Viking w-3000 Service Manual

PPrraaccttiicce

e

T

T

EELLEECCOOM

M

S

S

OOLLUUTTIIOONNSSFFOORRTTHHE

E

221

1

SST

T

C

C

EENNTTUURRY

Y

TECHNICAL

TECHNICAL

Answer Your Door or Gate from any

Phone in Your Home or Business

Answer your door or gate from the safety of your telephone!

The W-3000 weather resistant, handsfree doorbox provides an
attractive and vandal resistant stainless steel faceplate. It is
designed to interface directly with the unused telephone line input
of nearly any phone system. One or two doorboxes can also share
an existing residential phone line when used with a C-1000A door-
box controller.

When the “Call“ button is pressed, the doorbox generates a stan­dard or custom ring cadence of an adjustable number of rings. For

FFeeaattuurrees

s

PPhhoonnee......771155..338866..8888661

1

Power: 120V AC/13.8V AC 1.25A UL listed adapter provided
Dimensions: Overall - 127mm x 127mm x 57.2mm (5.0” x 5.0”

x 2.25”) Plastic Rough-In Box - 102mm x 102mm x 54mm (4.0” x

4.0” x 2.12”)

Shipping Weight: 1.81 Kg (4 lbs)
Operating Temperature: -26°C to 54°C (-15°F to 130°F)
Humidity: W-3000 - 5% to 95% non-condensing humidity, W-

3000-EWP - Up to 100% condensing humidity

Ringer Output: 20 Hz, 3.0 REN load maximum
Maximum Loop Length: 1.9 Km (6300 ft) - 24 AWG twisted pair
Maximum Power Run: 30.5 m (100 ft) - 24 AWG twisted pair

(additional length may be added by doubling wire pairs or
increasing wire gauge)
Connections: W-3000 - (4) position screw terminal strip, W­3000-EWP - Gel filled butt connectors

SSppeecciiffiiccaattiioonns

s

noisy environments, the doorbox’s new louder speaker output and
“Push-to-Talk” feature can be used.

The W-3000-EWP shares all of the features of the W-3000 in addi-
tion to Enhanced Weather Protection (EWP) for installation in
harsh environments. EWP products feature rubber gaskets and
boots, hand soldered silicon sealed connections, gel filled tip and
ring connectors, urethane potted circuit boards with weather
sealed, field adjustable trim pots and DIP switches for easy on-site
programming.

WW-3000/

-3000/

WW-3000-EWP

-3000-EWP

Vandal Resistant

Handsfree Doorbox

October 8, 2002

• Vandal resistant, 14 gauge stainless steel faceplate,
heavy-duty metal push button and mounting gasket.
Flush mount using the included rough-in box or
surface mount using an optional VE-5x5 backbox

• Yellow call progress/
night light LED

• New high output speaker amplifier with volume

adjustment POT

• Microphone volume adjustment POT

• 24 volt talk battery

• 20 Hz ring generator (3.0 REN ring load maximum)

• Selectable ring cadence (standard or 2 short rings)

• Selectable number of rings (2, 3, 10 or 30)

• Selectable “Push-to-Talk” feature for noisy

environments

• Extended operating temperature range: -15°F to 130°F

• Compact 45° terminal strip for easy wiring

• W-3000-EWP has Enhanced

Weather Protection

AApppplliiccaattiioonns

s

• Ideal for noisy locations

• Commercial, industrial or residential door security

• Door or gate communication

• Truck stop/gas station fuel island communication

• Use with the C-1000A controller for single line residen-

tial systems or when the operation of door strikes or
gate openers is necessary

W-3000 shown with optional VE-5x5

?

Need More Information on VE-5x5?

Call [phone] and select 424.

?

Need More Information on the C-1000A?

Call [phone] and select 155.

hhttttpp::////wwwwww..vviikkiinnggeelleeccttrroonniiccss..ccoom

m

?

Need More Information on EWP?

Call [phone] and select 859.

Front View of Optional

VE-5x5 (not included)

2.25”

Condensation

Drain Hole

* 1/8" thick foam gasket

(included)

5.14”

5.22”

3.25”

Call

4.0"

Rear View of VE-5x5

(not included)

Push to Call Button

Yellow Call Progress/Nightlight LED

(4) 6-32 X 3/4” stainless steel, flat
head, hexdrive, screws (included)

Condensation Drain Hole

5.0”
Typical

W-3000 shown with

Viking Model

VE-GNP

Gooseneck

Pedestal

(4) 0.38” diameter
(for gooseneck mounting)

(4) 0.2 x 0.43 slots
for double gang box

(2) 0.2 x 0.43 slots
for single gang box

(1) .74" dia

3.0” 3.3”

3.0”

2.1”

Wall Stud

Front View of

Plastic Rough-In

Box (included)

Wire knock out

(2) Standard flat head dry wall
(sheet rock) screws (not included)

IInnssttaallllaattiioon

n

A. Microphone and Speaker Volume Adjustment POTs

The optional VE-5x5 Surface Mount Box is designed
to be surface mounted to a single gang box, double
gang box or VE-GNP gooseneck pedestal (right).

Important: The W-3000 will NOT
mount to a standard double gang box.

Caution: When warm air comes in contact with cold surfaces, such as outside walls, it causes condensation. To prevent condensation from accumulat­ing inside the W-3000, bring conduit into the bottom of the unit. If this is not possible, drill a 1/4” diameter hole in the bottom of the plastic rough-in box.

Note: The plastic rough-in box (part # 259576) may be purchased separately
in advance. Go to www.vikingelectronics.com and click on “spare parts”.

?

Need More Information on VE-5x5 or VE-GNP?

Call [phone] and select 424.

* Note: Peel off paper liner and adhere gasket to the back of the faceplate, centering it over the four corner mounting holes.

Due to the dynamic nature of the product design, the information contained in this document is subject to change without notice. Viking Electronics, and its affiliates and/or
subsidiaries assume no responsibility for errors and omissions contained in this information. Revisions of this document or new editions of it may be issued to incorporate
such changes.

Fax Back Doc 212

ZF300610 Rev G

Printed in the U.S.A.

PPrroodduuccttSSuuppppoorrttLLiinnee......771155..338866..8866666

6

FFaaxxBBaacckkLLiinnee......771155..338866..4433445

5

IMPORTANT: Electronic devices are susceptible to lightning and power station elec­trical surges from both the AC outlet and the telephone line. It is recommended that
a surge protector be installed to protect against such surges. Contact Panamax at

[phone] or Electronic Specialists Inc. at [phone].

!

Important: Do NOT install a W-3000 on a
telephone line without a C-1000A
Controller (Fax Back Document 155).

Sw 1

OFF

ON

Ring Cadence

Standard: (1 sec ON, 3 sec OFF)

Custom (2 short rings): .5 sec ON,

.25 sec OFF, .5 sec ON, 3 sec OFF

DIP Switch Programming

Sw 4

OFF

ON

Communication Mode

Normal Handsfree Mode

Push-to-Talk Mode

Sw 2

OFF

ON

OFF

ON

Ring Output

2 Ring

3 Rings

10 Rings

30 Rings

Sw 3

OFF

OFF

ON

ON

In certain noisy locations, the microphone volume may need to be decreased. A microphone POT (see installation above) is provid­ed on the W-3000’s circuit board to increase or decrease the microphone volume. However, in extremely noisy locations the micro­phone POT adjustment may not be enough to allow two-way talk path. In this case the “Push-to-Talk” mode should be used as shown
in the DIP switch settings above (see section C below). Note: Both POTs come factory set in the middle position. A speaker volume

POT is also provided for increasing or decreasing the speaker audio as needed.

B. Handsfree Operation (Dip Switch 4 - OFF)

When the “Call” button is pressed, the call progress LED will turn off and the W-3000 will begin generating a 20 Hz ring signal. The
caller at the W-3000 will hear an audio ring back signal while the LED flashes. When the inside party has answered, the LED will light
until the inside party hangs up. At that point, the LED will turn off for approximately one second and then light steady to illuminate the

W-3000 after dark.

C. Push-To-Talk Operation (Dip Switch4-ON)

In extremely noisy locations, the “Push-to-Talk” mode should be used. To switch to the “Push-to-Talk” mode, place DIP switch 4 in the
ON position (see Dip Switch Programming). To initiate a call, momentarily press the “Call” button to generate the ring signal. After
the inside party has answered, press and hold the call button to talk. Release the call button to listen.

PPrrooggrraammmmiinnggaannddOOppeerraattiioon

n

* Note: To increase surge protection, loosen the PCB mounting screw labeled (as shown above) and fasten a wire with spade terminal (included)

from the mounting screw to Earth Ground (grounding rod, water pipe, etc.)

C-1000A Controller

VIKING

POWER 13.8V AC

LINE IN PHONES STATUS

MODEL C-1000A

©

VIKING

ELECTRONICS

HUDSON, WI 54016

DOOR ENTRY/PAGING

CONTROLLER

AUX.CONTACT

OUTPUT

DOOR

STRIKE 1

34567891011

12

C.O.
Line

DOOR

BOX 1

DOOR BOX

POWER

Single Line

Phone

DOOR

BOX 2

DOOR

STRIKE 2

12

Multi-Line

Phone

Unused

PABX/KSU

Trunk Input

3.63" Typical

(Spade connector

included)

* Earth

Ground

(optional)

Gel-filled tip

connectors

(EWP only)

or

3.63"

and ring

Red

Green

T&R 13V
OUT AC

ON

1

2
3

4

13.8V AC

Gel-filled
connectors
(EWP only)

Microphone

Min Max

Speaker

Min Max

DIP

Switches

ON

1 2 3 4

120V AC