Vector VEC270MG User Manual

VEC270MG

260 PSI AIR COMPRESSOR

CORDLESS y RECHARGEABLE

OWNER’S MANUAL

& WARRANTY INFORMATION

Features

Compact

Lightweight

Portable

Powerful

Rugged

 IMPORTANT SAFETY INFORMATION SAVE THESE INSTRUCTIONS

Inflation Uses

Car Tires

Bicycle Tires

Minivan Tires

Sports Equipment

Air Mattresses

Power Uses—12 Volt

Cellular Phones

Lights

Radios

Small Appliances

TVs

THIS MANUAL CONTAINS IMPORTANT INFORMATION REGARDING
SAFETY, OPERATION, MAINTENANCE AND STORAGE OF THIS
PRODUCT. BEFORE USING, READ AND UNDERSTAND ALL CAUTIONS,
WARNINGS, INSTRUCTIONS AND PRODUCT LABELS, PLUS YOUR
VEHICLE’S BATTERY AND INFLATABLE’S MANUFACTURER
GUIDELINES. FAILURE TO DO SO COULD RESULT IN INJURY AND/OR
PROPERTY DAMAGE.

4140 SW 28TH WAY, FT. LAUDERDALE, FL 33312

TEL [phone] • TOLL FREE: 866-584-5504 • FAX [phone]

Page 2 of 16
260 PSI AIR COMPRESSOR CORDLESS y RECHARGEABLE VEC270MG

TABLE OF CONTENTS VEC270MG

1.

SAFETY INFORMATION AND INSTRUCTIONS........................................ 4

1.1. Safety Symbols........................................................................................ 4

1.2. Charging Instructions...............................................................................4

A. Initial Use.................................................................................................4

B. End of use/Recharge............................................................................... 4

C. Maintenance/Recharge/Stored Item........................................................ 5

D. General Safety Precautions.....................................................................5

2. INTRODUCTION.......................................................................................... 6

3. OPERATION - RECHARGING.................................................................... 9

3.1. 120 Volt AC Recharging.......................................................................... 9

3.2. 12 Volt DC Recharging.......................................................................... 10

3.3. Battery Indicator Lights.......................................................................... 10

4. OPERATION AS A PORTABLE COMPRESSOR (INFLATOR)................ 10

4.1. Tire Inflation or Products With A Valve Stem ........................................11

4.2. Other Inflatables Without Valve Stem.................................................... 11

4.3. Typical Inflation Times For Products Without Valve Stems................... 12

5. OPERATION AS A 12 VOLT PORTABLE POWER SOURCE.................. 12

5.1. Estimated 12 Volt DC Usage Times...................................................... 12

6. EMERGENCY/WORKLIGHT.....................................................................13

7. REPLACEMENT PARTS...........................................................................13

7.1. Bulb Replacement .................................................................................13

7.2. Battery Replacement............................................................................. 13

7.3. Battery Disposal..................................................................................... 14

8. SPECIFICATIONS..................................................................................... 14

9. VECTOR ONE YEAR LIMITED WARRANTY ...........................................14

Page 3 of 16
260 PSI AIR COMPRESSOR CORDLESS y RECHARGEABLE VEC270MG

1. SAFETY INFORMATION AND INSTRUCTIONS

1.1. Safety Symbols

The following symbols will be used throughout this manual.

T DANGER indicates an imminently hazardous situation which, if not

avoided, WILL result in death or serious injury.

!

WARNING indicates a potentially hazardous situation which, if not

avoided, COULD result in death or serious injury.

È CAUTION indicates a hazardous situation which, if not avoided, MAY result

in minor or moderate injury.

→ NOTICE indicates important information that if not followed, may cause

damage to equipment.

The following safety precautions must be followed at all times along with any
additional existing safety rules.

1.2. Charging Instructions
For best results, charge the battery in temperatures ranging from 65

degrees F (18 degrees C) to 75 degrees F (24 degrees C). Inflator must
be charged at least 24 hours using the 120 volt AC method prior to
initial use.

A. Initial Use

The 260 PSI AIR COMPRESSOR CORDLESS y RECHARGEABLE is
shipped in a partially charged state (not fully charged). The battery
must be charged using the 120 volt AC before the initial use.

B. End of use/Recharge

When charge indicator runs down, recharge product before storing
away, using the 120 volt AC.

Page 4 of 16
260 PSI AIR COMPRESSOR CORDLESS y RECHARGEABLE VEC270MG

C. Maintenance/Recharge/Stored Item

Recharge the unit every 3 to 6 months even if the unit has not been
used.

D. General Safety Precautions

1. Completely read this product manual as well as all interactive applicable
manufacturers’ and/or vehicles’ manuals and safety guidelines.

2. Be familiar with the proper use of the unit and all interactive applicable
manufacturers’ products.

3. Never exceed recommended pressures or over inflate tires/inflatable items.
Bursting articles can cause serious injury. Always check pressure with the
pressure gauge. It is recommended to wear protective eyewear when
inflating tires/inflatable items.

4. Always wear protective clothing (i.e. no vinyl) and eyewear when using this
product: contact with battery acid may cause blindness and/or severe
burns. Be aware of first aid.

5. Never recharge more than 18 hours maximum using 12 volt DC
method/more than 24 hours maximum using 120 volt AC method.

6. To reduce risk of damage to plug and cord, pull by plug and not the cord
when disconnecting.

7. Never operate charger if it has received a sharp blow, been dropped, or
otherwise damaged in any way; take it to a qualified service technician or
call Vector Customer Service.

8. Never disassemble; take unit to a qualified service technician or call Vector
Customer Service when service or repair is required. Incorrect reassembly
may result in a risk of electric shock or fire and will void the warranty.

9. To reduce risk of electric shock, unplug charger from outlet before
attempting to clean.

10. Always recharge unit after each use, recommended 120 volt AC method.

11. Avoid charging the battery at temperatures,

y below 40 degrees F, (5 degrees C) or
y above 105 degrees F (40 degrees C).

12. Never operate the unit near fire, flammable gas or liquid. Never expose
battery to fire or intense heat as it may explode. Before disposing of the
battery, protect exposed terminals with heavy-duty electrical tape to
prevent shorting (shorting can result in injury or fire).

13. Never operate the inflator after the battery indicator light comes on.

14. Never operate the inflator with the 120 volt AC recharging adapter
connected to the unit as the charger could become damaged.

15. Never leave unit unattended while in use.

Page 5 of 16
260 PSI AIR COMPRESSOR CORDLESS y RECHARGEABLE VEC270MG