U-Line U-2075DWRWCB-00 Installation Manual

Installation Guide

2075DWRWC —
Drawer Model Wine Captain

™

®

www.U-LineService.com

Phone [phone] • FAX [phone]

Service & Parts Tech Lines Phone [phone] • FAX [phone]

[e-mail]

©2005 U-Line Corporation

02/2005

2075DWRWC — Drawer Model Wine Captain

®

™

Contents

Exterior Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Cut-Out Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Product Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Clearances Information . . . . . . . . . . . . . . . . . . . . . . . . . 5

Other Site Requirements . . . . . . . . . . . . . . . . . . . . . . . . 6

Adding a Final Finish Coat to Wood Trim . . . . . . . . . . 7

Staining Wood Trim a Different Color . . . . . . . . . . . . . 7

Checking Drawer Alignment . . . . . . . . . . . . . . . . . . . . 8

Adjusting Drawer Alignment . . . . . . . . . . . . . . . . . . . . 8

Electrical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . 11

Leveling Information . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Installation Tip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Installation of the 2075DWRWC . . . . . . . . . . . . . . . . . . 12

Anti-Tip Kit Installation . . . . . . . . . . . . . . . . . . . . . . . . . 12

Installation Troubleshooting . . . . . . . . . . . . . . . . . . . . . 13

Initial Start-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Start-Up Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . 14

Service Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

1 Follow Safety Precautions

IMPORTANT

PLEASE READ all instructions completely before
attempting to install or operate the unit.

• This unit requires connection to a grounded (three­prong), polarized receptacle that has been placed by a
qualified electrician in accordance with applicable
electrical codes.

Safety Alert Definitions

Safety items throughout this guide are labeled with a
Danger, Warning or Caution based on the risk type:

DANGER

Danger means that failure to follow this safety
statement will result in severe personal injury or
death.

WARNING

Warning means that failure to follow this safety
statement could result in serious personal injury,
or death.

CAUTION

Caution means that failure to follow this safety statement
may result in minor or moderate personal injury, property
or equipment damage.

www.U-LineService.com 2 02/2005

™

2075DWRWC — Drawer Model Wine Captain

®

General Precautions

Use this appliance for its intended purpose only and
follow these general precautions along with those listed
throughout this guide:

WARNING

SHOCK HAZARD — Electrical Grounding Required.

• Keep the unit unplugged throughout installation
except during testing.

• Never remove the round grounding prong from
the plug and never use a two-prong grounding
adapter.

• Never use an extension cord to connect power to
the unit.

• Always keep your working area dry.

WARNING

The Anti-Tip Kit must be installed on this unit
before it is used. Never use the drawers as steps
or as a shelf to support more than the drawers’
contents. Serious personal injury could occur.

CAUTION

• Use care when moving and handling the unit. Use
gloves to prevent personal injury from sharp edges.

• Do not lift the unit by the drawer handle.

• Do not install the unit behind closed doors or in any
way that would obstruct airflow to the front grille,
which may cause the unit to malfunction.

2 Inspect and Plan

You have received a carton containing your 2075DWRWC
Drawer Model Wine Captain
containing a User Manual, a Product Registration
Card and Anti-Tip Kit. Complete and mail the
Product Registration Card or register online at
www.U-LineService.com. Once your unit is installed,
keep the User Manual and this Installation Guide in
a safe place for future reference.

Your unit is Black or Stainless Steel. Black units have
drawers with black glass fronts, sculpted handles and
black vinyl-clad cabinets. Stainless Steel units have
drawers with stainless steel framed fronts, sculpted
stainless steel handles and black vinyl-clad cabinets. All
units come with maple trim wine racks and caddy that can
be finished or stained. Please carefully follow the
directions that apply to your unit and your intended
design.

Tools/Materials Required

• Wrenches

• Screwdrivers — slotted and Phillips head

• Sandpaper; low odor, water clean up, quick drying
finish; tack cloth and, if desired, water-based wood
stain and synthetic foam brush

Inspection

Unwrap and inspect the unit on a flat, level surface
capable of supporting its entire weight.

Removing Protective Coating

®

with a package inside

Stainless Steel Models:

When inspecting/installing a Stainless Steel unit, the
protective coating covering the drawer fronts must be
removed. Start at a corner of the drawers and pull back
the protective coating to remove it from the drawer
fronts.

After all the protective coating has been removed from
the drawers, clean all Stainless Steel surfaces with Claire
Stainless Steel Polish and Cleaner or comparable product
or a mild detergent and warm water solution and soft
cloth. Do NOT use abrasive cleaning agents.

Note: If cleaning with mild detergent and warm water
solution and soft cloth, the unit MUST be treated with
Claire Stainless Steel Polish and Cleaner or comparable
product to prevent discoloration.

Clean all glass surfaces with a non-chlorine glass cleaner.

02/2005 3 www.U-LineService.com

2075DWRWC — Drawer Model Wine Captain

®

™

Exterior Cleaning

(As Required)

Black Models:

• Clean glass drawer fronts with glass cleaner. The
drawers, grille and cabinet may be cleaned with a mild
detergent and warm water solution. Do not use
solvent-based or abrasive cleaners. Use a soft sponge
and rinse with clean water. Wipe with a soft, clean
towel to prevent water spotting.

Stainless Steel Models:

• Stainless steel models can discolor when exposed to
chlorine gas, pool chemicals, salt water or cleaners with
bleach.

• Clean glass drawer fronts with a non-chlorine glass
cleaner. Keep your stainless steel surfaces looking new
by cleaning with a good quality all-in-one stainless
steel cleaner/polish on a monthly basis. For best results
use Claire Stainless Steel Polish and Cleaner, which can
be purchased from U-Line Corporation. (The part
number is 173348.) Comparable products are
acceptable. Frequent cleaning will remove surface
contamination that could lead to rust. Some
installations may require cleaning on a weekly basis.

• Do not clean with steel wool pads.

• Do not use stainless steel cleaners/polishes on
the glass surfaces.

• Do not use cleaners that are not specifically
intended for stainless steel on stainless steel
surfaces (this includes glass, tile and counter
cleaners).

• If any surface discolors or rusting appears, clean it
quickly with Bon-Ami or Barkeepers Friend Cleanser
and a non-abrasive cloth. Always clean in the direction
of the grain. Always finish this process with Claire
Stainless Steel Polish and Cleaner or comparable
product to prevent further problems.

• Use of abrasive pads such as Scotchbrite will
cause the graining in the stainless to become
blurred.

• Rust that is allowed to linger can penetrate into the
surface of the stainless steel and complete removal of
the rust may not be possible.

3 Prepare Site

Your U-Line product has been designed for built-in
installation. Your unit does not require additional air
space for top, sides or rear. However, the front grille must
NOT be obstructed and clearance is required for electrical
connection in the rear.

Note: Unit can NOT be installed behind a closed cabinet
door.

Cut-Out Dimensions

See Electrical

Specifications

for Power Supply

34-1/4"

to

35-1/8"

24-3/16"

Figure 1

Follow the cut-out drawing in Figure 1. The 24-3/16"
width allows 1/4" for ease in installation and removal of
the unit. 24" is the counter depth in most installations.
The unit is 23-11/16" deep including the drawer and not
the full handle (see Figure 2).

23-11/16"

www.U-LineService.com 4 02/2005

™

2075DWRWC — Drawer Model Wine Captain

®

Product Dimensions

25-13/16"

Including

Handle

34-1/8"

23-15/16"

Black or Stainless Steel

Figure 2

Please note that the unit has adjustable feet that can add
one additional inch to height during leveling or to match
adjacent cabinets (see Figure 19 on Page 11).

Clearances Information

The unit must be installed in a wall or under a counter­top to allow for the installation of the Anti-Tip Kit (see

Page 12).

WARNING

The Anti-Tip Kit must be installed on this unit
before it is used. Never use the drawers as steps
or as a shelf to support more than the drawers’
contents. Serious personal injury could occur.

The unit is designed so it can be installed next to a wall on
either side (see Figure 3).

Figure 3

Cabinet
or Wall

02/2005 5 www.U-LineService.com