UVP XX-Series Bench Lamps User Manual

XX-Series Bench Lamps

Operating Instructions

Introduction

UVP XX-Series Bench Lamps are
ordered with or without two ultra­violet tubes. The series covers 15
watt, 20 watt and 40 watt models.

Before operating the XX-Series
lamp, read the Safety Precautions
below for important information on
protection from ultraviolet
radiation.

Installation

The XX-Series fixture is designed for installation on a wall, ceiling or other similar
location. A properly grounded outlet is required. The grounding plug is a necessary
safety feature; do not remove or override it or attempt to use an ungrounded outlet.

Each ultraviolet tube is equipped with two pins located on each end. To install the
tube into the fixture, hold the tube so the pins are vertical. Slide both ends of the tube
into lamp holders, beginning with the lower pins, and rotate the tube forward so that
the pins become horizontal and fit securely in the lamp holders.

The Exposure Stand is for use with the XX-15 lamps. The lamp mounts on top of the
stand. The shelf is adjustable to different levels for repeated exposure.

Filter covers, also for the XX-15 lamps, slide on and off the face of the lamp fixture.

Safety Precautions

When using shortwave ultraviolet, UV protective eyewear and skin covering is

required to protect all persons exposed to shortwave UV radiation. Unprotected

eyes and skin can be seriously damaged by exposure to shortwave UV. When

using longwave ultraviolet, UV protective eyewear is recommended to block UV

and “blue haze” associated with longwave UV.

Operation

To turn the lamp on, push the ON/OFF switch on the end of the XX-Series fixture to
the “ON” position. Ultraviolet tubes are fluorescent and require relatively little power
while in operation. However, turning the fixture on and off frequently will reduce the life
span of the fluorescent tubes.

Replacement Tubes and Accessories

Replacement Tube Part No.

365nm BLB Tube, 15W 34-0017-01
365nm Longwave Tube, 15W 34-0009-02
302nm Midrange Tube, 15W 34-0039-01
254nm Shortwave Tube, 15W 34-0008-01
365nm BLB Tube, 20W 34-0068-01
254nm Shortwave Tube, 20W 34-0067-01
365nm BLB Tube, 40W 34-0068-02
254nm Shortwave Tube, 40W 34-0067-02

Accessories Part No.

Spectacles 98-0002-01
Goggles 98-0002-02
Faceshield 98-0002-04
Exposure Stand (XX-15 series) 18-0062-01
Cover, filter (XX-15S, M) 38-0172-02
Cover, filter (XX-15L) 38-0172-01
Cover, clear (XX-15BLB) 19-0140-01

Web Site: www.uvp.com

Corporate Headquarters: UVP, LLC 2066 W. 11th Street, Upland, CA 91786

Tel: [phone] or [phone]

European Operations: Ultra-Violet Products Ltd.

Unit 1, Trinity Hall Farm Estate, Nuffield Road Cambridge, CB4 1TG UK

Tel: [phone]

81-0130-01 Rev E