Your purchase of this product attests to the importance you place upon
the quality and performance of the major appliances you choose. With
minimal care, as outlined in this manual, this product is designed to
provide you with years of dependable service. Please take the few
minutes necessary to learn the proper and efficient use and care of this
quality product.
We appreciate your choosing a Viking Range Corporation product, and
hope that you will again select our products for your other major
appliance needs.
To reduce the risk of fire, electrical shock, or injury
when using your compactor, follow basic
precautions, including the following safety
instructions.
IMPORTANT SAFETY INSTRUCTIONS
1. Read all instructions.
2. This compactor must be properly connected to electricity.
3. Use the compactor only for its intended purpose.
DDooNNoott
4.
time. Close supervision is necessary when used by or near
children. Lock when not in use and store key out ot reach of
children.
DDoonnoott
5.
compactor has been damaged in any manner. Have the
compactor examined, repaired, or adjusted by an authorized
servicer.
DDoonnoott
6.
electrical shock when next used.
DDoonnoott
7.
DDoonnoott
8.
material such as glass.
AAllwwaayyss
9.
drawer so the wastepaper below and beside the bottle can help
keep broken glass near the center of the bag, away from the sides.
DDoonnoott
10.
poisonous or explosive products.
DDoonnoott
11.
etc., which could create a hazard.
12. Do not shove items down into the compactor with hands or feet.
To avoid being cut, let the compactor do the compacting.
DDoonnoott
13.
bag and cause injury. Always carry a filled trash bag by the top.
AAllwwaayyss
14.
DDoonnoott
15.
appliances nor as a cutting board.
DDoonnoott
16.
DDoonnoott
17.
rags and insect sprays.
or other hot or burning items.
DDoonnoott
18.
DDoonnoott
19.
manufacturer.
allow to be used as a toy, or to run unattended at any
operate with a damaged cord, plug, motor, or after
take compactor apart. Incorrect reassembly can cause
touch moving parts.
DDoonnoott
DDoonnoott
overload trash with heavy
compact lighted cigarettes, cigars
overload compactor.
place glass bottles, etc., on their sides in the center of the
compact any container or material which might contain
compact cloths or cans containing paint liquids, thinners,
lift a trash bag by the sides. Sharp objects can pierce the
wipe off any broken glass before touching the ram cover.
use the compactor as a counter for electrical cooking
set hot pans, etc., on the compactor top.
compact toxic or volatile flammable material such as oily
spill any liquids on the compactor top.
use accessories other than those recommended by the
SAVE THESE INSTRUCTIONS
32
Compactor Features
Basket Wall
Support Channels
Charcoal Air
Filter with Fan
Break-Away
Trash Basket
Basket Wall
Support Channel
Control
Panel
Basket Release
Handle
Trash Drawer
Built-in
Storage
Compartment
Loading Your Compactor
LLaarrggeeCCaappaacciittyyTTrraasshhDDrraawweerr
Items should be placed directly into the drawer. It is not necessary to run
a compaction cycle everytime you place trash into the drawer. However,
the more often you run a cycle, the more compact the trash will be.
BBrreeaakk--AAwwaayyTTrraasshhBBaasskkeett
Your trash compactor is
equipped with a versatile twopiece, polypropylene basket. It
is designed for easy use and
removal of compacted trash.
The break-away basket may be
used with or without the
enclosed complimentary supply
of trash bags.
Your compactor has a built-in interlock and will not operate unless you
have:
1. Closed the trash drawer.
2. Turned the key/knob to start.
OFF will stop the ram movement at any point. After stopping the unit,
turn the key to START and ram will return to original “up” position.
WWAARRNNIINNGG::
recommend that you remove the key/knob when not in use. The unit will
not operate without it. Before running a compactor cycle, always check
to be sure that no item has been mistakenly placed in the trash drawer.
Do not allow children to operate the compactor. We
WWAARRNNIINNGG::PPEERRSSOONNAALLIINNJJUURRYYHHAAZZAARRDD
Compacted trash may contain broken glass, metal cans and other sharp
objects. Always use the half basket to dump trash.
HHAANNDDSS..
1. Place basket release handle in upright position. (See Illustration)
2. Put trash directly into the
basket. We recommend placing
several thicknesses of
newspaper at the bottom of the
basket when bags are not used.
This will minimize clean-up of
the basket after emptying
compacted trash.
We recommend removing the basket when trash is compacted to four or
five inches below the top of the basket. If you find this too heavy,
compact less trash next time.
trash will vary with the contents. Cans and bottles may weigh more than
paper products.
1. Place basket release handle in down
Compacting a folded
newspaper on top of loose
trash will keep the ram
clean of trash or broken
glass.
RREEMMEEMMBBEERR
position. Lift built-in storage
compartment cover up. (See
Illustration)
- the weight of the compacted
Use of Break-Away Trash Basket With Bag
1. Lift built-in storage compartment cover. Place basket release handle
in down position. (See Illustration)
2. Place folded trash bag inside
Break-Away trash basket.
3. Open bag. Pull top edges of
bag over top of drawer.
4. Lock bag in place by pulling
the four pre-punched holes in
the trash bag over buttons
on drawer sides. Holes will
expand over buttons without
damaging bag.
5. Spread bag to fit interior of
basket. Close built-in storage
compartment cover. Pull
basket release handle to up
position. (See Illustration)
2. Grasp both handles of basket and
remove from drawer by pulling basket
straight up. Carry basket to trash
storage area.
3. Remove basket wall support channels.
4. Carefully pull handles of basket away
from each other leaving compacted
trash in one half of the basket.
5. Dump compacted trash from half
basket into waste receptacle.
6. Replace support channels after dumping.
76
Bag Removal
CompactFan
Start
On
Off
S
top
We recommend removing bag when trash is compacted to four or five
inches below top of basket. If you find this is too heavy, compact less
trash next time.
Operating Your Trash Compactor
1. Pull basket release handle down. Lift storage compartment cover
up. Release bag from buttons. Pull up top edges of bag.
2. Close bag with twist-ties provided. (See Illustrations)
3. Grasp trash bag handles and carefully remove from drawer. Carry
basket with bag to trash storage area.
4. Pull handles of basket away from each
other to loosen bag.
5. Lift bag out.
WWAARRNNIINNGG::PPEERRSSOONNAALLIINNJJUURRYYHHAAZZAARRDD
Sharp objects may protrude through bag after removal from trash
basket. Handle carefully by the top to avoid injury.
TTooSSttaarrtt::
1. Close trash drawer.
2. Turn key/knob to START position and HOLD momentarily. Release
key/knob.
CCoommppaaccttiioonnCCyyccllee
The compactor ram will move down inside the trash drawer, reverse, and
return to original position, completing the cycle in approximately 35
seconds. As the basket is filled, the ram travels a shorter distance and
cycle time decreases.
As the ram compacts difficult to break items, you may notice a downward
movement of the compactor drawer. This in normal and will not cause
damage. The spring-loaded drawer is specially designed to move down
freely and return to its original position. The force of the ram during a
compaction cycle is absorbed by the heavy gauge steel frame of the
compactor.
TTooSSttooppCCyycclleeaannddOOppeennDDrraawweerr
You may stop or interrupt a compaction cycle at any time and raise the
ram to its original position.
1. Turn the key/knob to STOP position to stop the ram.
2. Turn the key/knob to START position and HOLD momentarily to
return the ram to original position. The drawer may then be
opened.
3. Turn key/knob to START position and HOLD to start another cycle.
98
Charcoal Air Filter with Fan
Your trash compactor features an activated charcoal air filter and fan
which absorbs and minimizes odor. The charcoal filter is located in the
left rear section of the compactor.
The degree of odor in your compactor will depend upon the type of
trash you place in it. Since odors are absorbed into the pores of the
charcoal filter, it may need to be replaced once or twice a year. Length
of time before filter replacement is necessary varies with the types of
trash compacted.
CChhaarrccooaallAAiirrFFiilltteerrFFaann
OONN--
The fan creates fast air movement for greater odor removal.
While the fan is on, the red light will glow on the control
panel.
Locking/unlocking trash drawer
To lock the trash drawer:
1. Turn the key/knob to START momentarily.
2. Before the compacting cycle is complete, turn the key/knob to the
STOP position. The trash drawer will not open when the ram is in
the downward position.
3. Remove the key/knob.
To unlock the trash drawer:
1. Replace the key/knob.
2. Turn the key/knob to the START position and hold momentarily.
3. Release the key/knob. The ram will return to the original position,
allowing the trash drawer to open.
OOFFFF--
TTooRReemmoovveeFFiilltteerr::
1. With trash drawer in open
2. Release filter from bottom clip,
TTooRReeppllaacceeFFiilltteerr::
Push replacement filter into place behind top clip. Snap securely into
bottom clip.
Even when the fan isn’t running, the filter is working to
remove odor.
position, reach into left rear
corner where filter is located.
pull down.
Special Use Tips
-Your compactor is designed to handle most dry trash. The compactor
is not a substitute for a food waste disposer. We urge you to continue
to dispose of garbage through a food waste disposer. Most food waste
will sour and become odorous when held at room temperature.
-Liquid or messy items should be wrapped in a newspaper or several
thicknesses of paper toweling to help keep the ram and Break-Away
basket clean.
-More trash can be compacted if you stop the ram in the “down”
position and allow it to dwell there overnight. This will result in heavier
bags of compacted trash.
-Place glass bottles on their side in the center for compacting rather than
upright. Bottles and cans may nest in lightly compacted paper. When
sufficient load is accumulated, most will be crushed. However, due to
the resiliency of paper, some bottles may not break. Don’t be alarmed
by the popping noise made when bottles are crushed. This is normal
and will not damage compactor. Placing a newspaper over bottles
before compacting will help muffle noise.
-If you are planning a weekend vacation, you may not want to remove
compacted trash if basket is not full. We recommend you simply lock
the compactor. On your return, you may wish to run the charcoal air
filter for a short time before opening the drawer.
-If you are planning to be away for more than a weekend, we recommend
that you remove and discard the compacted trash, replace basket and
lock the compactor. Before running a compaction cycle,
that no item has been mistakenly placed in the trash drawer.
aallwwaayyss
check
Caring for Your Compactor
CCoommppaaccttoorrIInntteerriioorr
MMeettaallDDrraawweerrLLiinneerr::
Clean as necessary using a cloth or sponge and mild detergent and
water. Rinse with clear water and dry. Do not use abrasive cleaners.
MMeettaallDDrraawweerr::
Occasionally the drawer latch rod and slide hood located on both sides
of the drawer opening should be lubricated. This will prevent the door
latch from squeaking or sticking and help insure and extend the life of
the latch mechanism. We suggest soap or a solid stick lubricant which
can be purchased at auto supply or hardware stores.
BBeehhiinnddMMeettaallDDrraawweerr::
Occasionally check the area behind the trash drawer and remove any
small pieces of trash. Placing a folded newspaper on top of trash will
help prevent small items from sticking to the ram and falling behind the
drawer.
NOTE: Drawer may be removed to facilitate the cleaning surrounding
areas.
1. Disconnect power supply to compactor before removing drawer.
2. Be sure ram is in “up” position.
3. Open drawer to fully extended position.
4. Remove any drawer retaining screws which hold drawer to track
assembly. Carefully remove drawer from track assembly, making
sure that the full weight of the drawer is supported at all times.
BBrreeaakk--AAwwaayyTTrraasshhBBaasskkeett
Clean as necessary after emptying compacted trash. Wearing rubber
gloves and using paper towels, remove any small pieces of debris from
basket such as crushed glass.
Light soil may be wiped away with a damp sponge or cloth. Heavy soil
may require use of mild detergent and water. Rinse with clear water and
dry.
RRaamm
Clean as necessary. Wearing rubber gloves and using paper towels,
remove any small pieces of debris from ram, such as paper or crushed
Wipe clean with a cloth or sponge and mild detergent and water. Rinse
with clear water and wipe dry. Do not use abrasive cleaners. On stainless
steel models, use a stainless steel cleaner and polish.
UUsseeEEnneerrggyyWWiisseellyy
A trash compactor uses a negligible amount of energy. Total energy
requirements associated with the trash compactor will be minimized by
following the recommendations in the Use and Care Guide.
13
Service Information
It is assumed that your trash compactor has been properly installed in
accordance with all specifications and local codes and that the appliance
has been properly grounded. If your trash compactor should fail to
operate, check the troubleshooting guide before calling your dealer. You
could save the cost of a service call.
If your trash compactor should fail to operate:
--
Have you read and followed the instructions provided with this unit?
-Is a fuse blown or the circuit breaker open?
-Is the trash drawer tightly closed? It is possible for a cycle to be
incomplete when the drawer has not been firmly closed before turning
the key to START. If this occurs, the unit will shut-off, but the drawer
cannot be pulled open. Close the drawer firmly and turn the key to
START. The ram will return to the original “up” position. Drawer will
open only when ram is all the way up.
-Compacting works best when only a few items are loaded. Use the
compacting cycle frequently.
-Not all bottles will break every time, depending upon trash load below.
If compactor stops during operation:
-Push drawer in while turning key to start. Repeat if necessary.
-Rearrange trash load. Do not load rigid items in front of drawer.
-Drawer must be at least 1/3 full to see compaction.
If Service is Required:
1. Call your dealer or authorized service agency. The name of the
authorized service agency can be obtained from the dealer or
distributor in your area.
2. Have the following information available:
-Model number
-Serial number
-Date purchased
-Name of dealer from whom you purchased the appliance.
3. Clearly describe the problem you are experiencing.
If you are unable to obtain the name of an authorized service agency,
or continue to have service problems, call Viking Range Corporation, 1888-VIKING1 (845-4641), or write to:
VIKING RANGE CORPORATION
PREFERRED SERVICE
1803 Hwy 82W
Greenwood, Mississippi 38930 USA
Record the information indicated below. You will need it if service
is ever required. The serial and model numbers for your trash compactor
are on an identification label located on the access panel on top of the
trash compactor.
Model Number Serial Number
Date Purchased Date Installed
Dealer’s Name
Address
If service requires installation of parts, use only authorized parts to
ensure protection under the warranty.
Undercounter trash compactors and all of their component parts, except as detailed below*, are warranted to be
free from defective materials or workmanship in normal household use for a period of twelve (12) months from the
ate of original retail purchase. Viking Range Corporation, warrantor, agrees to repair or replace, at its option, any
d
part which fails or is found to be defective during the warranty period.
Painted and decorative items are warranted to be free from defective materials or workmanship for a period of
*
ninety (90) days from the date of original retail purchase. ANY DEFECTS MUST BE REPORTED TO THE SELLING
DEALER WITHIN NINETY (90) DAYS FROM DATE OF ORIGINAL RETAIL PURCHASE.
iking Range Corporation uses the most up-to-date processes and best materials available to produce all color
V
finishes. However, slight color variation may be noticed because of the inherent differences in painted parts and
porcelain parts as well as differences in kitchen lighting, product locations, and other factors.
ONE YEAR FULL WARRANTY
Any drive system motor which fails due to defective materials or workmanship in normal household use during the
econd through the fifth year from the date of original retail purchase will be repaired or replaced, free of charge
s
for the part itself, with the owner paying all other costs, including labor.
NNIINNEETTYY((9900 ))DDAAYYRREESSIIDDEENNTTIIAALLPPLLUUSSWWAARRRRAANNTTYY
extends beyond normal residential use. Examples are, but not limited to, bed and breakfasts, fire stations, private
clubs, churches, etc. This warranty excludes all commercial locations such as restaurants, food service locations and
institutional food service locations.
This warranty extends to the original purchaser of the product warranted hereunder and to each transferee owner
of the product during the term of the warranty.
This warranty shall apply to products purchased and located in the United States and Canada. Products must be
purchased in the country where service is requested. Warranty labor shall be performed by an authorized Viking
Range Corporation service agency or representative. Warranty shall not apply to damage resulting form abuse,
accident, natural disaster, loss of electrical power to the product for any reason, alteration, outdoor use, improper
installation, improper operation or repair or service of the product by anyone other than an authorized Viking
Range Corporation service agency or representative. This warranty does not apply to commercial usage.
is not responsible for consequential or incidental damage whether arising out of breach of warranty, breach of
contract, or otherwise. Some jurisdictions do not allow the exclusion of limitation of incidental or consequential
damages, so the above limitation or exclusion may not apply to you.
Owner shall be responsible for proper installation, providing normal care and maintenance, providing proof of
purchase upon request, and making the appliance reasonably accessible for service. It the product or one of its
component parts contains a defect or malfunction during the warranty period, after a reasonable number of
attempts by the warrantor to remedy the defects or malfunctions, the owner is entitled to either a refund or
replacement of the product or its component part or parts. Replacement of a component part includes its free
installation. Warrantor’s liability on any claim of any kind, with respect to the goods or services covered hereunder,
shall in no case exceed the price of the goods or service or part thereof which give rise to the claim.
WARRANTY SERVICE:Under the terms of this warranty, service must be performed by a factory authorized Viking
Range Corporation service agent or representative. Service will be provided during normal business hours, and
labor performed at overtime or premium rates shall not be covered by this warranty. To obtain warranty service,
contact the dealer from whom the product was purchased, an authorized Viking Range Corporation service agent,
or Viking Range Corporation. Provide model and serial number and date of original retail purchase. For the name
of your nearest authorized Viking Range Corporation service agency, call the dealer form whom the product was
purchased or Viking Range Corporation. IMPORTANT: Retain proof of original purchase to establish warranty
period.
The return of the Owner Registration Card is not a condition of warranty coverage.
Owner Registration Card so that Viking Range Corporation can contact you should any question of safety arise
which could affect you.
Any implied warranties of merchantability and fitness applicable to the above described drive system motor is
limited in duration to the period of coverage of the applicable express written limited warranties set forth above.
Some jurisdictions do not allow limitations on how long an implied warranty lasts, so the above limitation may not
apply to you. This warranty gives you specific legal rights, and you may also have other rights which may vary from
jurisdiction to jurisdiction.
FIVE YEAR LIMITED WARRANTY
This warranty applies to applications where use of the product
Warrantor
You, however, should return the
Specifications subject to change without notice.
1716
1918
Loading...
+ hidden pages
You need points to download manuals.
1 point = 1 manual.
You can buy points or you can get point for every manual you upload.