Volvo C30 2011 User Manual

VOLVO C30, S40 (04-), V50 & C70 (06-)

WIRING DIAGRAM 2011

TP 39178202

Vehicles with SRS (Airbag)/SIPS bag/

IC (Inflatable curtain)

Warning!

Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC in order to avoid:

1. Personal injuries when performing repair work.

2. Damage or malfunction of the SRS/SIPS bag/IC system. Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo workshop. In case of doubt, consult the SRS and SIPS bag/IC service manual.

Is the vehicle equipped with SRS/SIPS bag/IC?

Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the dashboard above the glove compartment. SRS vehicles from 1993 and onward also have explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).

General recommendations

• Be especially careful when working on or around SRS, SIPS, and IC components.

• Make sure that no wires are pinched, frayed, or pierced.

• Never fit accessories by the sensors.

• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done in accordance with the methods in the SRS section of VIDA.

• Certain components of the aforementioned systems must be grounded while working. Read the appropriate sections in VIDA.

• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C and D-posts.

Test terminal

Fuse in cargo compartment auxiliary fuse box.

Changes implemented up to and including May 2010

Any changes made to the vehicle after this date are not included in the manual. If necessary, refer to service bulletins.

Volvo models are sold in versions adapted for different markets. These adaptations depend on factors such as legal requirements, taxation, and market demands. This manual may therefore include illustrations and text that do not apply to the vehicles in your country.

Ordering:

Electronic Wiring Diagrams (EWD) can be ordered from the Technical Information Shop (TIS) at www.volvocarstechinfo.ford.com

We retain the right to make modifications

Table of Contents 1:3

Vehicles with SRS (Airbag)/SIPS bag/

IC (Inflatable curtain) ..................................................... 2

Abbreviations................................................................. 6

How to use the wiring diagrams 1:2............................... 7

Electrical distribution 1:2................................................ 9

Fuses

Engine compartment distribution box F1-F10............... 11

Distribution box in engine compartment F11-F20......... 12

Distribution box in engine compartment F21-F31......... 13

Distribution box in engine compartment F32-F34......... 14

Distribution box in engine compartment F35-FH1 ........15

Main fuse box battery ...................................................16

Fuse holder midi ........................................................... 17

Central Electronic Module (CEM) F43-F48...................18

Central Electronic Module (CEM) F49-F61...................19

Central Electronic Module (CEM) F62-F69...................20

Central Electronic Module (CEM) F73-F85...................21

Central Electronic Module (CEM) F86.......................... 22

Battery PF1-PF2........................................................... 23

Relays

Ignition switch and relays............................................. 24

Distribution box in engine compartment R1-R14 ......... 25

Engine compartment.................................................... 26

Central electronic module (CEM) R15-R18 ................. 27

Central electronic module (CEM) R1-R11B................. 28

Other relays ................................................................. 29

Ground connections

Overview...................................................................... 30

31/3 - 31/10 cont.......................................................... 31

31/10 - 31/52 ............................................................... 32

31/66 - 31/80 ............................................................... 33

31/83 - 31/110 cont...................................................... 34

31/110 - 31/119 ........................................................... 35

31/131 - chassis........................................................... 36

Control modules

Overview locations....................................................... 37

Overview designations................................................. 38

Central electronic module (CEM) 1:2........................... 39

Data communication, Low speed CAN 1:2.................. 41

Data communication high speed CAN......................... 43

Data communication MOST......................................... 44

Data communication, LIN 1:2 ...................................... 45

Ignition switch (SCU) ................................................... 47

Accessory electronic module (AEM)............................ 48

Group 23 Fuel system

Engine management system, 4-Cyl. 1.6l 1:2 ............... 49

Engine management system, 4-Cyl. 2.0l 1:2 ............... 51

Engine management system, 5-Cyl. Turbo 1:2............ 53

Engine management system Diesel, 4-Cyl. 1.6l 1:2 .... 55

Engine management system Diesel, 4-Cyl. 1.6l 1:2 .... 57

Engine management system Diesel, 5-Cyl. 2.0l 1:3 .... 59

Emission control 4-Cyl. 1.6l ......................................... 62

Emission control 4-Cyl. 2.0l ......................................... 63

Emission control 5-Cyl. ................................................ 64

Group 26 Cooling system

Cooling fan................................................................... 65

Group 27 Engine controls

Cruise control 4-Cyl. .....................................................66

Cruise control 5-Cyl. .....................................................67

Start/stop function.........................................................68

Group 32 Alternator and voltage regulator

Power supply 4-Cyl...................................................... 69

Power supply 5-Cyl...................................................... 70

Group 33 Starting system

Starting system 4-Cyl................................................... 71

Starting system 5-Cyl................................................... 72

Group 35 Lighting

High and low beam ...................................................... 73

Active headlights, (Dual Xenon) S40/V50.................... 74

High and low beam, (Dual Xenon) C30/C70................ 75

Active headlight, (Dual Xenon) C30/C70 ..................... 76

Running/Parking light, Tail lights S40/V50................... 77

Running/Parking light, Tail light (Dual Xenon)

S40/V50 ....................................................................... 78

Running/Parking lights, Tail lights C30/C70................. 79

Running/Parking lights, Tail lights (Dual Xenon)

C30/C70....................................................................... 80

Brake lights S40/V50 ................................................... 81

Brake lights C30/C70................................................... 82

Reversing lights S40/V50............................................. 83

Reversing lights C30/C70 ............................................ 84

Fog lights S40/V50 ...................................................... 85

Fog lights C30/C70 ...................................................... 86

Fog lights RHD Japan S40/V50................................... 87

Fog lights RHD Japan C30/C70................................... 88

Interior lighting C30/S40/V50 1:2................................. 89

Interior lighting C70 1:2................................................ 91

Follow-me-home lighting.............................................. 93

Instrument and control illumination .............................. 94

Auxiliary lights.............................................................. 95

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 3

Table of Contents 2:3

Group 36 Additional electrical equipment

Direction indicator and hazard warning flashers

S40/V50....................................................................... 96

Direction indicator and hazard warning flashers

(Dual Xenon) S40/V50................................................. 97

Direction indicator and hazard warning flashers

C30/C70....................................................................... 98

Direction indicator and hazard warning flashers

(Dual Xenon) C30/C70 ................................................ 99

Wiper/washer windshield........................................... 100

Washer headlights..................................................... 101

Wiper/washer rear window C30/V50 ......................... 102

Rain sensor................................................................ 103

Parking assistance..................................................... 104

Keyless vehicle C30/S40/V50 1:2.............................. 105

Keyless vehicle C70 1:2 ............................................ 107

Immobilizer/Steering column lock module (SCL)....... 109

Horn ...................................................................... 110

Anti-theft alarm C30................................................... 111

Anti-theft alarm S40/V50............................................ 112

Anti-theft alarm C70................................................... 113

Alcohol lock................................................................ 114

Accessory Electronic Module (AEM) C30.................. 115

Accessory Electronic Module (AEM), S40/V50/C70 . 116

Group 37 Wiring and fuses

12V outlet C30/S40/V50 ............................................ 117

12V outlet, C70.......................................................... 118

Diagnostics system.................................................... 119

Cable harness towbar/tow hitch 4-pin S40/V50 ......... 120

Cable harness towbar/tow hitch 4-pin C30 ................ 121

Cable harness towbar/tow hitch 7-pin S40/V50 ......... 122

Cable harness towbar/tow hitch 7-pin C30/C70 ........ 123

Cable harness towbar/tow hitch 13-pin S40/V50/C70 124

Cable harness towbar/tow hitch 13-pin C30 .............. 125

Accessory USB unit (AUU) ........................................ 126

Group 38 Instruments

Driver information module.......................................... 127

Seat belt reminder C30/S40/V50............................... 128

Seat belt reminder C70.............................................. 129

Group 39 Other

Audio C30/S40/V50 ................................................... 130

Alternative connection audio S40/V50....................... 131

Audio C70.................................................................. 132

Audio High Performance/Premium Sound

C30/S40/V50 1:2 ....................................................... 133

Audio High Performance/Premium Sound C70 1:2 ... 135

Cellular phone 1:2...................................................... 137

Multimedia & Traffic information ................................ 139

Satellite radio ............................................................. 140

Navigation system, portable....................................... 141

Bluetooth.................................................................... 142

Bluetooth Handsfree, internal amplifier...................... 143

Bluetooth Handsfree, external amplifier..................... 144

Bluetooth Handsfree & AUU, internal amplifier.......... 145

Bluetooth Handsfree & AUU, external amplifier......... 146

Bluetooth Handsfree with AEM, internal amplifier,

LHD ...................................................................... 147

Bluetooth Handsfree with AEM, internal amplifier,

RHD ...................................................................... 148

Bluetooth Handsfree with AEM, external amplifier,

LHD ...................................................................... 149

Bluetooth Handsfree with AEM, external amplifier,

RHD ...................................................................... 150

Group 43 Transmission

Automatic transmission AW55-51.............................. 151

Automatic transmission AWF21................................. 152

Transmission M66...................................................... 153

Automatic transmission MPS6................................... 154

Group 59 Brake system

Brake control system & STC...................................... 155

Brake control system & DSTC ................................... 156

Group 64 Steering

Speed dependent power steering .............................. 157

Group 83 Doors and openings

Central locking front doors C30/S40/V50................... 158

Central locking rear doors S40/V50........................... 159

Central locking C70.................................................... 160

Central locking trunk lid/tailgate C30 ......................... 161

Central locking trunk lid/tailgate S40/V50 .................. 162

Central locking trunk lid/tailgate C70 ......................... 163

Central locking storage compartment C70................. 164

Child safety lock S40/V50.......................................... 165

Central locking fuel filler flap...................................... 166

Signal receiver central locking C30/S40/V50............. 167

Signal receiver central locking C70............................ 168

Power windows front doors C30/S40/V50 ................. 169

Power windows C70 .................................................. 170

Power windows rear doors S40/V50.......................... 171

Power sunroof C30/S40/V50 ..................................... 172

Power roof C70.......................................................... 173

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 4

Table of Contents 3:3

Group 84 Exterior decorative elements, etc.

Power door mirrors C30/S40/V50.............................. 174

Power door mirrors C70............................................. 175

Heated door mirrors................................................... 176

Heated rear window................................................... 177

Blind spot information system.................................... 178

Group 85 Interior equipment

Power driver’s seat with memory function LHD

S40/V50..................................................................... 179

Power driver’s seat with memory function RHD

S40/V50..................................................................... 180

Power driver’s seat with memory function LHD

C30/C70..................................................................... 181

Power driver’s seat with memory function RHD

C30/C70..................................................................... 182

Power passenger seat with memory function LHD

C30/C70..................................................................... 183

Power passenger seat with memory function RHD

C30/C70..................................................................... 184

Power driver’s seat LHD S40/V50 ............................. 185

Power driver’s seat RHD S40/V50............................. 186

Power passenger seat LHD S40/V50 ........................ 187

Power passenger seat RHD S40/V50 ....................... 188

Heated seats.............................................................. 189

Group 87 Climate control system

Climate control system PTC-elements ...................... 190

Climate control system, 4-Cyl. Gasoline 1:2.............. 191

Climate control system, Diesel 1.6l 1:2...................... 193

Climate control system, 5-Cyl. 1:2............................. 195

Parking heater, auxiliary heater ................................. 197

Relay, electric engine heater ..................................... 198

Electric engine heater Flexifuel.................................. 199

Group 88 Internal equipment

Rear-view mirror with automatic dimming.................. 200

Supplemental restraint system C30/S40/V50 1:2...... 201

Supplemental restraint system C70 1:2..................... 203

Remote control garage opening ................................ 205

Cable harness routing in vehicle

Engine harness, Gasoline 4-Cyl.1.6 ...........................258

Engine harness, Gasoline 4-Cyl.2.0 ...........................258

Engine harness, gasoline 5-Cyl. Turbo.......................259

Engine harness, Diesel 1.6l ........................................259

Engine harness, Diesel 1.6l ........................................260

Harness engine, Diesel 2.0l ........................................260

Engine compartment harness, 4-Cyl...........................261

Engine compartment harness, 5-Cyl...........................261

Harness dashboard, LHD ...........................................262

Harness Dashboard, RHD ..........................................262

Floor harness, C30 LHD .............................................263

Floor harness, C30 RHD.............................................264

Floor harness, S40 LHD .............................................265

Floor harness, S40 RHD.............................................266

Floor harness, V50 LHD .............................................267

Floor harness, V50 RHD.............................................268

Floor harness, C70 LHD .............................................269

Floor harness, C70 RHD.............................................270

Roof harness, C30......................................................271

Roof harness, S40 ......................................................271

Roof harness, V50 ......................................................272

Roof harness, C70......................................................272

Tunnel harness, C30/S40/V50....................................273

Tunnel harness, C70 ..................................................273

Driver’s door harness, C30 .........................................274

Passenger door harness, C30 ....................................274

Driver’s door harness, S40/V50..................................275

Passenger door harness, S40/V50.............................275

Driver’s door harness, C70 .........................................276

Driver’s door harness supplement, C70......................276

Passenger door harness, C70 ....................................277

Passenger door harness supplement, C70.................277

Harness rear door, right S40/V50 ...............................278

Harness rear door, left S40/V50 .................................278

Rear side panel harness, left C70...............................279

Rear side panel harness, right C70 ............................279

Trunk lid/tailgate harness, C30 ...................................280

Trunk lid/tailgate harness, S40 ...................................280

Trunk lid/tailgate harness, V50 ...................................281

Trunk lid/tailgate harness, C70 ...................................281

Connectors .............................................. 206

Branching points .....................................246

Component illustrations ..........................282

Index 1:2 ....................................................340

List of components 1:7 ............................342

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 5

Explanations Abbreviations

Groups

Group 23 = Fuel system Group 26 = Cooling system Group 27 = Engine controls Group 32 = Alternator and voltage regulator Group 33 = Starting system Group 35 = Lighting Group 36 = Additional electrical equipment Group 37 = Wiring and fuses Group 38 = Instruments Group 39 = Other Group 43 = Transmission Group 59 = Brake system Group 64 = Steering Group 83 = Doors and openings Group 84 = Exterior decorative elements, etc. Group 85 = Interior equipment Group 87 = Climate control system Group 88 = Internal equipment

Designations ignition switch

X = Accessories (audio position) S = Powered upon insertion of key 15 = Contact remains connected during

start 15l = Contact is broken while starting 30 = Constant power from the battery 50 = Start

Countries/Markets

A = Austria AUS = Australia B = Belgium CDN = Canada CH = Switzerland D = Germany DK = Denmark E= Spain EU/OS = Markets outside USA and Canada FIN = Finland GB = Great Britain ISR = Israel J = Japan KOR = Korea N= Norway NL = Netherlands S = Sweden USA = United States of America WEU = Western Europe

Other

ACC = Accessories Ag = Silver plated Au = Gold plated AUTO = Automatic transmission AWD = All wheel drive CAN = CAN communication D = Diesel DPY = Display ECC = Electronic climate control system ETA = Throttle unit EXT. X = Extended X-feed GDL = Gas discharge lamp HISPEED = High speed data bus IR = Infrared sensor LIN = LIN communication LHD = Left-hand drive LOSPEED = Low speed data bus MAN = Manual transmission MEMORY = Memory driver’s seat MMS = Mass Movement Sensor PETROL = Gasoline RHD = Right-hand drive SCR = Screened SRS = Airbag T = Turbocharged engine W/O = Without 2WD = Two-wheel drive 4CYL, I4 = 4-cylinder engine 5CYL, I5 = 5-cylinder engine

Colors

BK, SB = Black BN = Brown BU, BL = Blue GN = Green GY, GR = Gray LGN = Light Green OG, OR = Orange PK, P = Pink RD, R = Red VT, VO = Violet WH, W = White YE, Y = Yellow

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 6

How to use the wiring diagrams 1:2

The descriptions below apply in general to all wiring diagram manuals, although not all sections are necessarily contained in this manual.

A. Component designation

Every component has a component designation that consists of two parts.

The first part is a type number that describes the type of component in question, for example 3/xx.

The second part of the designation is a serial number, e.g. x/2.

Together, this constitutes a component designation, e.g. 3/2.

At the end of the manual is a list of components, where, with the help of the component designation, you can read off the name of the component, for example, 3/2 = light switch.

List of type numbers

The list shows which type of component that respective type numbers refer to, for example, 3/x = switch, 6/x = electric motor, etc.

1 Battery 2Relay 3 Switch 4 Control module 5 Driver information module 6 Electric motor 7Sensor 8 Actuator 9 Heating element 10 Light 11 Fuse 15 Electrical distribution rail/box 16 Audio 17 Service/diagnostics 18 Contact reel 19 Meter 20 Ignition component/shunt 27 Optics 31 Ground connection 63 Branching point 64 Connector

The systems are shown in non-active status. i.e. with "key removed" and when the doors, hatches and hood are closed.

B. Branching points

The wiring diagrams contain numbered junction points, e.g. 63/352.

This manual contains a section with a list of branching points. This list shows all the components that are connected to each branching point.

The location of the branching points is shown in the "Cable harness routing in vehicle" section.

C. Connectors

Connectors provide a bridge between two cable harnesses and are described in the "Connectors" section.

D. Electrical distribution

Operation of the fuses and relays is shown in the "Electrical distribution" section.

E. Data communication

Today’s cars contain CAN and MOST networks that transfer information. Connections to these networks are not shown in their entirety in the respective wiring diagram. Complete information on CAN and MOST communication is found in the section "Control modules".

F. Abbreviations

A number of different abbreviations are used in the manual. These are explained in the section "Abbreviations".

G. Component location

There is a section at the end of the manual in which the appearance and location of components is described in numerical order.

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 7

How to use the wiring diagrams 2:2

List of symbols

= System voltage

= Ground connection via wiring

= Ground connection in component/chassis = Screened wire

= Junction point

= Twisted cable

= Electrical connection

= Variant

= CAN communication

= CAN high data signal (CAN H)

= CAN low data signal (CAN L)

= LIN communication

= DIN cable, coaxial cable, etc.

= Data communication

= CAN communication

= MOST communication

= Connection with distribution box

= Further connection to...

= Connector between cable harnesses = Connector connected in component

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 8

Electrical distribution 1:2

F36

F34

F35

F33

F32

F10

F17

F14

BK-WH

GN-BU

2/32

R14

2/133

R13

2/35

R10

2/82

F12

F13

RD-OG

RD-GN

RD-OG

15/31

6/25

ACM

B:1

6/26

B+

B:1

A:1

12V

31/3

1/1

31/4

PF2

PF1

RD-OG

64/90=15/31A

64/91

7/51:6

8/84:1

6/114:1

64/90= 15/31A

BK-RD

64/90=15/31A

BK-BU

GN-BU

GN-YE

GN-OG

GN-YE

GN-BU

GN-YE

BK-YE

WH-BU

BK-RD

63/13

GN-YE

5 cyl

I4 Diesel

64/90= 15/31A

GN-BU

64/113

GN-BU

LIN

R12

2/14

G030184

Overview

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 9

Electrical distribution 2:2

RD-WH

RD-BK

RD-GN

RD-OG

RD-BU

RD-OG

RD-BU

CAN

CEM

4/56

LIN

BK-YE

G:11

G:18

E:29

E:9

E:30

3/1

15X

50 S

B:7

A:42

A:15

A:30

A:17

B:5

B:2

B:1

B:3

GY-BK

RD-GNYEGN-WH

64/111

G:9

E:22

E:23

E:20

E:21

RD-YE

RD-BU

RD-WH

RD-OG

BK-BU

2/182

2/34

2/22

R11

2/17

F20

F26

F30

F31

F16

F23

F18

F27

F29

F11

F21

F28

F22

F15

RD-OG

BK-WHFGN-BU

15/31

WH-BK

F24

BK-RD

64/90=15/31A

WH-BK

BK BK BK

GN-WH

OG-BU

64/90=15/31A

RD-WH

S40/V50

C70

64/90=15/31A

BK-YE

GN-YE

BK-RD

64/861

16/10

63/121

63/231

63/120

16/11

GN-WH

10/5:1 10/6:1

GN-YE

6/104:1

2/142

64/113

31/114

G030186

Overview

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 10

Fuses Engine compartment distribution box F1-F10

15/31 Distribution box in engine compartment

No. Fuse function via A

F1 4/71 Cooling fan control module - 50

F2 6/71 Electrical power steering module (EPS) - 80

F3 2/193 Relay, comfort functions

4/56 Central Electronic Module (CEM) F45 Fuse in the Central Electronic Module (CEM) F48-F49 Fuses in the Central Electronic Module (CEM) F60-F61 Fuses in the Central Electronic Module (CEM) F62-F63 Fuses in the Central Electronic Module (CEM) F68-F69 Fuses in the Central Electronic Module (CEM) F80 Fuse in the Central Electronic Module (CEM) F84-F85 Fuses in the Central Electronic Module (CEM)

F4 2/63 Relay, high beam

4/56 Central Electronic Module (CEM) F55 Fuses in the Central Electronic Module (CEM) F58-F59 Fuses in the Central Electronic Module (CEM) F74 Fuses in the Central Electronic Module (CEM) F77 Fuses in the Central Electronic Module (CEM)

F5 9/41 PTC-element - 80

F6 4/109 Glow plug control module (GCU), 5-Cyl. - 70

20/23-26 Glow plug, 4-Cyl. 2/14 60

F7 4/16 Brake Control Module (BCM), pump - 30

F8 4/16 Brake Control Module (BCM), valves - 20

F9 2/32 Main relay, engine management system

F32-F36 Fuses in the engine compartment distribution box

F10 4/31 Passenger compartment fan control module - 40

continues

2/193 2/193 2/193 2/193

2/193 2/193

2/63

2/32

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 11

Fuses Distribution box in engine compartment F11-F20

15/31 Distribution box in engine compartment

No. Fuse function via A

F11 2/182 Relay, headlight washer motor

4/59 Convertible Roof Module (CRM), C70 6/104 Pump, high pressure headlight washer

F12 2/82 Relay, heated rear window

9/2 Heated rear window

F13 6/25 Starter motor 2/35 30

F14 4/110 Trailer Module (TRM) - 40

F15 4/59 Convertible Roof Module (CRM), C70 30

F16 2/159 Infotainment relay, S40/V50/C30

16/105 Audio module (AUD), S40/V50/C30 F22 Fuse, Distribution box in engine compartment, S40/V50/C30 F43 Fuse in the Central Electronic Module (CEM), S40/V50/C30 F64 Fuse in the Central Electronic Module (CEM), S40/V50/C30 F65-F67 Fuses in the Central Electronic Module (CEM), S40/V50/C30

F17 6/1 Wiper Motor Module (WMM) - 30

F18 2/80 Relay, reversing lights

2/89 Relay, interior lighting 4/56 Central Electronic Module (CEM) F46-F47 Fuses in the Central Electronic Module (CEM) F56-F57 Fuses in the Central Electronic Module (CEM) F79 Fuse in the Central Electronic Module (CEM) F81-F83 Fuses in the Central Electronic Module (CEM) F86 Fuse in the Central Electronic Module (CEM)

F20 2/17 Relay, horn

16/10 Horn 1 16/11 Horn 2

continues

2/182

2/82, 16/141

2/159

2/89

2/80

2/89

2/17 2/17

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 12

Fuses Distribution box in engine compartment F21-F31

15/31 Distribution box in engine compartment

No. Fuse function via A

F21 4/7 Combustion Preheater Module (CPM) - 20

F23 4/28 Transmission Control Module (TCM), MPS6 - 15

4/28 Transmission Control Module (TCM), 5-Cyl. - 10

4/28 Transmission Control Module (TCM), AWF21 -

F24 9/32 PTC resistor, crankcase ventilation, 5-Cyl. Diesel

9/38 Heated fuel filter, 5-Cyl. Diesel

F25 1/3 Secondary battery, 1.6l Diesel

4/56 Central Electronic Module (CEM), 1.6l Diesel

F26 2/35 Relay, starter motor

3/1 Start Control Module (SCU) 4/56 Central Electronic Module (CEM) F44 Fuse in the Central Electronic Module (CEM) F51-F54 Fuses in the Central Electronic Module (CEM) F73 Fuse in the Central Electronic Module (CEM)

F27 8/3 Electromagnetic clutch, climate control system 2/22 10

F29 2/34 Relay, front fog lights

10/5 Fog light, front left 10/6 Fog light, front right

F30 4/46 Engine control module (ECM), 1.6l Gasoline - 3

6/73 Coolant pump, 1.6l Diesel 2/239 10

F31 6/26 Alternator, 4-Cyl. - 10

continues

2/142 2/142

-10

3/1

3/1 3/1 3/1 3/1

2/34 2/34

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 13

Fuses Distribution box in engine compartment F32-F34

15/31 Distribution box in engine compartment

No. Fuse function via A

F32 2/14 Relay, glow plug system

6/143 Regulator motor, Turbo 7/15 Front heated oxygen sensor, 4-Cyl. 7/17 Mass air flow sensor (MAF), 5-Cyl. Diesel 7/82 Rear heated oxygen sensor, 4-Cyl. 8/6-8/10 Injection valves, 5-Cyl. 8/11 Control valve fuel flow 8/122 Bypass valve, intercooler, 1.6l Diesel

F33 2/133 Relay vacuum pump

4/46 Engine Control Module (ECM), 5-Cyl. Diesel 6/114 Vacuum pump, 5-Cyl. 7/15 Front heated oxygen sensor, 5-Cyl. 7/82 Rear heated oxygen sensor, 5-Cyl. Turbo 8/84 Switch, vacuum pump 9/38 Heated fuel filter, 4-Cyl. Diesel

F34 2/35 Relay starter motor, 1.6l Diesel

2/242 Battery relay, 1.6l Diesel 2/243 Secondary battery relay, 1.6l Diesel 2/239 Relay coolant pump, 1.6l Diesel 4/46 Engine control module (ECM), 1.6l Diesel 4/109 Glow plug control module (GCU), 5-Cyl. 7/15 Front heated oxygen sensor 4-Cyl. 8/6-8/9 Injection valves, 1.6l. 8/111 Fuel flow control valve, 1.6l Diesel 8/119 Pressure monitor, climate control system, 5-Cyl. 8/120 EGR valve, 5-Cyl. Diesel 8/133 Control valve fuel pressure 20/3 -20/7 Spark plug and ignition coil 20/17 Transformer, ignition coils, 1.6l.

continues

2/133

2/247

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 14

Fuses Distribution box in engine compartment F35-FH1

15/31 Distribution box in engine compartment

No. Fuse function via A

F35 2/22 Relay, climate control system

4/46 Engine Control Module (ECM), 5-Cyl. Diesel 6/67 Fuel leakage control pump, 5-Cyl. 6/99 Engine EGR, 1.6l Diesel 7/17 Mass air flow sensor (MAF), 5-Cyl. Gasoline, 4-Cyl. Diesel 8/18 EVAP valve, Gasoline 8/19 Solenoid, variable valve timing, intake, 5-Cyl. Gasoline 8/28 Turbocharger control valve, 2.5l Turbo 8/65 Pressure switch, power steering, 1.6l 8/81 Solenoid, variable valve timing, exhaust, 2.5l Turbo 8/82 Solenoid, variable turbo geometry, 4-Cyl. Diesel 8/113 Bypass valve, EGR cooling 9/32 PTC resistor, crankcase ventilation 5-Cyl. Gasoline

F36 4/46 Engine Control Module (ECM)

7/15 Front heated oxygen sensor, 5-Cyl. Diesel 7/51 Accelerator pedal sensor

FH1 10/65 Auxiliary light, front right

10/69 Auxiliary light, front left

2/22

2/64 2/64

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 15

Fuses Main fuse box battery

15/34 Main fuse box battery

No. Fuse function via A

11M/1 6/26 Alternator

15/31 Distribution box in engine compartment

11M/2 7/240 Battery monitoring sensor (BMS) - 15

2/242

125

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 16

Fuses Fuse holder midi

15/37 Fuse holder midi

No. Fuse function via A

Cable fuse by secondary battery - 70

Cable fuse in distribution box in engine compartment - 70

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 17

Fuses Central Electronic Module (CEM) F43-F48

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F43 4/124 Accessory USB unit (AUU)

16/1 Integrated Audio Module (IAM) 16/46 RTI Display 16/60 Phone Module (PHM) 16/108 Multimedia Module (MMM) 16/147 Bluetooth Phone Module (BPM) 17/42 USB-port

F44 4/46 Engine Control Module (ECM), 5-Cyl.

4/9 Supplemental Restraint System Module (SRS)

F45 9/1 Front 12V outlet

9/25 Rear 12V outlet

F46 3/111 Switch unit, lights

5/1 Driver Information Module (DIM) 10/1 Lamp housing, front left 10/2 Lamp housing, front right 10/29 Glove compartment lighting 10/97 Courtesy lighting, left 10/102 Courtesy lighting, right

Alcohol lock

F47 4/76 Remote control unit for garage door opener

10/22 Ceiling light 10/150 Rear reading light 10/114 Vanity mirror lighting, left, not C70 10/115 Right-hand vanity mirror lighting

F48 2/16 Relay, rear window wiper

2/92 Relay, windshield washer motor 2/93 Relay, rear window washer motor 6/2 Washer pump 6/32 Rear window wiper motor

continues

2/92 2/16

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 18

Fuses Central Electronic Module (CEM) F49-F61

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F49 4/9 Supplemental Restraint System Module (SRS)

7/93 Occupant Weight Sensor (OWS), USA/CDN

F51 2/142 Relay pre-heater fuel filter

9/41 PTC-element

F52 4/16 Brake Control Module (BCM)

4/28 Transmission Control Module (TCM)

F53 6/71 Electrical power steering module (EPS) - 10

F54 4/46 Engine Control Module (ECM), 5-Cyl.

4/86 Parking Assistance Module (PAM) 4/112 Gas Discharge Lamp Module (GDL), master, left 4/113 Gas Discharge Lamp Module (GDL), slave, right 4/114 Headlamp Control Module (HCM) 10/1 Lamp housing, front left 10/2 Lamp housing, front right

F55 4/93 Keyless Vehicle Module (KVM) - 20

F56 4/119 Remote Keyless Entry (RKE)/Remote Receiver Module (RRX)

16/35 Siren Control Module (SCM)

F57 3/9 Contact brake light

17/13 Data link connector

F58 2/64 Relay, auxiliary lights

4/113 Gas Discharge Lamp Module (GDL), slave, right 10/2 Lamp housing, front right

F59 4/112 Gas Discharge Lamp Module (GDL), master, left

10/1 Lamp housing, front left

F60 9/12 Seat Heating Module (SHM), driver’s side - 15

F61 9/13 Seat Heating Module (SHM), passenger side - 15

continues

3/60

7.5

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 19

Fuses Central Electronic Module (CEM) F62-F69

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F62 4/33 Sunroof control module - 20

F63 3/129 Right rear door module (RDM) - 20

F64 10/245 Lock indicator, left door, C70

10/246 Lock indicator, right door, C70 16/145 Remote Digital Audio Receiver (RDAR)

F65 2/157 Relay, subwoofer control module

7/182 Remote control IR sensor, RTI 16/46 RTI Display 16/105 Audio module (AUD) 16/150 AM/FM antenna and amplifier, right rear fender, C70 16/150 Window antenna amplifier, left, C30

F66 3/112 Climate Control Module (CCM)

3/281 Infotainment Control Module (ICM) 16/1 Integrated Audio Module (IAM)

F68 3/254 Steering Wheel Module (SWM) - 5

F69 3/112 Climate Control Module (CCM)

3/286 Switch BLIS/PAS/DRIVe 6/48 Damper Motor Module (DMM), recirculation 6/95 Damper Motor Module (DMM), temperature, left side 6/96 Damper Motor Module (DMM), temperature, right side 6/102 Damper Motor Module (DMM), defroster 6/103 Damper Motor Module (DMM), floor/ventilation 7/149 Rain Sensor Module (RSM) 7/159 Air Quality Sensor (AQS)

continues

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 20

Fuses Central Electronic Module (CEM) F73-F85

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F73 3/117 Switch unit, ceiling light

3/217 Contact, LH rear belt buckle 3/218 Contact, center rear belt buckle 3/219 Contact, RH rear belt buckle 4/33 Sunroof control module 8/48 Auto-dimming rearview mirror 10/22 Ceiling light

F74 4/83 Fuel pump control module, Gasoline

4/111 Additive Dosing Module (ADM) 6/33 Fuel pump

F77 4/78 Accessory electronic module (AEM)

17/19 12V outlet, cargo compartment 17/39 13-pin outlet, tow hitch cable harness

F79 8/48 Auto-dimming rearview mirror

10/48 Right-hand reversing light 10/55 Left-hand reversing light

F81 3/128 Left rear door module (LDM) - 20

F82 3/127 Passenger Door Module (PDM) - 25

F83 3/126 Driver Door Module (DDM) - 25

F84 3/27 Switch unit, power passenger seat

4/54 Power Seat Module (PSM)

F85 3/26 Switch unit, power driver’s seat

4/52 Power Seat Module (PSM)

continues

2/23 2/23

2/23, 26/5

2/80

-25

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 21

Fuses Central Electronic Module (CEM) F86

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F86 3/26 Switch unit, power driver’s seat

3/27 Switch unit, power passenger seat 3/268 Load assistance switch 4/52 Power Seat Module (PSM) 4/54 Power Seat Module (PSM) 10/24 Cargo compartment lighting 10/25 Ceiling light, cargo compartment 10/26 Reading light, rear left 10/27 Reading light, rear right 10/114 Vanity mirror lighting, left, C70

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 22

Fuses Battery PF1-PF2

1/1 Battery

No. Fuse function via A

PF1 6/25 Starter motor

6/26 Alternator

PF2 F1-F14 Fuses in the engine compartment distribution box

F16-F18 Fuses in the engine compartment distribution box F20-F21 Fuses in the engine compartment distribution box F23-F24 Fuses in the engine compartment distribution box F26-F27 Fuses in the engine compartment distribution box F29-F31 Fuses in the engine compartment distribution box

150

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 23

Relays Ignition switch and relays

Relays, general

The diagram indicates two or three different designations for the relay’s position. This is described below.

ABC

1(86)

2(85)

5(87)

A = Corresponds to the position on the back

of the relay box (wiring side)

1 3(30)

B = Corresponds to the position on the relay C = An old designation that may be found on

the relay

4(87a) 5

G041236

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 24

Relays Distribution box in engine compartment R1-R14

15/31 Distribution box engine compartment

Pos Relay function

R1 2/239 Relay coolant pump

R2 2/17 Relay, horn

R3 2/133 Relay vacuum pump

R4 2/34 Relay, front fog lights

R5 2/142 Relay pre-heater fuel filter

R6 2/247 Relay autostart

R7 2/243 Secondary battery relay

R9 2/182 Relay, headlight washer motor

R10 2/82 Relay, heated rear window

R11 2/22 Relay, climate control system

R12 2/14 Relay, glow plug system

R13 2/35 Relay, starter motor

R14 2/32 Main relay, engine management system

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 25

Relays Engine compartment

Relay in extra holder engine compartment

Relay function

2/242 Battery relay

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 26

Relays Central electronic module (CEM) R15-R18

4/56 Central Electronic Module (CEM)

Pos Relay function

R15 2/23 Fuel pump relay, Gasoline

R18 2/193 Relay, comfort functions

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 27

Relays - soldered Central electronic module (CEM) R1-R11B

4/56 Central Electronic Module (CEM)

Pos Relay function

R1 2/89 Relay, interior lighting

R2 2/80 Relay, reversing lights

R7A 2/92 Relay, windshield washer motor

R7B 2/93 Relay, rear window washer motor

R8 2/63 Relay, high beam

R11A 2/16 Relay, rear window wiper

R11B 2/159 Relay, infotainment

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 28

Relays Other relays

Relays accessories

Pos Relay function

Dashboard 2/64 Relay, auxiliary lights

By climate control system

Cargo compartment

Front member

2/71 Relay cellular phone handsfree, internal amplifier

2/71 Relay cellular phone handsfree, external amplifier 2/157 Relay, subwoofer control module

2/192 Relay, electric engine heater

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 29

31/3

31/80

31/132

Ground connections Overview

TP 39178202 C30/S40 (04-)/V50/C70 (06-) 2011 30

+ 318 hidden pages