Volvo C30 2007 User Manual

VOLVO C30

WIRING DIAGRAM 2007

TP 39103202

Vehicles with SRS (Airbag)/SIPS bag/IC

(Inflatable Curtain)

Warning!

Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC in order to avoid:

1. Personal injuries when performing repair work.

2. Damage or malfunction of the SRS/SIPS bag/IC system. Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo workshop. In case of doubt, consult the SRS and SIPS bag/IC service manual.

Is the vehicle equipped with SRS/SIPS bag/IC?

Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the dashboard above the glove compartment. SRS vehicles from 1993 and onward also have explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).

General recommendations

• Be especially careful when working on or around SRS, SIPS, and IC components.

• Make sure that no wires are pinched, frayed, or pierced.

• Never install accessories by the sensors.

• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done in accordance with the methods in the SRS section of VIDA.

• Certain components of the aforementioned systems must be grounded while working. Read the appropriate sections in VIDA.

• Install no accessories in the areas between the A and B posts, the B and C posts, and the C and D posts.

Test terminal

Data link connector in the passenger compartment.

Changes introduced up to September 2006

Any changes made to the vehicles after this date are not included in the manual. If necessary refer to service bulletins.

Volvo models are sold in versions adapted for different markets. These adaptations depend on factors such as legal requirements, taxation, and market demands. This manual may therefore include illustrations and text that do not apply to the vehicles in your country.

Order number TP 39103202

Replaces previous publication 39103201 concerning Electronic Wiring Diagram (EWD) TP 39107201 Can also be found on Electronic Wiring Diagram (EWD) TP 39110201

Table of Contents 1:3

Vehicles with SRS (Airbag)/SIPS bag/IC

(Inflatable Curtain).................................. ... .................... 2

Abbreviations................................................ ... ... ........... 7

How to use the wiring diagrams 1:2............................... 8

Electrical distribution 1:2.............................................. 10

Fuses

Engine compartment distribution box F1-F10...............12

Engine compartment distribution box F11-F18.............13

Engine compartment distribution box F20-F31.............14

Engine compartment distribution box F32-F34.............15

Engine compartment distribution box F35-F36.............16

Distribution box in engine compartment FH1................17

Central Electronic Module (CEM) F43-F49...................18

Central Electronic Module (CEM) F51-F63...................19

Central Electronic Module (CEM) F64-F74...................20

Central Electronic Module (CEM) F79-F86...................21

Battery PF1-PF2...........................................................22

Fuses in holder.............................................................23

Relays

Ignition switch and relays............................................. 24

Distribution box in engine compartment R2-R14......... 25

Central Electronic Module (CEM) R15-R18................. 26

Central Electronic Module (CEM) R1 - R11B.............. 27

Relays - accessories.................................................... 28

Ground connections

Overview...................................................................... 29

31/3 - 31/10 ................................................................. 30

31/11 - 31/52 ............................................................... 31

31/66 - 31/67 ............................................................... 32

31/80 - 31/89 ............................................................... 33

31/110 - 31/119 ........................................................... 34

Ground connections in chassis.................................... 35

Control modules

Overview of locations................................................... 36

Overview of designations............................................. 37

Central Electronic Module (CEM)1:2 ......................... 38

Data communication, Low speed CAN 1:2 ................ 40

Data communication, High speed CAN ..................... 42

Data communication MOST ...................................... 43

Data communication LIN 1:2 ..................................... 44

Start Control Module (SCU) ....................................... 46

Group 23 Fuel system

Engine management system Diesel, 5-cyl. 2.4l 1:3..... 47

Engine management system, 4-cyl. 1.6l 1:2................ 50

Engine management system, 4-cyl. 1.8l & 2.0l 1:2...... 52

Engine management system, 5-cyl. 1:2....................... 54

Engine management system, 5-cyl. Turbo 1:2 ............ 56

Engine management system Diesel, 4-cyl. 1.6l 1:2..... 58

Engine management system Diesel, 4-cyl. 2.0l 1:2..... 60

Emission control, 4-cyl. 1.6l......................................... 62

Emission control 4-cyl. 1.8l & 2.0l................................ 63

Emission control, 5-cyl................................................. 64

Emission control, 5-cyl. Turbo...................................... 65

Group 26 Cooling system

Cooling fan............................................................ ... .... 66

Cooling fan, Diesel....................................................... 67

Group 27 Engine control

Cruise control, 4-cyl...................................... ................68

Cruise control, 5-cyl...................................... ................69

Group 32 Alternator and voltage regulator

Power supply, 4-cyl...................................................... 70

Power supply, 5-cyl...................................................... 71

Group 33 Starting system

Starting system, 4-cyl................................................... 72

Starting system, 5-cyl................................................... 73

Starting system, 5-cyl. Diesel....................................... 74

Group 35 Lighting

High and low beam...................................................... 75

High and low beam (Bi-Xenon).................................... 76

Manual beam length adjustment.................................. 77

Automatic beam length adjustment (Bi-Xenon) ........... 78

Position/Parking lights, Tail lights ............................... 79

Position/Parking lights, Tail lights (Bi-Xenon) ............. 80

Fog lights ..................................................................... 81

Fog lights LHD Japan.................................................. 82

Brake light.................................................................... 83

Reversing light............................................................. 84

Follow-me-home lighting.............................................. 85

Interior lighting 1:2 ....................................................... 86

Instrument and control illumination.............................. 88

Auxiliary lights.............................................................. 89

TP 39103202 C30 2007 3

Table of Contents 2:3

Group 36 Additional electrical equipment

Direction indicator and hazard warning flashers ......... 90

Direction indicator and hazard warning flashers

(Bi-Xenon).................................................................... 91

Wiper/washer............................................................... 92

Headlight washer........................................................ . 93

Rear window wiper/washer.......................................... 94

Rain sensor.................................................................. 95

Horn ........................................................................ 96

Immobilizer/Steering column lock module (SCL) ........ 97

Keyless vehicle 1:2...................................................... 98

Rear parking assistance............................................ 100

Front parking assistance............................................ 101

Anti-theft alarm .......................................................... 102

Alcolock ..................................................................... 103

Group 37 Wiring and fuses

12V outlet ...................................... ........................... 104

Diagnostics system.................................................... 105

Tow hitch cable harness, 4-pin.................................. 106

Tow hitch cable harness, 7-pin.................................. 107

Tow hitch cable harness, 13-pin................................ 108

Group 38 Instruments

Driver information module.......................................... 109

Seat belt reminder ..................................................... 110

Group 64 Steering

Electronic power steering........................................... 122

Group 83 Doors and openings

Central locking.................................. ... ... ................... 123

Central locking, trunk lid/tailgate................................ 124

Central locking, fuel filler flap..................................... 125

Signal receiver, remote-control, central locking......... 126

Power windows.......................................................... 127

Power sunroof............................................................ 128

Group 84 Exterior decorative elements, etc.

Power rear view mirrors............................................. 129

Heated door mirrors................................................... 130

Heated rear window................................................... 131

Blind Spot Information System................................... 132

Group 85 Interior equipment

Power driver’s seat with memory function, LHD ....... 133

Power driver’s seat with memory function, RHD........ 134

Power passenger seat with memory

function, LHD ............................................................ 135

Power passenger seat with memory

function, RHD ............................................................ 136

Heated seats.............................................................. 137

Group 39 Other

Multimedia & Traffic information................................ 111

Audio 1:2 ................................................................... 112

Audio High Performance/Premium Sound 1:2........... 114

Cellular phone 1:2...................................................... 116

Satellite radio............................................................. 118

Group 43 Transmission

Automatic transmission AW55-51.............................. 119

Transmission M66 ..................................................... 120

Group 59 Brake system

Brake control system & DSTC................................... 121

Group 87 Climate control system

Climate control system, 4-cyl. Gasoline 1:2............... 138

Climate control system, 5-cyl.1:2............................... 140

Climate control system, Diesel 1.6l & 2.0l 1:2............ 142

Climate control system PTC element ....................... 144

Parking heater, auxiliary heater................................. 145

Electric engine heater Flexifuel.................................. 146

Group 88 Internal equipment

Auto-dimming rearview mirror.................................... 147

Supplemental Restraint System (SRS) 1:2................ 148

Connectors............................................... 150

Branching points .....................................175

TP 39103202 C30 2007 4

Table of Contents 3:3

Routing of the cable harnesses in the vehicle

Engine harness, Gasoline 4-Cyl 1.6 .........................184

Engine harness, Gasoline 4-Cyl 1.8 .........................184

Engine harness, Gasoline 5-Cyl.................................185

Engine harness, Gasoline 5-Cyl Turbo.......................185

Engine harness, Diesel 1.6l........................................186

Engine harness, Diesel 2.0l........................................186

Engine harness, Diesel 2.4l........................................187

Engine compartment harness, 4-Cyl. .........................188

Engine compartment harness, 5-Cyl. ........................188

Dashboard harness, LHD...........................................189

Dashboard harness, RHD................................ ...........189

Floor harness, LHD.....................................................190

Floor harness, RHD....................................................191

Roof harness ..............................................................192

Tunnel harness...........................................................192

Driver’s door harness..................................................193

Passenger door harness.............................................193

Trunk lid harness........................................................194

Component images ..................................195

Index 1:2....................................................239

List of components 1:5 ............................241

TP 39103202 C30 2007 5

TP 39103202 C30 2007 6

Explanations Abbreviations

Groups

Group 23 = Fuel system Group 26 = Cooling system Group 27 = Engine controls Group 32 = Alternator and voltage regulator Group 33 = Starting system Group 35 = Lighting Group 36 = Additional electrical equipment Group 37 = Wiring and fuses Group 38 = Instruments Group 39 = Other Group 43 = Transmission Group 59 = Brake system Group 64 = Steering Group 83 = Doors and openings Group 84 = Exterior decorative elements, etc. Group 85 = Interior equipment Group 87 = Climate control system Group 88 = Internal equipment

Ignition switch symbols

X = Accessories (audio position) S = Powered upon insertion of key 15 = Contact remains connected during

start 15l = Contact is broken while starting 30 = Constant power from the battery 50 = Start

Countries/Markets

A = Austria AUS = Australia B = Belgium CDN = Canada CH = Switzerland D = Germany DK = Denmark E= Spain EU/OS = Markets outside USA and Canada FIN = Finland GB = Great Britain ISR = Israel J = Japan KOR = Korea N= Norway NL = Netherlands S = Sweden USA = United States of America WEU = Western Europe

Other

AUTO = Automatic transmission CAN = CAN communication D = Diesel DPY = Display ECC = Electronic climate control system ETA = Engine throttle body EXT. X = Extended X-feed GDL = Gas discharge lamp HISPEED = High speed data bus IR = Infrared sensor LIN = LIN communication LHD = Left-hand drive LOSPEED = Low speed data bus MAN = Manual transmission MEMORY = Memory driver’s seat MMS = Mass Movement Sensor GASOLINE = Gasoline RHD = Right-hand drive SCR = Screened SRS = Airbag T = Turbocharged engine W/O = Without 2WD = Two-wheel drive 4CYL, I4 = 4-cylinder engine 5CYL, I5 = 5-cylinder engine

Colors

BK, SB = Black BN = Brown BU, BL = Blue GN = Green GY, GR = Gray LGN = Light Green OG, OR = Orange PK, P = Pink RD, R = Red VT, VO = Violet WH, W = White YE, Y = Yellow

TP 39103202 C30 2007 7

How to use the wiring diagrams 1:2

The descriptions below apply in general to all wiring diagram manuals, although not all sections are necessarily contained in this manual.

A. Component designation

Every component has a component designation that consists of two parts.

The first part is a type number that describes the type of component in question, for example 3/xx.

The second part of the designation is a serial number, e.g. x/2.

Together, this constitutes a component designation, e.g. 3/2.

At the end of the manual is a list of components, where, with the help of the component designation, you can read off the name of the component, for example, 3/2 = light switch.

List of type numbers

The list shows which type of component that respective type numbers refer to, for example, 3/x = switch, 6/x = electric motor, etc.

1 Battery 2Relay 3 Switch 4 Control module 5 Driver information module 6 Electric motor 7Sensor 8 Actuator 9 Heating element 10 Light 11 Fuse 15 Electrical distribution rail/box 16 Audio 17 Service/diagnostics 18 Contact reel 19 Meter 20 Ignition component/shunt 27 Optics 31 Ground connection 63 Branching point 64 Connector

B. Branching points

The wiring diagrams contain numbered junction points, e.g. 63/352.

This manual contains a section with a list of branching points. This list shows all the components that are connected to each branching point.

The location of the branching points is shown in the "Cable harness routing in vehicle" section.

C. Connectors

Connectors provide a bridge between two cable harnesses and are described in the "Connectors" section.

D. Electrical distribution

Operation of the fuses and relays is shown in the "Electrical distribution" section.

E. Data communication

Today’s cars contain CAN and MOST networks that transfer information. Connections to these networks are not shown in their entirety in the respective wiring diagram. Complete information on CAN and MOST communication is found in the section "Control modules".

F. Abbreviations

A number of different abbreviations are used in the manual. These are explained in the section "Ab breviations".

G. Component location

There is a section at the end of the manual in which the appearance and location of components is described in numerical order.

TP 39103202 C30 2007

8

How to use the wiring diagrams 2:2

7/149

RSM

LIN

3/254

5/1

EACFBD

RD-OG

1

2

A:28

2/193

30+

1

F26

2

RD

5

64/ 111

RD

3/1

B:7

30

5

50 XS

15

B:3

GN-HW

A:17

CEM

R18

5

1

4

3

CAN

2

LIN

SWM

CAN

DIM

CAN

15/31

F3

C:8

C:9

10

9

1

3

2

BK

W/O KVM

63/214

OG-BK

WH-GN

BK

4/56

H:7

H:23

D:10

E:20

1

F69

2

G:3 A:14

Explanation of symbols

= System voltage = Ground connection via wiring = Ground connection in compo-

nent/chassis = Screened wire

= Junction point = Twisted cable = Electrical connection = Variant = CAN communication = CAN high data signal

(CAN H) = CAN low data signal (CAN L)

63/108

6/1

31/110

WMM

= LIN communication

WH-GN

M

1 LHD 4 RHD

LIN

3 LHD 2 RHD

BKBK

63/25

31/10

BK

LIN

63/12

BK

CAN

31/84

= LIN communication = DIN cable, coaxial cable, etc. = Data communication = CAN communication = MOST communication = MOST communication = Connection with distribution

box

G

1

= Further connection to... = Connector between cable

harnesses

1

= Connector connected in component

7_209

TP 39103202 C30 2007 9

Electrical distribution 1:2

F

E

C

1

F36 F34

F35

F33

F32

3

2

5

3

12

3

5

12

F10

F17

F14

BK-WH

GN-BU

2/32

R14

R13

2/35

R10

2/82

F12

F13

F9

RD-OG

RD-GN

RD-OG

A

15/31

6/25

50

31

M

ACM

30

B:1

6/26

B+

31

G

B:1

A:1

RD

12V

BK

31/3

1/1

BK

31/4

PF2

PF1

RD

RD-OG

40

14

39

64/90=15/31A

8/84:1

7/51:6

64/90=15/31A

11

4

BK-RD

GY

64/90=15/31A

41

12

21

BK-BU

GN-BU

GN-YE GN-YE

GN-BU

GN-YE

B

I4

I5

Diesel

BK-RD

GN-BU

2

11

2

35

63/13

GN-YE

5 cyl

I4 Diesel

D

64/90= 15/31A

31

64/90

9

GN-BU

64/113

6

GN-BU

6

B:11 B:29

B:17

B:33

ECM

4/46.1-3

CAN

LIN

5CYL

4/31

6/1

4/110

Overview

TP 39103202 C30 2007 10

Electrical distribution 2:2

RD-WH

RD-BK

RD-GN

RD-OG

RD-BU

RD-OG

RD-BU

2

1

3

5

3

1

5

2

3

1

5

2

5

3

1

CAN

CEM

4/56

LIN

BK-YE

G:11

C

G:18

E:9

E:30

3/1

30

15X

5

50 S

B:7

A:42

A:15

A:30

A:17

B:5

B:2

B:1

B:3

GY-BK

RD-GNYEGN-WH

64/111

5

G:9

E:22

E:23

E:20

E:21

RD-YE

RD-BU

RD-WH

RD-OG

RD

BK-BU

2/182

R9

2/34

R4

2/22

R11

R2

2/17

F20

F26 F3 F30 F31 F2

F16

F6

F23

F4

F18

F27

F29

F11

F8 F7 F1 F5 F21

F28 F22

A

RD-OG

E

BK-WHFGN-BU

15/31

WH-BK

R5

F24

BK-RD

13

64/90=15/31A

RD

WH-BK

BK BK BK

GN-WH

OG-BU

23

64/90=15/31A

RD

13

17

64/90=15/31A

BK-YE

18

GN-YE

BK-RD

B

64/861

1

RD

D

GN-BU

16/10

63/121 63/120

16/11

GN-WH

10/5:1 10/6:1

GN-YE

6/104:1

3

5

12

2/142

64/113

7

31/114

I4

I5

E:29

Overview

TP 39103202 C30 2007 11

Fuses Engine compartment distribution box F1-F10

F19

F8

F30

F24 F21 F20 F22

F31 F25

F32

F33 F34 F35

F36

F29

F17

F18

F28

F15

F16

F27 F26 F23

15/31 Engine compartment distribution box

No. Fuse function via A

F1 4/71 Cooling fan control module - 50 F2 6/71 Electrical Power Steering Module (EPS) - 80 F3 2/193 Relay , comfort func tions

F45 Fuse in the Central Electronic Module (CEM) F48-F49 Fuses in the Central Electronic Module (CEM) F60-F61 Fuses in the Central Electronic Module (CEM) F62-F63 Fuses in the Central Electronic Module (CEM) F68-F69 Fuses in the Central Electronic Module (CEM) F84-F85 Fuses in the Central Electronic Module (CEM)

F4 2/63 Relay, high beam

4/56 Central Electronic Module (CEM) F55 Fuses in the Central Electronic Module (CEM) F58-F59 Fuses in the Central Electronic Module (CEM) F74 Fuses in the Central Electronic Module (CEM)

F77 Fuses in the Central Electronic Module (CEM) F5 9/41 PTC-element - 80 F6 4/109 Glow plug control module, 4-cyl. Diesel

4/109 Glow plug control module, 5-cyl. Diesel F7 4/16 Brake Control Module (BCM), pump - 30 F8 4/16 Brake Control Module (BCM), valves - 20 F9 2/32 Main relay, engine management system

F32-F36 Fuses in the engine compartment distribution box

F10 4/31 Fan control module - 40

F7

F1

F2

F11

F9

F13

F12

F10

F14

F3

F4

F5

F6

2/193 2/193 2/193

2/193

-

2/63

-

2/32

continues

60

60 70

30

TP 39103202 C30 2007 12

Fuses Engine compartment distribution box F11-F18

F19

F8

F30

F24 F21 F20 F22

F31 F25

F32

F33 F34 F35

F36

F29

F17

F18

F28

F15

F16

F27 F26 F23

15/31 Engine compartment distribution box

No. Fuse function via A

F11 2/182 Relay, headlight washer motor

6/104 Pump, high pressure headlight washer

F12 2/82 Relay, heated rear window

9/2 Heated rear window F13 6/25 Starter motor 2/35 30 F14 4/110 Trailer Module (TRM)

17/39 13-pin outlet, tow hitch cable harness F15 - -F16 2/159 Relay, infotainment

16/105 Audio Module (AUD)

F22 Distribution box in engine compartment

F43 Fuse in the Central Electronic Module (CEM)

F64 Fuse in the Central Electronic Module (CEM)

F65-F67 Fuses in the Central Electronic Module (CEM) F17 6/1 Wiper Motor Module (WMM) - 30 F18 2/80 Relay, reversing light

2/89 Relay, interior lighting

4/56 Central Electronic Module (CEM)

F46-F47 Fuses in the Central Electronic Module (CEM)

F56-F57 Fuses in the Central Electronic Module (CEM)

F79 Fuse in the Central Electronic Module (CEM)

F81-F83 Fuses in the Central Electronic Module (CEM)

F86 Fuse in the Central Electronic Module (CEM)

F7

F1

F2

F11

F9

F13

F12

F10

F14

F3

F4

F5

F6

-

20

2/182

-

30

2/82

-

40

-

30

-

2/159

-

40

-

2/89

-

2/80

-

2/89

continues

TP 39103202 C30 2007 13

Fuses Engine compartment distribution box F20-F31

F19

F8

F30

F24 F21 F20 F22

F31 F25

F32

F33 F34 F35

F36

F29

F17

F18

F28

F15

F16

F27 F26 F23

15/31 Engine compartment distribution box

No. Fuse function via A

F20 2/17 Relay, horn

16/10 Horn 1

16/11 Horn 2 F21 4/7 Combustion Preheater Module (CPM) - 20 F22 - -F23 4/28 Transmission Control Module (TCM)

4/46 Engine Control Module (ECM), 5-cyl. Gasoline F24 9/32 PTC-resistor, crankcase ventilation, 5-cyl. 2.4l Diesel

9/38 Electrically heated fuel filter F26 3/1 Start Control Module (SCU)

4/56 Central Electronic Module (CEM)

11K/2 Fuse in holder

F44 Fuse in the Central Electronic Module (CEM)

F51-F54 Fuses in the Central Electronic Module (CEM)

F73 Fuse in the Central Electronic Module (CEM) F27 8/3 Electromagnetic clutch, climate control system 2/22 10 F29 2/34 Relay, front fog lights

10/5 Fog light, front left

10/6 Fog light, front right F30 4/46 Engine control module (ECM), 4-cyl. 1.6l/2.0l Diesel - 3 F31 6/26 Alternator, 4-cyl. - 10

F7

F1

F2

F11

F9

F13

F12

F10

F14

F3

F4

F5

F6

-

15 2/17 2/17

-

10

-

2/142

20

2/142

-

15

3/1 3/1 3/1 3/1

-

15 2/34 2/34

continues

TP 39103202 C30 2007 14

Fuses Engine compartment distribution box F32-F34

F19

F8

F30

F24 F21 F20 F22

F31 F25

F32

F33 F34 F35

F36

F29

F17

F18

F28

F15

F16

F27 F26 F23

15/31 Engine compartment distribution box

No. Fuse function via A

F32 6/143 Regulator motor, Turbo

7/15 Front heated oxygen sensor, 4-cyl. 7/17 Mass airflow sensor (MAF) 7/82 Rear heated oxygen sensor, 4-cyl. 8/6-8/10 Injection valves, 5-cyl. 8/121 Coolant valve, 4-cyl., 2.0l Diesel 8/122 Rear heated oxygen sensor, 4-cyl. 1.6l Diesel

F33 4/46 Engine control module (ECM), 5-cyl. Diesel

6/114 Vacuum pump, 5-cyl. 7/15 Front heated oxygen sensor, 5-cyl. 7/82 Rear heated oxygen sensor, 5-cyl. T 7/186 Heated oxygen sensor, rear, 5-cyl. without Turbo 7/187 Heated oxygen sensor, center 5-cyl. without Turbo 8/84 Switch, vacuum pump 9/32 PTC-resistor, crankcase ventilation, 4-cyl. 2.0l 9/38 Heated fuel filter, Diesel

F34 8/6 -8/9 Injection valves, 1.6l.

8/77 Fuel volume control valve, 4-cyl. 2.0l Diesel 8/111 Fuel flow control valve, 4-cyl. 1.6l Diesel 8/113 Fuel pressure bypass valve, Man 8/119 Pressure monitor, climate control system, 5-cyl. 8/120 EGR valve 8/133 Control valve fuel pressure 20/3 -20/7 Spark plug and ignition coil 20/17 Transformer, ignition coils, 1.6l

F7

F1

F2

F11

F9

F13

F12

F10

F14

F3

F4

F5

F6

-

8/84

-

continues

10

20

10

TP 39103202 C30 2007 15

Fuses Engine compartment distribution box F35-F36

F19

F8

F30

F24 F21 F20 F22

F31

F25

F32

F33 F34 F35

F36

F29

F17

F18

F28

F15

F16

F27 F26 F23

15/31 Engine compartment distribution box

No. Fuse function via A

F35 2/22 Relay, climate control system

4/46 Engine control module (EC M), 5-cyl. Diesel 6/67 Pump, fuel leakage control 6/99 Engine EGR 7/17 Mass airflow sensor (MAF ) 7/192 Water detection sensor 8/6-8/9 Injection valves 8/18 EVAP valve 8/19 Solenoid, variable valve timing, intake 8/28 Turbocharger control valve 8/45 Solenoid, variable valve timing, intake 8/65 Power steering pressure monitor 8/81 Solenoid, variable valve timing outlet 8/82 Solenoid, variable turbo geometry, 4-cyl. Diesel 8/114 Valve mixing air/fuel, 4-cyl. 1.8l & 2.0l. 8/132 Control valve inlet 9/32 PTC-resistor, crankcase ventilation 5-cyl. Gasoline

F36 4/46 Engine Control Module (ECM)

7/15 Heated oxygen sensor, front 7/51 Accelerator pedal senso r

F7

F1

F2

F11

F9

F13

F12

F10

F14

F3

F4

F5

F6

-

2/22

-

15

10

TP 39103202 C30 2007 16

Fuses Distribution box in engine compartment FH1

FH1

FH1 Fuse in holder

No. Fuse function via A

FH1 10/65 Auxiliary lights, front right

10/69 Auxiliary lights, front left

2/64 2/64

G017864

20

TP 39103202 C30 2007 17

Fuses Central Electronic Module (CEM) F43-F49

F43

F65

F37 F42

F64

F86

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F43 16/1 Integrated Audio Module (IAM)

16/46 RTI Display 16/60 Phone Module (PHM)

16/108 Multimedia Module (MMM) F44 4/9 Supplemental Restraint System Module (SRS) - 10 F45 9/1 Front 12V outlet

9/25 Rear 12V outlet F46 3/111 Switch unit, lights

5/1 Driver Information Module (DIM)

10/1 Lamp housing, front left

10/2 Lamp housing , fro nt right

10/29 Glove compartment lighting

10/97 Courtesy lighting, left

10/102 Courtesy lighting, right F47 10/22 Ceiling light

10/150 Rear reading light

10/114 Vanity mirror lighting, left

10/115 Vanity mirror lighting, right F48 2/16 Relay, rear window wiper

2/92 Relay, windshield washer motor

2/93 Relay, rear window washer motor

6/2 Washer pump

6/32 Rear window wiper motor F49 4/9 Supplemental Restraint System Module (SRS)

7/93 Occupant Weight Sensor (OWS), USA/CDN

continues

-

3/117

-

2/92 2/93 2/16

-

15

5

15

10

TP 39103202 C30 2007 18

Fuses Central Electronic Module (CEM) F51-F63

F43

F65

F37 F42

F64

F86

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F51 2/142 Fuel filter preheater relay

4/86 Parking Assistance Module (PAM) 4/112 Gas Discharge Lamp Module (GDL), master, left 4/113 Gas Discharge Lamp Module (GDL), slave, right 9/41 PTC-element 10/1 Front left lamp housing, beam length adjustment 10/2 Front right lamp housing, beam length adjustment

F52 4/16 Brake Control Module (BCM)

4/28 Transmission control module (TCM), not Diesel F53 6/71 Electrical Power Steering Module (EPS) - 10 F54 4/28 Transmission control module (TCM), Diesel

4/46 Engine Control Module (ECM), 5-cyl. Gasoline F55 4/93 Keyless Vehicle Module (KVM) - 20 F56 16/35 Siren Control Module (SCM) - 10 F57 3/9 Contact brake light

17/13 Data link connector F58 2/64 Auxiliary light relay accessory

4/113 Gas Discharge Lamp Module (GDL), slave, right

10/2 Lamp housing , fro nt right F59 4/112 Gas Discharge La mp Module (GDL), master, left

10/1 Lamp housing, front left F60 9/12 Seat Heating Module (SHM), driver’s side - 15 F61 9/13 Seat Heating Module (SHM), passenger side - 15 F62 4/33 Sunroof control module - 20 F63 - --

continues

-

4/112 4/113

-

-10

-

3/60

-

10

5

15

7.5

TP 39103202 C30 2007 19

Fuses Central Electronic Module (CEM) F64-F74

F43

F65

F37 F42

F64

F86

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F64 16/49 Traffic Message Channel Module (TMC)

16/139 Global Positioning System Module (GPS) 16/145 Remote Digital Audio Receiver (RDAR)

F65 7/182 Remote control IR sensor, RTI

16/46 RTI Display 16/105 Audio Module (AUD) 16/150 Amplifier window antenna, left

F66 3/112 Climate Control Module (CCM)

16/1 Integrated Audio Module (IAM)

16/1.2 Infotainment Control Module (ICM) F68 3/254 Steering Wheel Module (SWM) - 5 F69 6/48 Damper Motor Module (DMM), recirculation

6/95 Damper Motor Module (DMM), left-hand side

6/96 Damper Motor Module (DMM), right-hand side

6/102 Damper Motor Module (DMM), defroster

6/103 Damper Motor Module (DMM), floor/ventilation

7/149 Rain Sensor Module (RSM)

7/159 Air quality sensor F73 3/117 Switch unit, ceiling light

3/217 Belt buckle contact, left rear

3/219 Belt buckle contact, right rear

4/33 Sunroof control module

8/48 Auto-dimming rearview mirror

10/22 Ceiling light F74 4/83 Fuel pump control module, Gasoline

6/33 Fuel pump

continues

-

2/23

2/23, 26/5

5

10

5

15

TP 39103202 C30 2007 20

Fuses Central Electronic Module (CEM) F79-F86

F43

F65

F37 F42

F64

F86

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F79 8/48 Auto-dimming rearview mirror

10/48 Reversing light, right

10/55 Reversing light, left F81 - -F82 3/1 27 Passenger Door Module (PDM) - 25 F83 3/126 Driver Door Module (DDM) - 25 F84 4/54 Power Seat Module (PSM) - 25 F85 4/52 Power Seat Module (PSM) - 25 F86 4/52 Power Seat Module (PSM)

4/54 Power Seat Module (PSM)

10/24 Cargo compartment lighting

26/5 DC/AC converter, fuel tank

2/80

-

5

TP 39103202 C30 2007 21

Fuses Battery PF1-PF2

PF1

PF2

1/1 Battery

No. Fuse function via A

PF1 6/25 Starter motor

6/26 Alternator

PF2 F1-F14 Fuses i n the en g i ne compartment distribution box

F16-F18 Fuses in the engine compartment distribution box F20-F21 Fuses in the engine compartment distribution box F23-F24 Fuses in the engine compartment distribution box F26-F27 Fuses in the engine compartment distribution box F29-F31 Fuses in the engine compartment distribution box

-

150

TP 39103202 C30 2007 22

Fuses Fuses in holder

11K/1-2

11K Fuses in holder

No. Fuse function via A

1 Alcolock -5 2 Alcolock -5

TP 39103202 C30 2007 23

Relays Ignition switch and relays

A

3

1

B

Position

4

8

Relays, general

The diagram indicates two or three different designations for the relay’s position. This is described below.

KeyOut

0

I

II

III

Terminal

30SX

X

XX

XXXXX

XX

15

50

X

ABC

2

1(86)

5(87)

2(85)

5(87)

2(85)

4

A = Corresponds to the position on the back

of the relay box (wiring side)

B = Corresponds to the position on the relay.

1

3(30)

4(87a)

4(87a) 5

3

5

3

C = An old designation that may be found on

the relay

TP 39103202 C30 2007 24

Relays Distribution box in engine compartment R2-R14

R9

R6

R7

R12

R13

R14

15/31 Engine compartment distribution box

Pos Relay function

R2 2/17 Relay, horn R4 2/34 Relay, front fog lights R5 2/142 Fuel filter preheater relay R9 2/182 Relay, headlight washer motor R10 2/82 Relay, heated rear window R1 1 2/22 Relay, climate control system R13 2/35 Relay, starter motor R14 2/32 Main relay, engine management system

R10

R11

R3 R1

R8

R2R4R5

TP 39103202 C30 2007 25

Relays Central Electronic Module (CEM) R15-R18

R18 R15

4/56 Central Electronic Module (CEM)

Pos Relay function

R15 2/23 Fuel pump relay, Gasoline R18 2/193 Relay, comfort functions

TP 39103202 C30 2007 26

Relays - soldered Central Electronic Module (CEM) R1 - R11B

4/56 Central Electronic Module (CEM)

Pos Relay function

R1 2/89 Relay, interior lighting R2 2/80 Relay, reversing light R7A 2/92 Relay, windshield washer motor R7B 2/93 Relay, rear window washer motor R8 2/63 Relay, high beam R11A 2/16 Relay, rear window wiper R11B 2/159 Relay, infotainment

TP 39103202 C30 2007 27

Relays Relays - accessories

Relays accessories

Pos Relay function

2/64 Auxiliary light relay accessory

G017857

TP 39103202 C30 2007 28

19

31/11

31/12

31/66

31/83

31/6

31/115

31/52

31/114

31/3

31/1

31/80

31/4

31/84

31/10

31/116

31/110

31/67

31/89

31/112

31/88

Ground connections Overview

TP 39103202 C30 2007 29

Ground connections 31/3 - 31/10

31/3 Left MacPherson strut tower

1/1 Battery

31/4 Engine

1/1 Battery

31/6 A-post, driver’s side

3/111 Switch unit, lig hts 4/102 Steering Column Lock Module (SCL) 10/1 Lamp housing, front left 10/2 Lamp housing, front right 17/13 Data link connector

Alcolock

31/10 A-post, passenger side

2/16 Relay, rear window wiper 2/23 Relay, fuel pump 2/63 Relay, high beam 2/64 Auxiliary light relay accessory 2/89 Relay, interior lighting 2/92 Relay, windshield washer motor 2/93 Relay, rear window washer motor 2/159 Relay, infotainment 2/193 Relay, comfort functions 3/112 Climate Control Module (CCM) 3/117 Switch unit, ceiling light 3/286 BLIS switch 4/33 Sunroof control module 4/56 Central Electronic Module (CEM) 6/2 Washer pump 6/48 Damper motor, recirculation 6/95 Damper Motor Module (DMM), left-hand side 6/96 Damper Motor Module (DMM), right-hand side 6/102 Damper Motor Module (DMM), defroster 6/103 Damper Motor Module (DMM), floor/ventilation 6/117 Interior temperature sensor 7/122 Mass Movement Sensor Module (MMS), front 7/159 Air quality sensor 8/48 Auto-dimming rearview mirror 8/134 Solenoid, reverse interlock, manual 9/1 Front 12V outlet 9/25 Rear 12V outlet 10/22 Ceiling light 10/29 Glove compartment lighting 10/114 Vanity mirror lighting, left 10/115 Vanity mirror lighting, right 16/1 Integrated Audio Module (IAM)

TP 39103202 C30 2007 30

Ground connections 31/11 - 31/52

31/11 Rear left side

3/35 Switch, handle, trunk lid/tailgate 3/78 Lock unit, trunk lid/tailgate 4/86 Parking Assistance Module (PAM) 4/110 Trailer Module (TRM) 6/32 Rear window wiper motor 10/3 License plate lighting 10/18 Lamp housing, rear left 16/105 Audio Module (AUD)

31/12 Rear right side

6/37 Lock motor, fuel filler flap 10/17 Lamp housing, rear right 10/19 Brake light extra 16/139 Global Positioning Syste m Module (GPS) 16/145 Remote Digital Audio Receiver (RDAR) 17/37 4-pin outlet, tow hitch cable harness 17/38 7-pin outlet, tow hitch cable harness 17/39 13-pin outlet, tow hitch cable harness

31/52 Left MacPherson strut tower

3/10 Reversing light contact 4/28 Transmission Control Module (TCM) 4/46 Engine Control Module (ECM) 7/24 Front knock sensor, Gasoline 7/192 Water detection sensor, Diesel 8/3 Electromagnetic clutch, climate control system, 4-cyl. 9/32 PTC resistor, crankcase ventilation 9/38 Heated fu el filter, 4-cyl. Diesel

TP 39103202 C30 2007 31

Ground connections 31/66 - 31/67

31/66 Left B-post

3/287 Rear seat entry switch, left 4/52 Power Seat Module (PSM), LHD 4/54 Power Seat Module (PSM), RHD 4/93 Keyless Vehicle Module (KVM), RHD 6/35 Fuel pump, auxiliary heater 7/101 Glass-break sensor 8/51 Igniter, side airbag, driver’s side, LHD 8/52 Igniter, side airbag, passenger side, RHD 8/92 Lap belt tensioner, driver, LHD 9/2 Heated rear window 9/12 Seat Heati ng Module (SHM), driver’s side, LHD 9/13 Seat Hea ti ng Module (SHM), passenger side, RHD

31/67 Right B-post

3/288 Rear seat entry switch, right 4/52 Power Seat Module (PSM), RHD 4/54 Power Seat Module (PSM), LHD 4/93 Keyless Vehicle Module (KVM), LHD 7/93 Occupant Weight Sensor (OWS), USA/CDN 8/51 Igniter, side airbag, driver’s side, RHD 8/52 Igniter, side airbag, passenger side, LHD 8/92 Drive r’s lap belt tensioner, RHD 9/12 Seat Heati ng Module (SHM), driver’s side, RHD 9/13 Seat Hea ti ng Module (SHM), passenger side, LHD

TP 39103202 C30 2007 32

Ground connections 31/80 - 31/89

31/80 Left MacPherson strut tower

4/16 Brake Control Module (BCM), valves

31/83 A-post, driver’s side

3/1 Ignition switch 3/6 Switch, hazard warning flashers 3/254 Steering Wheel Module (SWM) 4/103 Remote Receiver Module (RRX) 5/1 Driver Information Module (DIM) 17/13 Data link connector

31/84 A-post, passenger side

4/56 Central Electronic Module (CEM) 7/51 Accelerator pedal sensor 7/149 Rain Sensor Module (RSM) 8/31 Airbag ign iter, passenger side 8/32 Ignite r, airbag stage 2, passenger side 16/1 Integrated Audio Module (IAM) 16/1.2 Infotainment Control Module (ICM) 16/46 RTI Display 16/60 Phone Module (PHM) 16/108 Multimedia Module (MMM)

31/88 Engine

9/32 PTC resistor, crankcase ventilation 20/3 Spark plug and ignition coil 20/4 Spark plug and ignition coil

31/89 Engine

20/5 Spark plug and ignition coil 20/6 Spark plug and ignition coil 20/7 Spark plug and ignition coil

TP 39103202 C30 2007 33

Ground connections 31/110 - 31/119

31/110 Right MacPherson strut tower

3/271 Contact, immobilizer, clutch pedal 4/7 Combustion Preheater Module (CPM) 4/113 Control module, gas discharge lamp slave, right 6/1 Wiper Motor Module (WMM) 6/28 Motor, passenger compartment fan 6/104 Pump, high pressure headlight washer 7/4 Brake fluid level sensor 7/5 Washer fluid level sensor 8/119 Pressure monitor, climate control system 8/127 Pressure switch, climate control system, Diesel 10/2 Lamp housing, front right 10/6 Fog light, front right

31/112 Right MacPherson strut tower

9/41 PTC-element

31/114 Left MacPherson strut tower

3/62 Ho od alarm contact 4/71 Co oling fan control module 4/109 Glow plug control module, Diesel 4/112 Gas Discharge Lamp Module (GDL), master 6/71 Elec trical Power Steering Module (EPS) 6/114 Vacuum pump, 5-cyl. Gasoline 10/1 Lamp housing, front left 10/5 Fog light, front left 16/10 Horn 1 16/11 Horn 2 16/35 Siren Control Module (SCM)

31/115 Left A-post

3/126 Driver Door Module (DDM), LHD 4/83 Fuel pump control module, RHD, Gasoline 4/111 Additive Dosing Module (ADM), RHD 6/33 Fuel pump, RHD 9/38 Heated fu el filter, RHD, 5-cyl. Diesel

31/116 Right A-post

3/127 Passenger Door Module (PDM), LHD 4/83 Fuel pump control module, LHD, Gasoline 4/111 Additive Dosing Module (ADM), LHD 6/33 Fuel pump, LHD 9/38 Heated fu el filter, LHD, 5-cyl. Diesel

31/119 Left MacPherson strut tower

4/16 Brake Control Module (BCM)

TP 39103202 C30 2007 34

Ground connections Ground connections in chassis

Grounded directly to chassis

3/4 Switch unit, cruise control (SWS) 3/37 Co ntact horn 3/47 Parking brake contact 4/9 Supplemental Restraint System Module (SRS) 4/56 Central Electronic Module (CEM) 6/25 Starter motor 7/6 Sensor, coolant temperature 8/3 Electromagnetic clutch, climate control system, 5-cyl. 8/33 Ignite r, belt tensioner, driver’s side 8/34 Ignite r, belt tensioner, passenger side 8/55 Igniter, left rear belt tensioner 8/56 Igniter, right rear belt tensioner 8/128 Driver’s belt force limiter 8/129 Passenger belt force limiter 16/16 Amplifier window antenna, right 16/49 Traffic Message Channel Module (TMC) 16/150 Amplifier window antenna, left 18/4 Contact reel 20/22-25 Glow plug

TP 39103202 C30 2007 35

Control modules Overview of locations

SRS

KVM

PSM

RKE

SHM

DDM

LCM

SCL

SWM

RRX

RSM

BCM

DIM

AQS

GDL

ECM

DMM

TCM

WMM

SCM

ACM

GDL

CPM

EPS

MMM

CEM

SCU

RCM

ADM

PAM

TRM

IAM

PDM

ICM

PHM

CCM

GSM

TP 39103202 C30 2007 36

GPS

AUD

TMC

OWS

SHM

BSC

Control modules Overview of designations

Unit Designation

ACM 6/26 Alternator Control Module (ACM) ADM 4/111 Additive Dosing Module (ADM)

AQS 7/159 Air Quality Sensor (AQS) AUD 16/105 Audio Mo dule (AUD)

BCM 4/16 Brake Control Module (BCM)

BSC 7/164 Body Sensor Cluster Stability Sensor (BSC) CCM 3/112 Climate Control Module (CCM) CEM 4/56 Central Electronic Module (CEM) CPM 4/7 Combustion Preheater Module (CPM) DDM 3/126 Driver Door Module (DDM)

DIM 5/1 Driver Information Module (DIM)

DMM Damper Motor Module (DMM)

-6/48 Damper Motor Module (DMM), recirculation

-6/95 Damper Motor Module (DMM), left-hand side

-6/96 Damper Motor Module (DMM), right-hand side

-6/102 Damper Motor Module (DMM), defroster

-6/103 Damper Motor Module (DMM), floor/ventilation

ECM 4/46 Engine Control Module (ECM)

EPS 6/71 Electrical Power Steering Module (EPS)

GDL Gas Discharge Lamp Module (GDL)

-4/112 Gas Discharge Lamp Module (GDL), master, left

-4/113 Gas Discharge Lamp Module (GDL), slave, right

GPS 16/139 Global Positi oning System Module (GPS) GSM 3 /156 Gear Selector Module (GSM)

IAM 16/1 Integrated Audio Module (IAM)

ICM 16/1.2 Infotainment Control Module (ICM) KVM 4/93 Keyless Vehicle Module (KVM) LCM 4/126 Left Camera Module (LCM)

MMM 16/108 Multimedia Module (MMM)

OWS 7/93 Occupant Weight Sensor (OWS)

PAM 4/86 Parking Assistance Module (PAM)

PDM 3/127 Passenger Door Module (PDM) PHM 16/60 Phone Modul e (PHM)

PSM 4/52 Power Seat Module (PSM)

4/54 Power Seat Module (PSM)

RCM 4/127 Right Camera Module (RCM)

RKE 4/103 Remote Keyless Entry (RKE) RRX 4/103 Remote Receiver Module (RRX)

RSM 7/149 Rain Sensor Module (RSM)

SCL 4/102 Steering Column Lock Module (SCL)

SCM 16/35 Siren Control Module (SCM)

SCU 3/1 Start Control Module (SCU)

SHM Seat Heating Module (SHM)

-9/12 Seat Heating Module (SHM), driver’s side

-9/13 Seat Heating Module (SHM), passenger side

SRS 4/9 Supplemental Restraint System Module (SRS)

SWM 3/254 Steering Wheel Module (SWM)

TCM 4/28 Transmission Control Module (TCM) TMC 16/49 Traffic Message Channel Module (TMC) TRM 4/110 Trailer Module (TRM)

WMM 6/1 Wiper Motor Module (WMM) 17/13 17/13 Data link connector

TP 39103202 C30 2007 37

B:12

B:11

A:32

G:18

G:9

H:22

H:1

D:3

C:4

C:3

A:25

G:2

C:14

B:6

C:6

B:3

H:6

A:41

E:37

E:25

C:2

H:21

E:10

C:12

C:13

B:5

C:7

D:5

B:14

A:1

B:10

E:13

E:39

E:38

D:4

C:9

H:23

B:17 G:26

G:3

C:10

A:40

H:2

B:1

G:1

A:35

A:33

E:9

E:40

C:26

G:11

C:8

C:45

H:5

C:20

A:7

A:38

C:11

D:7

D:9

D:12

C:38

E:29

C:39

A:3

E:1

E:2

E:3

A:10

F:12

B:26

A:34

B:27

F:20

F:21

F:18

F:19

G:21

G:12

G:23

A:15

F:28

F:31

B:21

B:22

B:23

G:27

B:19

B:2

B:4

F:7

F:5

G:28

F:24

F:22

B:28

B:30

G:19

A:42

E:14

E:41

H:18

H:20

H:19

B:18

B:32

F:1

F:3

F:2

F:13

F:17

B:31

B:29

A:39

A:17

F44 F52

F53

F54 F51

F47 F86

F46

B

A

F79

2/89

R1

2/80

R2

4/56

15+

CEM

CAN

LIN

Control modules Central Electronic Module (CEM)1:2

TP 39103202 C30 2007 38

A:19

C:23

D:14

C:29

C:30

C:44

A:9

A:4

C:24

C:31

C:25

A:18

E:36

A:8

C:16

E:28

C:17

C:40

A:29

A:21

C:27

C:41

G:30

D:8

E:11

E:27

C:21

E:8

A:14

D:10

A:28

E:12

A:45

H:7

31/10

63/25

BK BK

31/84

63/12

BK BK

A:44

C:46

A:43

C:37

C:42

C:43

C:28

A:23

C:22

E:30

C:33

C:34

G:32

G:16

H:24

H:8

H:4

C:18

A:16

B:25

B:24

F:15

F:30

G:14

G:15

B:9

B:8

F:14

F:16

B:15

B:16

F56 F83 F82 F57 F43 F64 F85

F84

F62

F66 F65

F67

R11B

2/159

R15

2/23

F81

F63

F74

E:23

E:20

H:3

C:32

2/93

2/92

2/63

R7B

R7A

R8

2/193

R18

E:22

F55

F58

F59

F68

F69

F80

F49

F61

F60

F45

F77

2/16

R11A

B

A

F48

F73

30+ (4)

30+ (3)

30+ (2)

E:18

30+ (5)

E:21

30+ (1)

A:30

X+

G:29

F:25

F:9

C:1

G:24

G:13

G:6

G:22

G:7

G:31

H:17

B:13

3

12

5 4

4/56

CEM

CAN

LIN

4 5

1

2

Control modules Central Electronic Module (CEM) 2:2

TP 39103202 C30 2007 39

16/60

PHM

7

4

#

1

CAN

0

586

9

23

A:3

A:12

3/127

CAN

PDM

A:4

CAN

A:5

4/7

CPM

CAN

4/52

4/54

PSM

CAN

3/126

DDM

CAN

SRS

4/9

10

1

CAN

7/93

OWS

B:16

B:15

4/56

CAN

CEM

B:9

B:8

GY-BK

BU-YE

BU-RD

GY-RD

11

17/13

CAN

3

BU-RD

GY-RDG:16

G:32

A:11

A:12

BU-BK

B:25

GY-OG

B:24

BU-RD

A:53

A:56

GY-RD

63/221

GY-RD

BU-RD

GY-RD

A:3

A:12

64/43

2

1

A:51

A:52

BU-YE

GY

GN

WH

-BK

63/220

1

2

64/41

63/228

63/232

63/233

63/229

BU-RD

GY-RD

F:30 F:15

A B

4/93

CAN

KVM

B:4

B:3

B:4

LIN

RHD

BU-RD

RHD

GY-RD

A:14

A:7

B:1

B:2

CAN

4/86

PAM

CAN

4/110

TRM

64/322

63/421

63/422

BU-RD

GY-RD

GN

WH

GY-RD

BU-RD

GY-RD

BU-RD

GY-RD

BU-RD

GY-RD

BU-RD

RHD

LHD

RHD

LHD

BU-RD

GY-RD

BU-RD

GN

WH

1 2

64/31

64/30

12

11

10

9

64/31

CAN

PSM

B:3

B:4

GN

WH

12

4X/110B

1 2

16/60

PHM

7

4

#

1

CAN

0

586

9

23

A:3

A:12

3/127

CAN

PDM

A:4

CAN

A:5

4/7

CPM

CAN

4/52

4/54

PSM

CAN

3/126

DDM

CAN

SRS

4/9

10

1

CAN

7/93

OWS

B:16

B:15

4/56

CAN

CEM

B:9

B:8

GY-BK

BU-YE

BU-RD

GY-RD

11

17/13

CAN

3

BU-RD

GY-RDG:16

G:32

A:11

A:12

BU-BK

B:25

GY-OG

B:24

BU-RD

A:53

A:56

GY-RD

63/221

GY-RD

BU-RD

GY-RD

A:3

A:12

64/43

2

1

A:51

A:52

BU-YE

GY

GN

WH

-BK

63/220

1

2

64/41

63/228

63/232

63/233

63/229

BU-RD

GY-RD

F:30 F:15

A B

4/93

CAN

KVM

B:4

B:3

B:4

LIN

RHD

BU-RD

RHD

GY-RD

A:14

A:7

B:1

B:2

CAN

4/86

PAM

CAN

4/110

TRM

64/322

63/421

63/422

BU-RD

GY-RD

GN

WH

GY-RD

BU-RD

GY-RD

BU-RD

GY-RD

BU-RD

GY-RD

BU-RD

RHD

LHD

RHD

LHD

BU-RD

GY-RD

BU-RD

GN

WH

1 2

64/31

64/30

12

11

10

9

64/31

CAN

PSM

B:3

B:4

GN

WH

12

4X/110B

1 2

Control modules Data communication, Low speed CAN 1:2

TP 39103202 C30 2007 40

Control modules

A

B

9

10

CAN

5/1

DIM

BU-WH

GY-VT

A:9

CAN

A:10

ICM

16/1.2

A:8

A:7

GY-RD

BU-WH

C°/F°

CAN

11

9

8

10

CCM

3/112

GY-BK

BU-YE

Data communication, Low speed CAN 2:2

TP 39103202 C30 2007 41

CAN

B:58

B:45

B:57

B:44

4/46.1

ECM

63/223

11

15

CAN

BCM

4/16

CAN

4/56

CEM

G:14

G:15

63/216

BU-RD

GY-RD

A:2

A:3

CAN

6/71

63/215

63/222

GY-RD

BU-RD

1

15

64/90

GY-RD

BU-RD

GY-RD

BU-RD

29

25

7/164

CAN

1

2

17

18

64/113

BU

GY

BU

GY

B:11

B:12

14

6

17/13

GY-RD

BU-RD

GY-RD

BU-RD

BSC

EPS

DSTC

GY-RD

BU-RD

ECM

4/46.6

CAN

A:41

A:30

GY-RD

BU-RD

1

15

64/90

A:8

A:6

CAN

4/28

TCM

AW55-51

CAN

B:54

B:41

B:57

B:44

4/46.2

ECM

BU-RD

GY-RD

BU-RD

1

15

64/90

1

15

64/90

ECM

4/46.5

CAN

A:4A

A:3A

GY-RD

BU-RD

GY-RD

BU-RD

CAN

3/254

SWM

CAN

4/111

ADM

5

4

64/112

7

6

2

6

64/51

C:9

C:8

BU-RD

GY -RD

BU-RD

GY-RD

BU-RD

GY-RD

BU-RD

GY-RD

BU-RD

GY-RD

ECM

4/46.4

CAN

A:4A

A:3A

GY-RD

BU-RD

ECM

4/46.7

CAN

B:31

B:19

GY-RD

BU-RD

1

15

64/90

GY-RD

BU-RD

1

15

64/90

CAN

B:22

B:23

B:49

B:50

4/46.3

ECM

GY-RD

BU-RD

F:16

F:14

5 CYL

2,4 L

5 CYL

2,4 L D

4 CYL

2,0 L D

4 CYL

1,6 L D

4 CYL

1,8 L

5 CYL

2,5 L T

4 CYL

1,6 L

CAN

B:58

B:45

B:57

B:44

4/46.1

ECM

63/223

11

15

CAN

BCM

4/16

CAN

4/56

CEM

G:14

G:15

63/216

BU-RD

GY-RD

A:2

A:3

CAN

6/71

63/215

63/222

GY-RD

BU-RD

1

15

64/90

GY-RD

BU-RD

GY-RD

BU-RD

29

25

7/164

CAN

1

2

17

18

64/113

BU

GY

BU

GY

B:11

B:12

14

6

17/13

GY-RD

BU-RD

GY-RD

BU-RD

BSC

EPS

DSTC

GY-RD

BU-RD

ECM

4/46.6

CAN

A:41

A:30

GY-RD

BU-RD

1

15

64/90

A:8

A:6

CAN

4/28

TCM

AW55-51

CAN

B:54

B:41

B:57

B:44

4/46.2

ECM

BU-RD

GY-RD

BU-RD

1

15

64/90

1

15

64/90

ECM

4/46.5

CAN

A:4A

A:3A

GY-RD

BU-RD

GY-RD

BU-RD

CAN

3/254

SWM

CAN

4/111

ADM

5

4

64/112

7

6

2

6

64/51

C:9

C:8

BU-RD

GY -RD

BU-RD

GY-RD

BU-RD

GY-RD

BU-RD

GY-RD

BU-RD

GY-RD

ECM

4/46.4

CAN

A:4A

A:3A

GY-RD

BU-RD

ECM

4/46.7

CAN

B:31

B:19

GY-RD

BU-RD

1

15

64/90

GY-RD

BU-RD

1

15

64/90

CAN

B:22

B:23

B:49

B:50

4/46.3

ECM

GY-RD

BU-RD

F:16

F:14

5 CYL

2,4 L

5 CYL

2,4 L D

4 CYL

2,0 L D

4 CYL

1,6 L D

4 CYL

1,8 L

5 CYL

2,5 L T

4 CYL

1,6 L

Control modules Data communication, High speed CAN

TP 39103202 C30 2007 42

CAN

16/60

PHM

D:1

D:2

#70

8

1452

9

6

3

CAN

ICM

16/1.2

16/105

AUD

2

1

64/97

16/108

MMM

2 1

64/978

16/139

AUD

16/105

16/49

C:1

C:2

B:2B:1

B:1

B:2

D:2

D:1

C:2

C:1

D:1

C:1

D:2

C:2

OO

O

OG

CAN

IAM

16/1

OG

O

2

1

64/978

OG

O

TMC

2 1

64/978

16/139

AUD

16/105

16/145

C:2

C:1

D:1

C:1

D:2

C:2

OO

O

OG

RDAR

16/105

AUD

D:2

D:1

OO

16/139

GPS

O

OG

64/978

C:2

C:1

2

1

D:2

D:1

O

16/145

RDAR

AUD

O

OG

64/978

C:2

C:1

2

1

Control module Data communication MOST

TP 39103202 C30 2007 43

Control modules

3/156

WH-GN

3

7/149

LIN

H:23

WH-GN

G:3

WH-RD

1

6/1 LHD

WMM

4

6/1 RHD

WH-BK

LIN

G:26

G:1

CEM

4/56

A:11

LIN

A:12

ECU SLAVE

4/112

GDL

ECU MASTER

SCM

16/35

2

64/90

A:7

RDRD

33

64/111

2

LIN

4/102

LIN

A:2

LIN

3/1

3/155

GSM

LIN

RSM

LIN

WMM

LIN

4/113

GDL

4/28

LIN

TCM

5CYL

AW55-51

WH-RD

WH-GN

WH-GNWH-GN

LIN

4/103

WH

4

5

A:35

LIN

BUS

3

LIN

BUS 9

LIN

BUS

2

B:17

RD

SCU

SCL

RRX

63/339

LIN

3/156

WH-GN

3

7/149

LIN

H:23

WH-GN

G:3

WH-RD

1

6/1 LHD

WMM

4

6/1 RHD

WH-BK

LIN

G:26

G:1

CEM

4/56

A:11

LIN

A:12

ECU SLAVE

4/112

GDL

ECU MASTER

SCM

16/35

2

64/90

A:7

RDRD

33

64/111

2

LIN

4/102

LIN

A:2

LIN

3/1

3/155

GSM

LIN

RSM

LIN

WMM

LIN

4/113

GDL

4/28

LIN

TCM

5CYL

AW55-51

WH-RD

WH-GN

WH-GNWH-GN

LIN

4/103

WH

4

5

A:35

LIN

BUS

3

LIN

BUS 9

LIN

BUS

2

B:17

RD

SCU

SCL

RRX

63/339

LIN

Data communication LIN 1:2

TP 39103202 C30 2007 44

Control modules Data communication

LIN 2:2

6/48 RHD

6/48RHD 6/95

6/95 6/103

6/103

DMM

LIN

7/159 RHD

AQS

LIN

6/48 LHD

6/48 LHD 6/96

6/96 6/102

6/102

DMM

2

ECC

2

9/12

SHM

LIN

A:2 A:2

YE

VT

A:2 A:2

BU

4

64/30

64/545

3

RHD

WH

RHD

LHD

WH WH-GN

64/112

WH

WH-GN

766

WH

LHD

WH-GN

9/13

64/31

SHM

LIN

BU

4

WH

WH-GN

12

7

3/112

CCM

C°/F°

LIN

64/333

GN-WH

5

7/159 LHD

6/26

3/126

B:4

3/81

WINDOW

CONTROL

4/126

LIN

AQS

LIN

ACM

B:2

LIN

G

DDM

LIN

SWITCH

LIN

LCM

ECC

2

A:13

4

A:1

3/254

SWM

16/1.2

ICM

A:2

VT

LIN

WH-RD

WH-BU

A:88

4/46.3

ECM

WH-RD

2.4L

Diesel

64/35

CAN

GN-WH

5

C:5

A:88

A:46

B:4

4/46.1

ECM

5 CYL

5CYL

4/46.2

ECM

5 CYL

5CYL

2,5 L T

3/127

4/127

LIN

2,4 L

LIN

PDM

LIN

RCM

LIN

TP 39103202 C30 2007 45

PATS

63/339

MODULE

0

1

2

3

KEY ININHIBIT

3

2

1

0

F26

305

IMMOBILIZER SUPPLY

S

B1

B2

5015X

B4

30

POWER

GROUND

BK-YE

WH-GN

RD-BK

RD-GNRD-GN

RD-GN

A:2

A:1

A:3

B:5

B:6

B:8

RD

3/1

B:7

GY-BK

B:2

RD-BK

GN-WH

B:3

YE

B:1

63/88

63/5

CEM

LIN

SCL

LIN

4

WH-GN

WH-GNB:17

BK

A:42

A:17

A:15

B:13

A:30

LIN

4/102

4/56

SCU

1

2

F44

1

2

F52

1

2

F53

1

2

F54

1

2

F51

1

2

F73

A:10 E:3 E:2 E:1 A:3 C:39 E:29 C:38 A:16 C:18 H:4

31/83

PATS

63/339

MODULE

0

1

2

3

KEY ININHIBIT

3

2

1

0

F26

305

IMMOBILIZER SUPPLY

S

B1

B2

5015X

B4

30

POWER

GROUND

BK-YE

WH-GN

RD-BK

RD-GNRD-GN

RD-GN

A:2

A:1

A:3

B:5

B:6

B:8

RD

3/1

B:7

GY-BK

B:2

RD-BK

GN-WH

B:3

YE

B:1

63/88

63/5

CEM

LIN

SCL

LIN

4

WH-GN

WH-GNB:17

BK

A:42

A:17

A:15

B:13

A:30

LIN

4/102

4/56

SCU

1

2

F44

1

2

F52

1

2

F53

1

2

F54

1

2

F51

1

2

F73

A:10 E:3 E:2 E:1 A:3 C:39 E:29 C:38 A:16 C:18 H:4

31/83

Control modules Start Control Module (SCU)

3/1

B:8

RD-GN

305

IMMOBILIZER SUPPLY

B:6

RD-BK

KEY ININHIBIT

S

B:5

RD-GNRD-GN

SCU

LIN

POWER

B1

A:3

RD-BK

3

2

MODULE

GROUND

B2

A:1

BK-YE

F26

RD

B:7

30

0

1

PATS

B4

A:2

WH-GN

3

2

5015X

B:3

B:2

GN-WH

GY-BK

0

1

B:1

YE

63/88

4/56

1

F44

2

1

F52

2

1

F53

2

1

F54

2

A:10 E:3 E:2 E:1 A:3 C:39 E:29 C:38 A:16 C:18 H:4

1

2

F51

B:13

A:15

CEM

LIN

63/339

WH-GNB:17

A:42

A:17

A:30

1

F73

2

WH-GN

4

4/102

SCL

LIN

63/5

BK

31/83

TP 39103202 C30 2007 46

MAF

GN-BU

GN-RD

GN-BU

GN-BK

GN-YE

GN-BU

A:56

A:60

A:53

A:77

A:29

A:59

A:86

A:50

A:1

2

1

BK-BUBK-BU

GN-BU

BN-WH WH-VT

A:48

A:6

A:80

A:57 A:31

BN-BU

WH-RD

BN-RD

7/16

7/25

7/17

4

1

3 2

A

2

1

F35 F34 F36

2

1

F32

2

1

F33

2

1

A:25

A:3

A:75

A:26

A:74

A:73

A:2

A:49

8/7

8/8

8/6

1

2

1

2

1

2

8/10

8/9

1

2

1

2

GN-YE BK-WH GN-YE BU GN-YE BK-GN

GN-YE

BK-BU

BK

GN-YE

A:90

WH-BU

BK-YE

A:37

GN-BU

WH-BU

YE-GN

A:32

BN-RD WH-RD

1

2

P

2

7/162

3

1

WH-GN

A:65

YE-GN

A:19

BN-GN

A:64

3

7/165

8/120

6/143

1 2

4

1 2

6

3

1 2

4

A:15

BN

3

A:82

BK-GN

WH-GN

GY

A:87 A:85

M

8/113

1

2

BK-GN

GN-BK

GN-OG

BK-GN

YE-GN

WH-GN

63/54

64/90

A:92

A:66

A:71

A:28

BK-RD

A:9

YE-BK

A:21

7

6

RD

C

GN-YE

GN-OG

B

GN-RD

D

1 2

A:62

A:84

7/190

WH-RD BN-RD

A:8

A:58

7/191

WH-BU BN-BU

P

GN-YE

GN-BU

BN-GN

BK-YE

WH

WH-BK

BN GY

7/15

GN-BU

AUTO

CAN

LIN

ECM

4/46.3

14

40

16

2

4

3

6

2

1 5

64/90

41

64/90

39

64/90

35

12

5CYL

2,4 L D

GN-BU

11

10

9

1

3

45

2

1

64/90

27

38

26

24

2

1

2

1

2

1

GN-YE

GN-RD

GN-BU

GN-OG

WH-RD

20/22

20/23 20/24 20/26

4/109

DRIVER

N

GLOW P5 GLOW P4 GLOW P3 GLOW P1

PUISSANCE

MOS

PUISSANCE

MOS

PUISSANCE

MOS

PUISSANCE

MOS

DRIVER

N

DRIVER

N

DRIVER

N

GLOW PLUG RELAY BOX

2

25

2

1

GN-WH

20/25

GLOW P2

PUISSANCE

MOS

DRIVER

N

15/31

2

1

F6

R14

2

1

2/32

2

1

5

3

30+

RD-OG

F9

21

Group 23 Fuel system Engine management system Diesel, 5-cyl. 2.4l 1:3

TP 39103202 C30 2007 47

30+

1

2

F18

1

2

1

F24

63/33

B:47

B:42

A

BK-BU

BK-YE

7/51

GN-BU

GN-OG

GY GY

4

5

1

2

3

6

B

3/1

30

15X

5

50 S

7

B:2

B:3

15I

C

B:22

B:23

B:4

63/12

63/120

63/121

63/25

63/65

BK

BK-YE

31/84

31/52

GN-YE

GN-OG

GN-WH

BNBKWH

YE

RD-BK

WH-BK

BK

WH-BK

GN-RD

BK

RHD

LHD

BK

14

7

8

31/116 31/10

BK

BK-OG

BK

31/114

BK-OG

31/115

BK-OG

64/51

63/85

63/53

B:38

GN-YE

GN-WH

GY-BK

GN-WH

RD-BU

D

B:5

B:3

B:1

ECM

4/46.3

CAN

LIN

2/142

R5

WH-BK

RD-YE

2

1

2

F26

1

2

1

2

5

3

F4

64/111

5

64/90

B:48

GN-WH

BK-YE

BK-WH

BK-YE BK-YE

GN-BU

8

37

64 / 111

7

64/90

28

6/33

M

56

1

64/113

7

RD

64/90

13

3/9

2

1

CAN

CEM

F74

E:21

LIN

1

2

F57

1

2

R15

2/23

F51

1

2

E:22A:17

RD RD

E:29

C:16

1

2

1

2

A:42

E:40

E:10

G:7

G:31

G:22

A:28

E:28E:41

OG

RD

OG-WH

2

5

1

3

4

9/32

B:2

B:6

4/56

9/38

15/31

5CYL

2,4 L D

BK

Group 23 Fuel system Engine management system Diesel, 5-cyl. 2.4l 2:3

TP 39103202 C30 2007 48

BN-RD

YE-RD

8/98

1

2

A:23

A:93

CAN

LIN

A:44

A:63 A:41

A:78

A:61

ECM

WH-VT

BN-WH

YE-VT

WH-BU

BN-BU

7/154

7/174

3 1 2

P

4/46.3

7/173

A:33 A:7

BN-WH

YE-RD

WH-VT

A:10

QLT

2

7/166

3

1

BN

A:36

YE

A:42

WH

A:34

1

2

8/111

M

1 2

1 2 3

6

3

2

4

1

ETA

6/120

6/118

GN-RD BN-BU BK-OG

A:24

A:72 A:67

A:18

WH-BU

YE

A:47

BN

A:94

A:11

YE-BU

5

4

3

2

1

BK GN-OG WH-BK

A:4

A:5 A:81

A:40

YE-BK

A:52

BN-YE

5CYL

2,4 L D

Group 23 Fuel system Engine management system Diesel, 5-cyl. 2.4l 3:3

TP 39103202 C30 2007 49

6

5

4

3

2

1

8/8

1

2

8/9

1

2

8/7

1

2

1

8/6

BN

WH

7/16

1

2

1

2

F35F34

2

11

2

F32

ETA

B:13

6/120

64/60

63/SH8

63/SH7

63/74

C

GN-OG

GN-RD

GN-BU

GN-YE

GN-WH

4/46.7

7/24

YE

BK

WH-RD

A

A:27

A:13

A:28

A:12

A:31

BK

SCR

A:16

A:32

B:41

B:42

ECM

A:21

YE

A:6

BN

CAN

WH-BU

YE-BU

WH-RD

YE

BN

WH-BU

YE-BU

B

GN-YE

A:22

A:48

1

2

B:36

WH-GN

GN-WH

A:52

B:17

P

7/165

3

2

1

4

WH-VT YE-GN

BN-GN

B:35

7/6

1

P

BK-OG

BK-BU

BK-OG

BK-YE

BK-WH

BK-BU

BK-OG

BK-YE

BK-WH

A:20

B:3

21

64/90

63/99

63/52

12 14

BK-BUBK-BU

GN-BU

GN-RD

1

2

F36

41

GN-BU

8

7

2

3

1

4

9

10

16

5

15

14

13

B:29

BN-WH

BK-OG

1

2

8/65

A:1

BK-GN

A:3

3

2

1

20/17

20/3 20/6

20/4 20/5

GN-RD

4CYL

1,6 L

R14

2

1

2/32

2

1

5

3

30+

15/31

RD-OG

F9

Group 23 Fuel system Engine management system, 4-cyl. 1.6l 1:2

TP 39103202 C30 2007 50

M

5 6

6/33

I4 PETROL

2WD

1 4 2

ECM

B:7

B:40

A:42

A:8

4/46.7

A

BK-BU

B

CAN

3/9

2

1

C

GN-WH

BK-OG

63/53

30+

1

2

F18

CAN

CEM

F74

15/31

E:21

LIN

3/1

30

15X

5

50 S

B:7

B:2

64/111

5

RD RD

GY-BK

1

2

4/56

F57

1

2

1

2

F4

1

2

F26

1

2

F30

RD-YE

RD-BU

64/90

8

13

37

28

GY

GN-BU

GN-WH

64/111

64/51

7

7/51

1

5

2

6

3

4

2

R15

2/23

5

1

3

E:22

C:16

A:42

E:40

E:10

G:22

G:31

G:7

A:28

A:47

A:40

B:21

GN-WH

B:9

RD RD

GN-BU

GY

WH

YE

BN

E:28E:41

OG

OG-WH

BK-YE

31/10

7 8

31/84

63/12

BK-YE

BK

GN-YE

B:8

BK-YE

A:5

BK-YE

31/52

GN-OG

BK

GN-WH

31/115

31/116

BK-OG

63/25

BK BK

BK-OG

LHD

RHD

4

B:19

B:31

4CYL

1,6 L

Group 23 Fuel system Engine management system, 4-cyl. 1.6l 2:2

TP 39103202 C30 2007 51

6

5

4

3

2

1

8/8

1

2

8/9

1

2

8/7

1

2

1

8/6

BN

WH

BN

7/16

1

2

1

2

F33

1

2

F35F34

2

11

2

F32

GN-BU

ETA

B:16

GN-BK

31

2

20/6

WH-BU

GN-RD

31

2

20/5

20/4

2

13

GN-BU

WH-RD

WH

GN-YE

31

2

20/3

GN-BU

6/120

GN-RD

C

GN-OG

63/95

WH-GN

GN-RD

GN-BU

GN-YE

GN-WH

63/54

4/46.6

7/24

BK

GN-BK

YE-GN

SCR SCR

WH-GN

WH-VT

YE

GN-RD

BK-OG

A

B:2

B:3

B:13

B:14

B:41

B:36

B:39

B:27

B:29

B:11

B:46

B:23

B:34

B:22

B:10

ECM

B:37

WH-BU

B:38

BN-BU

CAN

WH-BU

YE-BU

B

GN-YE

D

BK-BU

B:25

B:26

1

2

B:30

1

3

2

4

7/165

63/74

63/67

1

2

8/45

GN-YE

B:8

BK-YE

BK-OG

8/114

1

2

GN-OG

B:9

BK-RD

BK-BU

BK-YE

BK-WH

21

64/90

63/99

12 14

1

2

F36

BK-BU BK-BU

GN-BU

41

4CYL 1,8 L

R14

2

1

2/32

2

1

5

3

30+

15/31

RD-OG

F9

B:31

7/6

1

P

BK-OG

Group 23 Fuel system Engine management system, 4-cyl. 1.8l & 2.0l 1:2

TP 39103202 C30 2007 52

ECM

A:10

A:11

A:23

A:35

4/46.6

A

BK-BU

B

CAN

3/9

2

1

C D

GN-WH

RD

BK

RD

BK

31/84

63/53

30+

1

2

F18

CAN

CEM

F74

15/31

E:21

LIN

3/1

30

15X

5

50 S

B:7

B:2

64/111

5

RD RD

GY-BK

1

2

4/56

F57

1

2

1

2

F4

1

2

F26

RD-YE

RD-BU

64/90

8

37

28

4

34

17

5

GY

GN -BU

GN-WH

64 / 111

7

7/51

1

5

2

6

3

4

2

R15

2/23

3

1

5

E:22

C:16

A:42

E:40

E:10

G:22

G:31

G:7

A:28

A:32

A:39

A:46

GN-WH

GN-BU

GY

A:1

A:4

A:12

BK-RD

WH-RD

BK-YE

A:14

A:28

BK-OG

YE-RD

A:13

WH

YE

BN

E:28E:41

OG

OG-WH

BK-YE

6/26

31/10

7 8

64/54

64/51

4 3

63/12

BK-YEBK

GN-YE

A:34

BK-YE

31/52

GN-OG

GN-YE

BK-BU

BK

GN-OG

31/115

31/116

BK-OG

GN-WH

63/25

BK BK

BK-OG

LHD

RHD

M

5

26/5

FlexiFuel

6/33

1

5

Flexi fuel

1.8l/

2.0l

M

6/33

4

A:30

A:41

29

19

B:20

B:15

A:1

A:2

GY

BU

WH-VT

ACM

DC/AC

4CYL

1,8 L

Group 23 Fuel system Engine management system, 4-cyl. 1.8l & 2.0l 2:2

TP 39103202 C30 2007 53

6

5

4

1

2

3

2

1

MAF

8/8

1

2

8/9

1

2

8/7

1

2

1

8/6

2

1

8/10

GY

BK

BN

BN-WH

YE-VT

7/81

7/16

3

1

2

1

P

1

2

F32

1

2

F35F34

2

11

2

F36

GN-BU

7/17

4

3

2

5

GY

BN-BU

WH-RD

BN-BU

ETA

A:67

BK

31/89

31/88

GN-BU

31

2

4

20/7

GN-BU

31

2

4

20/6

WH-BK

GN-BU

31

2

4

20/5

20/4

4 2 13

GN-BU

BK-WH

GN-WH

WH-RD

WH

GN-BU

31

2

4

20/3

GN-YE

6/120

GN-BU

C

GN-BU

63/103

WH-GN

WH-BU

GN-YE

63/54

4/46.1

7/24

7/25

WH-BK

BN-YE

WH-RD

BN-RD

GN-RD

BK-OG

A

A:84

A:83

A:82

A:81

A:80

A:93

A:3

A:4

A:46

A:20

A:58

A:59

A:62

A:21

A:60

A:34

A:35

A:75

A:74

ECM

A:24

YE

A:72

BN-BU

GN-BU

CAN

WH-BU YE-BU

B

GN-YE

A:15

A:96

BK-OG BK-OG

A:53

A:78

1

2

A:22

A:16

WH-BU

A:71

A:94

P

7/156

3

2

1

4

WH-GN

YE-BU

BN-BU

A:91

7/6

1

P

BK-GN

GN-BU

63/97

YE-RD

A:12

YE-RD

A:23

A:70

A:69

BK

BK-BU

BK-GN

BU

BK-WH

A:5

A:13

21

64/90

41

64/90

63/98

12 14 39

1

2

8/84

1

6/114

P

63/121

31/114

BK

GN-RD

BK

63/120

BK

1

2

F33

BK-BU

GN-BU

GN-YE

63/13

1

2

1

8/18

2

1

8/19

2

1

9/32

2

5CYL

2,4 L

W/O T

BK-BU

R14

2

1

2/32

2

1

5

3

30+

15/31

RD-OG

F9

Group 23 Fuel system Engine management system, 5-cyl. 1:2

TP 39103202 C30 2007 54

ECM

B:3

B:2

B:1

B:16

4/46.1

A

BK-BU

B

CAN

3/9

2

1

C

63/53

30+

1

2

F18

CAN

CEM

F74

15/31

E:21 A:17

LIN

3/1

30

15X

5

50 S

B:7

B:2 B:3

64/111

5

RD RD

GY-BK

GN-WH

1

2

4/56

F57

1

2

1

2

F4

1

2

F26

1

2

F23

RD-YE

RD-BU

RD

64/113

7

64/90

23

8

37

28

13

24

GY

GN-YE

GN-WH

64/111

7

7/51

1

5

2

6

3

4

2

R15

2/23

5

1

3

E:22

C:16

A:42

E:40

E:10

G:22

G:31

G:7

A:28

B:54

B:26

B:41

B:14

GN-WH

GN-YE

GY

WH

YE

BN

E:28 E:1

F54

1

2

E:41

OG

OG-WH

BK-YE

B:30

GN-YE

B:20

WH-BK WH-BK

WH-BK

31/84

63/12

BK-YEBK

GN-YE

B:6

B:4

63/65

BK-YE

GN-BU

31/52

GN-BU

BK

4

A:45

A:58

A:44

A:57

63/56

RD

MAN

GN-YE

5CYL

2,4 L

W/O T

4/83

1

4

2

5

3

WH-BK

GN-WH

BK-OG

7

64/51

31/10

14 8

GN-WH

31/115

31/116

BK-OG

63/25

BK

BK-OG

LHD

RHD

M

5

6/33

I5 PLASTIC AWD 2WD

I5 PZEV METAL TA NK

6/33

1

BK-RD

M

56

1

GN-OG

BK-RD

BK-OG

63/33

1

4

1

2 3

WH-BK

GN-WH

BK-OG

64/956

4

5

GN-OG

BK-RD

64/956

Group 23 Fuel system Engine management system, 5-cyl. 2:2

TP 39103202 C30 2007 55

6

5

4

1

2

3

2

1

MAF

8/8

1

2

8/9

1

2

8/7

1

2

1

8/6

30+

2

1

8/10

GY

WH-GN

BN

WH-VT

BN-WH

7/16

3

1

2

1

2

F32

1

2

F35F34

2

11

2

F36

GN-BU

7/17

4

3

5

BN-BU

WH-RD

BN-RD

ETA

A:42

BK

31/89

31/88

GN-NU

31

2

4

20/7

GN-BU

31

2

4

20/6

WH-BK

GN-BU

31

2

4

20/5

20/4

4 2 13

GN-BU

WH-RD

WH

GN-BU

31

2

4

20/3

GN-YE

6/120

GN-BU

GN-YE

63/103

WH-GN

WH-BU

GN-YE

63/54

4/46.2

7/24

7/25

WH-BK

BN-YE

WH-RD

BN-RD

GN-RD

BK-OG

A

A:1

A:25

A:3

A:2

A:26

A:18

A:63

A:87

A:7

A:55

A:81

A:57

A:77

A:53

A:34

A:82

A:58

A:75

A:14

ECM

A:19

WH-BU

A:74

BN-BU

CAN

WH-BU YE-BU

C

GN-BU

B

A:88

A:65

1

2

A:12

A:43

WH-BU

A:41

A:89

P

7/156

3

2

1

4

GN-RD YE-BU

BN-BU

A:9

7/6

1

P

BK-GN

A:61

A:38

BK-OG

BK-BU

BK-GN

BK-YE

BK-WH

A:15

A:44

21

64/90

63/98

12 14 39

2

BN-RD

WH-RD

A:79

A:31

3

4

2

1

8/28

7/165

P

4

GN-BU

A:51

BN-YE

BK-GN

A:86

M

GN-BU

BK-BU

4135

40

2

8/84

1

6/114

P

63/121

31/114

BK

GN-RD

BK

63/120

BK

1

2

F33

GN-YE

GN-BU

GN-YE

63/13

GN-YE

1

2

1

9/32

2

GN-WH

BK-WH

BK-BU

5CYL

2,5 L T

R14

2

1

2/32

2

1

5

3

15/31

RD-OG

F9

Group 23 Fuel system Engine management system, 5-cyl. Turbo 1:2

TP 39103202 C30 2007 56

ECM

B:6

B:4

B:2

CAN

3/9

2

1

4/83

1

425

3

WH-BK

GN-WH

BK-OG

31/84

63/53

30+

1

2

F18

CAN

CEM

F74

15/31

E:21

LIN

3/1

30

15X

5

50 S

B:7

B:2

64 / 111

5

RD RD

GY

-BK

1

2

4/56

F57

1

2

1

2

F4

1

2

F26

1

2

F23

RD-YE

RD-BU

RD

64/113

64/90

23

8

37

13

9

6

28

24

GY

GN-YE

GN-WH

64/111

7

7/51

1

5

2

6

3

4

R15

2/23

E:22

C:16

A:42

E:40

E:10

G:22

G:31

G:7

A:28

B:16

B:15

B:30

B:14

B:21

GN-WH

GN-YE

B:17

B:13

GN-BU

B:26

GY

WH

YE

BN

E:28E:41

OG

OG-WH

BK-YE

64/51

31/10

14 8

63/12

WH-BK

BK-YEBK

GN-YE

B:5

B:3

63/65

BK-YE

GN-BU

31/52

GN-BU

BK

GN-WH

31/115

31/116

BK-OG

63/25

BK BK

BK-OG

LHD

RHD

M

5

6/33

I5 PLASTIC AWD 2WD

I5 PZEV METAL TA NK

6/33

1

BK-RD

M

56

1

GN-OG

BK-RD

B:27

4/46.2

A

BK-BU

B:41

B:54

B:44

B:57

MAN

2

5

1

3

4

C

B

BK-OG

63/33

1

4

5CYL

2,5 L T

63/56

RD

1

2 3

WH-BK

GN-WH

BK-OG

64/956

4

5

GN-OG

BK-RD

64/956

Group 23 Fuel system Engine management system, 5-cyl. Turbo 2:2

TP 39103202 C30 2007 57

3

2

1

5

4

MAF

BN

WH

7/16

7/191

1

2

1

2

F32

1

2

F35F34

2

11

2

F36

GN-RD

7/17

1

2

5

BK-BU

WH-BU

WH-RD

B:F2

C:C2

8/120

B

63/54

4/46.5

WH-GN

BN-GN

B:G2

B:H3

C:A3

C:D4

C:D3

ECM

B:A4

YE-GN

B:D2

BK-GN

CAN

GN-BK

A

D

C

B:C2

B:H1

A:E3

7/6

2

P

BK-GN

B:E2

B:E1

21

64/90

4

GN-BU GN-RD

M

BK-BU

BK

7/174

B:K1

WH-VT

BN-WH

C:F3

YE-VT

B:G4

2

1

BK-WH

C:G3

C:H1

2

1

8/7

8/6

BK-YE

C:G4

C:G2

2

1

8/8

BK-BU

C:H4

C:H2

GN-WH

GN-YE

GN-BU

2

1

8/9

BK-OG

C:H3

C:G1

GN-RD

2

1

8/82

7/86

BK-BU

GN-BU

C:E1

WH-VT

B:F1

B:L4

P

2

7/71

3

1

BN-GN

BN-BU

BN-WH

B:D4

WH-GN WH-BU

B:K2 C:A2

YE-GN

B:E4

BK-YE

B:M4

BN-BU

WH-BU

7/154

1

2

B:H2

C:F1

7/25

B:B1

WH-RD

BN-RD

B:C1

YE-RD

B:F3

1

2 3

C:A4

WH-BU

BK-YE

C:F2

2

64/90

16

P

7/21

B:D1

WH-VT

BN-WH

B:A1

YE-VT

B:F4

2 3

P

2

7/162

3

1

BN-GN

B:C4

YE-GN

B:B4

WH-GN

B:G3

4

8

3

5

1

2

67

2

1

2

1

63/121

9/38

BK

GN-YE

BK-OG

GN-BU

64/90

26

27

25

24

64/600

3

4

2 1

2

1

2

1

2

1

GN-OG

GN-OGGN-OG

GN-OG

20/25

20/24

20/23

20/26

BK

31/1

31/52

14

63/120

BK-YE

BK

4/109

RD

DRIVER

N

GLOW P4GLOW P3GLOW P2GLOW P1

PUISSANCE

MOS

PUISSANCE

MOS

PUISSANCE

MOS

PUISSANCE

MOS

DRIVER

N

DRIVER

N

DRIVER

N

BK-YE

GLOW PLUG RELAY B O X

WH-BU

BK-BU

1

2

F33

GN-BK

GN-BU

6 14

64/90

GN-RD

GN-BU

GN-YE

GN-RD

63/41

YE-RD

YE-VT

8/111

21

M

4CYL

1,6 L D

12 39

63/53

15/31

2

1

F6

R14

2

1

2/32

2

1

5

3

30+

RD-OG

F9

7/192

1

2

3

Group 23 Fuel system Engine management system Diesel, 4-cyl. 1.6l 1:2

TP 39103202 C30 2007 58

ECM

A:G1

B:M2

4/46.5

A

CAN

3/9

2

1

B C D

31/84

30+

1

2

F18

CAN

CEM

15/31

E:21

LIN

3/1

30

15X

5

50 S

B:7

B:2

64 / 111

5

RD RD

GY-BK

4/56

F57

1

2

1

2

F26

RD-YE

7

8

37

28

GY

GN-BU

GN-WH

64 / 111

64/51

64/90

7

7/51

1

5

2

6

3

4

A:42

E:40

E:10

G:22

G:31

G:7

C:B3

A:B3

A:A2

A:C3

GN-WH

GN-BU

GY

WH

YE

BN

E:28E:41C:16

OG

OG-WH

BK-YE

BK-OG

63/12

63/42

63/41

6/99

BK-YE

BK

GN-YE

A:H4

A:G4

63/53

BK-YE

31/52 31/11631/115

GN-OG

BK

RHD

LHD

WH-GN

G:30

C:D1

B:K3

B:J2

B:M1

B:F4

B:L1

7

8

BN-RD BN-RD

WH-RD

YE-RD

BK-BU

BN-GN

WH-GN

YE-RD

BK-GN

5

6

1

4

3

WH-GN

A:H1

BK-YE

64/90

41

A:A3

A:A4

GN-BU

GN-BK

8/122

5

6

1

3

4

GN-WH

BK-OG

BK-RD

GN-OG

6/33

4/111

1

8

9

10

7

6

M

2

134

CAN

ADM

M

4CYL

1,6 L D

Group 23 Fuel system Engine management system Diesel, 4-cyl. 1.6l 2:2

TP 39103202 C30 2007 59

MAF

BN

WH

7/16

1

2

1

2

F32

1

2

F35F34

2

11

2

F33

GN-RD

GN-YE

7/17

3

2

1

WH-BU

BN-BU

BU-WH

C:A2

B

63/54

4/46.4

B:G2

C:H3

ECM

CAN

A

A:G4

A:H4 B:K2

C:H4 C:J4

C:K4

C:G1

C:F3

7/6

2

P

BK-GN

B:C1

B:H3

15/31

21

64/90

4

2

1

8/132

GN-BU

B:M3

GN-BK

BK-BU

BK

31/52

C:E3

C:C1

C:D4

YE-VT

WH-VT

BN-WH

7/172

1

2 3

2

1

8/6

GN-WH

C:M3

C:L3

2

1

8/7

GN-YE

C:M2

C:L1

2

1

8/8

GN-BU

C:M4

C:L2

BK-WH

BK-YE

BK-BU

2

1

8/9

GN-RD

C:M1

C:L4

BK-OG

2

1

8/82

BK-BU

GN-BU

B:M1

2

1

F6

B:L4

BK-BU

B:M4

WH-BU

C:H2

P

2

7/71

3

1

BN-GN

C:D1

WH-GN

C:B1

YE-GN

C:E2

BN-BU

WH-BU

7/154

1

2

C:A3

C:J1

7/25

C:B4

WH-RD

BN-RD

C:F1

YE-RD

C:F4

3

2 1

B:D4

WH-BU

BK-YE

B:E1

2

64/90

7/192

16

BN-WH

WH-VT

7/77

1

2

B:A2

B:G3

BK-YE

4

8

3

5

1

2

67

2

1

2

1

63/121

63/86

9/38

BK BK-WH

GN-WH

GN-YE

GN-BU

64/90

26

27

25

24

64/600

3

4

2 1

2

1

2

1

2

1

GN-OG

GN-OGGN-OG

GN-OG

20/23

20/24 20/25 20/26

BK

31/114

63/120

63/53

BK-YE

BK

GN-BU

4/109

RD

BK-OG

BK-YE WH-BU

BK-BU

1

2

F36

14

64/90

12

39

GN-BU

6

64/90

GN-RD

RD

8/133

2

1

BK-BU

8/77

2

1

2

3

GN-BU

BK-GN

B:L3

8/121

2

1

GN-BK

DRIVER

N

GLOW P4GLOW P3GLOW P2GLOW P1

PUISSANCE

MOS

PUISSANCE

MOS

PUISSANCE

MOS

PUISSANCE

MOS

DRIVER

N

DRIVER

N

DRIVER

N

GLOW PLUG RELAY B O X

1

9/32

2

4CYL

2,0 L D

R14

2

1

2/32

2

1

5

3

30+

RD-OG

F9

Group 23 Fuel system Engine management system Diesel, 4-cyl. 2.0l 1:2

TP 39103202 C30 2007 60

ECM

C:J3

C:K3

C:K2

4/46.4

A

CAN

3/9

2

1

B

31/84

63/65

30+

1

2

F18

CAN

CEM

15/31

E:21

LIN

3/1

30

15X

5

50 S

B:7

B:2

64 / 111

5

RD RD

GY-BK

4/56

F57

1

2

1

2

F26

1

2

F30

RD-YE

RD

64/90

7

8

37

28

GY

GN-BU

GN-WH

64/111

7

7/51

1

5

2

6

3

4

A:42

E:40

E:10

G:22

G:31

G:7

A:E2

A:F3

A:E4

A:C3

GN-WH

GN-BU

GY

WH

YE

BN

E:28E:41

OG

OG-WH

BK-YE

63/12

BK-YE

GN-WHGN-WH

BK-OG

BK-RD

BK-OG

RHD

LHD

BK

GN-YE

6/33

4/111

GN-OG

WH-GN

G:30

13

WH-GN

B:B2

B:C2

YE-VT

B:A3

B:H2

BN-RD

WH-RD

B:B4

B:J2

BN-BU

WH-BU

WH-VT

B:D3

BN-WH

64/90

41

B:G4

RD

A:A3

A:A4

GN-BU

M

7/190

1

2

7/191

1

2

134

P

1

7/174

2

3

C:16

64/51

87

31/115 31/116

CAN

ADM

4

3

1

6

5

8/120

YE-GN

WH-GN

B:E2

B:D2 B:C3

BN-GN

B:L2

BK-GN

GN-BK

B:M2

M

GN-OG

1

8

9

10

7

6

7/193

B:D1

B:C4

YE-BK

WH-BK

BN-YE

B:E4

P

2

7/162

3

1

BN-GN

C:B3

YE-GN

C:A4

WH-GN

C:B2

2 3

1

4CYL

2,0 L D

Group 23 Fuel system Engine management system Diesel, 4-cyl. 2.0l 2:2

TP 39103202 C30 2007 61

2

3

4

1

B:2

A:49

BN-BU

WH-BU

BK-OG

7/15

2

O

B:6

B:16

GN-RD

BK-OG

2

1

8/18

WH-VT

BN-WH

7/163

B:38

B:27

11

12

CAN

ECM

F35

2

1

2

F32

4/46.7

A:8

BK-BU

GN-RD

64/90

64/60

39 32

14 21

A:30

A:41

GN-YE

GN-BU

BK-BU

1

4

3

2

BK-YE

WH

BN

O

2

7/82

B:14

A:38

B:39

1

2

7/25

WH-RD

BN-RD

B:37 B:26

4CYL

1,6 L

R14

2

1

2/32

5

3

30+

15/31

RD-OG

F9

2

1

Group 23 Fuel system Emission control, 4-cyl. 1.6l

TP 39103202 C30 2007 62

1

4

3

2

4

3

1

A:27

A:25

A:26

A:3

BK-OG

GN-YE

BK-GN

BN

WH-GN

BN-RD

WH-BU

BN-BU

BK-GN

7/15

B:32

1

2

O

2

CAN

2

8/18

63/54

GN-RD

GN-BU

ECM

F35

2

1

2

F32

4/46.6

A:35

BK-BU

B:45

B:44

BK-OG

BK-GN

BK-RD

BK-WH

GN-RD

GN-BK

A:7

BN-WH

B:7

WH-VT

B:18

7/163

2

1

WH-RD

B:6

BN-RD

B:17

7/25

2

1

63/63

GN-RD

BN-RD

7/82

A:5

64/90

39 32

14

B:33

21

A:30

A:41

GN-YE

GN-BU

BK-BU

6/99

M

P1 P2

P5

P3

P4

P6

4CYL

1,8 L

R14

2

1

2/32

5

3

30+

15/31

RD-OG

F9

2

1

Group 23 Fuel system Emission control 4-cyl. 1.8l & 2.0l

TP 39103202 C30 2007 63

27

6/67

1

3

WH-VT

BK-WH

YE-VT

GN-BU

BK-WH

64/113

13

M

2

4

64/51

10

12

WH-VT

GN-BU

YE-VT

BK-WH

11

10

12

25 11 9

1

4

3

2

4

3

1

A:11

A:49

A:47

A:48

A:78

A:53

GN-BU

BK-OG

GN-YE

BN-RD

WH-RD

BN-BU

BN-BU BN-BU

BK-YE

WH

BU

63/61

7/15

B:46

YE-VT

2

1

8/19

2

O

2

CAN

1

8/18

63/54

GN-BU

ECM

F35

2

1

2

F33

4/46.1

B:16

R11

BK-BU

B:33

BN-WH

A:68

WH-VT

A:63

YE-BK

A:17

A:19

7/172

1

2

3

BN-RD

BN

A:43

YE-RD

A:39

A:64

7/173

1

2

3

WH-BK

63/94

GN-YE

7/186

2

4

3

1

A:50

BN-RD

WH-RD

BK

O

2

A:95

7/187

A:76

64/90

40

14

GN-YE

BK-OG

B:23

21

B:45

B:58

B:44

B:57

GN-YEGN-YE

GN-BU

BK-BU

26

WH-VT

2/22:1

GN-BU

63/13

5CYL

2,4 L

W/O T

R14

2

1

2/32

5

3

30+

15/31

RD-OG

F9

2

1

Group 23 Fuel system Emission control, 5-cyl.

TP 39103202 C30 2007 64

27

1

4

3

2

A:95

A:49

A:50

A:72

GN-BU

BK-RD

GN-YE

WH-RD

BN-RD

B:46

YE-VT

2

1

8/18

O

2

CAN

1

6/67

1

3

8/19

63/54

GN-BU

WH-VT

BK-WH

YE-VT

GN-BU

WH-VT

BK-WH

YE-VT

ECM

64/113

13

F35

2

1

2

F33

4/46.2

B:27

BK-BU

B:23

M

2

4

64/51

10

12

BN-WH

WH-VT

GN-BU

YE-VT

BK-WH

A:90

WH-VT

A:83

YE-RD

A:16

A:36

7/172

1

2

3

BN-WH

7/82

64/90

35

14

GN-YE

BK-OG

11

B:45

21

WH-VT

6

2

1

5

3

4

A:68

A:92

A:67

A:91

A:73

BK-YE

GN-YE

BU

WH

GY

WH

7/15

O

2

BN-RD

WH-BK

A:59

YE-BK

A:17

A:37

7/173

1

2

3

BN-YE

A:96

GN-BU

2

1

8/81

BK-WH

B:41

B:54

63/13

GN-YE

GN-BU

40

BK-BU

26

WH-VT

B:44

B:57

GN-YE

2/22:1

GN-BU

10

12

25 11 9

5CYL

2,5 L T

R14

2

1

2/32

5

3

30+

15/31

RD-OG

F9

2

1

Group 23 Fuel system Emission control, 5-cyl. Turbo

TP 39103202 C30 2007 65

6/29

4/71

WH-RD

P

1

3

2

7/8

B:51

B:31

4/46.1 4/46.2

ECM

B:7

1

30+

2

BK

31/114

CAN

F1

B:8

2

1

4

34

B:47

B:53

32

29

19

9

10

YE-RD

WH-VT

BN-RD

YE-RD

WH-VT

BN-RD

64/90

WH

-

+

GN-YE

BK

2

1

OG-BU

15/31

1

2

7/16

BN-WH

YE-VT

WH-VT

BN-WH

T

W/O T

T

W/O T

T

W/O T

A:42

A:22

A:12

A:67

63/120

BK

B:45

B:58

B:44

B:57

63/67

CAN

ECM

4/46.6

A:12

A:10

1

2

7/16

WH

BN BN

B:16

B:30

1

2

7/16

BN

B:36

B:13

CAN

ECM

4/46.7

5CYL

4CYL

1,6 L

4CYL 1,8 L

Group 26 Cooling system Cooling fan

TP 39103202 C30 2007 66

Group 26 Cooling system Cooling fan, Diesel

30+

15/31

1

F1

2

OG-BU

4/71

1

WH

4

WH-RD

BU

WH-VT

A:58

B:36

B:26

4/46.3

ECM

5CYL

DIESEL

2,4 L

CAN

A:60

A:56

BN-WH

WH-VT

7/16

1

2

4/46.5

ECM

4CYL

A:C4

-

+

GN-YE

6/29

1

2

BK-BU

63/109

BK

2

BK

64/90

BU/

BK-YE

BK-BU

34

5

19

BU/

BK-YE

WH-VT/ BK-BU

BK-RD

BK-BU

8/119

1

8/127

3

4

2

H

1

L

2 1

BK-YE

BK-BU

WH-RD

BK-YE

BK-BU

A:G3

A:B2

A:H2

A:D2

DIESEL

1,6 L

CAN

4/46.4

ECM

4CYL

DIESEL

2,0 L

CAN

B:F2

B:H1

C:A2

C:G1

WH

BN

WH

BN

7/16

1

2

7/16

1

2

31/114

63/120

BK

63/108

BK

31/110

TP 39103202 C30 2007 67

Group 27 Engine control

B:31

B:19

F36

2

1

5

GY

30+

5(87)

3(30)

2(85)

1(86)

1

2

F9

R14

2/32

1.6L

1.8L

2.0L.D

6

GN-YE

21

28

GY

1.8L

1.6L

BK-BU

A:47

GY

A:32

GY

A:F3

A:8

BK-BU

A:35

BK-BU

B:H3

RD-OG

15/31

BK-BU

64/90

A:41

A:30

A:A3

A:A4

GY

A:B3

1.6L.D

BK-BUB:E:1

DIESEL

(1.6/2.0L)

A:2

A:3

SWS

3/4

A:1

18/4

SWM

3/254

C:9

C:8

31/83

7/51

2

3

1

4

4/46.4-7

ECM

G:22

G:31

G:7

63/12

BK

BK-YE

WH

BN

BK-YE

CAN

WH-BU

WH-RD

BN

YE

WH-BU

YE-BU

WH-BU

WH-RD

BN

YE

WH-BU

YE-BU

ETA

6/120

A:48

A:22

A:6

A:21

B:42

B:41

M

1

2

3

4

5

6

64/111

1.6L

1.8L

7

YE

CEM

63/5

64/60

BK

C:4

BK-WH

31/84

F68

2

1

C:1

A:45

2/193:3

4/56

63/30

B:3

B:2

B:5

RD

WH

BN

7/124

1

3

2

CAN

BCM

4/16

15

11

22

3

21

OG-BK

CAN

G:15

G:14

F:14

F:16

F:6

F:3

F:5D:1

D:3

D:4

8

7

2

3

1

4

WH-BU

BK-OG

GN-RD

BN-BU

WH-BU

YE-BU

ETA

6/120

B:26

B:25

B:38

B:37

B:10

B:22

M

1

2

3

4

5

6

G:21

G:24

BN

GN-YE

MAN

3/39

2

3

4CYL

4/56

Cruise control, 4-cyl.

TP 39103202 C30 2007 68

A:2

A:3

SWS

3/4

A:1

18/4

SWM

3/254

C:9

C:8

B:58

B:45

F36

2

1

31/83

7/51

5

1

2

3

4

4/46.1-3

ECM

G:7

G:22

G:31

63/12

BK

BK-YE

GY

YE

WH

BK-YE

CAN

30+

5(87)

3(30)

2(85)

1(86)

1

2

F9

R14

2/32

YE

BK-OG

GN-RD

BN-BU

WH-BU

YE-BU

ETA

6/120

A:96

A:15

A:72

A:24

A:74

A:75

5CYL T

M

5CYL T

5CYL T 5CYL T

5CYL T

WH-BU

A:19

3

M

5

6

4

A:74

YE-BU

A:88

WH-BU

BN-BU

A:65

5CYL W/O T

W/O T

T

2.4L.D

ETA

6/120

2

1

A:75

BK-OG

GN-RD

A:14

5CYL W/O T

5CYL W/O T 5CYL W/O T

5CYL W/O T

1

2

3

4

5

6

GN-YE

64/111

21

28

7

BN

GY

2.4L.D

Turbo

BK-BU

B:26

GY

B:26

GY

B:47

B:16

BK-BU

B:27

BK-BU

B:42

CEM

7/123

G:12

G:23

G:21

BN

YE

WH

3

2

1

5CYL T

5CYL T 5CYL T

5CYL

Diesel

Diesel Diesel

Diesel

Petrol

T

BK-BO

A:67

2

M

6

3

A:18

YE-BU

WH-BU

A:11

ETA

6/120

4

1

A:24

BN-BU

GN-RD

A:72

63/5

BK

C:4

BK-WH

31/84

F68

2

1

C:1

A:45

2/193:3

RD-OG

15/31

BK-BU

4/56

63/30

B:3

B:2

B:5

64/90

RD

WH

BN

7/124

1

3

2

CAN

BCM

4/16

15

11

22

3

21

OG-BK

CAN

G:15

G:14

F:14

F:16

MAN

F:6

F:3

F:5D:1

D:3

D:4

B:54

B:41

B:22

B:23

5CYL

Group 27 Engine control Cruise control, 5-cyl.

TP 39103202 C30 2007 69

A:3

VOLT. REG.

6/26

M

6/25

31/4

31/3

BK

B:1

RD

1

2

PF1

GY

12V

1/1

- +

A:1 A:2

BU

GY

BU

A:A1

B:H4

B:15

B:20

F31

2

1

20

64/90

RDRD

15/31

B+

A:1

ECM

4/46.6

CAN

1.8/2.0 L

ECM

4/46.4

CAN

A:7

A:33

ECM

4/46.7

CAN

1.6 L

C:B1

B:A3

ECM

4/46.5

CAN

LIN

ACM

DIESEL

2,0 L

DIESEL

1,6 L

PF2

2

1

RD

Group 32 Alternator and voltage regulator Power supply, 4-cyl.

TP 39103202 C30 2007 70

A:1

VOLT. REG.

B+

6/26

M

6/25

31/4

31/3

BK

B:1

RD

12V

1/1

- +

A:1

CAN

4/46.1

ECM

CAN

4/46.2

ECM

2.5L

Turbo

2.4L

A:46

CAN

4/46.3

ECM

2.4L

Diesel

A:88

WH-RD

LIN

ACM

1

2

PF1

Group 32 Alternator and voltage regulator Power supply, 5-cyl.

TP 39103202 C30 2007 71

12V

1/1

1

F26

2

E:9

CEM

4/56

RD

A:42

CAN

BK-RD

3/1

30

15X

5

50 S

B:7

B:2

4 11

64/90

64/120

31/3

BK

31/4

BK

1

F13

2

5

64/1

11

GY

BK-RD

GY-BK

15/31

2

PF2

1

5

1

R13

2/35

3

2

PF1

1

RD

RDRD

3/39

2

3

BN

GN-YE

G:24

G:21

RD-GN

6/26 B:1

RD

M

A:1

6/25

B:1

4/46.7

B:30

4/46.4

A:1D

4/46.6

A:4

4/46.5

C:1A

GY

BK-RD

1

CAN

ECM

2,0 L D

CAN

ECM

1,6 L

CAN

ECM

1,6 L D

CAN

ECM

1,8 L

MAN

Group 33 Starting system Starting system, 4-cyl.

TP 39103202 C30 2007 72

Group 33 Starting system

12V

1/1

1(86)

3(30)

1

R13

2/35

F13

2

E:9A:17

E:1

CEM

4/56

RD

BN

A:42

CAN

BK-RD

3/1

30

15X

5

50 S

B:7

B:2 B:3

RD

GY-BK

GY

4631 9

64/90

5(87)

2(85)

CAN

4/28

TCM

A:5

A:9

31/52

BK-YE

31/3

BK

31/4

BK

1

F26

2

5

64/111

RD-GN

RD

CAN

4/46.1

ECM

B:15

63/53

BK

B:17

B:11

B:30

B:8

CAN

4/46.2

ECM

B:13

B:15

B:17

B:11

B:9

GN-BU

BK-RD

GY

64/90

GN-BU

GN-YE

GN-YE GN-YE

GN-BU

GY-WH

LIN

15/31

B:1

6/26

B+

G

31

2

PF1

1

MAN

AUTO

3

2

1

7/123

BN

WH

YE

G:21

G:23

G:12

M

A:1

6/25

B:1

GN-BU

GN-WH

2

PF2

1

RD

ACM

1

2

F54

11

13

31/110

BK

63/108

BK BK

63/109

WH-RD

MAN

2

1

B:20

14

64/113

1

2

3/271

4/93

CAN

KVM

LIN

2,5 L T

2,4 L

GN-YE

Starting system, 5-cyl.

TP 39103202 C30 2007 73

12V

1/1

1(86)

3(30)

1

R13

2/35

F13

2

E:9E:1

CEM

4/56

RD

GY

A:42

CAN

3/1

30

15X

5

50 S

B:7

B:2

RD

4 31 9

64/90

5(87)

2(85)

CAN

4/28

TCM

A:5

A:9

31/52

BK-YE

31/3

BK

31/4

BK

1

F26

2

5

64/111

RD-GN

RD

GN-YE

GN-BU

GY-BK

RD

63/53

BK

4/46.3

B:34

B:41

B:44

B:29

B:33

GN-BU

BK-RD

GY

BK-RD

GN-BU

GY-WH

LIN

15/31

B:1

6/26

B+

G

31

2

PF1

1

AUTO

M

A:1

6/25

B:1

2

PF2

1

RD

ACM

20

LIN

CAN

ECM

2,4 L D

7/123

G:12

G:23

G:21

BN

YE

WH

3

2

1

MAN

11

Group 33 Starting system Starting system, 5-cyl. Diesel

TP 39103202 C30 2007 74

3/254

30+

1

2

SWM

F18

1

2

F4

CAN

CEM

F58

2

11

1

2

54

3

F59

C:7

31/10

CAN

R8

2/63

31/114

63/121

63/109

63/25

15/31

RD-BU

RD-YE

E:21

E:22

B:31

E:25

B:2

E:37

E:27

A:28

E:11

WH-VT

BK

BKBKBK

BK

GN-BK

GN-VT

GN-OG

GN-WH

BK

BK-GN

LIN

4/56

M

-

+

L

HIGH

LOW

PARK

TURN

10/1

4

93

10/68

10/70

M

-

+

L

LOW

HIGH

PARK

TURN

10/2

3

9

4

10/66

63/6

31/6

11

6

BK BK

31/110

10/64

CAN

9

10

5/1

DIM

B:9

B:8

63/120

63/108

3/111

0

1

2

SUPPLY

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

LIGHTS ON

FF = FRONTFOG

RF = REAR FOG

Group 35 Lighting High and low beam

TP 39103202 C30 2007 75

3/254

30+

1

2

SWM

F18

1

2

F4

CAN

CEM

F58

2

11

2

F59

C:7

31/10

CAN

R8

2/63

31/114

63/121

63/109

63/25

15/31

RD-BU

RD-YE

E:21

E:22

B:31

A:40

E:37

E:27

A:28

E:11

WH-VT

BK

GN-BK

BK

LIN

4/56

63/6

31/6

11

14

BK

31/110

M

PARK

TURN

10/1

9

HIGH BEAM ACTUATOR

ELEC. BALLAST

LEVELING

MAIN

AUX.

361211 28

LIN

GDL

MASTER

B:1

B:6

B:5

B:3

B:4

63/92

E:25

GN-OG

M

PARK

TURN

10/2

9

HIGH BEAM ACTUATOR

ELEC. BALLAST

LEVELING

MAIN

AUX.

361211 28

LIN

GDL

SLAVE

B:1

B:6

B:5

B:3

B:4

63/93

A:9

A:5

G:26

B:4

B:2

6

5

A:5

A:9

A:12

A:10

A:11

A:10

A:11

BK

GY-RD

BN-RD

GN-BKGN-BK

GN-VT

GN-BK

GN-OGGN-OG

4/113

4/112

BK-BU

BK-GN

OG-BK

WH-RD

WH-GN

WH-BU

GY-RD

BN-RD

WH-RD

WH-GN

WH-BU

CAN

9

10

5/1

DIM

B:9

B:8

WH-RD

BK

WH-BK

63/120

63/108

BK

3/ 111

0

1

2

SUPPLY

POS 0

POS 1

POS 2

FRONTFOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

LIGHTS ON

FF = FRONTFOG

RF = REAR FOG

LOW

HI DRTL

LOW

HI DRTL

Group 35 Lighting High and low beam (Bi-Xenon)

TP 39103202 C30 2007 76

63/6

31/6

M

+

-

L

LOW

HIGH

PARK

TURN

1

2

F46

M

+

-

L

LOW

HIGH

PARK

TURN

11

63/139

64 / 111

10/1

10/2

4/56

12

106

10

6

12

10 13

BK

OG

A:38

BU

9

64/111

6/38

6/39

63/124

BU

BK

BU

BK

8

BK

30+

15/31

CAN

CEM

LIN

14

A:40

OG-BK

OG

1

2

F18

1

2

F4

E:21 E:22

RD-BU

RD-YE

18

OG

3/ 111

0

1

2

SUPPLY

POS 0

POS 1

POS 2

FRONTFOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

LIGHTS ON

FF = FRONTFOG

RF = REAR FOG

2/89

R1

Group 35 Lighting Manual beam length adjustment

TP 39103202 C30 2007 77

1

2

54

3

30+

1

2

F18

1

2

F4

CAN

CEM

31/114

15/31

RD-BU

RD-YE

E:21

E:22

BK

LIN

4/56

31/110

M

PARK

TURN

10/1

HIGH BEAM ACTUATOR

ELEC. BALLAST

LEVELING

MAIN

AUX.

61211 28

LIN

GDL

MASTER

B:1

B:6

B:5

B:3

GY-RD

BN-RD

4/112

7/121

1

4

5

BN

WH

YE

64/113

19

27

20

7/120

4

1

5

64/50

8

7

9

A:4

A:3

A:2

A:1

BN

WH

YE

A:12

5410

WH-RD

WH-GN

WH-BUBNWH

GN-YE

B:4

B:2

B:7

B:8

M

PARK

TURN

10/2

HIGH BEAM ACTUATOR

ELEC. BALLAST

LEVELING

MAIN

AUX.

6121128

GDL

SLAVE

B:1

B:6

B:5

B:3

GY-RD

BN-RD

4/113

5410

WH-RD

WH-GN

WH-BUBNWH

GN-YE

B:4

B:2

B:7

B:8

BN

WH

YE

A:11 A:11

A:10

WH

BN

YE

WH

G:26

WH-RD

WH-BK

BK

63/121

BK

63/109

1

2

F59

R8

2/63

2

F58

E:11

E:27E:25E:37

1

3

A:5

GN-BK

63/92

3

A:5

GN-OG

63/93

GN-OG

GN-BK

GN-BK GN-OG

LIN

2

1

A:6

A:9

A:6

GN-YE

GN-VT

63/91G

GN-YE

A:9

GN-BK

GN-YE

E:29

F51

50 S X 15

3/1

30

5

B:7

RD

5

64 / 111

B:3

GN-WH

A:17

1

2

F26

63/120 63/108

BK

RD

LOW

HI DRTL

LOW

HI DRTL

Group 35 Lighting Automatic beam length adjustment (Bi-Xenon)

TP 39103202 C30 2007 78

63/120

LIN

F:14

F:16

G:14

G:15

30+

1

CEM

4/56

2

F42F18

C:12

1

15/31

C:14

RD-BU

RD-YE

BK

GY-OG

BU-GY

14

5

11

OG-BK

BK-BU

M

+

-

L

LOW

HIGH

PARK

TURN

M

+

-

L

LOW

HIGH

PARK

TURN

10/1

10/2

4

7

C2:3

C2:2

C4:4C1:1

C1:4

C3:3

C3:2

C4:1

7

4

10/12

10/11

10/51

10/52

10/44

10/45

10/17

E:21

E:22

E:13

G:2

A:40

B:4

31/6

63/6

BK

63/108

BK

31/11431/11031/1231/11

BK

OG-BU

OG

OG-WH

OG-GN

CAN

10/3

B:1

2

1

64/791

63/11

BK

63/174

BK-WH

63/175

BK

BK-YE

OG-BK OG-BK

C:13

63/121

63/109

BK

REVERSE

POSITION

TURN

POSITION

FOG

OG-BU

BK-BU

10/18

REVERSE

POSITION

TURN

POSITION

FOG

A:1

63/11G

A:2 B:2

BK-GN BU-BK

RD-BK

64/791

3/111

0

1

2

SUPPLY

POS 0

POS 1

POS 2

FRONTFOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

LIGHTS ON

FF = FRONTFOG

RF = REAR FOG

Group 35 Lighting Position/Parking lights, Tail lights

TP 39103202 C30 2007 79

M

PARK

TURN

10/2

9

10/12

10/11

HIGH BEAM ACTUATOR

ELEC. BALLAST

LEVELING

MAIN

AUX.

7

M

PARK

TURN

10/1

9

HIGH BEAM ACTUATOR

LOW

HI DRTL

ELEC. BALLAST

LEVELING

MAIN

AUX.

7

LOW

HI DRTL

63/120

LIN

F:14

F:16

G:14

G:15

30+

1

CEM

4/56

2

F42F18

C:12

1

15/31

C:14

RD-BU

RD-YE

BK

14

5

11

OG-BK

BK-BU

E:21

E:22

E:13

G:2

A:40

B:4

31/6

63/6

BK

63/108

BK

31/11431/110

BK

OG-BU

OG-GN

CAN

C:13

63/121

63/109

BK

GY-OG

BU-GY

C2:3

C2:2

C4:4C1:1

C1:4

C3:3

C3:2

C4:1

10/51

10/52

10/44

10/45

10/17

31/1

31/1231/11

OG

OG-WH

63/174

BK-WH

63/175

BK

REVERSE

POSITION

TURN

POSITION

FOG

OG-BU

BK-BU

10/18

REVERSE

POSITION

TURN

POSITION

FOG

10/3

B:1

2

1

64/791

63/11

BK

BK-YE

OG-BK OG-BK

A:1

63/11G

A:2 B:2

BK-GN BU-BK

RD-BK

64/791

3/111

0

1

2

SUPPLY

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

LIGHTS ON

FF = FRONTFOG

RF = REAR FOG

Group 35 Lighting Position/Parking lights, Tail lights (Bi-Xenon)

TP 39103202 C30 2007 80

63/121

BK

CAN

5/1

DIM

10

9

F29F4

2 2

30+

1 1

2

1

31/114

BK

2

10/5

1

GN-WH

CAN

4/56

CEM

8

LIN

F18

31/110

BK

63/109

BK

2

10/6

1

11

31/6

31 7

B:6

B:22

B:23

A:32

GN-BU

BK-YE

GN-YE

LHD

RHD

GN-OG

G:9E:22E:21

15/31

RD-YE

RD-BU

BK-YE

GN-WH

63/6

BK

1

2

3

5

2/34

R4

RD-OGRD-OG

RD-GN

63/120

BK

63/108

10/53

10/46

BK

BU-GY

C2:2

C2:1

C1:2

C1:4

C3:2

C4:1

10/17

31/1231/11

63/174

BK-WH

63/175

BK

REVERSE

POSITION

TURN

POSITION

FOG

BK-BU

10/18

REVERSE

POSITION

TURN

POSITION

FOG

C:6

3/111

0

1

2

SUPPLY

POS 0

POS 1

POS 2

FRONTFOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

LIGHTS ON

FF = FRONT FOG

RF = REAR FOG

Group 35 Lighting Fog lights

TP 39103202 C30 2007 81

63/121

BK

CAN

5/1

DIM

10

9

F29F4

2 2

30+

1 1

2

1

31/114

BK

2

10/5

1

GN-WH

CAN

4/56

CEM

LIN

F18

31/110

BK

63/109

BK

2

10/6

1

31/6

C:6

B:6

B:22

B:23

A:32

GN-BU

BK-YE

GN-OG

G:9E:22E:21

15/31

RD-YE

RD-BU

BK-YE

GN-WH

63/6

BK

GN-YE

1

2

3

5

2/34

R4

RD-OGRD-OG

RD-GN

63/120

BK

63/108

BK

10X/18C1

2

4 2

10X/18C1 10X/17C2

GN-YE

BU-GY

C2:2

C2:1

C1:4

C3:2

C4:1

10/17

31/12

31/11

63/174

63/175

10/46

BK BK-WH

BK-BU

BK BK

OG-GY

REVERSE

POSITION

TURN

POSITION

FOG

BK-BU

10/18

REVERSE

POSITION

TURN

POSITION

FOG

8

11

31 7

3/ 111

0

1

2

SUPPLY

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

LIGHTS ON

FF = FRONT FOG

RF = REAR FOG

Group 35 Lighting Fog lights LHD Japan

TP 39103202 C30 2007 82

1

2

3/9

2

1

10/19

BN

64/48A

WH

CAN

F:14

F:16

G:14

G:15

30+

1

CEM

4/56

2

64/48A

1

2

F4

2

F18

2

F57

E:21

E:22

E:28

E:41

C:7

C:4

1

OG-WH

OG

OG-BK

OG-YE

15/31

C:3

RD-BU

RD-YE

BK

LIN

64/90

8

E:40

GN-WH

ECM

BU-GY

C2:2

C1:4

C3:2

C4:1

10/17

31/1231/11

63/174

63/26

BK-WH

63/175

BK

REVERSE

POSITION

TURN

POSITION

FOG

BK-BU

BK-WH BK

10/18

REVERSE

POSITION

TURN

POSITION

FOG

C5:2

C5:1

STOP

C6:2

C6:1

STOP

10/50

10/43

Group 35 Lighting Brake light

TP 39103202 C30 2007 83

BK

GN-BK

CAN

F:14

F:16

G:14

G:15

A:6

A:8

TCM

4/28

30+

F18

2

11

2

F4

MAN

63/53

GN-BU

GN-WH / GN-YE

64/90

10

31/52

E:14

4/56

AW55-51

CEM

3/10

2/3

1

BK

F79

2

1

LIN

CAN

LIN

15/31

C:45

E:21

E:22

2/80

R2

3/156

A:7

64/90

RD RD

33

64/111

2

LIN

3/155

GSM

RD

AUTO

RD-YE

RD-BU

BU-GY

C2:2

C2:1

C3:1

C1:4

C3:2

C4:1

10/17

31/1231/11

63/174

BK-WH

63/175

BK

10/48

10/55

BK

REVERSE

POSITION

TURN

POSITION

FOG

BK-BU

10/18

REVERSE

POSITION

TURN

POSITION

FOG

Group 35 Lighting Reversing light

TP 39103202 C30 2007 84

21

BK

1

2

F18

30+

64/41

64/43

6 13

64/35

6 13

64/333

RD-YE

CAN

64/43

20

BKBK

31/116

A:9A:9

31/115

BK BK

20

B:13

B:12

3/126

DDM PDM

3/127

64/41

B:12

B:13

A:3

A:12 A:12

A:3

A:18 A:18

BK

y

M

x

M M

F

6/62

y

M

x

M M

F

6/63

MEM

X

MEM

Y

MEM

X

MEM

Y

E:21

1

2

F82

4/56

2

F83

1

BK

C:31 C:24

BK

15/31

10/148 10/149

BKBK

GN-YE GN-YE

Group 35 Lighting Follow-me-home lighting

TP 39103202 C30 2007 85

BK

63/211

63/213

A:1

OG

10/114

10/115

31/10

2

3

10/150

10/22

10/29

BK

F4

2

1

1 3

1

3

2

1

63/139

OG

2

10/97

1

2

OG

10/102

F18

RD-YE

2

1

30+

2

1

OG-YE

BK

BK-YE

63/25

BK

BK-BU

BK

CEM

CAN

LIN

A:4

1On

12321 21

2Off 3Ctsy

3/117

MAP READING

A:2

A:10

3/1

30

15X

5

50 S

B:7

B:1

F26

64/111

5

RDRD

RD-BU

YE

A:30 E:22

15/31

2/89

R1

A

E:21

F862F47

2

11

2

F46

1

2

F73

1

2

3/78

M

A:38

D:7

A:25

A:5

A:3

D:3

H:4

63/10

OG OG

OG-YE

D:12

A:28

3

5

C:20

F:24

4

2

10/24

63/173

BK-BU

BK

31/11

BK

63/174

4/56

1

OG-BU

BK-RD

OG-BU

Group 35 Lighting Interior lighting 1:2

TP 39103202 C30 2007 86

2

F822F83

11

64/43

3/127

A:11

A:12

A:3

CAN

PDM

A:18

BK

3/75

BK

3/74

BK

A:11

BK

64/43

20

3/126

64/41

DDM

F:18

F:19

21

CAN

A:18

21

A:3

A:2

BK

C:31

C:24

A:9

31/116

BK

BN-OG

BN-WH

A:9

64/41

20

BK

31/115

BK

RHD

LHD

BK

CLOCK

DLOCK

UNLOCK

FEEDBACK

LOCK

AJAR

4

212

1

DLOCK

CLOCK

UNLOCK

FEEDBACK

LHD

8

1

RHD

LOCK

212

AJAR

1

LHD

RHD

1 8

4

CAN

LIN

CEM

A

4/56

3

64/41

BK

64/43

BK

3

BK

RHD

LHD

63/198

63/195

Group 35 Lighting Interior lighting 2:2

TP 39103202 C30 2007 87

CAN

63/6

31/10

9

10

B:9

B:8

F:15

F:30

30+

1

CEM

4/56

5/1

DIM

31/6

2

F42F18

2

F46

A:1

1

15/31

B:21

RD-BU

RD-YE

A:38

3/286

64/25G

3

2

BK

3

2

12

9

11

63/25

BK

BK-RD

OG-BU

BK

OG-BU

1

4

E:21

E:22

LIN

3/126

DDM

A:13

LIN

3/127

PDM

R1

2/89

A:3

A:12

A:3

A:12

A:13

3

CAN

63/139

OG OG

OG-BU

OG

13

LIN

CAN

3/111

0

1

2

SUPPLY

POS 0

POS 1

POS 2

FRONTFOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

LIGHTS ON

FF = FRONTFOG

RF = REAR FOG

Group 35 Lighting Instrument and control illumination

TP 39103202 C30 2007 88

31/52

30+

1

2

F4

15/31

1

2

FH1

D:8

R8

154

23

1

2

F58

D:9

E:22

RD-BU

63/25

31/10

BK

CEM

CAN

LIN

4/56

A:28

2/63

1

2

1

10/69

10/65

2

4

30

1

3

2/64

85

87

86

5

2

3/60

1

BK

RD

RD RD

BK BK

BK

GN

GN-RD

RD

Group 35 Lighting, Accessories Auxiliary lights

TP 39103202 C30 2007 89

Group 36 Additional electrical equipment

BK

64/43

63/109

BK

20

63/5

BK-OG

LIN

3/6

B:19

10

3

5

1

B:3

BU

BU-RD

E:21

4/56

CEM

BU-RD

BK-OG

F18

2

1

30+

31/83

31/110

31/116

BK

y

M

x

M M

F

6/63

MEM

X

MEM

Y

CAN

PDM

E:22

F4

2

15/31

1

64/43

21

B:14

B:12

A:3

A:12

DDM

64/41

21

B:12

B:14

CAN

BK

C:31

C:24

BK

A:18A:18

3/127

3/126

BU

BU-OG

C:10 E:39C:9E:38

BK

A:9

64/41

20

31/115

BK

63/121

BK

31/114

BK

A:9

y

M

x

M

F

6/62

MEM

X

MEM

Y

M

-

+

L

HIGH

LOW

PARK

TURN

10/1

4

10/13

M

-

+

L

LOW

HIGH

PARK

TURN

10/2

4

10/14

10/16

10/15

1

BK

BN-OG

RD-YE

RD-BU

BK

BK-BU

CAN

63/108

BK

63/120

BKBK

F83

2

1

F82

2

1

A:3

A:12

5/1

CAN

DIM

9

10

CAN

3/254

SWM

C:8

C:9

BU-GY

C2:2

C4:3

C3:4

C1:4

C3:2

C4:1

10/17

31/12

31/11

63/174

BK-WH

63/175

BK

REVERSE

POSITION

TURN

POSITION

FOG

BK-BU

10/18

REVERSE

POSITION

TURN

POSITION

FOG

6 12

64/35

6 12

64/333

10/47

10/54

Direction indicator and hazard warning flashers

TP 39103202 C30 2007 90

BK

63/109

BK

31/83

63/5

BK-OG

LIN

3/6

B:19

10

3

5

1

B:3

BU

BU-RD

E:21

4/56

CEM

BU-RD

BK-OG

F18

2

1

30+

BK

y

M

x

M M

F

6/63

MEM

X

MEM

Y

CAN

PDM

E:22

F4

2

15/31

1

64/43

21

B:14

B:12

A:3

A:12

DDM

64/41

21

CAN

BK

C:31

C:24

BK

A:18A:18

3/127

3/126

BU

BU-OG

C:10 E:39C:9

E:38

31/110

BK

A:9

64/41

20

31/115

BK

31/114

A:9

10/16

RD-YE

RD-BU

CAN

63/108

64/43

20

31/116

BK

M

PARK

TURN

10/2

9

10/14

HIGH BEAM ACTUATOR

ELEC. BALLAST

LEVELING

MAIN

AUX.

1

BK

63/121

63/120

BK

PARK

TURN

10/1

9

10/13

HIGH BEAM ACTUATOR

ELEC. BALLAST

LEVELING

MAIN

AUX.

1

M

5/1

CAN

DIM

9

10

CAN

3/254

SWM

C:8

C:9

A:3

A:12

F83

2

1

F82

2

1

BK

B:12

B:14

y

M

x

M

F

6/62

MEM

X

MEM

Y

10/15

LOW

HI DRTL

LOW

HI DRTL

BK

BK-BU

6 12

64/35

BK

BN-OG

6 12

64/333

BU-GY

C2:2

C4:3

C3:4

C1:4

C3:2

C4:1

10/17

31/1231/11

63/174

BK-WH

63/175

BK

REVERSE

POSITION

TURN

POSITION

FOG

BK-BU

10/18

REVERSE

POSITION

TURN

POSITION

FOG

10/54

10/47

Group 36 Additional electrical equipment Direction indicator and hazard warning flashers (Bi-Xenon)

TP 39103202 C30 2007 91

3/254

30+

1

2

SWM

F26

1

2

F17

CAN

CEM

F68

2

254

13

254

13

1

CAN

R7 A

2/92

15/31

RD-OG

A:17

G:3

E:8

LIN

4/56

1

2

3/1

30

15X

5

50 S

B:7

B:3

6/1 LHD

WMM

R18

2/193

R7 B

2/93

F48

63/108

31/110

31/10

6/1 RHD

WMM

LINLIN

64/111

5

1

2

F3

4

1

3

1

4

2

WH-GN

BK BK

WH-GN

RD RD

GN-WH

E:20

C:9

C:8

31/83

63/5

E:12

BK-WH

OG-BK

BK

C:1

C:4

A:45A:28

63/25

BK BK

F:16 F:14

WH-BK

YE-BK

BK

6/2

45

1

3

2

M

64/79V

4

64/79V

1

5cyl

5cylPetrol

Petrol

YE-BK

WH-BK

YE-BK

Group 36 Additional electrical equipment Wiper/washer

TP 39103202 C30 2007 92

Group 36 Additional electrical equipment

30+

1

F11

2

CEM

CAN

OG-BK

G:11

A:40

BK-RD

BK-GN

RD-WH

B:2

1(86)

3(30)

2/182

2(85)

R9

5(87)

RD-BK

63/108

31/110

6/104

GN-YE

31/6

BK BK

63/6

4/56

LIN

BK BK

1

2

15/31

14

6

11

64/79V

2

5cyl

4cyl

GN-YE

5cyl

4cyl

64/79V

5

BK

3/111

0

1

2

SUPPLY

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

LIGHTS ON

FF = FRONT FOG

RF = REAR FOG

Headlight washer

TP 39103202 C30 2007 93

3/254

30+

1

2

SWM

F26

CAN

CEM

F68

CAN

R11 A

2/16

15/31

RD-OG

A:17

LIN

3/1

30

15X

5

50 S

B:7

B:3

5

2

R18

2/193

3

1

4

R7 A

2/92

31/10

64/111

5

1

2

F3

RD RD

GN-WH

E:20

C:9

C:8

31/83

63/5

BK-WH

OG-BK

BK

C:1

C:4

A:45

A:28

63/25

BK BK

R7 B

2/93

F48

1

2

1

64/48

3

5

1

31/11

63/174

63/196

C:34C:33

WH-RD

GN-BU

BKBK

BK

BKBK

6/32

1

2

3

F:16

F:14

4/56

E:8

1

2

E:12

WH-BK

YE-BK

6/2

64/79V

4

64/79V

1

5cyl

YE-BK

WH-BK

YE-BK

254

13

254

13

254

13

Group 36 Additional electrical equipment Rear window wiper/washer

TP 39103202 C30 2007 94

DIM

9

10

5/1

30+

1

2

F3

SWM

3/254

C:9

C:8

CAN

15/31

2

F26

1

30

15

50 XS

5

B:3

B:7

RD

5

RD

3/1

64/111

1

2

F69

2/193

1

2

5

4

7/149

WH-GN

OG-BK

2

3

1

CEM

31/84

CAN

BK

3 LHD

31/110

RSM

LIN

63/12

2 RHD

1 LHD 4 RHD

G:3 A:14

BK

63/214

BK

H:7

H:23

D:10

R18

4/56

E:20

GN-HW

RD-OG

WH-GN

A:17

LIN

6/1

WMM

LIN

63/108

BKBK

3

W/O KVM

BK

31/10

BK

63/25

A:28

BK

M

Group 36 Additional electrical equipment Rain sensor

TP 39103202 C30 2007 95

Group 36 Additional electrical equipment

2

1

G:18

B:26

CEM

4/56

31/83

BK

C:2

C:4

BK-BU

31/114

3/254

SWM

18/4

3/37

CAN

63/121

OG-BU

BK

16/11

1

2

1

16/10

63/5

BK-WH

LIN

BK

OG-BU

BK

BK-BU

OG-BU

30+

1

F20

2

RD-OG

1

3

2/17

4

2

R2

5

RD-BU

15/31

D:4

D:2

F:3

F:4

B:5

B:4

63/120

BK

63/30

OG-BU

Horn

TP 39103202 C30 2007 96

Group 36 Additional electrical equipment

F4

2

1

30+

1

2

F18

CAN

CEM

SCL

4/56

31/83

63/5

E:21 E:22

LIN

RD-YE

RD-BU

15/31

BK

G:14

1

2

F26

64/111

5

63/339

WH-GN B:17WH-GN

A:15

B:13

BK-YE

WH-GN

RD-BK

RD-GN

A:2

A:1

A:3

B:5

B:6

B:8

RD RD

B:7

PATS

MODULE

0

1

2

3

KEY ININHIBIT

3

2

1

0

B05

IMOBILIAIZER SUPPLY

S

B1

B2

5015X

B4

30

POWER

GROUND

3/1

LIN

SCU

G:15

F:16

F:14

A:42GY-BK

BK-RD

B:2

B:3

B:1

31/6

63/6

BK

WH-GN

OG-BK

3

4

2

4/102

B:10

R13

2/35

45

1

3

2

F13

2

1

64/90

11 9 3 1 4

RD-GN

BK-RD

GY

BK-RD

B:8

4/46.1

64/120:1

ECM

GN-BU

BK-RD

GY GN-BU GN-BU

GN-BU

I5

I4

E:9

63/88

BK-RD

B:9

4/46.2

4/46.4

4/46.6

BK-RD

A:D1

A:4

4/46.7

4/46.5

B:30

C:A1

CAN

ECM

4CYL

1,6 L D

CAN

ECM

4CYL

1,6 L

CAN

ECM

4CYL

1,8 L

CAN

ECM

4CYL

2,0 L D

CAN

ECM

5CYL

2,4 L

B:44

4/46.3

CAN

ECM

5CYL

2,4 L D

CAN

ECM

5CYL

2,5 L T

Immobilizer/Steering column lock module (SCL)

TP 39103202 C30 2007 97

Group 36 Additional electrical equipment

POWER

30+

1

2

F18

1

2

F4

63/88

4/93

KVM

CAN

15/31

E:22 E:21

3

2

1

H:6

D:10

H:3

GY-RD

BU-RD

BK BK

OG-YE

OG-WH

OG

WH-BK

WH

31/83 31/11 31/11031/67

1

2

F26

RD-YE

RD-BU

CAN

4/56

CEM

C:32

C:41

A:15 C:26

RD-BK

RD-GN RD-GN RD-GN

BK BK-YE

RD-GN

BK-YE

BK

A:1

A:3

B:5

B:6

RD

B:7

PATS

MODULE

0

1

2

3

KEY IN INHIBIT

3

2

1

0

B05

IMOBILIAIZER SUPPLY

S

B1

B2

5015X

B4

30

POWER

GROUND

3/1

LIN

SCU

64/111

5

63/5

BK

BKBK

BK

63/196

63/174

63/108

BK

31/66

BK

63/171

63/172

BK BK

63/109

63/214

10/3

3/35

1

2

B:4

B:3

C:4

B:5

D:15

D:14

B:20

C:5

B:17

1

64/48

8

64/112

WH-RD

MAN

RHD

LHD

MAN

WH-RD

BK-WH

2

1

14

64/113

2

64/48

1

2

3/271

F55

1

2

4/103

RKE

Keyless vehicle 1:2

TP 39103202 C30 2007 98

4/93

KVM

CAN

D:9

D:8

D:10

A:4

D:22

D:4

A:5

BK

BN-WH

WH

BK

WH

BK

RHD

BK

RHD

BK

RHD

BK

RHD

PAS S ENGER DOOR

DRIVER DOOR

21

1

2

63

3/259

3/263

1

3/75

11

64/43

12

14

15

5

13

6

E:18

E:1

E:20

E:22

E:4

E:2

WH-GN

GY-OG

WH-VT

WH

GY

GY-WH

E:14

E:15

WH-BK

GY-BK

16/132

1

A:11

2

P1

P2

2

16/133

1

2

1

P1

P2

16/134

P1

P2

16/135

2

1

P2

P1

16/129

4

5

P1

P2

63/195

4

2

3

12

LOCK

UNLOCK

RELEASE

CLUTCH

A:15

A:14

D:11

A:3

D:20

D:2

A:2

BK

BN-OG

WH

BK

WH

BK

RHD

BK

RHD

BK

RHD

BK

RHD

21

63

3/258

3/262

4

3/74

11

64/41

12

14

15

5

13

6

16/128

4

5

P1

P2

63/198

1

3

2

12

M

LOCK

UNLOCK

RELEASE

CLUTCH

BN-OG

1

2

1

2

1

2

CAN

3/126

DDM

CAN

3/127

PDM

Group 36 Additional electrical equipment Keyless vehicle 2:2

TP 39103202 C30 2007 99

15

1

15

3

2

6

5

4

F26

2

1

30+

15/31

5

B:7

30

B:3

50 S X15

5

1

2

F51

A:17

C:38

GN-WH

RD RD RD

64/111

3/1

4/56

31/11

BK BK

CAN

CEM

PAM

4/86

CAN

15

5

15

2

15

1

15

4

C:11

C:8

C:5

C:3

C:2

C:4

YE-RD

WH

WH-RD

WH-BU

WH-GN

BN-RD

63/415

7/134

7/133

7/132

7/131

1

3

2

1

3

2

1

3

2

1

3

2

1

63/416

YE-RD

WH

BN-RD

WH-RD

BN-RD

YE-RD

WH-GN

WH-BU

BN-RD

64/53

RD

64/322

GY-RD

BU-RD

4/110

A:1

RD

BK

A:8

A:14

A:7

GYBK-RDGY-RD

BU-RDBU-RD

B:1B:4 B:2

63/421

63/420

63/422

63/174

GY

BK

-RD BU-RD

RR/O

RR/I

LR/I

LR/O

TRM

CAN

Group 36 Additional electrical equipment Rear parking assistance

TP 39103202 C30 2007 100

Volvo C30 2007 User Manual

Specifications and Main Features

Frequently Asked Questions

User Manual

VOLVO C30

TP 39103202

Table of Contents 1:3

Table of Contents 2:3

Table of Contents 3:3

How to use the wiring diagrams 1:2

How to use the wiring diagrams 2:2

Electrical distribution 1:2

Electrical distribution 2:2

Data communication, Low speed CAN 2:2

Data communication LIN 1:2

Group 27 Engine control

Cruise control, 4-cyl.

Starting system, 5-cyl.

Group 36 Additional electrical equipment

Direction indicator and hazard warning flashers

Headlight washer

Horn

Immobilizer/Steering column lock module (SCL)

Keyless vehicle 1:2