Vector VEC011 User Manual

VEC011

VWC011

USER’S MANUAL

& WARRANTY INFORMATION

IMPORTANT SAFETY INFORMATION, SAVE THESE INSTRUCTIONS

TO REDUCE THE RISK OF INJURY, USER MUST READ AND UNDERSTAND
THIS INSTRUCTIONAL MANUAL. THIS MANUAL CONTAINS IMPORTANT
INFORMATION REGARDING THE OPERATION AND WARRANTY OF THIS
PRODUCT. PLEASE RETAIN FOR FUTURE REFERENCE.

www.vectormfg.com

4140 S.W. 30th Ave., Ft. Lauderdale, FL 33312 U.S.

Toll Free: [phone]

8

START-IT

®

Jump-Starter

12 Volt DC Power Supply

Portable • Cordless • Rechargeable

TWO YEAR LIMITED WARRANTY PROGRAM

This limited warranty program is the only one that applies to this product, and it sets forth all the
responsibilities of Vector Manufacturing, regarding this product. There is no other warranty , other than those
described herein.

This Vector Manufacturing product is warranted, to the original purchaser only, to be free of defects in
materials and workmanship for two years from the date of purchase without additional charge. The
warranty does not extend to subsequent purchasers or users. Manufacturer will not be responsible for any
amount of damage in excess of the retail purchase price of the product under any circumstances. Incidental
and consequential damages are specifically excluded from coverage under this warranty.

This product is not intended for commercial use. This warranty does not apply to accessories or damage to
units from misuse or incorrect installation/connection. Misuse includes wiring or connecting to improper
polarity power sources.

RETURN/REPAIR POLICY: Defective products, other than accessories, may be returned to manufacturer. Any
defective product, other than accessories, that is returned to manufacturer within 30 days of the date of
purchase will be replaced free of charge. If such a product is returned more than 30 days but less than two
years from the purchase date, manufacturer will repair the unit or, at its option, replace it free of charge.

If the unit is repaired, new or reconditioned replacement parts may be used, at manufacturer’s option. A
unit may be replaced with a new or reconditioned unit of the same or comparable design. The repaired or
replaced unit will then be warranted under the terms of the remainder of the warranty period. The customer
is responsible for the shipping charges on all returned items after 30 days. During the warranty period,
manufacturer will be responsible for the return shipping charges.

LIMITATIONS: This warranty does not cover accessories, bulbs, fuses and batteries, defects resulting from
normal wear and tear (including chips, scratches, abrasions, discoloration or fading due to usage or
exposure to sunlight), accidents, damage during shipping to our service facility, alterations, unauthorized
use or repair, neglect, misuse, abuse, failure to follow instructions for care and maintenance, fire, flood and
Acts of God.

If your problem is not covered by this warranty, call our Technical Support Department at [phone]
or toll free at [phone] for general repair information and charges if applicable. You may also
contact us through our website at www.vectormfg.com.

STATE LAW RIGHTS: This warranty gives you specific legal rights. Some states do not allow limitations on
how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages,
so the exclusions or limitations stated herein may not apply. This warranty gives the purchaser specific legal
rights; other rights, which vary from state to state, may apply.

TO REQUEST WARRANTY SERVICE FOR THIS PRODUCT: Contact Technical Support by telephone, fax or
mail (see below). We suggest that you keep the original packaging in case you need to ship the unit. When
returning a product, include your name, address, phone number, dated sales receipt (or copy) and a
description of the reason for return and product serial number. After repairing or replacing the unit, we will
make every effort to return it to you within four weeks.

WARRANTY ACTIVATION: Please complete Warranty Activation Card and mail to Vector Manufacturing.
Enter the Model Number and “START-IT

®

Jump-Starter” as Product Type. All Vector products must be
registered within 30 days of purchase to activate this warranty. Mail the completed registration form, along
with a copy of the original sales receipt to:

ATTN.: CUSTOMER SERVICE

4140 SW 30th Ave., Ft. Lauderdale, FL 33312

• TOLL FREE: (866 ) 584-5504 • FAX: [phone] •

WARRANTY IS NON-TRANSFERABLE AND NON-REFUNDABLE.

RD061005

© 2005 VECTOR MANUFACTURING

MADE IN CHINA

Vec011_VW011_Manual_061005 6/16/05 12:12 PM Page 8

iii

CAUTIONS

Use only the supplied cords/adapters for recharging this unit. Do not recharge for more than 3-4 hours
maximum using 12 volt DC method. Recharge unit after each use.

All on/off switches should be in the OFF position when the unit is charging or not in use. Make sure all
switches are in the OFF position before connection to a power source or load.

Never insert anything other than the supplied power/recharging cords or recommended appliance
power/recharging cords into the 12 volt DC charging/power socket on this unit. Do not use any
accessory that is not recommended or provided by the manufacturer.

Do not use this unit to operate appliances that draw more than 12 amps.
This system is not designed to be used as a replacement for a vehicular battery. Do not attempt to operate

a vehicle that does not have a battery installed.
Although this unit contains a non-spillable battery, it is recommended that it be kept upright during

storage, use and recharging. To avoid possible damage that may shorten the unit’s working life, protect
it from direct sunlight, direct heat and/or moisture.

Check unit periodically for wear and tear. Replace worn or defective parts immediately; contact the
Customer Service Department at [phone].

Never submerge this unit in water, or expose it to rain or snow.
Never attempt to jump-start a frozen battery.
All wires, cables, and cords must be positioned so they cannot be tripped over or damaged by moving

parts, pinching or abrading.

SAVE THESE INSTRUCTIONS

ii

IMPORT ANT SAFETY INSTRUCTIONS

WARNINGS

1. When working with lead acid batteries, always make sure immediate assistance
is available in case of accident or emergency.

2. Always use protective clothing and eyewear when using this product, contact with
battery acid may cause blindness and/or severe burns. Be aware of first aid
procedures in case of accidental contact with battery acid.

3. There is a risk of explosive gases being released when lead acid batteries are
being charged or discharged. Failure to follow instructions may cause property
damage, explosive hazard, and/or personal injury.

4. Make sure the power switch is OFF before connecting battery clamps to
discharged battery.

5. When charging unit from a 120 volt AC electrical outlet in any wet or damp area,
make sure that the outlet used is protected by a ground fault interrupt (GFCI)
outlet.

6. When charging the unit near water, do not allow the electrical cords and outlets
to get wet; electrical shock could result.

7. Jump-start procedures should only be performed in a safe, dry, well-ventilated
area.

8. Always store battery clamps when not in use. Never touch battery clamps
together – this can cause dangerous sparks, power arcing, and/or explosion.

9. When using this unit in proximity to the vehicle’s battery and engine, stand the
unit on a flat, stable surface, and be sure to keep all clamps, cords, clothing and
body parts away from moving vehicle components.

10. Do not wear vinyl clothing when jump-starting a vehicle-friction can cause
dangerous static electricity sparks. Remove all jewelry or metal objects that could
cause short circuits or react with battery acid.

11. Always disconnect the NEGATIVE (BLACK) jumper cable first: followed by the
POSITIVE (RED) jumper cable.

12. Never allow RED and BLACK clamps to touch each other or another common metal
conductor – this could cause damage to the unit and/or create sparking/
explosion hazard. Always store battery clamps when not in use.

13. Do not expose battery to fire or intense heat as it may explode. Before disposing
of the battery , protect exposed terminals with heavy-duty electrical tape to prevent
shorting (shorting can result in injury or fire).

14. Do not smoke, use matches or cigarette lighters while working on a vehicle’s
battery system.

15. Keep unit out of reach of children (whether stored or in use).

Note:

Read this User’s Manual and product labeling carefully before using. Follow
all recommended warnings, cautions and safety procedures; as well as
manufacturer’s guidelines for your vehicle batter y.

FIRST AID
Skin: If battery acid comes in contact with skin, rinse immediately with water, then wash thoroughly with

soap and water. If redness, pain, or irritation occurs, seek immediate medical attention.
Eyes: If batter y acid comes in contact with eyes, flush eyes immediately for a minimum of 15 minutes –

seek immediate medical attention.

Vec011_VW011_Manual_061005 6/16/05 12:12 PM Page ii