N TN ROHM 2
U200 AERO TRANCEIVER SI4201-BMR SILAB 1
U202 GSM AERO TRANCEIVER CHIP SET SI4200DB-BMR SILAB 1
U206 AERO RF SYNTHESIZER SI4133T-BMR SILAB 1
U201 GSM SAW FILTER B39941-B7706-B610 EPCOS 1
U203 DCS SAW FILTER SAFSD1G84FA0T00R00 MURATA 1
U205 U622 CMOS LDO REGULATOR (2.85V) MIC5245-2.85BM5TR MICREL 2
U401 MCP 64M FLASH & 32M SRAM, Top boot block TH50VPF5682CDSB TOSHIBA 1
U402 MELODY IC YMU762QE-2 (MA-3) YAMAHA 1
VENDOR
PURCHASE
U500 BASEBAND MAIN CHIP (ULYSSE_179BGA) F741529AGHHR TI 1
U501 BASEBAND CHIP 2 (OMEGA) TWL3012BGGMR-3 TI 1
U503 DECODER SN74LVC1G19DCK TI 1
U603 U604 ANALOG SWITCH DG9411DL-T1 VISHAY 2
U601 U612 ANALOG SWITCH SN74LVC1G3157DCKR TI 2
U608 DUAL COMPARATOR TC75W56FK(TE85L) N.C 1
RD700 HALL SITCH A3212ELHLT ALLEGRO 1
C301 SYSTEM I/O CONNECTOR, 18Pin,(HAVE NO DTC CHARGE PIN) 3key 1005-0018-307 KAE 1
CN600 SIM SOCKET 1318723-6 KAE 1
EAR600 EAR_JACK 02-828D0-53BKA EX 1
CN601 BATTERY CONNECTOR, 3PIN HB5P002
CN602 LCD CONNECTOR (0.4 pitch, 30 PIN, BOSS ) 24-5602-030-001-829 ELCO 1
D700 D701 D702 D703 D704 D705 D706 D707 KEY LED (BLUE,1608, 0.4t) LBH1000 LUXPIA 8
한빛
1
Page 56
REF.NO. Q’tyITEM NAME
T
A
D501 DIODE RB520S-30 TE-61 ROHM 1
D601 DIODE CRS08 (TE85L) TOSHIBA 1
D621 Silicon Epitaxial Planar Pin Diode HVD142KRF HITACHI 1
Q101 TRANSISTOR DTC114YE TL ROHM 1
Q600 TR P-MOSFET SI6459DQ-T1 VISHAY 1
Q604 TRANSISTOR DUAL TYPE UMH9N TN ROHM 1
Q605 PNP type TRANSISTOR 2SA1576FRT106 ROHM 1
Q701 Q702 TRANSISTOR DUAL TYPE EMX1T2R ROHM 2
PURCHASE
VENDOR
U204 VCTCXO 13 MHz X-TAL TTS17V 13MHz
X501 32.768 KHz X-TAL CC5V-T1 GOLLEDGE 1
F602
F600 F601
F603 F604
U623 U624
C204 C206 CAP CERAMIC CHIP 1pF GRM36COG 1R0C 50PN MURATA 2
C210 C212 CAP CERAMIC CHIP 1.5pF
C122 CAP CERAMIC CHIP 2.7pF
L100 CAP CERAMIC CHIP 5.6pF
C503 C625 CAP CERAMIC CHIP 15pF
C109 C113 CAP CERAMIC CHIP 22pF
C108 C305 C306 C307 C308 C501 C502 CAP CERAMIC CHIP 27pF
C103 CAP CERAMIC CHIP 33pF
C104 C106 C112 C114 CAP CERAMIC CHIP 47pF
FERRITE BEADS, 1005,Z=1000Ω,IR=50mA,Rdc=1.5Ω
FERRITE BEADS, 1608,Z=1000Ω,IR=50mA,Rdc=1.85Ω
FERRITE BEADS, 1005,Z=1000Ω,IR=200mA,Rdc=0.9Ω
FERRITE BEADS, 1608,Z=30Ω,IR=1000mA,Rdc=0.06Ω
BLM10A102SG
BLM15AG102SN1D
BLM 11HB 102SDPT
BLM18HD102SN1
BLM15BD102PN1
BLM15BD102SN1D
BLM11P300SPT
BLM18PG300SN1D
GRM36C0G 1R5C 50PN
GRP1555C1H1R5CZ01E
GRM36COG 2R7C 50PN
GRP1555C1H2R7CZ01E
GRM36C0G 5R6C 50PN
GRP1555C1H2R7CZ01E
GRM36C0G 150J 50PN
GRP1555C1H150JZ01E
GRM36COG 220J 50PN
GRP1555C1H220JZ01E
GRM36COG 270J 50PN
GRP1555C1H270JZ01E
GRM36COG 330J 50PN
GRP1555C1H330JZ01E
GRM36COG 470J 50PN
GRP1555C1H470JZ01E
OKYO DENP
MURATA 1
MURATA 2
MURATA 2
MURATA 2
MURATA 2
MURATA 1
MURATA 1
MURATA 2
MURATA 2
MURATA 7
MURATA 1
MURATA 4
1
Page 57
REF.NO. Q’tyITEM NAME
N
N
N
N
C205 C209 C216 C500 C663 CAP CERAMIC CHIP 100pF
C126 C603 CAP CERAMIC CHIP 150pF
C125 C404 CAP CERAMIC CHIP 180pF
C250 CAP CERAMIC CHIP 220F
C605 CAP CERAMIC CHIP 470p
C417 C504 CAP CERAMIC CHIP 1nF
C102 C117 C123 C213 C214 C220 C221 CAP CERAMIC CHIP 10nF
C200 C208 C218 C219 C601 C701 CAP CERAMIC CHIP 22nF
C403 CAP CERAMIC CHIP 47nF
C207 C409 C411 C510 C512 C513 C515 C519
C530 C540 C608 C612 C634 C700
C617 C618 C622 CAP CERAMIC CHIP 15pF (1608)
C623 C624 CAP CERAMIC CHIP 39pF (1608)
CAP CERAMIC CHIP 100nF
GRM36COG 101J 50PN
GRP1555C1H101JD01E
GRM36COG 151J 50PN
GRP1555C1H151JD01E
GRM36X7R 181K 25PN
GRP1556C1E181JD01E
GRM36X7R 221K 25PN
GRP1556C1E221JD01E
GRM36X7R 471K 50PN
GRP155R71H471KD01E
GRM36X7R 102K 50PN
GRP155R71H102KA01E
GRM36X7R 103K 16PN
GRP155R71C103KA01E
GRM36X7R 223K 16PN
GRP155R71C223KA01E
GRM36X7R 473K 10PN
GRP155R71A473KA01E
GRM36Y5V 104Z 16PN
GRP155F51C104ZA01E
GRM39C0G 150J 50PN
GRM1885C1H150JZ01D
GRM39COG 390J 50PN
GRM188RC1H390JZ01D
VENDOR
PURCHASE
MURATA 5
MURATA 2
MURATA 2
MURATA 1
MURATA 1
MURATA 2
MURATA 7
MURATA 6
MURATA 1
MURATA 14
MURATA 3
MURATA 2
C517 C528 CAP CERAMIC CHIP 100nF (1608) EMK107BJ104KA-T TAIYO YUDE
C516 CAP CERAMIC CHIP 220nF (1608) LMK107BJ224KA-T TAIYO YUDE
C416 C507 CAP CERAMIC CHIP 1uF (1608)
C100 C412 C609 CAP CERAMIC CHIP 2.2uF (1608) JMK 107F 225ZA TAIYO YUDE
C518 C602 CAP CERAMIC CHIP 2.2uF (2012) LMK21BJ225MG-T TAIYO YUDE
C130 C606 CAP CERAMIC CHIP NC (1005) 2
C107 C616 CAP CERAMIC CHIP NC (1608) 2
C222 C521 C525 C526 C527 C531 C661 TAN_CAP 10uF/6.3V TEPSLPOJ106M8RSN NEC 7
C600 TAN_CAP 33uF/10V F951A336MAAAQE2 NICHICON 1
C588 C615 TAN_CAP 47uF/4.0V F950G476MAAAQE2 NICHICON 2
GRM39Y5V 105Z 10PT
GRM188F51A105ZC01D
MURATA 2
2
1
3
2
Page 58
REF.NO. Q’tyITEM NAME
N
N
N
N
N
C101 TAN_CAP 220uF/6.3V F950J227MGGGZT NICHICON 1
PURCHASE
VENDOR
L110 CHIP INDUCTOR (1005) 2.7nH HK 1005 2N7J TAIYO YUDE
L202 CHIP INDUCTOR (1005) 3.9nH HK 1005 3N9J TAIYO YUDE
C121 CHIP INDUCTOR (1005) 5.6nH HK 1005 5N6J TAIYO YUDE
L201 CHIP INDUCTOR (1005) 7.5nH 0402CS-7N5XJBW COIL CRAFT 1
L200 CHIP INDUCTOR (1005) 27nH HK 1005 27NJ TAIYO YUDE
L103 CHIP INDUCTOR (1005) 56nH HK 1005 56NJ TAIYO YUDE
R500 R501 R502 R503 R663 RES. CHIP 0 ohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ000 ROHM 5
R302 R303 R304 R306 R307 RES. CHIP 10 ohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ100 ROHM 5
R106 RES. CHIP 12 ohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ120 ROHM 1
R713 R715 R718 R719 RES. CHIP 33 ohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ330 ROHM 4
R101 RES. CHIP 56 ohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ560 ROHM 1
R203 R336 R350 R351 R352 R353 R354 R355
R356 R357
R104 R105 RES. CHIP 430 ohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ431 ROHM 2
R103 R305 R604 R610 R611 R666 R722 RES. CHIP 1 Kohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ102 ROHM 7
R721 RES. CHIP 2 Kohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ202 ROHM 1
RES. CHIP 100 ohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ101 ROHM 10
2
1
1
1
1
R612 R613 RES. CHIP 1.8 Kohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ182 ROHM 2
R711 R716 RES. CHIP 3.9 Kohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ392 ROHM 2
R404 RES. CHIP 4.7 Kohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ472 ROHM 1
R600 RES. CHIP 7.5 Kohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ752 ROHM 1
R112 R113 R119 R201 R202 R409 R430 R450
R451 R504 R506 R507 R508 R601 R653
R510 R511 RES. CHIP 20 Kohm +-5%(J) 1/16W 1005(0402) MCRO1MZSJ203 ROHM 2
R402 RES. CHIP 27 Kohm +-5%(J) 1/16W 1005(0402) MCRO1MZSJ273 ROHM 1
R608 R703 RES. CHIP 47 Kohm +-5%(J) 1/16W 1005(0402) MCRO1MZSJ473 ROHM 2
R403 RES. CHIP 82 Kohm +-5%(J) 1/16W 1005(0402) MCRO1MZSJ823 ROHM 1
R607 R617 R712 R717 RES. CHIP 100 Kohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ104 ROHM 4
RES. CHIP 10 Kohm +-5%(J) 1/16W 1005(0402) MCR01MZSJ103 ROHM 15
Page 59
REF.NO. Q’tyITEM NAME
R519 R618 RES. CHIP 120 Kohm +-5%(J) 1/16W 1005(0402) MCRO1MZSJ124 ROHM 2
R614 R616 RES. CHIP 180 Kohm +-5%(J) 1/16W 1005(0402) MCRO1MZSJ184 ROHM 2
R358 RES. CHIP 200 Kohm +-5%(J) 1/16W 1005(0402) MCRO1MZSJ204 ROHM 1
R505 RES. CHIP 220 Kohm +-5%(J) 1/16W 1005(0402) MCRO1MZSJ224 ROHM 1
R359 RES. CHIP 1 Mohm +-5%(J) 1/16W 1005(0402) MCRO1MZSJ105 ROHM 1
R615 RES. CHIP 100 Kohm +-1%(F) 1/16W 1005(0402) MCR01MZSF1003 ROHM 1
R648 RES. CHIP 24 ohm +-5%(J) 1/10W (1608) MCR03EZHJ240 ROHM 1
R605 RESISTOR 0.2R_1% (2012) RLC20R20FTP KAMAYA 1
R413 R509 R606 R609 RES. CHIP NC 4
R301 RES. ARRAY CHIP 10 Kohm +-5%(J) 1/16W 1005 x4 MNR04 M0AB J103 ROHM 1
V300 V301 V302 V303 V304 V305 V306 V601
V602 V605 V606 V607 V608 V609 V610 V700
V701 V702 V703 V704 V705 V706 V707 V708
V709 V710 V711 V712 V713 V714 V715 V716
V307 V308 VARISTOR ARRAY 50pF ICVA21054E500 INNOCHIPS 2
VARISTOR 50pF 1005 ICVS0505500PR INNOCHIPS 32
PURCHASE
VENDOR
MAIN PCB (V1.0) DAP 1
ANTTENA D5-1-B1-05500 EMW 1
C-MIC
OBG-15P44-C2S1 BSE 1
Page 60
9.2 LCD Module
REF.NO. ITEM NAME
VENDOR
PURCHASE
PCB MODULE
U2 IC, CSTN DRIVER, 4K, TCP HM17CM4096 HYNIX
CON2 IC, B/W DRIVER 96*32 Dot TL0324S TOMATO LSI
BL1 LED BACK_LIGHT, 2-WAY LMD2240 Hanwool
PANEL1 PANEL, MAIN, 1.37", 128(RGB)*96 D-GCA60120F-0 POWER TIP
PANEL2 PANEL, SUB, 0.8", 96*32 D-GFC60108B-2 POWER TIP
U7 IC, TEMPERATURE SENSOR S-8120CNB SII
U3,U4,U6 IC, COMBINATION TRANSISTOR KTC801E KEC
U8 IC, VIBRATOR DRIVER NUD3105LT1 ON-SEMI
D5 DIODE, Schottky barrier diode RB551V-30 ROHM
D6 DIODE, ZENER, 12V KDZ12EV KEC
R13 RES, 1608, 15, 5% MCRO3MZSJ150 ROHM
R15,R16 RES, 1005, 68, 5% MCRO1MZSJ680 ROHM
R6,R7 RES, 1005, 100, 5% MCRO1MZSJ101 ROHM
R9 RES, 1005, 1K, 5% MCRO1MZSJ102 ROHM
R1,R5,R11 RES, 1005, 18K, 5% MCRO1MZSJ183 ROHM
R10 RES, 1005, 6.2, 5% MCRO1MZSJ6R2 ROHM
R2,R4 RES, 1005, 220, 5% MCRO1MZSJ221 ROHM
R12 RES, 1005, 1M, 5% MCR01MZSJ105 ROHM
R3,R8,R17 RES, 1005, 47K, 5% MCRO1MZSJ473 ROHM
U5 IC, LED DRIVER LT1937ES5 LINEAR
L1 INDUCTOR, 22uH LEMC2520T220K TAIYO YUDEN
F1,F2,F3,F4 FERRITE BEAD, 1005 HB-1M1005-102JT CERATECH
V1,V2,V3,V4 CHIP VASISTOR, 5V,50pF, 1005 AVLC5S02050 AMOTECH
C1,C3,C4,C6,C7,C39,C40 CAP, 1005, 0.1uF/16V X5R C1005X5RC104KT TDK
C22,C23,C24,C27,C41 CAP, 1608, 1uF/16V, X5R C1608X5RC105KT TDK
C2,C10,C12,C14,C15,C16,C17,C26 CAP, 1608, 1uF/25V, X5R TMK107C105K-T TAIYO YUDEN
C5,C8,C9,C11,C13,C20,C21,C25,C28,C29,C3
8
C18,C19 TANTALUM CAP, 1uF/16V SKF-1C105M-RJ ELNA
C30~C37,C42,C43 CAP, 1005, 27pF/50V, X5R - ANY
CAP, 1005, 1uF/6.3V, X5R C1005X5RC105KT TDK
LED1,LED2 LED, MULTI_COLOR FAGB1313FE-10-TR STANLY
CON1 CONNECTOR, 0.5mm PITCH, 30PIN AXK5F30345J NAIS
MOTOR1 MOTOR LAC12L(MOD) NIDEC COPAL
SPEAKER1 SPEAKER SBD001742PCW03 SAMBU
BAT1 BACKUP BATTERY
TAIL1 TAIL, CON TO CON FPCB SC-100CTC Hantech
PCB1 PCB, 0.4t LMD2240 (REV1.0) TECOS
MS412FFL26E
LM414
SII
SANYO
Loading...