True TUC-27G, TUC-60D-4, TWT-93, TPP-67, TPP-67D-2 Installation Manual
...
............ www.truemfg.com ............
............ www.truemfg.com ............
TABLE OF CONTENTS
Safety Information
Safety Precautions 1
Proper Disposal 2
Connecting Electricity 3
Adapter Plugs 3
Installation / Operation Instructions
Ownership 4
Required Tools 4
Uncrating 4
Locating & Installation of Leg/Castors 5
Pizza Prep Tables 6
Installing TSSU Hood Cover 6
Leveling Cabinet 7
Electrical Instructions 7
Wire Gauge Chart 8
Start-up 9
Cabinet Air-Flow 9
Shelving Install/Operation & Light Switch 10
Maintenance, Care & Cleaning
Cleaning Condenser Coil 11-12
Temperature Control Adjustment 13
Stainless Steel Equipment Care & Cleaning 14-15
Warranty (U.S.A. & Canada Only!) 16
INSTALLATION MANUAL FOR UNDERCOUNTERS,
WORKTOPS, SANDWICH/SALAD & PIZZA PREP
UNDERCOUNTERS, WORKTOPS,
UNDERCOUNTERS, WORKTOPS,
SANDWICH/SALAD & PIZZA PREP
SANDWICH/SALAD & PIZZA PREP
TRUE FOOD SERVICE EQUIPMENT, INC.
2001 East Terra Lane • P.O. Box 970 • O’Fallon, Missouri 63366
(636)-240-2400 • FAX (636)272-2408 • INT’L FAX (636)272-7546 • (800)325-6152
Parts Department (800)424-TRUE • Parts Department FAX# (636)272-9471
CONGRATULATIONS!
You have just purchased the finest commercial
refrigerator available. You can expect many years of
trouble-free operation.
TPP-93D-6
TWT-93
TPP-67D-2
TUC-60D-4
TSSU-48-10
TUC-27G
*Spanish, German, and French versions included.
11/9/07-25K SB #897003
............ www.truemfg.com ............
............ www.truemfg.com ............
True Food Service Equipment, Inc.
True Food Service Equipment, Inc.
............ www.truemfg.com ............
............ www.truemfg.com ............
SAFETY INFORMATION
SAFETY INFORMATION
True Food Service Equipment, Inc.
True Food Service Equipment, Inc.
1
1
1
1
This refrigerator must be properly installed and
located in accordance with the Installation
Instructions before it is used.
Do not allow children to climb, stand or hang
on the shelves in the refrigerator. They could
damage the refrigerator and seriously injure
themselves.
Do not touch the cold surfaces in the refrigerator compartment when hands are damp or wet.
Skin may stick to these extremely cold surfaces.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
Keep fingers out of the “pinch point”areas;
clearances between the doors and between the
doors and cabinet are necessarily small; be
careful closing doors when children are in the
area.
NOTE: We strongly recommend that any
servicing be preformed by a qualified
individual.
Unplug the refrigerator before cleaning and
making repairs.
Setting temperature controls to the 0 position
does not remove power.
WARNING!
Use this appliance for its intended purpose as described in
this Owner Manual.
How to Maintain Your Unit to
Receive the Most Efficient and
Successful Operation
You have selected one of the finest commercial refrigeration units made. It is
manufactured under strict quality controls with only the best quality materials
available. Your TRUE cooler when properly maintained will give you many
years of trouble-free service.
SAFETY PRECAUTIONS
When using electrical appliances, basic safety precautions should be followed, including the following:
............ www.truemfg.com ............
............ www.truemfg.com ............
True Food Service Equipment, Inc.
True Food Service Equipment, Inc.
SAFETY INFORMATION
SAFETY INFORMATION
2
2
2
2
PROPER DISPOSAL OF THE REFRIGERATOR
DANGER!
RISK OF CHILD ENTRAPMENT
USE OF EXTENSION CORDS
NEVER USE AN EXTENSION CORD! TRUE will not warranty any refrigerator that has been
connected to an extension cord.
Child entrapment and suffocation are not problems
of the past. Junked or abandoned refrigerators are
still dangerous… even if they will sit for “just a few
days.” If you are getting rid of your old refrigerator,
please follow the instructions below to help prevent accidents.
Before You Throw Away Your Old Refrigerator
or Freezer:
Take off the doors.
Leave the shelves in place so that children may
not easily climb inside.
Refrigerant Disposal
Your old refrigerator may have a cooling system
that uses “Ozone Depleting ” chemicals. If you are
throwing away your old refrigerator, make sure the
refrigerant is removed for proper disposal by a
qualified service technician. If you intentionally
release any refrigerants you can be subject to
fines and imprisonment under provisions of the
environmental regulations.
The power cord of this appliance is equipped with
a 3-prong (grounding) plug which mates with a
standard 3-prong (grounding) wall outlet to minimize the possibility of electric shock hazard from
this appliance.
Have the wall outlet and circuit checked by a qualified electrician to make sure the outlet is properly
grounded.
If the outlet is a standard 2-prong outlet, it is your
personal responsibility and obligation to have it
replaced with the properly grounded 3-prong wall
outlet.
The refrigerator should always be plugged into it’s
own individual electrical circuit, which has a voltage rating that matches the rating plate.
This provides the best performance and also prevents overloading building wiring circuits which
could cause a fire hazard from overheated wires.
Never unplug your refrigerator by pulling on the
power cord. Always grip plug firmly and pull
straight out from the outlet.
Repair or replace immediately all power cords that
have become frayed or otherwise damaged. Do not
use a cord that shows cracks or abrasion damage
along its length or at either end.
When removing the refrigerator away from the wall,
be careful not to roll over or damage the power
cord.
HOW TO CONNECT ELECTRICITY
Do not, under any circumstances, cut or remove the third (ground) prong from the power cord.
For personal safety, this appliance must be properly grounded.
WARNING!
USE OF ADAPTER PLUGS
NEVER USE AN ADAPTER PLUG! Because of potential safety hazards under certain conditions, we
strongly recommend against the use of an adapter plug.
............ www.truemfg.com ............
............ www.truemfg.com ............
SAFETY INFORMATION
SAFETY INFORMATION
True Food Service Equipment, Inc.
True Food Service Equipment, Inc.
3
3
3
3
(North America Use Only!)
NEMA plugs
TRUE uses these types of plugs.
If you do not have the right outlet
have a certified electrician install
the correct power source.
............ www.truemfg.com ............
............ www.truemfg.com ............
True Food Service Equipment, Inc.
True Food Service Equipment, Inc.
INSTALLATION / OPERATION INSTRUCTIONS
INSTALLATION / OPERATION INSTRUCTIONS
4
4
4
4
To insure that your unit works properly from the
first day, it must be installed properly. We highly
recommend a trained refrigeration mechanic and
electrician install your True equipment. The cost
of a professional installation is money well spent.
Before you start to install your True unit, carefully
inspect it for freight damage. If damage is discovered, immediately file a claim with the delivery
freight carrier.
True is not responsible for damage incurred during shipment.
OWNERSHIP
Adjustable Wrench
Phillips Head Screwdriver
Level
REQUIRED TOOLS
Step 1
The following procedure is recommended for
uncrating the unit:
A. Remove the outer packaging, (cardboard and
bubbles or styrofoam corners and clear plastic).
Inspect for concealed damage.Again, immediately file a claim with the freight carrier if there is
damage.
B. Move your unit as close to the final location as
possible before removing the wooden skid.
C. Remove door bracket on swing glass door
models (see image 1-2).
Note: Keys for coolers with door locks are located
in warranty packets.
UNCRATING
INSTALLATION / OPERATION INSTRUCTIONS
1
2
Glass Door Models Only.
REMOTE UNITS (This section applies to
remotes only!)
• Remote cabinets must be ordered as remote.
We do not recommend converting for a standard
self contained to remote system.
• All remote cabinets must be hard wired.
• No castors available.
• All remote cabinets come standard using 404A
refrigerant.
• All remote units come standard with expansion
valve, liquid line solenoid, heated condensate
pan, and defrost timer when applicable.
• Contact True Technical Service for BTU
requirements.
• No wiring necessary between cabinet and
condensing unit.
• All remote condensing units purchased from
True are 208/230 volts single phase.
If you have any questions regarding this section, please call True at 1-(800)-325-6152.
Loading...